Page 1
POWER AMPLIFIER
XP 600/1000XP 600/1000
Page 2
POWER AMPLIFIER
XP600/1000XP600/1000
PANEL LAYOUT.............................................................3
SYSTEM BLOCK DIAGRAM...........................................5
PCB
POWER AMPLIFIER PCB...............................................6
POWER SUPPLY PCB.....................................................7
MODE & POWER ON DISPLAY PCB................................8
INPUT PCB.....................................................................9
SPEAKON OUTPUT PCB...............................................11
LEVEL & STATUS DISPLAY.............................................12
SCHEMATICS
POWER AMPLIFIER SCHEMATIC..................................14
POWER SUPPLY SCHEMATIC.......................................16
INPUT & CONTROL DISPLAY SCHEMATICS
....................17
PART LIST
POWER AMPLIFIER PCB-PART LIST................................18
POWER SUPPLY PCB-PART LIST......................................22
MISCELLAN OUS ITEMS
POWER REQUIREME T CLASSIFICATION
N .......................29
DIME SIONS
N .....................................................................33
E ..................................................26
Phonic reserves the right to improve or alter any information supplied within this
document without prior notice.
V2.1
09/05/02
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 2
Page 3
PANEL LAYOUT
2
CLIP/LIMITCLIP/LIMIT
CLIP/LIMITCLIP/LIMIT
PROTECTPROTECT
CLIPCLIP
PROTECTPROTECT
-6
-6
0
0
-14
-14
-16
-16
-32
-32
LED:100-00110-000-0 RED
LED:100-00150-020-0 GRN
LED:100-00240-020-0 YLW
POWER
-6
POWER SW
210-03101-070-0
-6
0
-14
-14
-16
-16
-32
-32
-10 -10-10 -10-10 -10-10 -10
-20 -20-20 -20-20 -20-20 -20
-40 -40-40 -40-40 -40-40 -40
-10 -10-10 -10-10 -10-10 -10
-20 -20-20 -20-20 -20-20 -20
-40 -40-40 -40-40 -40-40 -40
CLIP
PROTECT
PROTECT
CLIP/LIMIT
CLIP/LIMITCLIP/LIMIT
PROTECTPROTECT
CLIPCLIP
PROTECTPROTECT
PROTECTPROTECT
CLIPCLIP
PROTECTPROTECT
-6
-6
0
0
-14
-14
-16
-16
-32
-32
POWER
POWER
-6 -6
-6 -6
-6
-6
0 0
0 0
0
-14 -14
-14 -14
-14
-14
-16 -16
-16 -16
-16
-16
-32 -32
-32 -32
-32
-32
-10 -10-10 -10-10 -10-10 -10
-20 -20-20 -20-20 -20-20 -20
-40 -40-40 -40-40 -40-40 -40
-10 -10-10 -10-10 -10-10 -10
-20 -20-20 -20-20 -20-20 -20
-40 -40-40 -40-40 -40-40 -40
-10 -10-10 -10-10 -10-10 -10
-20 -20-20 -20-20 -20-20 -20
-40 -40-40 -40-40 -40-40 -40
-10 -10-10 -10-10 -10-10 -10
-20 -20-20 -20-20 -20-20 -20
-40 -40-40 -40-40 -40-40 -40
CLIP
CLIP
PROTECT
PROTECT
PROTECT
PROTECT
CLIP/LIMIT
CLIP/LIMIT
CLIP/LIMIT
100-00010-030-0
PROTECT
100-00040-020-0
LED
100-00050-020-0
KNOB:540-20390-120-0
POT:023-50230-040-0
LED
100-00050-020-0
1
CLIP/LIMIT
100-00010-030-0
PROTECT
100-00040-020-0
XP 600/1000 (FRONT)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 4Page 3
Page 4
PANEL LAYOUT
12
3
FAN NET
528-00000-000-0
FAN
247-00000-201-0
STEREO
PARALLEL
BRIDGE
BEFORE ADJUSTING!
TURN OFF AMPLIFIER
XLR JACK
211-03300-160-0
CH 1
CAUTION :
OFF
30Hz
50Hz
TIP
SLV
1 / 4"1 / 4"
RNG
INPUT
1/4" JACK
211-01602-560-0
MODE
XLRXLR
PIN 2PIN 2
PIN 3PIN 3
PIN 1PIN 1
LIMITER HPF
ON OFF
FLOATING
GROUNDING
SLD SW:
210-60001-000-0
CH 2
XLR JACK
211-03300-160-0
BINDING POST
211-17000-410-0
PIN OUT
MONO
BRIDGE
OUTPUT
NE PAS OUVRIR
CAUTION
AVIS: RISQUE DE CHOC ELECTRIQUE
SPEAKON JACK
211-03400-021-0
CH 2 CH 1
GND
610-10002-130-0
US
D
E
T
S
I
L
~ 100 VAC 60Hz
WARNING!
TO REDUCE THE RISK
OF FIRE OR ELECTRIC
SHOCK DO NOT EXPOSE
THIS EQUIPMENT TO
~ 120 VAC 60Hz
RAIN OR MOISTURE.
