Page 1
ComfortBreeze®
READ AND SAVE THESE INSTRUCTIONS
UV360-1 SYSTEM
24V Ultra-Violet Air Cleaner
TRION® | www.trioniaq.com
Page 2
Installation, Operation, & Maintenance Manual
1. Warranty
ComfortBreeze® UV360 System 1-Year Limited Warranty
This limited warranty covers TRION Residential Type UV Air Cleaners,
excluding duct work, wiring and installation. TRION warrants that all
new TRION UV Air Cleaners are free from defects in material and
workmanship under normal, non-commercial use and service. TRION
will remedy any covered defects if they appear within 12 months from
the date of original installation & subject to the terms and conditions of
this Limited 1-Year Warranty stated below:
1. THIS LIMITED 1-YEAR WARRANTY is granted by TRION
Customer Service, 101 McNeill Road, Sanford, NC 27330.
2. This warranty shall extend only to any non-commercial owner
who has purchased the residential UV Air Cleaner other than for
purposes of resale.
3. All components are covered by this limited warranty except
expendable items.
4. If, within the warranty period, any TRION residential UV Air Cleaner
or component requires service it must be performed by a competent
heating and/or air conditioning contractor (preferably the installing
contractor). TRION will not pay shipping charges, or labor charges
to remove or replace such defective parts or components. If the
part or component is found by inspection to contain such defective
material and workmanship it will be either repaired or exchanged
free of charge at TRION’s option, and returned freight collect.
5. In order to obtain the benets of this limited 1-year warranty, the
owner must notify the dealer or distributor of any defect within 30
days of its discovery. If after reasonable time you have not received
an adequate response from the dealer or distributor, notify in
writing to TRION Customer Service 101 McNeill Road, Sanford,
NC 27330, or call 1-800-884-0002 or email customerservice@
trioniaq.com. UV Air Cleaners which have been installed or become
part of real estate cannot be returned. TRION will receive, freight
prepaid, only removable parts or components of such defective UV
Air Cleaners.
6. This limited warranty does not apply to any part or component
that is damaged in transit or in handling, has been subject to
misuse, neglect or accident; has not been installed, operated and
serviced according to TRION’s instructions; has been operated
beyond the factory rated capacity; or altered in any such way that
its performance is affected. There is no warranty due to neglect,
alteration or ordinary wear and tear. TRION’s liability is limited to
replacement of defective parts or components and does not include
the payment of the cost of labor charges to remove or replace such
defective components or parts.
7. TRION will not be responsible for loss of use of any product;
loss of time, inconvenience, or any other indirect, incidental or
consequential damages with respect to person or property, whether
as a result of breach of warranty, neglect or otherwise. SOME
STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION
OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE
LIMITATION OR EXCLUSION IN THE PRECEDING SENTENCE
MAY NOT APPLY TO YOU.
8. THIS WARRANTY GIVES YOU SPECIFIC RIGHTS, AND YOU
MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE
TO STATE.
9. Any warranty by TRION of merchantability, tness for use or any
other warranty (express, implied or statutory), representation or
guarantee other than those set forth herein, shall expire at the
expiration date of this express limited warranty. SOME STATES
DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED
WARRANTY LASTS, SO THE LIMITATION IN THE PRECEDING
SENTENCE MAY NOT APPLY TO YOU.
10. TRION reserves the right to make changes in the design and
material of its products without incurring any obligation to
incorporate such changes in units completed on the effective date
of such change.
2. Safety & Warnings
!
DANGER
RISK OF ELECTRIC SHOCK
Before installlation, cleaning, servicing, or parts replacement,
the unit must be disconnected from all sources of electricity.
There may be more than one switch.
!
WARNING
Never expose eyes or skin to the UVC light.
• Looking directly at a UVC light source may cause
permanent eye damage or even blindness.
• Never operate the UV360 Purifying System outside
plenum.
• This product is designed for a closed HVAC duct
system. Do not mount near a supply or a return air
opening.
• All duct openings in direct line of site of the UVC energy
source is to be sealed, using an aluminum tape or an
equivalent sealing product.
