Sanyo VMC-8314P, VMC-8314PC Service Manual

Page 1

SERVICE MANUAL

Colour Video Monitor

SPECIFICATIONS	2
1. OPERATING INSTRUCTIONS	3
2. SERVICE ADJUSTMENTS	5
3. PARTS LIST	8
CIRCUIT DIAGRAMS (Refer to the separate volume)

PRODUCT SAFETY NOTICE

Product safety should be considered when a component replacement is mand in any area of this unit. Components indicated by the symbol ( A) in the parts list and schematic diagram designate components in which safety can be of special significance. It is particularly recommended that only parts designated on the parts list in this manual be used for component replacement designated by the symbol. No deviations from resistance, wattage or voltage ratings may be made for replacement items designated by the symbol.

NOTE: 1. Parts order must contain model number, part number, and description.

2. Substitute parts may be supplied as the service parts.
3. N.S.P. : Not available as service parts.

Design and specifications are subject to change without notice.

VMC-8314P

(Product Code : 114 950 54) (Europe)

(Product Code : 114 950 56) (U.K.)

(Product Code : 114 950 58) (Australia)

VMC-8314PC (Product Code : 114 950 60) (H.K.)

Page 2

SPECIFICATIONS

Type : Colour video monitor Picture tube : 14" 90° colour. P22 in line aun Colour system : PAL Resolution : 650 TV lines or more (at Y/C input mode) Normal scan : 6 % over scan of picture tube effective screen area Input terminals : Video in BNC connector (x 1), 1.0 V (p-p) composite video signal, 75 ohm Audio in RCA jack (x 1), 400 mV Y/C-separated: 1 line, mini-DIN 4-pin connector (x 1) Y: 1.0 V (p-p), 75 ohm C: 0.3 V (p-p), 75 ohm (bridge connection possible) Outout terminals : Video out BNC connector (x 1), loop-through switch change HI termination Y/C-separated OUT, mini-DIN 4-pin connector (x 1), loop-through Audio out RCA jack (x 1), loop-through Audio power output: 1 W Built-in speaker : x 1, impedance of 8 ohm Power source : AC 100 to 240 V 50/60 Hz Power consumption - 80 Watts Operation temperature : -10 °C to 50 °C (14 °F to 122 °F) Storage temperature : -20 °C to 65 °C (-4 °F to 149 °F) Relative humidity: 10 % to 90 % Dimension (W x D x H ): 350 x 350 x 378 mm

Weight: 14 kg

Page 3

1. OPERATING INSTRUCTIONS 1-1. FRONT PANEL CONTROLS

Fig. 2

1. SPEAKER

2. VOLUME control

For adjustment of audio volume

3. CONTRAST control

For adjustment of picture contrast.

4. BRIGHT control

For adjustment of picture brightness.

5. COLOUR control

For adjustment of colour enhancement.

6. Power switch

Press to turn the monitor on, press again, to turn the power off.

7. Power indicator

To monitor on the indicator lights in green.

Note :

If the timing of display when you are using is not the same s factory or input timing you may need to adjust your monitor.

Page 4

1-2. REAR PANEL CONTROLS & CONNECTION

Fig. 3

1. AC INPUT (inlet) connector

Connect the AC power cord (supplied) to the AC input connector and to a wall outlet.

2. Y/C VIDEO signal input / output switch

Select the input signal either VIDEO (BNC) or Y/C (DIN jack).

3. Y/C IN connector (4-pin mini-DIN)

Connect to the Y/C separate output connector of a video camera, VCR or other video equipment.

4. Y/C OUT connector (4-pin mini-DIN)

Loop-through output of the Y/C in connector. Connector to the Y/C separate input connector of a VCR or another monitor.

5,7. HI/LO impeadance switch

When surveillance by signal monitor please set the impedance switch to 75 ohm, if several monitor connected in series please set impedance switch to 75 ohm for the last monitor and others set to HI position.

6. TRAP filter switch (4.43 MHz)

This switch is used to set the 4.43 MHz TRAP filter function ON/OFF. Set the TRAP filter switch to the ON position to reduce the cross colour noise.

8. VIDEO IN connector (BNC-type)

Connect to the video output connector of a video equipment, such as a VCR or a colour video camera.

9. VIDEO OUT connector (BNC-type)

Loop-through output of the video in connector. Connect to the video input connector for VCR or another monitor.

10. AUDIO IN connector (RCA jack)

Connect to the audio output connector of a VCR or other equipment.

11. AUDIO OUT connector (RCA jack)

Loop-through output of the audio in connector. Connect to the audio input connector of a VCR or another monitor.

ni-DIN) termir	nal specification
Signal
GND(Y)
GND(C)
Y
С
	ni-DIN) termir Signal GND(Y) GND(C) Y C

Page 5

2. SERVICE ADJUSTMENTS

1. Supply power to the set and measuring instruments and allow to warm up for at least 15 minutes.

NOTE

Be sure to use a non-metallic driver for adjusting there VRs. A metallic driver can cause damage by shorting.

