SAMSUNG N67 Schematics

1-1Samsung Electronics

1. Alignment and Adjustments

1-1 Tuner

FM THD Adjustment

Output

23 dB

60 dB

Minumum Distortion (0.3% below) (Figure 1-1)

SSG FREQ.

Adjustment point (TL3)

98 MHz

FM DETECTOR COIL

FM Search Level Adjustment

Adjust TSR1 so that “TUNED” of FLT is lighted (Figure 1-2)

Figure1-2 FM Auto Search Level Adjustment

*Adjust FM S.S.G level to 23dB

Figure1-1 IF CENTER and THD Adjustment

SSG FREQ.

Adjustment point

(TSR1)

98 MHz

BEACON SENSITIVITY SEMI-VR(5KΩ)

FM S.S.G

GND

23 dB

FM S.S.G

Output GND

Speaker Terminal

FM Antenna Terminal

Distortion Meter

Input

SET

Input

output

Oscilloscope

FM IN

FM Antenna

SET

5 kΩ

OUTPUT

AM SSG 450KHZ

INPUT

AM ANT IN

Speaker Terminal

60cm

TL2

VTVM Oscilloscope

AM(MW) I.F Adjustment

Maximum output (Figure 1-3)

SSG FREQ.

Frequency

Adjustment point (TL2)

450 kHz

522 kHz

AM I.F COIL

Figure1-3 AM I.F Adjustment

OUTPUT

* Adjustment Location of SW Band

* Adjustment Location of LW Band

Alignment and Adjustments

1-2 Samsung Electronics

1-2-2 AM(MW),LW,SW1,SW2 Adjustment

Circuit Measuring Instrument & Step S.S.G Radio dial Adjusting Adjust for to be Arrangement Frequency Setting Point Adjusted

1 522KHz 522KHz MW OSC Aduust for 1.0V±0.1V at the low.

OSC Connect AM signal (IR117)

generator to loop antenna,VTVM AND oscilloscope 2 1611KHz 1611KHz MW OSC

Check for 7.0V±1.0V at the high.

(Fig 1-3) (IR117) AM (MW)

RF “ 1 594KHz 594KHz MW ANT Maximum out

INTER FREQ “ 1 450KHz 522KHz TL2 Maximum out

OSC Fig 1-3 1 146KHz LW OSC Aduust for

2.0V±0.1V at the low.

LW 2 290KHz LW OSC

Check for 7.0V±1.0V at the high.

RF 1 150KHz 150KHz LW ANT Maximum out

OSC Fig 1-3 1 2.3MHz SW1 OSC Aduust for 1.0V±0.1V at the low.

SW1 2 7.3MHz SW1 OSC

Check for 8.5V±1.0V at the high.

RF 1 3.5MHz 3.5MHz SW1 ANT Maximum out

OSC Fig 1-3 1 9.5MHz SW2 OSC Aduust for 1.5V±0.1V at the low.

SW2 2 26.1MHz SW2 OSC Check for 8.0V±1.0V at the high.

RF 1 10MHz 10MHz SW2 ANT Maximum out

Alignment and Adjustments

1-3Samsung Electronics

1-2-1 To Adjust Tape Speed

* Measuring tape: i) MTT-111 CN(or equivalent)

(Tapes recorded with 3kHz)

ii) MTT-5512 (or equivalent)

Notes

SPEED

Control

MTT-111N (3KHZ)

3 kHZ ±1%

Fig. 1-4

FRONT PCB

Remark

Standard

Figure

Adjust Point

Item

Step

Tape

USVR1

Azimuth

MTT-111CN

8KHZ

Fig.1-4 Fig. 1-6

Output:Maximum

Remark

Standard

Figure

Adjust Point

Item

Step

Tape

Adjustment

screw of HEAD

MTT-5512

Fig. 1-5

85KHZ±1KHZ

Remark

Frequency Range

Figure

Adjust Point

Item

Step

Tape

JT1

Record Frequency

Speaker Terminal

output

Frequency Counter

Figure 1-4

Figure 1-6

Recording /Play head

AZIMUTH control

Figure 1-5

In Out

Cassette Deck

Oscilloscope

SET

(GND)

