Page 1
Component Replacement
- electrical -
TM
Xperia
Z3 Compact
D5803, D5833
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
Page 2
CONTENTS
1 Replaceable Components ............................................................. 3
2 Component Placing ........................................................................ 5
3 Additional Repair info .................................................................... 6
4 Revision History ........................................................................... 13
For general information about electrical repair related issues, refer to
1220-1336: Generic Repair Manual - electrical
Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction
Do not remove shield can lids (Heat pasta are added and RF performance will be damaged)
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
2(13)
Page 3
1 Replaceable Components
EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN ‘COMMENTS’ BELOW
COMPONENT LOCATION
P = Primary side
S = Secondary side
REPAIR METHOD
HA = Hot Air (removal & mounting)
ST = Soldering Tool (removal & mounting)
HA/ST = Hot Air for removal - Soldering Tool for mounting
BGA =BGAStation
BH = Bottom Heater
ADDITIONAL INFORMATION
Ö1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s).
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
3(13)
Page 4
Position Component Part no. Comments
CN1300 Conn BtB Plug 4p HIROSE/BM22 1281-9973 S HA+BH Ö1
CN1302 Conn Leaf Spring Plug 1p 1275-2490 S HA+BH Ö2
CN1303 Conn Leaf Spring Plug 1p 1275-2490 S HA+BH Ö2
CN2200 Conn USB B Receptacle 5p 1270-2769 S HA+BH or BGA Ö3
CN2650 Conn Pogopin Plug 1p 1272-1414 S HA+BH Ö4
CN2653 Conn Coax Receptacle 1p 1237-5326 S HA+BH Ö5
CN2655 Conn Coax Receptacle 1p 1237-5326
CN2656 Conn Coax Receptacle 1p 1261-3585
CN2657 Conn Coax Receptacle 1p 1261-3585 S HA+BH Ö8
CN2658 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123 S HA+BH Ö9
CN2659 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123 S HA+BH Ö10
CN2663 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123 S HA+BH Ö9
CN2664 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123 S HA+BH Ö9
CN2665 Conn Pogopin Plug 1p 1272-1414 P HA+BH Ö11
CN2670 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123 S HA+BH Ö9
CN2672 Conn Pogopin Plug 1p 1272-1414 P HA+BH Ö12
CN2673 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123 S HA+BH Ö9
CN2674 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878 P HA+BH Ö13
CN2675 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878 P HA+BH Ö14
CN2676 Conn Pogopin Plug 1p 1272-1414 P HA+BH Ö15
CN2677 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878 P HA+BH Ö14
CN2678 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878 S HA+BH Ö14
CN2682 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878 P HA+BH Ö14
CN2683 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878 P HA+BH Ö16
CN2684 Conn Leaf Spring Plug 1p Mid mount Type 1275-0410
CN2685 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
CN2686 Conn Leaf Spring Plug 1p Mid mount Type 1275-0410
CN2693 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5878
CN3500 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5880
CN3501 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5880
CN4000 Card Conn SIM Nano 1278-7930
CN4100 Card Conn Micro SD 1281-9124
CN7303 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
CN8000 Conn Leaf Spring Plug 1p Mid mount Type 1275-0410 S HA+BH Ö21
CN8003 Conn Coax Receptacle 1p 1237-5326 S HA+BH Ö22
CN8650 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5880 S HA+BH Ö23
CN8651 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5880
D7800 LED flash LED 2.03mmx1.63mmx0.70mm 1277-7270
MC3503 Mic 3.76 Silicon D66 1281-8880 P HA+BH Ö25
MC3504 Mic 3.76 Silicon D66 1281-8886 S HA+BH Ö26
R1304 Resistor 0.01 Ohm +/-1% 200.0 mW (1.6x0. 1238-2147
S HA+BH Ö6
S HA+BH Ö7
P HA+BH Ö16
P HA+BH Ö16
P HA+BH Ö16
P HA+BH Ö14
S HA+BH Ö17
S HA+BH Ö17
P HA+BH or BGA Ö18
P HA+BH or BGA Ö19
S HA+BH Ö20
S HA+BH Ö23
S HA+BH Ö24
S HA+BH Ö27
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
4(13)
Page 5
2 Component Placing
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only – icon not shown on hard-copies.