ADJUSTMENT ITEM	TIMING PATTERN	SETTING	VR LOCATION	ADJUSTMENT PROCEDURE
ADJUSTMENT B+ VOLTAGE	PATTERN GENERATOR MONOSCOPE PATTERN		VR902	TEST POINT : J45 DIGITAL VOLT METER VALUE 47.0 ± 0.5 VDC.
HORIZONTAL HOLD ADJUSTMENT	NO SIGNAL		VR501	TEST POINT : F.B.T. VALUE 15.40± 0.02 kHz
HORIZONTAL PHASE SIZE and VERTICAL SIZE ADJUSTMENT	PATTERN GENERATOR MONOSCOPE PATTERN		VR502 VR402	Horizontal size is adjusted by means of the horizontal control which is in the PWB. Adjust VR502 until center for eye comfort is obtained. Vertical size is adjusted by means of the vertical control which is in the PWB. Adjust VR402 until center for eye comfort is obtained.
DISTORTION ADJUSTMENT	PATTERN GENERATOR MONOSCOPE PATTERN			Adjust non distotion with move the CRT position.
COLOR CONTROL	PATTERN GENERATOR MONOSCOPE PATTERN	COLOR VR TO MIN.	VR302	TEST POINT : J25 DIGITAL VOLT METER VALUE 2.20 ± 0.05 V
		COLOR VR TO MAX.		TEST POINT : J25 DIGITAL VOLT METER VALUE 3.5 V OVER
		COLOR VR TO CENTER.
CONTRAST CONTROL	PATTERN GENERATOR MONOSCOPE PATTERN	CONTRAST VR TO MIN.	VR504	TEST POINT : J72 DIGITAL VOLT METER VALUE 2.25 ± 0.05 V
		CONTRAST VR TO MAX.		TEST POINT : J72 DIGITAL VOLT METER VALUE 2.8 V OVER
BRIGHTNESS CONTROL	PATTERN GENERATOR MONOSCOPE PATTERN	BRIGHT VR TO MIN.	VR304	TEST POINT : C318 DIGITAL VOLT METER VALUE 0.5 V
		BRIGHT VR TO MAX.		TEST POINT : C318 DIGITAL VOLT METER VALUE 2.5 V OVER
VERTICAL LINEARITY ADJUSTMENT	PATTERN GENERATOR CROSSHATCH PATTERN		VR506	Adjust vertical linearity with the VR506.

Page 6

ADJUSTMENT ITEM	TIMING PATTERN	SETTING	VR LOCATION	ADJUSTMENT PROCEDURE
FOCUS ADJUSTMENT	PATTERN GENERATOR MONOSCOPE PATTERN		FTB FOCUS VR	Adjust the FOCUS VR so that the center and four side lines will be clear and in fine detail.
WHITE BRIGHTNESS				Demarnetize CRT with the demagnetizer.
ADJUSTMENT	PATTERN GENERATOR NO SIGNAL		VR801,VR802, VR803,VR804, VR805	VR801,VR802,VR803,VR804 and VR805 is center position.
			VR801,VR805	Adjust the VR801 and VR805 to dark gray with screen.
	PATTERN GENERATOR FULL-WHITE PATTERN		VR802,VR804	Adjust the VR802 and VR804 to white gray with screen.
	PATTERN GENERATOR COLOR BAR PATTERN			It confirms that a color bar pattern is normal. If a color ber pattern is abnormal, it adjusts one more time.
FULL-WHITE BRIGHTNESS ADJUSTMENT	PATTERN GENERATOR FULL-WHITE PATTERN	CONTRAST VR AND BRIGHT VR TO MAX.	VR503	Adjust the VR503 to screen becomes bright.
COLOR BEAT ADJUSTMENT	PATTERN GENERATOR COLOR BAR PATTERN	COLOR VR TO MAX AND BRIGHT VR TO CENTER.	VR301	Adjust non color beat with the VR506.

Page 7

Fig. 6

Page 8

3. PARTS LIST

LOCAT		PARISNO.	DESCRIPTION	LOCATION	PART SNO .	DESCRIPTION
CAE	BII		CHASSIS PARTS	28 🛆	645 034 4695	AC SOCKET ASS'Y CM-14D
1		645 034 2906	EPONT PANEL CM 14 CDAV 7654	29	645 040 9448	JACK PLATE CH-14VA-P (SANYO)
0	۸	645 034 3090		30	645 034 3605	RH W/W SCR. 3*8 MM
2 '		645 034 4004 645 034 9605		31	645 034 3582	PH W/W SCR. 4*8 MM
3		645 034 3005		32	645 040 9202	VR LABEL CH-14VA-P (SANYO)
4		040 034 3902		33	645 040 9462	VR ASS'Y CM-14PA-N
5		040 034 3933 645 004 0560	PLUMAACOD ON MAA	34	645 034 3650	RUBBER WASHER 6202.5MM BLACK
0		040 004 0000		35	645 034 4701	LED ASS'Y CM-14PA
1		040.034.407.1	SW ASS Y CIVI-14A	36	645 034 3940	CORDS EDGE PROTECOR AMC-1C
0	۸	040 034 3000		37	645 034 3575	PH W/W SCR. 3*8 MM
9 4	~	645 040 9349		38	645 034 4602	FIXED BRACKET CM-14D (N.S.P.)
		040 040 9049 645 004 4506		39	645 035 9415	PCB HOLDER CM-14A (N.S.P.)
10		040 004 4090 645 004 4590		40	645 038 5759	Y/C BOARD CM-14PA/NA (SANYO)
10		040 004 4009 645 004 0500		41	645 038 5582	BRAID WIRE CM-14PA(SANYO)
12		645 034 3399 645 034 4400		42	645 040 9509	VIDEO BOARD CH-14DA
10		040 004 4420 645 004 4610		43	645 034 4305	WIRE CLIPS CH-01K
14		645 034 4019	DU MAN SCD 4*9 MM	44	645 034 4312	PURST LOCK A-11
10		645 034 3302		45	645 034 4268	F.B.T CLIP HV-1
17		645 034 3919		46	645 034 4329	SPACER SUPPORTS TCBS-15
18		645 040 0403		47	645 035 6247	MALAR FILM 120600.5 MM
10		645 034 3575		48	645 038 5629	MALAR FILM 90500.5MM
20		645 034 4640		49	645 034 3940	CORDS EDGE PROTECOR AMC-1C
20		645 034 4040		50	645 034 3940	CORDS EDGE PROTECOR AMC-1C
20		645 034 4235	RASE CM 14 V/C (SANVO) (N S D)	51	645 034 3612	SCREW+WASHER 3*6 MM
22		645 034 3605		52	645 035 9385	SLOT COVER CM-14PA(SANYO)
20		645 034 3575		53	645 040 9332	MALAR FILM 83.5870.5MM (N.S.P.)
24		645 034 4657		54	645 034 4305	WIRE CLIPS CH-01K
26		6/15 03/ 3026		55	645 040 9455	SW ASS'Y CH-14DA(PAL)
27		645 035 6216	BH SCREW A*6MM	56	645 040 9172	PH W/W SCR. 2*4MM
		0-0 000 02 10		57	645 040 9516	MAIN BOARD CH-14VA (PAL)

N.S.P.: Not available as service parts.

