Sanyo CE 25MT2A-C Service Manual

Part No. SKSM0299 F4ATV NOVEMBER 1998

Colour Television Service Manual

Give complete "SERVICE REF.NO." for parts order or servicing, it is shown on the rating sheet on the cabinet back of the TV set.

Note This TV receiver will not work properly in foreign countries where the television transmission system and power source differ from the design specifications. Refer to the specifications for the design specifications

Model: CE25MT2A-C(W.EUROPE)

Service Ref. No. CE25MT2A-C-01

PRODUCTCODE: 111327415 ORIGINALVERSION: Chassis No. EC5-A

CE25MT2A-C

Power Source AC220~240V 50Hz Television System System BG, DK Colour System PAL/SECAM Receiving Channels VHF : E2~E12, R1~R2, R12

CATV : X,Y,Z,S1~S41

UHF : 21~69 Aerial input impedance 75ohm AV Terminal 21 pin Terminal AV1: CENELEC Standard Speaker 8 ohm, 5 x 9 cm Sound output 5 watts Picture tube 63 cm diagonal, 90° Visible picture 59 cm (diagonal) Dimensions (W x H xD) 584 x 533.5 x 446.6 mm Weight 24.5 kg

Page

Safety precautions....................................................2

Block diagram

Main signal routing................................................3

Power signal routing.............................................4

Circuit description...............................................5 ~ 6

Service control adjustments...............................7 ~ 8

Circuit alignment.......................................................9

Memory IC replacement.........................................10

Special functions.....................................................11

Cabinet parts list.....................................................12

Chassis electrical parts list.............................13 ~ 20

Schematic Diagram...........................................loose

Specifications

Contents

-2-

Service Manual-EC5 Chassis

SAFETY PRECAUTION

X-RADIATION PRECAUTION

The primary source of X-RADIA TION in the television receiver is the picture tube. The picture tube is specially constructed to limit X-RADIATION emissions. For continued X-RADIATION protection, the replacement tube must be the same type as the original including suffix letter. Excessive high voltage may produce potentially hazardous XRADIATION. To avoid such hazards, the high voltage must be maintained within specified limit. Refer to this service manual, high voltage adjustment for specific high voltage limit. If high voltage exceeds specified limits, take necessary corrective action. Carefully follow the instructions for +B1 volt power supply adjustment, and high voltage adjustment to maintain the high voltage within the specified limits.

PRODUCT SAFETY NOTICE

Product safety should be considered when a component replacement is made in any area of a receiver. Components indicated by mark in the parts list and the schematic diagram designate components in which safety can be of special significance. It is particularly recommended that only parts designated on the parts list in this manual be used for component replacement designated by mark . No deviations from resistance wattage or voltage ratings may be made for replacement items designated by mark .

!!!

1: An isolation transformer should be connected in the

power line between the receiver and the AC line when a service is performed on the primary of the converter transformer of the set.

2: Comply with all caution and safety-related notes pro-

vided on the cabinet back, inside the cabinet, on the chassis or the picture tube.

3: When replacing a chassis in the cabinet, always be

certain that all the protective devices are installed properly, such as, control knobs, adjustment covers or shields, barriers, isolation resistor-capacitor networks etc.Before returning any television to the customer, the service technician must be sure that it is completely safe to operate without danger of electrical shock.

-3-

Service Manual-EC5 Chassis

BLOCK DIAGRAM (Main signal routing)

This is a diagram for all models and therefore differs slightly from the actual block diagram.

+150V

+24V

+18V

+15V

TU

VL

VH

U

IF

Q801

Q101/Q102

Q103/Q104

Q105/Q106

Tuner

Key scan

10 Scan

1 Tu

51 VL

52 VH

3 U

8 Standby

SCL 49

SDA 50

BLK 35

R 34

G 33

B 32

Sharp 3

Bright 6

Cont 5

Colour 4

TV/AV 14

6 SCL

5 SDA

46

45

22 R

23 G

24 B

21 BLK

14 Sharp

17 Bright

25 Cont

26 Colour

Volume 7

13 TV/AV

30 R-Y

31 B-Y

29 R-Y

28 B-Y

30 R-Y

31 B-Y

29 R-Y

28 B-Y

50 Sound

R out 18

G out 19

B out 20

CVBS out 7

SIF in 5

Int.video 13

Ext.video 15

Ext.audio 6

Audio out 1

H out

37

41

43

V-F/B

V out

4

2

42

8

R-out Q711

G-out Q721

B-out Q701

IC501 V-out

H-out circuit

Q431 Q432

V-control

circuit

Deflection

Yoke

T471 Flyback Trans.

High Voltage

Q151

X151

X161

Q161

Q154

Q241

SCART

19

20

2, 6

1, 3

Video out

Video in

Audio in

Audio out

Q1032/Q1031

IC801 CPU IC201

IF/video/chroma/def.

IC802 Memory

X131

SAW

IC271

1H delay

IC001

Audio out

Power

control

circuit

T611

converter trans.

AC

in

Q839

Power supply circuit

CRT Unit

-4-

Service Manual-EC5 Chassis

BLOCK DIAGRAM (Power supply routing)

D634

+15V

+5V

+18V

+24V

1

3

1

3

IC691

IC661

Q661

Q651

+9V

+8V

control

circuit

Q611,

Q612

Power

switching

Q613

C607

D601~D604

T611

converter trans.

AC in

IC801

CPU

IC802

Memory

A1901

RC Pre-amp

A101

Tuner

IC271

1H delay

IC001

Audio out

Speaker

CRT Unit

T471

FBT

Horizontal

Drive circuit

IC501

V-out

IC201

IF/video/chroma/def.

44

8

3

MB

10

36

9

19

8

62

2

V.deflection

+5V

+9V

+5V

+8V

+18V

+9V

+180V

+150V

+24V

Power supply circuit

Standby signal from CPU pin 8

+150V

-5-

Service Manual-EC5 Chassis

1. POWER SUPPLY

The power supply circuit of the EC5-A chassis is composed of a rectifier smoothing circuit, an oscillation circuit, a control circuit and an output rectifier circuit. The AC input voltage is full-wave rectified by the rectifier smoothing circuit, and an unstable DC voltage is generated at both terminals of the smoothing capacitor C607. This voltage is input to the oscillation circuit. The oscillation circuit is provided with a blocking oscillator circuit that switches the switching transistor Q613 ON and OFF, and an oscillation frequency and a duty square wave pulse are generated in the input windings according to operation of the control circuit. Asquare-wave pulse whose size is dependent on the turn ratio of the input and output windings is obtained in the output winding. This is rectified in the output rectifier circuit, and the desired DC voltage is obtained.

2. IF & DEFLECTION (TDA8361)

The IF output signal from the tuner passes through the SAW filter, and it is input to pin45 and pin46 of IC201. The signal input to the IC passes through the IF amplifier, video detection and video amplifier circuits and is output from pin7 as a composite video signal. And after this signal is converted to impedance at Q151, supplies to the video and chroma amplifier stages. The sync.-separation circuit separates the video signals applied to pin13(internal video signal) or pin15(external video signal) to vertical- and horizontal-sync. signals respectively . The horizontal oscillator requires no external components and is fully integrated. The oscillator is always running when the start-pin36 is supplied with 8V. Horizontal drive signal is output from pin37. VR361 is for adjustment of the horizontal centring. The separated vertical-sync. signal from sync. separation circuit passes through the vertical-separation circuit, and applied to trigger divider circuit. The horizontal oscillation pulse and input vertical sync. pulse are monitored by the trigger divider circuit, and switching 50Hz and 60Hz system, the vertical amplitude automatically adjusted for 50Hz and 60Hz. The output signal from the trigger divider is triggered vertical oscillation circuit consisting of C351, R356 and pin42, and vertical drive pulse is output from pin43. VR501 is for changing the amount of AC feedback applied to pin41 and for adjustment of the vertical amplitude.

3. VIDEO CHROMA & R.G.B. (TDA8361)

The composite video signal output from the pin7 of IC201 passes through Q151-Q154, and it is supplied to pin13. The external video signal output from SCART is supplied to pin15. The video signal input to pin13 or pin15 is separated to luminance (Y) signal and chroma signal in IC201. These pins are used in common with H/V-sync. separation input. The peaking of Y signal is adjusted by DC voltage of pin14. (“SHARPNESS” control) The chroma signal is divided into R-Y and B-Y chroma signals, demodulated

in IC201, and output from pin30 (R-Y) and pin31 (B-Y). These chroma signals pass through the 1H delay line circuit (IC271), and they are input to pin29 (R-Y) and pin28 (B-Y). These R-Y/B-Y signals pass through RGB matrix circuit and RGB selector circuit of IC201. The internal RGB signals are generated in RGB matrix circuit and the RGB selector, consisting linear amplifiers, clamps and selects either the internal RGB signals or the external RGB signals input from pin22(R), pin23(G), pin24(B). Selection is controlled by the voltage at the RGB switch control (pin21) and mixed RGB modes are possible since RGB switching is fast. The RGB switch also functions as a fast blanking pin by blanking the RGB output stages; here internal and external RGB signals are overruled. The colour gain is controlled by DC voltage of pin26. (“COLOUR” control) The contrast control voltage present at pin25, and the brightness control voltage present at pin17 controls DC level of RGB signals. The RGB signals are finally buffered before being available at the RGB output pins [pin20 (R), pin19 (G), pin18 (R)].

4. AUDIO OUTPUT(AN5265)

The audio signal output from pin52 of IC201 is input to pin2 of IC001 and passes through the pre-amplifier circuit and drive circuit, after which it is input to the audio amplifier. The audio amplifier is an SEPP (single-ended, pushpull) OTL type and output to pin8 to directly drive the speaker.

5. VERTICAL OUTPUT (LA7832/LA7833)

An IC (LA7832/LA7833) is used for the vertical output circuit in this chassis. The vertical drive pulse from pin43 of IC201 is input to pin4 of IC501. This pulse drives IC501, and vertical scanning is performed. In the first half of scanning a deflecting current is output from pin2 and passes through the following path: Vcc(B4) ➞ D501 ➞ pin3 ➞ pin2 ➞ DY ➞ C512 ➞ VR501/R509. An electric charge is then stored in C512. In the last half of scanning the current path is C512 ➞ DY ➞ pin2 ➞ pin1 ➞ VR501/R509 ➞ C512. In this way, an amplifying sawtooth waveform current flows directly to DY to perform electron beam defection. Next, in the first half of the banking period the vertical drive pulse suddenly becomes OFF, and in order to reduce the current flowing to DY, the current path becomes as follows by the inductance of DY: DY ➞ pin2 ➞ pin1 ➞ VR501/R509 ➞ C512 ➞ DY. Also, when the charge of DY has dissipated, the current path becomes Vcc24V ➞ pin6 ➞ pin7 ➞ C502 ➞ pin3 ➞ pin2➞ DY ➞ C512 ➞ VR501/R509, and when the prescribed current value is reached, the vertical drive pulse becomes ON. This completes one cycle.

CIRCUIT DESCRIPTION

-6-

Service Manual-EC5 Chassis

6. HORIZONTAL OUTPUT

A horizontal oscillation signal is output from pin37 of IC201 and switches the drive transistor Q431. This switching signal is current amplified by the drive transformer T431 and drives the output transistor Q432. When Q432 becomes ON, an amplifying current flows directly to DY through C441/C442 ➞ DY ➞ Q432 ➞ GND, and defection is performed in the last half of the scanning period. Next, when Q432 becomes OFF, the charge that had been stored in DY up to that point releases a resonance current to the resonant capacitors C421/C423 and charges them. The current stored in C421/C423 is then flowed back to DY, and an opposite charge is then stored in DY. This opposite charge then switches the dumper diode in Q432 ON, the resonance state is completed, and an amplifying current is then flowed again directly to DY through the dumper diode. By this means, deflection in the first half of the scanning period is performed, and when Q432 becomes ON at the end of the first half of the scanning period, deflection during the last half is begun, thus completing one cycle.

In the PCC circuit consisting of Q461 and Q462, the parabola signal supplied from the vertical circuit is added at the horizontal output stage and pincushion compensation is performed by varying the DC voltage bias. Further, the ABL voltage is feedback to the base of Q462 to compensate for width variations due to variations in the beam current.

7. CPU <System and Teletext Control> Pin description Pin1: Tuning voltage output Pin2: Band switch output 3 (UHF) Pin3: Sharpness control output (6-bit DAC) Pin4: Colour control output (6-bit DAC) Pin5: Contrast control output(6-bit DAC) Pin6: Brightness control output(6-bit DAC) Pin7: Volume control output(6-bit DAC) Pin8: Power ON/OFF output (Power-On:Lo) Pin9: AFT signal input Pin10: Option SW1&Keyboard scan input (DC) Pin11: Option SW2 Pin12: 50/60Hz switch input (50Hz: Hi) Pin13: GND Pin14: TV/AV switch output (TV: Hi) Pin15: 5.5/6.5 switch output Pin16: Nega./posi switch output Pin17: Function signal input for SCART Pin18: L switch output Pin19: L’ switch output Pin20: LED drive Pin21: Ignore output Pin22: GND Pin23: CVBS input0 (Internal) Pin24: CVBS input1 (Internal/External)

Pin25: Black Pin26: IREF Pin27: Odd/Even output Pin28: GND Pin29: Pin30: V-deflection stop output(Stop:Lo) Pin31: RGB REF Pin32: Blue output for OSD Pin33: Green output for OSD Pin34: Red output for OSD Pin35: Blanking output for OSD Pin36: H-sync. input (Horizontal pulse for OSD) Pin37: V-sync. input (Vertical pulse for OSD) Pin38~39: Supply (+5V) Pin40: OSC GND Pin41: Oscillator input for CPU Pin42: Oscillator output for CPU Pin43: Reset input Pin44: Supply (+5V) Pin45: Protect signal input (L:Power circuit defects) Pin46: Ident. signal input Pin47: R/C signal input Pin48: Mute output in no picture Pin49: I2C bus SCL (Serial clock) Pin50: I2C bus SDA (Serial date) Pin51: Option SW5 & Band switch output1 Pin52: Band switch output2

-7-

Service Manual-EC5 Chassis

SW601

F601 Fuse

D615

Q612

Q613 Power switching

T611 Converter

T471 FBT

R224

R492

AJ1

Mains SW

SW1901 Prog+

SW1904 Level-

SW1903 Level+

SW1902 Prog-

SW1906 Memory

SW1905 Function

IC801 CPU

IC802 Memory

IC001 Audio output

VR631 +B ADJ.

R638

Q432

H-output

IC501

V-output

VR462 PCC ADJ.

VR461 H-Width

VR501 V-Size

SW501 V-center

JS501

TP-D

IC271 1H delay

TP-A

K1001

IC281

VR361

VR131 AGC

A101 Tuner

IC201 IF/Video/Chroma/Def.

VC141

T141

T101

SIF decoder

B1 POWER SUPPLY ADJ.

TU-AGC ADJ.

