Sears 200.71991 User Manual
OPERATOR’S MANUAL
®
BATTERY CHARGER
70/40/20/4 Amp
300 AMP
ENGINE STARTER
With Battery Tester
Model No.
200.71991
CAUTION:
Read and follow all Safety
Rules and Operating Instructions
Before Every Use of this Product.
SAVE THESE INSTRUCTIONS.
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
00-99-000882/0808
TABLE OF CONTENTS
SECTION PAGE
1. IMPORTANT SAFETY INSTRUCTIONS 1
2. PERSONAL PRECAUTIONS 2
3. PREPARING TO CHARGE 3
4. CHARGER LOCATION 3
5. DC CONNECTION PRECAUTIONS 3
6. WHEN BATTERY IS INSTALLED IN VEHICLE 4
7. WHEN BATTERY IS OUTSIDE VEHICLE 5
8. BATTERY CHARGING - AC CONNECTIONS 6
9. PRODUCT FEATURES 8
10. ASSEMBLY INSTRUCTIONS 8
11. OPERATING INSTRUCTIONS 10
12. ENGINE START 11
13. CALCULATING CHARGE TIME 12
14. MAINTENANCE INSTRUCTIONS 14
15. STORAGE INSTRUCTIONS 14
16. TROUBLESHOOTING 14
DieHard Three-Year Full Warranty
When operated and maintained according to all supplied instructions,
if this DieHard product fails due to a defect in material or workmanship
within one year from the date of purchase, return it to any Sears store
or other DieHard outlet in the United States for free replacement.
This warranty does not include fuses, which are expendable parts.
This warranty gives you specic legal rights, and you may also have
other rights which vary from state to state.
Sears, Roebuck and Co., Hoffman Estates, IL 60179
FOR CUSTOMER ASSISTANCE OR REPLACEMENT PARTS,
CALL TOLL-FREE FROM 7 AM TO 4:30 PM CT
MONDAY THROUGH FRIDAY: 1-800-SEARS-64 (1-800-732-7764)
IMPORTANT: READ AND SAVE THIS SAFETY AND INSTRUCTION MANUAL.
IMPORTANT SAFETY INSTRUCTIONS1.
SAVE THESE INSTRUCTIONS - The DieHard model 71991 Manual Bat-1.1
tery Charger, offers a wide range of features to accommodate the needs
for home or light commercial use. This manual will show you how to use
your charger safely and effectively. Please read and follow these instructions and precautions carefully as this manual contains important safety
and operating instructions.
Do not expose charger to rain or snow.1.2
Use of an attachment not recommended or sold by the battery charger 1.3
manufacturer may result in a risk of re, electric shock or injury to persons.
To reduce the risk of damage to electric plug or cord, pull by the plug 1.4
rather than the cord when disconnecting the charger.
An extension cord should not be used unless absolutely necessary. Use of 1.5
an improper extension cord could result in a risk of re and electric shock.
If an extension cord must be used, make sure:
That the pins on the plug of the extension cord are the same number, •
size and shape as those of the plug on the charger.
That the extension cord is properly wired and in good electrical condition •
and;
That the wire size is large enough for the AC ampere rating of the charger •
as specied in Table 8.2.
Do not operate the charger with a damaged cord or plug; take it to a quali-1.6
ed serviceman. (Call customer service at: 800-SEARS-64).
Do not operate the charger if it has received a sharp blow, been dropped 1.7
or otherwise damaged in any way; take it to a qualied serviceman. (Call
customer service at: 800-SEARS-64).
DO NOT attempt to repair product yourself. To arrange for product repair, 1.8
or for information about customer replaceable parts, call 1-800-SEARS-64
(1-800-732-7764).
In case of charger malfunction, DO NOT attempt to repair the charger 1.9
yourself. To arrange for charger repair, or for information about customer
replaceable parts, call 1-800-SEARS-64 (1-800-732-7764)
Do not disassemble the charger; take it to a qualied serviceman when 1.10
service or repair is required. Incorrect reassembly may result in a risk of
electric shock or re. (Call customer service at: 800-SEARS-64).
To reduce the risk of electric shock, unplug the charger from the outlet 1.11
before attempting any maintenance or cleaning. Turning off the controls
will not reduce this risk.
