Philips 65HUF6923/T3 Schematic

在模拟电视以及数字电视信源下，按“选项”键再依次按数字键“1999”进入工厂菜单

主菜單

值，備註

工廠復位（按 OK 鍵）

工廠復位

老化模式（按 OK 鍵）

按 OK 鍵

頻道預設（按 OK 鍵）

按 OK 鍵

上電模式（按左右鍵）

待機/記憶/開機

Mboot 升級（按 OK 鍵）

按 OK 鍵

Main 升級（按 OK 鍵）

按 OK 鍵

写入 MAC 地址（按 OK 鍵）

按 OK 鍵

数据调试（按 OK 鍵）

数据调试

音量相关（按 OK 鍵）

特殊功能锁定/最大音量/开机音量

开机图像相关（按 OK 鍵）

修改开机画面/还原开机画面/取消

自动软件升级

其它

屏型號

PQ

軟件版本

条形编码

MAC 地址

UUID 激活

65HUF6923

滑翔底座

PS:

喇叭在背板上

软件升級

1). 软件重命名为 "MstarUpgrade.bin", 将软件存到 FAT32 格式的 U 盘里。

2). 将 U 盘插入到 USB 升級接口，然后根据以下步骤升級软件：

选择模拟电视以及数字电视信号源, 按 Menu 键再依次按数字键“1999”进入到工厂菜

单里，选择“Main 升級”, 然后按右键或确认键进入

5.4.1 注意

①. 当机器升級软件時（U 盘），不要拔掉 U 盘或者切断电源，否则会造成升级失败。

②. 在插入 U 盘前，确保电源是切断狀态，以免损坏 U 盘。

软件升级操作与流程:

软件更新菜单将弹出時按确认键，然後选择“Confirm”确认。

进入软件升級：

方法 2：长按电視面板上的 VOL+键 , 机器開机,待机指示灯快速闪 5 秒钟后，待机指示灯熄灭，大约 1 分钟后亮起，这表示升級完成。

5

4

3

2

1

MSD6A638

PAGE

方案

--T8F1

三合一板原理图

Content

VER:A1.0 2016-4-20

1 Index&History Rev

D D

C C

2 3 4 5 6 7 8 9 10 11

Block Diagram

CE & PFC Boost

LED Driver & Standby

System Power MSD6A638

MSD6A638 POWER

LVDS &V by one page

Video&VGA&USB&Amplify page HDMI&Ethernet page

Tuner &eMCC flash page

B B

History Rev

3

Author

ZHQINGFirst Version Release

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

文件名称：

文件编号：

设计:

发行部门：生效日期：

2

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

T4298

张志清

研发处

版本：3.0

审核:

111

页数:

页数: 批准:

批准:

Thursday, April 21, 2016

1

111

of

Rev

DescriptionDATE

Ver:A1.04/20/2015

A A

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

Copyright@ ShenZhen KTC Technology Co., LTD

5

4

5

D D

LLC

驱动

LED

背光

12V

/

滤波

整流

滤波电路

C C

RE/CE

PFC Flyback

AC INPUT

4

待机

12V OUTPUT

RESET

12V_NORMAL

5V_NORMAL

5V_STANDBY

PWR_ON/OFF

三极管控制

GPIO

3

3.3V_NORMAL

AS1117

TUNER PWR

AS1117

1.28V DC-DC

1.15V DC-DC

DDR PWR

DC-DC

3.3V_STANDBY AS1117

32Gbit

EMMC FLASH

HDMI1 (ARC)

HDMI2

HDMI3 (MHL)

TUNER_3.3V

VDDC_CPU PWR

VDDC PWR

DDR PWR 1.5V

3.3V_Standby

HDMI1

HDMI2

LAN

VB1 4K

屏电压

12V_NORMAL

MOS

MSD6A638

LAN

Y/Pb/Pr

管控制

Y/Pb/Pr

AV-IN

2

V by one

VGA

COAXIAL

USB

AV-OUT

COAXIAL

12V_NORMAL

Audio AMP

TPA3110LD2

IF

TUNER_3.3V

IR&KEY

VEDIO-OUT

SPK-L

SPK-R

SILICON TUNER

MXL661

IR&KEY

TUNER CONN

USBAV-IN

1

RF

B B

A A

文件名称：

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

5

4

3

Copyright@ ShenZhen KTC Technology Co., LTD

文件编号：

设计:

