Reznor P125 User Manual
Form P-Y (01-15)
Obsoletes Form P-Y (12-5-14)
1. Always include complete heater model and serial number
IMPORTANT
so that any specication change can be considered for
parts replacement. It can save time and expense.
2. Specications are subject to change without notice.
3. We reserve the right to substitute functional replacements.
4. Order by P/N; not Heater Option Designation.
A
Air Temp Sensor w/ 8”Probe 20
B
BacNet DDC Communication
Bus 11 See also Electrical
Components - Low
Voltage Panel
Blocked Condensate Switch
(High Efciency Furnace)
11
Building Static Pressure (in Op-
tion VFC4 & GF5) 11
Bypass Valve 42
C
External Cabinet Parts 48,
49, 50
Cabinet Sizes 1, 2 & 3
• Model YDHA:
• Cabinet Size 1 - DX
Cooling Sizes 60, 90, 120
& 150.
• Cabinet Size 2 - DX
Cooling Sizes 180, 210
& 240.
• Cabinet Size 3 - DX
Cooling Sizes 300 & 360.
• Model YDMA:
• Cabinet Size 1 - DX
Cooling Sizes 60, 90, 120
& 150.
• Cabinet Size 2 - DX
Cooling Sizes 180, 210
& 240.
• Cabinet Size 3 - DX
Cooling Sizes 300 & 360.
• Model YDSA:
• Cabinet Size 2 - Sizes 120
& 150.
• Cabinet Size 3 - Sizes 180
& 210
Capacitor 11, 16
Carel Digital Controller 16
Carel Digital Controller with
Programmed Software 11
Carel Plugs 11, 16
CO2 Sensor 11, 20
Condenser Coil 36, 41
Evaporator Coil 36, 41
Coil & Filter Access Panel 50
Coil Kit (24v Coil) 34
Combination Gas Valve 22
Compressor 34, 40, 41, 45
Compressor Mounting Kit
33, 42
Condenser Fan Installation &
Fan Support 34
Condenser Fan System 36, 37
Condenser Top 36
Contactor 11, 17, 45
Control Left Door 49, 50
SCR Controller 17
Control Right Door 49, 50
Convenience Outlet 11, 20
Cooling and Dehumidifying
Components 37, 38, 40,
41, 42
Crankcase Heater 35, 41
Cross-Reference by Model/Size
and Cabinet Size 4
D
Damper Ball & Socket Joint 44
Damper Linkage 44
Damper Motor Access Cover
50
Dampers and Controls 43, 44,
47, 48
Date of Manufacture 3
Digital Controller 11, 33, 34,
40, 41
Digital Controller for Compres-
sors 12
Dirty Filter Switch 11
Discharge Air Sensor 11
Disconnect Switch (Option
CP) 20
Hand Held Display for Digital
Controller (Option RB4)
Applies to: Replacement Parts for
Models YDHA, YDMA, and YDSA
Cabinet Sizes 1, 2 & 3.
INDEX
11
Remote Display for Digital
Controller (Option RB3)
11
Distribution Block 11
Distribution Block, 17
Drain Access Outer Panel 50
Drain Pan 51
DSI Control Module 11, 20
Ductstat 11
Duct Static Pressure (in Option
VFC3) 11
E
Electrical Compartment 4, 5,
6, 7, 8, 9, 10, 20, 21, 22,
24, 26
Electrical Components - Electric
Heat Section Panel 11
Electrical Components - High
Voltage Panel 11
Electrical Components - Unit
Low Voltage P 11
Electric Preheat Energy Recov-
ery Wheel, Options PH2A,
PH3A or PH4A 45
Energy Recovery Cassette 44
Energy Recovery Filter Switch
11
Energy Recovery Wheel Access
Panel 50
Energy Recovery Wheel Filters,
Options EW30, EW36,
EW46 or EW58 42
Energy Recovery Wheel
Package Components 44,
45, 46
Exhaust Fan Pressure Switch
11
Expansion Valves 35, 41
F
Fan Access Panel 50
Fan Blade 36
Fan Guard 36
Fan Motor, 3/4 HP 36
Fan/Motor Support 36
Dirty Filter Switch 44
Filter Drier 35, 41
Filter Pressure Switch, 17
Filter Support Asm Comp 43
Firestat 11, 20
Flame Sensor 22, 23, 24,
25, 26
Flexible Gas Connection 23,
25, 26
Frostat 44
Fuse 45
Fuseblock 45
Fuses 11
Fuses for wheel preheat (opt
PH-__) 11
G
Gas Door Left 49
Gas Door Right 50
Gas Orice Replacement 28
Gas Pressure Switch 24,
25, 26
Gas Valve 23, 25, 26, 27
Grounding Bar 12
Grounding Lug 11, 16
H
Hail Guard 50
Heater Rack 45
Heat Exchanger Assy 22, 23,
24, 25, 26
High Gas Pressure Switch 22,
23, 24, 25, 26
High Pressure Switch 34, 41
Hinge 51
I
Ignitor 22, 23, 24, 25, 26
Insufation Connector 37
IQ Digital Controller 11
Isolation Hardware on Fan
Support 34
L
Limit Control 22, 23, 24, 25, 26
Line Reactor 11, 16
Long Damper Rod 44
Low Ambient Controller for
ECM Condenser Fan 16
Low Ambient Controller for
ECM Condenser Fan (Opt
CUF4) 11
Low Ambient Controller for
Standard Condenser Fan
(Opt CUF3) 11
Low Ambient Controller for
Std Condenser Fan Sen-
sor 16
Low Gas Pressure Switch 22,
23, 24, 25, 26
Low Pressure Switch 34, 41
Low Speed Venter (Combustion
Air Switch - Low Pressure)
11
M
Modulating Valve 24, 25, 26
Molded Plug 35, 41
Damper Motor 44
Motor Bracket 44
Mounting Kit 34, 41
O
Option AG72 & 74 Gas Heat
Components 23, 25, 26
OPTIONAL GAS HEAT
SECTION, Option H_ 34
Optional Gas Heat Section
Rating Plate 3
Outside Air Hood, Option
AS16 43
Overload Relay 11
P
Phase Loss/Voltage Monitor 12
Phase Loss/Voltage Monitor
(Opt PL4) 11
Photoelectric Smoke Detector
20
Plenum Fan 36, 37
Plug-in Card 11
Power Feed Terminals 12
Pressure Sensor Transducer
11
R
Rating Plate 2
References 52
Relay 11
Relay Board 11, 20
Return Air Temperature Sensor
& Box, 8” probe 11
Rubber Isolation 37
S
SCR Controller 11
Sensor Port 17
Sensors for Monitoring and
Reporting to the Digital
Controller 11
Serial No. 2
Serial No. Date of Manufacture
Table 3
Shaft 44
Slam Latch 51
Smoke Detector 11
Socket for Code 1A Monitors
11
Solenoid Kit 33, 42
Solenoid Kit (24v Coil) 34, 41
Space Temperature Sensor
(Opts CL23, CL33 &
CL78) 11
Space Temp Sensor 20, 27, 33
Static Pressure Transducer 17
Supply Air Filters, Options
AW21 or AW24 42
Supply Fan 11
Air Proving Switch 11, 16, 17
Combustion Air Proving Switch
11, 17
Dirty Filter Pressure Switch 11
Disconnect Switch 11, 20
T
Temp Sensor (Wheel Supply
Air) 44
Terminal Blocks 11
Terminal Strip 11, 17
Thermister 33, 34, 40, 41
Top Cover Center 49
Top Cover End 49
Top Cover Rear 49
Transducer 11
Transformers 11, 12
V
Vent Box Subassembly 51
Venter Housing 11
VFD 11
W
Wheel Belt 44
Wheel Segment 44
Wiring Harness 44
IMPORTANT: Do not release refrigerant to the atmosphere! If required service
procedures include the adding or removing of refrigerant, the service technician
must comply with all federal, state, and local laws. Service procedures should only
be performed by a qualied HVAC technician.