VTVM

V H

1-2 Cassette Deck : Only MM-N7 Model

SP2

SPEAKER

PreSetup

Press play button after puting tape into the Deck1

PreSetup

Press Rec button after connecting (Fig1-5)

PreSetup

Press Play button after puting tape into the Deck1

- Adjust SPEED Control

- Adjust

Record Frequency

Adjust Azimuth

2.Exploded Views and Parts List

2-1 Auto Reverse Cassette Deck : Only MM-N7 Model

Samsung Electronics 2-1

No. Code No. Description Specification Remarks

AH59-20006H DECK-CASSETTE ADR241BTR : 1 AH81-00098A ASS,Y HEAD TR981PA 14KHZ 2 AH81-00099A ASS,Y MOTOR EG530YD-2BH 12V 3 AH81-00100A BELT MAIN ADR2400S-MAIN 4 AH81-00101A BELT FR ADR2400S-FR 5 AH81-00102A SOLENOID ADR2400-1 12V

2-2 Total Exploded View and Parts List : Only MM-N7 Model

Samsung Electronics

2-2

2-2-1 Parts List

1 AH64-00510C WINDOW-DISPLAY PMMA CLEAR 2 AH64-00507C DOOR-CD ABS 94HB 3 AH67-00043A LENS-CD PMMA CLEAR 4 AH64-00512B KNOB-CONTROL ABS 94HB 5 AH67-00042A LENS-LCD PMMA CLEAR 6 AH61-00312A HOLDER-LCD ABS 94HB 7 AH63-00123A COVER-PCB HIPS 94HB 8 AH64-00509D DECO-FRONT ABS 94HB 9 AH64-00514A KNOB-EQ ABS 94HB 10 AH64-00513A KNOB-VOLUME ABS 94HB 11 AH64-00518A DECO-SM ABS 94HB 12 AH61-00309A BASE-MECHA HIPS 94HB 13 AH66-00062A GEAR-DOOR POM BLK 14 AH61-00220A SHAFT-GEAR MBS 15 AH64-00503B CABINET-FRONT HIPS 94HB 16 AH61-00314A BRKT-JOINT SECC 1.0T 17 AH66-00060A GEAR-L POM BLK 18 AH66-00061A GEAR-S POM BLK 19 AH66-00059A GEAR-PULLEY POM BLK 20 AH61-00311A HOLDER-GEAR ABS 94HB 21 AH66-10025A PULLEY-MOTOR POM BLK 22 AH66-00063A BELT-PULLEY CR 23 AH95-50001A LATCH ASSY MAX555 24 AH64-00500B CABINET-TOP HIPS 94HB 25 AH64-00508B DOOR-CASSETTE ABS 94HB 26 AH64-00511B WINDOW-DOOR PMMA CLEAR 27 AH61-00361A SPRING-DOOR STS PI1.0 28 AH61-80030A DAMPER ASSY POM M0.8 29 AH64-00502C CABINET-REAR HIPS 94HB 30 AH61-20540A HOLDER-TUNER ABS BLK 31 AH62-00026A HEAT-SINK ALS 32 AH64-00505B CABINET-SIDE.R HIPS 94HB 33 AH64-00504B CABINET-SIDE.L HIPS 94HB 34 AH64-00501A CABINET-BOTTOM HIPS 94HB 35 AH61-00310A HOLDER-MECHA ABS 94HB 36 AH73-00007A RUBBER-MECHA.A SI RUBBER 37 AH73-00010A RUBBER-HOLDER BUTYL 38 AH64-70003H BADGE-BRAND ABS STAMPING

