Philips AZP-6 Service Manual

Portable Sound system

AZP6/

all

TABLE OF CONTENTS

Technical specification ..........................................................1-14

Safety instruction ................................................................2-1

ESD protection........................................................................2-2

Set Block diagram ..................................................................3-1

Set Wiring diagram............................................................. ....4-1

Disassembly diagram............................................................. 5-1

Main&Ipod Usb

Circuit diagram............................................................6-1..6-3

Layout diagram................................................................6-4..6-7

Display&Cass

Circuit diagram............................................................7-1..8-1

Layout diagram................................................................7-2..8-2

Mechanical Exploded view..... ...............................................9-1

©

Copyright 2012 Philips Consumer Electronics B.V.Eindhoven, The Netherlands

All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, inany form or by anymeans, electronic, mechanical, photocopying, orotherwise without
the prior permissionof Philips.

Published by LX 1228 Service Audio Printed in The Netherlands Subject to modification

board

board

Page

3141 785 38320

Version 1.0

Location of PC Boards

Display Board

1-2

Technical Specification and Connection Facilities

Usb/Aux Board

Cass deck Board

VERSION VARIATION

Main Board

Ipod Board

Power supply mounting

Type /Versions:

Board in used:

Service policy

Main BOARD
Display BOARD
Usb/Aux BOARD
Cass deck BOARD

Ipod BOARD
Power supply mounting

Type /Versions:

Features

Feature diffrence
RDS
VOLTAGE SELECTOR
ECO STANDBY - DARK

* TIPS : C -- Component Lever Repair.

M -- Module Lever Repair

-- Used

/12

(EUROPE)

C/M
C/M
C/M
C/M
C/M

M

/12

AZP6

AZP6

1 - 3

AZP6 SH190 Content List

1 GENERAL PART 1 - FRONT PANNEL SPECICFICATION 1
2 GENERAL PART 2 - BACK PANNEL SPECICFICATION 2
3 GENERAL PART 3 - GENERAL SPECICFICATION 3
4 GENERAL PART 4 - TECHNICAL SPECICFICATION 4
5 GENERAL PART 5 - AUDIO SIGNAL SPECICFICATION 5
6 GENERAL PART 6 - CLOCK / TIMER SPECICFICATION 7
8 GENERAL PART 8 - iPOD SPECICFICATION 8
9 GENERAL PART 9 - USB SPECICFICATION 9

10

GENERAL PART 10 - AUX SPECICFICATION

11 GENERAL PART 11 - CASSETTE SPECICFICATION 11
12 GENERAL PART 12 - VERSION OVERVIEW SPECICFICATION 12

10

egaPnpotiprcseD.oN

1 - 4

28

soPNOITCIPED
1
2
3
4
5
6
7
8
9

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30

egaPnoitpircseD

CABINET

Diemensions with Boxes ( wxhxd )
Diemensions without Boxes ( wxhxd )
Weight ( inclusive packing )
Weight ( exclusive packing & batery )

Remarks :

Remark :

GENERAL PART 1 - FRONT PANNEL SPECICFICATION

Class No Ver

Material : HIPS / ABS / POM / V2 / SAN
Finshing : Chrome Plate
Units in Masstercarton
Units in Dealercarton

AZP6

NAME : Andy Lai

CHECK DATE :

Issued Date

1
2
3

2012-2-2

A410 10 SH 190 - 1

1 - 5

egaPnoitpircseDsoPNOITCIPED
1
2
3
4
5
6
7
8
9

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28

CABINET

GENERAL PART 1 - BACK PANNEL SPECICFICATION

Class No

AZP6

NAME 10

NAME : 10 SH 190 - 2

CHECK

DATE :

SH 190 - 2

SPIH/SBA: lairetaM ) dxhxw ( sexoB htiw snoisnemeiD

etalP emorhC : gnihsniF ) dxhxw ( sexoB tuohtiw snoisnemeiD
notracretssaM ni stinU) gnikcap evisulcni ( thgieW
notracrelaeD ni stinU) yretab & gnikcap evisulcxe ( thgieW

Issued Date

Ver

2012-2-2

1
2
3

1 - 6

GENERAL DESCRIPTION
MP3-Micro Hi Fi System with Digital Tuner , 2 x 20W Bi-Amplifier
CD,IPhone ,USB,AUX IN ,CASSETTE,MIC X2,CLOCK, Head Phone and Remote Control,LCD display.