WARNING:1.12 Pursuant to California Proposition 65, this product contains
chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.
• 1 •
WARNING – RISK OF EXPLOSIVE GASES.
WORKING IN THE VICINITY OF A LEAD-ACID BATTERY IS DANGEROUS. BATTERIES GENERATE EXPLOSIVE GASES DURING NORMAL BATTERY OPERATION. FOR THIS REASON, IT IS OF UTMOST
IMPORTANCE THAT YOU FOLLOW THE INSTRUCTIONS EACH TIME
YOU USE THE CHARGER.
TO REDUCE THE RISK OF BATTERY EXPLOSION, FOLLOW THESE
INSTRUCTIONS AND THOSE PUBLISHED BY THE BATTERY MANUFACTURER AND THE MANUFACTURER OF ANY EQUIPMENT YOU
INTEND TO USE IN THE VICINITY OF THE BATTERY. REVIEW THE
CAUTIONARY MARKINGS ON THESE PRODUCTS AND ON THE
ENGINE.
PERSONAL PRECAUTIONS2.
Consider having someone close enough by to come to your aid when you 2.1
work near a lead-acid battery.
Have plenty of fresh water and soap nearby in case battery acid contacts 2.2
your skin, clothing or eyes.
Wear complete eye protection and clothing protection. Avoid touching your 2.3
eyes while working near the battery.
If battery acid contacts your skin or clothing, wash immediately with soap 2.4
and water. If acid enters your eye, immediately ood the eye with cold running water for at least 10 minutes and get medical attention immediately.
NEVER smoke or allow a spark or ame in the vicinity of a battery or 2.5
engine.
Be extra cautious to reduce the risk of dropping a metal tool onto the bat-2.6
tery. It might spark or short-circuit the battery or other electrical part that
may cause an explosion.
Remove personal metal items such as rings, bracelets, necklaces and 2.7
watches when working with a lead-acid battery. A lead-acid battery can
produce a short-circuit current high enough to weld a ring or the like to
metal, causing a severe burn.
Use this charger for charging a LEAD-ACID battery only. It is not intended 2.8
to supply power to a low voltage electrical system other than in a startermotor application. Do not use this battery charger for charging dry-cell
batteries that are commonly used with home appliances. These batteries
may burst and cause injury to persons and damage to property.
NEVER charge a frozen battery.2.9
WARNING: 2.10 Pursuant to California Proposition 65, this product contains
chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.
• 2 •
PREPARING TO CHARGE3.
If it is necessary to remove the battery from the vehicle to charge it, al-3.1
ways remove the grounded terminal from the battery rst. Make sure all of
the accessories in the vehicle are off, so as not to cause an arc.
Be sure the area around the battery is well ventilated while the battery is 3.2
being charged.
Clean the battery terminals. Be careful to keep corrosion from coming into 3.3
contact with your eyes.
Add distilled water to each cell until the battery acid reaches the level 3.4
specied by the battery manufacturer. Do not overll. For a battery without
removable cell caps, such as valve regulated lead-acid batteries, carefully
follow the manufacturer’s recharging instructions.
Study all of the battery manufacturer’s specic precautions while charging 3.5
and recommended rates of charge.
Determine the voltage of the battery by referring to the vehicle owner’s 3.6
manual and make sure that the output voltage selector switch is set to the
correct voltage. If the charger has an adjustable charge rate, charge the
battery at the lowest rate rst.
CHARGER LOCATION4.
Locate the charger as far away from the battery as the DC cables permit.4.1
Never place the charger directly above the battery being charged; gases 4.2
from the battery will corrode and damage the charger.
Never allow battery acid to drip onto the charger when reading the electro-4.3
lyte specic gravity or lling the battery.
Do not operate the charger in a closed-in area or restrict the ventilation in 4.4
any way.
Do not set a battery on top of the charger.4.5
DC CONNECTION PRECAUTIONS5.
Connect and disconnect the DC output clips only after setting all of the 5.1
charger switches to the “off” position and removing the AC plug from the
electrical outlet. Never allow the clips to touch each other.
Attach the clips to the battery and chassis, as indicated in steps 6.5, 6.6, 5.2
and 7.2 through 7.4.
• 3 •
Loading...