Form P-Y (01-15), PN 273651R6, Page 1
DANGER
This unit contains R-410A high pressure refrigerant. Hazards exist that could result
in personal injury or death. Installation, maintenance, and service should only be
performed by an HVAC technician qualied in R-410A refrigerant and using proper
tools and equipment. Due to much higher pressure of R-410A refrigerant, DO NOT
USE service equipment or tools designed for R22 refrigerant.
Rating Plates and Serial No.
Sample of System Rating Plate (applies to all Y series models)
RAD
MERCER, PA., U.S.A. 16137
FOR INDUSTRIAL/COMMERCIAL USE ONLY
SUITABLE FOR OUTDOOR USE
MODEL [ A ] [ B ]
SERIAL NO. [ ]
[D] VOLTS +/- 10% [D] PHASE [D] HZ
MINIMUM CIRCUIT AMPACITY (MCA) [ F ] AMPS
MAXIMUM FUSE SIZE/*CKT BREAKER [ G ] AMPS
SHORT-CIRCUIT CURRENT: 5,000 A RMS SYMMETRICAL [D] V MAX.
MAXIMUM OUTLET TEMPERATURE [ X ]
SUPPLY AIR BLOWER MOTOR 1 [ E ] [ C ]
CONDENSER FAN MOTOR (S) [ T ] [ U ] [ Z ]
COMPRESSOR A [ H ] [ I ] [ J ]
COMPRESSOR B [ K ] [ L ] [ M ]
COMPRESSOR C [ N ] [ O ] [ P ]
COMPRESSOR D [ Q ] [ R ] [ S ]
COMPRESSOR LOW ENTHALPY [ GG ] [ HH ] [ JJ ]
COMPRESSOR HIGH ENTHALPY [ KK ] [ LL ] [ MM ]
REFRIGERANT - R-410a CHARGE - LBS
TEST PRESSURES HIGH 600 PSIG LOW 45 PSIG
EQUIPPED FOR OPERATION AT AN AIR FLOW OF [ CC ] SCFM
AGAINST A STATIC PRESSURE OF [ DD ] INCHES WATER COLUMN
WIRE DIAGRAM [ FF ]
*HACR TYPE REQUIRED PER NEC
CLEARANCES TO COMBUSTIBLE CONSTRUCTION AND FOR SERVICE:
TOP - 60”, CONDENSER SIDE - 48”
CONTROL SIDE WITH GAS HEAT - 84”
CONTROL SIDE WITH ELECT OR NO HEAT - 36”
BOTTOM - 0”, INLET AIR SIDE - 24”, COIL/FILTER ACCESS SIDE - 72”
MADE IN USA
QTY FLA (EA)
QTY RLA (EA) LRA (EA)
CIRCUITS A B C D LE HE
[ V ] [ W ] [ X ] [ Y ] [NN] [PP]
HP (EA)
System Rating Plate Key:
A = Model
B = Manufacturing Date
(Month/Year)
C = Blower Motor HP
D = Volts/Phase/Hertz
E = Full Load Amps (FLA) of
Blower Motor
F = Minimum Circuit
Ampacity (MCA)
G = Maximum Fuse Size
(MOP)
H = Quantity - Compressor A
I = Rated Load Amps of
Compressor A
J = Locked Rotor Amps of
Compressor A
K = Quantity - Compressor B
L = Rated Load Amps of
Compressor B
M = Locked Rotor Amps of
Compressor B
N = Quantity - Compressor C
O = Rated Load Amps of
Compressor C
P = Locked Rotor Amps of
Compressor C
Q = Quantity - Compressor D
R = Rated Load Amps of
Compressor D
S = Locked Rotor Amps of
Compressor D
V = Refrigerant Charge (lbs) -
Circuit A
W = Refrigerant Charge (lbs)
- Circuit B
X = Refrigerant Charge (lbs) -
Circuit C
Y = Refrigerant Charge (lbs) -
Circuit D
Z = Condenser Fan Motor HP
CC = SCFM Airow
DD = External Static
Pressure (“ w.c.)
FF = Wiring Diagram No.
GG = Quantity - Compressor
Low Enthalpy
HH = Rated Load Amps
of Compressor Low
Enthalpy
JJ = Locked Rotor Amps
Compressor Low
Enthalpy
KK= Quantity - Compressor
High Enthalpy
LL= Rated Load Amps
of Compressor High
Enthalpy
MM= Locked Rotor Amps
Compressor High
Enthalpy
NN= Refrigerant Charge (lbs)
- RPLE Circuit
PP= Refrigerant Charge (lbs)
- RPHE Circuit
Serial No. Decoding
Decoding a System Serial No.
Serial No. Sample: 3 BIJ 789 BK 08 N 96 7D
Elements of No.: 1| 2 | 3 | 4 | 5 |6| 7 | 8
Elements 1-5 apply to all models.
Elements 6-8 apply to models with gas heat section (YDHA, YDMA & YDSA).
Key:
1 = Phase (1 or 3)
2 = Date CODE (See table top of page 3.)
3 = Consecutive number
4 = Not Applicable
5 = Motor HP (See explanation on the right.)
6 = Type of Gas - Models YDHA, YDMA & YDSA (N = Natural; L = Propane)
7 = Ignition CODE - Models YDHA, YDMA & YDSA (See Form P-Valve)
8 = Valve CODE - Models YDHA, YDMA & YDSA (See Form P-Valve)
Form P-Y (01-15), PN 273651R6, Page 2
Supply Air Blower Motor
Motor HP
Serial No.
Code
3 (3450 rpm) 08
5 (3450 rpm) 09
10 13
20 14
Serial No. Date of Manufacture Table
Year Jan Feb Mar Apr May June July Aug Sept Oct Nov Dec
2013 BMA BMB BMC BMD BME BMF BMG BMH BMI BMJ BMK BML
2014 BNA BNB BNC BND BNE BNF BNG BNH BNI BNJ BNK BNL
2015 BOA BOB BOC BOD BOE BOF BOG BOH BOI BOJ BOK BOL
2016 BPA BPB BPC BPD BPE BPF BPG BPH BPI BPJ BPK BPL
2017 BQA BQB BQC BQD BQE BQF BQG BQH BQI BQJ BQK BQL
2018 BRA BRB BRC BRD BRE BRF BRG BRH BRI BRJ BRK BRL
2019 BSA BSB BSC BSD BSE BSF BSG BSH BSI BSJ BSK BSL
2020 BTA BTB BTC BTD BTE BTF BTG BTH BTI BTJ BTK BTL
2021 BUA BUB BUC BUD BUE BUF BUG BUH BUI BUJ BUK BUL
2022 BVA BVB BVC BVD BVE BVF BVG BVH BVI BVJ BVK BVL
2023 BWA BWB BWC BWD BWE BWF BWG BWH BWI BWJ BWK BWL
2024 BXA BXB BXC BXD BXE BXF BXG BXH BXI BXJ BXK BXL
2025 BYA BYB BYC BYD BYE BYF BYG BYH BYI BYJ BYK BYL
Sample of a Optional Gas Heat Section Rating Plate
RAD
MERCER, PA USA 16137
MADE IN U.S.A.