Primary side
Secondary side
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
5(13)
Page 6
3 Additional Repair info
1
CN1300
Replace if mechanical damaged. (Phone dead or power
off)
Protect the RF connector with capton tape!
2
CN1302, CN1303
Replace if mechanical damaged. (Magnet charger not
working)
3
CN2200
Replace if mechanical damaged (USB charger or data
transfer not working)
Protect the RF and BtB connectors with capton tape!
4
CN2650
Replace if mechanical damaged (No or bad
GPS/Network secondary antenna)
Protect the RF and USB connectors with capton tape!
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
6(13)
Page 7
Repair Actions: Additional Repair Info
5
CN2653
Replace if open circuit 1-3 (No or bad GPS/ Network
secondary antenna)
Protect the BtB connector with capton tape!
6
CN2655
Replace if open circuit 1-3 (No or bad network, main
antenna)
Protect the BtB connector with capton tape!
7
CN2656
Replace if mechanical damaged (No or bad network,
secondary antenna)
Protect the SD connector with capton tape!
8
CN2657
Replace if mechanical damaged (No or bad network,
secondary antenna)
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
7(13)
Page 8
Repair Actions: Additional Repair Info
9
CN2658, CN2663, CN2664, CN2670, CN2673
Replace if mechanical damaged (Grounding Pin,
Antennas)
Protect the magnet connector with capton tape!
10
CN2659,
Replace if mechanical damaged (Grounding Pin,
Antennas)
Protect the magnet connector with capton tape!
11
CN2665
Replace if mechanical damaged (No or bad network,
main antenna)
12
CN2672
Replace if mechanical damaged (No or bad network,
main antenna)
Protect the microphone with capton tape!
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
8(13)
Page 9
Repair Actions: Additional Repair Info
13
CN2674
Replace if mechanical damaged (Grounding Pin , LCD
frame)
Protect the SD connector with capton tape!
14
CN2675, CN2677, CN2678, CN2682, CN2693
Replace if mechanical damaged (Grounding Pin , LCD
frame)
15
CN2676
Replace if mechanical damaged (Grounding Pin , LCD
frame)
Protect the BtB connector with capton tape!
16
CN2683, CN2684, CN2685, CN2686
Replace if mechanical damaged (Grounding Pin , LCD
frame)
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
9(13)
Page 10
Repair Actions: Additional Repair Info
17
CN3500, CN3501
Replace if mechanical damaged (Right Speaker not
working)
18
CN4000
Replace if mechanical damaged (No network, restart, No
SIM card inserted, NFC SIM problem, reset problem)
19
CN4100
Replace if mechanical damaged (No SD card)
20
CN7303
Replace if mechanical damaged (Grounding Pin,
Camera shield)
Protect the RF connector with capton tape!
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
10(13)
Page 11
Repair Actions: Additional Repair Info
21
CN8000
Replace if mechanical damaged (No or bad WLAN / BT)
22
CN8003
Replace if open circuit 1-3 (No or bad WLAN / BT)
23
CN8650, CN8651
Replace if mechanical damaged (No or bad NFC)
Protect the BtB connectors and Flash LED with capton
tape!
24
B3560
Replace if Flash LED not working,
Protect the BtB connectors and Microphone with
capton tape!
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
11(13)
Page 12
Repair Actions: Additional Repair Info
25
MC3503
Replace if no audio from primary microphone.
Protect the BtB connectors with capton tape!
When replacing protect primary mic with capton tape!
26
MC3504
Replace if no audio from secondary microphone.
Protect the BtB connectors and Flash LED with capton
tape!
When replacing protect secondary mic with capton
tape!
27
R1304
Replace if open circuit. (Phone dead or power off)
Protect the RF connector with capton tape!
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
12(13)
Page 13
4 Revision History
Rev. Date Changes / Comments
1 2014-09-10 Initial release
2 2014-09-12 Added additional Repair Info
1291-5738 Rev 2
Sony Mobile Communications AB – Company Internal
13(13)
Loading...