Page 9

ELECTRICAL PARTS

Note:

1. Materials of Capacitors and Resistors are abbreviated as follows ; F

Resistors		Capacitors
CF RES	Carbon Film Resistor	MEF CAP	Metallized Polyester Film Capacitor
MF RES	Metal Film Resistor		(Non-inductive)
MOF RES	Metallized Oxide Film Resistor		Mini Box Metallized Polyester Capacitor
			(Non-inductive)
		PEI CAP	Polyester Film Capacitor (Inductive)
		PPN CAP	Polypropylene Film Capacitor (Non-inductive)
		PPS CAP	Polypropylene and Metallized Polypropylene
			Film Capacitor (Non-inductive)
		MPP CAP	Metallized Polypropylene Capacitor
			(Non-inductive)
		X CAP(MKP)	Metallized Polypropylene Film Capacitor
			(Non-inductive)
		CC CAP	Ceramic Capacitor
		EC CAP	Electrolytic Capacitor
			•

2. N.S.P. : Not available as service parts.

LOCATION	N PARTS NO.	DESCRIPTION	LOCATI	ON	PARTS NO.	DESCRIPTION
SW A	SS'Y CM-14A				(BRIDGE DIODE
	645 034 4671		BD901	₪	645 034 3414	BRIDGE DIODE 2FBP06
			C001	٨	(CAPACITORS)	X CAD 1115 2501/ 1/ 109/ 15MM
0.000	(SWITCH)	DOWED OWTON OD 100 7	C901	Â	645 034 3070	X CAP 111E 250V +/-10% 151VIVI
SW901		POWER SWITCH SS-160-7	C902	A	645 034 2585	EC CAP/MINI)15011E 400V +/-20%
	(MISCELLANEU		C905	213	645 034 2974	MEE CAP 111E 630V +/-5% 10MM
	645 034 4084		C907		645 034 2615	FC CAP 100UF 25V T
			C908		645 034 2875	CC CAP 681PF 50V Y5P T
		A(DAL)	C909		645 034 3001	PL CAP .0056UF 100V +/-2% T
SW A			C910		645 034 2837	CC CAP 104PF 50V Y5V T
	645 040 9455		C911		645 034 3018	MEMB CAP .01UF 63V +/-5% T
			C912		645 034 2837	CC CAP 104PF 50V Y5V T
	(SWITCH)		C914	മ	645 034 3087	Y CAP 472PF 400V +/-20%
		3LIDE 3WITCH 33L731207-0000	C917		645 034 2851	CC CAP 271PF 1KV Y5P T
	645 040 9325	I AN HOUSING B&B/1007 24AWG (N S P )	C918		645 040 8946	EC CAP 470UF 100V 105C
	040 040 3020		C921		645 034 2721	EC CAP 2200 UF 35V
			C922		645 034 2721	EC CAP 2200 UF 35V
	SO'V CM-1/D	A-N	C923	•	645 040 8946	EC CAP 470UF 100V 105C
ип А			0925	/\	645 034 3087	Y CAP 4/2PF 400V +/-20%
	040 040 9402		0920	Δ	645 034 3067
	(VARIARI E RES		0929		045 034 3025 (DIODES)	IVIEIVIB CAF .220F 03V +/-3%
VB601	645 034 3445	VB 10K OHM 9DIA D E 15			645 034 3353
VB602	645 034 3438	VB 10K OHM 9DIA, ND F 15	OR		645 040 9141	BECTIFIER DIODE PG102B
VR603	645 034 3445	VR 10K OHM 9DIA. D F 15	D905		645 040 9165	BECTIFIER DIODE 31DE4
VR604	645 034 3445	VR 10K OHM 9DIA. D F 15	D908		645 034 3407	RECTIFIER DIODE HER205
	(MISCELLANEO	US)	D910		645 034 3315	DIODE 1N4148
W601	645 034 4138	L/W HOUSING W&R&B/B&R&B (N.S.P.)	OR		645 034 3308	DIODE 1N4148
			D921		645 034 3384	RECTIFIER DIODE BA159
			OR		645 034 3346	RECTIFIER DIODE BYT52M
LED /	ASS'Y CM-14	PA	ZD901		645 040 9134	ZENER DIODE HZ22-1
	645 034 4701				(FUSE)
			F901	Δ	645 038 5650	FUSE 3.15A/250V SLOWBLOW 5*20
	(LED)		10004
D601	645 034 3421	LED 3DIA.(GREEN)	00		040 034 3094
	(RESISTOR)				645 034 3100
R601	645 034 2363	CF RES 820 OHM 1/4W +/-5%			645 040 9117
			OR OR		645 040 9000	REGULATORIC KA431A7
	645 034 4114		10903		645 034 6231	LINEAR IC 4N35
	645 034 3964		10000		(INDUCTORS)
			L901	≙	645 034 4503	LINE FILTER VS-10S (E-28)
			L904		645 034 4459	CHOCK COIL 100UH +/-20%
~ 0W			L906		645 034 4466	CHOCK COIL 330UH +/-20%
	212 043 040 9493				(SEMICONDUCT	ORS)
		RASES	Q901	≙	645 040 9127	FET SSS7N60A
BOOT	A 645 034 3766	CONNECTOR BASE M241834 (N S P )	OR	Δ	645 034 3278	FET 2SK2545
B902	645 034 3742	CONNECTOR BASE M11383 (N S P )	Q902		645 035 6209	SCR MCR100-6
B903	▲ 645 034 3735	CONNECTOR BASE M241833-X (N.S.P.)	NTOO	~ 4	(RESISTORS)
P901	645 034 3698	CONNECTOR BASE M11352 (N.S.P.)	NIC9	01	645 034 2561	NTCH HES 10 UHM +/-20% 5A
DOOA	045 004 0004		P1C90	JT	045 034 2554	FIGH HES 14 UHM +/-30%

