EX 27D
ISSUE EMD-EU1622
2ZZ9990063
E X 1 3 D / E X 1 7 D
E X 2 1 D / E X 2 7 D
MODEL
US
NOTICE
FEDERAL EMISSION COMPONENT DEFECT W ARRANTY and CALIFORNIA
EMISSION CONTROL WARRANTY are applicable to only those engines
complied with EPA (Environmental Protection Agency) and CARB (California
Air Resources Board) emission regulations.
The engine exhaust from this product contains
chemicals known to the State of California to
cause cancer, birth defects or other reproductive
harm.
WARNING
AIR INDEX
An Air Index Information hang tag was supplied to this engine in accordance
with the emission regulations of the California Air Resources Board.
The bar graph on the hang tag shows the emissions performance of this engine.
The bar graph can be used to compare the emissions performance with other
available engines. The lower the Air Index, the less pollution.
The following durability description is to provide you with information relating to
the emission durability period of the engine.
Descriptive Term Applicable to Emissions Durability Period
Moderate - 125 hours (greater than 65 cc)
Intermediate - 250 hours (greater than 65 cc)
Extended - 500 hours (greater than 65 cc)
Notice : The Air Index Information hang tag must remain on the engine or on
the equipment until it is sold to the ultimate purchaser. Remove the hang tag
before operating the engine.
US
FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY
EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE
This emission warranty is applicable in all States, except the State of California.
Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein “ROBIN AMERICA”) warrant(s) to the initial retail purchaser and
each subsequent owner, that this Nonroad engine (herein “engine”) has been designed, built, and equipped to conform at the time of initial
sale to all applicable regulations of the U.S. Environmental Protection Agency (EPA), and that the engine is free of defects in materials and
workmanship which would cause this engine to fail to conform with EPA regulations during its warranty period.
For the components listed under PARTS COVERED, the service dealer authorized by ROBIN AMERICA will, at no cost to you, make the
necessary diagnosis, repair, or replacement necessary to ensure that the engine complies with applicable U.S. EPA regulations.
EMISSISON COMPONENT DEFECT WARRANTY PERIOD
The warranty period for this engine begins on the date of sale to the
initial purchaser and continues for a period of 2 years.
PARTS COVERED
Listed below are the parts covered by the Emission Components
Defect Warranty. Some of the parts listed below may require
scheduled maintenance and are warranted up to the first scheduled
replacement point for that part.
(1) Fuel Metering System
(i) Carburetor and internal parts (and/or pressure regulator or
fuel injection system).
(ii) Air/fuel ratio feedback and control system, if applicable.
(iii) Cold start enrichment system, if applicable.
(iv) Regulator assy (gaseous fuel, if applicable)
(2) Air Induction System
(i) Intake manifold, if applicable
(ii) Air filter.
(3) Ignition System
(i) Spark plugs.
(ii) Magneto or electronic ignition system.
(iii) Spark advance/retard system, if applicable.
(4) Exhaust manifold, if applicable
(5) Miscellaneous Items Used in Above Systems
(i) Electronic controls, if applicable
(ii) Hoses, belts, connectors, and assemblies.
(iii) Filter lock assy (gaseous fuel, if applicable)
OBTAINING WARRANTY SERVICE
To obtain warranty service, take your engine to the nearest authorized
Robin America service dealer . Bring your sales receipts indicating
date of purchase for this engine. The service dealer authorized by
ROBIN AMERICA will perform the necessary repairs or adjustments
within a reasonable amount of time and furnish you with a copy of the
repair order. All parts and accessories replaced under this warranty
become the property of ROBIN AMERICA.
WHAT IS NOT COVERED
* Conditions resulting from tampering, misuse, improper adjustment
(unless they were made by the service dealer authorized by ROBIN
AMERICA during a warranty repair), alteration, accident, failure to
use the recommended fuel and oil, or not performing required
maintenance services.
* The replacement parts used for required maintenance services.
