Thermador Cgb36ru, Cgb30rculp Owner's Manual
Care
&
Use Manual
for
Thermador Char Glo
Models:
CGB30RCULP • CGB36RU
CGB48RU • CGB48RSBU
Page 27
®
Outdoor Barbecues
A Special Message to Our Customers
Thank you for selecting the Thermador® Char Glo® outdoor barbecue. We
recommend that you take time to read this entire booklet before using your
new appliance for the first time.
This booklet contains suggestions we believe will be helpful as well as
directions for using all the features of your appliance. Keep it in a handy place
as it has the answers to questions that may occur when you start to cook.
Let us know if we can help you. When you write please include the model and
serial numbers of your barbecue.
Sincerely,
Thermador Test Kitchen Consumer Scientists
Page 26
TABLE OF CONTENTS
Warnings for Safe Gas Installations .......................................................... 2
For Y our Safety ........................................................................................................... 2
What To Do If You Smell Gas ................................................................................. 2
Important Information ............................................................................................. 3
Warnings for Safe Gas Gas Installations .............................................................. 3
Warning: California Proposition 65 B.................................................................. 3
Section 1: Safety Practices to Avoid Personal Injury ....................... 4
Important Safety Instructions............................................................................. 4, 5
Section 2: Model and Parts Identification ............................................. 6
Model CGB48RSBU.................................................................................................. 6
Model CGB48RU....................................................................................................... 7
Model CGB30RCULP............................................................................................... 8
Installation of LP (Propane) Gas Tank................................................................... 9
LP Lighting Instructions............................................................................................ 9
Model CGB36RU.....................................................................................................10
Section 3: Using Your Char Glo® Barbecue.........................................11
Before The First Use............................................................................................... 11
Lighting Instructions with Automatic Ignition...................................................12
Lighting Instructions for Manual Lighting...........................................................13
Section 4: The Grill ........................................................................................ 14
General Grill Information......................................................................................14
Using the Grill ..........................................................................................................14
General Smoker Information................................................................................15
Using the Smoker....................................................................................................15
Grilling Chart .................................................................................................... 16, 17
Section 5: The Rotisserie .............................................................................18
Using the Rotisserie................................................................................................18
General Rotisserie Information ...........................................................................18
Rotisserie Assembly ................................................................................................18
Trussing Poultry ....................................................................................................... 19
Rotisserie Chart ......................................................................................................20
Thermometer Gauge..............................................................................................20
Section 6: Extra Features........................................................................... 21
General Side Burner Information........................................................................21
Using the Side Burners....................................................................................... 21
Side Shelf....................................................................................................................21
Section 7: Care And Maintenance ...........................................................22
Quick Clean Method for Grates ......................................................................... 22
Quick Clean Method for the Grill.......................................................................22
Quick Clean Method for the Drip Tray..............................................................22
Cleaning Chart .........................................................................................................23
Section 8: Service............................................................................................24
Before Phoning for Service ...................................................................................24
Troubleshooting....................................................................................................... 24
Section 9: Warranty .......................................................................................25
Page 1
WARNINGS FOR SAFE GAS INSTALLATIONS
Installer: Please leave these instructions with the unit for the owner.
Owner: Please retain these instructions for future refer ence.
WARNING: If the information in this manual is not followed exactly, a fire or
!
▲
explosion may result causing property damage, personal injury or death.
FOR YOUR SAFETY
✓ Do not store or use gasoline or
other flammable vapors and
liquids in the vicinity of this or
any other appliance.
WHAT TO DO IF YOU SMELL GAS
• Shut off gas to the appliance.
• Extinguish any open flame.
• Open Lid.
• If odor continues, immediately phone your
gas supplier.
• If you cannot reach your gas supplier, call
the fire department.
AVERTISSEMENT
✓ Ne pas entreposer ni utiliser de
l‘essence ni d’autres vapeurs ou
liquides inflammables dans le
voisinag e de l’appar eil, ni de tout
autre appareil.
S’IL Y A UNE ODEUR DE GAZ:
• Coupez l’admission de gaz de l’appariel.
• Ènteindre toute flamme nue.
• Ouvrir le couvercle.
• Si l’odeur peraiste, a ppeler immediatement
votre compagnie de gaz ou votre
departement des incendies.
Installation and service must be performed by a qualified installer,
service agency or the gas supplier.
TESTED IN ACCORDANCE WITH ANSI Z21.58-1995, STANDARD FOR OUTDOOR
COOKING GAS APPLIANCES AND CAN/CGA 1.6-M95, STANDARD FOR OUTDOOR
COOKING GAS APPLIANCES.
This unit is for outdoor use only in a w ell-ventilated area. Not to be
used in a building, garage or any other enclosed area.