	1
B901	⚠ 645 034 3766	CONNECTOR BASE M241834 (N.S.P.)
B902	645 034 3742	CONNECTOR BASE M11383 (N.S.P.)
B903	⚠ 645 034 3735	CONNECTOR BASE M241833-X (N.S.P.)
P901	645 034 3698	CONNECTOR BASE M11352 (N.S.P.)
P904	645 034 3681	CONNECTOR BASE M241832 (N.S.P.)

Page 10

LOCATIO	N	PARTS NO.	DESCRIPTION
R901	≙	645 034 2301	CF RES 560K OHM 1/2W +/-5%
R902		645 034 2516	MOF RES 47K OHM 3W +/-5% 20MM
R903		645 034 2523	MOF RES 47K OHM 3W +/-5% 5MM
R905		645 034 2547	CEMENT RES 10K OHM 5W +/-5%
R906		645 034 1847	CF RES 10 OHM 1/4W +/-5%
R907		645 034 2257	CF RES 47K OHM 1/4W +/-5%
R908		645 034 2226	CF RES 47 OHM 1/4W +/-5%
R909		645 034 1854	CF RES 1K OHM 1/6W +/-5%
R910		645 034 2493	MOF RES 0.22 OHM 2W +/-5%
R910	≙	645 038 5612	INSULATED TUBE 1DIA. *26MM
R911		645 034 1946	CF RES 13K OHM 1/6W +/-5%
R912		645 034 2226	CF RES 47 OHM 1/4W +/-5%
R913		645 034 2271	CF RES 560 OHM 1/4W +/-5%
R915		645 034 2080	CF RES 240K OHM 1/6W +/-5%
R918		645 034 2387	CF RES 91 OHM 1/4W +/-5%
R919		645 034 1854	CF RES 1K OHM 1/6W +/-5%
R927		645 034 1861	CF RES 1K OHM 1/4W +/-5%
R928		645 034 2226	CF RES 47 OHM 1/4W +/-5%
R930		645 040 8854	MF RES 47K OHM 1/4W +/-1%
R931		645 034 1861	CF RES 1K OHM 1/4W +/-5%
R932		645 034 2240	CF RES 4.7K OHM 1/4W +/-5%
R933		645 034 2103	CF RES 2.7K OHM 1/4W +/-5%
R934		645 034 2042	CF RES 2.2K OHM 1/4W +/-5%
	٨	(TRANSFORMER
T901	∕∆	645 040 9356	POWER TRANS. CH-14DA (EER-39
		(VARIABLE RES	ISTOR)
VH902		645 034 3452	POT VH (METAL) 1K OHM 6DIA
70004	•	(VARISTOR)
ZH901	21	645 038 5391	INH 4/1KD20
	۸	(MISCELLANEO
	Ш	645 034 4404	FUSE CLIP BOARD TYPE 5"20MM (F901)

VIDEO BOARD CH-14DA

645 040 9509

	(CONNECTOR B)	ASES)
60	645 034 3667	CONNECTOR BASE P2351/2 (NISP)
	645 034 3608	CONNECTOR BASE M11352 (N.S.P.)
WRO1	645 034 3773	CONNECTOR BASE M241855 (N.S.P.)
1001	645 034 3750	CONNECTOR BASE M241854-Y (N.S.P.)
W002		CONNECTOR DASE M241034-X (N.S.F.)
C901	645 034 2608	EC CAR 100UE 16V T
C802	645 034 2000
0002	6/5 0/0 9077
0003	645 040 0977 645 040 9077
0004	645 040 0977
0000	645 040 0977
000	045 045 5159	CC CAF TUSEF TKV 250 TUIVIIVI
000
D003	040 034 3377
D004	045 034 3340
D805	045 034 3340	RECTIFIER DIODE BY 152M
D806	645 034 3346	RECTIFIER DIODE BY 152M
D807	645 034 3346	RECTIFIER DIODE BY 152M
D808	645 034 3346	RECTIFIER DIODE BY 152M
D809	645 034 3346	RECTIFIER DIODE BY 152M
0004	(SEMICONDUCT
Q801	645 034 3216	TRANSISTOR 2SC1815GR
OR	645 034 3254	TRANSISTOR 2SC945
Q802	645 034 3230	TRANSISTOR 2SC3417 (SANYO)
OH	645 040 9110	TRANSISTOR 2SC2688L
Q803	645 034 3216	TRANSISTOR 2SC1815GR
OH	645 034 3254	TRANSISTOR 2SC945
Q804	645 034 3230	TRANSISTOR 2SC3417 (SANYO)
OH	645 040 9110	TRANSISTOR 2SC2688L
Q805	645 034 3216	TRANSISTOR 2SC1815GR
OR	645 034 3254	TRANSISTOR 2SC945
Q806	645 034 3230	TRANSISTOR 2SC3417 (SANYO)
OR	645 040 9110	TRANSISTOR 2SC2688L
	(RESISTORS)
R801	645 040 8892	MOF RES 8.2K OHM 3W +/-5%
R802	645 034 2417	MF RES 2.2K OHM 1/2W +/-1%
R803	645 034 2141	CF RES 3.3K OHM 1/4W +/-5%
R804	645 034 2028	CF RES 220 OHM 1/4W +/-5%
R805	645 034 2141	CF RES 3.3K OHM 1/4W +/-5%
R806	645 040 8892	MOF RES 8.2K OHM 3W +/-5%
R807	645 034 2417	MF RES 2.2K OHM 1/2W +/-1%
R808	645 034 2141	CF RES 3.3K OHM 1/4W +/-5%

