Thermos 4656213, Grill2Go 4656110, Grill2Go 4656213 Assembly Manual
Grill2GO • 1
This Grill is for
Outdoor Use Only
• Some parts may contain sharp edges especially as noted in the manual!
Wear protective gloves if necessary.
WARNINGWARNING
WARNINGWARNING
WARNING
Read and follow all Safety
Statements, Assembly Instructions,
and Use and Care Directions before
attempting to assemble and cook.
Installer / assembler: Leave these
instructions with consumer.
To Consumer: Keep this manual for
future reference.
CACA
CACA
CA
UTIONUTION
UTIONUTION
UTION
ASSEMBLY
MANUAL
• Failure to follow all manufacturer’s
instructions could result in fire or
explosion which could cause property
damage, personal injury or death.
4656110-6213 E\F / 4-36-6047-050-200 (01-31-02)
Models
46561104656110
46561104656110
4656110
46562134656213
46562134656213
4656213
2 • Grill2Go
FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable vapors and liquids in
the vicinity of this or any other appliance
2. An LP Tank not connected for use shall not be stored in the vicinity of
this or any other appliance.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your gas supplier or your fire
department.
Safety Symbols
• The symbols and boxes shown below explain what each heading means.
Read and follow all of the messages found throughout the manual.
• DANGER: Indicates an imminently hazardous situation which, if not avoided, will
result in death or serious injury.
• WARNING: Be alert to the possibility of serious bodily injury if the instructions are
not followed. Be sure to read and carefully follow all of the messages.
• CAUTION: Indicates a potentially hazardous situation which, if not avoided, may
result in minor or moderate injury.
CACA
CACA
CA
UTIONUTION
UTIONUTION
UTION
WARNINGWARNING
WARNINGWARNING
WARNING
DD
DD
D
ANGERANGER
ANGERANGER
ANGER
WARNINGWARNING
WARNINGWARNING
WARNING
Grill2GO • 3
Call Grill Service Center For Help And Parts
• If you need help or warranty parts call
!!
!!
!1-800-241-7548 or send a FAX to
1-706-576-6355.
Business hours: Open 24 hours - Seven days a week
• To order non-warranty replacement parts or accessories (grill cover, 4’ Adaptor Hose,
Carrying case) call 1-800-993-2677 or visit www.Grilllovers.com send a FAX to 1-706565-2121.
Installation Safety Precautions
• This grill is designed for use with LP (propane) gas. The regulator/valve supplied must
be used. Replacement parts must be those specified by the manufacturer.
• Grill installation must conform with local codes, or in their absence with
National Fuel Gas Code, NFPA 54 / ANSI Z223.1 or CAN/CGA-B149.2 Propane
Installation Code. Handling and storage of LP cylinders must conform to LP Gas
Code NFPA/ANSI 58. Grill is not to be installed in or on recreational vehicles and/or
boats.
Keep any electrical cords and/or fuel supply hoses away from any hot surfaces.
• This grill is safety certified for use in the United States and Canada only. Do not
modify for use in any other location. Modification will result in a safety hazard.
This product is subject to patents pending in the U.S. and other countries.
• For residential use only. Do not use for commercial cooking.
Warranty Information
Model Number ______________________________________
Serial #(on grill)_______________________________________
Date Purchased ______________________________________
LP (Liquefied Petroleum Gas)
• Is nontoxic, odorless and colorless when produced. For Your Safety, LP gas has
been given an odor (similar to rotten cabbage) so that it can be smelled.
• LP gas is highly flammable and may expect ignite unexpectedly when mixed
with air.
CACA
CACA
CA
UTIONUTION
UTIONUTION
UTION
Important: Fill out Warranty Information below
4 • Grill2Go
Warranty
Thermos warrants to the original consumer-purchaser that this product shall be free from defects in
workmanship and materials under normal and reasonable use and correct assembly (If assembled by
consumer-purchaser) as follows:
(1) The aluminized top and bottom for a period of three (3) years from the date of purchase; excluding
the paint finish;
(2) The burner/venturi assembly for a period of three (3) years from the date of purchase;
and
(3) All other parts, for a period of one (1) year from the date of purchase.