DUCT FURNACE/GÉNÉRATEUR D’AIR CHAUD À GAINE
CATEGORY III/CATÉGORIE III
FOR INDUSTRIAL/COMMERCIAL USE ONLY
POUR USAGE INDUSTRIEL/COMMERCIAL
ANSI Z83.8 [AA] - [ A ]
CSA 2.6 [AA1] - [A1] DUCT FURNACE/GÉNÉRATEUR D’AIR CHAUD À GAINE
MODEL/MODÈLE [ C ] [ P ]
SERIAL NO. / #DE SÉRIE: [ ]
230 VOLTS 1 PH 60 HZ MAXIMUM TOTAL INPUT [ D ] AMPS
CONSOMMATION TOTALE MAX DE [ D ] AMPS
TYPE OF GAS/TYPE DE GAZ: [ E ]
ALTITUDE [ Q ] FEET/PIEDS, [ R ] MÈTRES
BURNER ORIFICE SIZE [ F ] DRILL HAS BEEN FACTORY ADJUSTED
BRULEUR DIMENSION DE L’ORIFICE [ F ] FORET
NORMAL INPUT/ENTRÉE NORMALE (TOTAL)
THERMAL OUTPUT / RENDEMENT THERMIQUE (TOTAL)
MINIMUM INPUT/ENTRÉE MIN.
NORMAL MANIFOLD PRESSURE
PRESSION NORMALE DE LA TUB
MIN. PERMISSIBLE GAS SUPPLY PRESSURE
FOR PURPOSE OF INPUT ADJUSTMENT.
PRES. D’ALIM. MIN. ACCEPTABLE DE GAZ POUR
DES FIN DE RÉGLAGE DE L’ENTRÉE
MAXIMUM THROUGHPUT / MINIMUM THROUGHPUT [ M ] / [ N ] C.F.M.
CONSOMMATION MAXIMUM / MINIMUM [ M ] / [ N ] PI3/MN
[ K ] IN.W.C.
[ K ] PO/COL D’EAU
[ L ] IN.W.C.
[ L ] PO/COL D’EAU
[ H ] BTU/HR
[ I ] BTU/HR
[ J ] BTU/HR
Gas Heat Section Rating Plate Key:
AA, A = ANSI Standard and Date
AA1, A1 = CSA Standard and Date
C = Model No.
D = Voltage
E = Type of Gas (natural)
F = Orice Size
H = Normal BTU/Hour Input (sea level)
I = Thermal Output BTU/Hour (sea level)
J = Minimum BTU/Hour Input (sea level)
K = Manifold Pressure
L = Minimum Gas Supply Pressure
M = Maximum Throughput
N = Minimum Throughput
P = Manufacturing Date (Month/Year)
Q = Altitude in Feet
R = Altitude in Meters
Form P-Y (01-15), PN 273651R6, Page 3
Cross-Reference Cabinet Size (1, 2 or 3) by Option Code
and Model/Model Size
Model YDHA YDMA YDSA
Nominal Cooling
Capacity (Tons)
Standard
Efciency
Gas Heat
Section
High
Efciency
Gas Heat
Section
Electric
Heat
Section
* Gas heat sections with dual furnaces.
Size 60 90 120 150 180 210 240 300 360 60 90 120 150 180 210 240 300 360 120 150 180 210
5 7.5 10 12.5 15 17.5 20 25 30 5 7.5 10 12.5 15 17.5 20 25 30 10 12.5 15 17.5
Opt
Code
H50 1 1 1 -- -- -- -- -- -- 1 -- -- -- -- -- -- -- -- -- -- -- -- H50
H75 1 1 1 1 2 -- -- -- -- 1 1 1 -- -- -- -- -- -- -- -- -- -- H75
H100 1 1 1 1 2 2 2 -- -- 1 1 1 1 -- -- -- -- -- 2 -- -- -- H100
H102* 1 1 1 1 2 2 2 -- -- 1 1 1 1 -- -- -- -- -- 2 -- -- -- H102*
H125* 1 1 1 1 2 2 2 -- -- 1 1 1 1 2 -- -- -- -- 2 2 -- -- H125*
H150* 1 1 1 1 2 2 2 -- -- 1 1 1 1 2 2 -- -- -- 2 2 3 -- H150*
H175* 1 1 1 1 2 2 2 -- -- 1 1 1 1 2 2 2 -- -- 2 2 3 3 H175*
H200 -- 1 1 1 2 2 2 3 3 1 1 1 1 2 2 2 3 3 2 2 3 3 H200
H202* -- 1 1 1 2 2 2 3 3 1 1 1 1 2 2 2 3 3 2 2 3 3 H202*
H300 -- 1 1 1 2 2 2 3 3 -- 1 1 1 2 2 2 3 3 2 2 3 3 H300
H400 -- -- 1 1 2 2 2 3 3 -- -- 1 1 2 2 2 3 3 2 2 3 3 H400
H402* -- -- 1 1 2 2 2 3 3 -- -- 1 1 2 2 2 3 3 2 2 3 3 H402*
H502* -- -- -- -- 2 2 2 3 3 -- -- -- -- 2 2 2 3 3 -- -- 3 3 H502*
H602* -- -- -- -- 2 2 2 3 3 -- -- -- -- 2 2 2 3 3 -- -- --- 3 H602*
H702* -- -- -- -H802* -- -- -- -- -- -- -- 3 3 -- -- -- -- -- -- -- 3 3 -- -- -- -- H802*
G150 1 1 1 1 2 2 2 -- -- 1 1 1 1 2 2 2 -- -- 2 2 3 3 G150
G225 1 1 1 1 2 2 2 3 3 1 1 1 1 2 2 2 3 3 2 2 3 3 G225
G300 -- 1 1 1 2 2 2 3 3 -- -- 1 1 2 2 2 3 3 2 2 3 3 G300
G302* -- 1 1 1 2 2 2 3 3 -- -- 1 1 2 2 2 3 3 2 2 3 3 G302*
G372* -- -- -- -- 2 2 2 3 3 -- -- -- -- 2 2 2 3 3 -- 2 3 3 G372*
G452* -- -- -- -- 2 2 2 3 3 -- -- -- -- 2 2 2 3 3 -- -- 3 3 G452*
G525* -- -- -- -- -- -- -- 3 3 -- -- -- -- -- -- -- 3 3 -- -- -- -- G525*
G602* -- -- -- -- -- -- -- 3 3 -- -- -- -- -- -- -- 3 3 -- -- -- -- G602*
E20 1 1 1 1 2 2 2 -- -- 1 1 1 1 2 2 2 -- -- 2 2 3 3 E20
E30 1 1 1 1 2 2 2 3 3 1 1 1 1 2 2 2 3 3 2 2 3 3 E30
E40 -- 1 1 1 2 2 2 3 3 -- 1 1 1 2 2 2 3 3 2 2 3 3 E40
E50 -- 1 1 1 2 2 2 3 3 -- 1 1 1 2 2 2 3 3 2 2 3 3 E50
E60 -- 1 1 1 2 2 2 3 3 -- 1 1 1 2 2 2 3 3 2 2 3 3 E60
E70 -- -- 1 1 2 2 2 3 3 -- -- 1 1 2 2 2 3 3 2 2 3 3 E70
E80 -- -- 1 1 2 2 2 3 3 -- -E90 -- -- 1 1 2 2 2 3 3 -- -- 1 1 2 2 2 3 3 2 2 3 3 E90
E120 -- -- -- -- 2 2 2 3 3 -- -- -- -- 2 2 2 3 3 -- -- 3 3 E120
-- -- -- 3 3 -- -- -- -- -- -- -- 3 3 -- -- -- -- H702*
1 1 2 2 2 3 3 2 2 3 3 E80
Opt
Code
Electrical Compartment and Control Components
Locations of High and Low Voltage Control Components
See pages 5 thru 11 for P/N’s and illustrations.