LOCATION	PARTS NO.	DESCRIPTION
R809	645 040 8816	CF RES 470 OHM 1/4W +/-5%
R810	645 034 2240	CF RES 4.7K OHM 1/4W +/-5%
R811	645 040 8892	MOF RES 8.2K OHM 3W +/-5%
R812	645 034 2417	MF RES 2.2K OHM 1/2W +/-1%
R813	645 034 2141	CF RES 3.3K OHM 1/4W +/-5%
R814	645 034 2028	CF RES 220 OHM 1/4W +/-5%
R815	645 034 2141	CF RES 3.3K OHM 1/4W +/-5%
R816	645 034 2066	CF RES 220K OHM 1/2W +/-5%
	(SPARK GAPS)
SGP801	▲645 038 5520	SPARK GAP DSP 250V +/-20%
SGP802	△645 038 5520	SPARK GAP DSP 250V +/-20%
SGP803	▲645 038 5520	SPARK GAP DSP 250V +/-20%
SGP804	▲645 035 9392	SPARK GAP 0.75PF 1KV +/-10%
SGP805	⚠645 035 9392	SPARK GAP 0.75PF 1KV +/-10%
	(CRT SOCKET)
SK801	645 040 9240	CRT SOCKET HPS3200-010520
		SISTORS)
VR801	645 034 3469	POT VR (METAL) 10K OHM 6DIA
VR802	645 034 3506	POT VR (METAL) 500 OHM 6DIA
VR803	645 034 3469	POT VR (METAL) 10K OHM 6DIA
VR804	645 034 3506	POT VR (METAL) 500 OHM 6DIA
VR805	645 034 3469	POT VR (METAL) 10K OHM 6DIA

MAIN BOARD CH-14VA (PAL) 645 040 9516

	(CONNECTORS	)
C201	645 034 3797	BNC CONNECTOR 13-60-2 75 OHM
C202	645 034 3797	BNC CONNECTOR 13-60-2 75 OHM
401	645 038 5445	CONNECTOR BASE M241856 (N.S.P.)
IND	645 034 3667	CONNECTOR BASE P235142 (N.S.P.)
/301	645 034 3773	CONNECTOR BASE M241855 (N.S.P.)
/303	645 034 3704	CONNECTOR BASE M241853 (N.S.P.)
/304	645 034 3704	CONNECTOR BASE M241853 (N.S.P.)
/501	645 040 9189	CONNECTOR BASE M11386 (N.S.P.)
/502	645 034 3759	CONNECTOR BASE M241854-X (N.S.P.)
/503	645 034 3704	CONNECTOR BASE M241853 (N.S.P.)
1702	645 034 3711	CONNECTOR BASE M241853-X (N S P )
/703	645 034 3704	CONNECTOR BASE M241853 (N S P )
/901	645 034 3728	CONNECTOR BASE M241833 (NISP)
/902	645 034 3674	CONNECTOR BASE M241852 (NISP)
100L	(CADACITORS)	OUNTEOTOT DAGE W241032 (N.S.T.)
201	645 024 2776
201	645 024 2027
202	645 004 2007
207	040 004 2000
200	040 034 2770
302	045 038 5414
303	645 034 2929	PEI CAP .010F 50V +/-5% 1
305	645 034 2882	CC CAP (NPO) 10PF 50V +/-5%
306	645 034 2899	CC CAP (NPO) 121PF 50V +/-5%
308	645 034 2608	EC CAP 100UF 16V
309	645 034 2844	CC CAP 223PF 50V 25V 1
310	645 034 2738	EC CAP 2.2UF 50V T
311	645 034 2738	EC CAP 2.2UF 50V T
313	645 040 8953	CC CAP 103PF 50V Y5P T
315	645 034 3049	MEMB CAP .47UF 63V +/-5% T
316	645 034 3049	MEMB CAP .47UF 63V +/-5% T
317	645 034 3049	MEMB CAP .47UF 63V +/-5% T
318	645 034 2738	EC CAP 2.2UF 50V T
319	645 034 2936	PEI CAP .1UF 50V +/-5% T
320	645 034 2 9 36	PEI CAP .1UF 50V +/-5% T
321	645 034 2738	EC CAP 2.2UF 50V T
322	645 038 5421	MEMB CAP .33UF 50V +/-5% T
323	645 034 2806	EC CAP 4.7UF 50V T
324	645 034 2677	EC CAP 1UF 50V T
325	645 040 8953	CC CAP 103PF 50V Y5P T
401	645 043 3191	CC CAP 271PF 50V Y5P T
402	645 040 9011	PEI CAP .047UF 50V +/-5% T
403	645 040 9028	MEMB CAP .001UF 50V +/-5% T
404	645 034 2790	EC CAP 470UF 35V
405	645 034 2622	EC CAP 100UF 35V
406	645 040 8915	EC CAP (M) 3300 UF 25V +/-20%
407	645 034 2806	EC CAP 4.7UF 50V T
408	645 040 8984	PEI CAP .001UF 50V +/-5% T
501	645 034 2943	PEI CAP .15UF 50V +/-5% T
502	645 034 2905	CC CAP (NPO) 151PF 50V +/-5%
503	645 034 2738	EC CAP 2.2UF 50V T

