Samsung MAX-N72, MAX-N73, MAX-N75 Service manual

3 CD CHANGER
MINI MINI COMPONENT

MAX-N72/73/75

SERVICE

Manual

MIMI MIMI COMPONENT SYSTEM CONTENTS

Disc 1 Disc 2 Disc 3

Disc Change

Open/
Close

Game

Demo

PTY

Display

Timer/
Clock

Rev Mode Deck 1/2

Counter Reset

Normal

CD REC/Pause

High

Dubbing

Mono/ST

Preset/Memory

REC/Pause

Program

TAPE

Volume

CDTUNER

Band

CD Repeat

Shuffle CD Synchro

S.BASS

ower

Surround

EQ

3D Surround

AUX

On/Standby

+

–

RDS

Preset/Manual

Manual EQ /EnterMoving Control

Up

D

o
w

n

1. Alignment and Adjustments

2. Exploded Views and Parts List

3. Electrical Parts List

4. Block Diagrams

5. PCB Diagrams

6. Wiring Diagram

7. Schematic Diagrams

1-1Samsung Electronics

1. Alignment and Adjustments

1-1 Tuner

FM THD Adjustment

Output

Output

23 dB

60 dB

Minumum Distortion (0.3% below)
(Figure 1-1)

SSG FREQ.

Adjustment
point
(TL3)

98 MHz

FM DETECTOR COIL

FM Search Level Adjustment

Adjust TSR1 so that “TUNED” of FLT
is lighted (Figure 1-2)

Figure1-2 FM Auto Search Level Adjustment

*Adjust FM S.S.G level to 23dB

Figure1-1 IF CENTER and THD Adjustment

SSG FREQ.

Adjustment
point

(TSR1)

98 MHz

BEACON
SENSITIVITY
SEMI-VR(5KΩ)

FM S.S.G

GND

23 dB

FM S.S.G

Output
GND

Speaker
Terminal

FM
Antenna
Terminal

Distortion Meter

Input

SET

Input

output

Oscilloscope

FM IN

FM Antenna

SET

5 kΩ

OUTPUT

AM SSG
450KHZ

INPUT

AM ANT
IN

Speaker Terminal

60cm

TL2

VTVM Oscilloscope

AM(MW) I.F Adjustment

Maximum output (Figure 1-3)

SSG FREQ.

Frequency

Adjustment
point
(TL2)

450 kHz

522 kHz

AM I.F COIL

Figure1-3 AM I.F Adjustment

OUTPUT

* Adjustment Location of SW Band

* Adjustment Location of LW Band

Alignment and Adjustments

1-2 Samsung Electronics

1-1-2 AM(MW),LW,SW1,SW2 Adjustment

Circuit Measuring Instrument & Step S.S.G Radio dial Adjusting Adjust for
to be Arrangement Frequency Setting Point
Adjusted

1 522KHz 522KHz MW OSC Aduust for 1.0V±0.1V at the low.

OSC Connect AM signal (IR117)

generator to loop
antenna,VTVM AND
oscilloscope 2 1611KHz 1611KHz MW OSC

Check for 7.0V±1.0V at the high.

(Fig 1-3) (IR117)

AM

(MW)

RF “ 1 594KHz 594KHz MW ANT Maximum out

INTER FREQ “ 1 455KHz 522KHz TL2 Maximum out

OSC Fig 1-3 1 146KHz LW OSC Aduust for 2.0V±0.1V at the low.

LW 2 290KHz LW OSC Check for 7.0V±1.0V at the high.

RF 1 150KHz 150KHz LW ANT Maximum out

OSC Fig 1-3 1 2.3MHz SW1 OSC Aduust for

1.0V±0.1V at the low.

SW1 2 7.3MHz -

Check for 8.5V±1.0V at the high.

RF 1 3.5MHz 3.5MHz SW1 ANT Maximum out

OSC Fig 1-3 1 9.5MHz SW2 OSC Aduust for 1.5V±0.1V at the low.

SW2 2 26.1MHz - Check for 8.0V±1.0V at the high.

RF 1 10MHz 10MHz SW2 ANT Maximum out

Alignment and Adjustments

1-3Samsung Electronics

(GND)

VTVM

1-2-1 To Adjust Tape Speed

1) Measuring tape: i) MTT-111 (or equivalent)
(Tapes recorded with 3kHz)

ii) MTT-5512 (or equivalent)

2) Connect the cassette deck to the frequency counter

as in figure 1-4.

1) Before the actual adjustment, clean the play/recording

head.

2) Measuring tape :

i) MTT-114NA(or equivalent 12.5kHz AZIMUTH control)

ii) MTT-150(or equivalent : Dolby level 200nwb/m)

3) Dolby NR SW OFF

4) The cassette deck is connections as shown in figure 1-6.

Notes

Notes

NOR
SPEED
Control

1

2

OUT

(connected

to the frequency

counter)

Turn CVR1 to
left and right

3KHz

6KHz

Turn CVR2
to left and
right

Remark

Standard

To Adjust

Pre-Setup

Item

Step

Pre-Setup
Condition

Same as above

1) Deck 1:MTT-111

2) Press PLAY

SW button

3) Deck 2:Same

as above

1) Deck 1:MTT-111

2) Deck 2:MTT-5512

3) Press DUBBING

SW button two times.

HI SPEED

Control

AZIMUTH

1

2

TP1 OUT

(VTVM is

connected to

the scope)

1) Turn the control
screw to as shown
in Figure 1-5.

2) Adjust the right

control screw to
playback REV. Mode

Max output
and same phase
(both channels)

After
adjustment
secure it with
REGION
LOCK.

Adjust to level
and same Aux
level.

