Page 1
44” FINISH CUT
TRAILMOWER
OWNER’S
MANUAL
1602 CORPORATE DRIVE, WARRENSBURG , MISSOURI 6409 3 PHONE 660-747-8183
FAX 660 -747-8650
MODEL NO.
T844CH
T10544CH
T10544B
T844CH-12V
T1244CH-12V
T8544SP
T12544CH
T10544TSP
T10544BSP
Manufacturing quality lawn care equipment since 1945
Assembly
Operation
Service and Adjustment
Repair Parts
Made I n T he
USA
Rev.01.12.2002
Read and follow all Safety
Precautions and
Instructions before
operating this equipment.
IMPORTANT
swisherinc.com
SERIAL # AFTER
L100313001
ONT44SPH
Page 2
FRONT
LEFT RIGHT
REAR
BALL LOCK PINS
TELESCOPING
Left offset shown
FIGURE TWO
FIGURE ONE
T44 12 VOLT START
FIGURE THREE
T44 RECOIL S TART
Slide plastic tube snug against
toggle switch.
Page 3
FIGURE FOUR
See Detail
DUAL HEIGHT ADJUST MODELS
See Details
See Detail
See Detail
10
1
6
5
4
3
2
9
8
7
11
13
12
17
16
15
14
18
19
18
20
21
22
23
24
25
25
21
26
22
23
27
28
29
30
17
31
ITEM # DESCRIPTION PART #
1 BELT BA66
2 RIGHT BELT COVER A44155R*
3 ACORN NUT/WASHER NB120/NB272
4 REAR BELT COVER 4430TK
5 LEFT BELT COVER A44155L*
6 GRASS CHUTE H41ATK
7 5/16 BOLT/NUT NB143/NB181
8 SPRING/BOLT/NUT H41AS/NB106/NB181
9 HEIGHT ADJUSTER H7N
TUBE H7N1TK
KNOB H7K
ARM ES214
RULER DECAL OD41
5/16 PAL NUT NB276
10 THIN WA SHER TR150W
11 LEFT AXLE H6L44*
RIGHT AXLE H6R44*
12 5/16 CARRIAGE BOLT NB110
13 COTTER PIN NB126
ITEM # DESCRIPTION PART #
14 TIRE/WHEEL F44157
15 HEIGHT ADJUST BOLT H4
16 ADJUST NUT NB213Z
17 5/16 NUT NB181
18 ANTI-SCALP ROLLER AS001
19 DECK W ELDMENT 4496*
20 3/8 BOLT NB575
21 3/8 NUT NB182
22 3/8 BOLT NB221
23 HITCH PIN H11
24 STRAIGHT HITCH 4473*
25 BALL LOCK PIN NB520
26 FAN HITCH 4472*
27 "L" HITCH H1
28 PLUG H1P
29 SWIVEL HITCH H10
BOLT/NUT NB145Z/NB561
30 FRONT HITCH 4470*
31 5/16 BOLT NB138
* = USE PAINT CODE:
C=RED,G=GREEN;S=SLIVER
EX: A44155RC; 4473G
Page 4
FIGURE FIVE
FIGURE S IX
ENGINE SET-UP
BLADE SET-UP32
34
33
34
35
36
33
40
39
38
37
43
42
41
47
46
44
45
50
49
48
53
52
47
43
55
54
51
ITEM # DESCRIPTION PART #
32 ENGINE NOT AVAILABLE
33 5/16 BOLT NB253
34 5/16 NUT NB170
35 TOGGLE BRACKET 4483TK
36 SAFETY TETHER 6736
37 TOGGLE SWITCH 685SP
38 UPPER ENG. SPACER BB105S
39 1/4 X 1 KEY STOCK 9031
40 ENG. PULLEY BB105
41 LOWER ENG. SPACER BB105SL
42 BELLEVILLE WASHER 699
43 3/8 BOLT NB238N
OIL DRAIN VALVE & CAP AS 122/AS123
MODULE & SCREW MOD1/NB137
ITEM # DESCRIPTION PART #
44 3/4 NUT NB175
45 UPPER BE LLEVILLE AS155
46 BLADE PULLEY B4104
47 THIN WASHER NB179
48 BLADE DRIVER 9085
BEARING B98
5" SHAFT 9077
BEARING HOUSING B99TK
49 1/4 B OLT NB250
50 1/4 NUT NB180
51 22" BLADE 9005
52 BLADE MOUNT PLATE 9008
53 3/8 NUT NB216
54 3/8 B OLT NB238
55 LOWER BELLEVILLE NB607
Page 5
FIGURE S EVEN
56
61
59
57
58
65
64 63
60
67
66
62
68
69
69
70
71
72
75
76
74
67
73
78
77
FIGURE EIGHT
T-HANDLE OPTION ST ANDARD ENGAGE
ITEM # DESCRIPTION PART #
56 T-HANDLE LEVER 4463TK
57 COTTER PIN NB597
58 1/4 BOLT NB180
59 W ASHER NB274
60 ENGAGE LINK 4461TK
61 CABLE CLEVIS 9023MOD
62 5/16 NUT NB181
63 CLEVIS PIN NB518
64 1/4 BOLT NB560
65 5/16 TORX BOLT NB591
66 CONSOLE WELDMENT 4464TK
67 KEY SW ITCH (RECOIL) KSM
KEY SWITCH (12 VOLT) KS12
68 W ING BOLT NB523
T-HANDLE ACCESSORY KIT 4498
BLADE ENGAGE DECAL OD10
ON/OFF DECAL OD99
12 VOLT ON/OFF DECAL OD28
ITEM # DESCRIPTION PART #
69 COTTER PIN NB126
70 ENGAGE LINKAGE 4534*
71 1/2 BOLT NB132
72 ENGAGE LEVER 4537*
73 HANDLE KNOB B19BLACK
74 1/4 NUT NB524