Condenser Fans
Supply
Fan
Condenser
Section
Electric Heat Section
Form P-Y (01-15), PN 273651R6, Page 4
Electrical / Control
Compartments
(See below.)
Optional Gas or
Access
Inlet Air
Hood
Coil and
Filter Access
Damper Access
Optional Wheel Access
Electrical Compartment and Control Components (Cont’d)
Electrical Panels Cabinet Size 1A, Models YDHA size 60 & YDMA size 90
High Voltage Panel
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
4 - Contactor
5 - Compressor
Controller (A)
11 / 12 - Low Ambient
Controller
(Cond Fan A)
4 - Contactor
(Compressor A)
4 - Contactor
(Compressor B)
4 - Contactor
(Compressor DH)
5 - Compressor
Controller (DH)
6 - Power
Feed
Terminals
1a - Phase Loss/Voltage
Monitor (not illustrated)
1b - Socket for 1a
4 - Contactor
(Power Exhaust)
4 - Contactor (ER Wheel)
4 - Contactor (ER Preheat)
3 - Transformer
13 - Capacitor
(Only used with standard
condenser Fan)
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
23 - Unit Dirty Filter Switch
High Side - Red Tubing
Low Side - Clear Tubing
22 - Exhaust Fan Pressure Switch
High Side - Yellow Tubing
Low Side - Clear Tubing
20 - Supply Fan Pressure Switch
High Side - Blue Tubing
Low Side - Clear Tubing
24 - Energy Recovery Filter Switch
High Side - Green Tubing
Low Side - Clear Tubing
4 - Contactor
(Cond Fan B)
25 - Terminal Strip
7 - VFD
3 - Transformer
27 - Terminal Blocks
2 - Ground Bar
Low Voltage Panel
21 - Relay
15 - Fuses
8 - Line Reactor
27 - Terminal Blocks
26 - Pressure Sensor
Transducer
16 - Carel
Controller
18 - BacNet Card (BHB8)
19 - Lon Card (BHB7)
(Not Illustrated)
17 - Plugs for Code 14
Form P-Y (01-15), PN 273651R6, Page 5
High Voltage Panel
Low Voltage Panel
Electrical Compartment and Control Components (Cont’d)
Electrical Panels Cabinet Size 1B, Models YDHA sizes 90, 120, 150 & YDMA sizes 120 & 150
11 / 12 - Low Ambient
Controller
13 - Capacitor
(Note: only used with
standard condenser fan)
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
4 - Contactor
(Compressor A)
5 - Compressor Controller
(Circuit A)
2 - Ground Bar
27 - Terminal
Blocks
4 - Contactor
(Cond Fan A)
4 - Contactor
(Cond Fan B)
4 - Contactor
(Compressor B)
4 - Contactor
(Compressor DH)
3 - Transformer
5 - Compressor
Controller (DH)
6 - Power Feed
Terminals
7 - VFD
1a - Phase
Loss/Voltage Monitor
(not illustrated)
1b - Socket for 1a
4 - Contactor
(Power Exhaust)
8 - Line Reactor
4 - Contactor
(ER Wheel)
4 - Contactor
(ER Preheat)
3 - Transformer
15 - Fuses
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
23 - Unit Dirty Filter Switch
High Side - Red Tubing
Low Side - Clear Tubing
24 - Energy Recovery Filter Switch
High Side - Green Tubing
Low Side - Clear Tubing
21 - Relay
25 - Terminal Strip
18 - BacNet Card (BHB8)
19 - Lon Card (BHB7)
(Not Illustrated)
16 - Carel
Controller
20 - Supply Fan Pressure Switch
High Side - Blue Tubing
Low Side - Clear Tubing
17 - Plugs for Code 14
26 - Pressure Sensor
Transducer
22 - Exhaust Fan Pressure Switch
High Side - Yellow Tubing
Low Side - Clear Tubing
27 - Terminal Blocks
Form P-Y (01-15), PN 273651R6, Page 6
High Voltage Panel
Electrical Panels Cabinet Size 2, Models YDHA & YDMA sizes 180, 210 & 240 and Model YDSA Sizes 120 & 150
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
4 - Contactor
(Compressor A)
5 - Compressor Controller
(Circuit A)
11 - Low Ambient Controller
for ECM Condenser Fan
12 - Low Ambient Controller
for Standard Condenser Fan
4 - Contactor
(Cond Fan A)
4 - Contactor
(Compressor B)
1
2
4 - Contactor
(Cond Fan B)
4 - Contactor
(Compressor DH)
6 - Power Feed
Terminals
1a - Phase
Loss/Voltage Monitor
(not illustrated)
1b - Socket for 1a
4 - Contactor
(Power Exhaust)
4 - Contactor
(ER Wheel)
4 - Contactor
(ER Preheat)
15 - Fuses
3
4
(Note: only used with standard condenser fan)
13 - Capacitors
5 - Compressor
Controller (DH)
3 - Transformers
27 - Terminal Blocks
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
24 - Energy Recovery Filter Switch
High Side - Green Tubing
Low Side - Clear Tubing
Low Voltage Panel
23 - Unit Dirty Filter Switch
High Side - Red Tubing
Low Side - Clear Tubing
21 - Relay
22 - Exhaust Fan Pressure Switch
High Side - Yellow Tubing
Low Side - Clear Tubing
8 - Line Reactor
20 - Supply Fan Pressure Switch
High Side - Blue Tubing
Low Side - Clear Tubing
26 - Pressure Sensor
Transducer
7 - VFD
2 - Ground Bar
(Not Illustrated)
25 - Terminal Strip
16 - Carel Controller
18 - BacNet Card (BHB8)
19 - Lon Card (BHB7)
(Not Illustrated)
27 - Terminal Blocks
17 - Plugs for Code 14
Form P-Y (01-15), PN 273651R6, Page 7
Electrical Compartment and Control Components (Cont’d)
27 - Terminal Blocks
16 - Carel Controller
18 - BacNet Card (BHB8)
19 - Lon Card (BHB7)
(Not Illustrated)
17 - Plugs for Code 16
21 - Relay
24 - Energy Recovery Filter Switch
High Side - Green Tubing
Low Side - Clear Tubing
23 -Unit Dirty Filter Switch
High Side - Red Tubing
Low Side - Clear Tubing
20 - Supply Fan Pressure Switch
High Side - Blue Tubing
Low Side - Clear Tubing
22 - Exhaust Fan Pressure Switch
High Side - Yellow Tubing
Low Side - Clear Tubing
26 - Pressure Sensor
Transducer
Low Voltage Panel
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
Electrical Panels Cabinet Size 3, Models YDHA & YDMA sizes 300 & 360 and Model YDSA Sizes 180 & 210