119301
~ 230 VAC 50Hz
~ 240 VAC 50Hz
C
US
R R
D
E
T
S
I
L
C
CONFORMS TO ANSI/UL STD-813
CERTIFIED TO CSA STD. C22.2 NO.1
POWER CORD
370-08810-702-0
XP 600/1000 (REAR)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 4Page 4
Page 5
SYSTEM BLOCK DIAGRAM
SYSTEM BLOCK DIAGRAM
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 5
Page 6
POWER AMPLIFIER PCB
POWER AMPLIFIER PCB
-+
R222
D203
D204
ZD203
R335
Q313
CN14
PGND
PROT
FAN
C302
C314
C203
C204
R302
C313
R301
C214
R225
Q207
B C E
C213
Q301
R224
R218
NTC4
JP16
BCE
Q206
R248
E C B
A
Q222
A
A
R254
R249
E C B
A
Q223
A
A
R255
R250
E C B
A
Q224
A
A
R256
D D
D222
Q228
GDS
AAA
CN10
-15V
+15V
SIGN
LIM
R209
R210
D202
R211
R221
R220
C212
B CE
R223
Q233
C222
C221
C220
+
SPK-O
R202
C206
R306
R308
R307
Q204
A
C211
B CE
B C E
Q205
R219
R216
R217
B
B
SVR201
B
B
C231
B
R247
R264
D210
R265
Q232
B CE
R266
B CE
C229
R267
R268
D209
A
D211
D214
A
ZD206
C219
C230
C223
R269
ZD205
D208
R272
D
C224
D
-65V
PGND
VAC
V+
R260
C310
D306
Q229
CN15
TMP1
B C E
A
R261
R316
A
GDS
A
R334
D304
R319
C316
R327
Q311
Q310
R333
B C E
R338
R332
Q314
ZD302
B C E
B C E
R318
R317
C306
R321
C305 C304
R328
4 3
5
6
B
A
L301
D302
A
R201
PIII1000/600_AMP.PCB
290-34610-100-0 REV A
IC201
C201
C202
Q201
C208
A
B CE
ZD201
ZD202
B C E
Q202
R203
R205
R206
R208
D201
R212
B
B
C209
R281
C210
R240
R278
D207
R279
Q214
R276
B CE
R277
R275
D219
D220
R274
ZD207
+
B C E
PGND
D215
R273
C218
R270
Q221
R271
D D
D216
CN9
-100V
+100V
D305
A
C225
C227
+65V
RA2
2
R330
ZD301
1
B
B C E
R331
C205
C207
R204
Q302
BCE
R305
R304
R303
R207
C301
B C E
R213
C228
R280
R214
B CE
C217
Q209
R229
D206
D205
ZD204
R226
C215
Q208
C216
Q203
BCE
R227
R215
R228
R234
A A A A A A AAA
Q215
ECB
R241
R235
Q216
A
C226
ECB
R242
R236
Q217
ECB
R243
D
G D S
D221
987654321
B C E
Q306
C315
Q308
B C E
R342
C309
Q312
BCE
C312
B C E
Q307
-15V
+15V
Q210
AA
A
R230
D
G D S
A
Q211
A
R341
R340
A
R231
Q316
BCE
D303
R329
R326
R325
R320
C308
B C E
R336
R337
Q315
C307
R324
R323
R322
R339
Q309
C311
CN6
AGND
OP_O
P_IN
AGND
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 6
Page 7
POWER SUPPLY PCB
POWER SUPPLY PCB
IC2
R3
R1
Q2
PIII1000/600
POWER_C.PCB REV_A
290-34610-203-0
CAUTION:
TO REDUCE THE RISK OF FIRE
BEPLACE ONLY WITH SAME TYPE FUSE
ATTENTION:
UTILISER UN FUSIBLE
DE RECHANGE DE MENE TYPE
RA1
R2
D1
BCE
BCE
Q1
+
C9
+
C10
+
~
BD3
/\
AC1
P3
TR1_115
P8
TR2_115
P7
NTC1
TR1_115
P10
NTC3 NTC2
TR2_0
P9
TR1_0
P6
P5
C1
TR2_0
~
-
P/SW
P2
C12
SW1
R137
R143
R144
JP8
SW2
R146
C119
C108
JP5
JP4
+
SPK GND L
SPK GND R
SW3
CN1
CN2
R116
C4
R4
+
C5
JP9A
JP9B
2.-80V
1.+80V
6.PGND
5.-50V
4.+50V
3.PGND
SW4
C11
D3
D2
C7
-
BD2
R5
8.V+
7.VAC
T1
BLK
YLW
BLU
YLW
+
R6 R7
+
BLU
GI O
C8
+
IC1
LM7815
G I O
LM7915
C2
-
BD1
WIT
BWN
WIT
+
F2
T2A 250V
T2A 250V
F1
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 7
Page 8
MODE & POWER ON DISPLAY PCB
MODE & POWER ON DISPLAY PCB
CN8
LED11
R145
LED8 LED10LED9
R145A
LED7LED6LED5LED4LED3
R145B
LED2LED1
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 8
Page 9
INPUT PCB (FRONT )
INPUT PCB (FRONT )
~
+
2 3
JP1
REV A
JK3AJK3 JK2A JK2
290-34610-301-0
2 3
-
JP6
~
4
D101
C111
+
1
LED101
CDS1
C145
C109
JP2
C120
4
CDS2
LED102
+
1
PHONIC CORPORATION
C122
PIII1K INPUT_D.PCB
R153
~
+
XP 600/1000 SERVICE MANUAL
-
JP7
~
D102
Page 4Page 9
Page 10
INPUT PCB (REAR )
R120
R121
R119
INPUT PCB (REAR)
R101
R107
R104
C102
R106
C101
R105
R102
IC2
R103
C106
R112
R111
C107
R113
C103
C104
R110
R109
R108
C105
R114
R115
C110
R118
R139
C121
R117
IC3
R138
C146
R140
R141
R142
R153
IC3
R134
R132
R133
C118
C117
R135
R136
R124
R128
C113
R125
C114
R131
R122
C115
R129
R130
C116
R123
C112
R127
R126
IC4
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 10
Page 11
SPEAKON OUTPUT PCB
SPEAKON OUTPUT PCB
A2
A1
2+
2+
1-
1+
2-
JK4
A3
A4
JK5
