Roland DJ-2000 Service Manual

May, 1998

Input Socket Rated Input Level Non-Clip Max, Input Input Impedance Type of Connectors MIC1

MIC2 LINE1-5

PHONO1-3

RETURN

-50dBm(2.45mV)

-20dBm(77.5mV) (GAIN = max) +4dBm(1.23V) (GAIN = min)

-55dBm(1.38mV) (GAIN = max)

-31dBm(22mV) (GAIN = min)

-10dBm(245mV)

-10dBm(245mV) 0dBm(775mV) (GAIN = max) +24dBm(12.3V) (GAIN = min)

-35dBm(13.8mV) (GAIN = max)

-5dBm(138mV) (GAIN = min) +10dBm(2.45V)

2.2k½

2.2k½ 22k½

50k½

100k½

XLR-3-31 TYPE(UNBAL) 1/4"TRS PHONE(UNBAL) 1/4"TRS PHONE(UNBAL) RCA

RCA

1/4" PHONE

Output Socket

Rated Output Level

-----------

Non-Clip Max, Output Output Impedance Type of Connectors

MASTER OUT

SEND OUT SAMPLER OUT PHONES * 0dBm=0.775 Vrms *1: Both Channels 33½ Loaded

+4dBm (1.23V) 0 dBm (0.775V)

-10dBm (245mV)

+20dBm (7.75V) +16dBm (4.89V) +10dBm (2.45V) +10dBm (2.45V) 1W+1W *1

300½

2.2k½

2.2k½ 10½

1/4" PHONE RCA 1/4" PHONE RCA 1/4" STEREO PHONE

DJ-2000

MAIN SPECIFICATIONS/INPUT AND OUTPUT STANDARDS

DJ-2000

Issued by RJA

TABLE OF CONTENTS Page

SPECIFICATIONS / INPUT AND OUTPUT STANDARD PANEL LAYOUT•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••3 EXPLODED VIEW•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••4 PARTS LIST•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••5, 6 IDENTIFYING THE VERSION NUMBER•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••7 TEST MODE ••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••7, 8 BLOCK DIAGRAM ••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••9 CIRCUIT BOARD

DSP BOARD ASSY (71018267) •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••10 MIXER BOARD ASSY (71017901) / PHONES BOARD (71017990) JACK BOARD A (71017934) / JACK BOARD B (71017967) SW BOARD A ASSY (71018278) / SW BOARD B ASSY (71120867) PS BOARD 1 ASSY (71019190) / PS BOARD 2 ASSY (71017890) / MIDI BOARD ASSY (71120889) / TRANS BOARD ASSY (********)

CIRCUIT DIAGRAM

DSP BOARD ASSY•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••14 MIXER BOARD ASSY 1/3•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••15 MIXER BOARD ASSY 2/3•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••16 MIXER BOARD ASSY 3/3+PHONES•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••17 JACK BOARD A+JACK BOARD B ••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••18 PS1+PS2+TRANS BOARD ASSY•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••19 SW BOARD A ASSY •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••20 SW BOARD B ASSY •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••21 MIDI BOARD ASSY ••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••22

•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••1, 2

•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••11

••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••12

•••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••13

Specifications

●Frequency Response•••••••••••••••••••••••••••••••••••••• 20Hz~20kHz +1dB(GAIN = min)

●Total Harmonic Distortion••••••••••••••••••••••••••••••••• 0.05% or less(20Hz to 20kHz rated output)

●SN Ratio ••••••••••••••••••••••••••••••••••••••••••••••••••••• 80dB(Input terminated with 150W, IHF-A,Typ.)

●Crosstalk••••••••••••••••••••••••••••••••••••••••••••••••••••• -70dB or less(1kHz between channels)

-70dB or less(1kHz between L and R)

●Equalizer••••••••••••••••••••••••••••••••••••••••••••••••••••• HIGH : +16dB(12kHz shelving type) MID : +16dB(2kHz peaking type) LOW : +16dB(40Hz shelving type)

●Isorator••••••••••••••••••••••••••••••••••••••••••••••••••••••• HIGH :-¥~+12dB MID :LOW :-

●Power••••••••••••••••••••••••••••••••••••••••••••••••••••••••• AC100V(50/60Hz), AC117V,AC230V,AC240V

