Tanaka TED-210 User Manual

IllustrIllustr

Illustr

IllustrIllustr

Model Number:

TED-210

PORTABLE GAS DRILL

aa

ted Pted P

a

ted P

aa

ted Pted P

arar

ar

arar

ts Mants Man

ts Man

ts Mants Man

P/N 11920
Rev 000
Date 1-15-08

ualual

ual

ualual

Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4th Street SW, Bldg B • Auburn, WA 98001 • Phone: [phone] • Fax: [phone]

www.tanakapowerequipment.com [e-mail]

PARTS INFORMA TION

ENGINE / CYLINDER, PISTON, CRANKSHAFT • FIGURE 1

TED-210

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

1-1 1570650091 CAP,SPARK PLUG ASS'Y 1
1-2 0181166021 PLUG,SPARK 1
1-3 0010650A90 CYLINDER SET 1 Includes gasket
1-4 99461050184 BOLT,HEX,5X18,S 2
1-7 0170650020 GASKET,CYLINDER 1
1-8 04100601210 RING,PISTON 1
1-9 0300650A90 PISTON SET 1 Includes rings & circlips
1-10 03706500200 PIN,PISTON 1
1-11 03901620200 CIRCLIP,PISTON PIN 2
1-12 04606500801 CRANKSHAFT 1
1-13 99962081225 BEARING,NEEDLE,F-810 1
1-27 1532153390 COIL,IGNITION 1
1-28 99416040226 SCREW,WS,4X22 2
1-36 25006500200 TUBE,INSULATOR 1
1-37 1780650080 CORD,STOP 1 R107152~

www.tanakapowerequipment.com

Page 1

[e-mail]

PARTS INFORMA TION

CRANKCASE & FLYWHEEL • FIGURE 2

TED-210

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

2-21 07206502900 CRANKCASE,ASS'Y 1 Includes gasket, seals and bearings
2-22 09006500200 GASKET,CRANKCASE 1
2-23 99966122240 SEAL,OIL,#12227 2
2-24 99961600115 BEARIN G, BALL,6001 C3 2
2-25 33000200210 SHIM,12.2X19X.10 1
2-25 33000200220 SHIM,12.2X19X.15 1
2-25 33000200230 SHIM,12.2X19X.20 1
2-25 33000200240 SHIM,12.2X19X.30 1
2-26 59900601200 CUSHION 1
2-30 99461050304 BOLT,HEX,5X30S 3
2-31 1552152380 ROTOR,MAGNETO 1
2-32 99201080011 WASHER,8 1
2-33 99210080012 WASHER,S,8 1
2-34 99101080011 NUT,8 1
2-35 10012000200 STUD,6X26 2

www.tanakapowerequipment.com

Page 2

[e-mail]

PARTS INFORMA TION

TED-210

FUEL SYSTEM • FIGURE 3

www.tanakapowerequipment.com

Page 3

[e-mail]

PARTS INFORMA TION

TED-210

FUEL SYSTEM • FIGURE 3

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

3-25 40306500200 GASKET,INTAKE 1
3-26 4040650090 SET, CA RB INSULATOR 1
3-27 99416050252 SCREW,5X25WS 2
3-30 40206500200 GASKET,CARBURETOR 1
3-33 99967015000 O-RING,P15 1
3-35 4230650081 BODY,CLEANER 1
3-36 47006500200 COLLAR 2
3-37 52806500200 LEVER,CHOKE 1
3-38 99204080030 WASHER,8 1
3-39 47601700200 BOARD, BLOW OVER CHECK 1
3-40 99210050012 WASHER,S,5 2
3-41 99011050602 SCREW,5X60 2
3-43 4460650021 FILTER,AIR 1
3-44 4520650091 COVER,CLEANER,W/BOLT 1
3-45 3800637C200 BOLT,CLEANER COVER 1
3-46 4550651A90 CARBURETOR 1 Z333901~ Includes gasket
3-50-1 70053005130 PIPE,FUEL 1 ~R107151
3-50 2230650090 PIPE,FUEL,ASS'Y 1 R107152~
3-51 68000731201 CLIP 6.3 1
3-52-1 6750608A900 FILTER,FUEL 1 ~P048170
3-52 6750404280 FILTER,FUEL 1 P048171~
3-53-1 5910650000 TANK,FUEL 1 ~T257999
3-53-2 5910660121 TANK,FUEL 1 ~Z333900
3-53 5910651A22 TANK,FUEL 1 Z333901~
3-55 65900801200 COLLAR 2
3-56 99201050011 WASHER,5 2 ~L206278
3-57 99210050012 WASHER,S,5 2 ~L206278
3-58-1 99011050181 SCREW,5X18 2 ~L206278
3-58 99463050185 BOLT,HEX 5X18PS 2 L206279~
3-63 5950650A90 CAP,TANK 1 ~T257999
3-63 5950656B90 CAP,FU EL BLACK,NON VENT 1 T258000~
3-70 44225143800 PUMP,PRI MING ASS'Y 1 Z 333901~
3-77 7000250408 PIPE,FUEL,2.5x4x80 1 Z333901~
3-78 7000250407 PIPE,FUEL,2.5x4x70 1 Z333901~
3-79 53432710200 GROMMET,FUEL PIPE 1 Z333901~
3-121 5640661190 V ENT, A IR ASS'Y 1 V 123421~
3-122-1 5650660121 PIPE,AIR VENT 1 ~V123420
3-122 5650441020 P IPE,AIR VENT 1 V123421~
3-123 6460661290 VALVE 1 T258000~
3-124 68000206200 CLIP,5.5 1 ~V123420
3-125 5610007020 COVER,AIR VENT 1 ~V123420