Check your local building codes for the proper method of installation. In the absence of local codes this
unit should be installed in accordance with the National Fuel Gas Code No. Z223.1 Current Issue and
National Electrical Code ANSI/NFPA No. 70 Current Issue or the CAN/CGA - B149.1 Natural Gas
Installation Code or CAN/CGA - B149.2 Propane Gas Installation Code and C22.1 Canadian Electrical
Code Part 1.
Page 2
WARNINGS FOR SAFE GAS INSTALLATIONS
IMPORTANT INFORMATION
This outdoor gas cooking appliance is not intended to
be installed in or on recreational vehicles and/or boats.
Always inspect the natural gas or LP gas hose assembly
before each use of the appliance. If there is evidence of
excessive abrasion or wear, or if the hose is cut, it must
be replaced prior to the appliance being put into
operation. Replacement hose assemblies can be
purchased at barbecue supply stores, or ordered through
Thermador® (see the rear cover for contact
information). If purchased at a retail outlet, the hose
assembly must be identical to the one supplied with the
unit. To inspect the hose assembly inside the unit, open
the left door on model CGB30RCULP or slide out the
left storage drawer on models CGB36RU, CGB48RSBU
and CGB48RU.
Keep the area around the appliance clear and free from
combustible materials, gasoline and other flammable
vapors and liquids.
Do not place any items in front of the unit while in use.
This could obstruct the proper flow of air needed for
proper combustion and ventilation.
Keep the ventilation opening(s) of the LP cylinder
enclosure free and clear of obstructions and debris.
Keep any electrical supply cord and the fuel supply hose
away from any heated surfaces.
Do not leave the grill unattended while cooking.
WARNING: CALIFORNIA PROPOSITION 65 B
The burning of gas cooking fuel generates some byproducts that are on the list of substances which
are known by the State of California to cause
cancer or reproductive harm. California law
requires businesses to warn customers of potential
exposure to such substances. To minimize exposure
to these substances, always operate this unit
according to the instructions contained in this
booklet and provide good ventilation when cooking
with gas.
Page 3
SECTION 1: SAFETY PRACTICES TO AVOID PERSONAL INJURY
IMPORTANT SAFETY INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USING YOUR BARBECUE
SAFETY PRECAUTIONS
When properly cared for, your new Thermador® Char
Glo® barbecue has been designed to be a safe and
reliable appliance. However, extreme care must be
used as the grill produces intense heat and can increase
the potential for accidents or injury. When using this
appliance, basic safety precautions must be followed,
including the following:
• Read this manual carefully before using the
barbecue to reduce the risk of fire, electric shock, or
injury to persons.
• Insure proper installation. Follow the instructions
in Sections 3 through 5 in the Installation Instructions.
Have the installer show you where the gas supply
shutoff valve is located, and how to shut off the gas to
the barbecue. Always adhere to the minimum clearances
to combustible materials as specified in Section 3.
• Do not repair or replace any part of this
appliance unless specifically recommended in this
manual. All other servicing should be referred to a
qualified service technician.
• This appliance is equipped with a three-prong
(grounding) plug for your protection against
shock hazard and should be plugged directly into a
properly grounded three-prong receptacle. Do not cut
or remove the grounding prong from this plug.
• Be aware that spiders and insects can nest in
the burners of this barbecue. This can obstruct the
proper flow of gas into the burner and cause improper
operation, fire hazard and potential damage to the unit.
Inspect the burners periodically, or immediately if any
of the symptoms denoted in Section 8 exist.
• The top cover (hood) is to be closed during the
outdoor cooking gas appliance preheat period.
• Never move barbecue with hood raised.
• Keep hands and fingers away from all edges of the
hood when it is in raised position.
WARNING: Never block vent opening at rear of
hood. Use with the vent opening
blocked will result in damage to the
unit and may cause a fire or injury.
• If you smell gas when the unit is not in use, have the
unit checked for leaks as defined in Section 4. Finding a
gas leak is not a do-it-yourself procedure as some leaks
can only be found with the burner control in the ON
position. This must be done by a qualified technician.
• If you smell gas when the unit is in use, immediately
shut off all controls. Open the lid and let the gas
dissipate for at least five minutes. Relight the burner(s)
and verify that they are operating properly. If the
burner(s) fail to relight or are not operating properly,
shut of the gas to the unit and have the unit checked by
a qualified service technician. See Section 9.
• Children should not be left unattended in the
area where the barbecue being used. Never allow
children to sit, stand or play on or around the barbecue
at any time. When in use, portions of the grill get hot
enough to cause severe burns. Children should never
be allowed to crawl inside the cart or enclosure.
• To avoid the potential for a grease fire, frequently
clean the drip tray. Be sure to let the unit cool
completely before removing the tray for cleaning.