L-CH:Turn JSR2L

to the right and

left
R-CH:Turn J SR2R to
the right and left

See the
diagram for
adjustment
locations.

Remark

Standard

To Adjust

Pre-Setup

Item

Step

Pre-Setup
Condition

Same as
above

After putting MTT-

114NA into Deck 1

1) Press FWD PLAY

button.

2) Press REV PLAY

button.

PLAY MTT-150

on Deck 1.

PlayBack
out Level

AZIMUTH

1

2

TP1 OUT

(VTVM is

connected to

the scope)

1) Turn the control
screw to as shown
in Figure 1-5.

2)Adjust the right

control screw to
playback REV. Mode

Max output
and same phase
(both channels)

After
adjustment
secure it with
REGION
LOCK.

Adjust to level
and same Aux
level.

L-CH:Turn JSR3L

to the right and
left

R-CH:Turn JSR3R to

the right and left

See the
diagram for
adjustment
locations.

Remark

Standard

To Adjust

Pre-Setup

Item

Step

Pre-Setup
Condition

Same as
above

After putting MTT-

114NA into Deck 2

1)Press FWD PLAY

button.

2)Press REV PLAY

button.

PLAY MTT-150

on Deck 2.

PlayBack
out Level

1-2-2 To Adjust PlayBack Level

@ Adjust Deck 2 Play Level

! Adjust Deck 1 Play Level

Cassette Deck

output

SPK OUT

Frequency Counter

Figure 1-4

Figure 1-5

SPK OUT

Recording /Play head

FWD PLAY

REVERSE PLAY

AZIMUTH control screw

Figure 1-6

In Out

Cassette Deck

Oscilloscope

1-2 Cassette Deck

Fig1-8

Fig1-8

To Adjust Recording Level

1

See diagram
for adjustment
locations

25 mV

L-CH: JSR1L and
R-CH: JSR1R to
the right and left

To Adjust

Standard

Remark

Pre-Setup

Item

Step

Pre-Setup
Condition

Connect to
JCW2 as in Figure
1-7 and read the
VTVM

Insert MTT-5512 into

Deck2, then press

REC button.

BIAS
Electric
current

Figure 1-7

Audio OSC.

Cassette Deck

Oscilloscope

AUX IN

SPK OUT

VTVM

IN

JCW2

IN OUT

Samsung Electronics 2-1

2.Exploded Views and Parts List

2-1 Cassette Deck :ADR241AMW1(OPTION)

No. Code No. Description Specification Remarks

1

2

3

4

6

5

6

77

AH59-20006T DECK-CASSETTE ADR241AMW1
1 AH81-00140A ASS.Y RP HEAD ADR2400-RP(SANKYO) MT91-11011P
2 AH81-00141A HEAD PB TC881CB MT59-00044A
3 AH81-00142A ASS,Y MOTOR ADR2400-SHU2L MT91-11013D
4 AH81-00143A BELT MAIN1 ADR2400-MAIN 76.2 6602-001038
5 AH81-00144A BELT MAIN2 ADR2400-MAIN 64.6 6602-001050
6 AH81-00101A BELT SUB ADR2400-FR 6602-001055
7 AH81-00102A SOLENOID ADR2400-1 MT75-00049A

Samsung Electronics

2-2

2-1-1 Cassette Deck :ADR241FTW(OPTION)

ADR241FTW

2

1

3

4

5

6

6

7

7

No. Code No. Description Specification Remarks

AH59-20006S DECK ASS’Y ADR241FTW
1 AH81-00140A RP HEAD ADR2400-RP(SANKYO),- MT91-11011P
2 AH81-00329A ASS’Y HEAD PB MK10PAA2N3, MT59-00041V
3 AH81-00142A ASSY MOTOR ADR2400-SHU2L,- MT91-11013D
4 AH81-00143A BELT MAIN1 ADR2400-MAIN 76.2,- 6602-001038
5 AH81-00330A BELT MAIN2 ADR2400-MAIN 93, 6602-001066
6 AH81-00101A BELT FR ADR2400S-FR,- 6602-001055
7 AH81-00102A SOLENOID ADR2400-1,- MT75-00049A

Samsung Electronics 2-3

2-2 Total Exploded View and Parts List

2-2-1 Total Exploded

Samsung Electronics

2-4

2-2-2 Parts List of Total Exploded view(MAX-N72)

No. Code No. Description ; Specification Q’ty Remarks

1 AH64-00615C CABINET-FRONT MIPS L/GRAY(G6236) 1 NONE MIC

AH64-00615D MIPS L/GRAY(G6236) 1 USE MIC 1
2 AH64-70003H BADGE-SAMSUNG SAMSUNG,SILVER 30mm 1
3 AH64-00621B WINDOW-CD PMMA 850-71129 1
4 AH64-00620B DOOR-CD ABS L/GRAY(G6236) 1
5 AH64-00622E WINDOW-DOOR.CD PMMA 850-71129 1
6 AH61-00366B CAP-FUNCTION ABS D/GRAY(G3174) 1
7 AH64-00623B WINDOW-VFD PMMA 850-41802 1 NONE RDS

AH64-00623C WINDOW-VFD PMMA 850-41802 1 USE RDS
8 AH64-00639B KNOB-VOLUME ABS L/GRAY(G6236) 1
9 AH64-00624B WINDOW-DOOR,A PMMA 850-83239 1