1-
1+
2-
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 11
Page 12
LEVEL & STATUS DISPLAY PCB ( FRONT)
R312B
Q303B
R313B
BCE
R314B
Q305B
Q304B
BC
BCE
E
LED305B
LED301B
LEVEL & STATUS DISPLAY PCB ( FRONT)
LED304B
LED303B
LED302B
PCB_E
VR2
JP10B
CN5
JP10A
BCE
BCE
R314A
R313A
Q303A
R312A
Q304A
BCE
LED301A
Q305A
LED305A
CN4
LED302A
LED303A
LED304A
VR1
PCB_F
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 12
Page 13
LEVEL & STATUS DISPLAY PCB( REAR)
LEVEL & STATUS DISPLAY PCB( REAR)
R311A
R310A
R344A
R309A
R343A
R311B
R343B
R310B
R345A
R344B
R345B
R309B
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 13
Page 14
POWER AMPLIFIER SCHEMATIC ( 2-1)
POWER AMPLIFIER SCHEMATIC (2-1)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 4Page 14
Page 15
POWER AMPLIFIER SCHEMATIC (2-2)
POWER AMPLIFIER SCHEMATIC (2-2)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 15
Page 16
POWER SUPPLY SCHEMATIC
POWER SUPPLY SCHEMATIC
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 16
Page 17
INPUT & CONTROL DISPLAY SCHEMATICS
INPUT & CONTROL DISPLAY SCHEMATICS
INPUT
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
MODE & POWER ON DISPLAY
Page 17
Page 18
Re f. Phonic Part No. Description
210-10090-001-0 TMP/SW US-602SXRFQC
212-10023-440-0 2P WAFER/P 100MM
526-20551-010-0 HEAT SINK XP600/1000
552-20063-400-0 TRAN. FIXED XP600/1000
66*26*1.9MM
552-20064-400-0 FET FIXED XP600/1000
37*20*1.9MM
290-34610-101-0 PCB XP600/1000 A+B AMP
C201.203.210 030-10656-0A0-0 E/C 10MF M 50V 5*11 T
C202.204 042-47325-050-0 C/C2 0.047MF K 50V 5 T
C205 032-10636-0A0-0 NP E/C 10MF M 25V 6.3*11 T
C206 042-33024-050-0 C/C2 33PF J 50V 5 T
C207.209.225 042-10225-050-0 C/C2 0.001MF K 50V 5 T
C212.217 030-47695-000-0 E/C 47MF K 160V P
C213.216 042-47164-050-0 C/C2 470PF J 350V 5 T
C214.215 042-10345-160-6 C/C2 0.01UF K 100V T
C218 042-56224-050-0 C/C2 0.0056MF J 50V T
C219.226.308 030-10728-0A0-0 E/C 100MF Z 16V 6*11 T
C220.221 042-10124-050-0 C/C2 100PF J 50V T
C222 042-03020-000-0 C/C2 3PF C 50V 5
C223.224.227.230 042-104A8-000-0 C/C2 0.1MF Z 250V 5
C228 042-391A4-050-0 C/C2 390PF J 250V 5 T
C229 042-201A5-000-0 C/C2 200PF K 250V
C231.315.316 042-10426-050-0 C/C2 0.1MF M 50V 5 T
C301 030-10638-0A0-0 E/C 10MF Z 25V 5*11 T
C302 032-22586-0A0-0 NP E/C 2.2MF M 100V 6*11 T
C304.305 046-10414-060-0 M/C 0.1MF J 100V 5 T
C306 030-22728-0A0-0 E/C 220MF Z 16V 8*11 T
C307 042-47124-050-0 C/C2 470PF J 50V 5 T
C309 030-10558-0A0-0 E/C 1MF Z 50V 5*11 T
C310.311.312 030-22638-0A0-0 E/C 22MF Z 25V 5*11 T
C313.314 030-47638-0A0-0 E/C 47MF Z 25V 6.3*11 T
CN14 211-10021-150-0 2P WAFER/S 5267 A2505 WV
P=2.5MM 180GEGREE
CN15
211-10021-161-0 2P WAFER/S TJC3-2A
P=2.5MM 180GEGREE
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
Page 4Page 18
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 19
Re f. Phonic Part No. Desc ription
CN6.10 211-10061-171-0 6P WAFER/S TJC3-6A
P=2.5mm
CN9 211-10093-000-0 9P WAFER/S 3.96MM
D201.202.203.206.303.3
04
090-02000-020-0 DIODE 1N4148 T
D204.205.302.305.306 090-00007-020-0 DIODE IN4004 SILTEK T
D207-210.219.220 090-02004-000-0 DIODE 1N4935 T
D211.216 090-02007-000-0 DIODE FR602
D214.215.221.222 090-00016-000-0 DIODE 1N5404
FIX IC1.2 313-00000-000-0 TRANSISTOR WASHER
TO-220
HEAT
SINK&TRANSISTOR
610-00300-501-0 PLA. WAS. D3.0*D7.0*0.5 NI
IC201 160-00021-900-0 IC NJM5534D JRC
L301 075-10082-100-0 INDUCTANCE 1UH K M
NTC4 011-10020-001-0 THERMISTER NSA05C3 10-301
Q201 120-00001-400-0 TRAN. 2N5551 MOTOROLA
Q202.316 121-00006-100-0 TRAN MJE350 MOTOROLA
Q203.301 120-00008-800-0 TRAN MJE802 MOTOROLA
Q204.214.232.233 121-00000-300-0 TRAN. 2N5401 MOTOROLA
Q205.221 120-00005-000-0 TRAN MJE340 MOTOROLA
Q206 121-00007-200-0 TRAN 2SA1837-M TOSHIBA
Q207 121-00007-500-0 TRAN. BC556B PHILIPS
