Sony Xperia M, Xperia M Dual, C1904, C1905, C2004 Test Instructions
...
TM
TM
Test Instructions
- mechanical -
Xperia
M, Xperia
C1904, C1905, C2004, C2005
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
M Dual
Test Instructions (mech)
CONTENTS
1 Pre-Test Preparations .................................................................... 4
1.1 Hardware ............................................................................................... 4
1.1.1 Water indicator inspection .......................................................................... 4
1.1.2 Test Enablers ............................................................................................... 5
1.2 Software ................................................................................................ 6
1.2.1 Software update ........................................................................................... 6
2 Tests ................................................................................................ 7
2.1 Service Test Mode ................................................................................ 7
2.2 Service Tests ........................................................................................ 8
2.2.1 Keyboard & Switch ...................................................................................... 8
2.2.2 Touch Screen ............................................................................................... 8
2.2.3 Display .......................................................................................................... 8
2.2.4 LED ............................................................................................................... 9
2.2.5 Illumination .................................................................................................. 9
2.2.6 Light Sensor ................................................................................................. 9
2.2.7 Speaker ....................................................................................................... 10
2.2.8 Earphone .................................................................................................... 10
2.2.9 Microphone ................................................................................................ 10
2.2.10 Secondary Microphone ............................................................................. 11
2.2.11 Vibrator ....................................................................................................... 12
2.2.12 Camera ....................................................................................................... 12
2.2.13 Front Camera ............................................................................................. 12
2.2.14 Bluetooth .................................................................................................... 13
2.2.15 WLAN .......................................................................................................... 13
2.2.16 GPS ............................................................................................................. 14
2.2.17 Compass .................................................................................................... 14
2.2.18 Accelerometer ............................................................................................ 14
2.2.19 Proximity switch ........................................................................................ 15
2.2.20 Real time clock .......................................................................................... 15
2.2.21 Total call time ............................................................................................. 16
2.2.22 External Memory ........................................................................................ 16
2.2.23 Security ...................................................................................................... 16
2.2.24 FM radio ...................................................................................................... 17
2.2.25 Battery Status Check................................................................................. 17
2.2.26 Flip slider counter ..................................................................................... 17
2.2.27 Verify certificates ....................................................................................... 18
2.2.28 SIM Card Test ............................................................................................. 18
2.2.29 USB Test ..................................................................................................... 18
2.2.30 Flash LED ................................................................................................... 19
2.2.31 NFC ............................................................................................................. 19
2.3 Manual Tests ...................................................................................... 20
2.3.1 SIM .................................................................... Error! Bookmark not defined.
2.3.2 Audio Jack test .......................................................................................... 20
2.3.3 Camera ............................................................. Error! Bookmark not defined.
2.3.4 Charging via USB and Easy Charger (Charger or Computer) ............... 20
2.3.5 Data Communication test ......................................................................... 21
2.3.6 Network Test .............................................................................................. 22
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
2(25)
Test Instructions (mech)
3 Revision History ........................................................................... 22
For general information about test procedures, refer to
1220-1333: Generic Repair Manual - mechanical
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
3(25)
1 Pre-Test Preparations
Pre-Test Preparations
1.1 Hardware
1.1.1 Water indicator inspection
Before starting any tests the liquid intrusion indicator has to
be checked.
The Water Indicator is located as shown in these pictures.
1. The first is located as shown in the picture after removing
Battery Cover Assy
Test Instructions (mech)
2. The second one is locate on the ANT Board as shown
after removing Rear Cover.
If affected (red color) - handle the phone according to the
local directives.
If not affected by liquid, proceed to the ‘Pre-Test
Preparation’ below.
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
4(25)
Pre-Test Preparations
1.1.2 Test Enablers
The tests in this document will refer to following items on the phone.
Front & side keys:
1. Back Key
2. Home Key
3. Multitask key
4. Secondary Camera
5. Ambient Light Sensor
6. Proximity Switch
7. Earphone
8. Notification LED
9. Microphone
10. On/Off Key
11. Volume up/down Key
12. Auto Focus / Camera Key
Test Instructions (mech)
4 5 6 7
10
11
1 2 3
8
12
9
Back:
13. Camera
14. Flash LED & Secondary Microphone
15. NFC
16. Speaker
13 14
15
16
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
5(25)
Test Instructions (mech)
Pre-Test Preparations
1.2 Software
1.2.1 Software update
1.2.1.1 Software version verification
Check the software version of the phone for fault verification. The latest improvements are found on
the support pages under the support news http://www.sonymobile.com/global-en/support/
• Start up the phone
• Note: Make sure the phone is in call setup.
• Press the following keypad combination: *#*#7378423#*#*
• Select ‘Service info’
• Select ‘Software info’
• Check the software file revisions and update as described below:
For more information, refer to 1220-1333: Generic Repair Manual - mechanical
1.2.1.2 Software version update
Mandatory first repair action!
Use the Micro USB to USB cable for this purpose.
Fully charged battery first, ensure the phone is powered off and proceed as follows:
• Open the Emma application and log in.
• Press and hold the volume down key on the phone, connect the phone to the USB cable and then
release the volume down key.
• Select the appropriate service and follow the on-screen instructions.
NOTE: For phones with internal storage (built in “SD card” user memory), the only service
which erase all user data in the internal memory and update the customization in the internal
storage (MS CDF) are the Services “Refurbish” and “Customize”.
See also emma User Guide info.
http://emma.extranet.sonyericsson.com/documents/emma_user_guide.pdf
(see “Service Types” and “Aspects of large files”)
In Swap flow, when change a phone from Customer A to Customer B, always use the service
Customization script.
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
6(25)
© Sony Mobile Communications AB
2 Tests
Test Mode
ake sure the phone is in
pad
Stamina mode needs to be turned off before entering
> STAMINA
Start up the phone and enter the service menus:
combination
elect one of the tests and follow the test instructions as
o stop the test and return to the ‘Service tests’ menu,
Generic Repair Manual
pictures will show a simplified basic phone for a general visualization of the
Test Instructions (mech)
2.1 Service
Note: Please m
pressing these touching key
menu.
Service Test Mode.
Settings -> Power management -
• Press the following keypad
• Select ‘Service tests’
• S
described below
T
press the Back key
For more information, refer to
1220-1333:
call setup when
s to get into the Service
: *#*#7378423#*#*
- mechanical
The following
service tests.
1277-1359 Rev 2
– Company Internal
7(25)
Tests
2.2 Service Tests
2.2.1 Keyboard & Switch
Press the touch screen and “Yes” to return to the
Service Test Menu.
Press all keys:
- Back key:
- Home key:
and reenter the Service tests
- Multitask key:
- Power key: the
more time
- Volume up/ down key:
- Auto Focus key and Camera key:
notification on screen
will leave the Service tests menu, unlock the unit
taskbar will be shown, press back key to return
screen will go black, press the Power key one
notification on screen
notification on screen
Test Instructions (mech)
2.2.2 Touch Screen
Move a finger across the Display, a line will be drawn as you
touches the Display.
Press the Back key to return to the Service Test Menu.
2.2.3 Display
Minor variations in the display’s brightness and color
may occur between phones.
There may be tiny bright dots on the display, called
defective pixels and which occur when individual dots
have malfunctioned and cannot be adjusted.
Two defective pixels are considered to be acceptable.
The display will show six test patterns of white, black, blue,
green, red, and rainbow colors on the full screen.
Make sure that there are no missing segments and that the
colors and contrast are OK.
Press the Back key to return to the Service Test Menu.
1277-1359 Rev 2
© Sony Mobile Communications AB – Company Internal
8(25)
Loading...