Tempo A018D-12C User Manual

Portable Air Conditioner

USER MANUAL

Model Number A018D-12C

AFTER SALES SUPPORT

(AU) 1300 886 649 (NZ) 0800 836 761

Contents

Page

03 Important Safety Instructions

07 R290-Specific Safety Advice

09 Getting Started

10 Product Overview

14 Installation

16 Instructions

19 FAQs & Troubleshooting Guide

20 Other Useful Information

2

After Sales Support

1300 886 649 | [e-mail]

Important Safety Instructions

READ CAREFULLY AND KEEP FOR FUTURE REFERENCE

Read this manual thoroughly before first use, even if you are familiar with
this type of product. The safety precautions enclosed herein reduce the risk
of fire, electric shock and injury when correctly adhered to. Make sure you
understand all instructions and warnings. Keep the manual in a safe place for
future reference, along with any warranty information, your purchase receipt
and the original packaging. If you sell or transfer ownership of this product,
pass on these instructions to the new owner.

Always follow basic safety precautions and accident prevention
measures when using an electrical appliance, including the following:

Electrical safety and cord handling

• Voltage: Before turning on the air conditioner, ensure the electrical voltage

and circuit frequency correspond to those indicated on the appliance.

• Socket: Ensure your electrical outlet is properly installed and earthed and
complies with your local electrical safety requirements.

• Moisture: To reduce the risk of electrocution, never operate the appliance
with wet hands; never submerge it in water or spill liquids into it. Do not use
it in a bathroom or laundry, or where it can be splashed with water.

• Power supply cord: Do not kink or damage the cord. Do not pull the cord
or place it near a heat source. Always unwind the cord completely to avoid
overheating. Run the cord in such a way so that no one will trip over it.

• Extension cord/adaptor: Do not use this appliance with an extension cord
or power adaptor.

• Damaged cord: If the supply cord is damaged, do not use the appliance.
A damaged power supply cord must be replaced by the manufacturer or
its service agent or a similarly qualified person in order to avoid a hazard.
Contact our after sales support centre.

• WARNING: Do not use when damaged! In case of damage, switch off the
appliance, unplug it and contact our after sales support centre. Do not pick
up or operate a damaged appliance, or after it malfunctions or has been
dropped or damaged in any manner.

• Power button: Do not use the mains plug to start and stop the unit; always
use the power button to start and stop the unit.

• Switching on/off: Do not use the mains plug to start and stop the unit;
always use the POWER button on the control panel or remote control to
start and stop the unit.

• Disconnect: Turn off the unit first and then unplug it when it is not in use
and before maintenance or cleaning, but do not unplug it when it is in
operation, as this could create a spark and cause a fire. Grip by the plug,
do not pull by the cord when disconnecting.

After Sales Support

1300 886 649 | [e-mail]

3

Important Safety Instructions (Cont.)

• RCD: The installation of a residual current device (safety switch) is
recommended to provide additional safety protection when using electrical
appliances. It is advisable that a safety switch with a rated residual
operating current not exceeding 30mA be installed in the electrical circuit
supplying the appliance. See your electrician for professional advice.

Usage conditions and restrictions

• Intended use: This appliance is intended for air conditioning indoor

domestic environments. It is not suitable for commercial, industrial or trade
use. Do not use it for any other purpose (such as drying clothes, cooling
food, etc.), and only use it as described in this manual.

• Common sense: These instructions are not intended to cover every
possible condition and situation. As with any electrical appliance, common
sense and caution are therefore always recommended when installing,
operating and maintaining the unit.

• No outdoor use: Do not use the unit outdoors. It is for indoor use only.

• Usage restriction: This appliance is not intended for use by persons

(including children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have been given
supervision or instruction concerning use of the appliance in a safe way
and understand the hazards involved.

• No external timer: This appliance is not intended to be used with an
external timer or a separate remote control system.

• WARNING: Do not cover! Do not cover the air conditioner or obstruct any
air inlet or outlet grilles. Obstructing these openings causes a fire hazard,
reduces the operating efficiency and may lead to malfunction or damage.

• Air outlets: Do not insert any objects, or your fingers, into the air outlet,
and make sure to warn children of the dangers. Keep ventilation openings
clear of obstructions.

• Children: Supervise children to ensure they do not play with the appliance.
Close supervision is necessary when any appliance is used by or near
children. Cleaning and user maintenance shall not be made by children
without supervision.

• Unattended: Do not leave the appliance unattended when in use.

• Attachments: The use of attachments not recommended or sold by the

manufacturer may cause fire, electric shock or injury.

• Start-up settings: Set the unit to maximum cooling and high speed
ventilation for the initial startup, then adjust the unit down to a more
comfortable setting as required.

• Airflow: Do not direct the airflow onto plants or animals, as long and direct
exposure to cold air from the air conditioner could adversely affect them.

4

After Sales Support

1300 886 649 | [e-mail]

Important Safety Instructions (Cont.)

• Cold air exposure: Never remain directly exposed to the flow of cold air
for a long time, as direct and prolonged exposure to cold air from the air
conditioner could be dangerous for your health. Take particular care in
rooms where there are children, old, or sick people.

• Moving the appliance: When moving the air conditioner, always turn it off
first and disconnect the power supply, and move it slowly. Keep the unit
upward during transport and storage.