www.tanakapowerequipment.com

Page 4

[e-mail]

PARTS INFORMA TION

STARTER, MUFFLER & COVER • FIGURE 4

TED-210

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

4-3 7380650020 PROTECTOR,MUFFLER 1
4-4 73706500200 GASKET,MUFFLER 1
4-5 13306500200 SHIELD,HEAT 1
4-6 7040650091 MUFFLER SET 1
4-7 99201050011 WASHER,5 2
4-8 99051050503 BOLT,HEX,5X50 2
4-11 1120650A80 CASE,FAN 1
4-12 78006097200 SPRING,RECOIL 1
4-13 77406097200 PULLEY,STARTER 1
4-14 80106091200 WASHER,ROPE REEL 1 ~Q020413
4-15 8390201020 SCREW,SET 1
4-16 79806500900 PULLEY,STARTER,ASS'Y 1
4-17 2030604A202 GROMMET 1
4-18 78306097200 ROPE,STARTER 1
4-19 78506410200 HANDLE,STARTER 1
4-20 99415040162 SCREW,PS,4X16 3
4-21 75106500200 GASKET,MUFFLER 1
4-22 7210650290 TA IL PIPE SET 1
4-24 99434040081 SCREW,4X8/S 2
4-47 2770634F901 CLUTCH,ASSY 1
4-61 99072045164 SCREW,TAPPING,4.5X16 1
4-62 99425040128 BOLT,PS,4X12 2
4-65 79006097200 SPRING,STARTER PAWL 1
4-66 7880650020 PAWL,STARTER 1

www.tanakapowerequipment.com

Page 5

[e-mail]

PARTS INFORMA TION

TED-210

CARBURETOR • FIGURE 5

A small retainer (560-07120-

20), has been added to this

model after serial # A099801

to prevent the barrel end of the

throttle wire from coming

detached from the carburetor.

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

5-0 4552518290 CARBURETOR,ASS'Y 1 ~Z333900 Includes gasket
5-1 54825140200 SCREW,THROTTLE SET 2
5-5 53925120200 SWIVEL 1
5-7 48925100200 RING,STOP 1
5-8 48825145800 VALVE,THROTTLE 1 ~S259000
5-10 55025100200 O-RING 1
5-11 5992000W410 JET,MAIN,#41 1 ~S259000
5-11 5992000W35 JET,MAIN,#35 1 ~Z333900
5-11 599200BW34 JET,MAIN,LONG,#34.5 1 Z333901~
5-13 ~ ~ ~ GASKET,PUMP 1
5-14 ~ ~ ~ DIAPHRAGM,PUMP 1
5-15 52325100201 PLATE,PUMP 1 ~S259000
5-16 52225100200 PLATE,CIRCUIT 1 ~S259000
5-17 57825007200 SCREEN,INLET 1
5-18 57525140800 BODY,PUMP 1 ~S259000
5-18 5752518280 BODY,PUMP 1 ~Z333900
5-18 5752514780 BODY,PUMP ASS'Y 1 Z333901~
5-19 ~ ~ ~ GASKET,DIAPHRAGM 1 ~ Contained in Carb Repair Kit
5-19 ~ ~ ~ GASKET,DIAPHRAGM 1 P/N 650-25140-900
5-20 ~ ~ ~ DIAPHRAGM,METERING 1 (not available individually)
5-21 47625004200 COVER,DIAPHRAGM 1
5-22 54825101200 SCREW,SET 4

www.tanakapowerequipment.com

Page 6

[e-mail]

