Page 1
INSTALLATION, OPERATION AND MAINTENANCE MANUAL
Warning
Please read carefully before proceeding with installation. Your failure to follow any attached instructions
or operating parameters may lead to the product’s failure.
Save manual for future reference
Model: UC1-HC
Premier, Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
Phone: 800-752-5582 www.PremierH2o.com Fax: 623-866-5666
Manual #: 299112 Manual Date: 09/25/2013
Page 2
Thank you for your purchase of a state of the art Premier Water Treatment system.
UC1-HC Water Treatment System:
Premier UC1-HC water treatment system contains a heavy duty sediment, cyst and chlorine
reducing lter block. The UC1-HC water ltration helps protect small appliances and provides
clean, clear, great tasting water with a higher ow and gallon rating than other similar systems.
System Maintenance
Just because you can not taste it, does not mean that it is not there. Many contaminants in the
drinking water are undetectable to the taste. Additionally, over time if you do not replace the
lter elements, other bad tastes and odors will be apparent in your drinking water. This is why
it is important to change your lters at the recommended intervals as indicated in this system
manual.
When replacing any of the lter elements, pay special attention to any cleaning instructions. Should
you have any further questions please refer to our web site at www.PremierH2o.com or call our
customer service department at 1-800-752-5582.
2
Page 3
Table of Contents
Service Record ...................................................................................................................................... 3
Operational Parameters ........................................................................................................................ 4
Contents of Under Counter System....................................................................................................... 4
Tools Recommended For Installation .................................................................................................... 4
Part Number List / Flow Diagram .......................................................................................................... 4
Blue Tube Connection to Cold Water Angle Stop Valve ........................................................................ 5
Blue Tube Connection TO Faucet Supply Hose ................................................................................... 5
Mount the Filtration System .................................................................................................................. 6
Connect the Blue Tube to the Filtration System ................................................................................... 6
Start-up Instructions ............................................................................................................................. 6
Changing The Filter Cartridge .............................................................................................................. 7
Performance Data Sheet ...................................................................................................................... 8
Warranty Registration ...................................................................................................................... 9-10
Removing chlorine from your shower ...................................................................................................11
Limited Warranty ................................................................................................................................ 12
Service Record
Filter Replacement Date
System Information
Model Number: _____________
Serial Number: _____________
Date of Purchase: _____________
Date of Install: _____________
Installed by: _____________
3
Page 4
Operational Parameters
Installation must comply with state and local plumbing regulations.
Water supply line to the system must be from the cold water supply line.
Operating Temperatures:
Operating Pressure:
Flow Rate:
Maximum 100°F (37.8°C) Minimum 40°F (4.4°C)
Maximum 100 psi (689 kpa) Minimum 25 psi (172 kpa)
1.5 GPM @ 60 psi
Contents of Under Counter System
√ 1 UC1-HC Unit √ 1 Parts Bag
If any of the items are missing, please contact Premier prior to installing.
Tools Recommended For Installation
√ Phillips bit for electric drill √ Sharp Knife or Scisors
√ 1/2" Open End Wrench √ Electric Drill
Part Number List / Flow Diagram
Counter Top
UC1-HC
Blue
Tubing
COLD
Blue
Tubing
Item Part # Description
1 231026 3/8” BRASS INSERT
2 231020 3/8” DELRIN SLEEVE
3 231002 3/8” BRASS NUT
4 140012 3/8” BLUE TUBING
5 125159 3/8” QC UNION
6 225008 3/8” QC STEM ADAPTER
7 137084 SYSTEM BRACKET
8 304132 SYSTEM LID
9 500168 15” HC CARBON FILTER
4
Page 5
Blue Tube Connection To Cold Water Angle Stop Valve
Caution:
Water supply line to the system must be from the cold water supply line only.
Hot water will severely damage your system.
Verify contents prior to installation:
( 1 ) - Brass Nut ( 1 ) - Plastic Delrin Sleeve ( 1 ) - 3/8” x 3/8” QC Union
( 1 ) - Brass Insert ( 1 ) - 3/8” Blue Tube ( 1 ) - 3/8” QC Stem Adapter
Step 1
Step 2
Step 3 Locate the blue 3/8” tube in the parts bag. Remove a brass
Turn off the cold water supply to the faucet by turning the angle stop valve completely off.
