Prestige GBQRP36L, GBQC36, GBQRP42L, GBQC42, Pro GBQRP36L Installation Instructions Manual

1

PRO Series

Installation

Instructions

36” 105,000 BTU Professional Grill

GBQRP36L – 36” Grill

GBQC36 – 36” Cart

42” 112,000 BTU Professional Grill

GBQRP42L – 42” Grill

GBQC42 – 42” Cart

PLEASE READ THESE OPERATING INSTRUCTIONS BEFORE INSTALLATION
AND USE TO PREVENT ACCCIDENT OR DAMAGE TO THE GRILL.

ATTENTION INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE

CONSUMER.

ATTENTION CONSUMER: PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE

REFERENCE.

If you have service or installation questions, please call us at

1-800-358-8886 or visit our website at www.prestige-america.com.

2

Safety Labels Appearing On The Appliance

MODEL NO: GBQRP36L – 36” Grill GBQRP42L – 42” Grill

EQUIPPED FOR: NATURAL GAS OR LP [PROPANE] GAS

SERIAL No: 000000****

ANSI Z21.58-1995/CGA 1.6-M95, ANSI Z21.58A-1998/CGA 1.6-M98,

ANSI Z21.58B-2000/CGA 1.6-M02 OUTDOOR COOKING GAS APPLIANCE

FOR OUTDOOR USE ONLY, IF STORED INDOORS, DETACH AND LEAVE CYLINDERS

OUTDOORS

BURNER INPUT RATING LP AND NATURAL GAS:

GBQRP36L – 36” Grill: 30,000 BTU X 3

GBQRP36L – 36” Grill BROILER: 13,500

GBQRP42L – 42” Grill: 13,500

GBQRP42L – 42” SMOKER BURNER: 7,000 BTU

GAS PRESSURE

LP GAS [PROPANE]

NATURAL GAS

MANIFOLD:

10.5" w.c

GBQRP36L: 5.0”wc

GBQRP42L: 5 0"w c

MINIMUM SUPPLY

TO REGULATOR

11.0" w.c.

5.0" w.c.

ELECTRICAL REQUIREMENT: 12 VDC

OPTIONAL ROTISSERIE IS PROVIDED WITH A SEPARATE POWER SUPPLY

CORD AND IS NOT CONSIDERED A PART OF THIS UNIT FOR RATING PURPOSES

A: DO NOT STORE A SPARE LP-GAS CYLINDER UNDER OR NEAR THIS

APPLIANCE;

B: NEVER FILL THE CYLINDER BEYOND 80 PERCENT FULL;

C: IF THE INFORMATION IN "A" AND "B" IS NOT FOLLOWED EXACTLY,

A FIRE CAUSING DEATH OR SERIOUS INJURY MAY OCCUR.

FOR INSTALLATION IN NON.-COMBUSTIBLE LOCATIONS ONLY.

DO NOT LOCATE UNDER OVERHEAD UNPROTECTED COMBUSTIBLE

SURFACES.

FOR INSTALLATION IN COMBUSTIBLE LOCATIONS, AS A FREESTANDING

UNIT, WITH CLEARANCES OF 24" FROM THE SIDE WALLS AND 24" FROM THE

REAL WALL SIDE BURNERS.

P/N: P10030

3

Safety Labels Appearing On The Appliance

YOUR GRILL IS EQUIPPED WITH A BATTERY OPERATED IGNITION SYSTEM FOR EASIER

LIGHTING OF YOUR GRILL. THE SYSTEM USES SIMPLE 9 VOLT BATTERIES.

READ THESE GRILL AND ROTISSERIE LIGHTING INSTRUCTIONS BEFORE LIGHTING

- KEEP THE GRILL HOOD OPEN DURING THE LIGHTING PROCESS. MAKE SURE ALL THE

BURNER KNOBS ARE TURNED TO THE "OFF" POSITION.

- PUSH IN AND TURN THE KNOB TO THE HIGHEST POSITION SETTING.

- PRESS THE IGNITION BUTTON IN AND HOLD UNTIL THE GRILL BURNER IGNITES.

- IF IHE BURNER DOES NOT IGNITE WIIHIN 5 SECONDS, TURN THE BURNER TO THE "OFF"

POSITION AND WAIT 5 MINUTES. REPEAT THE ABOVE STEPS.

TO SAFELY SHUT DOWN THE GRILL, TURN ALL BURNERS TO THE "OFF" POSITION. FOR LP

GAS MODELS, IN ADDITION TO TURNING THE BURNERS OFF, TURN THE VALVE ON THE

GAS CYLINDER TO THE "OFF" POSITION WHEN NOT IN USE.

WARNING

ELECTRICAL GROUNDING INSTRUCTIONS

THIS APPLLANCE IS EQUIPPED WITH A THREE-PRONG GROUNDING PLUG FOR PROTECTION

AGAINST SHOCK HAZARD AND SHOULD BE PLUGGED DIRECTLY INTO A PROPERLY

GROUNDED RECEPTACLE. DO NOT CUT OR REMOVE THE GROUNDING PRONG FROM THIS

PLUG.