●Power Consumption••••••••••••••••••••••••••••••••••••••• 35W

●Dimensions•••••••••••••••••••••••••••••••••••••••••••••••••• 482.0(W)x310.4(D)x111.9(H)mm (7U)

19(W)x12-1/4(D)x4-7/16(H) inches

●Weight•••••••••••••••••••••••••••••••••••••••••••••••••••••••• 6.8kg / 16lbs

●Accessories ••••••••••••••••••••••••••••••••••••••••••••••••• Owner's Manual English(#71018723)

AC Cord 100V : (#13499219)

Euro Converter Plug (#00905234) 230VE only

●Options••••••••••••••••••••••••••••••••••••••••••••••••••••••• Cross Fader for replacing : CFX-1

* In the interest of product improvement, the specifications and /or appearance of this unit are subject to change without prior notice.

Input Standard

_ _ _

~+12dB

117V : (#13499220) 230V : (#13499221) 240VA : (#13499222)

17059928

Output Standard

Printed in Japan (CR) ACE0 1

DJ-2000

May, 1998

[PANEL LAYOUT PARTS LIST]

No. PART No. PART NAME

q 01451045 LED(GREEN) LN31GPH-(TA5) w 01451089 LED(RED) LNJ801RFDAE e 01451056 LED(GREEN) LNJ309GKGAH r 01451090 LED(RED) LNJ809RKDAH t 01451078 LED(YELLOW) LNJ409YKXAH y 01451067 LED(YELLOW) LN41YPH-(TA5) u 01451112 12M/M ROTARY POT. EVJY96FB6B24

01341267 J R-KNOB SF(BLK/RED)

i 01451101 12M/M ROTARY POT. EVJY95FB6A15

01341267 J R-KNOB SF(BLK/RED)

o 01451123 12M/M ROTARY POT. EVJY95FB6B54

01341267 J R-KNOB SF(BLK/RED)

!0 01451156 12M/M ROTARY POT. EVJY15FB6A24

01341267 J R-KNOB SF(BLK/RED)

!1 01451167 9M/M ROTARY POT. EVUF2KFK3C15

01341267 J R-KNOB SF(BLK/RED)

!2 01451178 9M/M ROTARY POT. EVUF3KFK3B24

01341267 J R-KNOB SF(BLK/RED)

!3 01451134 14M/M ROTARY POT.RK14K12D (TKO05 A-3)

01452423 J R-KNOB MF BLK RED

!4 01454778 11M/M ROTARY POT.RK11K114 (TKO10 A-1)

01452423 J R-KNOB MF BLK RED

!5 01454789 11M/M ROTARY POT.RK11K114 (TKO10 A-2)

01341267 J R-KNOB SF(BLK/RED)

!6 01454767 ROTARY SWITCH SRBV16-F0020-11

01341267 J R-KNOB SF(BLK/RED)

!7 15029350 LED(GREEN/RED) LN11WP23 !8 01454745 LED(RED) LNJ808RKDAG !9 01454734 LED(GREEN) LN38GPX-(TA7) @0 01457167 LED(RED) LNJ208R8ARA

01455489 SW HOLDER 01455490 RUBBER SWITCH

@1 01454712 LED(SEGMENT) LN534RAMR

01455501 DISPLAY COVER

@2 01451189 60M/M SLIDE POT. EWAQ36D20A14

01455423 POT DUST COVER L 01452412 J S-KNOB L BLK RED

@3 01451190 60M/M SLIDE POT. EWAQ1GD20A14

01455423 POT DUST COVER L 01452412 J S-KNOB L BLK RED

@4 01451201 45M/M SLIDE POT. EWAP36D20A14

01455412 POT DUST COVER S 01452412 SLIDER KNOB(BLK/RED) J S-KNOB L BLK RED

@5 01454201 45M/M SLIDE POT. EWAP37D15G54

01455412 POT DUST COVER S 01452412 SLIDER KNOB(BLK/RED) J S-KNOB L BLK RED

@6 01348978 LEVER SWITCH LS001-D22BAB-LFA15B

01455401 DUST COVER

@7 01348990 LEVER SWITCH LS001-C23OAB-LFA15B

01455401 DUST COVER

@8 01348989 LEVER SWITCH LS001-D42BBB-LFA15B

01455401 DUST COVER

@9 01452812 PUSH SW/KEY TOP PS009-PSH022BBT-PA5.5W #0 13129375 PUSH SW SPEA12

22495521 BUTTON

#1 01451301 PUSH SW SPEA52-* (TKO05 A-5)