Cleaning and maintenance

• Disconnect: Make sure the appliance is disconnected from the power

supply when it will not be used for a long time and before carrying out any
cleaning or maintenance.

• Air filters: Keep the air filters clean. Do not use the unit without the
air filters fitted. Using it without air filters could cause an excessive
accumulation of dust or waste on the inner parts of the device with
possible subsequent failures.

• Service and repair: The air conditioner has no user-serviceable parts
contained inside. Do not attempt to disassemble, modify or conduct
repairs on this unit. It has been built in accordance with relevant safety and
performance standards. An electrical specialist must carry out all repairs.
Contact our after sales support centre for advice on service.

• Unplug the appliance immediately if you notice any smoke, odour or
strange sounds coming from the unit. Call for a service.

• Risk of fire: This appliance contains a flammable refrigerant. Do not open
the appliance. In case of damage or malfunction, turn off the appliance,
disconnect the power supply and call our after sales support centre for a
service.

Installation

• Proper installation: Install the appliance according to the instructions in

this manual and national wiring regulations. Improper installation may result
in the risk of fire, electric shock and/or injury.

• WARNING: Electric shock hazard! Before installation or servicing, ensure
the unit is switched off and disconnected from the power outlet to prevent
possible injury.

• The location: When deciding on an installation place, keep in mind that
the area must be flat, the air outlets must not be covered up, and there
must be a properly earthed 220~240V~ 50Hz power outlet nearby.

After Sales Support

1300 886 649 | [e-mail]

5

Important Safety Instructions (Cont.)

• Do NOT install/use the appliance in the following areas:

– outdoors or where water is likely to splash
– near a bath, shower, laundry basin or swimming pool
– in an area where oil is likely to splash
– near a hot gas or electric burner, or sources of fire
– near sources of heat, or exposed to direct sunlight
– in an area where furniture or other objects can obstruct the airflow
– in the presence of flammable substances or vapour such as alcohol,

insecticides, petrol, etc.

– at a dry cleaner’s premises.

• Clearances: There must be a clearance of at least 30cm between the
appliance and any walls, furniture, curtains or any other obstacles (refer to
Fig. 1, below). Maintaining this minimum 30cm clearance is essential; failure
to keep that distance can result in the unit malfunctioning or causing injury.

• Window application: The air exhaust can be installed in a vertical or
horizontal sliding window (refer to Fig. 2, below).

• Air exhaust installation instructions follow on pages 14–15. Keep the length
of the air exhaust hose to the minimum length necessary during operation.

• Upright position: Place the unit on a flat surface to reduce the risk of it tipping
over. Do not tilt the unit, always keep it upright during installation and use.

• Misuse: We accept no responsibility for any eventual injuries or damages
caused by improper installation, faulty use or failure to follow the instructions.

Fig. 1

• Pressure specifications:

Permissible excessive operating pressure Discharge 2.6MPa

Maximum allowable pressure Discharge 3.2MPa

6

Fig. 2

Suction 1.0MPa

Suction 1.2MPA

After Sales Support

1300 886 649 | [e-mail]

R290-SpecicSafetyAdvice

Important safety precautions concerning refrigerant R290

WARNING: Combustible & Dangerous

This symbol alerts you to take care as the appliance contains
a flammable refrigerant: R290 (propane). Take extra care when
installing the unit and when carrying out maintenance.

The refrigerant used in this air conditioner, R290 (propane) is a colourless and
odourless hydrocarbon gas. Although R290 is highly flammable, it is an efficient
refrigerant with a high level of environmental compatibility, with a low Global
Warming Potential (GWP) and no potential for ozone depletion. While R290
is highly flammable, there will be no risk of burning and explosion if the air
conditioner is properly installed and maintained following all instructions and
safety advice in this manual.

Read the user manual

• The room in which this air conditioner is installed must have a minimum area
of more than 12m2. (This unit is designed for use in a room of approximately
18–23m2 size.)

• Do not expose the appliance to high heat, sparks and open flames.

• The appliance shall be stored in a room without continuously operating
sources, such as open flames, an operating ignition gas appliance or an
operating electric heater.

• Do not pierce or burn the appliance.

• This air conditioner has been fully charged with refrigerant at the factory.
Should a recharge of refrigerant become necessary, it may only be recharged
by a professional installer.

• Maintenance must only be carried out by properly qualified, authorised
personnel. If the appliance requires maintenance or service, please contact
our after sales support centre.

• The service technician must strictly comply with:
– all safety instructions in the manual provided with the appliance
– all relevant provisions of gas-related local laws and regulations.

After Sales Support

1300 886 649 | [e-mail]

7

R290-SpecicSafetyAdvice(Cont.)

• After servicing the appliance, the service technician must:
– check that air cannot enter the refrigerant system
– check for refrigerant leaks when moving the air conditioner
– carry out a test cycle under controlled conditions after installing the unit and

record the operating data.

Disposal

• This air conditioner contains a flammable refrigerant, which must be
removed before disposal. Contact your municipal authorities for any codes
or regulations concerning the disposal of such materials.

• At the end of its working life, do not throw this appliance out with your household
rubbish. Electrical and electronic products contain substances that can have
a detrimental effect on the environment and human health if disposed of
inappropriately. Observe any local regulations regarding the disposal of electrical
consumer goods and dispose of it appropriately for recycling and recovery of the
refrigerant.

8

After Sales Support

1300 886 649 | [e-mail]