Prince castle IRT-SB-NA-1PS User Manual
Horizontal Infrared Toaster
Operation
Manual
Conveyor
Out-feed Tray
Product Identification
Display and
Touchpad
LCD
Display
LEFT and
RIGHT Scroll
Buons
IRT-SB-NA-1PS
IRT-SB-NA-3PS
MENU
Buon
This product is warranted to be free from defects in material and/or
LIMITED WARRANTY
workmanship for a period of two (2) years from date of original
installation, not to exceed 30 months from date of shipment from
our factory. Any part or component which proves to be faulty in
material and/or workmanship within the warranty period will be
replaced or repaired (at the option of Prince Castle, Inc.) without
cost to the customer for parts or labor.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this warranty
and all work must be performed by an authorized Prince Castle
Service Agent.
• All labor shall be performed during regular work hours. Overtime
premium will not be covered.
• Travel charges are limited to 200 kilometers (100 miles) round
trip, 2 hours travel time, one trip per repair.
• Damage caused by carelessness, neglect, and/or abuse (e.g.,
using wrong current, dropping, tampering with or altering electrical
components, or improper cleaning) is not covered.
• Equipment damaged in shipment, by fire, flood or an act of God
is not covered.
• Damage to non-stick coated surfaces is not covered by this warranty.
355 East Kehoe Blvd. • Carol Stream, IL 60188 USA
Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
Product Identification……………………………...….Page 1
Warranty Statement….….………………..………..…Page 1
Table of Contents…….……………….…………....…Page 1
Electrical Specifications.……………….…………..…Page 2
Safe Service Practices.………………………...…..…Page 2
Serial Number Matrix………………………………….Page 2
Installation…...……….…………………….………..…Page 3
Operation…….…………………..……………….…….Page 4
Cleaning…………………………...………………....…Page 6
Display Menu Options…..……………….…..…..…....Page 7
Management Programming…..……….…………..….Page 9
Exploded View and Parts List………………………...Page 12
Troubleshooting Guide………..……….…………..….Page 15
TABLE OF CONTENTS
IRT-SB-NA-1PS 1 Printed in USA 9/15
IRT-SB-NA-3PS 353-566
Horizontal Infrared Toaster
IRT-SB-NA-1PS
IRT-SB-NA-3PS
Electrical Specicaons
IRT-SB-NA-1PS 200-240VAC, 50/60 Hz, 1 Ph.
IRT-SB-NA-3PS 200-240VAC, 50/60 Hz, 1 Ph.
Disconnect Power
WARNING
Failure to turn off the unit before
servicing could result in severe
bodily injury or death. Switch the
On/Off switch to the Off position
before servicing.
Important
Prince Castle reserves the right to change specifications
and product design without notice. Such revisions do not
entitle the buyer to corresponding changes, improvements,
additions, or replacements for previously purchased equipment.
Safe Service Pracces
Indicates information important to the proper operation of
the unit. Failure to observe may result in damage to the
equipment and/or severe bodily injury or death.
Indicates information important to the operation of the unit.
Failure to observe may result in damage to the equipment.
This appliance is designed for toasting bread products in a commercial
McDonalds kitchen. The dimensions of the bread products as defined
by McDonalds.
Do not hose down or use a water jet on the unit. Keep the unit
away from running water. Disconnect power cord before performing any cleaning or maintenance.
Equipment must be elevated from the floor at all times during
cleaning and operation.
WARNING
CAUTION
GENERAL
CAUTION
CAUTION
Serial Number Matrix
The manufacture date is encoded in the unit’s serial number. The
service bench installaon date (used to determine warranty
coverage) is considered to be the end of the following month. For
example:
Serial Number: FJ0000458
Manufacture Date: June 2014
Service Bench Installaon Date: July 31, 2014
IRT-SB-NA-1PS 2 Printed in USA 9/15
IRT-SB-NA-3PS 353-566
Horizontal Infrared Toaster
IRT-SB-NA-1PS
IRT-SB-NA-3PS
Unpack and Inspect. Remove the unit from th e car -
1
ton and inspect for signs of damage. If there is damage
to the unit:
Notify the carrier within 24 hours of delivery
Save carton and packaging materials for inspection
purposes.
