Samsung S3110 Service Manual

GSM TELEPHONE

GT-S3110

GSM TELEPHONE

CONTENTS

Safety Precautions

1.

Specification

2.

Product Function

3.

Array course control

4.

Exploded View and Parts list

5.

MAIN Electrical Parts List

6.

Disassembly and Assembly

7. Instructions

Block Diagrams

8.

PCB Diagrams

9.

Chart of Troubleshooting

10.

Reference data

11.

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning.

●

Take specially care of tuning or test,

because specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool,

●

because performance of parts is damaged by the influence of manetic force.

Surely useastandard screwdriver when you disassemble this product,

●

otherwise screw will be worn away.

Useathicken twisted wire when you measure level.

●

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an

●

overcurrent and furious flames of parts etc) when you repair board in condition of

connecting Test Pack and tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

●

Surely tune on/off while using AC power plug, becausearepair of battery charger is

●

dangerous when tuning ON/OFF PBA and Connector after disassembing charger.

Don't use as you pleases after change other material than replacement registered on SEC

●

System.

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easilly by static electricity. Such parts are called by

ESD(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

●

semiconductor. There are ways that you touch an earthed place or wear static electricity

prevention string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

●

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by

●

static electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box

●

and aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

●

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM General Specification

2-1.

EGSM 900 DCS1800

Freq. Band[MHz]

Uplink/Downlink

ARFCN range 0~124 & 975~1023 512~885

Tx/Rx spacing 45MHz 95MHz

Mod. Bit rate

/BitPeriod

Time Slot Period

/ Frame Period

Modulation 0.3GMSK 0.3GMSK

880~915 925~960

270.833kbps

3.692us

576.9us

4.615ms

1710~1785 1805~1880

270.833kbps

3.692us

576.9us

4.615ms

MS Power 33dBm~5dBm 30dBm~0dBm

Power Class 5

Sensitivity -102dBm -100dBm

TDMA Mux 8 8

Cell Radius 35Km 2Km

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

pcl

2-1

~19

pcl

0

~15

pcl

Specification

GSM TX power class

2-2.

TX Power

control level

533±2

631±2

729±2

827±2

925±2

10 23±2

11 21±2

GSM900

dBm

TX Power

control level

0 30±3

1 28±3

2 26±3

3 24±3

4 22±3

5 20±3

6 18±3

DCS1800

dBm

12 19±2

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

dBm

7 16±3

8 14±3

9 12±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

dBm

15 0±5

2-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

dBm

Operation Instruction and Installation

3.

Main Function

S20 Pin TA

-

No Java

-

Phonebook

-

Dual band(900/1800MHz)

-

Auto power alarm

-

-46ｘ109

MP3 Ringtone,

-

SOS

-

ｘ

entry, quick search

200

mm

11.1

Poly Sound, WAV/MIDI

40

3-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4.

Software Adjustments

4-1.

Test Jig(GH99

RF Test Cable(GH

-36900

39-00985

A)

Test Cable(GH

Adapter(GH

39-01160

99-38251

A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Software Downloading

4-2.

4-2-1.

4-2-2.

■

1

2

Pre-requsite for Downloading

Downloader Program(

•

GT-S3110C Mobile Phone

•

Data Cable

•

Binary file, TFS file

•

OneNAND Downloader v0.1 For PNX6512.exe

S/W Downloader Program

Load the binary download program by executing the

OneNAND Downloader v1.5 Lite For PNX6512.exe

“

Select the connected serial port and the rate of speed

.

Select the check box, the mode you want to download.

.

if the binary file wanted, check only'BIN'

-

if the tfs file wanted, check only'TFS'

-

if all the files wanted, check'BIN+TFS'

-

”

)

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the file(s) what you want to download

.

3

click'BIN...'to selectabinary file.

-

click'TFS...' to selectatfs file.

-

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Click the'START' button to Erasing.

.

4

Click the'DOWNLOAD' button to downloading

Confirm the downloaded version name and etc.

.

5

*#1234#

Full Reset

:

*0206*3855#

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

:

Exploded View and Parts List

5.

5-1.