22495521 BUTTON

#2 01454723 PUSH SW SWITCH ESB64620

22495572 F S-BUTTON BX MCG

#3 00569278 6.5MM JACK LGR4609-7000

22150756 JACK NUT 2

#4 01455223 FRONT PANEL #5 01455278 CROSSFADER PANEL #6 01455290 EFFECT PANEL #7 01347734 SEESAW SWITCH MSR5-2#1 6A/250V #8 23425740 AC INLET INL-8 10A/125V 2P PO #9 01455245 BOTTOM COVER

22355160 FOOT D25 (BASE)

$0 13449283 6.5MM JACK HLJ7101-01-3010

$1 13449645 RCA PIN JACK YKC21-3049 $2 00569278 6.5MM JACK LGR4609-7000 $3 01239890 XLR CONNECTOR CANNON NC3FAH2-0 $4 13429672 MIDI JACK YKF51-5047 $5 01348889 GROUNDING TERMINAL MT-903C $6 01455234 BOTTOM CHASSIS

May, 1998

LOCATION OF CONTROLS

DJ-2000

EXPLODED VIEW

May, 1998

SAFETY PRECAUTIONS: The parts marked have safety-related characteristics. Use only listed parts for replacement.

CONSIDERATIONS ON PARTS ORDERING

When ordering any parts listed in the parts list, please specify the following items in the order sheet. QTY PART NUMBER DESCRIPTION MODEL NUMBER Ex. 10 22575241 Sharp Key C-20/50 15 2247017300 Knob (orange) DAC-15D Failure to completely fill the above items with correct number and description will result in delayed or even undelivered replacement.

May, 1998

DJ-2000

EXPLODED VIEW PARTS LIST

No. PART NUMBER PART NAME

q 01455290 EFFECT PANEL w 01455489 SW HOLDER e 01455490 RUBBER SWITCH r 71018278 SW BOARD A ASSY t 71120867 SW BOARD B ASSY y 71018267 DSP BOARD ASSY u 01455256 TRANS HOLDER i 71017890 PS BOARD 2 ASSY o 01455645 POWER TRANSFORMER UNIVERSAL !0 71019190 PS BOARD 1 ASSY HI

NOTE: Replacement PS BOARD 1 ASSY HI is 230V/240V version exclusive use.

When using PS BOARD 1 ASSY for 100V/117V veision, be sure to make the following modifications.

1. Replace fuse to specific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE A.

TABLE A 100V/117V #12559435 SB500 5x20mm 500mA/250V 230V/240V #12559540 S504 5x20mm T160mA/250

2. Replace fuse seal to specific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE B.

TABLE B 100V/117V #40014389 FUSE SEAL [UL 500MA 250V] 230V240V #40013589 FUSE SEAL [T160MAL250V]

3. Change the check mark on the PWB as shown in fig.1.

fig.1 230V/240V 100V/117V

● 230/240 71019190 230/240 71019190

!1 ******** CROSSFADER UNIT CFX-1

NOTE: CROSS FADER UNIT CFX-1 is consumable goods.

When necessary,please replace with the Cross Fader for replacing the DJ-2000(CFX-1;Optionally available.

!2 01455223 FRONT PANEL !3 01455234 BOTTOM CHASSIS !4 01347734 SEESAW SWITCH MSR5-2#1 6A/250V !5 71017990 PHONES BOARD ASSY !6 71017901 MIXER BOARD ASSY !7 71120889 MIDI BOARD ASSY !8 71017934 JACK BOARD ASSY A !9 71017967 JACK BOARD ASSY B @0 01455245 BOTTOM COVER @1 22355160 FOOT D25 @2 12159799 EDGE HOLDER

No. PART NUMBER PART NAME

Å 40239889 TRUSS BUTTON HEAD SCREW S-TITE M3*6 BZC ı 40239890 TRUSS BUTTON HEAD SCREW S-TITE M4*8 BZC Ç 22150756 JACK NUT 2 Î 40015967 FLAT TAPTITE S 3*6 BZC ‰ 40011312 BINDING TAPTITE P 3*8 BZC Ï 40011934 INTERNAL TOOTH WASHER M9 ZC

