SpeeCo Splitmaster 401628BB, Splitmaster 401628BBCA Owner's Manual
28 TON VERTICAL/HORIZONTAL LOG
SPLITTER
401628BB & 401628BBCA
Owner ’s Manual
ASSEMBLY & OPERATING INSTRUCTIONS
This safety alert symbol identifies important safety messages in this manual.
Failure to follow this important safety information may result in serious injury
or death.
L137 -822-1209
Rev. 0
MODEL NO.
Table of Contents
Page(s)
Important Safety Information................................................................................................................. 1-6
Intended Use ......................................................................................................................... 1
Personal Protective Equipment ............................................................................................... 1
Safety Decals ....................................................................................................................... 1-2
General Safety ...................................................................................................................... 3
Preparation of the Log ........................................................................................................... 3
Work Area ........................................................................................................................... 3
Operation of the Log Splitter ................................................................................................. . 3-4
Repair and Maintenance Safety ............................................................................................. 4
Hydraulic Safety .................................................................................................................. 5
Fire Prevention ..................................................................................................................... 5-6
T owing Safety ................................................................................................................. ..... 6
Assembly Instructions ...................................................................................................................... 7-13
Operating Instructions ....................................................................................................................... 12-13
Engine Oil Recommendations ................................................................................................ 12
Hydraulic Oil Recommendations ............................................................................................ 12
St arting Instructions ............................................................................................................... 12
Operation .............................................................................................................................. 13
T owing ........................................................................................................................ .............. 13
Maintenance .......................................................................................................................................... 13
Parts Breakdown Illustrations................................................................................................................ 10-11
Specifications ................................................................................................................ ......................... Back Cover
WARNING: Read and thoroughly understand all instructions and safety information before assembling
or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone
to operate this log splitter who has not read this manual. As with all power equipment, a log splitter
can be dangerous if assembled or used improperly. Do not operate this log splitter if you have doubts
or questions concerning safe operation. Call our customer service department at 1-800-525-8322
to address these concerns.
Si no entiende ingles, se prefiere que busque alguien que interprete las instrucciones para usted.
INTENDED USE
NEVER use this log splitter for any other purposes than splitting wood. It is designed for this use only. Any other use can
cause serious injury or death.
PEPER
PERSONAL PROTECTIVE EQUIPMENT
PERPERSONALSONAL PROTECTIVE EQUIPMENT
BEFORE operating this log splitter make sure that you wear safety gear such as goggles or safey glasses, steel toed
shoes and tight fitting gloves (without loose cuffs or draw strings). Always wear a protective hearing device when operating this log splitter.
NEVER wear loose clothing or jewelry that can be caught by moving parts of the log splitter. Keep clothing and hair away
from all moving parts when operating this log splitter.
SAFETY DECALS
Make sure that all safety warning decals are in good condition and readable. Always replace missing or defaced decals.
Contact Special Products Co. at 1-800-525-8322 for replacement decals.
PART NUMBER: 52020000
LOCATION: TOP, FRONT END OF TONGUE
Page 1
PART NUMBER: 52055200
LOCATION: BOTH STRIPPER
PLA TES AND CYLINDER
PART NUMBER: 52023200
LOCATION: HYDRAULIC TANK
LOWER T ANK, RIGHT CORNER
PART NUMBER: 51018900
LOCATION: TOP OF HYDRAULIC CYLINDER
Page 2
GENERAL SAFETY
Failure to follow these instructions may result in serious injury or death.
ALWAYSEread the operator’s manual before operation. It is located in the plastic canister on the tongue.
EVER
NEVER allow children to operate this log splitter. NEVER allow adults lacking proper instructions and understanding to
operate this log splitter.
KEEP all people and pets a minimum of 10 feet away from your work area when operating this log splitter. Only the
operator is to be near the log splitter during use.
NEVER actuate the control until all people are clear of the work area.
NEVER operate the log splitter when under the influence of alcohol, drugs or medication.
NEVER allow a person who is tired or otherwise not alert to operate the log splitter.
PREPARATION OF THE LOG
Both ends of the log should be cut as square as possible to help prevent the log from riding out of the splitter during
operation. Do not split logs greater than 26 in. in length.
WORK AREA
NEVER operate the log splitter on slippery, wet, muddy or icy ground.
ONLY operate your log splitter on level ground. Operating on a slope could cause the log splitter to roll over or logs to fall
off.
NEVER operate your log splitter in an enclosed area. Exhaust fumes contain carbon monoxide which can be deadly when
inhaled.
NEVER attempt to move your log splitter over hilly or uneven terrain without a tow vehicle or adequate help.
ALWAYS block the wheels to prevent movement of the log splitter while in operation.
ONLY operate your log splitter in daylight or under good artificial light.
ALWAYS keep the work area clean. Remove split wood around your log splitter immediately so that you don’t stumble
over it.
OPERATION OF THE LOG SPLITTER
ENGINE
TONGUE
ONLY operate the log splitter from the operator zone as
shown in the diagram. The operator has the safest and
most effcient access to the control valve and the beam
in this location.Failure to operate the log splitter in this
position can result in serious injury or death.
FOOT PLATE
OPERATOR
BEAM
ZONE
Page 3
KNOW how to stop the log splitter and disengage the controls before operating it.
NEVER place hands or feet between the log and splitting wedge during forward or reverse stroke. Serious injury or death
could result.
NEVER straddle or step over the log splitter during operation.
NEVER reach or bend over the log splitter to pick up a log.
NEVER try to split two logs on top of each other.
NEVER try to cross split a log.
NEVER attempt to load your log splitter when the ram or wedge is in motion.
ALWAYS use your hand to operate the control lever on the valve. NEVER use your foot, a rope or any extension device.
NEVER move the log splitter while the engine is running. Shut off the engine even if you are leaving the log splitter for a
short period of time.
ALWAYS avoid contact with the muffler and other hot areas of the engine during operation or after running to prevent
burns.
REPAIR AND MAINTENANCE SAFETY
NEVER operate your log splitter when it is in poor mechanical condition or in need of repair.
Periodically check that all nuts, bolts, screws, hydraulic fittings and hose clamps are tight.
NEVER alter your log splitter in any manner. Such alterations may cause your log splitter to be unsafe and will void the
warranty.
Perform all recommended maintenance procedures before using your log splitter.
Replace all damaged or worn parts immediately.
NEVER tamper with the engine to run it at excessive speeds. The maximum engine speed is preset by the manufacturer
and is within safety limits. See Honda engine manual.
ALWAYS remove the spark plug wire before performing any service or repair on your log splitter.
ALWAYS check the level of hydraulic oil and engine oil before operation.
ALL replacement parts must meet manufacturer’s specifications.
Page 4
Loading...