Page 11

LOCATION	PARTS NO.	DESCRIPTION	LOCATION	PARTS NO.	DESCRIPTION
C504	645 034 2684	EC CAP 22UF 16V T	R202	645 034 2028	CF RES 220 OHM 1/4W +/-5%
C505	645 040 9004	PEI CAP .039UF 50V +/-5% T	R203	645 034 1892	CF RES 100K OHM 1/4W +/-5%
C506	645 034 2592	EC CAP 10UF 16V T	R204	645 034 1991	CF RES 150K OHM 1/4W +/-5%
C507	645 034 2677	EC CAP 1UF 50V T	R205	645 034 1977	CF RES 1.5K OHM 1/4W +/-5%
C508	645 034 2738	EC CAP 2.2UF 50V T	R223	645 034 1861	CF RES 1K OHM 1/4W +/-5%
C509	645 034 2981	PPN CAP .0027UF 50V +/-5% T	H301	645 043 3177	CF RES /50 OHM 1/4W +/-5%
C510	645 034 2943	PEI CAP .15UF 50V +/-5% I	R306	645 043 3160	CF RES 1.3 KOHM 1/4W +/-5%
C511	645 034 2950	PELCAP .0220F 50V +/-5% T	H30/	645 038 5340
C512	645 040 8991	PEI CAP .0330F 50V +/-5% 1	FU D211	645 034 2020
0513	645 034 2691		D310	645 034 2028	CF RES 220 OHM 1/4W +/-5%
0514	645 040 9042 645 040 0050		R316	645 034 1878	CE BES 10K OHM 1/4W +/-5%
C516	645 034 2837	CC CAP 104PE 50V Y5V T	B317	645 034 2134	CE BES 330 OHM 1/4W +/-5%
C517	645 034 2738	EC CAP 2.2UE 50V T	R318	645 034 2059	CF RES 22K OHM 1/4W +/-5%
C518	645 034 2752	EC CAP 33UF 16V T	R320	645 034 2400	MF RES 20K OHM 1/4W +/-1%
C519	645 040 8939	EC CAP 47UF 100V	R321	645 034 1861	CF RES 1K OHM 1/4W +/-5%
C520	645 034 2998	PPN CAP .047 UF 250V +/-5%	R322	645 034 2400	MF RES 20K OHM 1/4W +/-1%
C523	645 034 2707	EC CAP 22UF 250V	R323	645 034 2110	CF RES 27K OHM 1/4W +/-5%
C524	645 040 9035	PPS CAP .0022UF 1KV +/-5%	R324	645 034 2004	CF RES 2K OHM 1/4W +/-5%
C525	645 034 2677	EC CAP 1UF 50V T	H326	645 034 2240	CF RES 4.7K OHM 1/4W +/-5%
C528	645 034 2783		H328	645 034 2165	CF RES 390 OHM 1/4W +/-5%
0529	645 034 2608		F1329	645 034 2103 645 034 1979
0530	645 034 2837 645 044 2605		D334	645 034 1878	CE RES 10K OHM 1/4W 4/-5%
C533	645 044 3095		R336	645 034 1878	CE RES 10K OHM 1/4W +/-5%
0532	645 034 2738	EC CAP 2 2/1F 50V T	B340	645 034 1878	CF RES 10K OHM 1/4W +/-5%
C534	645 034 3025	MEMB CAP. 22UE 63V +/-5% T	R341	645 034 1908	CF RES 11K OHM 1/4W +/-5%
C701	645 034 3049	MEMB CAP .47UF 63V +/-5% T	R342	645 034 2059	CF RES 22K OHM 1/4W +/-5%
C702	645 034 2837	CC CAP 104PF 50V Y5V T	R343	645 034 2059	CF RES 22K OHM 1/4W +/-5%
C703	645 034 2653	EC CAP 1000 UF 16V 10DIA.	R344	645 034 2073	CF RES 2.4K OHM 1/4W +/-5%
C915	645 040 8946	EC CAP 100UF 100V 105C	R401	645 034 2202	CF RES 4.3K OHM 1/4W +/-5%
C916	645 034 2660	EC CAP 1000 UF 35V	R402	645 034 2202	CF RES 4.3K OHM 1/4W +/-5%
C919	645 034 2653	EC CAP 1000 UF 16V 10DIA.	R403	645 034 2486	MOF RES 1.5 OHM 1W +/-5%
C920	645 034 2660	EC CAP 1000 UF 35V	H404	645 034 22/1	CF RES 560 OHM 1/4W +/-5%
C924	645 034 2837		H405	645 043 3164	CE DES 150K OHM 1/2W +/-5%
D401	645 034 3377 645 034 3352		R400 R407	645 034 2134	CE RES 330 OHM 1/2W +/-5%
D503	645 034 3333	RECTIFIER DIODE 10002	R407	645 040 8724	CE RES 1 OHM 1/2W +/-5%
D503	645 034 3360	RECTIFIER DIODE 10BB4	R408	645 034 2097	CF RFS 270 OHM 1/2W +/-5%
D504	645 040 9158	RECTIFIER DIODE PG104	R409	645 034 2219	CF RES 43K OHM 1/4W +/-5%
D505	645 034 3353	RECTIFIER DIODE 10BB2	R410	645 034 2172	CF RES 3.9K OHM 1/4W +/-5%
D505	645 040 9141	RECTIFIER DIODE PG102	R411	645 040 8885	MOF RES 0.68 OHM 2W +/-5%
D506	645 034 3353	RECTIFIER DIODE 10BB2	R412	645 040 8793	CF RES 240K OHM 1/4W +/-5%
D506	645 040 9141	RECTIFIER DIODE PG102	R501	645 034 2172	CF RES 3.9K OHM 1/4W +/-5%
D507	645 034 3315	RECTIFIER DIODE 1N4148	R501	645 034 1922	CF RES 12K OHM 1/4W +/-5%
D507	645 034 3308	RECTIFIER DIODE 1N4148	R502	645 034 2325
ZD501	645 034 3322		H503	645 034 2141
	645 034 3313		R505	645 034 2363	CE BES 820 OHM 1/4W +/-5%
Un			R506	645 034 2288	CE BES 5.6K OHM 1/4W +/-5%
DL301	645 043 3207	DELAY LINE 72A446-9	R507	645 034 2011	CF RES 22 OHM 1/4W +/-5%
DL302	645 034 4527	DELAY LINE PDL-644KIP	R508	645 034 1915	CF RES 1.2K OHM 1/4W +/-5%
	(INTEGRATED	CIRCUITS)	R509	645 034 2127	CF RES 30K OHM 1/4W +/-5%
IC301	645 034 3155	LINEAR IC TDA3566A	R510	645 034 1922	CF RES 12K OHM 1/4W +/-5%
IC401	645 034 3148	LINEAR IC TDA3653B	R511	645 034 2035	CF RES 220 OHM 1/2W +/-5%
IC501	645 034 3131	LINEAR IC TDA2579B	R513	645 034 2141	CF RES 3.3K OHM 1/4W +/-5%
IC701	645 034 3124	LINEAR IG TDA/056B	H514	645 034 2189
10904	645 034 3186	REGULATOR IC MC/81201	HO IO DE 16	040 040 07 17 645 024 0190
1 201	(INDUCTORS)		R516	645 034 2189	CE RES 39K OHM 1/4W 4/-5%
1302	645 034 4442		B518	645 040 8908	CEMEMT BES 51 OHM 5W +/-5%
1303	645 034 4435	INDUCTANCE 101H +/-2%	B519	645 034 2479	MOF BES 150 OHM 1W +/-5%
OR	645 040 9394	INDUCTANCE 10UH +/-6%	R521	645 040 8731	CF RES 15K OHM 1/2W +/-5%
L501	645 040 9400	LINEARITY COIL 18UH +/-20%	R523	645 034 1861	CF RES 1K OHM 1/4W +/-5%
L902	645 034 4473	CHOCK COIL 47UH +/-20%	R526	645 038 5377	MOF RES 30 OHM 3W +/-5%
	(SEMICONDUC	TORS)	R527	645 040 8878	MOF RES 3.3 OHM 2W +/-5%
Q201	645 034 3216	TRANSISTOR 2SC1815GR	R528	645 034 2394	MF RES 10K OHM 1/4W +/-1%
OR	645 034 3254	TRANSISTOR 2SC945	H529	645 034 2424	MF RES 33K OHM 1/4W +/-1%
Q205	045 034 3216		H030	040 038 5360	OF NEO YIU OHIVI 1/4VV +/-5% ME RES 13K OHM 1/4VV +/-5%
Q205	040 034 3254		DOGO REGI	040 030 0193 645 044 2699
0502	040 040 9103 645 034 3103	TRANSISTOR 2003280 (OANTU) TRANSISTOR 294673 (HITACHI) T	B53/	645 038 5353	CE BES 1 8K OHM 1/4W +/-5%
Q504	645 034 3254	TRANSISTOR 2SC945 (NFC) T	R535	645 034 1892	CF RES 100K OHM 1/4W +/-5%
OR	645 040 9097	TRANSISTOR 2SC1815Y TOSHIBA	R536	645 040 8779	CF RES 20K OHM 1/4W +/-5%
Q505	645 034 3209	TRANSISTOR 2SA733P (NEC) T	R537	645 040 8755	CF RES 16K OHM 1/4W +/-5%
Q507	645 034 3216	TRANSISTOR 2SC1815GR TÓSHIBA	R538	645 040 8762	CF RES 180 OHM 1/2W +/-5%
Q508	645 034 3247	TRANSISTOR 2SC4489 (SANYO)	R539	645 034 1953	CF RES 13K OHM 1/4W +/-5%
	(RESISTORS)		R539	645 040 8830	CF RES 91K OHM 1/4W +/-5%
R201	645 034 2356	CF HES 75 OHM 1/4W +/-5%	H540	645 040 8809	OF RES 33K OHM 1/4W +/-5%