发行部门：生效日期：

2

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

of

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Monday, April 25, 2016

1

of

211

5

4

3

2

1

放电针放电针

6mH

PL101

12

NC

3 2

放电针放电针

43

21

放电针放电针

TO220BHD

10F60

PD205

PR205 47R R1206PR205 47R R1206

PD207 1N4148

SOD123

NC

PR209

1

R1206

PC206

0.47uF/16V

PC206

0.47uF/16V

C0402

0.33UF/275V

PC101

AGND

PR210 10R

R1206

PR212 0R

R0402

PC207

PC207 10nF/16V

10nF/16V

C0402

PC103

471/400Vac

AGND

PR104

PR102

2MΩ

PR103

PR105

2MΩ

PC104

471/400Vac

PU201 FA5696 SOIC8PU201 FA5696 SOIC8

7

OUT

2

COMP

3

RT

PR213

68K

R0402

CN101

D D

C C

B B

4733-555-8888

6221-02N101-27239201

3

PF102

1

PF102

T5AH250Vac

T5AH250Vac T5AL250VacT5AL250Vac

PL202

2 6

3 5

1 4

280uH

POT33

100PF 1KV

CD15

PC201

1uF/450V

PL201

PL201 15uH

15uH

P7.5

1 2

PC202

0.22uF/50V

PC202

0.22uF/50V

CD15

VB+ VB-

PC203

C1206

L15

PR101

PR101 PVR10561

PVR10561

PL204

磁珠

L15

PL203

磁珠

1 2

PQ201

23

13N60

TO220BH

1

PR206

PR206 10K

10K

R0805

SOT-23 PQ202

SOT-23

PR208 NC

R1206

PR211 68K

PC205

0.47uF/16V

C0402

PQ202

R0402

6

PGND

PR224

PR224 820K R1206

820K R1206

GND

放电针放电针

PL102

PL102 15mH

15mH

放电针放电针

OVP

FB

VCC

IS

PC208

PC208 330pF/16V

330pF/16V

4

1

8

5

43

21

PR106

PR106 PVR10561

PVR10561

PC102

PR215

PR215 820K R1206

820K R1206

VB-

PR214

470R

PR223 0.2R 2WPR223 0.2R 2W

0.33UF/275V

0.1uF/50V

PR216

PR216 820K

820K

R1206

0.2R 2W

PR225

PC209

VCC_PFC

PC214

10uF/25V

10K

PR217

PC215

10uF/25V

PR218

PR218 16K

16K

R0402

PC210

PC210 1nF/50V

1nF/50V

C0402

PD409

PD409 RS07

RS07

PD410

PD410 RS07

RS07

NTC7.5_NEW

PR222

PR222 820K

820K

R1206

PR221

PR221 820K

820K

R1206

4

VB- VB+

PR438 10K

R1206

PC211 1nF/50V

C0402

PR438 10K

V_BUS

+

PR419 10K

HV1

PR107 2.5Ω/6A

t

PR220

PR220 820K

820K

R1206

PR219 16K

R0402

PR219 16K

R0402

PD201

AC+

2

6A/600V

-+

R1206

PC212

100uF/450V

H108

1 2 3

散热片

1

AC-

3

HV

A A

文件名称：

文件编号：

设计:

设计: 发行部门：生效日期：

发行部门：生效日期：

5

4

3

发行部门：生效日期：

2

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

of

311

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Tuesday, April 26, 2016

1

5

V_BUS

200K

PR357

PR355

100PF/1KV

PC301

PD301 fr507PD301 fr507

D D

PL301磁珠PL301

PC309

100PF/1KV

PR306 470RPR306 470R

PR307 0.33RPR307 0.33R

磁珠

PR301 12RPR301 12R

C C

3

PT301A

EQ40

1 8

1 2

23

PQ301

PQ301 80R650

80R650

PR304 10KPR304 10K

C0402

1

PC302

PC302 100PF

100PF

PR371 560KPR371 560K PR314 560KPR314 560K PR315 560KPR315 560K PR361 560KPR361 560K PR362 560KPR362 560K

10

PL404磁珠PL404

11

磁珠

PL405磁珠L10PL405磁珠L10

9

PR308

1N4148

PU302A

PU302A PC817C

PC817C

PGND

PD308

PD308 PD303

PD303

1 2

HV1

47R

PD302

4

PR359

3

PC303 10nFPC303 10nF

PC306 100pF/1000VPC306 100pF/1000V

PD313 SF59PD313 SF59

SF59

PR313 10kPR313 10k

PR310 10RPR310 10R

VCC_1

10k

1

0.01uF/16V

PR360 10KPR360 10K

PC321

R0805

PR108

PD310 NCPD310 NC

SF59

AGND

PR312 10kPR312 10k

HFC0500

2907

2907 PQ309

PQ309

3 2

PC108

471/250VAC

PU301

0R

+

VCC1

5

3

2

PC304NCPC304 NC

CY10PC108

CY10

PC307 33uF/200V

8

HV

GATE

CS

FB

RT1GND

AGND

+

6

VDD

4

PC308 33uF/200V

100nF/50V

100nF/50V PC305

PC305

4

VLED+

5V2

VLED+

100K

100K PR358

PR358

V-

PC322

470uF/16V

PC322

470uF/16V

0.1uF/250V

PC311

PC318 100nFPC318 100nF

+

PC817C

2

PD312 1N4148PD312 1N4148

1uF

PC319

PD314

AGND

PR320 12RPR320 12R

PR342NCPR342

5V

1N4148

PR321 12RPR321 12R

1

PR322 12RPR322 12R

PU303B

NC

PD309 1N4148PD309 1N4148

OUT1

PR316 10RPR316 10R

5V

VFB

PR323 12RPR323 12R

PR324 12RPR324 12R

1

12V

8

VCC

GND

4

PR356

100R

PR327 12RPR327 12R

PR325 12RPR325 12R

PR326 12RPR326 12R

PR341 1.5KPR341 1.5K

IN+

IN-

LM358

U906A

AGND

3

2

TO126

PZT651

PR328 12RPR328 12R

PR3542KPR354 2K

PR329 12RPR329 12R

PR317

VLED1

PQ304

PR330 12RPR330 12R

PR331 12RPR331 12R

5V2

U303B

7

OUT1

LM358

PR347 5.1KPR347 5.1K

PC315NCPC315

PR348 470RPR348 470R

3

100R

TO126

PQ305

PQ305 PZT651

PZT651

12R

PR333

PR332 12RPR332 12R

PR334 12RPR334 12R

PD311

PD311 RS2M

RS2M

IN+

IN-

PC314 0.1uF/25VPC314 0.1uF/25V

NC

PR3531KPR353

PC317

PC317 10nF

10nF

PR318

VLED2

5

6

1K

100R

PR335 2.2RPR335 2.2R

PR336 2.2RPR336 2.2R

VLED3

PQ306

TO126

PTZ651

PR337 2.2RPR337 2.2R

PR339 2.2RPR339 2.2R

PR338 2.2RPR338 2.2R

V-

PR369 2KPR369 2K

PR349 27KPR349 27K

PR351 4.3KPR351 4.3K

PC316

10nF

PR340 2.2RPR340 2.2R

PC313

100nF

AGND

1N4148

PD305

PR319

PR319 10K