!
WARNING
Improper installation, adjustment, alteration, service,
or maintenance may cause property damage, injury, or
death. This appliance must be installed according to these
instructions. Read these instructions thoroughly before
installing or servicing the unit.
!
CAUTION
Read these instructions thoroughly before installing this unit.
Check data label and verify electrical specications agree
with those at the point of installation.
!
WARNING
Installation in freezing conditions can result in unit failure.
Damage to personal property may also result.
!
CAUTION
TRION recommends that this UV Air Cleaner be installed by
a trained HVAC professional. Do not connect the unit to the
power source until the installation is complete. A thorough
checkout of the unit installation should be completed before
operating the unit. Failure to follow these directions may void
the manufacturer’s original warranty.
!
WARNING
Electrical power to the furnace must be disconnected before
proceeding. Serious injury or death may result.
!
WARNING
If the UV lamp is broken, DO NOT TOUCH the lamp or
internal contents of lamp. The lamp contains mercury.
• After opening the carton, unpack and inspect the
unit and lamp for damage. Do not install this unit
if any noticeable damage. If lamp is damaged
do not touch lamp or other contents in carton.
Close carton and return to seller immediately.
• In case of accidental exposure to internal contents of
lamp, wash hands and affected skin with mild detergent.
Remove any affected clothing immediately. If skin has
been pierced, seek medical attention immediately.
2 www.trioniaq.com
ComfortBreeze® UV360-1 System
Page 3
Installation, Operation, & Maintenance Manual
3. Application
The UV360’s unique “low-voltage” 24V power supply delivers
up to 22 Watts of UV-C power into most any application.
Its lamp and socket are water-resistant, and 24V power
means reduced danger from re or shock. The UV360
installs simply from the exterior of HVAC equipment, no
need to access the systems interior. Simply create a 2-7/8”
insertion hole at the intended site, mount the xture and plug
its UL Listed adapter into a nearby wall socket, or, wire it to
a suitable 24V power source (with no power uctuations).
NOTE: THE UV360 IS RATED AT 22VA. IT IS
RECOMMENDED THAT THE ANTICIPATED 24V SOURCE BE
CHECKED FOR ITS ABILITY TO SERVICE A 22VA LOAD. A
SEPARATE TRANSFORMER IS RECOMMENDED.
4. Safety Considerations
Improper installation, adjustment, alteration, service,
maintenance, or use can cause re, electrical shock, or other
conditions which may cause personal injury or property damage
and loss of warranty. Consult a qualied installer, service
agency, or your supplier for information or assistance. The
qualied installer or agency must use factory kits or accessories
when installing this product. Refer to the individual instructions
packaged with kits or accessories when installing them. Follow
all safety codes and wear safety glasses and work gloves.
Read all instructions thoroughly and follow any warnings or
cautions attached to any accessed area. Consult local building
codes and the National Electrical Code (NEC) for all applicable
requirements.
Understand the signal words DANGER, WARNING or CAUTION.
These words are universally used for overall safety. DANGER
identies the most serious hazards, which will result in severe
personal injury or death. WARNING signies hazards, which
could result in personal injury or death. CAUTION is used to
identify unsafe practices, which would result in minor personal
injury or product and property damage and loss of warranty.
4. General
1. UV360 xtures are used to bathe surfaces, air or both with
UV-C energy. For surfaces locate the UV360 at known
growth areas such as above the coil and drain pan rst,
then other moist areas around humidiers, etc. They can
also be placed in return, supply and mixed air plenums or
any combination of these locations.
5. Power Requirements
The UV360 is rated at 24V DC 50/60Hz-1 AMP.
6. Installation
(designed for metal plenums/drain pans and ducting):
1. Consult all applicable codes before installing. Check xture
label(s) for the correct power requirements and supply the
correct voltage from a suitable, protected (fused or breaker),
and grounded power source.
!
CAUTION
Using other than labeled voltages voids warranty and may
damage to the entire system. Operate xture
continuously to avoid growth of mold and bacteria in
damp areas (when AHU is off) and to extend product life.
