Star Manufacturing 11C-B, 11C Parts List

Star
Manufacturing
International Inc.

10 Sunnen Dr.
St. Louis, MO 63143

Installation

and
Operating
Instructions

Phone: [phone]
FAX: [phone]

SOUP KETTLESOUP KETTLE

SOUP KETTLE

SOUP KETTLESOUP KETTLE

COOKERS and HOLDERS COOKERS and HOLDERS

COOKERS and HOLDERS

COOKERS and HOLDERS COOKERS and HOLDERS

MODELSMODELS

MODELS

MODELSMODELS

7C, 7H, 11C, 11H7C, 7H, 11C, 11H

7C, 7H, 11C, 11H

7C, 7H, 11C, 11H7C, 7H, 11C, 11H

2M-Y5707 Rev. C 8/15/95

MODEL 11C

1

CAUTION

This equipment is designed and sold for
commercial use only by personnel trained and
experienced in its operation and is not sold for
consumer use in and around the home nor for
use directly by the general public in food service
locations.

INSTALLATION

These food warmers are equipped for the voltage
and wattage indicated on the nameplate mounted
to the back panel and are designed for use on
alternating current (AC) only. Serious damage
may result if appliance is used with incorrect
voltage.

5. Set the dial to the number required to
maintain the temperature desired. Because
the consistency of different food varies, and
because liquids and solids absorb heat at
different rates, it is impractical to specify the
exact dial setting. Therefore, we have
indicated the setting with a series of numbers.
A little experience will give you the proper
setting for various foods you are serving.

6. The soup cookers are equipped with a
warning light to prevent overheating or
scorching of certain soups. When the light is
on, all electric current to the heating elements
will be off. Turn the heat setting down to a
lower setting and wait 5-10 minutes for the
light to go out. It would also be advisable to
check the water level in the water bowl.

7. Turn the control to the "OFF" position when
the unit is not in use.

CAUTION

DO NOT CONNECT TO DIRECT
CURRENT (DC).

GENERAL OPERATING INSTRUCTIONS

1. Before using the soup kettle, clean the water
and soup bowls and its cover if furnished with
the kettle.

2. Do not operate the kettle dry. Place water in
the water bowl (14 ounces of water for 11 qt.
Model, 26 ounces for the 7 qt. Model).

3. The temperature control on these kettles is a
combination On/Off switch with an infinite
control. The "OFF" position will turn off the
electric current to the heating element.

4. If PRE-HEATING IS DESIRED SET THE
CONTROL AT "HI" for approximately 20-30
minutes. Prolonged "HI" setting may result in
overcooking or scorching of certain food.

CAUTION

DO NOT OVER-HEAT THE UNIT.

CLEANING INSTRUCTIONS

Change water in water bowl daily and remove
any food collection that may have entered the
water bath. Clean soup bowl, cover and the
kettle at a sink with soap and water.

The exterior surfaces of the warmer can be kept
clean and attractive by wiping or washing
regularly with a soft cloth and mild soap and
water. Any discoloration on the bowls and cover
can be removed with a non-abrasive cleaner. Do

not use an abrasive cleaner as the attractive
coatings will be affected adversely.

MAINTENANCE AND REPAIRS

Contact the factory, a service representative or a
local service company for service or required
maintenance.

RETAIN THIS MANUAL FOR FUTURE REFERENCE

2

PART NO. 2M-Y5707 REV. C 8/15/95

Visit our Website at: www.star-mfg.com Email: [e-mail] For Fax-On-Demand Literature: [phone]

THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL

This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in
which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the
transportation company who delivered the item to you and initiate your claim with same. If this procedure is not followed, it may affect the warranty
status of the unit.

LIMITED EQUIPMENT WARRANTY

All workmanship and material in Star products have a one (1) year limited warranty on parts & labor in the United States and Canada. Such warranty is
limited to the original purchaser only and shall be effective from the date the equipment is placed in service. Star's obligation under this warranty is limited
to the repair of defects without charge, by the factory authorized service agency or one of its sub-agencies. Models that are considered portable (see below)
should be taken to the closest Star service agency, transportation prepaid.