(BC560)
Q208 120-00009-700-0 TRAN. BC546B PHILIPS
(BC550)
Q209 120-00009-500-0 TRAN 2SC4793-M TOSHIBA
Q210.228 122-00002-500-0 MOSFET IRFP250
Q210.228 313-00010-000-0 WASHER TO-3P
Q215.216.217 120-00008-600-0 TRAN 2SC5200-O
TOSHIBA(XP1000)
Q215.217 120-00008-600-0 TRAN 2SC5200-O
TOSHIBA(XP600)
Q222.224 121-00006-000-0 TRAN 2SA1943-O TOSHIBA
Q302.306.308.309.310.3
12.314.315
120-00000-800-0 TRAN. 2SC1815 GR
TOSHIBA
Q307.311.313 121-00000-200-0 TRAN. 2SA1015 GR
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 19
Page 20
Re f. Phonic Part No. Desc ription
R201 006-49912-420-0 MF RES. 4K99 F 0.25W M
R202 006-51022-420-0 MF RES. 51K F 0.25W T
R203.204.212.216.217.2
19.279.306
006-10012-420-0 MF RES. 1K F 0.25W M
R205.206.317.318 006-39012-420-0 MF RES. 3K9 F 0.25W M
R207.234.236.254.256 006-10072-420-0 MF RES. 10F 0.25W M
R208.211.265.267.276.32
4.331.332.339
006-10022-420-0 MF RES. 10K F 0.25W M
R209.210.303.333 006-68022-420-0 MF RES. 68K F 0.25W M
R213.214.220.221.305.3
26.338
006-10002-420-0 MF RES. 100 F 0.25W M
R215.218 006-47083-420-0 MF RES. 4.7 F 0.5W M
R222.229.307.323.335 006-22012-420-0 MF RES. 2K2 F 0.25W M
R223 006-62012-440-0 MF RES. 6K2 F 0.25W T
(XP600)
R223.228 006-27012-400-0 MF RES. 2K7 J 0.25W T
R224.227 006-30012-440-0 MF RES. 3K F 0.25W T
R225.226 006-20022-420-0 MF RES. 20K F 0.25W M
R228 006-56012-400-0 MFRES. 5K6 F 0.25W T(XP600)
R230.264.260.277.278 006-51072-420-0 MF RES. 51F 0.25W M
R240.247 006-10003-420-0 MF RES. 100F 0.5W M
R241.243.248.250 003-22093-602-0 CEMENT RES. 0.22 J 5W
R266 006-33002-420-0 MF RES. 330 F 0.25W M
R268.342 006-33022-420-0 MF RES. 33K F 0.25W M
R269.280 006-15023-420-0 MF RES. 15K F 0.5W M
R270 006-82012-440-0 MF RES. 8K2 F 0.25W T
R271 006-47012-420-0 MF RES. 4K7 F 0.25W M
R272 006-27023-420-0 MF RES.27K F 0.5W M
R273 006-30022-420-0 MF RES. 30K F 0.25W M
R274 006-18022-420-0 MF RES. 18K F 0.25W M
R275 006-27032-420-0 MF RES. 270K F 0.25W M
R281 003-10071-602-0 CEMENT RES. 10 J 2W P
R301 006-75002-420-0 MF RES. 750 F 0.25W M
R304 006-27022-420-0 MF RES. 27K F 0.25W M
R308.327.334 006-10032-420-0 MF RES. 100K F 0.25W M
R316 003-22071-601-0 CEMENT RES. 22 J 2W
R319 006-68012-420-0 MF RES. 6K8 F 0.25W M
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 4Page 20
Page 21
Re f. Phonic Part No. Desc ription
R320.321.322 006-22032-420-0 MF RES. 220K F 0.25W M
R325.336.337.340 006-22022-420-0 MF RES. 22K F 0.25W M
R328 006-33012-410-0 MF RES. 3K3 F 0.25W P
R329 006-56022-420-0 MF RES. 56K F 0.25W M
R330 006-12022-420-0 MF RES. 12K F 0.25W M
R341 006-15012-420-0 MF RES. 1K5 F 0.25W M
RA2 076-02421-000-0 RELAY JC2AF-DC24V
MATSUSHITA
SVR201 020-47171-000-6 T/VR 470 0.5W 3U 10 -1-25
THERMAL SW*2 590-43008-100-0 M/E PAN SCR. M3.0*8 NI
THERMAL SW*5 590-43012-100-0 M/E PAN SCR. M3.0*12 NI
TRANSISTOR*6 590-43014-100-0 M/E PAN SCR M3.0*14 NI
TRERMAL RES.*1 610-60300-501-0 PAN SPR. WAS D3.0*D7*0.5 NI
ZD201.202 090-01752-010-0 ZEN/DIODE 7V5 K 0.5W
FAIRCH
ZD203.204.205.301.302 090-01682-000-0 ZEN/DIODE 6.8V J0.5W
UNIZO(XP1000)
ZD203.204.301 090-01682-000-0 ZEN/DIODE 6.8V J0.5W
UNIZO(XP600)
ZD205 382-20010-010-0 TINNER WIRE 10MM D0.6
(XP600)
ZD206 090-01103-010-0 Z/DIODE 10V K 0.5W FAIRC
ZD207 090-01153-010-0 Z/DIODE 15V K 0.5W
UNIZON
ZD302 090-01472-000-0 Z/DIODE 4.7V J 0.5W FAIRC
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
Page 16
PHONIC CORPORATION
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 21
Page 22
Re f. Phonic Part No. Desc ription
281-00000-010-0 FUSE CLIP FH-1208
(XP1000)
313-00000-060-0 RUBBER WASHER TO-2203
314-00000-050-0 BUSHES 602S(V.0)
180GEGREE
526-20040-010-0 HEAT.SINK POD1860 20*18
590-53010-100-0 M/E SET SCR. M3.0*10 NI
600-00302-010-0 HEX. NUT M3.0*2.0 NI
610-60300-700-0 PAN SPR WAS.