Ó 40016712 JACK WASHER 12*18*0.6 BZC ¬ 40011490 PAN MACHINE SCREW W/SW M3*6 BZC Ô 40011101 BINDING TAPTITE B 3*8 BZC  40011090 BINDING TAPTITE B 3*6 BZC Ò 40013056 PAN MACHINE SCREW W/SW+SMALL PW M3*6 ZC ˜ 22150524 BOSS NUT M3/M3 L8 ˆ 40017934 PAN MACHINE SCREW W/SW+PW M3*6 ZC Ø 40011056 BINDING TAPTITE B 3*6 ZC ∏ 40012289 BINDING TAPTITE B 3*16 ZC Œ 40012867 PAN MACHINE SCREW W/SW+PW M3*8 ZC Â 01458590 BOSS NUT M3/M3 L8.5 Í 22153526 BOSS NUT M3/M3 L12

40016756 JACK NUT HLJ0999-01-360 HEX M1240016712

100/117 71018478 ● 100/117 71018478

PARTS LIST

NOTE:The parts marked # are new (initial parts)

MB ===> MAIN BOARD IB ===> IF BOARD SCB ===> SCSI BOARD SB ===> SW BOARD EB ===> ENC BOARD

CASING

# 01455223 FRONT PANEL # 01455234 BOTTOM CHASSIS # 01455245 BOTTOM COVER

22355160 FOOT D25 # 01455278 FADER PANEL CROSS FADER # 01455290 EFFECT PANEL # 01455501 DISPLAY COVER

CHASSIS

# 01455256 TRANS HOLDER PS ASSY # 01455489 SW HOLDER EFFECT ASSY

00782734 IC HOLDER PS ASSY

KNOB, BUTTON

01341267 J R-KNOB SF BLK/RED

01452423 J R-KNOB MF BLK RED ISOLATOR, RATE, PITCH, FORMANT # 01452412 J S-KNOB L BLK RED FADER

22495521 BUTTON CUE SELECT, METER SELECT

22495572 F S-BUTTON BX MCG FREQ RANGE, SYNC TYPE, BPM SYNC # 01455490 RUBBER SWITCH EFFECT

SWITCH

# 01347734 MSR5-2#1 6A/250V Seesaw SWITCH (POWER) # 01348978 LS001-D22BAB-LFA15B Lever SWITCH SW101,SW103,SW201,SW203,SW301,SW303,SW401,

# 01348990 LS001-C23OAB-LFA15B Lever SWITCH SW701 on MX(ISOLATOR) # 01348989 LS001-D42BBB-LFA15B Lever SWITCH SW702 on MX(SEND SELECT)

13129375 SPEA12 2 CIRCUIT Push SWITCH SW704 on MX(METER) # 01451301 SPEA52-* (TKO05 A-5) Push SWITCH SW705 on MX(CUE) # 01452812 PS009-PSH022BBT-PA5.5W Push SWITCH SW1001-1002 on MX(TRANSFORMER) # 01454723 ESB64620 Push SWITCH SW1-3 on SWA(FREQ RANGE,SYNC TYPE,BPM SYNC) # 01454767 SRBV16-F0020-11 Rotary SWITCH SW4 on SWB(CH SELECT)

JACK, SOCKET

01239890 NC3FAH2-0 XLR JACK JK6 on JKA(MIC1)

13449645 YKC21-3049 PIN JACK JK1-2,JK4,JK7 on JKA, JK8 on JKB

13429672 YKF51-5047 MIDI JACK JK2 on MIDI

00569278 LGR4609-7000 PHONE JACK JK3,JK5 on JKA, JK1001 on PH(MIC1, MIC2, PHONES)

13449283 HLJ7101-01-3010 PHONE JACK JK9-14 on JKB(MASTER, SEND, RETURN)

PCB ASSY

‰ 71018267 DSP BOARD ASSY

71017901 MIXER BOARD ASSY

71017934 JACK BOARD A ASSY

71017967 JACK BOARD B ASSY

71017990 PHONES BOARD ASSY

71019190 PS-1 BOARD ASSY HI

NOTE: Replacement PS BOARD 1 ASSY HI is 230V/240V version exclusive use.