LIFETIME : 7 Years

XI

III

SAFETY requirements

RADIATION / IMMUNITY requirments ( EMC )

CLIMATIC requirements
ALL climates : + 5 Dregree till + 35 Degree
MODERATE climates : + N.A till N.A Degree
PERFORMANCE CLASSES

BSUkcolCEOPIsexoB rekaepsduoLreifilpmA + ylppuSssalC

XXXII

97846,5,4egaP

CMEytefaSnoisreV

02055NE/31055NE56006CEI50/21/

99CCF56006LU73/

31RPSIC56006CEI89/
31RPSIC56006CIE55/
31RPSIC56006CEI97/

POWER SUPPLY (AC ADAPTER)

CAV042~V001) SPMS ( SNIAM

llAnoisreV

oNnoitceleS egatloV

zH05/zH06ycneuqerF

POWER CONSUMER

/ 79 / 55/98 / 37 /12/05

( DEMO mode " OFF " ) , NOM. A, INPUT
Maximum :
@ 1/8 Prated , NOM. A, INPUT

Q and R according to Product Division Rules
Quality : 0.4 % ( Major ) 1.5 % ( Mirror )
Reliability : 2.0 % ( C 42 )
Tested according to General Test Instruction refer to PHILIPS standary ( UAN -D1591 )
Measured according to PHILIPS standary ( UAN - L1059 ) unless other wise stated
All not mentioned date, please refer to PHILIPS standary ( XUW - 0010 - MAR 1995 )

Remarks

W1<W1<W1<: ybdatS

W1<W1<W1<: edom rewoP OCE

<1W

<0.5W

NOITABORPPASKRAMERDEVIRED

Class No

NAME : Andy Lai

CHECK

GENERAL PART 1 - GENERAL SPECICFICATION

AZP6

DATE :

Ver

Issued Date
1
2
3

2012-2-2

4A3 - 091 HS0101

1 - 7

1

AUDIO SIGNAL PROCESSING
Main Operation for AZP6 /ALL VOERSION (RMS) 20W, 1 Channels (Lim:'±

1 ) DSC ( Digital Sound Control )
At AUX MODE
Set DSC to JAZZ mode
Adjust volume to obtain 500mW across 6 ohm load at LOW/HIGHT speaker ouput
The 50mW will be used as 0dB reference
Inject sinewave 500mV to AUX-IN with frequencies indicated below :

Tabel 1a ( Tolerance ± 3dB )

Frequency

1 kHz

JAZZ POP CLASSIC ROCK

DSC Modes with BASS Off (Db)

0 0
2 -4

( At Living Sound off, front 1channels )

640zH 08

6
00
410 kHz 0

2 ) BASS ( Dynamic Bass Boot )

Select AUX as input source with the following set conditions :
Inject sine wave 500mV at 1kHz to L/R channels from AUX IN
Set DSC to Flat mode and switch off DBB.
Adjust volume level will be as 0 dB reference.
Tabel 2 ( Tolerance ± 3dB )

Frequency

80 Hz 8 dB 0 dB

10KHz 0 dB 0 dB

Remarks

GENERAL PART 1 - AUDIO SIGNAL SPECICFICATION ( 1 )

BASS ON BASS OFF

AZP6

CHECK

DATE :

CD

Issued DateClass No

Ver

1

2012-2-2
2
3

5 - 091 HS0101iaL ydnA : EMAN

A4

1 - 8

TECHNIAL DESCRIPTION

20W +20W matching LOUDSPEAKER of 1x 6R. Two INPUT SOURCE Bi-amp)

GENERAL PART
OUTPUT stage Protection : Yes Temperature : YES Shorcircuit : Yes
LoudSpeaker D.C. Protection : Yes.