D3.0*6.0*0.7ZN
290-34610-202-0 PCB XP600/1000 C+G
PWR+LED
615-20104-620-0 LED HOLDER 3LED-3
290-34610-301-0 XP600/1000 D+E+F PCB
A1 212-10010-690-0 1P WAFER/P 80MM BWN
A2 212-10010-680-0 1P WAFER/P 80MM
UL1015#14 BLK
A3 212-10010-720-0 1P WAFER/P 80MM
UL1015#14 RED
A4 212-10010-730-0 1P WAFER/P 80MM
UL1015#14 ORANGE
BD1.2 090-10016-000-0 B/DIODE KBPC5006
BD3 090-10000-000-0 B/DIODE PB154
C1 058-68325-100-0 MEX-683K 0.068MF/250V
18*13.5 P=15
C101.102.112.113 039-22024-220-0 CHIP C/C 22PF J 50V 0603
C103.104.105.114.115.11
6
039-33435-220-0 CHIP. C/C 0.33MF 10V K 0603
C106.107.117.118 039-10405-220-0 CHIP C/C 0.1UF K 16V 0603
C108.119 030-22628-0A0-0 E/C 22MF Z 16V 5*11 T
C109.120 030-22628-000-0 E/C 22MF Z 16V 5*11 P
C11.12 030-10656-0A0-0 E/C 10MF M 50V 5*11 T
C110.121 039-33024-220-0 CHIP C/C 33PF J 50V 0603
C111.122 030-47628-0A0-0 E/C 47MF Z 16V 5*11 T
C145 030-10484-000-0 E/C 0.1MF J 100V 5
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
PHONIC CORPORATION
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 4Page 22
Page 23
Re f. Phonic Part No. Desc ription
C146 039-10324-220-0 CHIP C/C 0.01MF J 50V 0603
C2 030-47558-0A0-0 E/C 4.7MF Z 50V 5*11 T
(XP1000)
C4.5 030-47878-000-0 E/C 4700MF Z 80V 31*35 P
(XP600)
C4.5 030-47888-030-0 E/C 4700MF Z 100V 35*52 P
(XP1000)
C7.8 030-33866-030-0 E/C 3300UF M 63V 25*30 P
(XP600)
C7.8 030-33876-000-0 E/C 3300MF M 80V 30*31 P
(XP1000)
C9.10 030-22848-002-0 E/C 2200MF Z 35V 16*27 P
CDS1.2 010-00001-010-0 CDS P873-G35-552
HAMAMATSU
CN1 211-09142-000-0 14P B.E./S 180GEGREE
CN2 211-09202-000-0 20P B.E./S 180GEGREE
CN4.5 211-10031-170-0 3P WAFER/S 2532-03
(PITCH:2.5MM)
CN8 211-10041-140-0 4P WAFER/S 2532-04
D101.102 090-10000-000-0 B/DIODE PB154
D2.3 090-00007-020-0 DIODE IN4004 SILTEK T
FUSE1*2.FUSE2*2 281-00000-020-0 FUSE CLIP FH-1206
(XP1000)
IC1 160-00005-909-0 IC 7815
IC1-4 160-00021-300-0 IC NJM2068 SMD JRC
IC2 160-00002-909-0 IC 7915
JK2A.3A 211-01602-560-0 6D4/J YLJ-6405-300
(NUT&WASHER)
JK2A.3A 211-03300-160-0 XLR/J SKCA229-1K3F2
JK4.5 211-03400-021-0 SPEAKON/J SVP563S -CH
JP1 212-11214-000-0 IC/P 120MM
JP10A.10B 212-10061-360-0 6P WAFER/P 120MM
JP2 212-11220-000-0 IC/P 120MM XP2000/3000
PH=2.54MM
JP4 212-10032-490-0 3P WAFER/P 440MM
JP5 212-10032-480-0 3P WAFER/P 520MM
(PITCH=2.5MM)
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 23
Page 24
Re f. Phonic Part No. Desc ription
JP6 212-10061-370-0 6P WAFER/P 150MM
JP7 212-10061-380-0 6P WAFER/P 300MM
JP8 212-10041-220-0 4P WAFER/P 500MM
JP9A 212-10090-440-0 9P WAFER/P 250MM
UL1015#16 PITCH=3.96MM
JP9B 212-10090-460-0 9P WAFER/P 140MM
LED1 100-00150-020-0 LED LG5120 GRN
LED1.2 615-10054-620-0 LED BOSS L=6MM(XP1000)
LED101.102.301A.301B 100-00010-030-0 LED BL-B5141 RED
LED2 100-00110-000-0 LED BL-R5132N RED
LED302A.302B.303A.303
B.304A.304B
100-00050-000-0 LED BL-B2141 GRN
LED305A.305B 100-00040-000-0 LED 204YD YLW
LED3-11 100-00240-020-0 LED 5*5mm YLW
NTC1.2.3 012-400B0-000-0 NTC THERMISTORS
N15SP004(XP1000)
NTC1.2.3 382-20010-010-0 TINNER WIRE 10MM D0.6
(XP600)
P2.3.5-10 315-00012-000-0 LUG PIN JP-15
Q303A.303B.304A.304B.