AFT ADJ.

GREY SCALE ADJ.

FOCUS ADJ.

MAIN BOARD

HIGH VOLTAGE & H-WIDTH ADJ.

V-CENTRE ADJ. H-CENTRE ADJ.

V-SIZE ADJ.

VR702

B-Drive

VR712

R-Drive

VR701

B-Bias

VR721

G-Bias

VR711

R-Bias

Q701

Q721 Q711

SERVICE CONTROL ADJUSTMENT

CRT BOARD

-8-

Service Manual-EC5 Chassis

B1 POWER SUPPLY ADJUSTMENT

1. Set VR641 to be mechanical centre before pressing

the main switch.

2. Tune the receiver to PAL circular pattern.

3. Set brightness and contrast controls to normal.

4. Connect digital V-meter to the right side terminal of

R638.

5. By using VR631, adjust voltage to 150 ± 0.5 V.

AFT ADJUSTMENT

1. Tune the receiver to the clearest station.

2. By using T141, adjust AFT to obtain the best picture.

AGC ADJUSTMENT NOTE:

Do not attempt this adjustment with weak

signal.

1. Tune the receiver to the clearest station.

2. Set AGC VR(VR131) in direction which causes snow

noise to appear, then in the opposite direction until snow noise just disappears.

GREY SCALE ADJUSTMENT [SCREEN VR ADJUSTMENT]

1. Tune the receiver to the white pattern.

2. Set brightness and contrast controls to normal.

3. Set VR702 and VR712 to be mechanical centre.

4. Turn VR701, VR711 and VR721 fully counter-clock-

wise.

5. Connect a short lead between pin30 of IC801 and

GND to enter the service mode.

6. Set screen VR for one colour to be just visible.

[BIAS VR ADJUSTMENT]

7. By using VR701, VR711 or VR721, adjust line to be

white.

8. Disconnect a short lead.

[DRIVE VR ADJUSTMENT]

9. By using VR701 and VR711, adjust white balance.

HIGH VOLTAGE & WIDTH ADJUSTMENT [HIGH VOLTAGE ADJUSTMENT]

1. Tune the receiver to circular pattern.

2. Set brightness and contrast controls to maximum.

3. Connect digital V-meter to both terminals of R224, and high voltage meter to CRT anode.

4. Confirm high voltage to be 26.0 ± 1 KV at beam current 1.3mA, and less than 29.0 KV at 0 beam current.

[H-WIDTH ADJUSTMENT]

5. Adjust VR461 to obtain proper H- width.

6. Reconfirm high voltage.

H-CENTRE ADJUSTMENT

1. Tune the receiver to circular pattern.

2. Adjust H-centre by using VR361.

V-CENTRE ADJUSTMENT

1. Tune the receiver to circular pattern.

2. Adjust V-centre by using SW501.

V-SIZE ADJUSTMENT

1. Tune the receiver to circular pattern.

2. Adjust V-size by using VR501.

FOCUS ADJUSTMENT

By using FOCUS VR, adjust focus control for the best scanning lines.

-9-

Service Manual-EC5 Chassis

DC 15.5V AGC voltage (4.3-4.5V) Output probe

Input probe Marker frequency

Sweep A TT

0dB=176mVrms/75

SETTING

C644 + IC201-pin48 IC201-pin45 (Side b) IC201-pin7

38.9MHz 20dB

Adjustment

By using T141, adjust "P" to be maximum amplitude.

Waveform

CIRCUIT ALIGNMENT

VIF alignment

0.002µF

75Ω

1kΩ

a

b

10kΩ

Input probe

Output probe

P

-10-

Service Manual-EC5 Chassis

AS

P

When you replace a memory IC (IC802), it is necessary to initialise the IC as follows.

A. Initialisation of Memory IC

1. When you press and hold the Recall button on the RC transmitter and then press the Prog + button on the TV set, the following picture will appear on the screen.

2. Confirm SET number of all items is "0" by pressing the

Function button.

3. If it is not "0", change to "0" by the Level (+/-) button.

(Changing the SET number, automatically memorised.)

4. Press the Recall button, to return the normal TV mode.

For more information, please refer to "special functions" on the instruction manual.

MEMORY IC REPLACEMENT (Important Notice)

1

2

3

4

5

6

7

8

9

0-/--

i

P

P P

TV/

F

X

?

ITEM -1 SET➔ 0

1

2

1

3

4

-11-

Service Manual-EC5 Chassis

SPECIAL FUNCTION

■ Maximum volume setting and prohibition of presetting

■ Start up programme position

F

ITEM-1 SET➜0

1 2 3 4 5 6 7 8 9

AS

P

SETTING PROCEDURE

1

Press and hold the button on the Remote control

handset and then press the P▲ button on the TV set.

2

To select the "ITEM" number, press the button on the remote control handset.

3

To select the "SET" number, press the or button repeatedly.

4

To return to the normal TV mode, press the button.

✐ The setting conditions of all items can be confirmed. ✐ Special functions are not cancelled if the TV set is switched

off or the mains disconnected.

This TV set allows you to set up the following special functions.

■ Maximum volume setting and prohibition of presetting

ITEM-1

Sets the current volume as the maximum volume level and prohibition of presetting.

SET➞ 0 NO SET➞ 1 YES

■ Start up programme position

ITEM-2

Presets the programme position when the set is switched on.

SET➞ 0 Last programme position start SET➞ 1 Programme position "1" start SET➞ 2 Programme position "2" start SET➞ 3 Programme position "3" start SET➞ 4 Programme position "4" start SET➞ 5 Programme position "5" start SET➞ 6 Programme position "6" start SET➞ 7 Programme position "7" start SET➞ 8 Programme position "8" start SET➞ 9 "AV" start

1

3

1

2

4

-12-

F4ATV

Note: Parts order must contain Service Ref. No., Part No., and descriptions.

CABINET PARTS

1 610 267 0479 ASSY,CABINET FR-F4ACM 2 610 266 1811 BUTTON UNITED-F2ZE 3 610 255 2423 BUTTON POWER-E8GC 4 610 266 3839 CABINET BACK-F4ACM 5 610 261 4404 DEC BOARD-F2SGV

610 253 2449 HOLDER AC CORD-GBR-D4VA 610 260 0148 HOLDER RC GBR-BLFA

610 265 4202 HOLDER DC-F3SCM 6 610 261 3032 SPRING-E7GC 7 645 003 9256 BADGE,SANYO*46.2X13.5L45

645 013 5521 FIXER HOOK,D11.5(PA)

610 224 5721 CRT CUSHION-B3MY-UK

ACCESSORIES

8 JXYC RC TRANSMITTER

SKP10154 INST MANUAL-F4AT/ZT (1)

SKP10155 INST MANUAL-F4AT/ZT (2)

SKP10156 INST MANUAL-F4AT/ZT (3)

SKP20207 SHEM DIAG -F4ATV

645 027 6927 BATTERY

Ref. No. Part No. Description Ref. No. Part No. Description

7

4

1

5

3

62

1

2

3

4

5

6

7

8

9

0-/--

i

P

P P

TV/

F

X

?

8

CABINET PARTS LIST

-13-

F4ATV

Chassis construction CE25MT2A-C-01

OUT OF CIRCUIT-F4AEV (Page 13) ASSY,PWB,MAIN F4ATV 1AA0B10H022FA(Page 13) ASSY,PWB,CRT F4ATV 1AA0B10H022FB (Page 19)

OUT OF CIRCUIT-F4AEV

PICTURE TUBE

Q901 414 007 1104 CRT A59ECY13X38

COIL

L901 645 003 0031 COIL,DEGAUSSING

645 003 0062 COIL,DEGAUSSING

MISCELLANEOUS

SP901 610 055 5471 SPEAKER

610 230 5234 SPEAKER W901 645 012 7632 ASSY,CORD,POWER W902 610 024 2210 GROUNDING CONNECTOR-D8AC

610 204 6083 GROUNDING CONNECTOR

ASSY,PWB,MAIN F4ATV 1AA0B10H022FA

TRANSISTOR

Q101 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q102 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q1021 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q1022 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q103 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q1031 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP

!

Ref.No. Part No. Description

Product safety should be considered when a component replacement is made in any area of a receiver. Components indicated by a mark in this parts list and the circuit diagram show components whose value have special significance to product safety. It is particularly recommended that only parts specified on the following parts list be used for components replacement pointed out by the mark.

!

Note: Parts order must contain Service Ref. No., Part No., and descriptions.

Read description in the Capacitor and Resistor as follows:

CAPACITOR CERAMIC 100PK 50V

Rated Voltage

Tolerance Symbols: Less than 10PF A:Not specified B:±0.1PF C:±0.25PF D:±0.5PF F:±1PF G:±2PF R:±0.25-0PF S:±0-0.25PF E:+0-1PF More than 10PF A:Not specified B:±0.1% C:±0.25% D:±0.5% F:±1% G:±2% H:±3% J:±5% K:±10% L:±15% M:±20% N:±30% P:+100-0% Q:+30-10% T:+50-10% U:+75-10% V:+20-10% W:+100-10% X:+40-20% Y:+150-10% Z:+80-20%

Rated value: P=pico farad, U=Micro farad

Material:

CERAMIC . . . . . .Ceramic

MT-PAPER . . . . .Metallized Paper

POLYESTER . . .Polyester MT-POLYEST . . .Metallized Polyester

POLYPRO . . . . .Polypropylene

MT-POLYPRO . .Metallized Polypropylene COMPO FILM . . .Composite film

MT-COMPO . . . .Metallized Composite

STYRENE . . . . .Styrene

TA-SOLID . . . . . .Tantalum Solid

AL-SOLID . . . . . .Aluminium Solid

ELECT . . . . . . . .Electrolytic

NP-ELECT . . . . .Non-polarised Electrolytic

OS-SOLID . . . . .Aluminium Solid with Organic Semiconductive Electrolytic

DL-ELECT . . . . .Double Layered Electrolytic

RESISTOR CARBON 4.7K J A 1/4W

Rated Wattage

Performance Symbols: A: General B: Non flammable Z:Low noise Other:Temperature coefficient

Tolerance Symbols: A:±0.05%B:±0.1%C:±0.25%D:±0.5% F:±1% G:±2% J:±5% K:±10% M:±20% P:+5-15%

Rated value, ohms: K:1,000, M: 1,000,000

Material:

CARBON . . . . . .Carbon

MT-FILM . . . . . .Metal Film

OXIDE-MT . . . . .Oxide Metal Film

SOLID . . . . . . . .Composition

MT-GLAZE . . . . .Metal Glaze

WIREWOUND . .Wire Wound CERAMIC RES . .Ceramic FUSIBLE RES . .Fusible

CHASSIS ELECTRICALPARTS LIST

Q1032 406 007 2106 TR JC546A

406 007 2007 TR JC546B 405 019 1909 TR 2SC536-E-NP 405 019 2708 TR 2SC536-F-NP 405 019 3804 TR 2SC536-G-NP

Q104 406 007 2106 TR JC546A

406 007 2007 TR JC546B 405 019 1909 TR 2SC536-E-NP 405 019 2708 TR 2SC536-F-NP 405 019 3804 TR 2SC536-G-NP

Q105 406 007 1901 TR JC556A

406 007 1802 TR JC556B 405 004 4205 TR 2SA608-E-CTV-NP 405 004 4809 TR 2SA608-F-CTV-NP 405 028 7909 TR 2SA608-G-CTV-NP

Q106 406 007 2106 TR JC546A

406 007 2007 TR JC546B 405 019 1909 TR 2SC536-E-NP 405 019 2708 TR 2SC536-F-NP 405 019 3804 TR 2SC536-G-NP

Q121 406 007 2106 TR JC546A

406 007 2007 TR JC546B 405 019 1909 TR 2SC536-E-NP 405 019 2708 TR 2SC536-F-NP 405 019 3804 TR 2SC536-G-NP

Q151 406 007 2106 TR JC546A

406 007 2007 TR JC546B 405 019 1909 TR 2SC536-E-NP 405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q152 406 007 2106 TR JC546A Q153 406 007 1901 TR JC556A Q154 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q161 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q162 406 007 2106 TR JC546A Q163 406 007 2106 TR JC546A Q2001 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q201 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q241 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q251 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q431 405 018 0507 TR 2SC3332-R

405 018 0606 TR 2SC3332-S Q432 406 015 2501 ON5111 (BU2708DX) PH. Q461 405 064 7307 TR 2SB1274-Q-RA

405 064 7406 TR 2SB1274-R-RA

405 064 7505 TR 2SB1274-S-RA Q462 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q611 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP 405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q612 405 058 0208 TR 2SC3807-R-CTV-YA Q613 405 018 9203 TR 2SC3895-T-CTV-YB Q631 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q651 405 089 0000 TR 2SA1707-S

405 089 0109 TR 2SA1707-T

405 009 6907 TR 2SB985-S

405 009 7003 TR 2SB985-T Q661 405 008 4805 TR 2SB764-E Q682 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP

Q685 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP

Q686 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q801 405 118 4207 TR PH2369 Q831 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q839 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q847 406 007 2106 TR JC546A

Q861 406 007 1901 TR JC556A

406 007 1802 TR JC556B

405 004 4205 TR 2SA608-E-CTV-NP

405 004 4809 TR 2SA608-F-CTV-NP

405 028 7909 TR 2SA608-G-CTV-NP Q871 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q872 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q873 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q874 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP Q875 406 007 2106 TR JC546A

406 007 2007 TR JC546B

405 019 1909 TR 2SC536-E-NP

405 019 2708 TR 2SC536-F-NP

405 019 3804 TR 2SC536-G-NP

INTEGRATED CIRCUIT

IC001 409 073 1509 IC AN5265 IC201 409 380 8703 IC TDA8361/N5 IC271 409 404 0201 IC U3665M

Ref. No. Part No. Description Ref. No. Part No. Description

-14-

F4ATV

IC501 409 192 5709 IC LA7833 IC661 409 367 2809 IC BA178M09T

409 366 7904 IC UPC78M09AHF

IC691 409 298 5306 IC AN78M05 LB

409 241 5407 IC BA178M05T 409 265 4806 IC L78M05CV 409 172 1509 IC MC78M05CT

409 320 5700 IC UPC78M05AHF IC801 410 323 9305 SAA5290PS/117 EC5/V2 IC802 409 247 7702 IC ST24C02AB1

409 281 8307 IC 24C02A/P

409 333 3700 IC 24LC02B/P

CAPACITOR

C001 403 043 3906 ELECT 33U M 16V C002 403 270 3908 MT-POLYEST 0.47U K 63V

403 256 0808 MT-COMPO 0.47U J 50V C003 403 178 9210 POLYESTER 1000P J 50V C004 403 051 0607 ELECT 4.7U M 50V C005 403 041 8804 ELECT 10U M 16V C006 403 041 8804 ELECT 10U M 16V C010 403 270 2901 MT-POLYEST 0.1U K 63V