(NOTE: Picture shown for illustration purpose - actual configuration to change with options purchased)
4 - Contactor
(Compressor A)
4 - Contactor
(Condenser A)
4 - Contactor
(Compressor DH)
5 - Compressor Controller
(Circuit A)
5 - Compressor
Controller (DH)
13 - Capacitors
(Note: only used with standard condenser fan)
11 - Low Ambiant
Controller
High Voltage Panel #1
14 - Grounding Lug
6 - Power Feed
Terminals
1
2
3
4
1a - Phase Loss / Voltage
Monitor
4 - Contactor
(Compressor B)
4 - Contactor
(Condenser B)
50 - Convenience
Outlet - 125v
27 - Terminal Blocks
12 - Low Ambiant
Controller
3 - Transformer
Form P-Y (01-15), PN 273651R6, Page 8
Electrical Panels Cabinet Size 3, Models YDHA & YDMA sizes 300 & 360 and Model YDSA Sizes 180 & 210
(cont’d)
Low Voltage Panel
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
26 - Pressure Sensor
Transducer
24 - Energy Recovery Filter Switch
High Side - Green Tubing
Low Side - Clear Tubing
23 -Unit Dirty Filter Switch
High Side - Red Tubing
Low Side - Clear Tubing
21 - Relay
22 - Exhaust Fan Pressure Switch
High Side - Yellow Tubing
Low Side - Clear Tubing
20 - Supply Fan Pressure Switch
High Side - Blue Tubing
Low Side - Clear Tubing
27 - Terminal Blocks
16 - Carel Controller
18 - BacNet Card (BHB8)
19 - Lon Card (BHB7)
(Not Illustrated)
17 - Plugs for Code 16
Form P-Y (01-15), PN 273651R6, Page 9
Gas Heat Section Control Panel
Electrical Compartment and Control Components (Cont’d)
Electrical Panel Cabinet Size 1, 2 & 3 - All Models
(NOTE: Picture shown for illustration purposes - actual configuration to change with options purchased)
Electric Heat Control Panel
27 - Contactors
28 - SCR Controller
26 - Fuses
29 - Distribution Block
(NOTE: Picture shown for illustration purposes - actual configuraton to change with options purchased)
31 - Low Speed Venter Switch
(Options AG73 & AG74)
30 - High Speed Venter
Combustion Air Switch
32 - Blocked Condensate
Switch for High Efficiency,
Condensing Furnace
Controls for all Gas Heat Sections
Additonal Controls for Dual
Gas Heat Sections
30 - High Speed Venter
Combustion Air Switch
32 - Blocked Condensate
Switch for High Efficiency,
Condensing Furnace
36 - 75VA Transformer
25 - Terminal Blocks
33 - Venter Motor Speed Controller
(Options AG73 & AG74)
34 - Relay
35 - DSI Control Module for
Single Heat Section or
Right (first) Furnace in
a Dual Heat Section
34 - Relay
35 - DSI Control Module for
the Left (second) Furnace
in a Dual Heat Section
Form P-Y (01-15), PN 273651R6, Page 10
Electrical Components - Replacement P/N’s
For Component Location: Cabinet 1A & 1B, see pages 5, 6 & 10; Cabinet 2, see pages 7 & 10, Cabinet 3, see
pages 8, 9 & 10. For an Illustration of most parts, see pages 12, 16 & 17.
Electrical Components - Unit High Voltage Panel
Code Description P/N
1A Phase Loss/Voltage Monitor (Opt PL4) 208/230/460V (AK5/6/7) - 176826; 575V (AK8) - 258881
1B Socket for Code 1A Monitors 194168
2 Grounding bar, 12 Output 273792
3 Transformers
4 Contactor (24v coil)
5 Digital Controller - for compressors 266067
6 Power Feed Terminals 271834 L-1; 271833 L-2; 271832 L-3
7 VFD
8 Line Reactor
9 Supply Fan
10 Overload Relay See table on page 13
11 Low Ambient Controller for ECM Condenser Fan (Opt CUF4) Control P/N 272460; Sensor P/N 272461
Low Ambient Controller for Standard Condenser Fan (Opt
12
CUF3)
13 Capacitor 207448
14 Grounding Lug 179196
15 Fuses for wheel preheat (opt PH-__) 207617, (Opt AK3) & 207615, 207617(Opt AK5 & AK6)
Electrical Components - Unit Low Voltage Panel
16 Carel Digital Controller with Programmed Software 235689
17 Carel Plugs 272630
18 BacNet DDC Communication Bus (Opt BHB8) 272633
19 LON DDC Communication Bus (Opt BHB7) 284991 (Opt BHB7 w/D19 uploaded by Carel) or 284992 (Opt BHB7 w/D21 uploaded by Carel)
20 Supply Fan Pressure Switch 234712
21 Relays (2 Pole & 3 Pole) 2 Pole 211411, 24v (Base, P/N 211415) & 3 Pole 211799, 24v (Base, P/N 211800)
22 Exhaust Fan Pressure Switch 234712
23 Unit Dirty Filter Switch 105507
24 Energy Recovery Filter Switch 105507
25 Terminal Strip 164545
26 Pressure Sensor Transducer 234818 (Opt VFC3, EFC3); 234819 (Opt VFC4, EFC4, GF5)
Terminal Blocks (Note: used in low voltage, high voltage and
27
gas heat control panels)
Electrical Components - Electric Heat Section Panel
28 Fuses 207615 (30A/250V); 207617 (60A/250V); 207627 (45A/600V)
29 Contactors For P/N’s, see Table, pages 37 thru 39 & 45
30 SCR Controller 234057 (208/230/3/60); 220688 (460/575/3/60)
31 Distribution Block 223495
Electrical Components - Gas Heat Section Panel
32 High Venter (Combustion Air Switch - High Pressure) For P/N’s, see illustration & Table, pages 18 & 19
33 Low Speed Venter (Combustion Air Switch - Low Pressure) For P/N’s, see illustration & Table, pages 18 & 19
34 Blocked Condensate Switch (High Efciency Furnace) 234712
35 Venter Motor Speed Control (Opts AK3, AK5, AK6, AK7, AK8) Ref picture and option sheet for specic board w/ correct switch settings on page 20
36 Ribme Relay Board 234656
37 DSI Control Module 272626
38 Transformers
Various Sensors for Monitoring and Reporting to the Digital Controller - Depending on the application, sensors may be standard or part of controls
options Opt BE__, supply fan control options Opt VFC__, or inlet damper control options Opt GF__.