75 1/4 BOLT NB250
76 1/2 NUT NB213Z
77 ENGAGE LEVER BRACKET 4535*
78 1/2 NUT NB121
ON/OFF DECAL OD10
* = USE PAINT CODE:
C=RED,G=GREEN;S=SLIVER
EX: A44155RC; 4473G
Page 6
FIGURE TEN
FIGURE NINE
80
85
84
83
82
81
87
88
86
91
9089
79
ITEM # DESCRIPTION PART #
79 3/8 NUT NB212
80 3/8 BOLT NB231
81 WASHER NB271
82 BRAKE PAD BP370
83 BRAKE PAD CLIP BP370S
84 BRAKE SPRING BT297
85 3/8 NUT NB207
86 3/8 NUT NB280
87 BRAKE CHAIN (9 LINKS) AS080
88 SAFETY SWITCH SSSC
89 BRAKE PIVOT 4097TK
90 #6 SCREW NB259
91 WASHER NB196
BRAKE ASSEMBLY
BELT CONFIGURATION
WIRING HARNESSES
STANDARD ENGAGE WH44CHNCB
T-HANDLE OPT. W/ B&S ENGINE WH44CHB
T-HANDLE OPT. W/ TEC. ENGINE WH44CHT
T-HANDLE OPT. W/ 12 VOLT START WH44B12V
BLADE ENGAGE CABLE 9074
12 VOLT MODELS
BATTERY (12N12A) RECOMMENDED SOLD SEPARATELY
SOLENOID 9043
BATTERY CABLE - POSITIVE BCSR
BATTERY CABLE - NEGATIVE BCS
EXTRAS
VELCRO STRAPS 7033
SWISHER DECAL OD99116
44" DECAL OD99119
PARTS NOT S HOWN
Page 7
FIGURE ELEVEN
ENGAGE / T ENSION ASSEMBLY
92
93
94
95
96
98
99
97
100
101
102
103
104
105
106
107
108
109
110
113
111
112
114
ITEM # DESCRIPTION PART #
92 3/8 LOCK NUT NB280
93 WAS HER NB272
94 IDLER PULLEY B527
95 1/2 SHOULDER BOLT NB220
96 IDLER ARM OFFSET 687RTK
97 3/8 JAM NUT NB174
98 WAS HER NB271
99 3/8 NYLOK NUT NB182
100 WIRE LINK BRS6H
101 3/8 BOLT NB231
102 CLUTCH ROD SPRING 682S
103 CLUTCH ROD SPRING 682S
104 PULL ROD 3123TK
105 5/16 NUT NB210
106 BRAKE LINKAGE BL370
107 1/2 BOLT NB220
108 ENGAGEMENT ARM 4467TK
109 WASHER NB271
110 3/8 NUT NB182
111 5/16 NUT NB210
112 1/4 NUT NB102
113 CLUTCH CABLE 9023MOD
114 1/4-20 NYLOCK NUT NB180
Page 8
ITEM # DESCRIPTION PART #
115 CRANK KNOB H7K
116 CRANK HANDLE ES214
117 CRANK ROD 4006
118 SINGLE POINT FRAME 4001TK
119 BUSHING 21008
120 PIVOT BLOCK 4007TK
121 GRASS CHUTE MOUNT 6030TK
122 CHUTE SPRING 9100
123 GRASS CHUTE 4019TK
124 TIRE/W HEEL/BEARING F44157
125 ANTI-SCALP ROLLER 1/2" AS003
126 LEFT ROLLER BRACKET 4015TK
127 ANTI-SCALP ROLLER 3/8" AS001
128 FRONT ROLLER BRACKET 4018TK
129 UNIVERSAL MOUNT DECK 4017*
CENTER HITCH DECK 4025*
130 RIGHT ROLLER BRACKET 4016TK
* ADD PAINT CODE: C=RED;G=GREEN;S=SILVER EX: 4017C;4025G
FIGURE TWELVE
SINGLE POINT HEIGHT ADJUST MODEL
Page 9
OWNER’S
MANUAL
HOW TO ORDER
REPAIR PARTS :
44” FINISH CUT
TRAILMOWER
Each TrailMower has its own serial number. Each engine has
its own serial number. The serial number for the TrailMower
will be found on the right hand side of the drive belt housing.
The serial number for the engine will be found on the top of
the blower fan housing.
All T railMower parts listed herein may be ordered directly
from Swisher Mower & Machine Co. Inc., your nearest
Swisher dealer, or from our website. www.swisherinc.com
All engine parts may be ordered from the nearest dealer of the
engine supplied with your mower.
WHEN ORDERING PARTS, PLEASE HAVE T HE
FOLLOWING INORMATION AVAILABLE:
* PRODUCT – T-44 FINISH CUT TRAILMOWER
* SERIAL NUMBER - _______________
* MODEL NUMBER - _______________
* ENGINE MODEL NUMBER - _______________
T YPE - _______________
* PART NUMBER
* PART DESCRIPTION
www.swisherinc.com
TELEPHONE - 1-800-222-8183
FAX - 1-660-747-8650
SWISHER MOWER & MACHINE CO. INC.
1602 CORPORATE DRIVE
WARRENSBURG, M O 64093
SWISHER MOWER & MACHINE CO. INC.
MODEL NO.
T844CH
T10544CH
T10544B
T844CH-12V
T1244CH-12V
T8544SP
T12544CH
T10544TSP
T10544BSP
Loading...