Contact your local dealer.
Verify parts. Verify that all parts have been received.
When replacing parts use Prince Castle parts only.
2
Horizontal Infrared Toaster
Out-Feed Tray
In Feed Rack
Crumb Tray (Already installed)
Installaon
Install In-Feed Rack . Slid e th e in -feed rack onto 1
5
hook on each side. Ensure the rack is secure before
operating the unit.
Install Out-Feed Tray. Insert the Out-Feed Tray onto
one hook on each side. Ensure the rack is secure before
operating the unit.
Place toaster on a sturdy surface. Remo ve blu e and /
3
or white protective covering prior to powering on.
CAUTION
Two man lift, unit weight is more than 50 lbs.
Plug unit in. Plug un it into a grou nded recep tac le
Follow daily PM procedures.
4
6
with a matching plug configuration.
WARNING
All electrical connections must be in accordance with local electrical codes and any other applicable codes.
If the supply cord is damaged, it must be replaced by the manufacturer, its service agent, or similarly qualified persons in order to
avoid hazards.
To prevent an electric shock hazard, this device must
be bonded to equipment in close proximity with an
equipotential bonding conductor. This device is
equipped with grounding lug for this purpose and is
marked with the following symbol.
IRT-SB-NA-1PS 3 Printed in USA 9/15
IRT-SB-NA-3PS 353-566
Horizontal Infrared Toaster
IRT-SB-NA-1PS
IRT-SB-NA-3PS
Operaon
Turn unit ON. Turn th e
1
On/Off switch located on
back of toaster to ON. The
Prince Castle screen will
appear in the display for
three seconds.
(Ensure the conveyor is
fully closed)
Wait through Warm-Up. During Warm-Up, the LCD display
2
will read “WARMING UP”. Warm-Up me, is about 15-20
minutes. Bagel Mode will come up by default
WARMING UP
4
5
BURN/ELECTRICAL SHOCK HAZARD! Toaster can be
HOT and can cause severe burns or severe shock.
Keep hands and objects out of the toaster unit! Failure
to exercise caution may result in serious injury! Turn
the unit off, and let it cool down completely before
touching or working on internal apparatus.
Watch for Product.
When ready temperature
is reached, the LCD
display will read
“”BAGEL” or “MUFFIN”
depending on the mode.
Feeding in Muffins and Bagels. Feed product cut
side up in the in feed wire racks shown. Rack will allow 6
muffin or 5 bagels across.
WARNING
- - - - -
BAGEL
Select product to be toasted by touching the button until
3
indicator light illuminates. Note: Conveyor belt will
change speed based on product selected.
Muffin = White LED
Bagel = Blue LED
Adjusting Toast. For l ig ht er toast, p ress and hol d, ~5
6
seconds, directional key (left) until indicator move towards lighter rectangle. For darker toast, repeat with the
direction key (right) that points toward the blackened
rectangle.
- - - - - -
BAGEL
IRT-SB-NA-1PS 4 Printed in USA 9/15
IRT-SB-NA-3PS 353-566
Horizontal Infrared Toaster
IRT-SB-NA-1PS
IRT-SB-NA-3PS
Remove Stuck Product. Retrieve stuck product
7
by first shutting off the power to the unit. BE CAREFUL NOT TO CONTACT INTERNAL COMPONENTS DURING RETRIEVAL, THEY WILL BE
VERY HOT. DO NOT CONTACT HEATING ELEMENTS DURING RETRIEVAL. DAMAGE MAY
OCCUR.
Operaon
IRT-SB-NA-1PS 5 Printed in USA 9/15
IRT-SB-NA-3PS 353-566
Loading...