RHEEM-RUUD COMMERCIAL TANKLESS
COMMERCIAL TANKLESS SERIES
Endless hot water for high-volume use
GT-199PV indoor, GT-199X outdoor and GT-199DV
indoor direct vent natural and LP models –
19,900 - 199,900 BTU max.
8.5 gal./min at 35° F rise max., 7.4 gal./min. at 45° F rise
Limited Warranty:
5-Year on heat exchanger and parts, 1-Year on labor
See Commercial Warranty Information Brochure for complete warranty information.
GT-199 units are specifically designed for commercial applications
•
UMC-117 remote control is included – up to a 180 degree maximum
•
EZ-Link™cable available for high demand applications to connect
•
two tankless units to operate as one
Exclusive! All Rheem models can be linked in up to 20 unit manifold installations
•
by using the optional MIC-180 and MICS-180 manifold control assembly
Exclusive! Guardian SBT™sensing burner technology
•
Exclusive! Guardian OFW™overheat film wrap
•
Exclusive! Two high-altitude options – up to 6,560 or 9,840 ft. elevations
•
above sea level
All Rheem tankless models are third-party efficiency certified by GAMA
•
Continuous hot water, energy saving and compact, space saving design
•
Intelligent electronic controls designed to increase energy efficiency
•
and safety
Self diagnostic program
•
Digital display shows temperature setting and maintenance codes
•
Built-in electric blower
•
Indoor units use Category III stainless steel vents and vent horizontally
•
or vertically
Indoor models supplied with a 120 volt power cord
•
Environmentally friendly Low NOx burner meets SCAQMD
•
rule 1146 requirements
Installation vent kits available – sold separately
•
Indoor and outdoor models feature freeze protection to -30°F
•
(altitude chip required – sold separately)
GT-199 COMMERCIAL
INDOOR DIRECT VENT
GT-199 COMMERCIAL
OUTDOOR
See reverse for specifications.
GT-199 COMMERCIAL
INDOOR
Tankless water heaters
Endless hot water
COMMERCIAL TANKLESS SERIES
Specifications
DESCRIPTION FEATURES ROUGHING IN DIMENSIONS (SHOWN IN INCHES) ENERGY INFO.
G
MODEL INPUT TEMP.
N
UMBER BTU/HR. TYPE RANGE
R
HEEM-RUUD COMMERCIAL TANKLESS WATER HEATERS
GT-199PVN-1
GT-199XN-1
GT-199DVN-1
All models are available in Natural Gas and Propane (LP).
For Propane replace the N with P when ordering.
Factory set maximum temperature is 120° F, capable of temperatures up to 180° F.
•
ee Use and Care Manual for setting.
S
• For installations above 3,280 feet, a high altitude chip is required. Refer to Rheem price list or consult
actory for details.
f
• Consult factory for information on sizing the application.
Installation Vent Kits available separately: 4" diameter for GT-199PV models.
ent Termination Kits are required for Direct Vent models. Contact your distributor for details.
V
AS WATER FLOW RATE VENT SHIP. D.O.E. ANN.
19,000 199,900 180° F
19,000 199,900 180° F
19,000 199,900
Indoor
Outdoor
Indoor
DirectVent
GPM @ 77° GPM @ 45° GPM @ 35°
RISE MAX. RISE MAX. RISE MAX. WATER GAS
100° to
100° to
100° to
180° F
4.3 7.4 8.5 3/4 3/4 25-3/8 14-7/8 11-1/8 4 55 .82 $223/$374
4.3 7.4 8.5 3/4 3/4 25-3/8 14-7/8 11-1/8 N/A 55 .82 $223/$374
4.3 7.4 8.5 3/4 3/4 25-3/8 14-7/8 11-1/8
CONNECTION
AB
H
EIGHT WIDTH DEPTH (INCHES) (LBS.) FACTOR NAT/LP
nergy Factor and Average Annual Operating Costs based on D.O.E.
E
Department of Energy) test procedures. D.O.E. national average fuel rate
(
atural gas $1.218/therm; LP $1.87/gallon
n
DIAMETER WEIGHT ENERGY OP. COST
4 by 4
2-PIPE
55 .82 $223/$374
.