1. Replace fuse to specific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE A.

TABLE A 100V/117V #12559435 SB500 5x20mm 500mA/250V

230V/240V #12559540 S504 5x20mm T160mA/250

2. Replace fuse seal to specific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE B.

TABLE B 100V/117V #40014389 FUSE SEAL

230V240V #40013589 FUSE SEAL [T160MAL250V

3. Change the check mark on the PWB as shown in fig.1.

fig.1 230V/240V 100/117 71018478

● 230/240 71019190 100V/117V

● 100/117 71018478 230/240 71019190

71017890 PS-2 BOARD ASSY

When using PS BOARD 1 ASSY for 100V/117V veision, be sure to make the following modifications.

[

UL 500MA 250V

]

GAIN, EQ, MIC2, RETURN, MONITOR, CH SELECT, EFFECT BAL

SW403 on MX (INPUT, ASSIGN)

DJ-2000

! !

! ! !

! ! ! ! !

! ! !

May, 1998

NOTE: PS-2 BOARD ASSY includes TRANS BOARD ASSY. 71120889 MIDI BOARD ASSY

71018278 SW BOARD A ASSY 71120867 SW BOARD B ASSY

******** CROSS FADER UNIT CFX-1 NOTE: CROSS FADER UNIT CFX-1 is consumable goods.

When necessary,please replace with the Cross Fader for replacing the DJ-2000. (CFX-1;Optionally available)

# 01340078 HD6433040SA00F IC CPU IC2 on DSP

01236401 TMS57070FFT IC DSP IC3 on DSP 01126767 UDA1309H IC AD/DA IC16 on DSP 01349178 NN514260J-60T IC DRAM IC4,IC5 on DSP ******** LH28F400SUT FLASH Memory IC11 on DSP 15289123 M51953AFP Reset IC (chip) IC10 on DSP 15169334H0 HD74LS05P Gate IC IC4 on MIDI 15249111 TC7WU04F Gate IC (chip) IC6 on DSP 00127490 TC7W08F Gate IC (chip) IC9 on DSP 00232634 TC7W74F Gate IC (chip) IC8 on DSP 15259738T0 TC74HC138AF Gate IC (chip) IC1 on SWA

# 01454667 BA6137 IC LED Driver IC727,IC729 on MX

15289154 UPC4072G2 IC OP-Amp (flat) IC716-725 on MX 15289105 UPC4570G2 IC OP-Amp (flat) IC101,IC104,IC201,IC204,IC301,IC304,

15189189 UPC4570HA IC OP-Amp IC2,IC4 on SWB" 01129078 AN7715F IC +15V Voltage Regulator IC1 on PS2 15199134 AN7915F IC -15V Voltage Regulator IC2 on PS2 15199294 AN7705F IC +5V Voltage Regulator IC3 on PS2 15289402 TA78L05F IC +5V Volatage Regulator (chip) IC15 on DSP

IC401,IC404,IC501,IC502,IC701-703, IC705-712,IC715,IC726,IC728 on MX, IC1-4 on JKA, IC14,IC17 on DSP

TRANSISTOR

15119615 2SB647C TRANSISTOR Q727,Q730 on MX 15129623 2SD667C TRANSISTOR Q724,Q728 on MX 15309104 2SA1586-GR TRANSISTOR(chip) Q103,Q110,Q203,Q210,Q303,Q310,Q403,

15319107 2SC4116-GR TRANSISTOR(chip) Q106,Q206,Q306,Q406,Q713 on MX, Q9-16 15319105 2SC3326-A TRANSISTOR(chip) Q703,Q707,Q710,Q711,Q718,Q721,Q726, 15329103T0 2SK880-GR TRANSISTOR FET (chip) Q101-102,Q104-105,Q108-109,Q201-202,

15309101 2SA1037KR TRANSISTOR(chip) Q3 on DSP 15319101 2SC2412KR TRANSISTOR(chip) Q1,Q4 on DSP 15319102 2SC2882-Y TRANSISTOR(chip) Q2 on DSP 15119132 2SA1015-GR TRANSISTOR Q1 on MIDI