* Consequential damages such as loss of time, inconvenience, loss
of use of the engine or equipment, etc.
* Diagnosis and inspection charges that do not result in warranty-
eligible service being performed.
* Any non-authorized replacement part, or malfunction of authorized
parts due to use of non-authorized parts.
OWNER’S WARRANTY RESPONSIBILITIES
As the engine owner, you are responsible for the performance of the
required maintenance listed in your owner’s manual. ROBIN
AMERICA recommends that you retain all receipts covering
maintenance on your engine, but ROBIN AMERICA cannot deny
warranty solely for the lack of receipts or for your failure to ensure
the performance of all scheduled maintenance.
As the engine owner, you should however be aware that ROBIN
AMERICA may deny warranty coverage if your engine or a part has
failed due to abuse, neglect, improper maintenance or unapproved
modifications.
You are responsible for presenting your engine to the nearest service
dealer authorized by ROBIN AMERICA when a problem exists.
If you have any questions regarding your warranty rights and
responsibilities, you should contact the Robin America customer
service department at 1-630-350-8200 for the information.
THINGS YOU SHOULD KNOW ABOUT THE EMISSION
CONTROL SYSTEM WARRANTY MAINTENANCE AND
REPAIRS
You are responsible for the proper maintenance of the engine.
You should keep all receipts and maintenance records covering the
performance of regular maintenance in the event questions arise.
These receipts and maintenance records should be transferred to
each subsequent owner of the engine. ROBIN AMERICA reserves
the right to deny warranty coverage if the engine has not been properly
maintained. Warranty claims will not be denied, however, solely
because of the lack of required maintenance or failure to keep
maintenance records.
MAINTENANCE, REPLACEMENT OR REPAIR OF EMISSION
CONTROL DEVICES AND SYSTEMS MA Y BE PERFORMED BY ANY
REPAIR ESTABLISHMENT OR INDIVIDUAL;
HOWEVER, WARRANTY REPAIRS MUST BE PERFORMED BY A
SERVICE DEALER AUTHORIZED BY ROBIN AMERICA. THE USE
OF PARTS THAT ARE NOT EQUIVALENT IN PERFORMANCE AND
DURABILITY TO AUTHORIZED PARTS MAY IMPAIR THE
EFFECTIVENESS OF THE EMISSION CONTROL SYSTEM AND MA Y
HAVE A BEARING ON THE OUTCOME OF A WARRANTY CLAIM.
If other than the parts authorized by ROBIN AMERICA are used for
maintenance replacements or for the repair of components affecting
emission control, you should assure yourself that such parts are
warranted by their manufacturer to be equivalent to the parts
authorized by ROBIN AMERICA in their performance and durability.
HOW TO MAKE A CLAIM
All repair qualifying under this limited warranty must be performed by a
service dealer authorized by ROBIN AMERICA. In the event that any
emission-related part is found to be defective during the warranty period,
you shall notify Robin America customer service department at 1-630-
350-8200 and you will be advised of the appropriate warranty service
dealer or service providers where the warranty repair can be performed.
US
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Fuji Heavy Industries Ltd. (herein “FUJI”) are pleased to explain the emission control system warranty
on your 2002 and later Small Off-Road engine (herein "engine"). In California, the engine must be designed, built and equipped to meet the
State's stringent anti-smog standards. FUJI must warrant the emission control system on your engine for the periods of time described below,
provided there has been no abuse, neglect or improper maintenance of your engine. Your emission control system may include parts such as
the carburetor or fuel-injection system, and the ignition system. Also included may be hoses, belts, connectors and other emission-related
assemblies. Where a warrantable condition exists, FUJI will repair your engine at no cost to you including diagnosis, parts and labor.
MANUFACTURER'S WARRANTY COVERAGE:
The 2002 and later engines are warranted for two (2) years. If any emission related part on your engine is defective, the part will be repaired
or replaced by FUJI.