10K

PC310

PC310 10nF

10nF

AGND

VFB

22uF/6.3V

PR350 68KPR350 68K

PQ307 2222PQ307 2222

PD306 1N4148PD306 1N4148

VOCP

PC320

VLED+

PR3524.7K PR3524.7K

1N4148

PD307

PR344

3.6K

100nF

PC312

5V2

2

470pF/500V

PD407 PS20U100

PD407 PS20U100 PD408 PS20U100

PD408 PS20U100

PC403 10nFPC403 10nF

470pF/500V

PC410

12VSB 12VS

R0805

TO220BH

AGND

PR408 10RPR408 10R

OB5269B

TO220BH

PU401

47NF/50V

PC404

+

HV

5

3

2

PC4111000uF/16V

PD403

8

HV

GATE

CS

FB

RT1GND

+

PC412 1000uF/16V

RS2M

PC405 47uF/50V

6

PC406 10nFPC406 10nF

VDD

VCC1

4

VCC_SB

PC407

PC407 47uF/50V

47uF/50V

RS2M

PGND

PL402磁珠L10PL402磁珠L10

10

PL403磁珠L10PL403磁珠L10

11

9

PR407 100RPR407 100R

PD402 1N4148PD402 1N4148

3

PR423 47RR1206 PR423 47RR1206 PR424 47RR1206 PR424 47RR1206

1 2

4

PU406A PC817CPU406A PC817C

V_BUS

PC401

PC401 102PF/1KV

102PF/1KV

PWM

PR346 NCPR346 NC

PR345 470RPR345 470R

R1206

PR401 51kPR401 51k

PR418 47RPR418 47R PR415

PR415 PR402 47RPR402 47R PR403 47RPR403 47R

PD401 RL207PD401 RL207

PL401磁珠PL401

PQ401

PR404 10KPR404 10K

PR406 470Ω

47R

磁珠

70R600

EQ25

PT401A EQ25

3

1 8

1 2

2 3

PC402

PC402 100PF

100PF

PR410 0.33R 2WPR410 0.33R 2W

1

+

VCC_SB

+

DO-214

PD404

1uF/25V

470uF/16V

PC413

PR439

PR421 22RPR421 22R

+

PU405A

PU405A PC817C

PC817C

GUANGOU

PC414

1

PGND

1

PR426 1K

R0402

4

PGND

PR425NCPR425 NC

22R

6

5

PT402B

PT402B EQ25

EQ25

32

PQ403 2907

SOT-23

47uF/50V

PC408

3

VCC_1

+

CE/6.3MM_PTH5MM_AUTO

12V

PC415

PC415 1uF/25V

1uF/25V

AGND

2K

2K PR422

PR422

R0805

SOT-23

2222

PQ404

18V

PD405

SOD123

PC409 1uF/50V

C0805

NC

PD406NCPD406

VCC_PFC

PU402B

PU402B PC817C

PC817C

PU404

TL431

1

2

12VSB

PR435

PR435 1K

1K

R0402

PR428

R0402

2

3

1

PR434

PR434 10k

10k

R0402

1K

PC416

0.22uF/16V

C0402

PR429

R0402

5.1K

12VS

R0402

PR431

PR431 10k

10k

R0402

PR430

5.1k

VLED1

VLED2

VLED3

VLED+.

1A 2A 3A 4A 5A 6A

CN302A 13PINCN302A 13PIN

7A 8A

9A 10A 11A 12A 13A

PR436 4.7K

1

B B

PC817C

PC817C PU403B

PU403B

2

GUANGOU

PQ406

PQ406 2222

2222

SOT-23

R0402

PR432

NC

R0402

PC417

0.1uF/16V

C0402

12VS

10K

10K PR433

PR433

R0402

BL-ON

GUANGOU

AGND

A A

KTC ISO9001.ISO14001体系文件

文件名称：

文件编号：

设计:

发行部门：生效日期：

5

4

3

2

发行部门：生效日期：

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

of

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Tuesday, April 26, 2016

1

of

411

5

+12V

PC56

PC61

10uF/16V

D D

靠近

DC-DC

10uF/16V

PC57

0.1uF

Vout=0.765V*(1+R1/R2)