Cellular phone Exploded View

QFR01

QKP01

QME01

QCA01

QLC01

QVK01

QLB01

QSP01

QCR94

QVO01

QRE01

QBA01

QBA00

QMP01

QAN02

QSD01

QIF01

QCR60

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Description SEC CODE

QAN02 INTENNA-MAIN(GT-S3110) GH42-01875A

QBA00 PMO CASE-BATT GH72-51755A

QBA01 INNER BATTERY PACK-800MAH,BLK,ENG,M GH43-02483A

QCA01 ASSY CAMERA-GT_S3110(1.3M) GH96-03535A

QCR60 SCREW-MACHINE

QCR94 SCREW-TAPPING

6001-002005

6002-001429

QFR01 ASSY CASE-FRONT(EU/SILVER) GH98-11413A

QKP01 ASSY KEYPAD-(EU/SILVER) GH98-11579A

QLB01 ASSY BRACKET-LCD GH98-11531A

QLC01 ASSY LCD-2.0" QCIF LCD ASSY GH96-03527A

QME01 KEY FPCB-MAIN KEY PBA(GT-S3110) GH59-06744A

QMP01 ASSY PBA MAIN-GT_S3110 GH92-05172A

QSP01 MODULE-SPK/MOT MODULE(GT-S3110) GH59-06843A

QVK01 KEY FPCB-VOLUME KEY(GT-S3110) GH59-06750A

QVO01 PMO KEY-VOLUME V2 GH72-52706A

QRE01 ASSY CASE-REAR GH98-11414A

QSD01 PMO COVER-SD GH72-51756A

QIF01 PMO COVER-IF GH72-51757A

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

SEC CODE Design LOC Discription

0403-001339

0403-001547

0406-001286

0406-001288

0406-001306

0407-001002

1108-000187

1201-002731

1201-002733

1203-004726

1203-004948

1203-005310

1203-005566

1204-002979

1205-003310

1205-003419

1205-003659

1404-001221

2007-000141

2007-000148

2007-000149

2007-000151

2007-000152

2007-000157

2007-000162

2007-000166

2007-000172

U503 UDZS TE-17

ZD300 TDZ5.6

D502 PESD5V0L5UV

ZD403 PESD5V0L5UV

ZD402 PESD5V0S1UL

D503 CM1219-05SE

ZD301 CM1219-05SE

ZD302 CM1219-05SE

D500 DAN222TL

UME200 KAP29SN00C-AEEC

PAM100 SKY77534-11

U400 MAX9877EWP

U502 AAT3193IJQ-1-T1

U501 MIC5320-GFYMT

U300 NCP360SNAFT1G

PM300 PCF50615HN/02/N1

U103 SI4708-B-GMR

U101 AERO4208HN/2

U100 BCM2046SB1KUFBXG

UCP200 PNX6508EL1/139/1A

VR401 NCP15WB473J04RC

R312 RC1005J222CS

R305 RC1005J103CS

R400 RC1005J103CS

R408 RC1005J103CS

R410 RC1005J103CS

R211 RC1005J123CS

R311 RC1005J153CS

R411 RC1005J203CS

R306 RC1005J473C

R315 RC1005J104CS

R309 RC1005J304CS

R313 RC1005J304CS

R401 RC1005J100CS

R402 RC1005J100CS

6.2B

S

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription

2007-001319

2007-001333

2007-002970

2007-007312

2007-007489

2007-007573

2007-007589

2007-008052

2007-008354

2007-008419

2007-008478

2007-008587

2007-009084

2007-009108

2007-009168

2203-000233

R205 RC1005J122CS

R206 RC1005J122CS

R207 RC1005J122CS

R208 RC1005J122CS

R317 MCR01MZP5J183

R321 MCR01MZP5J183

R412 MCR01MZP5J183

R501 MCR01MZP5J183

R101 MCR01MZP5J560

R10

3

MCR01MZP5J560

R502 MCR01MZP5F2002

R108 RK73H1ETP1503F

R307 RK73H1ETP3303F

R415 RK73H1ETP6802F

R302 ERJ1GENJ472X

R308 ERJ2RKF224X

