Star Manufacturing 6015CB Installation Manual

Star
Manufacturing
International Inc.

10 Sunnen Drive
St. Louis, MO 63143

Phone: [phone]
FAX: [phone]

2M-Y7198 Rev. F 6/28/00

Installation

and
Operating
Instructions

STAR-MAX

GAS CHARBROILER

MODELS

6015CB, 6024CB, 6036CB,

6115RCB, 6124RCB, and 6136RCB

Model 6024CB

1

GENERAL INSTALLATION DATA

CAUTION

This equipment is designed and sold for
commercial use only by personnel trained and
experienced in its operation and is not sold for
consumer use in and around the home nor for
use directly by the general public in food service
locations. For equipment to be used by the
general public, please contact the factory.

The Star-Max series gas charbroiler is equipped
for the type of gas indicated on the nameplate
mounted on the front panel. All units are shipped
from the factory for use with natural gas. The unit
can easily be converted for use with propane gas:
see propane gas.

-IMPORTANT-

INSTALLATION: INSTALL IN NON­COMBUSTIBLE LOCATIONS ONLY! Clearance
from non-combustible construction must be 6"
from back and sides.

The installation of the Appliance must
conform to the NATIONAL FUEL GAS CODE
"ANSI Z223.1 - LATEST EDITION" AND ALL
LOCAL GAS COMPANY RULES AND
REGULATIONS.

IN CANADA INSTALLATION SHALL BE IN
ACCORDANCE WITH THE CURRENT CAN/
CGA-B149.1 NATURAL GAS INSTALLATION
CODE OR CAN/CGA-B149.2 PROPANE
INSTALLATION CODE AND LOCAL
CODES WHERE APPLICABLE.

WARNING: Improper installation,
adjustment, alteration, service or maintenance
can cause property damage, injury or death.
Read the installation, operating and
maintenance instructions thoroughly before
installing or servicing the equipment.

FOR YOUR SAFETY

DO NOT STORE OR USE GASOLINE OR

OTHER FLAMMABLE VAPORS AND LIQUIDS

IN THE VICINITY OF THIS OR ANY OTHER

APPLIANCE. KEEP THE APPLIANCE AREA

CLEAR AND FREE FROM COMBUSTIBLES.

This appliance, its pressure regulator and its
individual shutoff valve must be disconnected
from the gas supply piping system during any
pressure testing of that system at test pressures
in excess of 1/2 PSIG. This appliance and its
pressure regulator must be isolated from the gas
supply piping system by closing its individual
manual shutoff valve during any pressure testing
of the gas supply piping system at test pressures
equal to or less than 1/2 PSIG. For your
protection, we recommend a qualified installing
agency install this appliance. They should be
familiar with gas installations and your local gas
requirements. In any case, your gas company
should be called to approve the final installation.
In addition, there should be posted, in a
prominent location, detailed instructions to be
followed in the event the operator smells gas.
Obtain the instructions from the local gas
supplier.

LEVELING UNIT

This charbroiler is supplied with 4 feet which
must be screwed into the body. Level unit by
adjusting the (4) feet which have an adjustment of
1-3/4" for accurate and perfect line-up with other
units. CAUTION: DO NOT INSTALL
WITHOUT ATTACHING FEET - DO NOT
REMOVE FEET.

GAS INPUT TO CHARBROILER:
Models 6015CB and 6115RCB 25,000 BTU/HR
Models 6024CB and 6124RCB 50,000 BTU/HR

25,000 BTU/HR/BURNER

Models 6036CB and 6136RCB 75,000 BTU/HR

25,000 BTU/HR/BURNER

2