403 237 8007 MT-COMPO 0.1U J 50V C011 403 045 1504 ELECT 1000U M 25V C012 403 199 9708 ELECT 470U M 25V C013 403 086 2300 NP-ELECT 1U M 50V C020 403 069 8305 CERAMIC 0.01U Z 50V C100 403 043 9106 ELECT 47U M 16V C1001 403 009 5708 CERAMIC 100P J 50V C1002 403 270 3908 MT-POLYEST 0.47U K 63V

403 256 0808 MT-COMPO 0.47U J 50V C1003 403 069 9500 CERAMIC 0.01U Z 50V C1004 403 041 8804 ELECT 10U M 16V C101 403 043 9106 ELECT 47U M 16V C102 403 069 1712 CERAMIC 1000P K 50V C105 403 049 0008 ELECT 1U M 50V C106 403 069 9500 CERAMIC 0.01U Z 50V C121 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C131 401 037 5004 MT-GLAZE 0.000 ZA 1/10W C132 403 069 1702 CERAMIC 1000P K 50V C133 403 069 9500 CERAMIC 0.01U Z 50V C134 403 049 9803 ELECT 2.2U M 50V C135 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C136 403 194 4609 ELECT 470U M 16V C137 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C138 403 069 9500 CERAMIC 0.01U Z 50V C140 403 010 8507 CERAMIC 12P J 50V C141 403 028 4409 CERAMIC 56P J 50V C142 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C143 403 073 4201 CERAMIC 3900P K 50V C151 403 020 0419 CERAMIC 27P J 50V C152 403 026 2813 CERAMIC 47P J 50V C153 403 033 4510 CERAMIC 82P J 50V C154 403 009 5718 CERAMIC 100P J 50V C155 403 069 9510 CERAMIC CHIP 0.01Z 50V C156 403 069 9510 CERAMIC CHIP 0.01Z 50V C160 403 069 1702 CERAMIC 1000P K 50V C161 403 072 5001 CERAMIC 270P K 50V C171 403 049 0008 ELECT 1U M 50V C172 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C173 403 041 8804 ELECT 10U M 16V C2001 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C2002 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C2003 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C201 403 014 3409 CERAMIC 18P J 50V C202 403 270 2901 MT-POLYEST 0.1U K 63V

403 237 8007 MT-COMPO 0.1U J 50V C203 403 073 9107 CERAMIC 4700P K 50V C204 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V

C205 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V

C206 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V

C207 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V

C208 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C212 403 049 9803 ELECT 2.2U M 50V C215 403 270 3908 MT-POLYEST 0.47U K 63V

403 256 0808 MT-COMPO 0.47U J 50V C222 404 045 6605 NP-ELECT 2.2U M 50V C231 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V

C233 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V

C251 403 043 6006 ELECT 330U M 16V C271 403 069 1702 CERAMIC 1000P K 50V C272 403 069 1702 CERAMIC 1000P K 50V C273 403 069 9500 CERAMIC 0.01U Z 50V C275 403 069 9500 CERAMIC 0.01U Z 50V C276 403 069 9500 CERAMIC 0.01U Z 50V C277 403 069 9500 CERAMIC 0.01U Z 50V C351 403 270 2901 MT-POLYEST 0.1U K 63V

403 237 8007 MT-COMPO 0.1U J 50V

C352 403 061 8303 POLYESTER 4700P K 50V

403 179 1104 POLYESTER 4700P K 50V

C353 403 073 9107 CERAMIC 4700P K 50V C354 403 049 0008 ELECT 1U M 50V C361 403 072 5605 CERAMIC 2700P K 50V C362 403 069 9500 CERAMIC 0.01U Z 50V C363 403 042 2405 ELECT 100U M 16V C421 404 046 8806 MT-POLYPRO 6200P J 1.5K C422 404 061 0601 MT-POLYPRO 5100P J 1.5K C424 403 083 4901 POLYPRO 0.027U J 400V C425 403 083 4307 POLYPRO 0.022U J 400V C429 403 066 6106 MT-POLYEST .47U J 250V C431 403 068 5602 CERAMIC 0.056U Z 25V C432 403 075 7101 CERAMIC 1000P K 500V C433 403 076 3102 CERAMIC 3900P K 500V C434 403 054 0703 ELECT 47U M 35V C438 403 057 0601 POLYESTER 0.01U K 50V

403 179 3801 POLYESTER 0.01U K 50V

C441 403 083 5106 POLYPRO 0.27U J 400V C445 403 049 4204 ELECT 10U M 50V C462 403 049 0008 ELECT 1U M 50V C463 403 214 4404 ELECT 470U M 35V C464 403 067 7895 MT-COMPO 0.47 J 50V C465 403 066 0104 MT-POLYEST 2.2U K 100V C466 403 270 2901 MT-POLYEST 0.1U K 63V

403 237 8007 MT-COMPO 0.1U J 50V

C467 403 040 3701 ELECT 220U M 10V C468 403 045 5809 ELECT 22U M 25V C470 403 069 8305 CERAMIC 0.01U Z 50V C491 403 076 5304 CERAMIC 680P K 500V C492 403 050 2800 ELECT 22U M 50V C501 403 054 1502 ELECT 470U M 35V C502 403 053 2104 ELECT 220U M 35V C503 403 024 2102 CERAMIC 39P J 50V C504 403 069 9500 CERAMIC 0.01U Z 50V C505 403 075 7101 CERAMIC 1000P K 500V C506 403 188 0907 MT-POLYEST 0.22U K 100V C511 403 183 7901 MT-POLYEST 0.1U K 100V C512 403 148 0701 ELECT 2200U M 25V C513 403 049 4204 ELECT 10U M 50V C520 403 069 1702 CERAMIC 1000P K 50V C601 404 056 1408 MT-POLYEST 0.1U M 250V

404 074 6508 MT-COMPO 0.1U K 250V

C602 404 056 1408 MT-POLYEST 0.1U M 250V

404 074 6508 MT-COMPO 0.1U K 250V

C606 403 076 6707 CERAMIC 1000P K 1K

403 312 8205 CERAMIC 1000P K 1K

C607 404 044 5005 ELECT 220U M 400V C614 403 270 2901 MT-POLYEST 0.1U K 63V

403 237 8007 MT-COMPO 0.1U J 50V

C615 403 058 2604 POLYESTER 0.015U J 50V

!!!!!

Ref. No. Part No. Description Ref. No. Part No. Description

-15-

F4ATV

403 179 3207 POLYESTER 0.015U J 50V

C616 403 247 6604 CERAMIC 680P K 2K

403 275 8205 CERAMIC 680P K 2K 403 232 2109 CERAMIC 680P K 2K

C617 403 059 6205 POLYESTER 0.022U K 50V

403 179 2408 POLYESTER 0.022U K 50V

C621 404 059 9203 CERAMIC 1000P M 400V

404 060 6000 CERAMIC 1000P M 400V

C624 404 044 2806 CERAMIC 470P K 400V

404 044 2707 CERAMIC 470P M 400V

C631 403 247 5003 CERAMIC 470P K 1K

403 269 1809 CERAMIC 470P K 1K 403 232 0501 CERAMIC 470P K 1K

C634 403 247 5003 CERAMIC 470P K 1K

403 269 1809 CERAMIC 470P K 1K

403 232 0501 CERAMIC 470P K 1K C641 404 055 9801 ELECT 220U M 200V C643 403 148 1906 ELECT 330U M 35V C644 403 148 0404 ELECT 1000U M 25V

403 134 5307 ELECT 1000U M 25V C645 403 148 0404 ELECT 1000U M 25V

403 134 5307 ELECT 1000U M 25V C662 403 044 1703 ELECT 470U M 16V C663 403 040 3701 ELECT 220U M 10V C685 403 049 0008 ELECT 1U M 50V C691 403 039 6508 ELECT 100U M 10V C800 401 037 5014 MT-GLAZE 0.000 ZA 1/10W C801 403 069 9500 CERAMIC 0.01U Z 50V C805 403 051 0607 ELECT 4.7U M 50V C807 403 070 2606 CERAMIC 0.1U Z 50V C814 403 046 9905 ELECT 4.7U M 25V C819 403 046 9905 ELECT 4.7U M 25V C824 403 049 0008 ELECT 1U M 50V C829 403 049 0008 ELECT 1U M 50V C833 403 069 5611 CERAMIC 0.01U K 50V C834 403 049 0008 ELECT 1U M 50V C841 403 069 9500 CERAMIC 0.01U Z 50V C851 403 069 9510 CERAMIC CHIP 0.01 Z 50V C861 403 138 5600 POLYESTER 5600P J 50V

403 179 0800 POLYESTER 5600P J 50V C870 403 022 8205 CERAMIC 33P J 50V C871 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C872 403 043 9106 ELECT 47U M 16V C873 403 018 0503 CERAMIC 22P J 50V C874 403 018 0503 CERAMIC 22P J 50V C875 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C878 403 073 9107 CERAMIC 4700P K 50V C879 403 068 0409 CERAMIC 0.1U Z 25V

403 070 2606 CERAMIC 0.1U Z 50V C881 403 069 9500 CERAMIC 0.01U Z 50V C882 403 041 8804 ELECT 10U M 16V C885 403 069 1702 CERAMIC 1000P K 50V

RESISTOR

R001 401 018 1605 CARBON 33 JA 1/4W R002 401 027 2303 CARBON 560 JA 1/6W R003 401 024 7400 CARBON 10K JA 1/6W R004 401 024 7004 CARBON 1K JA 1/6W R006 401 024 7400 CARBON 10K JA 1/6W R1001 401 037 6803 MT-GLAZE 12K JA 1/10W R1002 401 037 6803 MT-GLAZE 12K JA 1/10W R1003 401 038 7700 MT-GLAZE 5.6K JA 1/10W R1004 401 038 7601 MT-GLAZE 560 JA 1/10W R1005 401 037 5707 MT-GLAZE 100K JA 1/10W R1007 401 027 6608 CARBON 75 JA 1/6W R1008 401 026 7408 CARBON 39K JA 1/6W R1009 401 038 2200 MT-GLAZE 27K JA 1/10W R101 401 038 6505 MT-GLAZE 47K JA 1/10W R1011 401 027 6608 CARBON 75 JA 1/6W R1015 401 027 6608 CARBON 75 JA 1/6W R1016 401 027 6608 CARBON 75 JA 1/6W R1019 401 027 6608 CARBON 75 JA 1/6W R102 401 037 6803 MT-GLAZE 12K JA 1/10W R1020 401 027 6608 CARBON 75 JA 1/6W R1021 401 038 6307 MT-GLAZE 470 JA 1/10W

R1022 401 024 7400 CARBON 10K JA 1/6W R1023 401 020 2003 CARBON 4.7K JA 1/4W R1026 401 038 7601 MT-GLAZE 560 JA 1/10W R1027 401 038 7601 MT-GLAZE 560 JA 1/10W R1028 401 038 7601 MT-GLAZE 560 JA 1/10W R1029 401 038 5003 MT-GLAZE 390 JA 1/10W R103 401 038 6505 MT-GLAZE 47K JA 1/10W R1031 401 037 6704 MT-GLAZE 1.2K JA 1/10W R1032 401 038 3603 MT-GLAZE 3.3K JA 1/10W R1033 401 037 6704 MT-GLAZE 1.2K JA 1/10W R104 401 037 6803 MT-GLAZE 12K JA 1/10W R105 401 038 6505 MT-GLAZE 47K JA 1/10W R106 401 037 6803 MT-GLAZE 12K JA 1/10W R109 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R110 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R121 401 038 6505 MT-GLAZE 47K JA 1/10W R122 401 038 0909 MT-GLAZE 220K JA 1/10W R123 401 038 0909 MT-GLAZE 220K JA 1/10W R133 401 037 9101 MT-GLAZE 180 JA 1/10W R134 401 039 0403 MT-GLAZE 8.2K JA 1/10W R135 401 038 0800 MT-GLAZE 22K JA 1/10W R137 401 037 5202 MT-GLAZE 100 JA 1/10W R138 401 038 7700 MT-GLAZE 5.6K JA 1/10W R141 401 038 9209 MT-GLAZE 6.8K JA 1/10W R150 401 037 5400 MT-GLAZE 1K JA 1/10W R151 401 019 1000 CARBON 390 JA 1/4W R152 401 037 9111 MT-GLAZE 180 JA 1/10W R155 401 037 5410 MT-GLAZE 1K JA 1/10W R156 401 038 6416 MT-GLAZE 4.7K JA 1/10W R157 401 037 5410 MT-GLAZE 1K JA 1/10W R158 401 037 5410 MT-GLAZE 1K JA 1/10W R159 401 037 5410 MT-GLAZE 1K JA 1/10W R160 401 037 5410 MT-GLAZE 1K JA 1/10W R161 401 019 1000 CARBON 390 JA 1/4W R162 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R163 401 025 7409 CARBON 220 JA 1/6W R164 401 038 6208 MT-GLAZE 47 JA 1/10W R165 401 037 6813 MT-GLAZE 12K JA 1/10W R166 401 027 5225 CARBON 680 JA 1/6W R167 401 038 6218 MT-GLAZE 47 JA 1/10W R168 401 037 6813 MT-GLAZE 12K JA 1/10W R169 401 027 5225 CARBON 680 JA 1/6W R170 401 038 7700 MT-GLAZE 5.6K JA 1/10W R171 401 037 5608 MT-GLAZE 10K JA 1/10W R173 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R174 401 037 8005 MT-GLAZE 15K JA 1/10W R1901 401 027 3003 CARBON 56K JA 1/6W R1902 401 025 1902 CARBON 15K JA 1/6W R1903 401 023 2802 CARBON 8.2K JA 1/4W R1904 401 026 9907 CARBON 4.7K JA 1/6W R1905 401 038 2101 MT-GLAZE 2.7K JA 1/10W R1906 401 038 0701 MT-GLAZE 2.2K JA 1/10W R1907 401 037 7909 MT-GLAZE 1.5K JA 1/10W R1908 401 038 3504 MT-GLAZE 330 JA 1/10W R1909 401 037 5608 MT-GLAZE 10K JA 1/10W R1911 401 026 9600 CARBON 470 JA 1/6W R1912 401 025 7805 CARBON 2.2K JA 1/6W R2001 401 038 2200 MT-GLAZE 27K JA 1/10W R2002 401 037 5608 MT-GLAZE 10K JA 1/10W R2003 401 037 6803 MT-GLAZE 12K JA 1/10W R2004 401 037 7800 MT-GLAZE 150 JA 1/10W R2005 401 013 6407 CARBON 12K JA 1/4W R201 401 039 0403 MT-GLAZE 8.2K JA 1/10W R202 401 037 5707 MT-GLAZE 100K JA 1/10W R203 401 037 5202 MT-GLAZE 100 JA 1/10W R204 401 037 5202 MT-GLAZE 100 JA 1/10W R205 401 037 5202 MT-GLAZE 100 JA 1/10W R213 401 037 8005 MT-GLAZE 15K JA 1/10W R214 401 038 9209 MT-GLAZE 6.8K JA 1/10W R217 401 038 0800 MT-GLAZE 22K JA 1/10W R218 401 015 2704 CARBON 1.8K JA 1/4W R222 401 013 7305 CARBON 120K JA 1/4W R223 401 024 7400 CARBON 10K JA 1/6W R224 401 012 5708 CARBON 1K JA 1/4W R226 401 037 5707 MT-GLAZE 100K JA 1/10W R227 401 024 7400 CARBON 10K JA 1/6W R231 401 037 5004 MT-GLAZE 0.000 ZA 1/10W

!

