Spectrum Winco Rollsight EHDG-5R, Winco Rollsight EHDG-7R, Winco Rollsight EHDG-11R Installation And Operating Instruction Manual

ROLLSRIGHT™ ELECTRIC COUNTERTOP
COMMERCIAL HOT DOG ROLLER GRILL
Installation and Operating Instruction Manual
EHDG-7REHDG-5R
Optional curved glass
sneeze guards available
(sold separately)
EHDG-11R
Overall Dimensions
Model Volta ge Frequency Power Amperage Plu g Ty pe
Weight
Length Depth Heig ht
EHDG-5R
EHDG-7R 900W 8.1A
110V 60Hz
700W 6.3A
EHDG-11R 1400W 12.7A
NEMA 5-15P
23"
(585mm)
10 -1 /2"
(270mm)
13 -1/2"
(345mm)
19-3/4"
(505mm)
7"
(180mm)
7"
(180mm)
7"
(180mm)
16.3 lbs
7.4 k g s
20.2 lbs
9.2 kgs
29 lbs
13.2 kgs
BEFORE OPERATING ANY EQUIPMENT, READ AND FAMILIARIZE YOURSELF WITH THESE USE AND SAFETY INSTRUCTIONS
Congratulations on your purchase of this SPECTRUM commercial roller grill. When used as intended, and with proper care and maintenance, you are sure to experience years of reliable operation from this equipment. To ensure best results, it is important that you read and follow the instructions in this manual carefully. It is important to keep
Form No. EHDG -Series Manual - 041019
Electric Countertop Roller Grill
Important For Future Reference
Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or parts, this information is required.
Model Number Serial Number Date Purchased
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE
! !
PROPERTY DAMAGE, INJURY, OR DEATH. READ THE INSTALLATION, OPERATION, AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT.
CAUTION: THESE MODELS ARE DESIGNED, BUILT, AND SOLD FOR COMMERCIAL USE ONLY. IF THESE MODELS
! !
ARE POSITIONED SO THE GENERAL PUBLIC CAN USE THE EQUIPMENT, MAKE SURE THAT CAUTION SIGNS, WARNINGS, AND OPERATING INSTRUCTIONS ARE CLEARLY POSTED NEAR EACH UNIT SO THAT ANYONE USING THE EQUIPMENT WILL USE IT CORRECTLY AND NOT INJURE THEMSELVES OR HARM THE EQUIPMENT.
WARNING: A FACTORY AUTHORIZED SERVICE PROVIDER SHOULD HANDLE ALL MAINTENANCE
! !
AND REPAIR. BEFORE DOING ANY MAINTENANCE OR REPAIR, FOLLOW SERVICE SET UP ARRANGEMENT ON PAGE 11.
AVERTISSEMENT: TOUTE INSTALLATION, RÉGLAGE, MODIFICATION, RÉPARATION OU ENTRETIEN INCORRECT PEUT OCCASIONNER DES DOMMAGES MATÉRIELS, DES BLESSURES GRAVES OU LA MORT. LIRE LES INTRUCTIONS D'INSTALLATION, D'UTILISATION ET D'ENTRETIEN ATTENTIVEMENT AVANT D'INSTALLER OU DE RÉPARER CET APPAREIL.
ATTENTION: CES MODÈLES SONT CONÇUS, FABRIQUÉS, ET VENDUS POUR UN USAGE COMMERCIAL SEULEMENT. SI CES MODÈLES SONT PLACÉS POUR QUE LE GRAND PUBLIC PUISSE LES UTILISER, ASSUREZ-VOUS QUE LES CONSIGNES D’ATTENTION, D'AVERTISSEMENT, ET LES INSTRUCTIONS D'UTILISATION SOIENT CLAIREMENT AFFICHÉES PRÈS DE CHAQUE UNITÉ DE SORTE QUE N'IMPORTE QUEL UTILISATEUR DE L'APPAREIL L'EMPLOIE CORRECTEMENT ET NE SE BLESSE PAS OU N'ENDOMMAGE PAS L'APPAREIL.
AVERTISSEMENT: UN TECHNICIEN AUTORISÉ PAR L'USINE DEVRA EFFECTUER TOUT L'ENTRETIEN ET LES RÉPARATIONS. AVANT DE FAIRE TOUT ENTRETIEN OU RÉPARATION, VEUILLEZ CONTACTER WINCO.
