Sta-Rite 10DOM05221 Installation Manual
OWNER’S MANUAL
S.T.E.P. Plus D Series
Submersible Pump
©2004, Sta-Rite Industries 253P6310 (Rev. 3/29/06)
293 Wright Street, Delavan, WI 53115
Models: 10DOM05121, 10DOM05221,
20DOM05121, 20DOM05221, 20DOM05221+1,
20DOM05121+1, 30DOM05121, 30DOM05221
IInnssttaallllaattiioonn//OOppeerraattiioonn//PPaarrttss
For further operating, installation, or maintenance assistance:
CCaallll 11--226622--772288--55555511
2
READ AND FOLLOW
SAFETY INSTRUCTIONS!
This is the saaffetyy allert ssymbbol.
When you see this symbol
on your pump or in this manual, look for one of the following signal words and be alert to the potential for personal
injury.
warns about hazards that
wwill
cause serious per-
sonal injury, death or major property damage if ignored.
warns about hazards that
ccan
cause serious per-
sonal injury, death or major property damage if ignored.
warns about hazards that
wwilll
or
ccan
cause
minor personal injury or property damage if ignored.
The label
NNOOTICCE
indicates special instructions which are
important but not related to hazards.
Caarreefuullyy rreeaadd andd ffolloww aalll saafetyy instructions inn this maanuuaal
aanndd onn ppump.
Haazaarddouus presssuure. Unddeer certaainn cconnditionns,
subbmeersiblee ppumpss ccan ddeevveelop exxtreemeelyy hhighh presssuure.
Instaall a preesssuree rreelieff vvaalvve caapable off ppasssinng entiree ppump
ffloww aat 75 PSSI.
Do not aalllooww pump, pipinng, or anyy other ssysteem comppo-
nent ccontainning wwateer to frreeezee. Freeezzing maayy ddamaagee
syysteem, leeadding to innjury or floodding. AAlllowwinng pump or syystem
comppooneenntss too ffreeeezee wwill vvooidd wwaarrraanntyy.
Hazardous vvooltaagee. Can shhoocck, burn or ccausse
deaath. Too aavvoid ddangeroous or ffataal eeleecctric sshhock haazaardd, usee
pump onnllyy in an eeffluent ssysstem. DO NNOT instaall ppump in an
open bboddyy of wwater ( a llake, sswwimming pooll, etcc.).
Install, ground and wire pump according to local and
Canadian Electrical Code or National Electrical Code
requirements that apply
.
Disconnect electrical power supply before installing or
servicing pump.
Make sure pump nameplate voltage and frequency match
line voltage and frequency of power supply
.
1. Install pump according to all plumbing, pump and well
code requirements.
2. Install an all leg disconnect switch in the power supply
near the pump.
3. Two-wire motors are equipped with automatic thermal
overload protection which will open the circuit and stop
the motor when a thermal overload (excessive heating)
exists. When motor cools, overload will rest and motor will
restart automatically.
This can cause the pump to start
unexpectedly and without warning.
GENERAL
Inspect pump for delivery damage. Report any damage to shipping carrier or to Sta-Rite immediately.
Have any installation, repair, or service work done by your
Sta-Rite dealer.
Never run pump dry.
LLIIMMIITTEEDD WWAARRRRAANNTTYY
Sta-Rite warrants to the original consumer of the products listed below, that they will be free from defects in material and workmanship for the Warranty Period from the date of original installation or manufacture as noted.
Prodduct WWarrranty Peeriodd
Submersible Pump Products 1 year
Our warranty will not apply to any product that has been subject to negligence, misapplication, improper installation or maintenance. In the event a three phase submersible motor is operated with single phase power through a phase converter, or if threeleg ambient compensated, extra-quick trip overload relays of recommended size are not used, our warranty is void.
Buyer’s only remedy and Sta-Rite’s only duty is to repair or replace defective products (at Sta-Rite’s choice). Buyer agrees to pay
all labor and shipping charges associated with this warranty and to request warranty service through the installing dealer as soon
as a problem is discovered. If warranty service is requested more than 30 days after the Warranty Period has ended, it will not
be honored.
STA-RITE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL, INCIDENTAL, OR CONTINGENT DAMAGES WHATSOEVER.
THE FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER EXPRESS WARRANTIES. IMPLIED WARRANTIES, INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A
PARTICULAR PURPOSE, SHALL NOT EXTEND BEYOND THE WARRANTY PERIOD PROVIDED HEREIN.
Certain states do not permit the exclusion or limitation of incidental or consequential damages or the placing of limitations on
the duration of an implied warranty, therefore, the limitations or exclusions herein may not apply. This warranty sets forth specific legal rights and obligations, however, additional rights may exist, which may vary from state to state.
Supersedes all previous publications.
SSta-RRitee IInndduusstrieess, 22993 WWrigghht SSt., DDeelaavvaann, WWII 5533111155
Loading...