Ref. No. Part No. Description Ref. No. Part No. Description

-16-

F4ATV

R232 401 037 5202 MT-GLAZE 100 JA 1/10W R241 401 038 6307 MT-GLAZE 470 JA 1/10W R242 401 025 7409 CARBON 220 JA 1/6W R243 401 025 7409 CARBON 220 JA 1/6W R251 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R252 401 037 5608 MT-GLAZE 10K JA 1/10W R253 401 024 7400 CARBON 10K JA 1/6W R271 401 016 2604 CARBON 220 JA 1/4W R351 401 024 6700 CARBON 100 JA 1/6W R352 401 037 5806 MT-GLAZE 1M JA 1/10W R356 401 037 5202 MT-GLAZE 100 JA 1/10W R357 401 037 5608 MT-GLAZE 10K JA 1/10W R361 401 038 5409 MT-GLAZE 390K JA 1/10W R363 401 038 0800 MT-GLAZE 22K JA 1/10W R364 401 037 5202 MT-GLAZE 100 JA 1/10W R365 401 038 6406 MT-GLAZE 4.7K JA 1/10W R371 401 012 7009 CARBON 10K JA 1/4W R429 402 068 0204 WIRE WOUND 10 JA 5W

402 075 2307 WIRE WOUND 10 JA 5W R432 401 037 5400 MT-GLAZE 1K JA 1/10W R433 401 007 1104 CARBON 1K JA 1/2W R434 401 009 9306 CARBON 390 JA 1/2W R444 401 058 3706 OXIDE-MT 1K JA 1W R447 401 026 9907 CARBON 4.7K JA 1/6W R448 401 009 5803 CARBON 330 JA 1/2W R463 401 025 1625 CARBON 1K5 JA 1/6W R464 401 014 4105 CARBON 1.5K JA 1/4W R465 401 038 7908 MT-GLAZE 560K JA 1/10W R468 401 025 4200 CARBON 1.8K JA 1/6W R469 401 027 5908 CARBON 68K JA 1/6W R471 401 025 1605 CARBON 1.5K JA 1/6W R472 401 027 0309 CARBON 47K JA 1/6W R473 401 022 1905 CARBON 680 JA 1/4W R474 401 009 0907 CARBON 270 JA 1/2W R480 401 027 0309 CARBON 47K JA 1/6W R481 401 064 5305 OXIDE-MT 1.5 JA 2W R491 401 008 3701 CARBON 2.2 JA 1/2W R495 401 025 4903 CARBON 180K JA 1/6W R496 401 027 2600 CARBON 5.6K JA 1/6W R501 401 020 2003 CARBON 4.7K JA 1/4W R502 401 026 8108 CARBON 4.7 JA 1/6W R505 401 027 5502 CARBON 6.8K JA 1/6W R506 401 026 7022 CARBON 3K9 JA 1/6W R507 401 027 8107 CARBON 82 JA 1/6W R508 401 026 1000 CARBON 2.7K JA 1/6W R509 401 057 6807 OXIDE-MT 0.68 JA 1W R511 401 062 1200 OXIDE-MT 470 JA 1W R513 401 058 3706 OXIDE-MT 1K JA 1W

R514 401 025 5405 CARBON 2.2 JA 1/6W

R601 401 008 8607 CARBON 220K JA 1/2W R602 402 067 7709 WIRE WOUND 3.9 KA 7W

402 072 4403 WIRE WOUND 3.9 KA 7W R611 401 027 2600 CARBON 5.6K JA 1/6W R615 401 016 4806 CARBON 22K JA 1/4W R617 401 024 7004 CARBON 1K JA 1/6W R619 401 016 1508 CARBON 22 JA 1/4W R620 401 007 5805 CARBON 120K JA 1/2W R621 401 007 5805 CARBON 120K JA 1/2W R622 401 014 5201 CARBON 15K JA 1/4W R623 401 026 1000 CARBON 2.7K JA 1/6W R624 401 069 6208 OXIDE-MT 82 JA 2W R625 401 069 1708 OXIDE-MT 68 JA 2W R626 401 018 3401 CARBON 3.3K GA 1/4W R628 402 000 8305 SOLID 5.6M KA 1/2W R629 402 000 8305 SOLID 5.6M KA 1/2W R635 401 012 8105 CARBON 100K JA 1/4W R636 401 020 2003 CARBON 4.7K JA 1/4W R637 401 015 4708 CARBON 180K JA 1/4W R638 401 061 4400 OXIDE-MT 33K JA 1W R639 401 024 9701 CARBON 12K JA 1/6W R642 401 059 3903 OXIDE-MT 1.5K JA 1W R645 402 052 2405 WIRE WOUND 18 KA FH 3W R646 401 025 7805 CARBON 2.2K JA 1/6W R651 401 012 7009 CARBON 10K JA 1/4W R652 401 019 1901 CARBON 3.9K JA 1/4W R661 401 012 7009 CARBON 10K JA 1/4W R662 401 069 5607 OXIDE-MT 8.2 JA 2W

R663 401 013 5301 CARBON 1.2K JA 1/4W R666 401 008 0205 CARBON 18 JA 1/2W R681 401 012 7009 CARBON 10K JA 1/4W R686 401 016 5803 CARBON 220K JA 1/4W R687 401 021 5003 CARBON 560K JA 1/4W R688 401 012 7009 CARBON 10K JA 1/4W R689 401 025 8208 CARBON 22K JA 1/6W R800 401 038 0701 MT-GLAZE 2.2K JA 1/10W R801 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R802 401 038 0701 MT-GLAZE 2.2K JA 1/10W R803 401 037 9408 MT-GLAZE 180K JA 1/10W R804 401 012 7009 CARBON 10K JA 1/4W R805 401 039 0403 MT-GLAZE 8.2K JA 1/10W R806 401 066 2104 OXIDE-MT 18K JA 2W R807 401 037 5608 MT-GLAZE 10K JA 1/10W R811 401 038 6406 MT-GLAZE 4.7K JA 1/10W R812 401 038 0701 MT-GLAZE 2.2K JA 1/10W R813 401 038 5112 MT-GLAZE 3.9K JA 1/10W R814 401 038 3603 MT-GLAZE 3.3K JA 1/10W R816 401 038 0701 MT-GLAZE 2.2K JA 1/10W R817 401 037 5608 MT-GLAZE 10K JA 1/10W R818 401 038 0800 MT-GLAZE 22K JA 1/10W R819 401 038 6505 MT-GLAZE 47K JA 1/10W R821 401 037 5202 MT-GLAZE 100 JA 1/10W

R822 401 037 5608 MT-GLAZE 10K JA 1/10W R823 401 039 0403 MT-GLAZE 8.2K JA 1/10W R824 401 027 0329 CARBON 47K JA 1/6W R826 401 037 6704 MT-GLAZE 1.2K JA 1/10W R827 401 038 5102 MT-GLAZE 3.9K JA 1/10W R828 401 038 3702 MT-GLAZE 33K JA 1/10W R831 401 037 5202 MT-GLAZE 100 JA 1/10W R832 401 037 6803 MT-GLAZE 12K JA 1/10W R833 401 039 0502 MT-GLAZE 82K JA 1/10W R834 401 038 6406 MT-GLAZE 4.7K JA 1/10W R836 401 037 6704 MT-GLAZE 1.2K JA 1/10W R837 401 038 6505 MT-GLAZE 47K JA 1/10W R838 401 037 8005 MT-GLAZE 15K JA 1/10W R839 401 038 6406 MT-GLAZE 4.7K JA 1/10W R840 401 020 2003 CARBON 4.7K JA 1/4W R841 401 038 0800 MT-GLAZE 22K JA 1/10W R842 401 019 1901 CARBON 3.9K JA 1/4W R843 401 037 5608 MT-GLAZE 10K JA 1/10W R844 401 037 5608 MT-GLAZE 10K JA 1/10W R846 401 020 2003 CARBON 4.7K JA 1/4W R847 401 012 7009 CARBON 10K JA 1/4W R848 401 020 2003 CARBON 4.7K JA 1/4W R850 401 038 6416 MT-GLAZE 4.7K JA 1/10W R851 401 037 5410 MT-GLAZE 1K JA 1/10W R852 401 012 5708 CARBON 1K JA 1/4W R856 401 016 4806 CARBON 22K JA 1/4W R857 401 012 7049 CARBON 10K JA 1/4W R861 401 038 2101 MT-GLAZE 2.7K JA 1/10W R862 401 038 0800 MT-GLAZE 22K JA 1/10W R863 401 038 0800 MT-GLAZE 22K JA 1/10W R864 401 037 5400 MT-GLAZE 1K JA 1/10W R865 401 038 6406 MT-GLAZE 4.7K JA 1/10W R866 401 038 6406 MT-GLAZE 4.7K JA 1/10W R867 401 038 6406 MT-GLAZE 4.7K JA 1/10W R868 401 037 6704 MT-GLAZE 1.2K JA 1/10W R869 401 038 2200 MT-GLAZE 27K JA 1/10W R870 401 038 0800 MT-GLAZE 22K JA 1/10W R871 401 038 6406 MT-GLAZE 4.7K JA 1/10W R872 401 038 3702 MT-GLAZE 33K JA 1/10W R873 401 038 6406 MT-GLAZE 4.7K JA 1/10W R874 401 037 5608 MT-GLAZE 10K JA 1/10W R875 401 038 7700 MT-GLAZE 5.6K JA 1/10W R876 401 037 5608 MT-GLAZE 10K JA 1/10W R877 401 039 0403 MT-GLAZE 8.2K JA 1/10W R878 401 037 7909 MT-GLAZE 1.5K JA 1/10W R879 401 012 7009 CARBON 10K JA 1/4W R880 401 038 6505 MT-GLAZE 47K JA 1/10W R881 401 038 2200 MT-GLAZE 27K JA 1/10W R883 401 020 0801 CARBON 470 JA 1/4W R884 401 038 2101 MT-GLAZE 2.7K JA 1/10W R885 401 038 5102 MT-GLAZE 3.9K JA 1/10W R887 401 038 5102 MT-GLAZE 3.9K JA 1/10W R891 401 038 6406 MT-GLAZE 4.7K JA 1/10W

!

!!!

!!!!!!!

!

!!!

!

Ref. No. Part No. Description Ref. No. Part No. Description

-17-

F4ATV

R892 401 038 6406 MT-GLAZE 4.7K JA 1/10W R895 401 037 6704 MT-GLAZE 1.2K JA 1/10W R896 401 038 5102 MT-GLAZE 3.9K JA 1/10W R897 401 038 5102 MT-GLAZE 3.9K JA 1/10W R898 401 038 5102 MT-GLAZE 3.9K JA 1/10W

VARIABLE RESISTOR

VR131 645 006 5422 VR,SEMI,10K N

610 239 7567 VR B-10K

VR361 645 006 5422 VR,SEMI,10K N

610 239 7567 VR B-10K

VR461 645 006 5606 VR,SEMI,4.7K N

610 232 8455 VR,SEMI,5K N

VR501 645 006 5408 VR,SEMI,100 N

610 232 7908 VR,SEMI,100 N

VR631 645 006 5514 VR,SEMI,2.2K N

610 239 7574 VR B-2K

TRANSFORMER

T141 610 037 4522 S COIL T431 610 223 1656 DRIVE TRANS T471 645 017 4230 TRANS,FLYBACK T611 645 007 7494 TRANS,POWER,PULSE

645 009 0349 TRANS,POWER,PULSE

COIL

L1002 645 001 4567 INDUCTOR,10U K L1003 645 001 4567 INDUCTOR,10U K L1006 645 001 4567 INDUCTOR,10U K L1021 645 002 1787 CORE,PIPE L103 645 008 2894 INDUCTOR,5.6U K L141 645 001 4567 INDUCTOR,10U K L151 645 008 2924 INDUCTOR,8.2U K L152 645 002 1459 PEAKING COIL L161 645 002 1534 PEAKING COIL 8.2UHK L162 645 002 1534 PEAKING COIL 8.2UHK L201 645 008 2863 INDUCTOR,4.7U K L202 645 008 2863 INDUCTOR,4.7U K L203 645 008 2863 INDUCTOR,4.7U K L431 645 008 5628 INDUCTOR,1U M L444 610 000 0964 LINEARITY COIL

610 212 6310 LINEARITY COIL

610 218 3856 LINEARITY COIL L444P1 645 008 4058 TERMINAL,PLUG L444P2 645 008 4058 TERMINAL,PLUG L444P3 645 008 4058 TERMINAL,PLUG L444P4 645 008 4058 TERMINAL,PLUG L445 610 221 3348 COIL L445P1 645 008 4058 TERMINAL,PLUG L461 610 031 1367 INDUCTOR 202J L462 610 000 0261 COIL

610 208 3781 COIL L521 645 001 5748 INDUCTOR,33U K L601 645 012 3337 LINE FILTER L607 610 237 1000 PIPE CORE L608 610 237 1000 PIPE CORE L615 645 002 1787 CORE,PIPE L801 645 008 2894 INDUCTOR,5.6U K L841 645 008 0203 INDUCTOR,5.6U K L871 645 008 0203 INDUCTOR,5.6U K L881 645 011 0221 INDUCTOR,1.5U K

DIODE

D001 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D002 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D1007 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC D1011 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC D1015 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC D1016 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC D1019 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC

D1020 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC

D1021 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176

D1031 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176

D1032 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176

D135 407 063 8309 ZENER DIODE MTZJ11C

407 158 3400 ZENER DIODE UZ-11BSC D1910 407 116 6504 LED SLP-181B-51 D221 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D222 407 005 4505 DIODE DS442X

407 013 1008 DIODE 1S1553

407 013 4306 DIODE 1S2076A

407 013 6508 DIODE 1S2471 D251 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D252 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D253 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D254 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D271 407 053 6407 ZENER DIODE MTZ5.1C

407 056 8200 ZENER DIODE RD5.1EB3

407 163 8209 ZENER DIODE UZ-5.1BCC D351 407 163 9909 ZENER DIODE UZ-9.1BCA

407 162 2703 ZENER DIODE UZ-9.1BCB D352 407 005 7308 DIODE EM01Z

407 005 8602 DIODE ERA15-02 D441 407 095 8001 DIODE ERD07-15L D442 407 006 4108 DIODE ERB44-04 D445 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D446 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D447 407 199 8600 ZENER DIODE UZ-7.5BSC

407 199 8709 ZENER DIODE UZ-8.2BSA D465 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D466 407 164 7805 ZENER DIODE UZ-20BCA D469 407 007 7405 DIODE EU1 D491 407 007 7405 DIODE EU1 D495 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176 D501 407 005 7308 DIODE EM01Z

408 009 9008 DIODE BYD33D D603 407 006 6300 DIODE ERC05-10B

407 009 6901 DIODE RM11C D604 407 006 6300 DIODE ERC05-10B

407 009 6901 DIODE RM11C D605 407 006 6300 DIODE ERC05-10B

407 009 6901 DIODE RM11C D606 407 006 6300 DIODE ERC05-10B

407 009 6901 DIODE RM11C D614 407 005 4505 DIODE DS442X

407 013 1008 DIODE 1S1553

407 013 4306 DIODE 1S2076A

407 013 6508 DIODE 1S2471 D615A 407 173 2907 PHOTO COUPLE PC123F2 D616 407 005 4505 DIODE DS442X

407 013 1008 DIODE 1S1553

407 013 4306 DIODE 1S2076A

407 013 6508 DIODE 1S2471 D617 407 007 6606 DIODE ES1

407 007 6903 DIODE ES1Z

408 009 9008 DIODE BYD33D D618 407 005 4505 DIODE DS442X

407 013 1008 DIODE 1S1553

407 013 4306 DIODE 1S2076A

407 013 6508 DIODE 1S2471 D619 407 057 8209 ZENER DIODE RD8.2EB1 D631 407 007 7702 DIODE EU2A D633 407 007 7603 DIODE EU2

407 007 7801 DIODE EU2Z

!!!