Introduction
Congratulations on the purchase of the SPECTRUM™ RollsRight™ Commercial Hot Dog Roller Grill. Please take time to carefully read through this manual to ensure the machine is operated and maintained properly, to ensure the best possible performance from the product for many years.
SPECTRUM will not accept liability for the following if:
• The instructions in this manual have not been followed correctly.
• Non-authorized personnel have tampered with the machine.
• Non-original spare parts are used.
• The machine has not been handled and cleaned correctly.
• There is any use damage to the unit.
2
Immediately Inspect for Shipping Damage
All containers should be examined for damage before and during unloading. The freight carrier has assumed responsibility for its safe transit and delivery. If equipment is received damaged, either apparent or concealed, a claim must be made with the delivering carrier.
A. Apparent damage or loss must be noted on the freight bill
at the time of delivery. It must then be signed by the carrier representative (Driver). If this is not done, the carrier may refuse the claim. The carrier can supply the necessary forms.
B. If concealed damage or loss is not apparent until after equipment
is uncrated, a request for inspection must be made to the carrier within 15 days. The carrier should arrange an inspection. Be certain to keep all contents and packaging material.
Table of Contents
Specications ....................................................................................... 1
Warnings .............................................................................................. 2
Introduction ........................................................................................ 2
Packaging ............................................................................................ 3
Installation .......................................................................................... 4
Operation ............................................................................................ 5
Optional Accessories .......................................................................... 5
Cleaning, Care & Maintenance ......................................................... 6
Safety ................................................................................................... 6
Troubleshooting ................................................................................. 7
Service & Repair .................................................................................. 7
Exploded View .................................................................................... 8
Electric Countertop Roller Grill
Spare Parts List .................................................................................... 9
Electrical Diagram ............................................................................ 10
Assembly Instructions - sneeze guards ........................................ 11
Limited Warranty .............................................................................. 12
Package Contents
All units come with an Operating Instruction Manual and the following:
• SPECTRUM™ RollsRight™ Commercial Hot Dog Roller Grill
• Drip Tray
SPECTRUM prides itself on quality and service, ensuring that at the time of packing, all products are supplied fully functional and free of damage. Should you nd any damage as a result of freight, please contact your SPECTRUM dealer immediately.
Installation and start-up must be performed by a qualified installer who has thoroughly read, understands and follows these instructions.
Please keep this manual in a safe place for future use!
Unpacking the Equipment
DISPOSE OF ALL PACKAGING MATERIALS IN AN ENVIRONMENTALLY RESPONSIBLE MANNER.
1. Remove all packing materials and tape, as well as any protective plastic and cardboard, from the unit.
2. Clean any glue residue left over from the plastic or tape.
3. Place the unit in the desired position and height.
NOTE
Please remember that this manual and the warning labels do not replace the need to be alert, to properly train and supervise operators, and to use common sense when using this equipment.
3
Installation
These instructions should be followed at all times. Failure to follow these instructions could result in injury to yourself and others.
TO REDUCE RISK OF INJURY OR DAMAGE TO THE UNIT:
1. Read this manual thoroughly before installation and operation. DO NOT proceed with installation and operation if you have any questions or do not understand anything in this manual. Contact your representative or the manufacturer rst.
WARNING AVERTISSEMENT
Fire Hazard.
Correct installation precautions, procedures and regulations must be fo llowed. Operati on and safe ty training is ne cessary for all use rs of this equipme nt.
The equip ment must be install ed by qualied per sonnel only. Correc t installatio n precautions, procedures and regulati ons must be followe d in order to re duce the risk of re. Hood an d re suppression system s must be maintaine d per manufacturer's guidelines. Only quali ed and trained person nel are to use this equipment.
2. Remove the SPECTRUM™ Commercial Hot Dog Roller Grill from the packaging. Be certain that all protective plastics and residues are thoroughly cleaned from its surface.
3. Place Roller Grill on a rm level surface; the adjustable feet can assist in leveling. Local standards and regulations should be consulted in order to abide by standards set in relation to positioning, spacing, and ventilation. SPECTRUM recommends that you allow no less than 4” for a ventilation gap around the perimeter of this unit. Common sense should be used when choosing position and operation of this product.
