Trane TDC1B040A9241A, TDC1B060A9361A, TDC1B080A9421A, TDC1C100A9481A, TDC1D120A9601A User Manual

Downflow/Horizontal
Condensing,
Gas-Fired Furnace

XB 90

TDC1B040A9241A, TDC1B060A9361A
TDC1B080A9421A, TDC1C100A9481A
TDC1D120A9601A

Single-Stage Fan Assisted
Combustion System

PUB. NO. 22-1670-10

General
Features

NATURAL GAS MODELS

Central Heating furnace designs are
certified by the American Gas Associa­tion for both natural and L.P. gas. Limit
setting and rating data were established
and approved under standard rating
conditions using American National
Standards Institute standards.

SAFE OPERATION

The Integrated System Control has
solid state devices, which continuously
monitor for presence of flame, when the
system is in the heating mode of opera­tion. Dual solenoid combination gas
valve and regulator provide extra safety.

QUICK HEATING

Durable, cycle tested, heavy gauge
aluminized steel heat exchanger
quickly transfers heat to provide warm
conditioned air to the structure. Low
energy power vent blower, to increase
efficiency and provide a positive dis­charge of gas fumes to the outside.

BURNERS

Multiport Inshot burners will give years
of quiet and efficient service. All models
can be converted to L.P. gas without
changing burners.

INTEGRATED SYSTEM CONTROL

Exclusively designed operational pro­gram provides total control of furnace
limit sensors, blowers, gas valve, flame
control and includes self diagnostics for
ease of service. Also contains connec­tion points for E.A.C./humidifier.

AIR DELIVERY

The variable speed, direct drive blower
motor, has sufficient airflow for most
heating and cooling requirements, will
switch from heating to cooling speeds
on demand from room thermostat. The
blower door safety switch will prevent or
terminate furnace operation when the
blower door is removed.

STYLING
Heavy gauge steel and “wrap-around”
cabinet construction is used in the

cabinet with baked-on enamel finish for
strength and beauty. The heat exchang­er section of the cabinet is completely
lined with foil faced fiberglass insulation.
This results in quiet and efficient opera­tion due to the excellent acoustical and
insulating qualities of fiberglass. Built-in
bottom pan and alternate bottom, left or
right side return air connection provision.

FEATURES AND
GENERAL OPERATION

The XV 80 High Efficiency Gas Fur­naces employ a Hot Surface Ignition
system, which eliminates the waste of
a constant burning pilot. The integrated
system control lights the main burners
upon a demand for heat from the room
thermostat. Complete front service

access.
a. Low energy power venter
b. Vent proving pressure switch.

© Trane 2015

2

Pub. No. 22-1670-10

Contents

Feature Summary

Features and Benefits

General Data

Performance Data

Electrical Data

Field Wiring

Dimensions

2

4

Standard Equipment
Optional Equipment

6

TDC1B040A9241A
TDC1B060A9361A
TDC1B080A9421A
TDC1C100A9481A
TDC1D120A9601A

8

9

11

13

Pub. No. 22-1670-10

3

Features
and Benefits

XB 90 STANDARD EQUIPMENT

•Downowpowersupply115/1/60

•Downowconvertibletohorizontalon

left side

•Type 29-4CTM stainless steel

secondary heat exchanger

•Innerblowerdoors

•Directdrive,4-speedmotor

•SiliconNitridehotsurfaceigniterwith

adaptive heat up

•Accessoryhook-upcapability-Hum

and EAC

•Quietinduceddraftblower

•Blowerdoorsafetyswitch

•Dualsolenoidcombinationgasvalve&

regulator

•PVCventing-1Pipe

•Left/rightgasconnection

•Selectablecoolingfanoffdelayelimi-

nates need for BAY24X045 time delay
relay

•Integratedsolidstatecontrolwith
self diagnostics

•24voltfuse

•Manualresetburnerboxlimit

• Optional extended warranties

4

Pub. No. 22-1670-10

Features
and Benefits

XB 90 OPTIONAL EQUIPMENT

Thermostat, Electronic, Non-programmable 1 Heating/1 Cool ...................................................................... TCONT200AN11AA [ ]

Thermostat, Electronic Programmable 1-Stage Heating/1-Stage Cooling .................................................... TCONT800AS11AA [ ]

Thermostat, Heating/Cooling Single Stage (Mounts Vertically) ................................................................................ BAYSTAT305 [ ]

Thermostat, Electronic Programmable 1-Stage Heating/1-Stage Cooling ...............................................................BAYSTAT300 [ ]

Propane Conversion Kit .........................................................................................................................................BAYLPKT210A [ ]

Electronic Air Filter, “Perfect Fit” High Efficiency (17-1/2" Wide Gas Furnace) ......................................................TFM175A9FR0 [ ]

Electronic Air Filter, “Perfect Fit” High Efficiency (21" Wide Gas Furnace) ............................................................TFM210A9FR0 [ ]

Electronic Air Filter, “Perfect Fit” High Efficiency (24-1/2" Wide Gas Furnace) ......................................................TFM245A9FR0 [ ]

Electronic Air Filter, “Perfect Fit” Standard Efficiency (17-1/2" Wide Gas Furnace)............................................... TFP175A9FR0 [ ]

Electronic Air Filter, “Perfect Fit” Standard Efficiency (21" Wide Gas Furnace) ..................................................... TFP210A9FR0 [ ]

Electronic Air Filter, “Perfect Fit” Standard Efficiency (24-1/2" Wide Gas Furnace)............................................... TFP245A9FR0 [ ]

Coil Enclosure (17-1/2" Wide Cabinets) ..........................................................................................................BAYCLE17A1722A [ ]

Coil Enclosure (21" Wide Cabinets) ................................................................................................................BAYCLE21A2130A [ ]

Coil Enclosure (24-1/2" Wide Cabinets) ..........................................................................................................BAYCLE24A2430A [ ]

Side Filter Rack ........................................................................................................................................................BAYFLTR200 [ ]

High Altitude Switch ..................................................................................................................................................BAYHALT239 [ ]

Pub. No. 22-1670-10

5