No. Code No. Description Specification Remarks

Samsung Electronics

2-3

2-3 Total Exploded View and Parts List : Only MM-N6 Model

Samsung Electronics

2-4

2-3-1 Parts List

No. Code No. Description Specification Remarks

1 AH64-00641B WINDOW-DISPLAY PMMA CLEAR 2 AH64-00507E DOOR-CD ABS 94HB 3 AH67-00043A LENS-CD PMMA CLEAR 4 AH64-00512B KNOB-CONTROL ABS 94HB 5 AH67-00042A LENS-LCD PMMA CLEAR 6 AH61-00312A HOLDER-LCD ABS 94HB 7 AH63-00123A COVER-PCB HIPS 94HB 8 AH64-00509F DECO-FRONT ABS 94HB 9 AH64-00514A KNOB-EQ ABS 94HB 10 AH64-00513A KNOB-VOLUME ABS 94HB 11 AH64-00518A DECO-SM ABS 94HB 12 AH61-00309A BASE-MECHA HIPS 94HB 13 AH66-00062A GEAR-DOOR POM BLK 14 AH61-00220A SHAFT-GEAR MBS 15 AH64-00503B CABINET-FRONT HIPS 94HB 16 AH61-00314A BRKT-JOINT SECC 1.0T 17 AH66-00060A GEAR-L POM BLK 18 AH66-00061A GEAR-S POM BLK 19 AH66-00059A GEAR-PULLEY POM BLK 20 AH61-00311A HOLDER-GEAR ABS 94HB 21 AH66-10025A PULLEY-MOTOR POM BLK 22 AH66-00063A BELT-PULLEY CR 23 AH64-00506B CABINET-TOP HIPS 94HB 24 AH64-00502C CABINET-REAR HIPS 94HB 25 AH61-20540A HOLDER-TUNER ABS BLK 26 AH62-00026A HEAT-SINK ALS EXTR 27 AH64-00505B CABINET-SIDE.R HIPS 94HB 28 AH64-00504B CABINET-SIDE.L HIPS 94HB 29 AH64-00501A CABINET-BOTTOM HIPS 94HB 30 AH61-00310A HOLDER-MECHA ABS 94HB 31 AH73-00007A RUBBER-MECHA.A SI RUBBER 32 AH73-00010A RUBBER-HOLDER BUTYL 33 AH64-70003H BADGE-BRAND ABS STAMPING

Samsung Electronics

2-5

2-4. CD Deck Exploded View and Parts list(COMMON)

Samsung Electronics

2-6

No. Code No. Description Specification Remarks

1 2 3 4 5 6 7 8

9 10 11 12 13 14

AJ59-20003F AH61-10022B AH63-30048A AH66-20016A AH66-20017A AH66-20018A AH71-50036A

15253-503-011

AH64-10648A AH66-90029A

AJ30-20001B AH61-60055A AH31-10009A AH31-10002B AH60-10014A

DECK-CD CHASSIS-DECK(M) COVER-GEAR GEAR(A) GEAR(B) GEAR(C) SHAFT-PU CENTER-RING CENTER-KNOB TURN-TABLE(M) PICK-UP CDP SPRING-T/TABLE MOTOR-SPINDLE MOTOR-FEED SCREW-PH(+M2*3)

CMS-P30NM6 CMSA30 POM M90-44 CMS-V30 BLK ABS CMS-V30 M0.3 Z13 SP POM CMS-V30 M0.3 Z13 SP POM CMS-V30 M0.3 Z16/Z90 SP POM CMS-V30 D3 L79 SUS420J2 ABS+GS 20% CMS-V10N ABS 94HB

-,-,-,CMS-V30 P/U SOH-A1 ROW V-P/J CS STS-W PI0.4 D5.7 L9.3 CMS-V10N RF-310T-11400 43L 25V 85mA RF-310ta 30MM NDM4RA3ETL 11.0MM +M2X3 FE FZY W700

+ 21 hidden pages