40 Discharge Air Sensor & Box, 8” probe 222753 (in the discharge ductwork)
41 Space Temperature Sensor (Opts CL23, CL33 & CL78) 257338 (Opt CL23); 221038 (Opt CL33); 272631 (Opt CL78)
42 Return Air Temperature Sensor & Box, 8” probe 222753 (in the return air inlet)
43 Building CO
44 Photoelectric Smoke Detector (in BE17) 259076 (BE17 includes; smoke detector, P/N 159553 & sampling tube, P/N 259069)
45 Duct Static Pressure (in Option VFC3) Transducer, P/N 234818; Sensor Port, P/N 234821
46 Building Static Pressure (in Option VFC4 & GF5) Transducer, P/N 234819 (installed in the building)
47 Dirty Filter Pressure Switch (in Option BE18 & BE28) 105507 (measures pressure drop)
Sensor (in Opts GF8 & BE15) 256975 (BE15 includes CO2 sensor; P/N 234820)
2
Other Electrical Components
50 Convenience Outlet 125v 272900
51 Ductstat (Return or Discharge) or Firestat (in Opt BD5) 42782
52 Remote Display for Digital Controller (Opts RB5, RB6)
53 Non-fusible Disconnect Switch (in Option BA6_) See Table on page 20
54 Disconnect Switch (Option CP_) See Table on page 20
55 Display for Digital Controller (Option RB4) 258452
11100, 0.5 kva, 480-230/120 (Fuse 201803, 3 amp), Cutler Hammer S20N11S51
11217, 0.75 kva, 240/480-120/240V, Cutler Hammer S20N11S76
for
Condenser Fan
271999,12A 271836, 9A 271836, 9A 271836, 9A 272001, 26A 271836, 9A
272489 (Gray), 272490 (Orange), 272791 (Blue), 272492 (Black), 272493 (Red), 272494 (Ivory),
208989, 75 va, 120/208/240/480-24V, includes circuit breaker, Functional Devices TR75VA005
260436 (Opt RB5 Includes Display, P/N 260178, 6-pin Connection Cable P/N 260175 & Cable Splitter & Signal
Booster Module, P/N 260735); 272407 (Opt RB6 includes Remote Hand Held Display, P/N 272642)
Compressors
271999,12A 271999,12A 271999, 12A 272416, 40A
272000,16A 272000, 16A
272001, 26A
272002, 30A
272416, 40A
272417, 50A
272418, 75A
258912, 75 va 460/575-24V, Hartland Controls HCT-130J2K02199
210862, 200 va, 460/575-230V, (ERM)
284219, 6.0 kva, 600/480V
for
272495 (Yellow), 272496 (Green) & 272497 (End Section)
284237, 9.0 kva, 600/480V
for
Supply Air Fan
See tables on pages 12 thru 15
Control P/N 261041; Sensor P/N 261042
for
Power Exhaust
for
Preheater
for
ER Wheel
Form P-Y (01-15), PN 273651R6, Page 11
Electrical Components - Replacement P/N’s (Cont’d)
For Component Location: Cabinet 1A & 1B, see pages 5, 6 & 10; Cabinet 2, see pages 7 & 10, Cabinet 3, see
pages 8, 9 & 10. For an Illustration of most parts, see pages 12, 16 & 17.
Code 1A - Phase Loss/Voltage
Monitor, 208/230/460V - P/N 176826;
575V - P/N 258881
Code 1B - Socket for
Code 1A monitors -
P/N
194168
Codes 3 & 38 Transformers
- P/N’s Vary
Ref Electrical
Components
Chart, page 11
Code 5 -
Digital
Controller for
Compressors,
P/N 266067
Code 2 - Grounding
Bar - P/N 273792
Code 4 - Contactor
- P/N’s Vary
Ref Electrical
Components Chart,
page 11
Code 6 - Power Feed
Terminals - P/N’s
Vary Ref Electrical
Components List,
page 11
Unit Supply Fan Option A10 Components (Codes 7, 8 & 9)- See component photos on page 16
Mod
&
Code No Description
Size
7 VFD --- ---
8 Line Reactor --- ---
120
9 Supply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
150
9 Supply Fan --- ---
YDSA
7 VFD --- ---
8 Line Reactor --- ---
180
9 Supply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
210
9 Supply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
210
9 Supply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
240
9 Supply Fan --- ---
YDHA
7 VFD --- ---
8 Line Reactor --- ---
300
9 Supply Fan ---
7 VFD --- ---
8 Line Reactor --- ---
360
9 Supply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
210
9 Supply Fan
YDMA
7 VFD --- ---
8 Line Reactor --- ---
240
9 Supply Fan
AK3 - 230/1/60 AK5 - 208/3/60 AK6 - 230/3/60 AK7 - 460/3/60 AK8 - 575/3/60 AK12 - 400/3/50
Model No P/N Model No P/N Model No. P/N
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- KDRA4L 221588 --- --- KDRA4L 221588
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- KDRA4L 221588 --- --- KDRA4L 221588
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- KDRA4L 221588 --- --- KDRA4L 221588
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- KDRA4L 221588 --- --- KDRA4L 221588
ER50C-4DM.
G7.1R
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
221621
235687
Model/Part
No.
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
P/N
284560
235687
284560
235687
284560
235687
284560
235687
221619
235687
221619
235687
284560
235687
284560
235687
221619
235687
221619
235687
Model/Part
No.
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
P/N
221858
235688
221858
235688
221858
235688
221858
235688
221858
235688
221858
235688
221858
235688
221858
235688
221858
235688
221858
235688
Model/Part
No.
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
ACS355-03U-
12A5-4+J404
ER50C-4DM.
G7.1R
P/N
284560
235687
284560
235687
284560
235687
284560
235687
221619
235687
221619
235687
284560
235687
284560
235687
221619
235687
221619
235687
Form P-Y (01-15), PN 273651R6, Page 12
Unit Supply Fan Option A10 Components (Codes 7, 8 & 9) Cont’d - See component photos on page 16
Mod
&
Code No Description
Size
7 VFD --- ---
8 Line Reactor --- ---
300
9 Supply Fan ---
YDMA
7 VFD --- ---
8 Line Reactor --- ---
360
9 Supply Fan ---
AK3 - 230/1/60 AK5 - 208/3/60 AK6 - 230/3/60 AK7 - 460/3/60 AK8 - 575/3/60 AK12 - 400/3/50
Model No P/N Model No P/N Model No. P/N
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
G7.1R
221621
235687
221621
235687
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
ACS550-U1-
024A-2
ER50C-4DM.
G7.1R
221621
235687
221621
235687
Model/Part
No.
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
P/N
284560
235687
284560
235687
Model/Part
No.
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
ACS550-U1-
09A0-6
ER50C-4DM.
G7.1R
P/N
221858
235688
221858
235688
Unit Supply Fan Opton A10E Components (Codes 4, 9 & 10)- See component photos on page 16
Mod
&
Code No Description
Size
Supply Fan
4
Contactor
9 Supply Fan --- ---
60
Overload
10
4
9 Supply Fan --- ---
90
10
4
9 Supply Fan --- ---
120
YDHA
10
4
9 Supply Fan --- ---
150
10
4
9 Supply Fan --- ---
180
10
4
9 Supply Fan --- ---
60
10
4
9 Supply Fan --- ---
90
10
4
9 Supply Fan --- ---
120
YDMA
10
4
9 Supply Fan --- ---
150
10
4
9 Supply Fan --- ---
180
10
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
Supply Fan
Contactor
Overload
Relay
AK3 - 230/1/60 AK5 - 208/3/60 AK6 - 230/3/60 AK7 - 460/3/60 AK8 - 575/3/60 AK12 - 400/3/50
Model No P/N Model No P/N Model No. P/N
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
AF09-30-10-41 271836 AF09-30-10-41 271836 AF09-30-10-41 271836
ER31C-ZID.
DC.1R
TA25DU6.5 -
4.5 - 6.5 - 5.9
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
AF09-30-10-41 271836 AF09-30-10-41 271836 AF09-30-10-41 271836
ER31C-ZID.