Open cold water sink faucet to relieve pressure.
Place a small container under the cold water angle stop valve to catch any runoff water.
Disconnect the cold water faucet supply hose from the cold water angle stop valve.
nut, plastic delrin sleeve and brass insert from the parts bag.
To assemble, place the brass nut on the blue tube rst (Open
end out), then the sleeve and then push the brass insert all
the way into the end of the tube. (See Picture)
Do not use Teon tape.WARNING:
Step 4
Insert the assembled blue tube into the open tting of the
cold water angle stop valve and use an adjustable wrench
to tighten the brass nut securely.
Blue Tube Connection To Faucet Supply Hose
Step 5 Locate the threaded 3/8” male stem adapter tting in the parts
bag. Thread the stem adapter on to the supply hose attached
to the faucet and tighten with an adjustable wrench.
Step 6
Locate the 3/8”x3/8” Quick Connect union in the parts bag.
Push the union on to the 3/8” stem adapter tting attached
to the faucet hose until fully seated.
Faucet Supply
Hose
3/8” Adapter
3/8” Union
Step 7 Connect the open end of the 3/8” blue tube to the open end
of the 3/8”x3/8” Quick connect union tting by pushing the
tube into the adapter until fully seated.
3/8” Blue Tube
5
Page 6
Mount the Filtration System
Step 8 Determine best location for the ltration system to be mounted and
spliced into the 3/8” blue tubing. Using the mounting holes on the
bracket, mark the location for the mounting screws on the cabinet
wall under the sink (Make sure to leave enough room to remove
the lter during lter changes, approximately 2” below lter). In the
parts bag, locate the two self tapping screws. Using an electric
drill with a Phillips bit, screw them into the cabinet at the marked
location. Hang the system on the screws using the mounting holes
in the bracket
Connect the Blue Tube to the Filtration System
Step 9
Step 10
After mounting the system, determine where and cut the 3/8” blue
tubing into two parts in order to connect it to the ltration system.
Connect the 3/8” blue tube coming from the angle stop valve into
the left side of the ltration system (IN), by pushing the tubing rmly
into the quick connect tting. Connect the 3/8” blue tube coming
from the faucet supply hose into the right side of the ltration system
(OUT), by pushing the tubing rmly into the quick connect tting.
IN OUT
Congratulations!
You have completed the installation of your new water ltration system.
Please Follow the Startup Instructions.
Start up Instructions
Step 1
Step 2
Turn on water supply at cold water angle stop. Turn cold water faucet handle to the open
position to start the ow of water through the unit. Run 5 gallons of water through the unit in
order to ush out the normal black carbon nes (it will “sputter” until the air is purged out) from
the unit. Initially, the water may appear cloudy which is due to tiny air bubbles and it will clear
up shortly. Close the faucet when nished.
Check for leaks. If you have any leaks, shut off the water supply to your system, tighten
any ttings and restart unit.
(Check frequently over the next 24 hours to ensure no leaks are present)
6
Page 7
Filter Change
Premier recommends changing the lter element once every 1 year. However lter life may
vary depending on local water conditions and water use.
Use Premier’s replacement cartridge only. Other lters may look the same, but only lters
by Premier are manufactured to t your UC1-HC lter unit in order to ensure proper reduction
of water contaminants.
Carbon Block Cyst Filter:
Part# 500168
(A) Turn off incoming water supply to the ltration unit.
(B) Open the cold water faucet handle to relieve the
water pressure.
(B) Remove lter from lid by turning it to the left, then pulling
the lter down out of the lid. Discard of old lter.
(C) Remove plastic wrapping and cap from new lter.
(D) To install new lter cartridge, with the lter label facing
approximately 45 degrees to the left, push the lter into
the lid and twist it to the right until the lter locks in and
the label on lter is facing the front.
(H) Follow start-up procedure on page 6.
To Loosen To Tighten
7
Page 8
Performance Data Sheet
Premier Inc.
8716 W Ludlow Drive Suite #1
Peoria, AZ 85381
UC1-HC
GENERAL USE CONDITIONS:
1: System to be used with municipal or well water sources treated and tested on regular basis to insure
bacteriological safe quality. DO NOT use with water that is micro biologically unsafe or of unknown quality
without adequate disinfection before or after the system. Systems certied for cyst reduction may be used on
disinfected waters that may contain lterable cysts.