R102 ERJ1GEJ102C

R213 ERJ1GEJ102C

R403 RMC1/20152JPA

R404 RMC1/20152JPA

R406 RMC1/20152JPA

R407 RMC1/20152JPA

R200 ERJ1GEJ561C

R405 ERJ1GEJ561C

R310 MCR006YZPJ105

R314 MCR006YZPJ105

R104 RC0603J154CS

R107 RC0603J154CS

R300 MCR006MZPJ563

R30

1

3

MCR006MZPJ563

R304 MCR006MZPJ563

C116 GRP1555C1H101J

C312 GRP1555C1H101J

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription

2203-000278

2203-000330

2203-000386

2203-000425

2203-000438

2203-000679

2203-000812

2203-000995

2203-002709

2203-003054

2203-005050

2203-005057

2203-005281

2203-005444

2203-005450

2203-005482

C115 GRP1555C1H100D

C437 GRP1555C1H120J

C440 GRP1555C1H150J

C441 GRP1555C1H150J

C109 GRP1555C1H180J

C314 GRP1555C1H180J

C317 GRP1555C1H180J

C108 GRP155R71H102K

C127 GRP155R71H102K

C209 GRP1555C1H270J

C404 GRP1555C1H270J

C438 GRP1555C1H270J

C439 GRP1555C1H270J

C114 GRP1555C1H330J

C131 GRP1555C1H330J

C104 GRP1555C1H470J

C128 C1005Y5V1C104ZT

C129 C1005Y5V1C104ZT

C208 C1005Y5V1C104ZT

C210 C1005Y5V1C104ZT

C222 C1005Y5V1C104ZT

C431 C1005Y5V1C104ZT

C403 GRP1555C1H9R0C

C121 GRP1555C1H1R8CZ01E

C122 GRP1555C1H1R8CZ01E

C421 GRP1555C1H8R2CZ01E

C424 GRP1555C1H8R2CZ01E

C428 GRP1555C1H8R2CZ01E

C123 GRP1555C1H1R5BZ01E

C124 GRP1555C1H1R5BZ01E

C100 GRP1555C1H3R0B

C207 GRP1555C1H5R6BZ01E

C103 GRP155R61A104KA01E

C307 GRP155R61A104KA01E

C319 GRP155R61A104KA01E

Main Electrical Parts List

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription

2203-005482

2203-006048

2203-006123

2203-006257

2203-006260

2203-006324

2203-006348

2203-006361

2203-006399

2203-006562

C402 GRP155R61A104KA01E

C408 GRP155R61A104KA01E

C423 GRP155R61A104KA01E

C426 GRP155R61A104KA01E

C436 GRM155R71A104K

C205 GRM0335C1E5R6CD01D

C211 GRM0335C1E5R6CD01D

C301 GRM155R60J474KE19E

C303 GRM155R60J474KE19E

C306 GRM155R60J474KE19E

C308 GRM155R60J474KE19E

C313 GRM155R60J474KE19E

C320 GRM155R60J474KE19E

C323 GRM155R60J474KE19E

C218 GRM155R61A224KE19E

C219 GRM155R61A224KE19E

C302 GRM155R61A224KE19E

C411 GRM155R61A224KE19E

C412 GRM155R61A224KE19E

C413 GRM155R61A224KE19E

C414 GRM155R61A224KE19E

C318 GRM188R61A225KE19D

C316 CV105X5R105K25AT

C300 GRM21BR61A106K

C321 GRM21BR61A106K

C204 GRM155R60J105KE19D

C212 GRM155R60J105KE19D

C216 GRM155R60J105KE19D

C500 GRM155R60J105KE19D

C505 GRM155R60J105KE19D

C510 GRM155R60J105KE19D

C511 GRM155R60J105KE19D

C304 CV05X5R105K10AH

C309 CV05X5R105K10AH

C310 CV05X5R105K10AH

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription

Main Electrical Parts List

2203-006562

2203-006648

2203-006681

2203-006825

2203-006838

C311 CV05X5R105K10AH

C322 CV05X5R105K10AH

C324 CV05X5R105K10AH

C330 CV05X5R105K10AH