B
Remote
Control
GT-199PV
Indoor
A
B
Remote
Control
GT-199X
Outdoor
A
A
B
Remote
Control
GT-199DV
Indoor
Direct Vent
COMMERCIAL TANKLESS SERIES
W
ater Heater Flow Rate Curves
0
1
2
3
4
5
6
7
8
9
10 15 20 25 30 35 40 45 50 55 60 70 80 90 100 120 140
AXIMUM HOT WATER FLOW RATE AND TEMPERATURE RISE
M
Temp. Rise (°F) 35 45 50 60 70 77 90 100 110 120 130 140
Water Flow (GPM) 8.5 7.4 6.6 5.5 4.7 4.3 3.7 3.3 3.0 2.8 2.6 2.4
Minimum flow rate required to initiate heating cycle .66 gpm.
bove estimates are for sizing purposes only.
A
LEARANCE TO
C
inches)
COMBUSTIBLES
ODEL
M
UMBER SIDE REAR
N
GT-199PV 1/2 0 12
GT-199X 1/2 0 12
GT-199DV 1/2 0 12
(
FRONT
BOTTOM
TOP &
RHEEM-RUUD GT-199 MANIFOLD INSTALLATIONS
TEMP.
FLOW RATE (GPM)
RISE (°F) 1 UNIT 2 UNITS 5 UNITS 10 UNITS 15 UNITS 20 UNITS
140 2.4 4.7 11.9 23.7 35.6 47.4
130 2.6 5.1 12.8 25.5 38.3 51.1
120 2.8 5.5 13.8 27.7 41.5 55.3
110 3.0 6.0 15.1 30.2 45.3 60.3
100 3.3 6.6 16.6 33.2 49.8 66.4
90 3.7 7.4 18.4 36.9 55.3 73.7
80 4.1 8.3 20.7 41.5 62.2 83.0
77 4.3 8.6 21.5 43.1 64.6 86.2
70 4.7 9.5 23.7 47.4 71.1 94.8
60 5.5 11.1 27.7 55.3 83.0 110.6
50 6.6 13.3 33.2 66.4 99.6 132.7
45 7.4 14.7 36.9 73.7 110.6 147.5
35 8.5 17.0 42.5 85.0 127.5 170.0
COMMERCIAL TANKLESS SERIES
ACCESSORIES FOR MULTI-UNIT MANIFOLD INSTALLATIONS
# OF WATER HEATERS
PART NO. DESCRIPTION ACCESSORIES
RTG20040 EZ-Link™Cable 1 N/A N/A
RTG20126A MIC-180 Main Communication
PCB w/ Manifold Control Box
RTG20126B MICS-180 Extended Communications PCB N/A N/A 1
RTG20126C MIC-K-16 Communications Cable (16 ft.) N/A 3 to 6 7 to 20
RTG20126D MIC-K-32 Communications Cable (32 ft.) N/A 3 to 6 7 to 20
RTG20126E MIC-K-65 Communications Cable (65 ft.) N/A 3 to 6 7 to 20
2 3 TO 6 7 TO 20
N/A 11
Extensive Manifold Capacity
Up to 20 of the Commercial Tankless units can be linked in a manifold configuration
to meet the hot water needs of larger applications.
These units are designed to meet or exceed ANSI (American National
Standards Institute) requirements and have been tested according to
D.O.E. test procedures and meet or exceed the energy efficiency
requirements of NAECA, ASHRAE standard 90, ICC Code and all state
energy efficiency performance criteria for energy consuming
appliances.
Before purchasing this appliance, read important energy cost and
efficiency information available from your supplier.
In keeping with its policy of continuous progress and product improvement,
Rheem reserves the right to make changes without notice.
Rheem Heating, Cooling & Water Heating
101 Bell Road • Montgomery, AL 36117-4305
1-866-720-2076 • www.rheemtankless.com
Rheem Canada Ltd./Ltée • Water Heater Division
128 Barton Street West, Hamilton, Ontario L8N 3P3
Rheem manufactures residential & commercial heating,
cooling & water heating products.
Printed in U.S.A. 07/08 WP Form No. RR101-50
RHEEM-RUUD
CARRIES A COMPLETE LINE
OF COMMERCIAL WATER HEATERS
TO SUIT ANY APPLICATION.