USE DOLBY MARK

AH64-00624C WINDOW-DOOR,A PMMA 850-83239 1 NONE DOLBY MARK
10 AH64-00625B WINDOW-DOOR,B PMMA 850-83239 1
11 AH64-00618B DOOR-CASS.A ABS L/GRAY(G6236) 1
12 AH64-00619B DOOR-CASS.B ABS L/GRAY(G6236) 1
13 AH61-00365A HOLDER-DOOR,A ABS L/GRAY (G6236) 1
14 AH61-00378A HOLDER-DOOR,B ABS L/GRAY (G6236) 1
15 AH61-62004C SPRING-EJECT,A SUS 304 PI 1.0 1
16 AH61-62005C SPRING-EJECT,B SUS 304 PI 1.0 1
17 AH61-00376A BRKT-MIC SECC 1.0T 1
18 AH64-00632B KNOB-POWER ABS L/GRAY (G6236) 1
19 AH67-00056A LENS-POWER PMMA MILKY 1
20 AH64-00634A KNOB-TIMER ABS D/GRAY(G3174) 1
21 AH64-00631B KNOB-DISC ABS D/GRAY (G3174) 1
22 AH67-00055A LENS-DISC PMMA CLR 1
23 AH64-00630B KNOB-OPEN ABS L/GRAY (G6236) 1
24 AH64-00635B KNOB-FUNCTION ABS D/GRAY(G3174) 1
25 AH67-00057A LENS-FUNCTION PMMA CLR 1
26 AH64-00636A KNOB-TURBO ABS D/GRAY(G3174) 1
27 AH67-00058B LENS-TURBO PMMA CLR 1
28 AH64-00637B KNOB-EQ,1 ABS L/GRAY(G6236) 1
29 AH64-00638B KNOB-EQ,2 ABS L/GRAY(G6236) 1
30 AH95-50001A LATCH ASSY POM BLACK 2
31 AH61-80030A DAMPER ASSY POM BLACK 2
32 AH64-00627B KNOB-JOG ABS L/GRAY (G6236) 1
33 AH67-00059B LENS-JOG PMMA CLR 1
34 AH64-00626B DECO-JOG ABS D/GRAY (G3174) 1
35 AH61-00369B CAP-MOV,TOP ABS L/GRAY (G6236) 1
36 AH67-00061A LENS-ENTER PMMA CLR 1
37 AH64-00628B KNOB-ENTER ABS L/GRAY (G6236) 1
38 AH67-00060A LENS-MOVING PMMA MILKY 1
39 AH61-00370A CAP-MOV,BOTTOM PC/ABS GRAY(1PB-0401) 1
40 AH61-00372A HOLDER-FEED NYLON 6/6 BLK 1
41 AH61-00374A BRKT-FEED SUS 301 1/4H 1
42 AH61-00371A HOLDER-MOVING PC/ABS GRAY(1PB-0401) 1
43 AH61-00367B CAP-UPPER ABS GRAY(1PB-0401) 1 USE DOLBY NR

AH61-00367C CAP-UPPER ABS GRAY(1PB-0401) 1 NONOE DOLBY NR
44 AH67-00062A LENS-RECORD PMMA MILKY 3
45 AH64-00629B KNOB-DECK ABS L/GRAY (G6236) 1
46 AH61-00368A CAP-BOTTOM ABS D/GRAY(G3174) 1
47 AH61-00399B SHAFT-GUIDE SUS 303 1
48 AH66-00114A PULLEY-MOTOR POM BLK 1

49 AH66-00108A BELT CR, MAX-N75 1
50 AH66-00110A PULLEY-SHAFT POM BLK 1
51 AH61-00375A BRKT-STOPPER SUS 301 1/4H 1
52 AH61-00399A SHAFT-FEED SUS 303 1
53 AH61-00373A HOLDER-VFD ABS WHT 1
54 AH64-00616A CABINET-TOP PCM 0.625T SILVER 1
55 AH64-30416C CABINET-BOTTOM SECC 1.0T 1
56 AH61-20540A HOLDER-TUNER PC/ABS BLACK 1
57 AH64-00617B CABINET-REAR SECC 0.8T 1 1 VOL

AH64-00617C CABINET-REAR SECC 0.8T 1 2 VOL
AH64-00617D CABINET-REAR SECC 0.8T 1 1 VOL + SW
AH64-00617E CABINET-REAR SECC 0.8T 1 2 VOL + SW

AH64-00617F CABINET-REAR SECC 0.8T 1 1 VOL + DIGITAL OUT
58 AH64-00640B KNOB-MIC,VOL ABS L/GRAY(G6236) 1 OPTION
59 AH64-00633B KNOB-ECHO ABS L/GRAY(G6236) 1 OPTION

No. Code No. Description ; Specification Q’ty Remarks

Samsung Electronics 2-5

2-2-3 Parts List of Total Exploded view(MAX-N73)

No. Code No. Description ; Specification Q’ty Remarks

1 AH64-00615C CABINET-FRONT MIPS L/GRAY(G6236) 1 NONE MIC

AH64-00615D CABINET-FRONT MIPS L/GRAY(G6236) 1 USE MIC 1
2 AH64-70003H BADGE-SAMSUNG SAMSUNG,SILVER 30mm 1
3 AH64-00621B WINDOW-CD PMMA 850-71129 1
4 AH64-00620B DOOR-CD ABS L/GRAY(G6236) 1
5 AH64-00622F WINDOW-DOOR.CD PMMA 850-71129 1
6 AH61-00366B CAP-FUNCTION ABS D/GRAY(G3174) 1
7 AH64-00623B WINDOW-VFD PMMA 850-41802 1 NONE RDS

AH64-00623C WINDOW-VFD PMMA 850-41802 1 USE RDS
8 AH64-00639B KNOB-VOLUME ABS L/GRAY(G6236) 1
9 AH64-00624B WINDOW-DOOR,A PMMA 850-83239 1