!

Ref. No. Part No. Description Ref. No. Part No. Description

-18-

F4ATV

408 007 2506 DIODE BYW32

D634 407 007 7603 DIODE EU2

407 007 7801 DIODE EU2Z 408 007 2506 DIODE BYW32

D635 407 007 7603 DIODE EU2

407 007 7801 DIODE EU2Z

408 007 2506 DIODE BYW32 D641 407 057 4003 ZENER DIODE RD6.8EB1 D643 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D644 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D645 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D646 407 053 3109 ZENER DIODE MTZ12A

407 054 3108 ZENER DIODE RD12EB1

407 164 6808 ZENER DIODE UZ-12BCA D649 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D661 407 005 8602 DIODE ERA15-02 D669 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D683 408 007 8607 DIODE 1N4148

407 013 1206 DIODE 1S1555 D685 407 057 4003 ZENER DIODE RD6.8EB1 D805 409 013 0104 IC HZT33

409 026 8005 IC L5630

409 057 5103 IC UPC574J D831 407 005 4505 DIODE DS442X

407 013 1008 DIODE 1S1553

407 013 4306 DIODE 1S2076A

407 013 6508 DIODE 1S2471

D861 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176

D862 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176

D871 407 012 4406 DIODE 1SS133

407 012 5809 DIODE 1SS176

D872 407 055 7907 ZENER DIODE RD3.6EL

MISCELLANEOUS

F601 423 022 2102 FUSE 250V 4A F601-A1 645 000 5077 HOLDER,FUSE F601-A2 645 000 5077 HOLDER,FUSE A101 645 023 4118 TUNER,U/V A101P1 645 008 4058 TERMINAL,PLUG A101P2 645 008 4058 TERMINAL,PLUG A1901 645 028 1044 REMO REC SPS-443-1-E TP-A 645 008 4058 TERMINAL,PLUG TP-D 645 008 4058 TERMINAL,PLUG TP-E 645 008 4058 TERMINAL,PLUG J124 401 037 5014 MT-GLAZE 0.000 ZA 1/10W J813 401 037 5014 MT-GLAZE 0.000 ZA 1/10W K1001 645 005 5867 SOCKET,RGB 21P

610 234 3779 SOCKET 21P

K1001Z 610 261 2813 MOUNTING-BRKT F2WV KAC-1 645 008 4058 TERMINAL PLUG KDY-1 645 008 4058 TERMINAL PLUG PS601 408 013 3801 TH PTH451C262BF140M27

0

SW1901 610 011 2698 SWITCH,PUSH SW1902 610 011 2698 SWITCH,PUSH SW1903 610 011 2698 SWITCH,PUSH SW1904 610 011 2698 SWITCH,PUSH SW1905 610 011 2698 SWITCH,PUSH SW1906 610 011 2698 SWITCH,PUSH SW501 610 011 2728 SWITCH,LEVER 1P-3T SW601 645 017 0928 SWITCH,PUSH POWER 2P-2T X131 421 004 7701 SAW F TSF5344 X151 645 000 4490 TRAP,CERAMIC 6.5MHZ

610 015 3011 TRAP,CERAMIC 6.5MHZ

X152 610 015 3547 CERAMIC TRAP

610 015 2854 TRAP,CERAMIC 5.5MHZ

X161 645 003 2806 CERAMIC FILTER X162 645 007 7326 CERAMIC FILTER X201 645 018 9050 OSC,CRYSTAL 4.433619MHZ

610 249 5577 CRYSTAL OSCILLATOR

X231 610 226 6894 TRAP,CERAMIC 5.74MHZ

610 012 2222 TRAP,CERAMIC 5.74MHZ

X871 645 015 8339 OSC,CRYSTAL 12MHZ

645 018 9593 SC,CRYSTAL 12MHZ

ASSY,PWB,CRT F4ATV 1AA0B10H022FB

TRANSISTOR

Q701 405 041 6507 TR 2SC2621-D-RA

405 041 6705 TR 2SC2621-E-RA 405 066 9903 TR 2SC2688(1)-K 405 067 0008 TR 2SC2688(1)-L 405 067 0107 TR 2SC2688(1)-M 406 000 3605 TR 2SC3620(LB-SAN-1)

Q711 405 041 6507 TR 2SC2621-D-RA

405 041 6705 TR 2SC2621-E-RA 405 066 9903 TR 2SC2688(1)-K 405 067 0008 TR 2SC2688(1)-L 405 067 0107 TR 2SC2688(1)-M 406 000 3605 TR 2SC3620(LB-SAN-1)

Q721 405 041 6507 TR 2SC2621-D-RA

405 041 6705 TR 2SC2621-E-RA 405 066 9903 TR 2SC2688(1)-K 405 067 0008 TR 2SC2688(1)-L 405 067 0107 TR 2SC2688(1)-M 406 000 3605 TR 2SC3620(LB-SAN-1)

Q741 406 007 1901 TR JC556A

406 007 1802 TR JC556B 405 004 4205 TR 2SA608-E-CTV-NP 405 004 4809 TR 2SA608-F-CTV-NP 405 028 7909 TR 2SA608-G-CTV-NP

CAPACITOR

C701 403 073 6403 CERAMIC 470P K 50V

C711 403 073 6403 CERAMIC 470P K 50V C721 403 073 6403 CERAMIC 470P K 50V C731 403 077 2807 CERAMIC 1000P Z 2K

RESISTOR

R701 401 018 2800 CARBON 330 JA 1/4W R702 401 017 1844 CARBON 2K7 JA 1/4W R703 401 012 5708 CARBON 1K JA 1/4W R704 401 065 4604 OXIDE-MT 12K JA 2W R705 401 009 6602 CARBON 3.3K JA 1/2W R711 401 018 2800 CARBON 330 JA 1/4W R712 401 017 1844 CARBON 2K7 JA 1/4W R713 401 016 3809 CARBON 2.2K JA 1/4W R714 401 065 4604 OXIDE-MT 12K JA 2W R715 401 009 6602 CARBON 3.3K JA 1/2W R721 401 018 2800 CARBON 330 JA 1/4W R722 401 017 1844 CARBON 2K7 JA 1/4W R723 401 015 2704 CARBON 1.8K JA 1/4W R724 401 065 4604 OXIDE-MT 12K JA 2W R725 401 009 6602 CARBON 3.3K JA 1/2W R727 401 020 0801 CARBON 470 JA 1/4W R741 401 020 2003 CARBON 4.7K JA 1/4W R742 401 018 3807 CARBON 3.3K JA 1/4W R744 401 018 2800 CARBON 330 JA 1/4W

VARIABLE RESISTOR

VR701 645 003 5722 VR,SEMI,4.7K N VR702 645 003 5647 VR,SEMI,1K N VR711 645 003 5722 VR,SEMI,4.7K N VR712 645 003 5647 VR,SEMI,1K N VR721 645 003 5722 VR,SEMI,4.7K N

MISCELLANEOUS

K701 610 233 7990 CRT SOCKET

!

!!!!!

!

Ref. No. Part No. Description Ref. No. Part No. Description

-19-

F4ATV

-20-

SANYO ELECTRIC CO. LTD

Service Manual-EC5 Chassis

Part No. SKP20207 F4ATV (SHEET 1/2)

COLOUR TELEVISION

SERVICE REF.NO.

MODEL NUMBER

CHASSIS SERIES

CE25MT2A-C-01

CE25MT2A-C

The service Precaution:

The area enclosed by this line ( ) is directly connected with AC mains voltage. When servicing the area, connect an isolating transformer between TV receiver and AC line to eliminate hazard of electric shock.

NOTIZIE SULLA SICUREZZA DI FUNZIONAMENTO

Ogni sotituzione di componenti va fatta tenendo conto della sicurezza di funzionamento. I componenti indicati sollo schema con il simbolo /!\ hanno particolare importanza per il sicuro funzionamento del TV. I suddetti componenti devono essere sostituti esclusivamente con quelli indicati nell'elenco.

PRECAUZIONE DI SERVIZIO

L'area inclusa in questa linea ( ) è collegata direttamente con la tensione della rete CA quando si serve l'area collegare un trasformatore isolante tra il ricevitore TV e la linea CA per eliminare il pericolo di scossa elettrica.

Product safety notice:

Product safety should be considered when a component replacement is made in any area of a receiver. Components indicated by a mark /!\ in this circuit diagram show components whose values have special significance to product safety. It is particularly recommended that only parts specified on the part service manual be used for components replacement pointed out by the mark.

Note sul diagramma di circuito :

1. Tutte i valori di resistenza sono in ohm, K=1,000, M=1,000,000.

2. Tutte le resistenze nominali watt sono di 1/6 a meno che sia specificato altrimenti.

3. Eccetto per i condensatori elettrolitici, tutti i valori di capacitanza di meno di sono espressi in µF, e di piu di 1 sono in pF. I varoli di capacitanza elettrolitici sono in µF.

4. Tutti volt di capacitanza nominali sono di

50V a meno cha sia indicato altrimenti.

5. Tutti valori di inductanza sono in µH.

6. I valori letti del voltaggio presi con un "VTVM" proven gono dal punto indicato sulla massa del chassis, i valori di voltaggio presi usando un segnale di barre colore sono con tutti i controlli alle loro posizioni normali ed il commutatore AFC in posizione "OFF". Il voltaggio puo variare

con l'intensita del segnale.

7. Le forme di onda furono prese con il segnale di barre colore e i controlli regolati oppure le forme di onda di immagine normale furono prese usando un oscillatore a larga banda ed una sonda bassa capasità.

8. Rispetto a quando indicato su questo schema possono essere state introdotte delle modifiche.

9.■ I diodo 1S1555 possono essere sostitutti

con 1S2473, 1S2076 oppure DS472 a meno che sia specificato altrimenti.

■ I transistori possono essere sostitutti con

2SC536(Q,R,S), 2SC1740(Q,R,S), 2SC945A(Q,R,P) oppure 2SC1815(G,O,Y) a meno che sia specificato altrimenti.

■ Il transistore 2SA608(E,F) puo essere

sostituito con 2SA933(Q,R), 2SA564(QA,RA), oppure 2SA1015(O,Y)

Circuit diagram notes :

1. All resistance values are in ohms, K=1,000, M=1,000,000.

2. All resistance rated wattages are 1/6W unless otherwise noted.

3. Excepting electrolytic capacitors, all

capacitance values of less than 1 are expressed in µF and more than 1 are pF.

4. All capacitance rated voltages are 50V unless otherwise noted.

5. All inductance values are in µH.

6. Voltage readings taken a digital voltmeter are from point indicated chassis ground. Voltage readings taken by using a colour bar signal are with all controls at normal position. Some voltages may vary with signal strength.

7. Waveforms were taken with colour bar and controls adjusted for normal picture. Waveforms were taken by using a wide band oscilloscope and a low capacity probe.

1

AUTO SORTING

OPTION

POWER LED

SCART

OPTION

KEY SCAN

VOL

BAND 3

IGNOR

SERVICE

TV/AV

VSSD

50/60

VCC

B

R

BLK

VDDA

X-OUT

VDDM

POWER

FAIL

IDENT

VSSA

CVBS0 (TV)

RESET

AFT

Q871/Q872/

Q873/Q874/Q875

L'

H-SYNC

RGBREF

ODD/EVENIREF

BLACK

CVBS1 (AV)

L

5.5/6.5x

NEGA/POSI

SDA

SCL

POWER

G

V-SYNC

VDDT

OSCGND

X-IN

BLK

RC IN

SCL

SDA

BAND 2

BAND 1

SHARP NESS

COLOR

CONT

BRIGHT

TUNING

NC

TEST IN

TEST OUT

SAND CASTLE

TEST IN

GND

VCC1

CLR

CONT

B-IN

G-IN

R-IN

BLK

R-OUT

G-OUT

B-OUT

BRIGHT

TV/AV

S-CHR.

CVBS

EXT(1V)

SHARP NESS

CVBS

INT(2V)

CAL DEC

GND

VCC

GND

DIS DEC

V-OUT

(2V)

A-IN

SIF-IN

IDENT

(T.B)

IF C/R

SCART OUT

GND F.B FILTER VOL MUTE IN VCC1VCC2 OUT

R <POWER>

PRESET

FUNCTION

VOL-

VOL+

POS-

POS+

R/C PRE AMP.

Q613H 4AA0HA 0020---

D603/.../D606

C603/.../C605

1

2

1

2

D614/D616/D618

Q631/Q685

D649/D669

H-DRIVE TRANS

HORIZ DRIVE

VCC

IN

OUT

GND

IC501H 4AA0HA 0018---

Q461H 4AA2HA 0034---

ODD/EVEN

IC661H 1AA2HEA 0083--

NOTES;

1. RESISTORS SPECIFIED WITH RESISTANCE VALUE ARE "1/6DJ".

2. RESISTORS SPECIFIED WITH TYPE OF RESISTOR, TOLERANCE AND RESISTANCE VALUE ARE "1/4".

3. ALL CAPACITORS ARE 50WV RATING UNLESS OTHERWISE NOTED.

4. PARTS MARKED WITH ARE RELATED WITH X-RADIATION.

5. THICK LINES ARE 15WATTS SUPPLY LINE.

6. VIEW OF TR & IC.

7. ISOLATION BORDER LINE.

COLD SIDE HOT SIDE

N

1

TOP VIEW

LETTER SIDE

E

C

B

E

B

C

E

B

1

2

3

IN CASE OF TR IN CASE OF IC

8. LIST OF REPLACEABLE DIODES.

R (7DD00019) 1S1555, 1S2076, 1S2473, DS442, 1N4148

P (7DD00021) 1S1553, 1S2076A,1S2471, 1N4148

9. LIST OF REPLACEABLE TRANSISTORS.

AE (7QT00202)

AD (7T200183)

AB (7T200181)

2SC536 2SC945A 2SC1815

2SA608 2SA564A 2SA1015

E,F,G

F,G

E,F

R,Q,P

Q,P

Q,R

O,Y,GR

O,Y

Y,GR

10. "J" : JUMPER WIRE. "X" : PART NOT USED.