C406 CV05X5R105K10AH

C416 CV05X5R105K10AH

C419 CV05X5R105K10AH

C420 CV05X5R105K10AH

C507 CV05X5R105K10AH

C509 CV05X5R105K10AH

C130 GRM033R60J223KE01D

C112 GRM155F51E104ZA01D

C305 JMK107BJ106KA-T

C102 CL05A225KQ5NSNC

C105 CL05A225KQ5NSNC

2203-006838

2203-006839

2203-006841

2203-006842

2203-006901

2203-007165

2203-007279

C107 CL05A225KQ5NSNC

C110 CL05A225KQ5NSNC

C118 CL03A104KP3NNNC

C200 CL03A104KP3NNNC

C201 CL03A104KP3NNNC

C202 CL03A104KP3NNNC

C206 CL03A104KP3NNNC

C220 CL03A104KP3NNNC

C221 CL03A104KP3NNNC

C430 CL03A104KP3NNNC

C315 CV05X5R105K16AH

C117 CL05C471JB5NNNC

C329 TV105X5R105K25AT055

C215 CL05A475KQ5NRNC

C327 CV105X5R106M10AT

2203-007279

C328 CV105X5R106M10AT

6-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription

2404-001377

2404-001415

2703-001723

2703-001726

2703-001737

2703-001938

2703-002170

2703-002178

2703-002201

2703-002368

2703-003121

2703-003476

2703-003498

2801-004339

2801-004787

2901-001424

2904-001879

2909-001312

3301-001659

3301-001729

3301-001812

3705-001503

C415 F980J226MMA

C113 TLJR106M010R3000

C435 TLJR106M010R3000

L111 LL1005-FH33NJ

L106 LL1005-FH27NJ

L110 LL1005-FH2N7S

L101 LL1005-FH56NJ

L105 CIH05T6N8JNC

L409 LL1608-FSR27J

L108 CIH05T33NJNC

L112 CIH05T1N8SNC

L408 MLG1005SR15J

L403 LQG15HSR27J02D

L405 LQG15HSR27J02D

C325 LPS181210T-6R8M

C326 LPS181210T-6R8M

OSC300 FC-135(0.032768MHz)

OSC100 CXC6X260000GHVRN00

F400 AVRC-14S-03Q-030-100R

F500 AVRC-14S-03Q-030-100R

F502 AVRC-14S-03Q-030-100R

F503 AVRC-14S-03Q-030-100R

F102 SFR942PY002

F100 LCB10B2450K3

L102 BLM15AG601SN1

L406 BLM15AG102SN1D

L407 BLM15AG102SN1D

L402 BLM15HD102SN1

L410 BLM15HD102SN1

L412 BLM15HD102SN1

L413 BLM15HD102SN1

L414 BLM15HD102SN1

L400 BLM15HD102SN1

L401 BLM15HD102SN1

RFS100 KMS-560

6-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

SEC CODE Design LOC Discription

3709-001552

3710-002681

3711-006108

3711-006420

3711-006508

4202-001463

4302-001180

CN300 SCHG1B0102-DIP

IFC400 HY20-AB0360

CN400

SLC500

SOC500

2005-03-247A

14-5805-016-000-829

14-5805-050-000-829

ANT102 ODBTP3015

BAT300 ML-414RM/F9ME

GH70-03349A SC1 ONBOARD-CLIP-3

GH70-03349A SC2 ONBOARD-CLIP-3

GH70-03349A SC3 ONBOARD-CLIP-3

GH70-03349A SC4 ONBOARD-CLIP-3

GH70-03349A SC5 ONBOARD-CLIP-3

GH70-03349A SC6 ONBOARD-CLIP-3

Main Electrical Parts List

GH70-03349A SC7 ONBOARD-CLIP-3

GH70-03349A SC9 ONBOARD-CLIP-3

Please consuit the GSPN website(Samsung Portal) for the most recent version of the product's part list.

6-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Samsung S3110 Service Manual

Specifications and Main Features

Frequently Asked Questions

User Manual