OWNER'S WARRANTY RESPONSIBILITIES:
-As the engine owner, you are responsible for the performance of the required maintenance listed in your Owner's Manual. FUJI
recommends that you retain all receipts covering maintenance on your engine, but FUJI cannot deny warranty solely for the lack of
receipts or for your failure to ensure the performance of all scheduled maintenance.
-As the engine owner, you should ,however, be aware that FUJI may deny you warranty coverage if your engine or a part has failed due
to abuse, neglect, improper maintenance or unapproved modifications.
-You are responsible for presenting your engine to a service dealer or warranty station authorized by ROBIN AMERICA Inc. 940 Lively
Blvd., Wood Dale, IL 60191 (herein ROBIN AMERICA) as soon as a problem exists. The warranty repairs should be completed in a
reasonable amount of time, not to exceed 30 days.
If you have any questions regarding your warranty rights and responsibilities, you should contact the Robin America Inc. Customer Service
Department at 1-630-350-8200.
LIMITED WARRANTY
on Emission Control Systems
-
California Only
-
FUJI warrants to the owner of the 2002 and later engine that the engine (1) has been designed, built and equipped so as to conform at the time
of manufacture with the applicable regulations of the California Air Resources Board, and (2) is free from defects in materials and workmanship
that could cause it to fail to conform with those regulations as may be applicable in the terms and conditions stated below.
A. COMMENCEMENT DATE
The warranty period begins on the date the engine is delivered to a
first retail purchaser.
B. LENGTH OF COVERAGE
FUJI warrants to a first retail purchaser and each subsequent purchaser
that the engine is free from defects in materials and workmanship that
cause the failure of a warranted emission-related part for a period of
two (2) years after the date of delivery to the first retail purchaser.
C. WHAT IS COVERED:
1. REPAIR OR REPLACEMENT PARTS
Repairs and replacement of any warranted part will be performed
at no charge to you by an authorized service dealer or a warranty
station. You may contact the Robin America Inc. Customer Service
Department at 1-630-350-8200 to obtain the name of the nearest
appropriate location where your warranty repairs are performed.
2. WARRANTY PERIOD
This warranty continues for a period of two (2) years and applies
only to the repair, replacement or adjustment of the component
parts that are not scheduled for replacement as required
maintenance. Further, component parts which are scheduled only
for regular inspection to the effect of "repair or replace as
necessary" are warranted for the warranty period. Any warranted
part which is scheduled for replacement as required maintenance
is warranted for the period of time up to the first scheduled
replacement point for that part.
3. DIAGNOSIS
You will not be charged for diagnostic labor that leads to the
determination that a warranted part is defective, if the diagnostic
work is performed at an authorized service dealer or warranty station.
4. DAMAGES
If a warranted part failed causing damage to other engine
components, consult an warranty station.
D. WHAT IS NOT COVERED
1. This limited warranty does not cover any part which malfunctions,
fails or is damaged due to failure to follow the maintenance and
operating instructions set forth in the 2002 and later Owner's
Manual including:
(1) improper or inadequate maintenance of any warranted parts
(2) improper installation, adjustment or repair of the engine or of
any warranted part unless performed by an authorized service
dealer
(3) failure to follow recommendations on fuel use contained in
the 2002 and later Owner's Manual
(4) repairs performed outside of the authorized warranty service
dealers
(5) use of parts which are not authorized by FUJI.
2. Add-on or modified parts
This warranty does not cover any part that malfunctions, fails or is
damaged due to alterations by changing, adding to or removing
parts from the engine.
3. Expenses incurred by processing warranty claims
FUJI, any authorized service dealer and warranty station shall not
be liable for any loss of use of the engine, for any alternative usage,
for any damage to goods, loss of time or inconvenience.