Page 12

LOCATION	PARIS NO.	DESCRIPTION
R542	645 034 1861	CF RES 1K OHM 1/4W +/-5%
R543	645 040 8861	MOF RES 110 OHM 3W +/-5%
R544	645 034 1922	CF RES 12K OHM 1/4W +/-5%
R545	645 040 8809	CF RES 33K OHM 1/4W +/-5%
R547	645 040 8786	CF RES 220K OHM 1/4W +/-5%
R701	645 034 2165	CF RES 390 OHM 1/4W +/-5%
R704	645 034 2325	CF RES 6.8K OHM 1/4W +/-5%
R706	645 034 2370	CF RES 82K OHM 1/4W +/-5%
R707	645 034 1861	CF RES 1K OHM 1/4W +/-5%
R924	645 034 2448	MOF RES 10 OHM 3W +/-5%
	(JACK)
RJ701	645 034 3803	RCA JACK MPJ-02-A
	(SWITCH)
SW201	645 034 3827	SLIDE SWITCH SSP711210-34FH1
	(TRANSFORME	RS)
T501	645 034 4374	DRIVE TRANS. CM-14A (EI-19)
T502 🛆	645 040 9363	FBT TRANS. CH-14DA
T503	645 040 9370	PIN TRANS. CH-14DA
	(TRAP)
TR301	645 043 3214	TRAP 4.43MHZ
	(VARIABLE RES	BISTORS)
VR301	645 034 3452	POT VR (METAL) 1K OHM 6DIA
VR302	645 034 3483	POT VR (METAL) 100K OHM 6DIA
VR304	645 034 3490	POT VR (METAL) 250K OHM 6DIA
VR401	645 034 3490	POT VR (METAL) 250K OHM 6DIA
VR402	645 034 3452	POT VR (METAL) 1K OHM 6DIA
VR501	645 034 3476	POT VR (METAL) 10K OHM 6DIA
VR502	645 034 3520	POT VR (METAL) 50K OHM 6DIA
VR503	645 034 3483	POT VR (METAL) 100K OHM 6DIA
VR504	645 034 3513	POT VR 5K OHM 6DIA L TYPE
VR506	645 034 3513	POT VR 5K OHM 6DIA L TYPE
	(OSC)
X302	645 034 2578	OSCILLATOR 8.86MHZ
	(MISCELLANEO	US)
	645 038 5544	L/W HOUSING B&B&R/1015 22AWG (N.S.P.)
	645 038 5551	L/W HOUSING B&G&H&B&O/1015 22 (N.S.P.)