LAYOUT

注意：输入、输出电容需靠近

12V

PWR-ON/OFF

4

TO MASTER CHIP

C C

BL_ON 4

PR427

PR427 0R/NC

0R/NC

PR199

4.7K

+12V

PR200

10K

5V

+5V_Standby

PR17

PR198

4.7K

BL_ADJ

4.7K

BL-ADJUST

PWM OUT

R550R/NC R550R/NC

R530R R530R

1K/nc

TO MASTER CHIP

PWR-ON/OFF

4

Inverter controler Power for panel

B B

12V TO 5V Power

PU12

PC166

0.22uF

PR207

PR207 100K

100K

PQ103

PQ103 MMBT3904

MMBT3904

R57 4.7K/ncR57 4.7K/nc

1

FB

PR227

100K

PU12

3

VIN

5

EN

4

VFB

TPS563200

PQ113

ME2325

1

SOT23

PC165

0.22uf

R511K R511K

+5V_Standby

VBST

DC-DC

+12V_NORMAL

32

PQ112

ME2325

1

SOT23

+5V_Normal

R43

10K/nc

Q11

3904/nc

2 3

SW

GND

470uF/16V

1K

2 3

1

2

PC59 0.1uFPC59 0.1uF

6

1

，电容地到IC的地在

32

CA9

+

R61KR6

Q1

1

3904Q13904

SAMSUNG panel 0~3.3V R34=10K

LG/CMO/AU panel 0~5V,R34 NC

"VBL_CTRL" IO "VBL_CTRL" IO

R54 4.7KR54 4.7K

PR75

PR75 10K

10K

PC71

0.1uF

Q3 MMBT3904Q3MMBT3904

+5V_Standby +5V_Normal

PR228

10K

4.7K

R52

Q10

3904/nc

2 3

PR41

PR41 10K 1%

10K 1%

R2

+12V_Normal

R3200R R3200R

Q208

3904

2 3

C143

C144

0.1uF

10uF

R504.7K R504.7K

BL_ON

口为高电平时，背光开。口为低电平时，背光关。

PL8 4.7uH/3APL8 4.7uH/3A

PR54 56K 1%PR54 56K 1%

R1

R15200R R15200R

R13 10KR13 10K

1

BRI_ADJ 4

4

VBL_CTRL 4

12

22uF/6.3V

PR55 750R 1%PR55 750R 1%

TOP

+3.3V_Standby

Q207

3904

PCA7

2 3

4

C153

C157

10uF

22uF/6.3V

靠近

层最短回路。

R9 10KR910K

R12 10KR12 10K

1

12V

PANEL_ON/OFF4

+5V_Standby

C156

0.1uF

DC-DC

PWR-ON/OFF

放电电路

+12V

L111

0805_BEAD/12V

PANEL_ON/OFF

3

VDDC DC/DC

VDDC

+12V_Normal

靠近

电阻靠近

C125

C138

10uF/16V

0.1uF

DC-DC

DCDC,

敏感线,远离干扰源

R127

100K

C136

0.47uF

R48 NC/0RR48 NC/0R

R47 NC/0RR47 NC/0R

C140

1uF

+1.2V_VDDC_CPU+1.2V_VDDC

R120

R120 10k

10k

U15

8

1

3

4

VDDC_CPU DC/DC

+12V_Normal

C122

10uF/16V

靠近

电阻靠近

C37

屏

0.1uF

R42 4.7KR42 4.7K

DC-DC

DCDC,

C137

0.1uF

R41

R41 10K

10K

R121

100K

C130

C131

0.47uF

1uF

敏感线,远离干扰源

VCC_P

C67

0.47uF

PANEL_ON

R58

R58 100K

100K

Q9

1

3904Q93904

2 3

R122

R122 10k

10k

Q12

Q12 ME2325

ME2325

0.1uF

C47

Panel_VCC

U14

8

PVDD

1

EN

3

5V

4

SDA

Addr 0x80

C134

10uF/16V

最大平均电流为

PVDD

EN

5V

SDA

PowerPAD

9

MSH6110A1

Addr 0x82

此

PowerPAD

9

MSH6110A

CA8

10uF/16V

2

3A ,

保证

DCDC

温升电流

12K_1%

18K_1%

5

电压为

+1.2V_VDDC

22uF/6.3V

靠近

follow

电压为

+1.2V_VDDC_CPU

22uF/6.3V

靠近

SPM30202R2/2A

C110 33pFC110 33pF

R103 3K_1%R103 3K_1%

R111 2K_1%R111 2K_1%

C133

22uF/6.3V

1A DC/DC!!

R1

R2

L14

6

LX

C124 0.1uFC124 0.1uF

7

BST

2

FB

5

SCL

Vout=0.83V*(1+R1/50k)

DCDC

不能改，并且参数设置尽量

6

LX

C121 0.1uFC121 0.1uF

7

BST

2

FB

5

SCL

pull a 5 mil +1.2V_VDDC_CPU trace from IC of bottrom to voltage feedback of switching power IC .the trace shall shield gnd

+5V_Standby

靠近

DC-DC

L14

12

SPM65302R2/5A

C127

330pF/X7R

R118

R118 NC/22K_1%

NC/22K_1%

R117

R1

I2C-SCL 4,6,9I2C-SDA4,6,9

pull a 5 mil +1.2V_VDDC trace from IC of bottrom to voltage feedback of switching power IC .the trace shall shield gnd

L13

12

SPM65302R2/5A

C126

330pF/X7R

R115

NC/22K_1%

R113

R1

D4 NC/SS34D4NC/SS34

I2C-SCL 4,6,9I2C-SDA4,6,9

Vout=0.83V*(1+R1/50K)