2: Operating Temperature: Maximum 100o F (38o C) Minimum 40o F (4.4o C)
3: Operating Water Pressure: Maximum 100-psi (689kpa) Minimum 25-psi (172kpa)
4: Maximum ow Rate: 1.5 gpm (5.7 lpm)
5: Rated Capacity (Chlorine): 10000 Gallons (37,854 liters)
RECOMMENDED REPLACEMENT PARTS AND CHANGE INTERVAL:
Note: Depending on incoming feed water conditions replacement time frame may vary.
Description Part Number Change time Frame
UC1-HC 303016 12 Months or 10000 gallons of water
California Proposition 65 Warning
WARNING: this product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. (Installer:
California law requires that this warning be given to the consumer). For more information: www.wattsind.com/prop65
8
Page 9
WARRANTY REGISTRATION
Thank you for selecting Premier for your water ltration needs.
4 Ways to Register
1. On-line at www.PremierH2o.com
Register your product on-line and receive a 5% discount on your next on-line order, Plus receive reduced shipping.
2. Call in your information 1-800-752-5582
Call and we will enter your registration information for you.
3. Fax in your information 623-866-5666
Fax this form directly to us.
Registering will
insure you
receive Premier
FREE
4. Mail in the information.
Please complete the form below. Mail to: Premier
8716 W Ludlow Drive Suite #1
Peoria, AZ 85381
Premier Inc. is concerned for the safety of your personal information. Premier collects personal information when you register with Premier.
This information is stored in our data base and we do not rent, sell, or share personal information with other people or nonafliated companies. We reserve the right to send you certain types of communications such as direct mail, email, or by telephone relating to our products
or products that you have purchased. We limit access to your personal information to those employees who will directly provide you with
services or products in order to do their jobs. We want to offer you four ways to communicate with us. 1.Online, 2.Fax, 3.Telephone, and
4. Mail the form below. By registering your product you will receive the full benet of our warranty. Premier will also send you a semiannual
lter change reminder beginning six months from date of installation. To insure the highest quality of your water, lters should be replaced
every 6 months. If you have any questions or comments please give us a call at 1-800-752-5582 M-F 8:00am -5:00pm MST.
First Name:_________________________ Last Name:____________________________
Address: ________________________________________ City: ____________________
Filter
Reminder
Notice
State: _______________________________________ Zip Code: ___________________
Country: USA CANADA MEXICO OTHER ____________
Phone # ______-__________ -__________ Email Address: ______________________
Date of Purchase: ___________________ Date of Install: _______________________
Installed By: SELF Plumbing Professional Where Purchased: ____________
Model Number: _______________________ Serial Number: ____ - __________
Premier, Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
Phone: 800-752-5582 www.PremierH2o.com Fax: 623-866-5666
XXXXX
9
XXXXXX
-
Page 10
WARRANTY REGISTRATION
Please Fill out and keep for your Records
First Name:_________________________ Last Name:____________________________
Address: ________________________________________ City: ____________________
State: _______________________________________ Zip Code: ___________________
Country: USA CANADA MEXICO OTHER ____________
Phone # ______-__________ -__________ Email Address: ______________________
Date of Purchase: ___________________ Date of Install: _______________________
Installed By: SELF Plumbing Professional Where Purchased: ____________
Model Number: _______________________ Serial Number: ____ - __________
XXXXXX
XXXXX
-
Iowa Department of Public Health - Sales in Iowa require this to be completed, signed and returned.
These signatures will be retained on le for two years.
Insert into envelope and return to Premier
Premier
8716 W Ludlow Drive Suite #1
Peoria, AZ 85381
10
Page 11
Removing chlorine from your shower
Special Chlorgon & KDF media – More effective then carbon medias with
hot water applications in the removal of the following.
√ Free Chlorine (CL-)
√ Combined Chlorine (Sodium Hypochlorite)
√ Hydrogen Sulde (Rotten egg smell)
√ Plus, its pH balanced.