AC (7T200182)

FRY

2SC1740S

Q,R,S

2SA933S

Q,R

R

AA (7DD00192) 1S1555, 1S2076, 1S2473, DS442, 1N4148, 1SS176, 1SS133, GMA01

M (7ED00025) 1SS176, 1SS133, GMA01

R842 DJ10K

D831 1SS133: 1SS176

W901

L901

R864

R896

R897

R898

C020

D646

R646

R881

R884

JS1902

R1912

D805

A1901

C878

X871

R839

Q839

R1908

R2003

JS819

D645

L803

R123

R122

R880Q875

D1910

R801

C801

L801

L802

R808

C805

R806

R804

C808

C807

JS142

R243

R241

Q241

R242

JS141

D862

R811 R892

L841

R836

C834

R834

R837

R833

Q831

R832

D861

C841

R895

Q874

C872

D871

R856

R843

R800

R863

C879

R848

R852

L871

R2001

C2003

R887

R885

L881

IC802

TP-D

Q861R862

R841

R840

C121

R121

Q121

R803

Q801

R802

R891

R842

C875

R883

C885

R876

D872

R878R877

Q873

C873

C874

C871

R871

R868

R865

R866

R867

R2004

R861

Q2001

R2002

C2001

C2002

R819

C881

R846

R847

R844

C882

R873

R838

R879

R875

C861

R874

Q871

R872

R828

R817

R813

R822

R827

C829

Q872

R824

C819

C814

C824

R818

R814

R823

IC801

IC001

C003

C002

C004

C005

R004

C006

R006

C010

C011

C012

R002

C001

R001

D001

D002 R003

C013

IC271

Q201

R217

IC201

C206

C207

C208

C233

C231

C212

R231

R218

L231

L232

L201

L202

L203

R203

R204

R205

SW1906

SW1905

SW1904

SW1903

SW1902

SW1901

R1911

D1901

R1901

R1902

R1903

R1904

R1905

R1906

R1907

R1909

KL

R807

R805

C870

R870

R869

L831

L826

L821

L816

L811

R831

R826

R821

R816

R812

L832

C276

C277

C275

R232

X231

IC001H

R626

D634

C634

C644

R645

C645

D635

D633

C643

D631

C631

C641

R637

R638

T611

Q613

R623

C607

R624

PS601

L612

L611

JS612

R602

D615A

IC691

R635

R636

D641

R625

R628 R629

C621

C617

Q612

C615

R619

C614

R622

R621

R620

R615

D617

D616

R617

C603

C604

C605

C606

Q611

R611

C601

C613

D619

D618

D614

R601

D606D604

D603 D605

D649

R639

R651

Q651

R652

Q686

R689

R688

Q685

D685

C685

R687

R686

Q682

C691

C624

Q631

R681

L610

VR631

KE

R643

R642

D683

L631

L633

L635

L634

KAC

F601-A2

F601-A1

SW601

KAC-2

KAC-1

KE-1

KE-2

IC661P1

C602

JS631

C663

L661

C662

R663

D669

R661

D661

D662

JS610

L607

L608

IC661

Q661

L615

D644

D643

JS613

C608

L601

C616

R662

F601

R666

C434R434

R433

C433

C432

Q431

R432

C431

T431

R226

R371

D351

L431

C501

IC501

D501

C505

C503

R501

R2005

C506

C504

C502

R502

L521

D469

L462

C462

C468

D466

C464

R464

R463

C467

C470

D465

R465

R468

C466

R469

R480

R472

R473

R471

C465

Q461

R227

R474

C438

VR461

Q462

L461

D222D221

D352

SP901

W10B00100

L81B16100

1/10GJ 1K

1/10GJ

3.9K

1/10GJ

3.9K

1/10GJ

3.9K

KZ0.01F

MTZ12A: RD12EB1: UZ-12BCA

2.2K

1/10GJ 27K

1/10GJ

2.7K

J

2.2K

HZT33: L5630: UPC574J

U20B20900

KK 4700BA

V10B1690N: V10B2120N

1/10GJ

4.7KQT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 330

1/10GJ 12K

1/10GZ

0.0

1S1555: ED0274

J

1/10GJ 220K

1/10GJ 47K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

SLP-181B51

1/10GZ

0.0

KZ

0.01FA

L2B9 5R6KN

J

EM4.7

2SJ 18K

DJ10K

X

KZ0.1FA

J

220

1/10GJ 470

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

220

J

1SS133: 1SS176

1/10GJ

4.7K

1/10GJ

4.7K

L2C1 5R6KN

1/10GJ

1.2K

EM1

1/10GJ

4.7K

1/10GJ 47K

1/10GJ 82K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 12K

1SS133: 1SS176

KZ

0.01FA 1/10GJ

1.2K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

16EM 47

1SS133: 1SS176

DJ22K

1/10GJ 10K

1/10GJ

2.2K

1/10GJ 22K

25KZ0.1FA: KZ0.1FA

DJ4.7K

DJ1K

L2C1 5R6KN

1/10GJ 27K

25KZ0.1FA: KZ0.1FA

1/10GJ

3.9K

1/10GJ

3.9K

L2B9 1R5KN

24C02A/P: 24LC02B/P: ST24C02AB1

J30B0250N

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

1/10GJ 22K

DJ4.7K

25KZ0.1FA: KZ0.1FA

1/10GJ 47K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 180K

PH2369

1/10GJ

2.2K

1/10GJ

4.7K

DJ3.9K

25KZ0.1FA: KZ0.1FA

DJ470

KK1000BA

1/10GJ 10K

RD3.6EL

1/10GJ

1.5K

1/10GJ

8.2K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

CJ22CA

25KZ0.1FA: KZ0.1FA

1/10GJ

4.7K

1/10GJ

1.2K

1/10GJ

4.7K

1/10GJ

4.7K

1/10GJ

4.7K

1/10GJ 150

1/10GJ

2.7K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 10K

25KZ0.1FA: KZ0.1FA

1/10GJ 47K

KZ0.01FA

DJ4.7K

DJ10K

1/10GJ 10K

16EM 10

1/10GJ

4.7K

1/10GJ 15K

DJ10K

1/10GJ

5.6K

FJ5600 (D:BE)

1/10GJ 10K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 33K

1/10GJ 10K

1/10GJ

1.5K

1/10GJ 10K

1/10GJ

3.9K

EM1

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

47K

25EM

4.7

25EM

4.7

EM1

1/10GJ 22K

1/10GJ

3.3K

1/10GJ

8.2K

QXXAVB063A--N

AN5265

FK1000 (BE:D)

63GK0.47V :HJ0.47G

EM

4.7

16EM 10

1K

16EM 10

10K

63GK0.1V :HJ0.1G

25EM 1000

25EM 470CD

560

16EM 33

DJ33

1S1555: ED0274

10K

PM1

U3665M

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 22K

TDA8361/N5-N

25KZ0.1FA: KZ0.1FA

63GK

0.47V :HJ

0.47G

25KZ0.1FA: KZ0.1FA

EM

2.2

1/10GZ

0.0

DJ1.8K

J

L2B94R7KN

1/10 GJ100

S10B1130N

470

X

56K

15K

DJ8.2K

4.7K

1/10GJ

2.7K

1/10GJ

2.2K

1/10GJ

1.5K

1/10GJ 10K

J10EA030N

1/10GJ 10K

1/10GJ

8.2K

CJ33CA

1/10GJ 22K

1/10GJ 27K

J

1/10GJ 100

1/10GJ

1.2K

1/10GJ 100

1/10GJ

2.2K

1/10GJ

2.2K

J

KZ

0.01FA

KZ

0.01FA

KZ

0.01FA

1/10GJ 100

F32B0110N: F32B0160N

2HA0038---

DG

3.3K

EU2(:Z): ED0277

1000KK470 (NH:CRD:CTB)

25EM 1000 (T:DT)

3WK18FH

25EM 1000 (T:DT)

EU2(:Z): ED0277

35EM470T

EU2A

1000KK470 (NH:CRD:CTB)

200EM 220XD

DJ 180K

1SJ 33K

L51B05700: L51B0660N

2SC3895 TYB

2.7K

400EM 220XC

2SJ82

EV0038

J

7WK3.9 (I:VC)

PC123F2

BA178M05T: MC78M05CT: UPC78M05AHF: AN78M05-LB: L78M05CV

DJ100K

DJ4.3K

RD6.8EB1

2SJ68

1/2CK

5.6MXG

1/2CK

5.6MXG

400KK1000XH: 400KM1000XS

FK0.022 (BE:D)

2SC3807 RYA

FJ0.015 (BE:D)

DJ22

63GK0.1V :HJ0.1G

DJ15K

1/2DJ 120K

DJ22K

ES1: ES1Z: ED0448

DS442X: 1S1553: 1S2076A: 1S2471

1K

XXX

1000KK1000 (CBB:HB)

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

5.6K

250HM0.1XD: 250GM0.1XBC

X

RD8.2 EB1

DS442X: 1S1553: 1S2076A: 1S2471

1/2DJ 220K

RM11C: ERC05-10B

1S1555: ED0274

12K

DJ10K

2SB985(S:T): 2SA1707(S:T)

DJ3.9K

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

22K

DJ10K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

RD6.8EB1

EM1

DJ560K

DJ220K

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

10EM100

400KK470XH: 400KM470XJ

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

DJ10K

J

R3D6222NJ: R30132XM<B-2.2K;2K>

X

J

1SJ

1.5K

1S1555: ED0274

J

X

J20B00100: J3EZ0333-

S10B2490N

250HM0.1XD: 250GM0.1XBC

J

10EM 220

J

16EM 470

DJ1.2K

1S1555: ED0274

DJ10K

ERA 15-02

J

Z20103---

BA178M09T: UPC78M09AHF

2SB764E

Z21B0040N

1S1555: ED0274

J

X

F35B0330N

2000KK 680(NH: CRD:CTB)

2SJ8.2

4A250VT CSL

1/2DJ 18

35EM471/2DJ

390

1/2DJ 1K

500KK 3900A

500KK 1000A

2SC3332

(R:S) 1/10GJ 1K

25KZ

0.056FA

AD0002 (:C)

1/10GJ 100K

DJ10K

UZ-9.1 BC(A:B)

L2G3 1R0MN

35EM470

LA7833

EM01Z: ED0448

500KK 1000A

CJ 39CA

DJ4.7K

DJ12K

100GK

0.22P

KZ0.01FA

35EM220

4.7

L2C2330KN

EU1

AA0025 (:A)

EM1

25EM22

UZ-20 BCA

0.47

DJ1.5K

1.5K

10EM 220

KZ0.01F

1SS133: 1SS176

1/10GJ 560K

1.8K

63GK0.1V :HJ0.1G

68K

47K

DJ680

1.5K

100GK

2.2

2SB1274 (QRA:RRA :SRA)

10K

1/2DJ270

FK0.01 (BE:D)

R3D6472NJ: R3L1502NJ <B-4.7K,B-5K>

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

LM0045

DS442X: 1S1553: 1S2076A: 1S2471

1SS133: 1SS176

EM01Z: ERA15-02

VS003PEB

C800 1/10GZ

0.0

R010 1K

BG

5V

R850 1/10GJ

4.7K

DK

Q847 QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

R851 1/10GJ 1K

3

2

1

8

7

6

54

3

2

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26 27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

123456789

1

2

3

4

5

6

7

8

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

5

8

2

31112

13

14

15

16

17

1432

123

321

1234567

P.F

5V

5V5V

BAND3

BAND2

BAND1

TUNE

5V

VOL

SCRT

9V

IDNT

IGNR B

G

R

BLK

P.F

TV

8V

SHRP

9V

COLR

BRIT

CONT

18V

VOL

9V

TV

COLR

CONT

BRIT

SHRP

9V

BLK

RGB

5V-A

150V

5V-A

150V

24V

18V

5V

9V

P.F

8V

24V

IC001H2

IC001H1

R645H2 R645H3

C641H2

C641H1

R602H1

R602H2

Q613H3

Q613H2

Q613H1 Q613H4

Q613H5 Q613H6

T611H11

T611H8

T611H2

C607H2

C607H1

T611H5

T611H17

SW601H2

SW601H3

SW601H1

SW601H4

L601H1

L601H2

L601H3

L601H4

Q432H4 Q432H5 Q432H6 Q432H7

IC501H1

IC501H4

IC501H2

Q461H1

L462H1L462H2

J30B0250N

R166 680

VC141

C147

C148

C146

R146

R147

R148

C3C21000N

KZ

0.01FA

CJ15CA

KZ

0.01FA

1/10GJ

5.6K

1/10GJ

5.6K

DJ1K

L'

C152

Q152

C151

L152

R155

R157

R158

Q153

CJ47CA

CJ27CA

L2B9

220KN

1/10 GJ1K

R159

QT0378(A:B): 2SC536(E-NP:

F-NP:G-NP)

1/10GJ 1K

QT0379(A:B): 2SA608(ECNP:

Q151/Q153/Q154 Q152 QT0379(A:B): 2SA608(ECNP:

C140

L141

R156

R171

C160

X152

R170

R163

C154

R167

X161

R162

Q161

C143

C142

C136

C215

C137

C135

R141

C141

R150

R152

X151

L151

D135

R160

T141

R161

Q151

R151

C161

Q162

CJ12CA

L2B9 100KN

1/10GJ

4.7K

1/10GJ 10K

KK1000 BA

F32B0140N

1/10GJ

5.6K

220

CJ82 CA

1/10GJ 47

L161 L2B98R2KA

F31B0020N <5.5MHZ>

C153

R164

L162

X162

CJ100 CA

1/10GJ 47

L2B98R2KA

F31B0170N <6.5MHZ>

1/10GZ

0.0

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

KK3900 BA

25KZ0.1FA: KZ0.1FA

16EM 470CD

25KZ0.1FA: KZ0.1FA

1/10 GJ

6.8K

CJ56RA

1/10GJ 1K

1/10 GJ 180

F32B00100: F32B0090N

L2B9 8R2KN

MTZJ11C: UZ-11BSC

1/10GJ 1K

SL0005XV

DJ390

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

DJ 390

KK270BA

Q154

Q163 R169

680

C156 KZ

0.01FA

C155 KZ

0.01FA

IDNT

8V

DK

9V

R168 1/10GJ 12K

BG

R165 1/10GJ 12K

9V

Main/CRT Board /Pannello Principal/Cinescopio

Circuit side/Lato del Circuito

8. This circuit diagram covers a basic or representative chassis only. There may be some components or partial circuit differences between the actual chassis and the circuit diagram.