305A.305B
120-00000-800-0 TRAN. 2SC1815 GR
TOSHIBA
R1 006-47032-420-0 MF RES. 470K F 0.25W M
(XP1000)
R101.103.122.124.311A.
311B
008-01042-600-0 CHIP RES. 100K J 0603
R102.112.123.133 008-02232-600-0 CHIP RES. 22K J 0603
R104-107.125-128 008-01532-600-0 CHIP RES. 15K J 0603
R108.129 008-01232-600-0 CHIP RES. 12K J 0603
R109.130 008-08232-600-0 CHIP RES. 82K J 0603
R110.131 008-04322-600-0 CHIP RES. 4.3K J 0603
R111.132 008-04732-600-0 CHIP RES. 47K J 0603
R113.114.115.134.135.13
6
008-02212-600-0 CHIP RES. 220 J 0603
R116.137 006-33011-400-0 MF RES. 3K3 F 0.125W T
R117.138.309A.309B 008-01032-600-0 CHIP RES. 10K J 0603
R118.139 008-04332-600-0 CHIP RES. 43KJ 0603
R119.140 008-03322-600-0 CHIP RES. 3.3K J 0603
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 24
Page 25
Re f. Phonic Part No. Desc ription
R120.141 008-01512-600-0 CHIP RES. 150 J 0603
R121.142 008-03922-600-0 CHIP RES. 3.9K J 0603
R143.144 006-10012-420-0 MF RES. 1K F 0.25W M
R145.145A.145B 006-56003-420-0 MF RES. 560 F 0.5W M
R146 006-33022-420-0 MF RES. 33K F 0.25W M
R153 006-10073-420-0 MF RES. 10F 0.5W M
R2 006-10022-420-0 MF RES. 10K F 0.25W M
(XP1000)
R3 005-10127-100-0 MOF RES. 100OHM 2W P
(XP1000)
R310A.310B 008-02032-600-0 CHIP RES. 20K J 0603
R312A.312B.313A.313B.
314A.314B
006-10012-420-0 MF RES. 1K F 0.25W M
R343A.343B 008-07522-600-0 CHIP RES. 7.5K J 0603
(XP1000)
R343A.343B 008-08222-600-0 CHIP RES. 8.2K J 0603
(XP600)
R344A.344B 008-04722-600-0 CHIP RES. 4.7K J 0603
(XP1000)
R344A.344B 008-06822-600-0 CHIP RES. 6K8 J 0603
(XP600)
R4.5.6.7 006-33023-420-0 MF RES.33K F 0.5W M
RA1 076-02411-001-0 RELAY T9AS1D12-24 (02182)
(XP1000)
SPK-GND 212-10010-700-0 1P WAFER/P 200MM
UL1015#14 BLK
SPK-GND 212-10010-710-0 1P WAFER/P 250MM
UL1015#14 BWN
SW1.2.3.4 210-60001-000-0 SLD/SW SLD -43-10
T1 211-10084-020-0 8P WAFER/S 396108 180
P=3.96MM
VR1.2 023-50230-040-0 D.ROT/VR 5KA 20MM P
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 25
Page 26
MISCELLANEOUS ITEMS
Re f. Phonic Part No. Desc ription
211-17000-410-0 BINDING POST BP-47-2P
212-10010-650-0 1P WAFER/P 100MM
UL1015#14 RED
307-00000-070-0 CORD CONNECTOR C5
321-00000-020-0 CABEL TIE 140MM
321-00000-070-0 CABLE TIE HW-100MM
347-00000-201-0 FAN JF0825S2H-419
510-20960-102-0 XP600/1000 PANEL
511-20650-101-0 BACK PANEL SECC T=1.2MM
XP600/1000
516-20430-102-0 TOP COV
524-20006-012-0 HANDLE XP600/1000
525-00009-100-0 FEET D26.5*11 BLK
528-00000-000-0 FAN NET WHT PWA2200 8"
529-20026-001-0 LENS PMMA 45.6*11.6
540-20390-120-0 R/KNOB D18*18MM BLK
552-20048-420-0 ADHESIVE FIXED FW -5D-3M
552-20054-401-0 X'MER FIXED XPSERIES
560-21020-300-0 CARTON XP600
614*522*205MM A=B
561-21260-500-0 G/B XP600 597*505*185MM
565-20051-020-0 LF POLYLON XP600/1000
565-20053-020-0 RT POLYLON XP600/1000
566-10015-010-0 SPONGE 40*10*5
568-00003-000-0 PE BAG #10 240*340*0.05
568-20018-000-0 PE BAG 630*630*0.07
572-00000-050-0 DRYER 5g
573-10124-010-0 GND LABEL MAR2
573-20340-001-0 LABEL D25 BLK
573-20402-030-0 LED LABEL LEVEL METER
LABEL XP/XP600/1000
573-20411-032-0 PVC PANEL LABEL
573-60240-000-0 BAR CODE LABEL PHONIC
SERIES LABEL
573-60343-000-0 LABEL LEVEL METER LABEL
BLUE D=8mm
573-60351-001-0 POWER OUT LABEL
MISCELLANEOUS ITEMS
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 26
Page 27
Re f. Phonic Part No. Desc ription
574-34640-111-0 OWN. MANU.