Deluxe Shower Handle with Built in Filter Replacement lters 2PK
5-Way Massaging Spray
72” Reinforced Hose
High Strength Bracket
Triple Plated Finish
Reversible Filter Cartridge (Model HHC)
Cartridge Life Rating: 3 months
Part No. 107070 WHITE *$38.95
Part No. 107091 CHROME *$44.95
Part No. 107092 GOLD *$44.95
Shower Falls Deluxe Shower Handle with Built in Filter
Curved Ergonomic Shower Handle Replacement lters 2PK
Filter Handle Extension
Dual Swivel Adjustment
Ultra Deluxe 5 Way Massaging Spray
72” Reinforced Hose
Chrome Plated Brass Bracket & Swivel Ball Extension
Triple Plated Finish
Reversible Filter Cartridge (Model HHC)
Cartridge Life Rating: 3 months
Part No. 107095 CHROME *$55.95
√ Iron oxide (rust water)
√ Dirt, sediment
√ Odors
Part No. 107075 *$15.95/pk
Part No. 107075 *$15.95/pk
All-In-One reversible High-Flow Filter Replacement lter
Deluxe 5-Way Massaging Spray
Soft-Touch Adjustment Pads
Anti-Scaling Spray Nozzle
High Strength Housing
Triple Plated Finish
Cartridge Life Rating: 6 months
Part No. 107098 White/Chrome *$39.95 Part No. 107080 *$13.95/ea
*All prices subject to change without notice.
11
Page 12
8716 W Ludlow Drive Suite #1 Peoria, AZ 85381
Limited Warranty
What your Warranty Covers:
If any part of your Premier UC1-HC is defective in workmanship (excluding replaceable lters ), return unit after obtaining
a return authorization (see below), within 3 years of original retail purchase, Premier will repair or, at Premier’s option,
replace the system at no charge.
How to obtain Warranty Service:
For warranty service, call 1-800-752-5582 for a return authorization number. Then, ship your unit to our factory, freight and
insurance prepaid, with proof of date of original purchase. Please include a note stating the problem. Premier will repair it,
or replace it, and ship it back to you prepaid.
What this warranty does not cover:
This warranty does not cover defects resulting from improper installation, (contrary to Premier’S printed instructions),
from abuse, misuse, misapplication, improper maintenance, neglect, alteration, accidents, casualties, re, ood, freezing,
environmental factors, water pressure spikes or other such acts of God.
This warranty will be void if defects occur due to failure to observe the following conditions:
1. The UC1-HC System must be hooked up to a potable municipal or well cold water supply.
2. The pH of the water must not be lower than 5 or higher than 10.
3. The incoming water pressure must be between 25 and 100 pounds per square inch.
4. Incoming water to the Counter Top cannot exceed 100 degrees F (38 degrees C.)
This warranty does not cover any equipment that is relocated from the site of its original installation.
This warranty doe not cover any charges incurred due to professional installation.
This warranty does not cover any equipment that is installed or used outside the United States of America and Canada.
LIMITATIONS AND EXCLUSIONS:
Premier WILL NOT BE RESPONSIBLE FOR ANY IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND
FITNESS FOR A PARTICULAR PURPOSE. Premier WILL NOT BE RESPONSIBLE FOR ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES, INCLUDING TRAVEL EXPENSE, TELEPHONE CHARGES, LOSS OF REVENUE, LOSS OF TIME, INCONVENIENCE,
LOSS OF USE OF THE EQUIPMENT, AND DAMAGE CAUSED BY THIS EQUIPMENT AND ITS FAILURE TO FUNCTION PROPERLY.
THIS WARRANTY SETS FORTH ALL OF PREMIER’S RESPONSIBILITIES REGARDING THIS EQUIPMENT.
OTHER CONDITIONS:
If Premier PREMIER chooses to replace the equipment, Premier may replace it with reconditioned equipment. Parts used in repairing or
replacing the equipment will be warranted for 90 days from the date the equipment is returned to you or for the remainder of the original
warranty period, whichever is longer. This warranty is not assignable or transferable.
YOUR RIGHTS UNDER STATE LAW:
Some states do not allow limitations on how long an implied warranty lasts, and some states do not allow the exclusion or limitation of
incidental or consequential damages, so the above limitations or exclusions may not apply. This warranty gives you specic legal rights,
and you may have other legal rights which vary from state to state.
Loading...