Southbend SX-34EC User Manual
Model Compartments Capacity
SX-34EC 2 1-7 Pans
SX-55EC 2 1-10 Pans
Standard Features
- Automatic generator blow down
- Delime mode power setting
- Deliming port for each generator, which is located on the rear of
the unit.
- Split water connections for simple hook up for a treated water
system.
- 28” high stainless steel construction cabinet base with operable
door for storage.
- Two electric, stainless steel generators operating at 0 psi (0 kPa)
with eld replaceable element rated at:
SX-34EC - 7.5kW + 10kW
SX-55EC - 15 kW + 15kW
ElEctric two compartmEnt
c
onvEction StEamEr on
c
abinEt baSE
Model SX-55EC
Job Item#
CONSTRUCTION SPECIFICATIONS
Southbend Convection Steamer with individual steam generator
for each cavity. C-CSA-US Certied and NSF Approved.
Model SX-34EC shall have 3 pan capacity on top and 4 pan
capacity on bottom. Model SX-55EC shall have 5 pan capacity on top and bottom. The steamer shall be constructed of
a satin nish stainless steel #304. The cooking chamber is a
one piece all welded, #316 stainless steel with coved corners.
The heavy duty door shall have an inner liner of stainless steel
with a full perimeter gasket seal, an outer liner of one piece all
welded stainless steel, and a positive lock and seal mechanism
with spring release. Each compartment shall be provided with
removable stainless steel pan supports. A stainless steel drip
trough shall be integrally connected to drain to collect condensate when the doors are opened.
The control housing shall be constructed of stainless steel with
a full access removable panel. Each compartment shall have
individual controls which include an illuminated three way power
switch (ON/OFF/Delime), a pilot ready light, a pilot cooking light,
a 60-minute electric timer which sounds an audible signal at
the end of the cooking cycle, and solid state generator controls
for each generator. Steam ow to the cooking chamber shall
be cut off when the door is opened and reactivated when the
door is closed.
WATER QUALITY STATEMENT
Water quality is the major factor affecting the performance of your appliance. If you are unsure of water quality, consult a local
water treatment specialist and have the water analyzed. Your water supply must be within these general guidelines:
Total dissolved solids - less than 60 PPM
Total alkalinity - less than 20 PPM
Silica - less than 13 PPM
Chlorine -less than 1.5 PPM
pH Factor -7.0-8.5
Water which fails to meet these standards should be treated by installation of water conditioner.
FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY
Form SXEC Rev 3 (March/2015)
www.yatesgd.com www.yatesgraphicdesign.com
Models:
SX-34EC SX-55EC
UTILITY CONNECTIONS
Two electrically heated, stainless steel steam generators operating at 0 psi
(0kPa) and rated at:
SX-34EC - 7.5kW + 10kW
SX-55EC - 15kW + 15kW
Controls:
- 208 VAC, 3 Phase, 50/60 Hz
- 220 VAC, 3 Phase, 50/60 Hz
- 240 VAC, 3 Phase, 50/60 Hz
Electrical: 1 1/8” hole for electrical connection. Rating to be as specied on data plate.
Drain: 1” IPS piped to open oor drain. No Solid Connection. 24” length before open air gap opening (no bends or elbows)
Generator Water: 3/8” O.D. tubing at 25-50 PSI (170-345 kPa)
Condensing Water: 3/8” O.D. tubing at 25-50 PSI (170-345 kPa)
Model KW Phase
SX-34EC 17.5 3 49 46 42 26.6 21.1
SX-55EC 30 3 83.3 78.7 72.2 45.6 36.1
208V 220V 240V 380V 480V
aMPs Per line
OPTIONS/ACCESSORIES
380, 415, or 480 VAC, 3 Phase, 50/60 Hz Controls
220/380 or 240/415 VAC, 3 Phase, 50/60 Hz, 4 wire Controls
120 Minute Timer
12” x 20” pan guides for cabinet base
Correctional Package
Form SXEC Rev 3 (March/2015)
INTENDED FOR COMMERCIAL USE ONLY.
NOT FOR HOUSEHOLD USE.
1100 Old Honeycutt Road, Fuquay-Varina, NC 27526
(919) 762-1000 www.southbendnc.com
Loading...