USE DOLBY MARK

AH64-00624C WINDOW-DOOR,A PMMA 850-83239 1 NONE DOLBY MARK
10 AH64-00625B WINDOW-DOOR,B PMMA 850-83239 1
11 AH64-00618B DOOR-CASS.A ABS L/GRAY(G6236) 1
12 AH64-00619B DOOR-CASS.B ABS L/GRAY(G6236) 1
13 AH61-00365A HOLDER-DOOR,A ABS L/GRAY (G6236) 1
14 AH61-00378A HOLDER-DOOR,B ABS L/GRAY (G6236) 1
15 AH61-62004C SPRING-EJECT,A SUS 304 PI 1.0 1
16 AH61-62005C SPRING-EJECT,B SUS 304 PI 1.0 1
17 AH61-00376A BRKT-MIC SECC 1.0T 1
18 AH64-00632B KNOB-POWER ABS L/GRAY (G6236) 1
19 AH67-00056A LENS-POWER PMMA MILKY 1
20 AH64-00634A KNOB-TIMER ABS D/GRAY(G3174) 1
21 AH64-00631B KNOB-DISC ABS D/GRAY (G3174) 1
22 AH67-00055A LENS-DISC PMMA CLR 1
23 AH64-00630B KNOB-OPEN ABS L/GRAY (G6236) 1
24 AH64-00635B KNOB-FUNCTION ABS D/GRAY(G3174) 1
25 AH67-00057A LENS-FUNCTION PMMA CLR 1
26 AH64-00636A KNOB-TURBO ABS D/GRAY(G3174) 1
27 AH67-00058B LENS-TURBO PMMA CLR 1
28 AH64-00637B KNOB-EQ,1 ABS L/GRAY(G6236) 1
29 AH64-00638B KNOB-EQ,2 ABS L/GRAY(G6236) 1
30 AH95-50001A LATCH ASSY POM BLACK 2
31 AH61-80030A DAMPER ASSY POM BLACK 2
32 AH64-00627B KNOB-JOG ABS L/GRAY (G6236) 1
33 AH67-00059B LENS-JOG PMMA CLR 1
34 AH64-00626B DECO-JOG ABS D/GRAY (G3174) 1
35 AH61-00369B CAP-MOV,TOP ABS L/GRAY (G6236) 1
36 AH67-00061A LENS-ENTER PMMA CLR 1
37 AH64-00628B KNOB-ENTER ABS L/GRAY (G6236) 1
38 AH67-00060A LENS-MOVING PMMA MILKY 1
39 AH61-00370A CAP-MOV,BOTTOM PC/ABS GRAY(1PB-0401) 1
40 AH61-00372A HOLDER-FEED NYLON 6/6 BLK 1
41 AH61-00374A BRKT-FEED SUS 301 1/4H 1
42 AH61-00371A HOLDER-MOVING PC/ABS GRAY(1PB-0401) 1
43 AH61-00367B CAP-UPPER ABS GRAY(1PB-0401) 1 USE DOLBY NR

AH61-00367C CAP-UPPER ABS GRAY(1PB-0401) 1 NONOE DOLBY NR
44 AH67-00062A LENS-RECORD PMMA MILKY 3
45 AH64-00629B KNOB-DECK ABS L/GRAY (G6236) 1
46 AH61-00368A CAP-BOTTOM ABS D/GRAY(G3174) 1
47 AH61-00399B SHAFT-GUIDE SUS 303 1
48 AH66-00114A PULLEY-MOTOR POM BLK 1

49 AH66-00108A BELT CR, MAX-N75 1
50 AH66-00110A PULLEY-SHAFT POM BLK 1
51 AH61-00375A BRKT-STOPPER SUS 301 1/4H 1
52 AH61-00399A SHAFT-FEED SUS 303 1
53 AH64-00373A HOLDER-VFD ABS WHT 1
54 AH64-00616A CABINET-TOP PCM 0.625T SILVER 1
55 AH64-30416C CABINET-BOTTOM SECC 1.0T 1
56 AH61-20540A HOLDER-TUNER PC/ABS BLACK 1
57 AH64-00617B CABINET-REAR SECC 0.8T 1 1 VOL

AH64-00617C CABINET-REAR SECC 0.8T 1 2 VOL
AH64-00617D CABINET-REAR SECC 0.8T 1 1 VOL + SW
AH64-00617E CABINET-REAR SECC 0.8T 1 2 VOL + SW

AH64-00617F CABINET-REAR SECC 0.8T 1 1 VOL + DIGITAL OUT
58 AH64-00640B KNOB-MIC,VOL ABS L/GRAY(G6236) 1 OPTION
59 AH64-00633B KNOB-ECHO ABS L/GRAY(G6236) 1 OPTION

No. Code No. Description ; Specification Q’ty Remarks

Samsung Electronics

2-6

2-2-4 Parts List of Total Exploded view(MAX-N75)

No. Code No. Description ; Specification Q’ty Remarks

1 AH64-00615C CABINET-FRONT MIPS L/GRAY(G6236) 1 NONE MIC

AH64-00615D CABINET-FRONT MIPS L/GRAY(G6236) 1 USE MIC1
2 AH64-70003H BADGE-SAMSUNG SAMSUNG,SILVER 30mm 1
3 AH64-00621B WINDOW-CD PMMA 850-71129 1
4 AH64-00620B DOOR-CD ABS L/GRAY(G6236) 1
5 AH64-00622B WINDOW-DOOR.CD PMMA 850-71129 1
6 AH61-00366B CAP-FUNCTION ABS D/GRAY(G3174) 1
7 AH64-00623B WINDOW-VFD PMMA 850-41802 1 NONE RDS