DIELECTRIC TESTED

GAS LEAK

TESTED

4

Table of Contents

Congratulations on the purchase of your Prestige® Pro Series Grill. These products were
designed and developed by AMD Direct, Inc. in partnership with Prestige®, the premier
manufacturer and distributor of high quality outdoor products.

This grill meets or exceeds the requirements of ETL as intended for outdoor use.

This product carries a limited lifetime warranty on all stainless steel parts and components,
with a one year warranty on all other components.

SAFETY LABELS APPEARING ON THE APPLIANCE 3

IMPORTANT INSTRUCTIONS FOR SAFE INSTALLATION AND OPERATION 5

IF YOU SMELL GAS 6

FILLING AND REFILLING LP GAS CYLINDERS 7

CHECKING FOR GAS LEAKS

8

GENERAL USE AND CARE 9

UNIT INSTALLATION 10

CONNECTING TO THE GAS SOURCE 10

LIGHTING YOUR GRILL 12

TROUBLESHOOTING 12

FIRST TIME OPERATION 13

ROTISSERIE & SEAR BURNER 14

HALOGEN LIGHTING 14

CLEANING 15

BURNER ADJUSTMENTS 16

WHEN THE BURNERS WILL NOT LIGHT 17

YELLOW OR ORANGE FLAME 17

WARRANTY REGISTRATION 18

APPLIANCE CUT OUT DIMENSIONS 19

WIRING DIAGRAMS 20

5

Safety and Installation Instructions

When using your Prestige® Pro Series grill, please read and follow these basic precautions:

GRILL INSTALLATION

This gas grill must be installed in accordance with all local codes.

If installation is planned in an area with no local codes, the gas grill must be installed in accord with the

National Fuel Gas Code ANSI Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA

58 or CSA B149.1 natural gas and propane installation code.

CALIFORNIA PROPOSITION 65 WARNING

The burning of gas cooking fuel generates some by-products which are on the list of

substances which are known by the State of California to cause cancer or reproductive

harm. California law requires businesses to warn customers of potential exposure to such

substances. To minimize exposure to these substances, always operate the unit according

to the use and care manual, ensuring you provide good ventilation when cooking with

gas.

GRILL LOCATION

 Do not use or locate your gas grill in garages, porches, breezeways, sheds, enclosed areas or under

overhead unprotected combustible construction.

 Do not store or use your grill or gas tanks indoors; this gas grill is designed for outdoor use only.
 This gas grill cannot be used on or in recreational vehicles or boats.
 Clearances to combustible materials must be a minimum of 24" from the back and 24" on each side.
 The grill must be installed using only non-combustible materials.
 Do not obstruct the flow of combustion and ventilation air around the grill housing. Refer to minimum

clearances stated above and keep free and clear of debris.

6

Safety and Installation Instructions

 Please read all instructions before installing or operating your gas grill to prevent injury and appliance

damage.

 All gas grills will get hot during use. Use extreme caution when operating the grill.
 Do not touch hot surfaces. Always use the handle to open or close the grill.
 Close supervision is necessary when this or any appliance is used near children. Keep children away

from the grill during operation and until the grill has cooled off.

 Do not store any LP cylinder or tank not connected for use with the grill, in the area of this grill or any

other appliance. Never store an LP cylinder or tank indoors, or within the reach of children.

 Keep any electrical supply cord and fuel supply hose away from any heated surfaces and dripping

grease.

 Do not twist the gas supply hose.
 Before each use, visually inspect the gas supply hose for cracks, cuts or excessive wear. Replace the

hose if necessary.

 Never test the grill for gas leaks using a lighted match or any other open flame; see leak test

procedures using soap/water solutions - included in following pages of this manual.

 The use of accessories, regulators, or components not recommended by the appliance manufacturer may

cause injuries and will void warranty.

 Never light the grill with the hood closed and be certain that the burners are positioned and seated over

the gas valves and on the burner support.

 Never lean over the cooking surface when lighting or operating the grill.
 Use barbecue tools with wood handles and insulated oven mitts when operating the grill.

IF YOU SMELL GAS:

I - Shut off the gas supply to the appliance at its source.

2 - Extinguish any open flames.

3 - Open grill hood to release any accumulation of gas vapor.

4 - If a gas odor persists, contact your gas supplier immediately.

 Gas Specifications: Be sure that the gas supplied to the grill conforms to the model you purchased. A

Natural Gas grill requires natural gas to operate; an LP grill requires liquid propane gas to operate.

Check the rating label on the bottom left side of the back of the unit.

 Never connect the appliance to an unregulated gas supply line. Grills operated without a regulator are

unsafe and will not be serviced until installed properly and safely, unsafe operation without a gas

regulator will void warranty of the grill.

 Grills operated with NG (natural gas) gas must be installed with the NG regulator supplied with the

unit set to 5.0" water column pressure.