Q410,Q502,Q701,Q712,Q731 on MX, Q2-8, Q17 on SWA

on SWA Q729 on MX Q204-205,Q208-209,Q301-302,Q304-305,

Q308-309,Q401-402.Q404-405,Q408-409, Q501,Q503-507,Q702,Q704-706,Q708-709, Q714-717,Q719-720,Q722-723,Q725, Q732-736 on MX

DIODE

15039166 S2VB20-4001L15 2A/200V BRIDGE DIODE D1 on PS2 15039172 S4VB20-4001L15 3.9A/200V BRIDGE DIODE D2 on PS2 15039159T0 S5688G DIODE D3-5 on PS2 15019126 1SS133 DIODE D102,D707-712 on MX 15019145 1SS133 DIODE D1,D7,D13-16,D24-25,D27-28,D30 on SWA 15019181 1SS254 DIODE D6-8 on MIDI 15339412 U1BC44 DIODE (chip) D701 on MX 15339105 DAN202K DIODE Array (chip) DA101-104,DA201-204,DA301-304,DA401-404,

15339108 DA204K DIODE Array (chip) DA1,DA2,DA3,DA4,DA5 on DSP 15339119T0 1SS352 DIODE (chip) (C173 on DSP)

DA501-503,DA701-710 on MX

LED

# 01451045 LN31GPH LED(Green) D101,D201,D301,D401 on MX(BEAT)" # 01451067 LN41YPH LED(Yellow) D702-706 on MX(CUE SELECT) # 01451056 LNJ309GKGAH LED(Green) D604-607, D612-615 on MX(METER) # 01451078 LNJ409YKXAH LED(Yellow) D603,D611 on MX(METER) # 01451090 LNJ809RKDAH LED(Red) D601-602,D609-610 on MX(METER) # 01451089 LNJ801RFDAE LED(Red) D608 on MX (POWER) # 01454712 LN534RAMR 7seg LED(Red) D26 on SWA (7seg) # 01454734 LN38GPX LED (Green) D2-5 on SWA (FREQ RANGE) # 01454745 LNJ808RKDAG LED (Red) D8-12 on SWA (SYNC TYPE)

15029350 LN11WP23 LED (Red+Green) D6 on SWA (BMP SYNC)

# 01457167 LNJ208R8ARA LED (Red) chip D17-19,D21-23 on SWA (EFFECT)

RESISTOR ARRAY

15399965 RCE9A103JAG7A RESISTOR ARRAY(chip) RA3,RA4 on DSP 00346690 RCE9A682JAG7A RESISTOR ARRAY(chip) RA5,RA7 on DSP 15399997 RCB8C101J5 RESISTOR ARRAY(chip) RA10,RA11,RA15,RA16 on DSP 15399957 RCB8C103J5 RESISTOR ARRAY(chip) RA1,RA2,RA6,RA8,RA9 on DSP

POTENTIOMETER

# 01451101 EVJY95FB6A15 12M/M ROTARY POTENTIOMETER VR101,VR201,VR301,VR401 on MX(GAIN) # 01451112 EVJY96FB6B24 12M/M ROTARY POTENTIOMETER VR103-105,VR203-205,VR303-305,VR403-

# 01451123 EVJY95FB6B54 12M/M ROTARY POTENTIOMETER VR702 on MX(RETURN) # 01451156 EVJY15FB6A24 12M/M ROTARY POTENTIOMETER VR704 on MX(MONITOR LEVEL) # 01451167 EVUF2KFK3C15 9M/M ROTARY POTENTIOMETER VR501 on MX(MIC2) # 01451178 EVUF3KFK3B24 9M/M ROTARY POTENTIOMETER VR503-504 on MX(MIC1 EQ) # 01454778 RK11K114 (TKO10 A-1) 11M/M ROTARY POTENTIOMETER VR1-3 on SWB(RATE, PITCH, FORMANT) # 01454789 RK11K114 (TKO10 A-2) 11M/M ROTARY POTENTIOMETER VR4 on SWB(EFFECT BAL) # 01451134 RK14K12D (TKO05 A-3) 14M/M ROTARY POTENTIOMETER VR705-707 on MX(ISOLATOR) # 01451189 EWAQ36D20A14 60M/M SLIDE POTENTIOMETER VR102,VR202,VR302,VR402 on MX(CH FADER) # 01451190 EWAQ1GD20C15 60M/M SLIDE POTENTIOMETER VR502 on MX(MIC1 FADER) # 01451201 EWAP36D20A14 45M/M SLIDE POTENTIOMETER VR701 on MX(MASTER FADER) # 01454201 EWAP37D15G54 45M/M SLIDE POTENTIOMETER VR1001 on CF(CROSS FADER)