AH64-00623C WINDOW-VFD PMMA 850-41802 1 USE RDS

AH64-00639B KNOB-VOLUME ABS L/GRAY(G6236) 1
9 AH64-00624B WINDOW-DOOR,A PMMA 850-83239 1
10 AH64-00625B WINDOW-DOOR,B PMMA 850-83239 1
11 AH64-00618B DOOR-CASS.A ABS L/GRAY(G6236) 1
12 AH64-00619B DOOR-CASS.B ABS L/GRAY(G6236) 1
13 AH61-00365A HOLDER-DOOR,A ABS L/GRAY (G6236) 1
14 AH61-00378A HOLDER-DOOR,B ABS L/GRAY (G6236) 1
15 AH61-62004C SPRING-EJECT,A SUS 304 PI 1.0 1
16 AH61-62005C SPRING-EJECT,B SUS 304 PI 1.0 1
17 AH61-00376A BRKT-MIC SECC 1.0T 1
18 AH64-00632B KNOB-POWER ABS L/GRAY (G6236) 1
19 AH67-00056A LENS-POWER PMMA MILKY 1
20 AH64-00634A KNOB-TIMER ABS D/GRAY(G3174) 1
21 AH64-00631B KNOB-DISC ABS D/GRAY (G3174) 1
22 AH67-00055A LENS-DISC PMMA CLR 1
23 AH64-00630B KNOB-OPEN ABS L/GRAY (G6236) 1
24 AH64-00635B KNOB-FUNCTION ABS D/GRAY(G3174) 1
25 AH67-00057A LENS-FUNCTION PMMA CLR 1
26 AH64-00636A KNOB-TURBO ABS D/GRAY(G3174) 1
27 AH67-00058B LENS-TURBO PMMA CLR 1
28 AH64-00637B KNOB-EQ,1 ABS L/GRAY(G6236) 1
29 AH64-00638B KNOB-EQ,2 ABS L/GRAY(G6236) 1
30 AH95-50001A LATCH ASSY POM BLACK 2
31 AH61-80030A DAMPER ASSY POM BLACK 2
32 AH64-00627B KNOB-JOG ABS L/GRAY (G6236) 1
33 AH67-00059B LENS-JOG PMMA CLR 1
34 AH64-00626B DECO-JOG ABS D/GRAY (G3174) 1
35 AH61-00369B CAP-MOV,TOP ABS L/GRAY (G6236) 1
36 AH67-00061A LENS-ENTER PMMA CLR 1
37 AH64-00628B KNOB-ENTER ABS L/GRAY (G6236) 1
38 AH67-00060A LENS-MOVING PMMA MILKY 1
39 AH61-00370A CAP-MOV,BOTTOM PC/ABS GRAY(1PB-0401) 1
40 AH61-00372A HOLDER-FEED NYLON 6/6 BLK 1
41 AH61-00374A BRKT-FEED SUS 301 1/4H 1
42 AH61-00371A HOLDER-MOVING PC/ABS GRAY(1PB-0401) 1
43 AH61-00367B CAP-UPPER ABS GRAY(1PB-0401) 1 USE DOLBY NR
44 AH67-00062A LENS-RECORD PMMA MILKY 3
45 AH64-00629B KNOB-DECK ABS L/GRAY (G6236) 1
46 AH61-00368A CAP-BOTTOM ABS D/GRAY(G3174) 1
47 AH61-00399B SHAFT-GUIDE SUS 303 1
48 AH66-00114A PULLEY-MOTOR POM BLK 1

49 AH66-00108A BELT CR, MAX-N75 1
50 AH66-00110A PULLEY-SHAFT POM BLK 1
51 AH61-00375A BRKT-STOPPER SUS 301 1/4H 1
52 AH61-00399A SHAFT-FEED SUS 303 1
53 AH61-00373A HOLDER-VFD ABS WHT 1
54 AH64-00616A CABINET-TOP PCM 0.625T SILVER 1
55 AH64-30416C CABINET-BOTTOM SECC 1.0T 1
56 AH61-20540A HOLDER-TUNER PC/ABS BLACK 1
57 AH64-00617B CABINET-REAR SECC 0.8T 1 1 VOL

AH64-00617C CABINET-REAR SECC 0.8T 1 2 VOL
AH64-00617D CABINET-REAR SECC 0.8T 1 1 VOL + SW
AH64-00617E CABINET-REAR SECC 0.8T 1 2 VOL + SW

AH64-00617F CABINET-REAR SECC 0.8T 1 1 VOL + DIGITAL OUT
58 AH64-00640B KNOB-MIC,VOL ABS L/GRAY(G6236) 1 OPTION
59 AH64-00633B KNOB-ECHO ABS L/GRAY(G6236) 1 OPTION