579-00000-068-0 MINI CATALOG PHONIC
SERIES
590-53006-200-0 M/E SET SCR. M3.0*6 BLK
610-00300-516-0 FIBER WAS. D3*D8*0.5 RED
610-60300-700-0 PAN SPR WAS.
D3.0*6.0*0.7ZN
619-06380-320-0 PLA RIVET SR-3L BLK
AMP 630-20046-410-0 MYLAR INSU 268*48*0.5MM
BOT COV FIX X'MER 610-00601-000-2 PLA WAS D6*D12*1.0MM BLK
BOT COV&HEAT SINK 610-60401-001-0 PAN SPR. WAS. D4*7.6*1.0 NI
FAN&HEAT SINK 615-20035-600-0 BOSS D8*D6*7MM
FIX BACK
PANEL&PANEL*4
590-03006-200-0 M/E FLT SCR. M3.0*6 BLK
FIX BOT COV & X'MER
FIXED
590-46015-200-0 M/E PANE SCR. M6.0*15 BLK
FIX BOT COV&X'MER
FIXED
600-00605-000-0 HEX. NUT M6.0*5.0 ZN
FIX FAN BRACKET 590-53012-200-0 M/E SET SCR. M3.0*12 BLK
FIX FAN BRACKET 600-00302-210-0 HEX. NUT M3.0*2.2 NI
FIX FAN HEAT SINK 590-44040-200-0 M/E PAN SCR. M4.0*40 BLK
FIX FAN NET 610-00408-001-0 PLA. WAS. D4.0*8.0*1.0 NI
FIX M'MER 610-60601-001-0 PAN SPR. WAS. D6*D12*1 NI
FIX NERTRIK*4 590-03010-200-0 M/E FLT SCR. M3.0*10 BLK
FIX VR PCB 590-53004-100-0 M/E SET SCR. M3.0*4 NI
FIXE PANEL&HANDLE 590-04008-100-0 M/E FLT SCR. M4.0*8 NI
FIXED FEET 591-54010-200-0 T/P SET SCR. D4.0*10 BLK
FIXED LED PCB 615-20108-100-0 PCB BOSS M3*13MM
FIXED POWER PCB 615-20107-100-0 PCB BOSS M3*14MM
FIXED PWR PCB&BOT
COV.*5 LED PCB*2
590-33008-200-0 M/E RUD SCR. M3.0*8 BLK
FIXED ROT/VR PCB 615-20110-100-0 PCB BOSS M3*5MM
GND 315-00000-000-0 LUG D4 FOR GROUND
GND 600-00403-510-0 HEX. NUT M4.0*3.5 NI
GND 600-00602-010-0 HEX. NUT M6.0*2.0 NI
GND 610-30400-501-0 TOOTH WAS. D4.0*D8.5*0.5
NI
MISCELLANEOUS ITEMS
MISCELLANEOUS ITEMS
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 27
Page 28
Re f. Phonic Part No. Desc ription
GND 615-10001-130-0 EARTH BOSS 2+5 NI
GND SCREW FIX BOT
COV HEAT SINK
590-44010-200-0 M/E PAN SCR M4*10 BLK
GND TERMINAL 615-10002-130-0 EARTH BOSS 10+5 NI
(EARTH BOSS)
HEAT SINK 610-00402-018-0 FIBER WAS D4.0*D9.0*2.0
RED
HENDEL&PANEL*6 590-44008-200-0 M/E PAN SCR. M4.0*8 BLK
PANEL&BACK PANEL*6 590-54006-200-0 M/E SET SCR. M4*6 BLK
PHONIC JACK 610-20901-001-0 TOOTH WAS D9*12*1 NI
POWER PCB 610-30300-501-0 TOOTH WAS. D3.0*D6.5*0.5
NI
POWER SW 212-10010-750-6 1P WAFER/P 1617#14 AWG
370MM BLUE
POWER SW 212-10010-760-6 1P WAFER/P 1617#14 AWG
320MM RED
POWER SWE 210-03101-070-0 SSA/SW
SELECTIVE VOLTAGE 618-14180-662-0 SPEC FIXED PIN SR-2 WHT
VR1.2 630-20047-410-0 MYLAR INSU 63*35*0.5MM
XLR/JACK 591-03008-200-0 T/P FLT SCR. D3.0*8 BLK
S34-61000-000-0 XP600/1000 MATERIAL
510-20960-102-F XP600/1000 PANEL
511-20650-101-F BACK PANEL
516-20430-102-F TOP COV XP2000/3000(B)
600/1000
MISCELLANEOUS ITEMS
MISCELLANEOUS ITEMS
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 28
Page 29
Ref. Phonic Part No. Description
PIII600 BS
070-20548-800-0 X'MER 115/230V PIII600
FUSE1.2 280-20263-000-0 FUSE T2A 250V VDE S
280-63263-000-0 FUSE 6.3A 250V VDE/CE S
281-00000-020-0 FUSE CLIP FH-1206 (ONLY
XP600)
370-26640-432-6 P/CORD 250V/15A 2.5M 3P BS
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20079-010-0 FUSE LABEL T6.3A
250V(ONLY XP600)
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
PIII1000 BS
070-20558-800-0 X'MER 115/230V PIII1000
280-1038B-001-0 FUSE 10A 250V UL/CSA/JIS S
280-20263-000-0 FUSE T2A 250V VDE S
370-26640-432-6 P/CORD 250V/15A 2.5M 3P BS
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
PIII600 IEC
070-20548-800-0 X'MER 115/230V PIII600
FUSE1 FUSE2 280-20263-000-0 FUSE T2A 250V VDE S
280-63263-000-0 FUSE 6.3A 250V VDE/CE S