LP TANK REQUIREMENTS
Model CGB30RCULP is provided with an LP tank from
the factory. All other units can be converted for use
with an LP tank which can be purchased locally at a
barbecue supply store or other retail outlet. The
maximum tank capacity for use with
Thermador® Char Glo® barbecues is twenty
pounds (five gallons). The tank must be constructed
and marked in accordance with the specifications for
LP-gas tanks of the U.S. Department of Transportation
(DOT) or the National Standard of Canada, CAN/
CSA-B339, tank, Spheres and Tubes for the
Transportation of Dangerous Goods. To minimize the
potential for fire or an explosion, the following
precautions should be observed when using, filling or
storing an LP tank:
• Never use a dented or rusty LP tank. If there is
any question as to the soundness of the tank, have it
checked by your LP supplier.
• Never use a tank with a damaged or defective
shut off valve.
• Always close the tank shut off valve after use.
Page 4
FOR YOUR SAFETY
• The gas supply must be turned off at the
LP-gas supply tank when this outdoor cooking gas appliance is not in use.
• The LP-gas supply cylinder must be disconnected when this outdoor cooking gas
appliance is not in use.
AVERTISSEMENT
• L’alimentation du gaz doit étre fennée a
la bouteille de gaz de pétrole liquéfié,
lorsque cet appareil de cuisson extérieur
n’ est pas utilisé.
• La bouteille d’alimentation en gaz de
pétrole liquéfié doit étre débranchée,
lorsque cet appareil de cuisson extérieur
n’est pas utilisé.
• Do not overfill the LP tank. Never fill the LP tank
beyond eighty percent (80%) of its capacity. Overfilling
will cause the pressure relief valve on the tank to vent
excess gas vapor. This vapor is combustible and can
ignite, causing a fire.
FOR YOUR SAFETY
An LP tank not connected for use shall not
be stored in the vicinity of this or any other
appliance.
AVERTISSEMENT
Une bouteille de propane qui n’est pas
raccordée en vue de son utilisation, ne doit
pas etre entreposée dans le v oisinage de cet
appareil ou de tout autre appareil.
• The LP tank must be disconnected and removed
from the appliance if the appliance is to be stored
indoors.
• Always check for leaks after every tank change.
See Section 6 of Installation Instructions.
FOR YOUR SAFETY
For Outdoor Use Only. If stored indoors,
detach and leave tank outdoors.
• When transporting an LP tank, insure it is in an
upright position and away from any sources of high
heat.
• Do not store additional LP tanks inside the cart
of the unit. Tanks must be stored outdoors in a well-
ventilated area out of direct sunlight and/or sources of
high heat, and out of the reach of children.
• LP tank supply system must be arranged for
vapor withdrawal.
• LP tank used must include a collar to protect the
tank valve.
AVERTISSEMENT
P our utlilisation a la l’e xtérieur seulement.
Si l’appareil est entreposé à l’intérieur,
enlever les bouteilles et les laisser a
l’extérieur.
CAUTION
Simultaneous operation of rotisserie
burners, smok er burner and grill burners on
the HI setting is not recommended.
Excessive temperatures could result.
Page 5
SECTION 2: MODEL AND PARTS IDENTIFICATION MODEL CGB48RSBU
2
16
Front of
hood
5
1
3
17
4
9
11
6
10
8
13
19
20
1. Hood / Lid with Handle
2. Thermometer Gauge and Thermador Nameplate
3. Infrared Rotisserie Burner (1)
4. Rotisserie Motor
5. Rotisserie Glow Igniter
6 . Grill Grates:
6 on Model CGB36RU and
CGB48RSBU
8 on Model CGB48RU
7. Radiants (heating baffles shown Page 7)
8. Burners: 3 on CGB36RU and CGB48RSBU
4 on CGB48RU
9. Drip Pan
10 . Smoker T ray
11. Control Knobs
12. Ignition Switch
13. Lighting Instructions on control panel
14. LP Container / Storage Cabinet
15
12
14
15. Storage Drawers
16. Side Burners (cover shown in close up)
17. Sure-Lock™ shelves (2) (packaged with panel kit
models C48FP, C48SBFP, C36FP purchased
separately).
18. Toe Kick Panel (not shown)
(packaged with 36 and 48 models)
19. Data Rating Label (left sidewall, inside storage
drawer)
20. Front Caster with Lock.
Page 6
MODEL AND PARTS IDENTIFICATION MODEL CGB48RU
1
Ergo Balanced Hood
7
Rotisserie Glow
Igniters (2)
5
3
Infrared
Rotisserie
Burners (2)
Side Panel not
furnished with
built-in models.
To install as a
free-standing
model, order
C36FP, C48 FP
or C48SBFP
panel kit.
(Purchase
separately)
Literature Pack Contents:
✓ Product Registration Card – Please
complete and return. Thank You.
✓ User's Manual:
Care & Use Recommendations
Grill /Rotisserie Cooking Charts
✓ Installation Instructions
✓ Orifices for LP Conversion
AGA and CGA Approved
20
20
Page 7
Loading...