No. Code No. Description ; Specification Q’ty Remarks

Samsung Electronics 2-7

2-3 CD Deck Exploded View and Parts list

12

8

2

19

7

6

5

4

3

1

15

27

10

9

20

21

11

14

16

13

CD SUB PCB

TRAY STOPPER

22

BASE MAIN

23

24

17

18

25

26

No. Code No. Description Specification Remarks

AJ59-20150T ASS’Y-DECK CMS-300
1 AH66-80022A SLIDER-CAM ABS HF-380 NTR
2 AH66-60034A BELT-LOAD CR
3 AH66-20186A GEAR-PULLEY POM (M90-44) WHT
4 AH66-20187A GEAR-LOAD POM (M90-44) BLK
5 AH66-20188A GEAR-CAM POM (M90-44) WHT
6 AH66-20189A GEAR-TRAY POM (M90-44) BLK
7 AH66-20190A GEAR-CONVERT POM (M90-44) WHT
8 AH66-20191A GEAR-SYNCRO ABS HF-380 NTR
9 AH66-20192A GEAR-WORM POM(M90-44),M0.5,PCD4.5
10 AH31-12001A MOTOR-LOADING FF-030PN-09120
11 AH66-20193A GEAR-ROULLETE POM(M90-44) BLK
12 AH66-90056A TRAY-ROULLETE ABS XR-401 BLK
13 AH66-90055A TRAY-DISC ABS BLK
14 AH59-10099A ASSY-PCB SENSOR CMS-300,ASSY SENSOR
15 AH61-00225A BRKT-CHUCK SECC T0.8,CMS-300
16 3302-000159 MAGNET-CHUCK AC,3500-3800G,2.6-3.2MGOe,30
17 AH66-90057A TABLE-CHUCK ,ABS,BLK,CMS-300
18 AH69-20342B SHEET-CHUCK SHEET,HYMERON,BLK,0.4T
19 AH59-10102A ASSY-PCB SW CMS-300,ASSY SW
20 AH31-10021A MOTOR-DC RF-500TB,9VDC/130MA
21 AH66-10008A PULLEY-MOTOR POM,BLK,CMS-CR3
22 AH73-10031A RUBBER-CD(R) SI,CMS-300,40,RED
23 AH91-60150A CDP DECK ASSY CMS-D50SG6,CMS-300D
24 AH66-30098A LEVER-LIFTER ABS BLK CMS-300
25 AH30-00003A PICK-UP SOH-AA,D51SG6(W/D/CO)
26 AH73-10034A RUBBER-CD(G) SI,CMS-300,40,GREEN
27 AH61-20428A BASE-MAIN ABS,BLK,CMS-300

Samsung Electronics

2-8

2-4 SPEAKER Exploded View and Parts list

* PSN72 : ASS'Y SPK(AH81-00253A)

Description

7
7

* CAUSION : It is used the bonding, connet FRONT PANEL ASS’Y to CABINET ASS’Y.

So when the disassembly, take extreme care not to demage the SPEAKER.

2-4-1 MAX-N72

Samsung Electronics 2-9

2-4-2 MAX-N73

1

4

3

2

5

* PSN73 : ASS'Y SPK(AH81-00252A)

Description

AH81-00277R

W/F

AH81-00277J

6

6

* CAUSION : It is used the bonding, connet FRONT PANEL ASS’Y to CABINET ASS’Y.

So when the disassembly, take extreme care not to demage the SPEAKER.

2-4-3 MAX-N75

1

5

6

3

2

4

* PSN75 : ASS'Y SPK(AH81-00251A)

Description Description

Samsung Electronics 3-1

***** MAXN72 Parts List *****

AH26-00063A TRANS-POWER;E85.8X50,-,-,-,-,SILICON STEEL SHEET,230
AH38-10001A WIRE-LEAD;1007#22,1500MM
AH39-00021A LEAD-CONNECTOR ASSY;-,5264,GT201-6,6P,300MM,2547#28,2P SHIEL
AH39-00202A LEAD CONNECTOR-ASSY;-,1533#28,-,3P,200MM,-,-,5264-3P,GIL-S-3
AH39-10002L POWER CORD;CP2,KLCE-2F,2.15M,5239,VDE
AH42-20001Q ANT-LOOP;-,KS980214-01,18.5uH,CONNECTOR
AH59-00004Q REMOCON—ASSY;-,-,-,22KEY,MAX-N75,SAMSUNG
AH59-20006S DECK;ADR241FTW,-,DC12V,-,-,MAXN75,-

AH92-00245A ASSY-PCB;SMK35/45,TUNER-T S.N.A.