> Star will not assume any responsibility for loss of revenue.
> On all shipments outside the United States and Canada, see International Warranty.
* The warranty period for the JetStar series six (6) ounce popcorn machines is two (2) years.
* The warranty period for the Chrome-Max Griddles is five (5) years on the griddle surface. See detailed warranty provided with unit.
* The warranty period for Teflon/Dura-Tec coatings is one year under normal use and reasonable care. This warranty does not apply if damage occurs to

Teflon/Dura-Tec coatings from improper cleaning, maintenance, use of metallic utensils, or abrasive cleaners. This warranty does not apply to the
“non-stick” properties of such materials.

> This warranty does not apply to "Special Products" but to regular catalog items only. Star's warranty on "Special Products" is six (6) months on parts

and ninety (90) days on labor.

> This warranty does not apply to any item that is disassembled or tampered with for any purpose other than repair by a Star Authorized Service Center or

the Service Center's sub-agency.

> This warranty does not apply if damage occurs from improper installation, misuse, wrong voltage, wrong gas or operated contrary to the Installation and

Operating instructions.

> This warranty is not valid on Conveyor Ovens unless a "start-up/check-out" has been performed by a Factory Authorized Technician.

PARTS WARRANTY

Parts that are sold to repair out of warranty equipment are warranted for ninety (90) days. The part only is warranted. Labor to replace the part is
chargeable to the customer.

SERVICES NOT COVERED BY WARRANTY

1. Travel time and mileage rendered beyond the 50 mile radius limit

2. Mileage and travel time on portable equipment (see below)

3. Labor to replace such items that can be replaced easily during a daily cleaning
routine, ie; removable kettles on fryers, knobs, grease drawers on griddles, etc.

4. Installation of equipment

5. Damages due to improper installation

6. Damages from abuse or misuse

7. Operated contrary to the Operating and Installation Instructions

8. Cleaning of equipment

9. Seasoning of griddle plates

10. Voltage conversions

11. Gas conversions

12. Pilot light adjustment

13. Miscellaneous adjustments

14. Thermostat calibration and by-pass adjustment

15. Resetting of circuit breakers or safety controls
16 . Replacement of bulbs

17. Replacement of fuses
18 . Repair of damage created during transit, delivery, &

installation OR created by acts of God

PORTABLE EQUIPMENT

Star will not honor service bills that include travel time and mileage charges for servicing any products considered "Portable" including items listed below.
These products should be taken to the Service Agency for repair:

* The Model 510F Fryer.
* The Model 526TO Toaster Oven.
* The Model J4R, 4 oz. Popcorn Machine.
* The Model CFS Series Food Steamer.
* The Model 526WO Warming Oven.
* The Model 518CM & 526CM Cheese Melter.
* The Model 12MC & 15MC & 18MCP Hot Food Merchandisers.
* The Model 12NCPW & 15NCPW Nacho Chip/Popcorn Warmer.
* All Hot Dog Equipment except Roller Grills & Drawer Bun Warmers.
* All Nacho Cheese Warmers except Model 11WLA Series Nacho Cheese Warmer.
* All Condiment Dispensers except the Model CSD & HPD Series Dispenser.
* All Specialty Food Warmers except Model 130R, 500, 11RW Series, and 11WSA Series.

The foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty.

FOR ASSISTANCE

Should you need any assistance regarding the Operation or Maintenance of any Star equipment; write, phone, fax or email our Service Department.

In all correspondence mention the Model number and the Serial number of your unit, and the voltage or type of gas you are using.

ALL:
* Pop-Up Toasters
* Butter Dispensers
* Pretzel Merchandisers
* Pastry Display Cabinets
* Nacho Chip Merchandisers
* Accessories of any kind
* Sneeze Guards
* Pizza Ovens
* Heat Lamps
* Hot Cups
* Pumps

Part# 2M-4497-2 02/03 RB