Southbend STRG-3D User Manual

St r a t o St e a m Ga S

3 and 5 Pan, Gas Fired Countertop Steamer

Standard Features

- Increased productivity in a space-saving design

- Single operating switch for easy operation

- Minimal side clearance required

- 5 minute cold start-up

- Constant water ow -minimizes water contamination buildup

- Self-contained (steam is generated within the cavity without

the cost of expensive boiler maintenance)

- Efcient design allows for 100% side serviceable and easy

cleaning

- Larger 3/4” “clog-free” drain capacity

- Side mount water resistant controls

- Stackable -no stand required

STRG-3D; STRG-5D

(shown on optional

stainless cabinet)

Job Item#

STANDARD CONSTRUCTION SPECIFICATIONS

Exterior : Type 304 stainless steel, #3 sanitary nish.

Interior: Type 304 stainless steel.

Legs: 4” stainless steel legs standard. Optional cabinet base

available.

Fully insulated cooking compartment.

Power Source: Natural Gas heat, Electric for controls. Avail-

able in 120V 60Hz Single Phase, 208/220V 50/60Hz Single
or Three phase, 240V 60Hz Single phase. A positive ground
connection is essential.

Controls:

- ON/OFF Lever: Single switch for operation. When the am-

ber Power light is illuminated this indicates the unit is on.

- 60 Minute Timer: Time can be set between 1 and 60 min­utes. When time expires, buzzer sounds. Buzzer can be
disabled by turning knob to manual position. Timer has no
effect on the operation of the steamer.

WATER QUALITY STATEMENT

Water quality is the major factor affecting the performance of your appliance. If you are unsure of water quality, consult a local
water treatment specialist and have the water analyzed. Your water supply must be within these general guidelines:
Total dissolved solids - less than 60 PPM
Total alkalinity - less than 20 PPM
Silica - less than 13 PPM
Chlorine -less than 1.5 PPM
pH Factor -7.0-8.5
Water which fails to meet these standards should be treated by installation of water conditioner.

FAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER WARRANTY

Form STRG Rev 2 (01/08)

www.yatesgd.com www.yatesgraphicdesign.com

Printed in USA

Models:

 STRG-3D  STRG-5D

UTILITY INFORMATION

Models: STRG-3D; STRG-5D

Electric:

One Electrical connection per unit is required. STRE-3 (0.5A); STRE-5 (0.5A)

Gas Supply:

Natural Gas, minimum 4” W.C., Orce size 54 (LP Gas minimum 10” W.C. Orice
size 64) Connection 1/2” NPT male, usage 37K Btu/hr. , (4) burners @ 9,250 BTU/
Hr ea. 37,000 BTU/Hr total.

Water Usage:

0.12 gallons per minute at 45 p.s.i. water pressure in cavity. 0.34 gallons per
minute at 45 p.s.i. water pressure in condenser. 0.46 total gallons per minute at 45
p.s.i.

OPTIONS AND ACCESSORIES

 Stainless steel cabinet base with rack pan guides

 6” base legs

 120V 60 Hz 1 Phase

MISCELLANEOUS

- For installation on combustible oors (with 4” high
legs) and adjacent to combustible walls, allow 6”
clearance.

- Check local codes for re, installation and sanitary
regulations.

NOTICE:

Southbend has a policy of continuous product
research and improvement. We reserve the
right to change specications and product design
without notice. Such revisions do not entitle the
buyer to corresponding changes, improvements,

additions or replacements for previously

purchased equipment.

 208-220VAC 50 Hz 1 or 3 Phase

 240VAC 60 Hz 1 or 3 Phase

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

Form SRTG Rev 2 (01/08)

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

[phone] www.southbendnc.com

www.yatesgd.com www.yatesgraphicdesign.com