E. HOW TO FILE A CLAIM
All repairs qualifying under this Limited Warranty must be performed
by a dealer who sold you the engine or warranty station authorized
by ROBIN AMERICA. In the event that any emission-related part is
found to be defective during the warranty period, you must notify the
Robin America Inc. Customer Service Department at 1-630-350-8200
and you will be advised of the appropriate warranty service facilities
where the warranty repair is to be performed.
F. WHERE TO OBTAIN WARRANTY SERVICE
It is recommended that warranty service be performed by the authorized
dealer who sold you the engine, although warranty service will be
performed by any authorized service dealers or warranty stations
anywhere in the United States.
US
PROCEDURE INTERVAL
1) Clean engine and check bolts & nuts : Every 8 hours (daily)
2) Check and refill engine oil : Every 8 hours (refill daily up to upper limit)
3) Change engine oil : Initial 20 hours and every 100 hours afterward
4) Clean spark plug : Every 50 hours (weekly)
5) Clean air cleaner : Every 50 hours (weekly)
6) Replace air cleaner element : Every 200 hours (monthly)
7) Clean fuel filter : Every 200 hours (monthly)
8) Clean and adjust spark plug and electrodes : Every 200 hours (monthly)
9) Replace spark plug : Every 500 hours
10) Remove carbon from cylinder head : Every 500 hours
11) Check and adjust valve clearance : Every 500 hours
12) Clean and adjust carburetor : Every 500 hours
13) Replace fuel lines : Every 1000 hours (yearly)
14) Overhaul engine : Every 1000 hours
Note: More frequent maintenance may be necessary under dusty, dirty or severe conditions.
When warranty repair is needed, the engine must be brought to an
authorized service dealer or warranty station’s place of business during
normal business hours. In all cases, a reasonable time, not to exceed
30 days, must be allowed for the warranty repair to be completed after
the engine is received by the authorized service dealer or warranty station.
G. MAINTENANCE, REPLACEMENT AND
REPAIR OF EMISSION-RELATED PARTS
Only warranted engine replacement parts approved by FUJI should
be used in the performance of any warranty maintenance or repairs
on emission-related parts. If other than authorized parts are used for
maintenance, replacement or repair of components affecting emission
control, you should assure yourself that such parts are warranted by
their manufacturer to be equivalent to authorized parts in performance
and durability . FUJI ,however , assumes no liability under this warranty
with respect to parts other than authorized parts. The use of non-
authorized replacement parts does not invalidate the warranty on
other components unless the non-authorized parts cause damage to
warranted parts.
I. MAINTENANCE STATEMENTS
It is your responsibility to have all scheduled inspection and maintenance services performed at the times recommended in the 2002 and later
Owner's Manual and to retain proof that inspection and maintenance services are performed at the times when recommended. FUJI will not
deny a warranty claim solely because you have no record of maintenance; however, FUJI may deny a warranty claim if your failure to perform
required maintenance resulted in the failure of warranted part. The proof which you maintain should be given to each subsequent owner of the
engine. You are responsible for performing the scheduled maintenance described below based on the procedures specified in the 2002 and
later Owner's Manual. The scheduled maintenance below is based on a normal engine operating schedule.
H. PARTS COVERED UNDER THE CALIFORNIA EMISSIONS
WARRANTY
(1) Fuel Metering System
(i) Carburetor and internal parts (and/or pressure regulator or
fuel injection system).
(ii) Air/fuel ratio feedback and control system, if applicable.
(iii) Cold start enrichment system, if applicable.
(iv) Regulator assy (gaseous fuel, if applicable)
(2) Air Induction System
(i) Intake manifold, if applicable
(ii) Air filter.
(3) Ignition System
(i) Spark plugs.
(ii) Magneto or electronic ignition system.
(iii) Spark advance/retard system, if applicable.
(4) Exhaust manifold, if applicable
(5) Miscellaneous Items Used in Above Systems
(i) Electronic controls, if applicable
(ii) Hoses, belts, connectors, and assemblies.
(iii) Filter lock assy (gaseous fuel, if applicable)
Loading...