Philips HTS-3566-D, HTS-3565-D Service Manual

1 - 1

HTS3565D/3566D/37

All rights reserved. No part of this publication may be reproduced, stored in a retrieval syst em or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.

Published b

y LM0815 Service Audio Printed in The Netherlands Subject to modification

DVD Home Theater System

Version 1.2

TABLE OF CONTENTS

Service Manual

Service

Tfswjdf

3139 785 33292

Chapter

Location of PCB Boards .............................................. 1-2

Versions Variation.......................................................1-2

Specifications ..............................................................1-3

Measurement setups................................................... 1-4

Service Aids.................................................................1-5

ESD & Safety instruction ............................................. 1-6

Lead-tree solding information...................................... 1-7

Setting procedure & Repair instructions......................... 2

Disassembly instruction & Service Postion .................... 3

Block & Wring Diagram ..................................................4

VFD+JACK+VOL+STANDBY Board .............................. 5

Main Board ..................................................................... 6

Power Board................................................................... 7

AMP Board ..................................................................... 8

IPOD Board .................................................................... 9

Mechanical Exploded View & Parts.............................. 10

Revision List ................................................................. 11

LOCATION OF PCB BOARDS

Type/Versions

Boards in used

HTS3565D

/37

Main board

Power board

AMP board

IPOD board

VFD+JACK +VOL+STANDBY board

HTS3566D

/37

Type/Versions

Features

HTS3565D

/37

Main (Output Power-1000W)

S-Video out

Power Voltage (120V)

IPOD Dock

HTS3566D

/37

1 - 2

VERSION VARIATION:

SERVICE SCNARIO MATRIX:

* Bd= Board Level Repair

1 - 3

SPECIFICATIONS(red colour only for hts3566d/37)

AMPLIFIER

Total output power:

- Home Theater mode ................... ........................ ..... 1000 W

- FTC* output power . .. .. .. ... .. ... .. .. .. ... .. ... .. .. .. ... .. .. .. ... .. ... . 640 W

Frequency Response ...... ......... .......... 180 Hz – 14 kHz / ±3 dB

Signal-to-Noise Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . > 60 dB (A-weighted)

Input Sensitivity

- AUX 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400 mV

- AUX 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400mV

- MP3 LINK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 400mV

* (Main Ch @1 kHz Sub Ch 60 Hz within 10% THD)

RADIO

Tuning Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 87.5–108 MHz (100kHz)

26 dB Quieting

Sensitivity ............. ................ ....... ......... ................ ..... FM 22dBf

IF Rejection Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 60 dB

Signal-to-Noise Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 50 dB

Harmonic Distortion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM Mono 3%

............................................................................ FM Stereo 3%

Frequency Response ...... ......... ...... FM 180 Hz–10 kHz / ±6 dB

Stereo Separation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 26 dB (1 kHz)

Stereo Threshold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FM 29 dB

DISC

Laser Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Semiconductor

Disc Diametre . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12cm / 8cm

Video Decoding . .. . .. .. .. .. .. .. .. . .. .. .. .. .. .. .. . .. .. .. .. .. .. .. . .. .. .. .. .. .. .. . .. .. .. .. .

........................................ MPEG-1 / MPEG-2/ DivX, DivX Ultra

Video DAC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Bits

Signal System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . NTSC / Multi

Video Format . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4:3 / 16:9

Video S/N .... ....... ....... ....... ........................................ ....... 56 dB

Composite Video

Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.0 Vp-p, 75Ω

S-Video Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Y - 1.0 Vp-p, 75Ω

................................................................... C - 0.286 Vp-p, 75Ω

Audio DAC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Bits / 96 kHz

Frequency Response ...... ......... ........... 4Hz–20 kHz (44.1 kHz)

.................................................................. 4Hz–22kHz (48 kHz)

.................................................................. 4Hz–44kHz (96 kHz)

PCM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . IEC 60958

Dolby Digital ...... ......... ............................. ................ IEC 60958,

.................................................................................. IEC 61937

FRONT AND REAR SPEAKERS

System . . . . . . . . . . . . . . ........................................... Full range satellite

Impedance . . . . . . . . . . . . . . ............................................................. 6 Ω

Speaker drivers ...... .................................. 3” full range speaker

Frequency response . . . . . . . . . . . . . . ......................... 150 Hz – 20 kHz

Dimensions(front & rear) ......................... 103 x 203 x 71 (mm)

...................................................................................(w x h x d)

Weight .... ....... ....................................................... 0.56 kg/each

Dimensions(front) . .. ... .. ... .. ....................... 103 x 203 x 71 (mm)

Dimensions(rear) . . . . . . . . . . . . . . ......................... 262x1199x264(mm)

...................................................................................(w x h x d)

Weight(front) . . . . . . . . . . . . . . ........................................... 0.54 kg/each

Weight(rear) . . . . . . . . . . . . . . ............................................ 3.53 kg/each

CENTER SPEAKER

System . . . . . . . . . . . . . . ........................................... Full range satellite

Impedance . . . . . . . . . . . . . . .............................................................. 3Ω

Speaker drivers ...... ..... 2x 2.5” full range woofer,1 x 2” tweeter

Frequency response . . . . . . . . . . . . . . ......................... 150 Hz – 20 kHz

Dimensions . . . . . . . . . . . . . . ............................. 438 x 101 x 73.5 (mm)

...................................................................................(w x h x d)

Weight .... ....... ................................................................ 1.43 kg