至少需使用

U12 SY8087U12 SY8087

4

SW3VIN

1

EN

C115

22uF/6.3V

C106

0.1uF

FB

GND

2

1.0V

+1.2V_VDDC

C139

C141

22uF/6.3V

DC-DC

公板

1.1V

+1.2V_VDDC_CPU

C129

C123

22uF/6.3V

DC-DC

L12

1

4

U11

ADJ

OUT

ADJ

OUT

AMS1117L-3.3

IN

+5V_Standby

+5V_Normal

IN

321

+3.3V_Standby

200mA

C102

C101

C135

2.2uF

0.1uF

4

U13

ADJ

OUT

ADJ

OUT

AMS1117L-3.3

IN

321

+3.3V_Normal

C107

C112

C108

0.1uF

2.2uF

0.1uF

C132

5A

C111

0.1uF

450mA Max

4

U16

ADJ

OUT

ADJ

OUT

AS1117L-1.8

IN

321

C41

C40

+5V_Normal

C104

0.1uF

+5V_Normal

2.2uF

+1.5V_DDR

C116

22uF/6.3V

C117

1A Max

C118

22uF/6.3V

靠近

DC-DC

C105

0.1uF

12

C40

0.1uF

40mA

4

U901

ADJ

OUT

ADJ

OUT

IN

321

C908

C902

0.1uF

C57

2.2uF

AMS1117L-3.3

+3.3V_TU

C901

C903

2.2uF

R1190RR119

0R

C904

C904 47nF

47nF

+1.8V_Normal

LDO

+3.3V_TU

C911

C911 10uF

10uF

Vout=0.6V*(1+R1/R2)

H12NCH12

1

5

9

4

8

3

7

2

6

A A

NC

1

H26NCH26

NC

H11NCH11

1

5

4

3

2

NC

1

NC

1

H24NCH24

H23NCH23

NC

H21NCH21

9

8

7

6

H20NCH20

1

5

4

3

2

NC

1

H29NCH29

H17NCH17

NC

Test Point & MARK

5

H22NCH22

1

5

9

8

7

6

1

H19NCH19

NC

9

4

8

3

7

2

6

NC

1

H28NCH28

NC

1

NC

H30NCH30

H27NCH27

NC

1

SN2NCSN2

SNNCSN

NC

4

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

3

@

深圳市康冠技术有限公司

Copyright@ ShenZhen KTC Technology Co., LTD

2

文件名称：

文件编号：

设计:

发行部门：生效日期：

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Thursday, April 21, 2016

1

of

511

5

MST chip

C95

C95 1uF

TP6TP6

1

UART-RX

3D_EN

UART-TX

AMP-MUTE

IC底下需要加一个3mm 的hole

D D

SYSTEM-RST

1

HDMI-CEC

BIN0 GIN0 GIN0N RIN0

BIN1 GIN1 GIN1N RIN1 VCOM0 CVBS0

LED-R

+5V_Standby

R392

4.7K

R390 100RR390 100R R391 100RR391 100R

RESET

2

IRIN

3

CEC

4

HOTPLUGA_HDMI20_5V

5

HOTPLUGB_HDMI20_5V

6

HOTPLUGC_HDMI20_5V

7

MHL_CABLE_DET

8

AVDD_NODIE

9

AVDD33_MHL3

10

B_RXCN

11

B_RXCP

12

B_RX0N

13

B_RX0P

14

AVDD11_MHL3

15

B_RX1N

16

B_RX1P

17

B_RX2N

18

B_RX2P

19

GND

20

A_RXCN

21

A_RXCP

22

A_RX0N

23

A_RX0P

24

AVDD11_MHL3

25

A_RX1N

26

A_RX1P

27

A_RX2N

28

A_RX2P

29

GND

30

AVDD_HDMI_5V_PC

31

HOTPLUGC

32

VDD

33

HSYNC0

34

BIN0P

35

GIN0P

36

GIN0M

37

RIN0P

38

VSYNC0

39

AVDD3P3_ADC

40

BIN1P

41

GIN1P

42

GIN1M

43

RIN1P

44

VCOM

45

CVBS0

46

CVBS_OUT1

47

LINEIN_L0

48

LINEIN_R0

49

VRM_ADC

50

VAG

51

LINEIN_L4

52

LINEIN_R4

53

LINEOUT_L3

54

LINEOUT_R3

U1 MSD6A638JSM

LED-R 3

UART-TX UART-RX

5

Crystal

IRIN

IRIN3

HOTPLUGA_HDMI20_5V HOTPLUGB_HDMI20_5V HOTPLUGC_HDMI20_5V

MHL_CABLE_DET

AVDD_NODIE +3.3V_MHL3

HDMI2-CLKN HDMI2-CLKP HDMI2-RX0N HDMI2-RX0P

AVDDL_DVI

HDMI2-RX1N HDMI2-RX1P HDMI2-RX2N HDMI2-RX2P

HDMI1-CLKN HDMI1-CLKP HDMI1-RX0N HDMI1-RX0P

AVDDL_DVI

HDMI1-RX1N HDMI1-RX1P HDMI1-RX2N HDMI1-RX2P

AVDD5V_MHL

HDMI3-HPDIN

+1.2V_VDDC

AVDD3P3_MPLL

R186 4.7KR186 4.7K R185 4.7KR185 4.7K

R200 4.7KR200 4.7K

UART_TX UART_RX

VGA_HSYNC

VGA_VSYNC

CVBS_OUT

LINE_IN_0L LINE_IN_0R AUVRM AUVAG

PANEL_ON/OFF

VBL_CTRL

R393

4.7K

DEBUG_UART

C C

B B

CHIP_CONFIG[2:0] {PANEL_ON/OFF,LED-R,VBL_CTRL}

Value Mode Description 3'b000 SB51_ExtSPI 51 boot from SPI 3'b001 HEMCU_ExtSPI ARM boot from SPI 3'b010 HEMCU_ROM_EMMC ARM boot from ROM; outer storage is eMMC 3'b011 HEMCU_ROM_NAND ARM boot from ROM; outer storage is NAND 3'b100 DBUS for test only 3'b101 HEMCU_ExSPI_AUT 3'b110 HEMCU_ROM_EMMC_AUT 3'b111 HEMCU_ROM_NAND_AUT

Chip Configuration Selection(Default EMMC 010)

+3.3V_Standby

A A

UART_TX7 UART_RX7

HDMI2-HPDIN

214

213

212

217

218

216

215

GND

EPAD

DDCA_DA

DDCA_CK

GPIO_PM[5]

GPIO_PM[1]

AVDD_EAR3355EARPHONE_OUTL56EARPHONE_OUTR57IFAGC58VIFP59VIFM60AVDD3P3_DADC61AVDD3P3_DMPLL62XTAL_IN63XTAL_OUT64C_RXCN66C_RXCP67C_RX0N68C_RXOP69C_RX1N71C_RX2N73C_RX2P74GND75DM_P076DP_P077DM_P178DP_P179DM_P280DP_P281VDD82VDD1583VDD1584VDDIO_CMD_A85VDDIO_MCLK_A86GND87VDDIO_DATA_A88AVDD_PLL_A

DIFP+

DIFM-

EARPHONE-OUTR

EARPHONE-OUTL

IF_AGC

AVDD_AU33

IC Configuration Selection

C281

XTALO

12

24MHZ

XTALI

C284 33pFC284 33pF

NOTE:

晶体频偏需要小于

VID0

T_RESET

HDMI2-SDA

HDMI2-SCL

HDMI3-SDA

LED-R

HDMI1-SCL

HDMI1-SDA

HDMI3-SCL

GND_FUUSE

HDMI1-HPDIN

211

208

207

206

205

203

204

210

209

202

201

VID0

LED-R

HOTPLUGB

HOTPLUGA

DDCDB_DA

DDCDB_CK

DDCDA_DA

DDCDA_CK

DDCDC_DA

DDCDC_CK

GPIO_PM[8]

GND_EFUSE

MSD6A638JSM

AVDD33_MHL3_C65AVDD11_MHL3_C70C_RX1P

HDMI3-RX0P

HDMI3-RX0N

HDMI3-CLKN

XTALO

XTALI

HDMI3-CLKP

HDMI3-RX1N

AVDDL_DVI

AVDD_DADC

+3.3V_MHL3_C

AVDD3P3_DMPLL

C1

33pF

Y201

3

C2

30PPM

1uF

KEY_SAR0

PWR-ON/OFF

power_detect

MDI_TP

MDI_TN

KEY0-in

DVDD_NODIE

PANEL_ON/OFF

VBL_CTRL

194

200

195

198

192

191

197

196

199

193

TP

LED1

LED0

SAR0

SD_CDZ

VBL_CTRL

Power_detect

PWR-ON/OFF

DVDD_NODIE

PANEL_ON/OFF

72

HDMI3-RX2P

HDMI3-RX2N

USB1_D+

USB1_D-

USB2_D+

USB2_D-

HDMI3-RX1P

USB0_D-

USB0_D+

+5V_Standby

C285

2.2uF

R269

R269 100K

100K

Chip Audio to GND of L/C

L20

L20 120Ω/500mA

120Ω/500mA

L0402

Close to MST IC with width trace

需要选择阻值小

(L20

或

500R的Bead)