9. ■ Diode 1S1555 may be replaced with

1S2473, 1S2076 or DS472 unless otherwise noted.

■Transistor 2SC536(Q,R,S), 2SC1740(Q,R,S), 2SC945A(Q,R,P) or 2SC1815(G,O,Y) unless otherwise noted.

■ Transistor 2SA608(E,F) may be replaced with 2SA933(Q,R), 2SA564(QA,RA), or 2SA1015(O,Y) unless otherwise noted.

E

C

B

E

C

B

E

C

B

A

K

A

K

A

K

1

N

N/2

N/2 + 1

3

2

1

4

5

6

7

3

2

1

9

10

B

C

E

B

C

E

Terminal guide

C : Collector B : Base E : Emitter

A : Anode K : Kathode

Expression of capacitance and resistance in circuit diagram.

Capacitance (Example)

1000 C M 2000 D

Characteristic Capacitance value (220pF) Tolerance (±20%) Kind(Ceramic) Rated voltage (1,000V)

Resistance (Example)

1/2 N J 1.2

Resistance value (1.2Ω) Tolerance (±5%) Kind (M.carbon) Rated wattage(1/2W)

D : Carbon N : Metallized carbon S : Oxide metallized W : Wire wounding C : Solid

T, A, U, D : Electrolytic C, K, B : Ceramic F : Mylar film M, N : Polypropylene Z : Metallized paper

J= ± 5% K= ± 10% M= ± 20%

Transistor

C

B

E

Diode

K

A

Resistor

123

12 x 103= 12k

Chip Components

IC201-pin7

IC201-pin15 <CVBS in>

IC201-pin18

<B out>

IC201-pin19

<G out>

IC201-pin20

<R out>

IC201-pin28

<B-Y in>

IC201-pin29

<R-Y in>

IC201-pin37

<H out>

IC201-pin38

<H F/B>

IC201-pin41

<V F/B>

IC201-pin42

IC201-pin43

<V out>

Q431-C

Q432-C <H out>

Q461-E

<Pcc>

IC501-pin4

<V in>

IC501-pin2

<V out>

Q611-C

Q612-C

Q613-C

IC801-pin36 <CPU H in>

IC801-pin37 <CPU V in>

Q2601-C

Q2611-C

Q2621-C

IC3811-pin8 <Sound out>

1V/div. 10µs/div.

10V/div. 10µs/div. 250V/div. 10µs/div.

250V/div. 10µs/div.

1V/div. 10µs/div.

1V/div. 5ms/div.

20V/div. 10µs/div.

0.2V/div.

200µs/div.

20V/div. 10µs/div.

5V/div. 5ms/div.

0.2V/div. 10µs/div. 0.5V/div. 10µs/div.

1V/div. 10µs/div.

0.2V/div. 5ms/div.

0.5V/div. 5ms/div.

10V/div. 5ms/div.

1V/div. 10µs/div.

0.2V/div. 10µs/div.

1V/div. 10µs/div.

0.5V/div. 10µs/div.

Waveforms on ICs and Transistors

Voltage on ICs

IC001

1 1.6V 2 1.6V 3 15.5V 4 1.6V 5 1.6V 6 0V 7 - 8 13.8V 9 28.6V

10 14.0V 11 0V IC201

1 3.1V 2 6.0V 3 6.0V 4 6.1V 5 0V 6 4.0V 7 3.1V 8 1.6V 9 0V 10 8.0V 11 0V 12 3.6V 13 4.4V 14 3.2V 15 3.9V 16 0V 17 3.4V 18 2.5V 19 2.5V 20 2.5V 21 0.2V 22 3.4V 23 3.4V 24 3.4V 25 2.9V 26 1.6V 27 5.9V 28 4.0V 29 4.0V 30 1.5V 31 1.5V 32 0V 33 4.9V 34 3.5V 35 2.6V 36 8.0V 37 0.9V 38 0.7V 39 3.0V 40 4.0V 41 2.5V 42 0V 43 0.8V 44 4.1V 45 4.1V 46 4.1V 47 7.0V 48 3.1V 49 1.6V 50 3.6V 51 4.3V 52 6.7V

IC271

1 5.3V 2 0V 3 0V 4 0V 5 0.7V 6 0V 7 0V 8 0V 9 5.2V 10 0V 11 3.1V 12 3.1V 13 0V 14 1.3V 15 0V 16 1.3V

IC501

1 0V 2 13.4V 3 25.3V 4 0.7V 5 0.7V 6 25.2V 7 2.1V

IC651

IC652

1 14.5V 2 0V 3 11.9V 1 10.5V 2 0V 3 8.0V

IC801

1 0.6V 2 2.4V 3 3.7V 4 1.8V 5 2.1V 6 0V 7 0V 8 0V 9 2.6V 10 0.5V 11 2.5V 12 0V 13 0V 14 3.7V 15 0V 16 0V 17 0V 18 0V 19 0V 20 0V 21 0V 22 0V 23 2.2V 24 0.2V 25 2.0V 26 2.3V 27 0V 28 0V 29 5.0V 30 5.0V 31 5.0V 32 0V 33 0V 34 0V 35 0V 36 0.8V 37 0.2V 38 4.9V 39 4.9V 40 0V 41 2.1V 42 2.4V 43 0V 44 4.9V 45 4.7V 46 5.4V 47 5.0V 48 0V 49 4.8V 50 4.8V 51 0V 52 2.9V

IC802

1 0V 2 0V 3 0V 4 0V 5 4.8V 6 4.8V 7 0V 8 5.0V

IC810

1 0V 2 11.6V 3 2.0V 4 0V 5 0V 6 11.3V 7 2.2V 8 0V 9 11.7V

IC1201

1 11.8V 2 7.8V 3 0V 4 7.1V 5 0V 6 0V 7 7.7V 8 0V

IC1202

1 3.0V 2 2.0V 3 6.0V 4 0V 5 0V 6 2.7V 7 0V 8 1.7V 9 5.7V

IC1251

1 8.4V 2 8.4V 3 5.0V 4 8.4V 5 0V 6 0V 7 0V 8 0V 9 0V 10 11.9V 11 5.0V 12 8.4V 13 8.4V 14 8.4V 15 8.4V 16 11.9V

IC3401

1 4.8V 2 3.4V 3 2.7V 4 2.5V 5 2.5V 6 2.5V 7 2.5V 8 2.5V 9 2.5V 10 2.5V 11 2.5V 12 2.5V 13 2.5V 14 2.5V 15 2.5V 16 0V 17 2.5V 18 5.1V 19 3.3V 20 4.8V

IC3431

1 5.8V 2 11.7V 3 5.8V 4 11.8V 5 0V 6 0V 7 5.8V 8 5.8V 9 5.8V 10 0V 11 4.8V 12 4.8V 13 5.8V 14 5.8V 15 5.8V 16 5.8V 17 0V 18 0V 19 0V 20 0V

IC3451

1 0V 2 0.3V 3 5.1V 4 0V 5 2.5V 6 0.4V 7 2.5V 8 2.5V 9 0V 10 0V 11 2.5V 12 0V 13 0V 14 0V 15 2.5V 16 2.5V 17 0.4V 18 4.6V 19 0V 20 2.3V 21 2.5V 22 2.5V 23 2.4V 24 0V 25 2.5V 26 5.0V 27 2.4V 28 2.3V 29 2.3V 30 2.3V 31 2.3V 32 0.3V 33 2.3V 34 2.3V 35 2.3V 36 4.7V 37 0V 38 4.8V 39 2.0V 40 3.4V 41 2.4V 42 0V 43 2.0V 44 0V 45 2.4V 46 4.8V 47 4.7V 48 2.0V 49 4.8V 50 0V 51 4.0V 52 0V

IC3801

1 4.5V 2 4.6V 3 6.0V 4 0V 5 0V 6 0V 7 0V 8 5.3V 9 5.3V 10 0V 11 11.9V 12 5.9V 13 0V 14 0V 15 4.5V 16 4.5V

IC3811

1 2.5V 2 0V 3 0V 4 0V 5 0V 6 0V 7 2.2V 8 2.2V 9 2.2V 10 2.2V 11 2.6V 12 4.3V 13 0V 14 5.1V 15 2.5V 16 0V

Voltage on Transistors

Q801

E0V C 2.0V B 0.6V

Q2001

E0V C 13.2V B0V

Q861

E 5.0V C 2.5V B 5.0V

Q875

E0V C 4.7V B0V

Q874

E 4.9V C 4.9V B 5.6V

Q873

E0V

C0V

B 0.8V

Q872

E0V C 0.2V B 0.6V

Q871

E0V C 6.3V B 0.1V

Q1902

E0V

C 5.0V

B 0.0V

Q1901

E 1.8V C 5.0V B 0.2V

Q121

E 2.8V C 8.0V B 3.3V

Q1003

E0V C 0.6V B0V

Q1202

E0V

C0V

B0V

Q1201

E0V C0V B 0.6V

Q652

E 5.2V C 8.3V B 5.8V

Q641

E 6.3V

C 29.5V

B 6.7V

Q613

E0V C-B -1.1V

Q612

E0V C -1.1V B -1.4V

Q611

E 10.8V C -1.4V B 10.5V

Q682

E 5.0V C 0.1V B 5.6V

Q681

E 5.0V C 7.8V B 5.7V

Q835

E0V C 29.4V B0V

Q001

E0V

C 15.5V

B 0.1V

Q1043

E 3.4V C 11.9V B 4.0V

Q1042

E 10.0V C 4.0V B 9.4V

Q1041

E 2.4V C 9.4V B 3.0V

Q171

E 2.5V C 11.8V B 3.1V

Q1005

E 5.0V C 11.9V B 5.6V

Q1004

E 5.0V C 11.9V B 5.6V

Q1002

E 0.1V C 11.8V B 0.6V

Q1001

E 0.6V C0V B0V

Q1203

E0V C0V B0V

Q2651

E 11.8V C0V B 11.9V

Q2640

E 1.5V C0V B 0.9V

Q3802

E 5.2V C 11.9V B 5.9V

Q3801

E 0.7V C 6.1V B 1.4V

Q462

E0V C 12.9V B 0.5V

Q461

E 12.9V C0V B 13.5V

Q432

E0V C-B0V

Q431

E0V C 10.8V B 0.3V

Q154

E 3.1V C0V B 2.4V

Q153

E 9.3V C 2.3V B 8.7V

Q152

E 3.2V C 8.7V B0V

Q151

E 3.8V C0V B 3.2V

Q501

E0V C 4.7V B0V

Q203

E0V

C 6.0V

B0V

Q202

E0V C 0.4V B0V

Q201

E0V C0V B 0.8V

Q1204

E0V C 11.9V B0V

Q3483

E 1.9V C 8.4V B 2.5V

Q1252

E 7.9V C 11.9V B 8.4V

Q1251

E 7.7V C 11.9V B 8.4V

Q3482

E 7.7V C 11.9V B 8.4V

Q2621

E 1.9V C 143.8V B 2.2V

Q3481

E 1.9V

C 8.4V

B 2.5V

Q2611

E 1.8V C 137.1V B 2.2V

Q3432

E 5.2V C 11.9V B 5.9V

Q2601

E 1.8V C 134.3V B 2.3V

Q3431

E 5.2V C 11.9V B 5.9V

Q3484

E 7.7V C 11.9V B 8.4V

W902

JG0112

MAIN :1AA0B10H022FA CRT :1AA0B10H022FB

DY

G-BIAS

G-OUT

R-DRIVE

R-BIAS

R-OUT

B-BIAS

B-OUT

B-DRIVE

5

1

PWB 1AA4B10E1140B

1

3

Q701,Q711,Q721

R102/R104/R106

R101/R103/R105

Q102/Q104/Q106

Q101/Q103/Q105

D251/../D254

V:IN

VCC2

GND

R-Y OUT

B-Y OUT

REF

B-Y IN

NC

R-Y IN

HUE

B-Y IN

R-Y IN

R-Y OUT

B-Y OUT

SECAM

COL-PLL

3.58XTAL

4.43XTAL

H-START

H-OUT

H-F/B

H-SHIFT

AFC1

V-F/B

V-RAMP

V-OUT

AFT

IF IN-M

IF IN-P

TU AGC

AGC CAP.

AGC ADJ.

A-OUT

S.C.P

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

A:OUT

A:IN

B

G

BLK

V:OUT

V:IN

R

VTR:PLAY

RGB

Q1021/Q1031

Q1022/Q1032

D1007/D1011/D1015/ D1016/D1019/D1020

11.IF

6.MB

5.LB

4.HB

3.UB

1.AGC

2.TU

5

1

FBT

HORIZ. OUTPUT

1

3

2

6

3

5

Q432H 4AA0HA 0019---

MODEL: CE25MT

2

CHASSIS: EC5-A

2

Q901

R725

Q721

R724

Q711

R714

R715

Q701

R705

R732

K701

C731

K7D

K7M

R704

K7P

K7Q

C732

L701

R703

R713

R723

R702

R701

C701

C711

R711

R712

R722

R721

C721

R741

R727

Q741

R742

R744

VR721

VR711

VR701

VR702

VR712

L700

L705

R102

R104

R106

L1002

L1006

C102

A101

D1032

R1029

R1026

R1027

R1028

C171

TP-E

L1021

R358

D1016

L1020

C100

Q251

D1031

D252

D253D254

K1001

R1020

R1016

R1015

R1011

R1019

R1007R1008

R1001

C1002

R1004

C1004

R1005

R1002

R1023

Q1021

Q1022

R1021

R1003

L1003

C1003

R1009

R1022

C1001

D1021

Q1031

Q1032

R1031

R1032

R1033

C1021

L1030

D1011

D1019

D1015

D1020

D1007

R105

Q105

Q106

Q104

Q103

R103

R101

Q101

Q102

C109

C108

C110

T101

R110

L103

C172

C273

C272

C271

D271

C274

R362

R365

C205

C204

C203

C202R202

C362

R137

C361

C353

C352

C351

C132

R138

R352

R364

R356

R351

X131

C134

R357

C363

C133

R133

R134

C201

R201

X201

R213

D361

C131

R361

R363

R174

R135

C138

C354

R271

VR361

VR131

R173

C173

A101P2

A101P1

KP

R251

R252

D251 C251

R253

L100

TP-A

R109

C105C101

L105

C106

C520

R496

D495

R495

T471

R223 R224

C421

Q432

R444

C441

L432

L444

R222

R491

D491

C491

C422

C492

L444P3

L444P2

L444P1

L444P4

C511

R507R506

R508

L501

R505

VR501

R509

R511

R513

SW501

C513

R429

C429

C424C425

D441

D442

L445P1

L445C512

JS435

R514

C222

R481

KDY

R448

D446

C445

R447

D445

KQ

KDY-1

KDY-3

KDY-6

KDY-5

D447

A59EHJ43X38 <VIDEO COLOUR>

1/2DJ

3.3K

QT0229Z: 2SC2621 (DRA:ERA): 2SC2688'1' (K:L:M)