TR6 2007-000030 R-CHIP;560OHM,5%,1/10W,DA,TP,2012
TR101 2007-000033 R-CHIP;0OHM,5%,1/8W,DA,TP,3216
TR102 2007-000033 R-CHIP;0OHM,5%,1/8W,DA,TP,3216
TR103 2007-000033 R-CHIP;0OHM,5%,1/8W,DA,TP,3216
TR104 2007-000033 R-CHIP;0OHM,5%,1/8W,DA,TP,3216
TR19 2007-000282 R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
TR45 2007-000282 R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
TR47 2007-000282 R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
TR49 2007-000282 R-CHIP;100KOHM,5%,1/10W,DA,TP,2012
RR2 2007-000290 R-CHIP;100OHM,5%,1/10W,DA,TP,2012
TR24 2007-000290 R-CHIP;100OHM,5%,1/10W,DA,TP,2012
TR43 2007-000290 R-CHIP;100OHM,5%,1/10W,DA,TP,2012
TR2 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR21 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR22 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR46 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR48 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR50 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR53 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR54 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR56 2007-000300 R-CHIP;10KOHM,5%,1/10W,DA,TP,2012
TR10 2007-000308 R-CHIP;10OHM,5%,1/10W,DA,TP,2012
TR20 2007-000409 R-CHIP;15KOHM,5%,1/10W,DA,TP,2012
TR28 2007-000457 R-CHIP;18KOHM,5%,1/10W,DA,TP,2012
TR52 2007-000468 R-CHIP;1KOHM,5%,1/10W,DA,TP,2012
TR9 2007-000468 R-CHIP;1KOHM,5%,1/10W,DA,TP,2012
TR35 2007-000493 R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
TR36 2007-000493 R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
TR40 2007-000493 R-CHIP;2.2KOHM,5%,1/10W,DA,TP,2012
TR7 2007-000518 R-CHIP;2.7KOHM,5%,1/10W,DA,TP,2012
TR11 2007-000572 R-CHIP;220OHM,5%,1/10W,DA,TP,2012
TR105 2007-000586 R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
TR15 2007-000586 R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
TR37 2007-000586 R-CHIP;22KOHM,5%,1/10W,DA,TP,2012
TR12 2007-000686 R-CHIP;3.3KOHM,5%,1/10W,DA,TP,2012
TR29 2007-000686 R-CHIP;3.3KOHM,5%,1/10W,DA,TP,2012
TR23 2007-000710 R-CHIP;3.9KOHM,5%,1/10W,DA,TP,2012
TR8 2007-000822 R-CHIP;390OHM,5%,1/10W,DA,TP,2012
TR4 2007-000872 R-CHIP;4.7KOHM,5%,1/10W,DA,TP,2012
TR51 2007-000872 R-CHIP;4.7KOHM,5%,1/10W,DA,TP,2012
TR17 2007-000981 R-CHIP;5.6KOHM,5%,1/10W,DA,TP,2012
TR25 2007-001043 R-CHIP;56OHM,5%,1/10W,DA,TP,2012
TR27 2007-001071 R-CHIP;6.8KOHM,5%,1/10W,DA,TP,2012
TR38 2007-001177 R-CHIP;8.2KOHM,5%,1/10W,DA,TP,2012
TR44 2007-001177 R-CHIP;8.2KOHM,5%,1/10W,DA,TP,2012
TC41 2203-000239 C-CERAMIC,CHIP;0.1nF,5%,50V,NP0,TP,2012
RC2 2203-000260 C-CERAMIC,CHIP;10nF,10%,50V,X7R,TP,2012
TC20 2203-000260 C-CERAMIC,CHIP;10nF,10%,50V,X7R,TP,2012
TC28 2203-000260 C-CERAMIC,CHIP;10nF,10%,50V,X7R,TP,2012
TC29 2203-000260 C-CERAMIC,CHIP;10nF,10%,50V,X7R,TP,2012
TC3 2203-000260 C-CERAMIC,CHIP;10nF,10%,50V,X7R,TP,2012
TC44 2203-000260 C-CERAMIC,CHIP;10nF,10%,50V,X7R,TP,2012
TC7 2203-000429 C-CERAMIC,CHIP;0.018nF,5%,50V,NP0,TP,2012
TC1 2203-000609 C-CERAMIC,CHIP;22nF,10%,50V,X7R,TP,2012
TC5 2203-000609 C-CERAMIC,CHIP;22nF,10%,50V,X7R,TP,2012
TC99 2203-000609 C-CERAMIC,CHIP;22nF,10%,50V,X7R,TP,2012
TC33 2203-000844 C-CERAMIC,CHIP;39nF,10%,50V,X7R,TP,2012,­RC7 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
TC10 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
TC13 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
TC15 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
TC35 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
TC45 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
TC6 2203-000979 C-CERAMIC,CHIP;47nF,10%,50V,X7R,TP,2012
RC8 2203-001058 C-CERAMIC,CHIP;0.56nF,5%,50V,NP0,TP,2012
TC61 2203-001105 C-CERAMIC,CHIP;6.8nF,10%,50V,X7R,TP,2012
TC62 2203-001105 C-CERAMIC,CHIP;6.8nF,10%,50V,X7R,TP,2012
TC32 2203-001132 C-CERAMIC,CHIP;0.68nF,5%,50V,NP0,TP,2012
TC2 2203-001517 C-CERAMIC,CHIP;0.015nF,5%,50V,NP0,TP,2012
RC4 2203-001524 C-CERAMIC,CHIP;0.047nF,5%,50V,NP0,TP,2012
RC5 2203-001524 C-CERAMIC,CHIP;0.047nF,5%,50V,NP0,TP,2012
TC63 2203-001551 C-CERAMIC,CHIP;1.5nF,10%,50V,X7R,TP,2012
TC64 2203-001551 C-CERAMIC,CHIP;1.5nF,10%,50V,X7R,TP,2012
TC50 2203-001611 C-CERAMIC,CHIP;0.022nF,5%,50V,NP0,TP,2012

TC51 2203-001611 C-CERAMIC,CHIP;0.022nF,5%,50V,NP0,TP,2012
TD3 0401-000101 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,TP
TD4 0401-000101 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,TP
TD5 0401-000101 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,TP
TD6 0401-000101 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,TP
TZD1 0403-000367 DIODE-ZENER;UZ7.5BSC,7.5V,7.33-7.64V,500mW
RZD1 0403-000393 DIODE-ZENER;UZP5.1B,5.1V,4.8-5.4V,1W,DO-41
TZD2 0403-000393 DIODE-ZENER;UZP5.1B,5.1V,4.8-5.4V,1W,DO-41
TQ4 0501-000294 TR-SMALL SIGNAL;KSA708-Y,PNP,800mW,TO-92,TP,12
TQ2 0501-000392 TR-SMALL SIGNAL;KSC838-O,NPN,250mW,TO-92,-,70­TQ3 0501-000392 TR-SMALL SIGNAL;KSC838-O,NPN,250mW,TO-92,-,70­TQ1 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250mW,TO-92,TP,120­TQ5 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250mW,TO-92,TP,120­TQ6 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250mW,TO-92,TP,120­TQ7 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250mW,TO-92,TP,120­TR30 2001-000117 R-CARBON(S);68OHM,5%,1/2W,AA,TP,2.4X6.4MM
RR1A 2001-000118 R-CARBON(S);180ohm,5%,1/2W,AA,TP,2.4x6.4mm
TR44 2001-000118 R-CARBON(S);180ohm,5%,1/2W,AA,TP,2.4x6.4mm
TR58 2001-000273 R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR5 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM

- 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR39 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR1 2001-000331 R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RR3 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RR4 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RR5 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR32 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR34 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR55 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR18 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR3 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR13 2001-000515 R-CARBON;220OHM,5%,1/8W,AA,TP,1.8X3.2MM
TR40 2001-000522 R-CARBON;22KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR61 2001-000591 R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR62 2001-000591 R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR42 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
TR16 2001-000745 R-CARBON;4.7OHM,5%,1/8W,AA,TP,1.8X3.2MM
TR41 2001-000802 R-CARBON;5.6Kohm,5%,1/8W,AA,TP,1.8x3.2m
TR57 2001-000802 R-CARBON;5.6Kohm,5%,1/8W,AA,TP,1.8x3.2m
TSR1 2103-000290 VR-SEMI;20Kohm,30%,1/10W,TOP
TC14 2201-000565 C-CERAMIC,DISC;47nF,20%,50V,Y5V,12.5x4.0mm,5mm,TP
TC39 2201-000565 C-CERAMIC,DISC;47nF,20%,50V,Y5V,12.5x4.0mm,5mm,TP
RC9 2202-000796 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,­TC40 2202-000796 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,­TC42 2202-000796 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,­TC48 2202-000807 C-CERAMIC,MLC-AXIAL;22NF,+80-20%,25V,Y5V,TP,3.5X19
TC21 2401-000240 C-AL;100uF,20%,10V,GP,TP,5x11,5
TC46 2401-000240 C-AL;100uF,20%,10V,GP,TP,5x11,5
TC12 2401-000419 C-AL;10UF,20%,16V,GP,-,4X7,5
TC26 2401-000419 C-AL;10UF,20%,16V,GP,-,4X7,5
TC27 2401-000419 C-AL;10UF,20%,16V,GP,-,4X7,5
TC30 2401-000419 C-AL;10UF,20%,16V,GP,-,4X7,5
RC1 2401-000907 C-AL;22UF,20%,16V,GP,-,5X11,2MM
TC34 2401-000907 C-AL;22UF,20%,16V,GP,-,5X11,2MM
TC37 2401-001022 C-AL;3.3UF,20%,50V,GP,-,5X11,2MM
TC38 2401-001164 C-AL;33UF,20%,16V,GP,-,5X11,2MM
TC47 2401-001895 C-AL;100uF,20%,16V,GP,6.3x11mm,2.5m
TC11 2401-001912 C-AL;1uF,20%,50V,GP,5x11mm,2mm,BK
TC17 2401-001912 C-AL;1uF,20%,50V,GP,5x11mm,2mm,BK
TC19 2401-001912 C-AL;1uF,20%,50V,GP,5x11mm,2mm,BK
TC16 2401-001954 C-AL;4.7UF,20%,50V,GP,TP,5X11MM,5
TC23 2401-001954 C-AL;4.7UF,20%,50V,GP,TP,5X11MM,5
TC25 2401-001954 C-AL;4.7UF,20%,50V,GP,TP,5X11MM,5
TC18 2401-001968 C-AL;470NF,20%,50V,GP,TP,5X11MM,5
TC43 2401-001968 C-AL;470NF,20%,50V,GP,TP,5X11MM,5
TC4 2401-001975 C-AL;47UF,20%,16V,GP,TP,5X11MM,5
TC9 2401-001975 C-AL;47UF,20%,16V,GP,TP,5X11MM,5
RC6 2401-002180 C-AL;2.2UF,20%,50V,GP,TP,5X11,5MM
RIC1 AH14-10008E IC;BU1923F,SOP,+5V
VVC1 0405-000137 DIODE-VARACTOR;KV-1260,20V,100NA,T0-92S
TFL4 14529-304-610 FILTER CERAMIC;AHCM2-450BL

2202-000263 C-CERAMIC,MLC-AXIAL;470pF,10%,50V,Y5P,TP,3.5x19,­TX1 2801-000734 CRYSTAL-UNIT;7.2MHZ,50PPM,28-AAM,12PF,30OHM
RX1 2801-003601 CRYSTAL-UNIT;4.332MHz,30ppm,28-AAM,30pF,
TFL2 2903-000105 FILTER-CERAMIC;BP,10.7MHZ+-25KHZ,180KHZ+-50KH
TFL1 2903-000119 FILTER-CERAMIC;SFE10.7MJA-10-A
TWA1 3710-001421 CONNECTOR-SOCKET;14P,1R,2mm,ANGLE,SN
TJ2 3711-000814 CONNECTOR-HEADER;BOX,2P,1R,2.5mm,ANGLE,SN
TJ1 3716-000210 TERMINAL-BLOCK;-,-,-,60V,7A
HIC1 AH14-10007G IC;LC72131,DIP,STICK PLL
TIC1 AH14-10008B IC;LA1837,DIP,RF+MPX
TLPF1 AH26-00005A TRANS-IF;-,LKS75M00-X000264-0,LOW PASS FILTER,-,7
TLPF2 AH26-00005A TRANS-IF;-,LKS75M00-X000264-0,LOW PASS FILTER,-,7
TL2 AH26-10001E TRANS-IF;KS940228-09,-,-,7.6X12.0,-,450KHZ,BULK,
TL3 AH26-10020A TRANS-DET;-,7KLL,DET,-,7.8MM,91PF,11.32M
LW AH27-00007A COIL-OSC;LKS7FB00-0060BLO-0,-,LW OSC
OSC AH27-00007A COIL-OSC;LKS7FB00-0060BLO-0,-,LW OSC
MW AH27-00008A COIL-OSC;LKS75M00-0060LMO-0,-,MW OSC
OSC AH27-00008A COIL-OSC;LKS75M00-0060LMO-0,-,MW OSC

Location no. Code no. Description & Specifiation Remarks

Location no. Code no. Description & Specifiation Remarks

3. Electrical Parts List

*S.N.A. : Service Not Available