CAUTION
Do not position or operate near combustible materials/ammable objects.
Ne pas placer ni faire fonctionner l'appareil près de matériels combustibles ou d'objets inflammables.
Once your Hot Dog Roller has been placed in position, be sure that the stainless steel drip tray is correctly positioned.
Une fois que votre Machine à Hot-Dog à Rouleau est mise en place, veillez à ce que le bac à déchets en acier inoxydable soit correctement placé.
Risque d'incendie
La surcha ue des vapeurs d' huile ou de l'huile peut s'enammer et provoquer un incendi e. Surveillez la temp érature, la qualité et l e niveau d’huile. Uti lisez et entrete nez le système d'élimi nation des vapeurs d'huile.
Faire chau er l'huile avec préca ution. Si l'huile fu me, réduire le feu. Ne p as laisser l'appareil s ans surveillance. S i le feu se produit , éteindre l'apparei l, couvrir jusqu'à refroi dissement. Ne pas m ettre l'eau dans l'huile chau de ou enammée. Ne fa ites pas fonct ionner avec de l'huile s ous la barre d'huile. L’huile sal e a un point d'éclair plus bas. R emplacer l'huile sur un e base régulière. Maintenir le niveau d'huile correct. Utiliser un système d'évacuation de la vapeur d' huile (capot) pour réd uire l'accumulation de graisse et d'huile sur les surfa ces de paroi ou de plaf ond.
ATTENTION
WARNING AVERTISSEMENT
Electrical Shock Hazard
Keep water an d other liquids from entering the inside of the unit. Liquid inside the unit could cause an el ectrical sho ck.
Do not spray w ater or cleaning products. Liquid could contact the electrical components and cause a s hort circuit o r an elect rical shock. Do n ot use unit if power cor d is damaged or has been modied.
4. Once the Roller Grill has been placed in position, be sure that the stainless steel drip tray is correctly positioned.
5. Proper connections and power supply are essential for ecient performance. Supply the appropriate power and
connect to source; your Roller Grill is now ready to turn on and operate. (For power supply please see technical specication on page 1).
Fournir l'alimentation secteur appropriée et brancher l’appareil à la source d'alimentation ; votre Machine à Hot-Dog à Rouleau est maintenant prête à être allumée et à fonctionner. (Pour l’alimentation, veuillez voir la che technique, page 1).
6. The units are wired to be used with a standard 110V/AC receptacle and may be plugged into any convenient outlet.
Proper Grounding · Mise à la terre correcte
This machine is p rovided with a three-pronged grounding plug. The outle t to which this plug is connected must be pr operly grounded. If the receptacle is not the prop er grounding type, cont act an electr ician. DO NOT, under any circumstance s, cut or remove the thir d ground prong from the power cord or use any adapter plug.
Cette machine est équip ée d'une che à trois broches. La prise sur laquelle cette che es t branchée doit être correctement mise à la terre. Si la prise n'est pas le type d e mise à la terre, contactez avec un électrici en. NE PAS, en aucun cas couper ou enlever la troisièm e broche de terre à partir du cordon d'alimentation ou utiliser un adaptateur.
7. The installation of the unit must conform to the NATIONAL ELECTRIC CODE, ALL LOCAL ELECTRIC CODES AND ORDINANCES, AND ALL THE LOCAL ELECTRICAL COMPANY RULES AND REGULATIONS. Additionally, we recommend a 4" spacing surrounding the unit in order to provide adequate ventilation.
Risque de choc électrique
Conser ver l'eau et d'autres liqui des de pénétr er à l'intérieur de l'app areil. Liquide à l'intérieur de l'appareil pourrait provoquer un choc électrique.
Ne pas pulvé riser de l'eau ou des pro duits de nettoyage. Le liquide pourrait contacter avec les comp osants élec triques et caus er un court- circuit ou un cho c électrique. Ne pas util iser l'appareil si le cor don d'alimentation est endommagé. ou a été modi é.
USE A GROUNDED OUTLE T DO NOT ADD AN ADAPTO R
TO THE PLUG
UTILISER UNE PRISE AVEC M ISE À LA TERRE NE PAS AJO UTER UN
ADAPTATEUR SUR LA FICHE
4
Loading...
+ 8 hidden pages