How it Works
Siemens
Loading...
HDP3L150L

Siemens HFP3L250L, HFP3M250L, HDP3L150L, HFP3H250L, HDP3M150L Operating Instructions Manual

...
Download
s
Motor Circuit Protector, Frame DG, FG
Protector Del Circuito Del Motor, Caja Base DG, FG Protecteur De Circuit De Moteur, de Base DG, FG
U.S. Cat. No. Order No.
item: H.P.L.50.
H.P.M.50.
H.P.H.50.
3VL.5.5 - 2KJ.. - 0AA0 3VL.5.5 - 2KK.. - 0AA0 3VL.5.5 - 2KL.. - 0AA0
Betriebsanleitung Instruções de Serviço
Vor der Installation, dem Betrieb oder der Wartung des Geräts muss diese Anleitung gelesen und verstanden werden.
!
Gefährliche Spannung. Lebensgefahr oder schwere Verletzungsgefahr.
Vor Beginn der Arbeiten Anlage und Gerät spannungsfrei schalten.
Eine sichere Gerätefunktion ist nur mit zertifizierten Komponenten gewährleistet.
Leer y comprender este instructivo antes de la instalación, operación o mantenimiento del equipo.
! !
Tensión peligrosa. Puede causar la muerte o lesiones graves.
Desconectar la alimentación eléctrica antes de trabajar en el equipo.
El funcionamiento seguro del aparato sólo está garantizado con componentes certificados.
İşletme kılavuzu
Instructions de service
Инструкция по эксплуатации
Instructivo
使用说明
Deutsch English Français
Ne pas installer, utiliser ou intervenir sur cet équipement avant d'avoir lu et assimilé les présentes instructions et notamment les conseils de sécurité et mises en garde qui y figurent.
DANGER
!
Tension électrique. Danger de mort ou risque de blessures graves.
Mettre hors tension avant d’intervenir sur l’appareil.
GEFAHR
Read and understand these instructions before installing, operating, or maintaining the equipment.
DANGER
!!
Hazardous voltage. Will cause death or serious injury.
Turn off and lock out all power supplying this device before working on this device.
VORSICHT CAUTION PRUDENCE
Reliable functioning of the equipment is only ensured with certified components.
La sécurité de fonctionnement de l'appareil n'est garantie qu'avec des composants certifiés.
Español Italiano Português
Ler e compreender estas instruções antes da instalação, operação ou manutenção do equipamento.
PERIGO
!
Tensão perigosa. Perigo de morte ou ferimentos graves.
Desligue a alimentação elétrica e proteja contra o religamento, antes de iniciar o trabalho no equipamento.
PELIGRO
Leggere con attenzione queste istruzioni prima di installare, utilizzare o eseguire manutenzione su questa apparecchiatura.
Tensione pericolosa. Può provocare morte o lesioni gravi.
Scollegare l’alimentazione prima di eseguire interventi sull'apparecchiatura.
!
PERICOLO
PRECAUCIÓN CAUTELA CUIDADO
Il funzionamento sicuro dell'apparecchiatura è garantito soltanto con componenti certificati.
O funcionamento seguro do aparelho apenas pode ser garantido se forem utilizados os componentes certificados.
Türkçe Русский 中文
Cihazın kurulumundan, çalıştırılmasından veya bakıma tabi tutulmasından önce, bu kılavuzun okunmuş ve anlaşılmış olması gerekmektedir.
TEHLİKE
! !
Tehlikeli gerilim. Ölüm tehlikesi veya ağır yaralanma tehlikesi.
Çalışmalara başlamadan önce, sistemin ve cihazın gerilim beslemesini kapatınız.
ÖNEMLİ DİKKAT
Cihazıngüvenliçalışması ancak sertifikalı bileşenler kullanılması halinde garanti edilebilir.
GWA 4NEB 179 6957-10 DS 01 Bestell-Nr. / Order No.: 3ZW1012-0VL00-4AA0
Перед установкой, вводом в эксплуатацию или обслуживанием устройства необходимо прочесть и понять данное руководство.