2. Power must also be switched, at all install access points,
with a properly rated SPST interlock switch to completely deenergize the assembly when its install location is accessed.
Accesses are to have signs in appropriate languages
alerting maintenance personnel to the possible hazard of
looking at, or exposing skin to UVC energy (English label(s)
provided).
NOTE: UV-C energy may damage certain plastics.
Protect susceptible items with UV-C resistant materials such
as aluminum tape, foil or aluminum paint when these items
are in “line of sight” of UV-C energy.
3. Determine mounting location and apply template - cut the
hole using the included 2 7/8” hole saw.
4. When installing on duct-board, use the provided Duct-Board
Mounting Plate to provide a stronger mounting surface.
Apply template to the Duct-Board Mounting Plate.
!
CAUTION
Do not drill into refrigerant lines or other critical system
components. After cutting hole, avoid sharp edges.
5. Slide mounting “ring” into hole and afx with 3 Phillips
screws (Image B)
2. Check rst for power 120V wall socket availability or 24V
DC and all probable service accesses.
“What’s in the Box?”
UV360 Description
167315-001 UV-C Light Kit*
167315-102 UV Bulb, 17” Phillips
* UV-C Light Kit includes hole saw, installation template,
mounting ring, and 24V DC adapter.
ComfortBreeze® UV360-1 System
Image A: Mounting Ring Image B: Mounting Ring
www.trioniaq.com
3
Page 4
Installation, Operation, & Maintenance Manual
7. Connecting Power
6. Remove LampClamp™ ‘nut’ (image C). Insert lamp into
socket until it “clicks” in. Slide LampClamp over end of lamp
and hand tighten.
Locking Clip
Image C: LampClamp
7. Insert power supply/UV lamp into the mounting ring; pull up
on yellow locking clip; turn clock-wise until power supply is
fully installed.
8. Push-in yellow locking clip to lock power supply into
mounting ring (photo C).
1. Hardwiring: Read labeled power requirements – wire to
24V-1A, DC power, in accordance NEC and local codes.
2. All power-in ‘wire’ and ‘switch ratings’ must be in accordance with applicable codes. Power must also be switched
at all install access points with a properly rated, SPST interlock switch in order to completely de-energize the assembly
when its install location is accessed.
3. Connect power “cap” (white) to xture and twist clockwise
to secure.
4. Soft wiring: A 24V DC adapter is provided. Plug adapter
into 120V wall socket and secure.
8. Maintenance
UV-C lamps should be replaced annually. While there still
may be a visible blue light, this is not an indication of UV-C
output (the UV-C wavelength is invisible). Contact your
local TRION representative or visit www.trioniaq.com.
Lamp part number: 167315-102.
4 www.trioniaq.com
ComfortBreeze® UV360-1 System
Page 5
9. Diagrams
4.72”
Installation, Operation, & Maintenance Manual
18”
Power Cap
Lamp Clamp UV-C Lamp
UV360
24V power supply
(ballast)
Lamp Socket
Mounting Ring
10. Installation Location Options
The ComfortBreeze UV360 24V UV-C xture can be placed in several locations in the A/C system. Images of typical residential A/C
systems and the various locations that the ComfortBreeze UV360 can be installed are as follows:
A = Best installation
B = Better installation
C = Good installation
Typical Horizontal A-Coil: Right Airow (Figures 3 and 4)
Figure 3
Figure 4
Typical Upow Coil
Typical Horizontal Slab Coil (Figures 1 and 2)
Figure 1 Figure 2
ComfortBreeze® UV360-1 System
Typical Horizontal A-Coil: Left Airow (Figure 5)
Figure 5
www.trioniaq.com
5
Page 6
101 McNeill Rd. | Sanford, NC 27330
P: 800.884.0002 | F: 800.458.2379 | www.trioniaq.com | customerservice@trioniaq.com
Form No. 167315-500 Rev. 07/15 © TRION 2015. All Rights Reserved.
TRION
®
Loading...