281-00000-020-0 FUSE CLIP FH-1206
370-23610-902-0 P/CORD 230V 15A 2.5m3P
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20079-010-0 FUSE LABEL T6.3A 250V
PIII1000 IEC
070-20558-800-0 X'MER 115/230V PIII1000
280-1038B-001-0 FUSE 10A 250V UL/CSA/JIS S
FUSE1.2 280-20263-000-0 FUSE T2A 250V VDE S
370-23610-902-0 P/CORD 230V 15A 2.5m3P
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 29
Page 30
Ref. Phonic Part No. Description
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
PIII600 SA
070-20548-800-0 X'MER 115/230V PIII600
FUSE1.2 280-20263-000-0 FUSE T2A 250V VDE S
280-63263-000-0 FUSE 6.3A 250V VDE/CE S
281-00000-020-0 FUSE CLIP FH-1206
370-15020-829-0 P/CORD 15A/250V 1.0MM*3 6F
3P
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20079-010-0 FUSE LABEL T6.3A 250V
PIII1000 SA
070-20558-800-0 X'MER 115/230V PIII1000
070-20558-800-0 X'MER 115/230V PIII1000
280-1038B-001-0 FUSE 10A 250V UL/CSA/JIS S
FUSE1.2 280-20263-000-0 FUSE T2A 250V VDE S
370-15020-829-0 P/CORD 15A/250V 1.0MM*3 6F
3P
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
PIII600 UL
070-20548-800-0 X'MER 115/230V PIII600
280-1038B-001-0 FUSE 10A 250V UL/CSA/JIS S
FUSE1.2 280-2026B-000-0 FUSE 2A 250V UL/CSA/JIS S
281-00000-010-0 FUSE CLIP FH-1208
281-00000-020-0 FUSE CLIP FH-1206
370-08810-702-0 P/CORD 120V20A 2.5m
2.0MM/3PUL/CSA
527-14000-000-0 STR.REL BUSHING 6W3-4 S
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 30
Page 31
Ref. Phonic Part No. Description
PIII1000 UL
070-20558-800-0 X'MER 115/230V PIII1000
280-1538B-000-0 FUSE 15A 250V UL/CSA/JIS S
FUSE1.2 280-2026B-000-0 FUSE 2A 250V UL/CSA/JIS S
370-08810-702-0 P/CORD 120V20A 2.5m
2.0MM/3PUL/CSA
527-14000-000-0 STR.REL BUSHING 6W3-4 S
573-20334-010-0 FUSE LABEL 15A 250V(12*2.5)
PIII600 JIS
070-20540-600-0 X'MER 100V JIS PIII600
280-1038B-001-0 FUSE 10A 250V UL/CSA/JIS S
FUSE1.2 280-2026B-000-0 FUSE 2A 250V UL/CSA/JIS S
281-00000-010-0 FUSE CLIP FH-1208
281-00000-020-0 FUSE CLIP FH-1206
370-24610-602-0 P/CORD 100V 12A 2.5m
1MM/2P JIS
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
PIII1000 JIS B34-62013-220-1
070-20550-600-0 X'MER 100V JIS PIII1000
280-1538B-000-0 FUSE 15A 250V UL/CSA/JIS S
280-2026B-000-0 FUSE 2A 250V UL/CSA/JIS S
370-24810-602-0 P/CORD 125V/15A 2.0MM/2P
2.5M JIS
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20334-010-0 FUSE LABEL 15A 250V(12*2.5)
PIII600 SAA B34-61016-510-1
070-20548-800-0 X'MER 115/230V PIII600
FUSE1.2 280-20263-000-0 FUSE T2A 250V VDE S
280-63263-000-0 FUSE 6.3A 250V VDE/CE S
281-00000-020-0 FUSE CLIP FH-1206
370-12640-631-6 P/CORD 15A/250V 3P 2.5m
(1.0)SAA
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 31
Page 32
Ref. Phonic Part No. Description
527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20079-010-0 FUSE LABEL T6.3A 250V
PIII1000 SAA B34-62016-510-1
070-20558-800-0 X'MER 115/230V PIII1000
280-1038B-001-0 FUSE 10A 250V UL/CSA/JIS S
FUSE1.2 280-20263-000-0 FUSE T2A 250V VDE S
R281 370-12640-631-6 P/CORD 15A/250V 3P 2.5m
(1.0)SAA
R316 527-11000-000-0 STR.REL BUSHING 6W3-4 R
(6N3-4)
R241.242.243.248.249.2
50
573-60022-010-0 FUSE LABEL 10A 250V
(12*2.5)
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 32
Page 33
DIMENSIONS
DIMENSIONS
442.4/17.42
482.6/19
Measurement are shown in mm/ inch.
347.2/13.67
374.2/14.73
89/3.5
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 33
Page 34
Loading...