405,VR703 on (MXEQ, MONITOR BALANCE)

CAPACITOR

01453278 DE1307E 472M-KH Ceramic Capacitor C15 on PS1 13529264 ECKDAE472ZV Ceramic Capacitor C1,C10 on PS2

INDUCTOR, COIL, FILTER

12449355 FBR07HA850TB00 Ferrite Beads L1-2 on MIDI 12449323 ESD-R-25SD Ferrite CorePhones Wiring

CRYSTAL, RESONATOR

00901912 MA-406 24.576MHZ CRISTAL X1 on DSP 00894034 MA-406 16.000MHZ CRISTAL X2 on DSP

FUSE, FUSE HOLDER

12559435 SB 500 500MA/250V FUSE 5x20 500mA/250V for 100V/117V 12559540 S504 160MA T160MAL250V FUSE 5x20 T160mA/250V for 230V/240V 12189823 CNT47-0003A FUSE HOLDER on PS1

CONNECTOR

13369925 53253-0310 CONNECTOR CN3 on PS2, CN6 on JKA, CN1002 on PH 13369926 53253-0410 CONNECTOR CN5 on PS2 13369929 53253-0710 CONNECTOR CN704 on MX, CN2 on PS2 13369932 53253-1010 CONNECTOR CN4 on PS2 13369934 53253-1210 CONNECTOR CN701 on MX, CN3 on JKB 13369939 53254-0310 CONNECTOR CN9 on DSP 13369940 53254-0410 CONNECTOR CN1 on DSP, CN11 on SWA 13369942 53254-0610 CONNECTOR CN8 on DSP 13369943 53254-0710 CONNECTOR CN10 on SWB

# 13369946 53254-1010 CONNECTOR CN4 on DSP

13429301 51048-1200 CONNECTOR CN1 on PS2, CN6 on TR 13369669 S9B-PH-K-S CONNECTOR CN1001 on CF

# 01456567 IL-FPC-10SL-N CONNECTOR CN7 on DSP, CN7 on SWB

13379157 IL-FPC-16SL-N CONNECTOR CN2 on DSP, CN13 on SWA # 01120345 IL-FPC-28SL-N CONNECTOR CN7 on JKA # 01120356 IL-FPC-28ST-N CONNECTOR CN712 on MX

WIRING, CABLE

# 01454990 12X180-P2.0-51065-51065-F WIRING (MX to JKB) # 01455012 10X200-P2.0-51065-51065-F WIRING (PS2 to DSP) # 01455067 7X180-P2.0-51065-51065-F WIRING (PS2 to MX) # 01455078 3X180-P2.0-51065-51065-F WIRING (PS2 to JKA) # 01560990 4X200-P2.0-51065-51065-F WIRING (PS2 to SWA) # 01565767 3*270-P2.0-51065-51015-R WIRING on MX (to PH) # 01455034 9X150-P2.0-PH-51015-F WIRING on MX (to CF) # 01560945 10X50-A5.0 BBR-P1.25-HBL8 FUJI CARD (DSP to SWB) # 01560967 16X50-A5.0 BBR-1.25-HBL8 FUJI CARD (DSP to SWA) # 01560978 28X200-A6.0 BBR-P1.25-HBL10 FUJI CARD (MX to JKA) # 01455089 W7 WIRING on MX (to DSP and SWB) # 01455101 W8 WIRING on PS1 (to Power SW), Black # 01455134 W9 WIRING on PS1 (to Power SW), Brown # 01561012 W11 WIRING on PS1 (to Power Trans), Brown # 01561023 W12 WIRING on PS1 (to Power Trans), White # 01672734 W13 WIRING on MIDI (to DSP)