ОПАСНО
!
Опасное напряжение. Опасность для жизни или возможность тяжелых травм.
Перед началом работ отключить подачу питания к установке и к устройству.
ОСТОРОЖНО
Безопасность работы устройства гарантируется только при использовании сертифицированных компонентов.
安装、使用和维修本设备前必须先 阅读并理解本说明。
危险
!
危险电压。 可能导致生命危险或重伤危险。 操作设备时必须确保切断电源。
小心
只有使用经过认证的部件才能 保证设备的正常运转。
Last update: 21 February 2013
NOTE - These instructions do not purport to cover all details or variations in equipment, or to provide for every possible contingency to be met in connection with installation, operation or maintenance. Should further information be desired or should particular problems arise, which are not covered sufficiently for the purchaser’s purposes, the matter should be referred to the local Siemens sales office. The contents of this instruction manual shall not become part of or modify any prior or existing agreement, commitment or relationship. The sales contract contains the entire obligation of Siemens. The warranty contained in the contract between the parties is the sole warranty of Siemens. Any statements contained herein do not create new warranties or modify the existing warranty.
Trademarks - Unless otherwise noted, all names identified by ® are registered trademarks of Siemens AG or Siemens Industry, Inc. The remaining trademarks in this publication may be trademarks whose use by third parties for their own purposes could violate the rights of the owner.
Use only with Siemens certified Components. Utilizar únicamente con componentes certificados de Siemens. A utiliser uniquement avec les composants certifiés Siemens.
DE EN FR ES
IT
TR
中文
Notwendige Werkzeuge für die Montage Necessary assembly tools Outils nécessaires pour le montage Herramientas requeridas para el montaje Utensili necessari per il montaggio Ferramentas necessárias para a montagemPT Montaj için gerekli aletler Инструменты, необходимые для монтажаРУ
安装所需工具
11/32“
[7 mm]
Ø = 0.22“
[Ø = 5.5]
Ø 0.08 … 0.10 x 5.9
[Ø 2 … 2.5 mm x 150 mm]
Cal ISO 6789
5/16“ 5/32“
DE
Lieferumfang
EN
Quantity of delivery
FR
Composition de la fourniture
3VL2515 - 2KL30 - 0AA0 3VL2515 - 2KK30 - 0AA0 3VL2515 - 2KJ30 - 0AA0
M4 x 90 mm
HFP3L250L HFP3M250L HFP3H250L
ES
Alcance del suministro
IT
Configurazione di fornitura
PT
Âmbito do fornecimento
TR
РУ
中文
3VL3525 - 2KL30 - 0AA0 3VL3525 - 2KK30 - 0AA0 3VL3525 - 2KJ30 - 0AA0
M4 x 90 mm
HDP3L150L HDP3M150L HDP3H150L
Teslimat hacmi
Комплект поставки
供货范围
6 x
8 … 32 x
3.38”
6 x
8 … 32 x
3.38”
2 3ZW1012-0VL00-4AA0
Hazardous Voltage.
Hazardous Voltage. Will cause death or serious injury.
Will cause death or serious injury.
Turn off and lock out all power supplying this device before
Turn off and lock out all power supplying this device before working on this device.
working on this device. Replace all covers before power supplying this device is
Replace all covers before power supplying this device is turned on.
turned on.
DG - FG
Trip
[Interrumpir]
Tensión peligrosa.
Tensión peligrosa. Puede causar la muerte o lesiones graves.
Puede causar la muerte o lesiones graves.
Desenergice totalmente antes de instalar o darle servicio.
Desenergice totalmente antes de instalar o darle servicio. Reemplace todas las barreras y cubiertas antes de
Reemplace todas las barreras y cubiertas antes de energizar el interruptor.
energizar el interruptor.
Tension dangereuse.
Tension dangereuse. Danger de mort ou risque de blessures graves.
Danger de mort ou risque de blessures graves.