DC.1R
TA25DU6.5 -
4.5 - 6.5 - 5.9
AF09-30-10-41 271836 AF09-30-10-41 271836 AF09-30-10-41 271836
ER31C-ZID.
DC.1R
TA25DU6.5 -
4.5 - 6.5 - 5.9
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
AF12-30-10-41 271999 AF12-30-10-41 271999 AF09-30-10-41 271836
ER45C-ZID.
GG.1R
TA25DU14 -
10.0 - 14.0
235653
284011
235655
284014
235655
284014
235655
284014
235655
284014
235653
284011
235653
284011
235655
284014
235655
284014
235655
284014
ER31C-ZID.
DC.1R
TA25DU6.5 -
4.5 - 6.5 - 5.9
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
ER31C-ZID.
DC.1R
TA25DU6.5 -
4.5 - 6.5 - 5.9
ER31C-ZID.
DC.1R
TA25DU6.5 -
4.5 - 6.5 - 5.9
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
ER45C-ZID.
GG.1R
TA25DU11 - 7.5
- 11.0 - 9.2
235653
284011
235655
284013
235655
284013
235655
284013
235655
284013
235653
284011
235653
284011
235655
284013
235655
284013
235655
284013
Model/Part
No.
ER31C-ZID.
DC.1R
TA25DU3.1 2.2
- 3.1 - 2.8
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
ER31C-ZID.
DC.1R
TA25DU3.1 2.2
- 3.1 - 2.8
ER31C-ZID.
DC.1R
TA25DU3.1 2.2
- 3.1 - 2.8
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
ER45C-ZID.
GG.1R
TA25DU5.1 -
3.5 - 5.0 - 4.6
P/N
235656
235695
235658
284010
235658
284010
235658
284010
235658
284010
235656
235695
235656
235695
235658
284010
235658
284010
235658
284010
Model/Part
No.
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
--- ---
P/N Model/Part No. P/N
AF09-30-10-41 271836
TA25DU4.0 2.8 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
AF09-30-10-41 271836
TA25DU4.0 2.8 -
AF09-30-10-41 271836
TA25DU4.0 2.8 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
AF09-30-10-41 271836
TA25DU6.5 - 4.5 -
Form P-Y (01-15), PN 273651R6, Page 13
Model/Part
No.
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ACS550-U1-
012A-4
ER50C-4DM.
G7.1R
ER31C-ZID.
DC.1R
4.0 - 3.6
ER45C-ZID.
GG.1R
6.5 - 5.8
ER45C-ZID.
GG.1R
6.5 - 5.8
ER45C-ZID.
GG.1R
6.5 - 5.8
ER45C-ZID.
GG.1R
6.5 - 5.8
ER31C-ZID.
DC.1R
4.0 - 3.6
ER31C-ZID.
DC.1R
4.0 - 3.6
ER45C-ZID.
GG.1R
6.5 - 5.8
ER45C-ZID.
GG.1R
6.5 - 5.8
ER45C-ZID.
GG.1R
6.5 - 5.8
P/N
284560
235687
284560
235687
235656
235696
235658
284011
235658
284011
235658
284011
235658
284011
235656
235696
235656
235696
235658
284011
235658
284011
235658
284011
Electrical Components - Replacement P/N’s (Cont’d)
For Component Location: Cabinet 1A & 1B, see pages 5, 6 & 10; Cabinet 2, see pages 7 & 10, Cabinet 3, see
pages 8, 9 & 10. For an Illustration of most parts, see pages 12, 16 & 17.
Unit Supply Fan Opton A11 Components (Codes 7, 8 & 9)- See component photos on page 16
Mod
&
Code No Description
Size
7 VFD --- ---
8 Line Reactor --- ---
120
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
150
9 Suppply Fan --- ---
YDSA
7 VFD --- ---
8 Line Reactor --- ---
180
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
210
9 Suppply Fan --- ---
7 VFD
8 Line Reactor
60
9 Suppply Fan
7 VFD --- ---
8 Line Reactor --- ---
90
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
120
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
150
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
180
YDHA
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
210
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
240
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
300
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
360
9 Suppply Fan --- ---
Form P-Y (01-15), PN 273651R6, Page 14
AK3 - 230/1/60 AK5 - 208/3/60 AK6 - 230/3/60 AK7 - 460/3/60 AK8 - 575/3/60 AK12 - 400/3/50
268522
268506
268522
268506
221622
268506
221622
268506
221610
268504
221611
268505
221611
268505
221611
268505
268522
268506
268522
268506
268522
268506
221622
268506
221622
268506
Model/Part
No.
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
ACS355-03U-
05A6-4+J404
ER28C-2DM.
D7.1R
ACS355-03U-
08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U-
08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U-
08A8-4+J404
ER45C-4DM.
F7.1R
ACS350-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
Model No P/N Model No P/N Model No. P/N
ACS355-03U-
31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS355-03U-
31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
ACS350-01U-
09A8-2+J404
KDRB22L 221599 KDRA28L 221597 KDRA28L 221597 KDRA2L 221586 --- --- KDRA2L 221586
ER28C-2DM.
D7.1R
221604
272639
H7.1R
ACS355-03U-
09A8-2+J404
ER28C-2DM.
D7.1R
ACS355-03U-
17A6-2+J404
KDRB22L 221599 KDRB22L 221599 KDRA3L 221587 --- --- KDRA3L 221587
ER45C-4DM.
F7.1R
ACS350-03U-
17A6-2+J404
KDRB22L 221599 KDRB22L 221599 KDRA3L 221587 --- --- KDRA3L 221587
ER45C-4DM.
F7.1R
ACS355-03U-
17A6-2+J404
KDRB22L 221599 KDRB22L 221599 KDRA3L 221587 --- --- KDRA3L 221587
ER45C-4DM.
F7.1R
ACS355-03U-
31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS355-03U-
31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS355-03U-
31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
--- --- --- --- --- --- --- --- --- ---
ER50C-4DM.
H7.1R
268522
268506
268522
268506
221622
268506
221622
268506
221610
272630
221611
268505
221611
268505
221611
268505
268522
268506
268522
268506
268522
268506
221622
268506
221622
268506
ACS355-03U31A0-2+J404
ER50C-4DM.
H7.1R
ACS355-03U31A0-2+J404
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
ER50C-4DM.
H7.1R
ACS355-03U09A8-2+J404
ER28C-2DM.
D7.1R
ACS355-03U17A6-2+J404
ER45C-4DM.
F7.1R
ACS350-03U17A6-2+J404
ER45C-4DM.
F7.1R
ACS355-03U17A6-2+J404
ER45C-4DM.
F7.1R
ACS355-03U31A0-2+J404
ER50C-4DM.
H7.1R
ACS355-03U31A0-2+J404
ER50C-4DM.
H7.1R
ACS355-03U31A0-2+J404
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
ER50C-4DM.
H7.1R
P/N
221620
268506
221620
268506
284561
268506
284561
268506
221617
268504
221618
268505
221618
268505
221618
268505
221620
268506
221620
268506
221620
268506
284561
268506
284561
268506
Model/Part
No.
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS355-U1-
03A9-6
ER28C-2DM.
D7.1R
ACS550-U1-
06A1-6
ER45C-4DM.
F7.1R
ACS550-U1-
06A1-6
ER45C-4DM.