INDICATORS
Standby Mode Indicator : LCD display active

ELECTRICAL DATA

DSC :

INTERCONNECTS
Input Sensitity (

Microphone 40HZ-7KHZ(reference 1KHZ)input leven 5mv rms(Lim:'-1dB) Rs=600ohm

± 3 dB ) rated ouput power at 1 kHz

800mVIPHONE

Signal / Noise ( A-weighted )

Line Output Voltage ( *1 )

9

) muiniM emuloV ( esioN laudiseRA/N: SIS

) zHk 1 ta ( noitarapeS lennahCA/N: CAV

esioN / langiSA/N: XOOW

enohpdaeHevaH BSU

Frequency response @±4dB 7KHZ-20KHZ(reference 10KHZ)

3Bd64- ta recnereffiD lennahC,kcoR,SALC ,poP ,zzaJ

002<) numiniM emuloV ( muHffo/noBBD

<200

≥ NA

≥ 50
≥ 60

A.N) thgiR / tfeL ( tuO eniLETTESSAC
A.NtuO refoowbuSA/N DC

600mV ± 2 dB, RL = 32Ω

A.NtuO laixaoC latigiD)Vm008 ~ Vm004(Vm006 XUA
A.NtuO retsooBA/NenohporciM

dB

nW
nW

dB
dB
dB

OUTPUT POWER ( * 1 ) At Cold Condition with 10% THD , 1KHz,10KHZ and DBB of ,DSC=JAZZ (Bi-AMP)
Main Operation /ALL VOERSION (RMS) Low Freq.1KHZ 20W ,

High Freq 10KHZ 20W,

Rated Impedance

Remarks/Emphasis

( *1 ) Electrical parameters are to be measuremend at specker terminals across 6 Ohm load ( pure resistor )
with rated input signal in CD/AUX/USB mode; DSC setting in JAZZ mode with DBB OFF
Measuremend output data must used audio analyzer equipment.(必须使用音频分析仪测试+滤波器)

GENERAL PART 1 - TECHNAICAL SPECICFICATION

Class No

1 Channels (Lim:'-1dB)

Ver

AZP6

NAME : Andy Lai

CHECK

DATE :

1
2
3

Issued Date

2012-2-9

4A4 - 091 HS0101

1 - 9

TECHNIAL DESCRIPTION
SOFTWARE IMPLEMENTED CLOCK / TIMER FUNCTION WITH 32.768kHz QUARTZ OSCILLATOR.

GENERAL PART

remiT dna kcolC :gnitteS remiT

renuT , :edoM puekaW remiT

srh21 rof noisrev 73/ srh42 rof noisrev 97/89/21/50 :gnitteS emiT skrameR

euloV level 21 :puekaW ta emuloV

No of Timer Settings : 1
Clock Accuracy : Nom : 1 sec/day Limit : 2 sec/day

INDICATORS

DCLepyT yalpsiD

Remark

Class No

AZP6

CHECK DATE :

CLOCK / TIMMER SPECICFICATION

Ver Issued Date

1

2012-2-2
2
3

6 - 091 HS0101iaL ydnA : EMAN

A4

a

TECHNIAL DESCRIPTION
CD + MP3 - Part Specifications

GENERAL PART

Measurement are directly done at the connector on CD board

1 - 10

Remark

Description

Extern

oNecnatsiseR tuptuO
oN) zHk 1 , Bd0 ( dedaolnU - egatloV tuptuO

oN) rekaeps ta() Bd02- xaM loV ( esioN & muH

Nom Lim Unit

< 100

0555seY) 1* () dethgiewnU ( noitaR esioN ot langiS

0304seY) zHk1 ( klatssorC

80 200 nW

Ohms
Vrms

dB2 ± <oNecnalabnU lennahC

dB

dB

BdBd 3±oNFrequency Response BI-AMP(40 HZ -7 kHz for LOW channel,7KHz -20 kHz for HIGHT ch

ABd5526seY) 1* () dethgiew - A ( noitaR esioN ot langiS

Bd0353oN ) zHk01 ( klatssorC

Su0551- sisahpmE

( *1 ) Measured at CDM level

Class No

NAME : Andy Lai

CHECK DATE :

AZP6

CD / MP3 SPECICFICATION

10 10 SH 190 - 7

Ver Issued Date

1

2012-2-2

2
3

A4