Couper l'alimentation de l'appareil et barrer avant de
Couper l'alimentation de l'appareil et barrer avant de travailler.
travailler. Remplacez touts les couverts avant que
Remplacez touts les couverts avant que l'approvisionnement de pouvoir soit alimenté.
l'approvisionnement de pouvoir soit alimenté.
2
1
DG
3
“A”
“B”
Wire Connector
[Conexión del cable]
DG (Cu / Al)
TA1DG30 / 3VL9230-4TD01
3TA1DG30 / 3VL9230-
4TD31
3ZW1012-0VL00-4AA0
4 mm
OR
5/32“
Wire Size
[Rango Cable]
Cu / Al
6 … 1 AWG
[16 … 35 mm²]
Cu / Al
1/0 … 3/0 AWG
[50 … 70 mm²]
Req. UL 486A - 486B
Wire Stranding
(Cable)
CU / AL Class B
7 STRANDS
CU
Class C
19 STRANDS
37 STRANDS19 STRANDS
Torque
[esfuerzo de torsión]
“B”
50 lb.in.
[5,5 Nm]
120 lb.in.
[13,5 Nm]
Wire Strip Length
[Quitar]
“A”
0.59”
[15 mm]
3
1
3
FG
2
click
“A”
Wire Connector
[Conexión del cable]
8 mm
OR
5/16“
TAW1FG350 / 3VL9335 - 4TD01
3TAW1FG350 / 3VL9335 - 4TD31
“B”
Wire Size
[Rango Cable]
Cu / Al
4 AWG
Cu / Al
3 … 1 AWG
[25 … 35 mm²]
Cu / Al
1/0 … 4/0 AWG
[70 … 95 mm²]
250 … 350 kcmil
[120 … 150 mm
UL 486A - 486B
Req. Wire Stranding
(Cable)
CU / AL Class B
7 STRANDS
19 STRANDS
2
]
37 STRANDS
CU
Class C
19 STRANDS7 STRANDS
19 STRANDS
37 STRANDS
61 STRANDS
Torque
[esfuerzo de torsión]
“B”
150 lb.in.
[17 Nm]
200 lb.in.
[23 Nm]
275 lb.in.
[31 Nm]
Wire Strip
Length
[Quitar]
“A”
0.87”
[22 mm]
4 3ZW1012-0VL00-4AA0
Hazardous Voltage.
Hazardous Voltage. Will cause death or serious injury.
Will cause death or serious injury.
Turn off and lock out all power supplying this device before
Turn off and lock out all power supplying this device before working on this device.
working on this device. Replace all covers before power supplying this device is
Replace all covers before power supplying this device is turned on.
turned on.
6X Ø.25 [Ø6.3]
Tensión peligrosa.
Tensión peligrosa. Puede causar la muerte o lesiones graves.
Puede causar la muerte o lesiones graves.
Desenergice totalmente antes de instalar o darle servicio.
Desenergice totalmente antes de instalar o darle servicio. Reemplace todas las barreras y cubiertas antes de
Reemplace todas las barreras y cubiertas antes de energizar el interruptor.
energizar el interruptor.
Tension dangereuse.
Tension dangereuse. Danger de mort ou risque de blessures graves.
Danger de mort ou risque de blessures graves.
Couper l'alimentation de l'appareil et barrer avant de
Couper l'alimentation de l'appareil et barrer avant de travailler.
travailler. Remplacez touts les couverts avant que
Remplacez touts les couverts avant que l'approvisionnement de pouvoir soit alimenté.
l'approvisionnement de pouvoir soit alimenté.
DG - FG
(4P)
2 x Ø.22 [Ø 5.5] (2P & 3P)
4 x Ø.22 [Ø.5.5] (4P)
(4P)
(2P, 3P & 4P)
3ZW1012-0VL00-4AA0
.69 [17.5] (2P, 3P & 4P)
5
General information: [Información General:]
U.S. Cat. No.
2 x 8 - 32 x 3.38”
MSKF2 - ( 2 + 3 Pole / Polos )
3VL9300 - 8SB21
4 x 8 - 32 x 3.38”
MSKF4 - ( 4 Pole / Polos )
3VL9300 - 8SB41
19 lb. in. [2.2 Nm]
Euro Order No.
