Southbend SX-5G User Manual

Model Compartments Capacity

SX-5G 1 1-5 Pans (2-1/2”)

Standard Features

- Automatic generator blow down

- Delime mode power setting

- Deliming port for the generators, which is located on the
right side panel.

- Split water connections for simple hook up for a treated
water system.

- 4” Stainless steel adjustable legs

- Gas red, stainless steel generator operating at 0 psi (0
kPa) and rated at 45,000 BTU

Gas Counter top

ConveCtion steamer

Job Item#

CONSTRUCTION SPECIFICATIONS

Southbend counter convection steamer with gas red steam
generator. AGA/CGA Certied and NSF Approved. The
steamer shall be constructed of a satin nish stainless steel
#304. The cooking chamber is a one piece all welded, #316
stainless steel with coved corners. The heavy duty door shall
have an inner liner of stainless steel with a full perimeter gasket
seal, an outer liner of one piece all welded stainless steel, and
a positive lock and seal mechanism with spring release. The
compartment shall be provided with removable stainless steel
pan supports. A stainless steel drip trough shall be integrally
connected to drain to collect condensate when the doors are
opened.

The control housing shall be constructed of stainless steel with a
full access removable panel which includes an illuminated three
way power switch (ON/OFF/Delime), a pilot ready light, a pilot
cooking light, an ignition light, a 60-minute electric timer which
sounds an audible signal at the end of the cooking cycle, solid
state generator controls and electronic ignition. Steam ow to
the cooking chamber shall be cut off when the door is opened
and reactivated when the door is closed.

WATER QUALITY STATEMENT

Water quality is the major factor affecting the performance of your appliance. If you are unsure of water quality, consult a local
water treatment specialist and have the water analyzed. Your water supply must be within these general guidelines:
Total dissolved solids - less than 60 PPM
Total alkalinity - less than 20 PPM
Silica - less than 13 PPM
Chlorine -less than 1.5 PPM
pH Factor -7.0-8.5
Water which fails to meet these standards should be treated by installation of water conditioner.

FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY

Form SX-5G Rev 1 (November/2009)

www.yatesgd.com www.yatesgraphicdesign.com

Models:

 SX-5G

in [mm]

UTILITY CONNECTIONS

Gas red, stainless steel steam generators operating at 0 psi (0kPa) and rated at 45,000 BTU (13.2 kW/hr)

Required minimum inlet pressure:

-Natural Gas 6” W.C.

-Propane Gas 11” W.C.

Controls:

- 120 VAC, 1 Phase, 50/60 Hz

Electrical: Unless otherwise specied, Field Wire Electrical Connection to be 120 VAC, 1 Phase, 50/60 Hz with ground wire. Furnished with 6
foot cord with 3-prong plug. Maximum amps 2.0.

Drain: 1” IPS piped to open oor drain. No Solid Connection. 24” length before open air gap opening (no bends or elbows)

Gas: 3/4” IPS supply line required

Generator Water: 3/8” O.D. tubing at 25-50 PSI (170-345 kPa)

Condensing Water: 3/8” O.D. tubing at 25-50 PSI (170-345 kPa)

OPTIONS/ACCESSORIES

 220 VAC, 1 Phase, 50/60 Hz Controls  120 Minute Timer  Correctional Package

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

Form SX-5G Rev 1 (November/2009)

[phone] www.southbendnc.com