Thermos will, at its option, refinish or replace any product or part found to be defective during the
warranty period. Thermos will require you to return the part(s) claimed to be defective, for its inspection,
freight or postage prepaid. If you wish to obtain performance of any obligation under this limited warranty,
you should write to:
THERMOS GRILLS
Consumer Warranty / P.O. Box 1240
Columbus, GA 31902-1240
Thermos may require reasonable proof of purchase and we suggest you keep your receipt. In the
state of California only, if refinishing or replacement of the product is not commercially practicable, the
retailer selling this product or Thermos will refund the purchase price paid for the product, less the amount
directly attributable to use by the original consumer-purchaser prior to discovery of the nonconformity. In
addition, in the state of California only, you may take the product to the retail establishment from which it
was purchased or to any retail establishment selling this product in order to obtain performance under this
warranty. This warranty does not include the cost on any inconvenience or property damage due to failure
of the product and does not cover damage due to misuse, abuse, accident, damage arising out of
transportation of the product, or damage incurred through commercial use of the product. ALL IMPLIED
WARRANTIES, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A
PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO THE EXPRESS WARRANTY PERIODS
SPECIFIED ABOVE FOR THE PARTS DESCRIBED THEREIN. Some states do not allow limitations on how
long an implied warranty lasts, so the above limitation may not apply to you. Neither dealers nor the retail
establishment selling this product has any authority to make any warranties or to promise remedies in
addition to or inconsistent with those stated above. Thermos' maximum liability, in any event, shall not
exceed the purchase price of the product paid by the original consumer-purchaser. Some states do not
allow the exclusion or limitation of incidental or consequential damages, so the above l imitations or
exclusions may not apply to you. The warranty gives you specific legal rights and may also have other
rights which vary from state to state.
Grill2GO • 5
Table of Contents
For Your Safety ........................................................................................................................2
Safety Symbols........................................................................................................................2
LP (Liquefied Petroleum Gas).....................................................................................................3
Call Grill Service Center For Help And Parts..................................................................................3
Installation Safety Precautions .....................................................................................................3
Warranty Information...............................................................................................................3
Warranty ................................................................................................................................4
Table of Contents .................................................................................................................5
Assembly
Assembly ........................................................................................................................ 6-9
Li d Exploded View ............................................................................................................11
Body Exploded View .........................................................................................................12
Base\Legs Exploded View .................................................................................................13
Leak Test .........................................................................................................................14
Operation
For Safe Use Of Your Grill(1lb tank) ......................................................................................15
Safety Tips ........................................................................................................................16
Ignitor Check.....................................................................................................................16
Ignitor Lighting For This Grill ..................................................................................................16
Match Lighting ...................................................................................................................17
Burner Flame Check ..........................................................................................................17
Before Your First Cookout ....................................................................................................17
Turning Grill Off ..................................................................................................................17
Heat Indicator Instructions .....................................................................................................17
Leveling Your Grill ..............................................................................................................18
Care
General Grill Cleaning .........................................................................................................18
Cleaning Burner Assembly .................................................................................................19
Non-Stick Surface care and use. ..........................................................................................19
Cooking
Food Safety.......................................................................................................................20
How To Tell If Meat Is Grilled Thoroughly...............................................................................20
Storing Your Grill ..............................................................................................................20
Troubleshooting................................................................................................................21
20lb Cylinder and Adapter Hose Use and Care. .............................................................. 22-26
Recreational Vehicles .........................................................................................................2 7
6 • Grill2Go
NOTE: Your grill will require minimal assembly The Grill2Go™ is
packaged in three major components. Additional parts are stored within
grillbody and legs.
Side with graphics should face forward.
Leg with locking device is on the right
when assembling.
Base is designed to fit into slots
at each corner of leg assembly.
Carton
1
2
Legs
Base
Body
Assembly
Base will only fit
into legs one way.
NOTE: The twelve Rubber Spacers
located on the grill lid are designed
to help protect the non-stick
cooking surface. They should not
be removed.
Remove all protective packaging and Product
Information Cards before assemby.
Spacers
Spacers
Grill2GO • 7
Carriage bolt fits completely through
holes in Base and Legs. NOTE: Use
square hole not round hole when
assembling Legs to Base.
NOTE: Do not fully tighten fasteners at this time.
Release leg lock by pulling hook.
Top View
FRONT
Unfold legs to locked position.
A
B
Plastic Hand
Fastener
Carriage Bolt
Qty: 4
Qty: 4
4
Washer
Qty: 4
3
8 • Grill2Go
With legs fully extended, hand-tighten fasteners.
Grill body fits
firmly on to base.
Attach 1lb tank to
regulator and twist
clockwise.
Connect regulator
to burner tube on
righ tside of grill.
A
B
NOTE: 1lb tank sold separately.
Regulator slides
straight into burner.
Regulator should
rest firmly against
burner.
Grease container slides
onto slot on left side of
base. Cap on Grease
container should be open
when installing
5
6
Ignitor fits
into slot in
base.
B1
B2
Grill2GO • 9
B
Shelf with (Valve) hole attaches
to the right side of grill.
For transporting grill, store side shelves by stacking shelves together
(shelf with cut out for regulator must be on bottom) and placing them
on screw(A) using the center tool holders(B). Once in place, use
Plastic hand fastener(C) to secure.
B
A
C
7
Loading...