2 x M4 x 90 mm
3VL9300 - 8SA20 - ( 2 + 3 Pole / Polos )
4 x M4 x 90 mm
3VL9300 - 8SA40 - ( 4 Pole / Polos )
8 - 32 UNC
M4
11/32“
[7 mm]
0
5
.
1
[
]
m
m
3
…
”
2
1
.
0
…
6
0
.
6 3ZW1012-0VL00-4AA0
Hazardous Voltage.
Hazardous Voltage. Will cause death or serious injury.
Will cause death or serious injury.
Turn off and lock out all power supplying this device before
Turn off and lock out all power supplying this device before working on this device.
working on this device. Replace all covers before power supplying this device is
Replace all covers before power supplying this device is turned on.
turned on.
Tensión peligrosa.
Tensión peligrosa. Puede causar la muerte o lesiones graves.
Puede causar la muerte o lesiones graves.
Desenergice totalmente antes de instalar o darle servicio.
Desenergice totalmente antes de instalar o darle servicio. Reemplace todas las barreras y cubiertas antes de
Reemplace todas las barreras y cubiertas antes de energizar el interruptor.
energizar el interruptor.
Tension dangereuse.
Tension dangereuse. Danger de mort ou risque de blessures graves.
Danger de mort ou risque de blessures graves.
Couper l'alimentation de l'appareil et barrer avant de
Couper l'alimentation de l'appareil et barrer avant de travailler.
travailler. Remplacez touts les couverts avant que
Remplacez touts les couverts avant que l'approvisionnement de pouvoir soit alimenté.
l'approvisionnement de pouvoir soit alimenté.
DG
EX: HDP3M150. [3VL2515 - 2KK30 - 0AA0]
Motor Full Load Amps
35 - 50 42 - 60 48 - 70 55 - 80 62 - 90 69 - 100 58 - 83 69 - 100 81 - 117 92 - 133
104 - 150
(115 - 150) See Footnote
96 - 139
(115 - 150) See Footnote
(135 - 150) See Footnote
(135 - 150) See Footnote (135 - 150) See Footnote (135 - 150) See Footnote
-67
46 55 - 80 65 - 93 74 - 107 83 - 120 92 - 133 77 - 111
92 - 133 108 - 156 123 - 178 138 - 200 154 - 222 135 - 194 162 - 210 188 - 220 215 - 241
(242 - 250) See Footnote
(242 - 250) See Footnote
-These settings are provided for starting currents greater than 11X but not to exceed 17X.
FG
VL Motor Circuit Protector (MCP)
Trip Switch Setting (A)
450
540 630 720
810 900 750 900
1050 1200 1350 1500 1250 1500
 
1750 2000 2250
2500
600
720
840
960
1080 1200 1000 1200 1400 1600 1800 2000 1750 2100 2450 2800
3150
3500
Full Load Amps ( FLA ) not to exceed ampere rating of MCP.
[3VL2515 - 2KJ.. - 0AA0]
[3VL2515 - 2KK.. - 0AA0]
[3VL2515 - 2KL.. - 0AA0]
[3VL3525 - 2KJ.. - 0AA0]
[3VL3525 - 2KK.. - 0AA0]
[3VL35
EX: HFP3M250. [3VL3525 - 2KL30 - 0AA0]
Catalog Number
HDP.L150.
150 Amp
HDP.M150.
150 Amp
HDP.H150.
150 Amp
HFP.L250.
250 Amp
HFP.M250.
250 Amp
HFP.H250.
25 - 2KL.. - 0AA0]
250 Amp
Technical Support: Internet: http://www.siemens.com/lowvoltage/technical-support
Technische Änderungen vorbehalten. Zum späteren Gebrauch aufbewahren. Subject to change without prior notice. Store for use at a later date.
Bestell-Nr./Order No.: 3ZW1012-0VL00-4AA0
© Siemens AG 2006
Loading...
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use