LOCATION PARTS NO. DESCRIPTION

ACCESSORIES AND PACKING MATERIALS

	645 040 9233	USER MANUAL CH-14VA—P (SANYO)
⚠	645 034 3971	POWER CORD 10-1 VDE
		(VMC-8314P EUROPE ONLY)
⚠	645 040 9257	POWER CORD 10-1 VDE
		(VMC-8314P AUSTRALIA ONLY)
∕∆	645 040 9264	POWER CORD 10-1 VDE
	53	(VMC-8314P U.K. ONLY)
⚠	645 043 3146	POWER CORD 10-1 VDÉ (VMC-8314PC ONLY)
	645 035 6254	PE BAG 15 INCHES 16"16"32"
	645 034 4336	POLYFORM CM-14A
	645 040 9219	CARTON CH-14VA-P (EXCEPT VMC-8314PC)
	645 043 3146	CARTON CH-14VA-P (VMC-8314PC ONLY)

Y/C BOARD CM-14PA/NA

645 038 5759

(C.	ΔP	Δ(	ЗT	Ô۴	25
•••		~``		~


C601	645 034 2776	EC CAP 47UF 16V T
C602	645 034 2776	EC CAP 47UF 16V T
	(SOCKET)	x
DJ601	645 034 3995	DIN SOCKET DJ-024
	(SEMICONDUCTORS)
Q601	645 034 3254	TRÁNSISTOR 2SC945
OR	645 034 3216	TRANSISTOR 2SC1815GR
Q602	645 034 3254	TRANSISTOR 2SC945
OR	645 034 3216	TRANSISTOR 2SC1815GR
	(RESISTORS)
R601	645 034 2349 ^°	CF RES 75 OHM 1/6W +/-5%
R602	645 034 2349	CF RES 75 OHM 1/6W +/-5%
R603	645 034 2332	CF RES 68K OHM 1/6W +/-5%
R604	645 034 1885	CF RES 100K OHM 1/6W +/-5%
R605	645 034 1885	CF RES 100K OHM 1/6W +/-5%
R606	645 034 1885	CF RES 100K OHM 1/6W +/-5%
R607	645 034 1960	CF RES 1.5K OHM 1/6W +/-5%
R608	645 034 1960	CF RES 1.5K OHM 1/6W +/-5%
	(SWITCHES)
SW601	645 034 3834	SLIDE SWITCH SAP712210-35FH1
SW602	645 034 3834	SLIDE SWITCH SAP712210-35FH1
(MISCELLANEOUS)
	è45 035 6230	L/W HOUSING 1007 /1185 (N.S.P.)

SANYO Electric Co.,Ltd. Osaka, Japan

Page 13

VMC-8314P VMC-8314PC

BLOCK DIAGRAM, CIRCUIT DIAGRAMS & PRINTED WIRING BOARDS

TABLE OF CONTENTS

1. BLOCK DIAGRAM OVERALL BLOCK	1
2. CIRCUIT DIAGRAMS AND PRINTED WIRING BOARDS (P.W.B.)
POWER BOARD POWER SUPPLY	2
POWER P.W.B.	3
VIDEO BOARD CRT SOCKET AND AUDIO AMP	4
VIDEO P.W.B.	4
MAIN BOARD VIDEO DECODER	5
	6
MAIN P W.B.	7

Page

Page 14

PRODUCT SAFETY NOTICE

THE COMPONENTS DESIGNATED BY A SYMBOL ( A) IN THIS SCHEMATIC DIAGRAM DESIGNATES COMPONENTS WHOSE VALUE ARE OF SPECIAL SIGNIFICANCE TO PROD-UCT SAFETY.

SHOULD ANY COMPONENT DESIGNATED BY A SYMBOL NEED TO BE REPLACED, USE ONLY THE PART DESIG-NATED IN THE PARTS LIST.

DO NOT DEVIATE FROM THE RESISTANCE, WATTAGE AND VOLTAGE RATINGS SHOWN.

1. NOTE FOR REPAIRING SERVICE

(1)Do not touch the LIVE side GND or the LIVE side GND and the ISOLATED side GND simultaneously. If the above caution is not respected ,an electric shock may be caused. Therefore, make sure that the power cord is surely removed from the receptacle when, for example, the chassis is pulled out.

(2)Do not short between the LIVE side GND and ISOLATED side GND or never measure with measuring apparatus the LIVE side GND and ISOLATED side GND at the same time. If the above precaution is not respected, a fuse or any parts will be broken.

2. NOTE FOR CIRCUIT DIAGRAMS

(1)Due to part number standardization, some part numbers shown in the circuit diagram may not agree with those indicated the parts list. When ordering parts, please use the numbers that appear in the parts List.

(2) The character 'U' or 'u' may be used as the character 'u'.

Page 15