2SJ 12K

QT0229Z: 2SC2621 (DRA:ERA): 2SC2688'1' (K:L:M)

2SJ 12K

1/2DJ

3.3K

QT0229Z: 2SC2621 (DRA:ERA): 2SC2688'1' (K:L:M)

1/2DJ

3.3K

X

EK0618L

2000KP 1000 AHE

X

J30B0250N

2SJ 12K

J10EA050N

J10EA030N

X

J

DJ1K

DJ2.2K

DJ1.8K

DJ3.9K

DJ330

KK470

DJ330

DJ3.9K

DJ330

KK470

DJ4.7K

DJ470

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

DJ3.3K

DJ330

R3D8472NJ

R3D8102NJ

J

ZZ0122

1/10GJ 12K

L2B9 100KN

KK1000 BA

F1BEB0090

1SS133: 1SS176

1/10GJ 390

1/10GJ 560

EM1

J30B0250N

Z21B0040N

X

MTZJ11C: UZ-11BSC

J

16EM 47

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

1SS133: 1SS176

J1EK1745-: J11B0490N

75

7539K

1/10GJ 12K

63GK0.47V :HJ0.47G

1/10GJ 560

16EM 10

1/10GJ 100K

1/10GJ 12K

DJ4.7K

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ 470

1/10GJ

5.6K

L2B9 100KN

KZ

0.01FA

1/10GJ 27K

10K

CJ100CA

1SS133: 1SS176

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

1/10GJ

1.2K

1/10GJ

3.3K

1/10GJ

1.2K

25KZ0.1FA: KZ0.1FA

J

MTZJ11C: UZ-11BSC

1/10GJ 47K

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

1/10GJ 47K

QT0379(A:B): 2SA608(ECNP: FCNP:GCNP)

QT0378(A:B): 2SC536(E-NP: F-NP:G-NP)

X

1/10GZ

0.0

L2B9 5R6KN

25KZ0.1FA: KZ0.1FA

KZ

0.01FA

KK 1000BA

RD5.1EB3: UZ-5.1BCC: MTZ5.1C

X

J

1/10GJ

4.7K

25KZ0.1FA: KZ0.1FA

KK4700BA

63GK0.1V :HJ0.1G

1/10GJ 100K

KZ

0.01FA

1/10GJ 100

KK2700 BA

KK4700 BA

FK4700 (BE:D)

63GK0.1V :HJ0.1G

KK1000BA

1/10GJ

5.6K

1/10GJ 1M

1/10GJ 100

100

SF5344

EM2.2

1/10 GJ10K

16EM 100

KZ0.01FA

1/10GJ 180

1/10GJ

8.2K

CJ18CA

1/10GJ

8.2K

V10B2110N: V1E042XCB

1/10GJ 15K

MTZJ11C: UZ-11BSC

1/10GZ

0.0

1/10GJ 390K

1/10GJ 22K

1/10 GJ15K

1/10GJ 22K

KZ

0.01FA

EM1

DJ220

R30128XMT: R3D6103NJ <B-10K>

R30128XMT: R3D6103NJ <B-1OK>

1/10GZ

0.0

16EM 10

J30B0250NJ30B0250N

J10EA050N

1/10GZ

0.0

1/10GJ 10K

1SS133: 1SS176

16EM 330

10K

J

J30B0250N

1/10GZ

0.0

EM116EM

47

J

KZ0.01FA

KK1000BA

5.6K

1SS133: 1SS176

180K

L40B05900

10K DJ1K

1500MJ 6200XE

2SD1556-3E

1SJ1K

400NJ

0.27 EAQ

J

AC0040 (:B:C)

DJ120K

1/2DJ

2.2

EU1

500KK 680A

1500MJ 5100XE

EM22

J30B0250N

100GK

0.1P

82

3.9K

2.7K

J

6.8K

R3D6101NJ: R3L1101NJ <B-100>

1SJ0.68

1SJ 470

1SJ 1K

S10B1370N

EM10

5WJ 10 (I:VC)

250GJ

0.47

400NJ

0.027 EAQ

400NJ

0.022 EAQ

ERD07

-15L

ERB44

-04

J30B0250N

L1AA0041-25EM

2200T

J

2.2

PM2.2X

2SJ1.5

X

1/2DJ330

1SS133: 1SS176

EM10

4.7K

1SS133: 1SS176

J10EA030N

UZ-7.5BSC: UZ-8.2BSA

R214 1/10GJ

6.8K

275 910

6

8

11

-41

9

10

11

12

13

14

15

16

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

64

10

7

35

2

1

9V

TUNE

BAND3 BAND2 BAND1

9V

IGNR

SCRT

9V

P.F

150V

P.F

Q432H1

Q432H2

Q432H3

T471H1 T471H2

T471H5

T471H10

T471H13

L444H3

L444H4

L445H2

R429H1 R429H2

C422H1

C422H2

C421H1

C421H2

D441H2

D441H1

L445H1

C441H2C441H1

Part No. SKP20207 F4ATV (SHEET 2/2)

Main Board /Pannello Principal

Component Location/Lato del Componente

SW601

F601

Fuse

D615

Q612

Q613

Power switching

T611

Converter

T471

FBT

R224

R492

AJ1

Mains SW

SW1901

Prog+

SW1904

Level-

SW1903

Level+

SW1902

Prog-

SW1906

Memory

SW1905

Function

IC801

CPU

IC802

Memory

IC001

Audio output

VR631

+B ADJ.

R638

Q432

H-output

IC501

V-output

VR462

PCC ADJ.

VR461

H-Width

VR501

V-Size

SW501 V-center

JS501

TP-D

IC271

1H delay

TP-A

K1001

IC281

VR361

VR131

AGC

A101

Tuner

IC201

IF/Video/Chroma/Def.

VC141

T141

T101

SIF decoder

GENERAL BLOCK DIAGRAMS FOR EC5 CHASSIS

+130V

+24V

+18V

+15V

TU

VL

VH

U

IF

Q801

Q101/Q102

Q103/Q104

Q105/Q106

Tuner

Key scan

10 Scan

1 Tu

51 VL

52 VH

3 U

8 Standby

SCL 49

SDA 50

BLK 35

R 34

G 33

B 32

Sharp 3

Bright 6

Cont 5

Colour 4

TV/AV 14

6 SCL

5 SDA

464522 R

23 G

24 B

21 BLK

14 Sharp

17 Bright

25 Cont

26 Colour

Volume 7

13 TV/AV

30 R-Y

31 B-Y

29 R-Y

28 B-Y

30 R-Y

31 B-Y

29 R-Y

28 B-Y

50 Sound

R out 18

G out 19

B out 20

CVBS out 7

SIF in 5

Int.video 13

Ext.video 15

Ext.audio 6

Audio out 1

H out

37

41

43

V-F/B

V out

4

2

42

8

R-out Q711

G-out Q721

B-out Q701

IC501 V-out

H-out circuit

Q431 Q432

V-control

circuit

Deflection

Yoke

T471 Flyback Trans.

High Voltage

Q151

X151

X161

Q161

Q154

Q241

SCART

19202, 6

1, 3

Video out

Video in

Audio in

Audio out

Q1032/Q1031

IC801 CPU IC201

IF/video/chroma/def.

IC802 Memory

X131

SAW

IC271

1H delay

IC001

Audio out

Power

control

circuit

T611

converter trans.

AC

in

Q839

Power supply circuit

CRT Unit

D634

+15V

+5V

+18V

+24V

1

3

1

3

IC691

IC661

Q661

Q651

+9V

+8V

control

circuit

Q611,

Q612

Power

switching

Q613

C607

D601~D604

T611

converter trans.

AC in

IC801

CPU

IC802

Memory

A1901

RC Pre-amp

A101

Tuner

IC271

1H delay

IC001

Audio out

Speaker

CRT Unit

T471

FBT

Horizontal

Drive circuit

IC501

V-out

IC201

IF/video/chroma/def.

44

8

3

MB

10

36

9

19

8

62

2

V.deflection

+5V

+9V

+5V

+8V

+18V

+9V

+180V

+150V

+24V

Power supply circuit

Standby signal from CPU pin 8

+150V

CRT Board /Pannello Cinescopio

Component Location/Lato del

Componente

VR702

B-Drive

VR712

R-Drive

VR701

B-Bias

VR721

G-Bias

VR711

R-Bias

Q701

Q721 Q711

REGOLAZIONE DELL’ALIMENTATORE

B1

1. Regolare VR641 in modo che sia centro

meccanico, prima di premere l’interruttore

principale.

2. Sintonizzare il ricevitore sull’oscillogramma

circolare PAL.

3. Regolare i comandi di luminosità e contrasto

sui livelli normali.

4.Collegare il misuratore V digitale su R638.

5.Servendosi di VR631, regolare il voltaggio su

130 ± 0,5 V (per 14/21 pollici).

Servendosi di VR631, regolare il voltaggio su

150 ± 0,5 V (per 25/28 pollici).

REGOLAZIONE AFT

1.Sintonizzare il ricevitore sulla stazione più

chiara.

2.Servendosi di T141, regolare AFT per

ottenere l’immagine migliore.

REGOLAZIONE AGC

NOTA: Non tentare questa regolazione con

un segnale debole.

1.Sintonizzare il ricevitore sulla stazione più

chiara.

2.Regolare AGC VR(VR131) nella direzione in

cui appaiono i disturbi da neve, quindi

regolare in direzione opposta nel punto esatto

in cui i disturbi da neve scompaiono.

REGOLAZIONE DELLA SCALA DEI

GRIGI

[REGOLAZIONE VR DI SCHERMO]

1.Sintonizzare il ricevitore sull’oscillogramma

bianco.

2.Regolare il comando della luminosità su

centro display e quello del contrasto su

normale.

3.Regolare VR702 e VR712 in modo che sia

centro meccanico.

4.Ruotare fino in fondo, in senso antiorario

5.Collegare un cortofilo mezzo spillo 30 di IC801

e GND (terra) a entrare in servizio modo.

VR701, VR711 o VR721.

6.Regolare VR di schermo per un solo colore in

modo che sia ben visibile.

[REGOLAZIONE VR DEL BIAS

(POLARIZZAZIONE)]

7.Servendosi di VR701, VR711 o VR721,

regolare la linea in modo che sia bianca.

8.Staccare la cortofilo.

[REGOLAZIONE VR DEL DRIVE

(ECCITAZIONE)]

9.Servendosi di VR701 e VR711, regolare il

bilanciamento del bianco.

REGOLAZIONE DI ALTO VOLTAGGIO E

DI AMPIEZZA

[REGOLAZIONE DI ALTO VOLTAGGIO]

1.Sintonizzare il ricevitore sull’oscillogramma

circolare PAL.

2.Regolare i comandi di luminosità e contrasto

sui livelli massimi.

3.Collegare il misuratore V digitale su entrambi i

terminali di R224 (lato sinistro) (+), e il

misuratore di alto voltaggio sull’anodo CRT.

4.Confermare che l’alto voltaggio sia 21,0 ± 1

KV alla corrente di fascio di elettroni 0,7, e

meno di 25,0 KV alla corrente di fascio di

elettroni 0 (per 14 pollici)

Confermare che l’alto voltaggio sia 25,0 ± 1

KV alla corrente di fascio di elettroni 1,0, e

meno di 28,0 KV alla corrente di fascio di

elettroni 0 (per 21 pollic.

Confermare che l’alto voltaggio sia 26,0 ± 1

KV alla corrente di fascio di elettroni 1,1, e

meno di 29,0 KV alla corrente di fascio di

elettroni 0 (per 25 pollici).

[REGOLAZIONE DI AMPIEZZA-H]

5.Se l’ampiezza H è troppo larga o troppo

stretta, collegare o scollegare un filo in

piombo AJ1 (per 14/21 pollici).

6.Riconfermare l’alto voltaggio.

REGOLAZIONE DI CENTRO-H

1.Sintonizzare il ricevitore sull’oscillogramma

circolare.

2.Regolare il centro-H servendosi di VR361.

REGOLAZIONE DI CENTRO-V

1.Sintonizzare il ricevitore sull’oscillogramma

circolare.

2. If picture is not in vertical centre, connect or

disconnect a lead wire JS501 (per 14 pollici).

Regolare il centro-V servendosi di SW501 (per

21/25/28 pollici).

REGOLAZIONE DELLA DIMENSIONE-V

1.Sintonizzare il ricevitore sull’oscillogramma

circolare.

2.Regolare la dimensione-V servendosi di

VR501.

REGOLAZIONE DELLA MESSA A

FUOCO

Servendosi di FOCUS VR, regolare il controllo

della messa a fuoco per una buona scansione

delle linee.

REGOLAZIONI DI SERVIZIO TECNICO

P

DC 15V

TensioneAGC (4.3-4.5V)

Sonda di uscita

Sonda di ingresso

Marker Freq.

Sweep ATT

0dB=176mVrms/75

REGOLAZIONE DEL

RIVELATORE

IMPOSTAZIONE

R664 +

IC201-48 p

IC201-45 p

(Lato b)

IC201-7 p

38.9

20dB

Regolazione

Servendosi di T141,

regolare “P” in modo che

sia di ampiezza massima.

Forma d’onda VIF

ALLINEAMENTO DI CIRCUITO

ALLINEAMENTO VIF

0.002µF

75Ω

1kΩ

a

b

10kΩ

Sonda di ingresso

Sonda di

uscita

38.9MHz

Quando si sostituisce una IC di memoria (IC802), è

necessario inizializzare la IC come segue.

A. Inizializzazione di IC di memoria

1. Se si mantiene premuto il tasto Prog. + sull’apparecchio

TV e poi si preme il tasto di Richiamo sul trasmettitore RC,

sullo schermo appare l’immagine seguente.

2. Premendo il tasto Funzione, confermare che il numero SET

di tutte le voci sia “0”.

3. Se non è “0”, cambiare su “0” per mezzo del tasto Livello

(+/-). (Cambiamento del numero SET, memorizzato

automaticamente.)

4. Premere il tasto di Richiamo per ritornare al modo TV.

Per ulteriori informazioni, si prega di vedere le “funzioni

speciali” sul manuale delle istruzioni.

SOSTITUZIONE IC DI MEMORIA

(Avviso importante)

ITEM -1 SET➔ 0

Tasto Livello

Regolare VR462 per ottenere l’ampiezza

H appropriata (per 25/28 pollici).

T141

Regolazione del rivelatore

1

2

3

4

5

6

7

8

9

0-/--

i

P

P P

TV/

F

X

?

Tasto di Richiamo

Tasto Funzione

Tasto Prog. +

P

AS

Sanyo CE 25MT2A-C Service Manual

Specifications and Main Features

Frequently Asked Questions

User Manual