System . . . . . . . . . . . . . . ........................................... Full range satellite

Impedance . . . . . . . . . . . . . . .............................................................. 6Ω

Frequency response . . . . . . . . . . . . . . ......................... 150 Hz – 20 kHz

Dimensions . . . . . . . . . . . . . . ................................ 244 x 105 x 74 (mm)

...................................................................................(w x h x d)

Weight .... ....... ................................................................ 0.84 kg

SUBWOOFER

Impedance . . . . . . . . . . . . . . .............................................................. 3Ω

Speaker drivers ...... ................................... 203 mm (8”) woofer

Frequency response . . . . . . . . . . . . . . ........................... 40 Hz – 150 Hz

Dimensions . . . . . . . . . . . . . . ........................ 162.5 x 362.5 x 369 (mm)

...................................................................................(w x h x d)

Weight .... ....... ................................................................ 4.98 kg

Speci cations subject to change without prior notice.

MAIN UNIT

Power Supply Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120 V; 60 Hz

Power Consumption . .. .. .. ... .. ... .. .. .. ... .. ... .. .. .. ... .. .. .. ... .. ... .. . 180 W

Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 435 x 57 x 360 (mm)

...................................................................................(w x h x d)

Weight .... ....... ....... ....... ....... ................................. ....... ... 4.04 kg

IPOD DOCK

Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34.6 x 103.8 (mm)

......................................................................................... (h x d)

Weight .... ....... ....... ....... ........................................ ....... ... 163.5 g

Tuner FM

Bandpass

MEASUREMENT SETUP

1 - 4

1 - 5

1 - 6

1 - 7

System , Region Code , etc. Setting Produre

2 - 12 - 1

1)System Reset

a) press “OPTIONS“ button on R/C,TV will show setup menu

b) select the menu using the and

c) go preference page to do sysytem reset

2)Region Code Change

a) In open model,press”9” “9“ “9“ “9“ on R/C,then input desired

number to change region code :

1 USA

2 EU

3 AP

4 Australia ,NZ , Latam

5 Russia , INDIA

6 CHINA

3)Version Control Change

a) In open model, press “1“ “5“ “9“ on R/C

b) press “ok” button to con rm

c) TV will show message as below:

on R/C

7) Upgrading new sofeware

a) copy “sofeware  les” into a CD-R disc

b) open the CD Door,then insert CD-R program disc

c) close the CD Door

d) VFD will show:

“Loading“

“Erase” -- erase the  ash memory

“Writing” about 1 minute

“done “

* the system will switch off and on again automatically.

e) OSD will show:

upgrade  le detected

Do you wish to continue with

the sofeware upgrade?

OK Cancel

Current model HTS3565D/3566D/37

Version: 00.12.01_1 Release: 2007.12.19

region : 1 Servo: 5B.61.00.00

8032: 05.00.04.06 RISC:00.00.02.00

MCU: V04.08

IF current model does not match you set use down arrow

key on the remote to change

4)Password Change

a) press “OPTIONS “ button on R/C,TV will show setup menu

b) select the menu using the and on R/C

c) go preference page select “password“ to change

* 000000 is default password supplied.

5)Check on the Sofeware Version

a) open the CD Door

b) press “INFO“ button on R/C

c) TV will show the version on screen

6)Trade model

a) press “Open/Close “ button on R/C

b) Press “2” “5” “9” on R/C,VFD will display “TRA ON “ or “TRA

OFF“

f) select “OK”, OSD will show:

upgrade in process...

V356X

please do not unplug or

switch off the device.

CAUTION!

This information is conﬁ dential and may not be distributed.Only a qualiﬁ ed s ervice person should reprogram the Region Code.

REPAIR INSTRUCTIONS (part one)

2 - 22 - 2

REPAIR INSTRUCTIONS (part two)

2 - 32 - 3

REPAIR INSTRUCTIONS (part three)

2 - 42 - 4

3 - 1 3 - 1

Figure 8

Figure 9

DISASSEMBLY INSTRUCTIONS

3) Loosen 7 screws and remove the Top Cover by lifting the rear portion upwards before sliding it out towards the rear.

- 1 screw “A” each on the left & right side as shown in  gure 4

- 5 screws “B” at the back panel as shown in  g ure 5

4) Loosen 1 screw “C“ each left & right side on the front panel after move the top panel as shown in  g ure 6.

5)Loosen 6 screws “D” at bracket of front panel as shown in  g ure 7

Figure 4

Figure 5

Dismantling of the AMP Board

1) Loosen 4 screws to remove the AMP Board.

- 2 screws “ E “ on the top of AMP board as shown in  gure 8

- 2 screws “ F “ at the back panel as shown in  gure 9

Push

24mm

mm2

Figure 1

Figure 3

Figure 2

Dismantling of the Front Panel Assemble

1) Open the DVD Tray by using the Open/Close Button while the Set is ON and disconnect the mains supply after removing the Tray Cover.

Note: If this is not possible, the DVD Tray has to be open manually.

Take a mini screw driver about 2mm diameter and make a marking 24mm from the tip as shown in  gure 2 . Place the set on its

side, insert the mini screw driver till the marking and slide it towards the right as shown in  gure 1 until the Tray moves out of the Front Panel.

2) Return the set to its upright position and remove the Tray Cover as shown in Figure 3 and close the tray manually by pushing it back in.

Figure 6

Figure 7

+ 26 hidden pages