00890734 12X100-P2.0 RIBON CABLE on PS2 and TR

TRANSFORMER

# 01455645 01455645U0 UNIVERSAL POWER TRANSFORMER

AC INLET

23425740 INL-8 10A/125V 2P PO AC INLET JK1 on PS1

SCREW

40011090 Binding Taptite B 3x6 BZC

40011101 Binding Taptite B 3x8 BZC

40012289 Binding Taptite B 3x16 ZC

40011056 Binding Taptite B 3x6 ZC

40011312 Binding Taptite P 3x8 BZC for XLR, Pin Jack, MIDI Jack, AC INLET # 40239889 Button-Trus Taptite S M3x6 BZC # 40239890 Button-Trus Taptite S M4x8 BZC

40015967 Flat Taptite S 3x6 BZC for Crossfader Unit

40011490 Sems Screw M3x6 BZC

40013056 Pan Machine Screw W/SW+Small PW M3*6 ZC

40017934 W Sems Screw M3x6 ZC

40012867 W Sems Screw M3x8 ZC

22150756 JACK NUT 2 for Headphones Jack # 22150524 BOSS NUT M3/M3 L8 # 22153526 BOSS NUT M3/M3 L12 EFFECT ASSY # 01458590 BOSS NUT M3/M3 L8.5 EFFECT ASSY

40011789 Hex Nut M3 ZC for Phono Earth

40016712 Jack Washer 12x18x0.6 BZC

40016756 Jack Nut HLJ0999-01-0360 M12

40011878 External Tooth Washer M3 ZC for Phono Earth

40011934 Internal Tooth Washer M3 BZC for XLR Gnd

PACKING

# 01455456 PACKING CASE for Packing # 01561534 UPPER PAD # 01561545 SUB PAD # 01561556 BOTTOM PAD # 01561567 SIDE PAD # 40123401 VINYL BAG 0.05*600*460

MISCELLANEOUS

# 01455267 HEATSINK PS ASSY

12159799 EHS-11U EDGE HOLDER PS ASSY # 01348889 MT-903C GROUNDING TERMINAL Phono Earth

12199584 M1698 GROUNDING TERMINAL TER1-2 on MIDI

01569934 VR SPACER EFFECT ASSY # 01455401 DUST COVER SW SW MASK # 01455412 POT DUST COVER S MASTER/CROSS FADER MASK # 01455423 POT DUST COVER L CH FADER MASK

40016523 Inshlock Tie 100mm T-18R # 40014389 FUSE SEAL UL 500MA 250V on PS1 for 100V/117V # 40013589 FUSE SEAL T160MAL250V #397 on PS1 for 230V/240V

ACCESSORIES(Standard)

# 71018234 OWNER'S MANUAL SET Japanese # 71018723 OWNER'S MANUAL SET English

13499219 DC-382-J01 VFF2P AC CORD SET 100V

13499220 UC-713-J01 SJT2P18AWG60 AC CORD SET 120V

13499221 EC-511-E07 H03VVH2-F 2P AC CORD SET 230V

13499222 SC-078-J02 ES206-75HMA AC CORD SET 240VA

00905234 ECP01-5A EURO CONVERTER PLUG for 230V E

May, 1998

[EFFECT BAL] : MAX [FORMANT / RESO] : MIN [PITCH / DEPTH] : MAX [RATE / CUTOFF] : MIN

DJ-2000

IDENTIFYING THE VERSION NUMBER

1.Set the each potentiometers as follows.

TEST MODE

This test mode is for DSP EFFECT Board.

●Entering test mode

Set the each potentiometers as follows.

Turn the power on, while holding down the [TAP] button.

*In the case of version number is 1.01.

The software program version will be displayed on the display and it will blink few times. Next, DJ-2000 get back to normal mode automatically.

Turn the power on, while holding down the[TAP] button and [FREQ RANGE] button.

DJ-2000 will enter the test mode and the software program version will be displayed on the display and it will blink few times.

At the same time, DRAM check runs automatically. If the function are normal, LED TEST stars automatically. (It takes about 3 sec.)

1. DRAM TEST

When entering the test mode, DRAM TEST runs automatically. And if the function are normal,the software program version will displayed on the 7seg LED for the few seconds, and next test starts automatically. If the problem is found in DRAM, the following display will appear and the test mode stop.

+ 15 hidden pages

Roland DJ-2000 Service Manual

Specifications and Main Features

Frequently Asked Questions

User Manual