PARTS INFORMA TION

Units af ter S/N C085101

Use P/N 018.32120.00

Gear Set (#14 & #5)

TED-210

GEAR CASE • FIGURE 6

www.tanakapowerequipment.com

Page 7

[e-mail]

PARTS INFORMA TION

TED-210

GEAR CASE • FIGURE 6

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

6-0 0183212000 GEAR SET 1 C085101~
6-1 0023218280 CASE,GEAR A 1
6-2 0063210A80 CASE,GEAR,B 1
6-3 2263210A800 HOUSING,CLUTCH 1
6-4 01232120200 GEAR,#2 1
6-5 0163 2120201 GEAR,#3 1 NLA - Use 018.32120.00 Gear Set
6-5 0163 212021 GEAR,#3 1 After S/N C085101~
6-6 06800300200 KEY,WOODRUFF,3X10X3.7 1
6-7 99962091211 BEARING,NEEDLE,TLA912 2 ~P230680
6-10 99905041201 PIN,KNOCK,4X12 2 ~P230680
6-11 99961600102 BEARING,BALL,#6001Z 1
6-12 99961600115 BEARING,BALL,6001 C3 1
6-13 99350012002 RING,STOP,C-12 EX 1
6-14 01832120200 GEAR,4 1 NLA - Use 018.32120.00 Gear Set
6-14 0183212021 GEAR,4 1 After S/N C085101~
6-15 99961720221 BEARING,BALL,#7202B 1
6-16 04032120201 WASHER,BEARING 1
6-17 99961620202 BEARING,BALL,#6202Z 1
6-18 99351035002 RING,IN,C-35,STOP 1
6-19 06801006200 KEY,WOODRUFF,3X13X5 1
6-20 02232120201 SHAFT,DRIVE 1
6-22 99023060301 BOLT,P,6X30 2
6-23 99101060011 NUT,6 2
6-24 99210060012 WASHER,S,6 4
6-26 99414050181 SCREW,S,5X18 4
6-42 02532120200 WASHER,GEAR 2 ~P230680
6-43 99209350030 WASHER,WAVE,B.B,35 1
6-44 23132175200 COLLAR,GEAR SH AFT B 1
6-45 30032250801 FITTING,GREASE 1

www.tanakapowerequipment.com

Page 8

[e-mail]

PARTS INFORMA TION

HANDLES & THROTTLE • FIGURE 7

TED-210

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

7-28 2583210A82 HANDLE,A 1
7-29 1653313020 HANDLE,GRIP,A 1
7-30 10132120201 LEVER,THROTTLE 1
7-34 99011050251 SCREW,5X25 1
7-35 99101050011 NUT,5 2 ~L158632
7-35 99101050011 NUT,5 1 L158633~
7-36 19833130200 CLAMP,CORD 2
7-37 99023060161 BOLT,6X16 PLUS 1
7-38 99210060012 WASHER,S,6 1
7-39 25932120810 HANDLE 1
7-41 99210100012 WASHER,S,10 1
7-46 1563210A801 SWITCH,STOP 1
7-47 9253317620 DECAL,STOP BUTTON 1
7-48 2581165020 BUTTON,STOP 1
7-49 99011030101 SCREW,3X10 1
7-51 88506502801 WIRE,THROTTLE 1
7-52 16407029000 TUBE,PROTECTION,7X290 1
7-53 1553210A200 HOLDER,CHUCK KEY 1

www.tanakapowerequipment.com

Page 9

[e-mail]

PARTS INFORMA TION

TED-210

CHUCK & KEY • FIGURE 8

4

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

8-0 05932120911 CHUCK & KEY SET 1/2" 1
8-1 06032120911 CHUCK,1/2" 1
8-2 06132120811 CHUCK KEY 1/2" 1
8-3 8292000080 SPANNER,COMBI,13X19 1
8-4 27218 KEYLESS CHUCK 1/2" 1 OPTIONAL

www.tanakapowerequipment.com

Page 10

[e-mail]

PARTS INFORMA TION

TED-210

DECALS • FIGURE 9

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

9-1 90606502200 DECAL 1
9-2 9083316021 DECAL,CAUTION 1 N204151~
9-3 91106500200 DECAL,SRS 1
9-4 9203246620 DECAL,CAUTION 1
9-5 9293210A200 DECAL,INDUSTRIAL 1 ~Q259772
9-6 95037900200 DECAL,PRO-FORCE A 1 Q259773~
9-10 9200650A20 DECAL,WARNING 1 N204151~
9-10 9200650A20 DECAL,WARNING 1 ~Q259772

www.tanakapowerequipment.com

Page 11

[e-mail]