Southbend BGS-12SCAT User Manual
CONVECTION OVEN
B-SErIES All TErrAIN
GAS, SINGLE DECK
Standard Features
- 54,000 BTU (LP)
- Standard depth
- Single deck convection oven is 55-1/4” in height
- Patented “plug-in, plug-out” control panel - easy to
service
- Slide out control panel for full view servicing
- Stainless steel front, sides and top
- Full stainless steel dependent doors (Full 180° opening)
- Transportation door locks (Pad lock not included)
- Fully enclosed stainless steel rear jacket for
transportation protection
- Heat keeping dual door seal system
- Top and bottom rear covers for utility protection
- Coved, porcelain interior
- Stay cool heavy duty door handle
- Soft Air, two-speed, 1/2 hp fan motor
- Custom design rugged terrain tube chassis
- Integrated equipment shelf on tube chassis
- 11-position rack guides and 5 plated oven racks
- Electronic ignition
- Forced cool down fan mode
- Oven “heat” light cycles with burners
- All Terrain 10” casters
(1000 lbs maximum capacity)
- Interior oven lights
Available Control
BGS/12SCAT
BGS/12SCAT All Terrain
Job Item#
SC-Standard Controls
140°F to 500°F solid state thermostat and 60 minute
mechanical cook timer.
STANDARD CONSTRUCTION SPECIFICATIONS
Exterior Finish: Stainless steel front, sides and top.
Doors: Dependent doors, stainless steel construction, heavy-
duty welded steel frame and 5/8” diameter full-length hinge pin.
Oven Interior: Porcelain enamel nish, coved, fastener free.
Rack and Rack Guides: Heavy-duty removable wire rack guides
spaced on 1-5/8” centers offer 11 different rack positions. 5 wire
racks provided with each oven.
Blower Fan and Motor: 1/2hp, 2-speed motor, 1710/1120 r.p.m
Oven Heating: 54,000 BTU (LP). Oven heating is regulated
by an adjustable thermostat control. Blower fan circulates air
within the cavity “scrubbing” heat to the oven interior for even
heat distribution within the cavity.
Electronic Ignition: Hot surface ignitor with ame safety device.
Control Panel: Located on front, at right side of oven, away from
heat zone. Slide out panel extends over 17” for easy servicing.
Interior Lights: Two 40 watt high temperature recessed lamps
located within the oven cavity.
Casters: All Terrain 10” pneumatic casters (1000 lbs
maximum capacity)
Form BGS/12AT Rev 4 (February/2017)
www.yatesgd.com www.yatesgraphicdesign.com
Printed in USA
Models:
BGS/12SCAT
Dimensions -in (mm)
55-1/4”
(1398)
12-5/8”
(305)
MODEL
38”
(965)
29-1/4”
(762)
38-3/8”
(966)
32-1/4”
(812)
23-3/4”
(610)
SIDE VIEWFRONT VIEW REAR VIEW
DEpth OvEn IntErIOr rack cLEarancE ShIppIng cratE
a B c WIDth DEpth hEIght WIDth DEpth WIDth DEpth hEIght vOLuME WEIght
26-1/2”
(673)
2”
(51)
(228)
9”
30-1/4”
(762)
(76)
3-7/8”
(102)
3”
BGS/12SCAT
37.25”
(946)
30.25”
(768)
33.75”
(857)
29”
(737)
21.50”
(546)
20”
(508)
Note: When shipped on legs, crated height is 69” (1753 mm)
UTILITY INFORMATION
GAS:
• 54 ,000 BTU (LP)
• One 3/4” male connection
• Required minimum inlet pressure:
- Propane gas 11” W.C.
ELECTRIC: Standard: 120/60/1 phase, furnished with 6’ cord w/3-
prong plug (1 plug/deck). NEMA #5-15p. Total maximum amps 7.9.
* All units are shipped single phase.
28.25”
(718)
21”
(533)
57.50”
(1461)
45.5”
(1156)
81.5”
(2070)
123.4 cu. ft.
(3.49 cu. m.)
MISCELLANEOUS
• If using ex hose connector, the I.D should not be smaller
than 3/4” and must comply with ANSI Z 21.69.
• If casters are used with ex hose, a restraining device
should be used to eliminate undue strain on the ex hose.
• Clearances from combustibles: Top-0”, bottom-0”, right
side-0” and left-2”
• Recommend - Install under vented hood if operated
indoors
• Check local codes for re and sanitary regulations
• If the unit is connected directly to the outside ue, an CSA
approved down draft diverter must be installed at the ue
outlet of the oven
• Oven cannot be operated without fan in operation
Notice: Southbend reserves the right to change specica-
tions and product design without notice. Such revisions do
not entitle the buyer to corresponding changes, improvements, additions, or replacements for previously purchased
equipment.
750 lbs
(340 kg.)
3/4” quick disconnect with exible
hose (specify length: 3ft, 4ft, or
5ft)ue
Down draft diverter for direct ue
Form BGS/12AT Rev 4 (February/2017)
OPTIONS AND ACCESSORIES
Chassis mount dry chemical
re extinguisher (Class A,B &
C) 5 lbs capacity
INTENDED FOR COMMERCIAL USE ONLY.
NOT FOR HOUSEHOLD USE.
1100 Old Honeycutt Road, Fuquay-Varina, NC 27526
(919) 762-1000 www.southbendnc.com
Loading...