F7.1R
ACS550-U1-
06A1-6
ER45C-4DM.
F7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
P/N
221859
272434
221859
272434
221859
272434
221859
272434
221856
272432
221857
272433
221857
272433
221857
272433
221859
272434
221859
272434
221859
272434
221859
272434
221859
272434
Model/Part
No.
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
ACS355-03U-
05A6-4+J404
ER28C-2DM.
D7.1R
ACS355-03U-
08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U-
08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U-
08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U-
15A6-4+J404
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
ACS550-U1-
015A-4
ER50C-4DM.
H7.1R
221620
268506
221620
268506
284561
268506
284561
268506
221617
268504
221618
268505
221618
268505
221618
268505
221620
268506
221620
268506
221620
268506
284561
268506
284561
268506
P/N
Unit Supply Fan Opton A11 Components (Codes 7, 8 & 9) Con’t- See component photos on page 16
Mod
&
Code No Description
Size
7 VFD --- ---
8 Line Reactor --- ---
60
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
90
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
120
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
150
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
180
YDMA
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
210
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
240
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
300
9 Suppply Fan --- ---
7 VFD --- ---
8 Line Reactor --- ---
360
9 Suppply Fan --- ---
AK3 - 230/1/60 AK5 - 208/3/60 AK6 - 230/3/60 AK7 - 460/3/60 AK8 - 575/3/60 AK12 - 400/3/50
Model No P/N Model No P/N Model No. P/N
ACS355-03U09AB-2+J404
KDRA28L 221597 KDRA28L 221597 KDRA2L 221586 --- --- KDRA2L 221586
ER28C-2DM.
D7.1R
ACS355-03U09AB-2+J404
KDRA28L 221597 KDRA28L 221597 KDRA2L 221586 --- --- KDRA2L 221586
ER28C-2DM.
D7.1R
ACS355-03U17A6-2+J404
KDRB22L 221599 KDRB22L 221599 KDRA3L 221587 --- --- KDRA3L 221587
ER45C-4DM.
F7.1R
ACS355-03U17A6-2+J404
KDRB22L 221599 KDRB22L 221599 KDRA3L 221587 --- --- KDRA3L 221587
ER45C-4DM.
F7.1R
ACS355-03U17A6-2+J404
KDRB22L 221599 KDRB22L 221599 KDRA3L 221587 --- --- KDRA3L 221587
ER45C-4DM.
F7.1R
ACS355-03U31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS355-03U31A0-2+J404
KDRD25L 273362 KDRD25L 273362 KDRA5L 221589 --- --- KDRA5L 221589
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
--- --- --- ---
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
--- --- --- ---
ER50C-4DM.
H7.1R
221610
272430
221610
272430
221611
268505
221611
268505
221611
268505
268522
268506
268522
268506
221622
268506
221622
268506
ACS355-03U-
09AB-2+J404
ER28C-2DM.
D7.1R
ACS355-03U-
09AB-2+J404
ER28C-2DM.
D7.1R
ACS355-03U-
17A6-2+J404
ER45C-4DM.
F7.1R
ACS355-03U-
17A6-2+J404
ER45C-4DM.
F7.1R
ACS355-03U-
17A6-2+J404
ER45C-4DM.
F7.1R
ACS355-03U-
31A0-2+J404
ER50C-4DM.
H7.1R
ACS355-03U-
31A0-2+J404
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
ER50C-4DM.
H7.1R
ACS550-U1-
031A-2
ER50C-4DM.
H7.1R
221610
268504
221610
268504
221611
268505
221611
268505
221611
268505
268522
268506
268522
268506
221622
268506
221622
268506
Model/Part
No.
ACS355-03U05A6-4+J404
ER28C-2DM.
D7.1R
ACS355-03U05A6-4+J404
ER28C-2DM.
D7.1R
ACS355-03U08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U15A6-4+J404
ER50C-4DM.
H7.1R
ACS550-U1-
15A-4
--- --- --- --- --- ---
ER50C-4DM.
H7.1R
ACS550-U1-
15A-4
--- --- --- --- --- ---
ER50C-4DM.
H7.1R
P/N
221617
268504
221617
268504
221618
268505
221618
268505
221618
268505
221620
268506
221620
268506
284561
268506
284561
268506
Model/Part
No.
ACS550-U1-
03A9-6
ER28C-2DM.
D7.1R
ACS550-U1-
03A9-6
ER28C-2DM.
D7.1R
ACS550-U1-
06A1-6
ER45C-4DM.
F7.1R
ACS550-U1-
06A1-6
ER45C-4DM.
F7.1R
ACS550-U1-
06A1-6
ER45C-4DM.
F7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
ACS550-U1-
011A-6
ER50C-4DM.
H7.1R
P/N
221856
272432
221856
272432
221857
272433
221857
272433
221857
272433
221859
272434
221859
272434
221859
272434
221859
272434
Model/Part
No.
ACS355-03U05A6-4+J404
ER28C-2DM.
D7.1R
ACS355-03U05A6-4+J404
ER28C-2DM.
D7.1R
ACS355-03U08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U08A8-4+J404
ER45C-4DM.
F7.1R
ACS355-03U15A6-4+J404
ER50C-4DM.
H7.1R
ACS355-03U15A6-4+J404
ER50C-4DM.
H7.1R
ACS550-U1-
15A-4
ER50C-4DM.
H7.1R
ACS550-U1-
15A-4
ER50C-4DM.
H7.1R
P/N
221617
268504
221617
268504
221618
268505
221618
268505
221618
268505
221620
268506
221620
268506
284561
268506
284561
268506
Form P-Y (01-15), PN 273651R6, Page 15
Electrical Components - Replacement P/N’s (Cont’d)
For Component Location: Cabinet 1A & 1B, see pages 5, 6 & 10; Cabinet 2, see pages 7 & 10, Cabinet 3, see
pages 8, 9 & 10. For an Illustration of most parts, see pages 12, 16 & 17.
Code 7 -
VFD
Part Number
Varies Reference
Tables on Pages
12 thru 15
Code 9 -
Supply Fan
(Part Number
Varies Refer to
tables shown on
pages 12 thru 15)
Code 12 Low
Ambient
Controller for
Std Condenser
Fan Sensor - P/N
261042
(Control P/N
261041 not shown)
Variable Frequency
Drive Model ACS550
Variable Frequency
Drive Model ACS355
Code 10 -
Overload Relay
(Part Number
Varies Refer to
table on shown on
page 13)
Code 13 -
Capacitor P/N 207448
Code 8 -
Line Reactor
(Part Number
Varies Refer to
tables shown on
Pages 12 thru 15)
Code 11 Low
Ambient
Controller
for ECM
Condenser Fan
- P/N 272460 &
Sensor - P/N
272461 (not
shown)
Code 14 Grounding Lug
- P/N 179196
Codes 15, 28 &
190
Fuse- P/N’s:
207615 (30Amp),
207617 (60Amp),
207627 (45Amp)
Code 18
BacNet DDC
Communication
Bus,
P/N 272633
Form P-Y (01-15), PN 273651R6, Page 16
Code 16 - Carel Digital
Controller w/ Programmed
Software, Opt D19 or D21
Code 19
LON DDC
Communication
Bus,
P/N 272632
Code 17
Carel Plugs
P/N 272630
Codes 20, 22 & 34
Pressure Switch,
P/N 234712
Loading...