190

TN

+1.2V_VDDC

4

All I2S trace need to shield GND

3

DVDD_DDR

AVDD_DDR_B

AVDD_PLL_B

DRAM_Power_B

AVDD_ETH

+1.2V_VDDC

MDI_RP

MDI_RN

183

189

185

187RN188

181

186

184

182

180

178

AVDD33_ETH

AVDD_DDR_A

根据实际电源上电时序调整

BAV99

1

C199

0.1uF

3

D202

VDD

GND

AVDD_MOD

DVDD_DDR_B

VDDIO_DATA_B

VDDIO_MCLK_B

DVDD_DDR_A90VDD91VDD_CPU92VDD_CPU93GND94GND95VDD_CPU96VDD_CPU97TS0_CLK98TS0_SYNC99TS0_VLD

89

+3.3V_PLL

DVDD_DDR

+1.2V_VDDC

R272 1KR272 1K

2

AUVRM

AUVAG

C200

C200 10uF/6.3V

10uF/6.3V

Bead,

4

179

VDD15

VDDIO_CMD_B

+1.2V_VDDC_CPU

RESET

不可以选择

RP

DRAM_Power_A

HDMI1-ARC

SPDIF_OUT

I2C_SCL

I2C_SDA

175

171

170

174

172

177

173

176

ARC0

VDD15

DDCR_CK

SPDIF_OUT

I2S_OUT_SD

I2S_OUT_WS

I2S_OUT_BCK

I2S_OUT_MCK

EMMC_IO11 / EMMC_RSTn / NAND_WEZ

GPIO87

100

101

102

System-RST

0R

+1.2V_VDDC

BRI_ADJ

LR_SYNC

169

163

167

166

165

164

168

VDD

PWM2

TCON0

TCON1

TCON2

TCON3

BRI_ADJ

DDCR_DA

TCON4 TCON5 TCON6

AVDD15_MOD

GND

AVDDL_PREDRV

AVDDL_MOD

LVSYNC LHSYNC

LDE LCK

R_ODD[7] / LVB0-

R_ODD[6] / LVB0+

R_ODD[5] / LVB1-

R_ODD[4] / LVB1+

R_ODD[3] / LVB2- / Vx1_0-

R_ODD[2] / LVB2+ / Vx1_0+

R_ODD[1] / LVBCLK- / Vx1_1-

R_ODD[0] / LVBCLK+ / Vx1_1+

G_ODD[7] / LVB3- / Vx1_2-

G_ODD[6] / LVB3+ / Vx1_2+

AVDD_MOD

G_ODD[5] / LVB4- / Vx1_3-

G_ODD[4] / LVB4+ / Vx1_3+

G_ODD[3] / LVA0- / Vx1_4-

G_ODD[2] / LVA0+ / Vx1_4+

G_ODD[1] / LVA1- / Vx1_5-

G_ODD[0] / LVA1+ / Vx1_5+

B_ODD[7] / LVA2- / Vx1_6-

B_ODD[6] / LVA2+ / Vx1_6+

B_ODD[5] / LVACLK- / Vx1_7-

B_ODD[4] / LVACLK+ / Vx1_7+

B_ODD[3] / LVA3- / LOCKn

B_ODD[2] / LVA3+ / HTPDn

B_ODD[1] / LVA4-

B_ODD[0] / LVA4+

VDD

AVDD_EMMC_3318

SD_D3 / NAND_WPZ

SD_D2 / NAND_ALE SD_D1 / NAND_CLE

SD_D0 / NAND_RBZ

I2C-SCL3,6,9

I2C-SDA3,6,9

R230

R230 1K/NC

1K/NC

R233

10K/NC

R229

R229 1K/NC

1K/NC

GND

VDD_CPU

+3.3V_Normal

R194

4.7K

I2C-SCL

I2C-SDA

+12V_Normal

Power_Detect,Normal work V=1V

power_detect

EMMC_IO10 / EMMC_CLK / NAND_REZ

EMMC_IO9 / EMMC_CMD / NAND_CEZ EMMC_IO6 / EMMC_D[6] / NAND_AD[0] EMMC_IO7 / EMMC_D[7] / NAND_AD[1] EMMC_IO2 / EMMC_D[2] / NAND_AD[2] EMMC_IO1 / EMMC_D[1] / NAND_AD[3] EMMC_IO0 / EMMC_D[0] / NAND_AD[4] EMMC_IO3 / EMMC_D[3] / NAND_AD[5] EMMC_IO4 / EMMC_D[4] / NAND_AD[6] EMMC_IO5 / EMMC_D[5] / NAND_AD[7]

GPIO82

GPIO81

TS0_D0

VDDP

SD_CLK / NAND_CEZ1

SD_CMD

108

103

104

105

106

107

+3.3V_Normal

IIC

Detect EMMC/NAND Flash Power

162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109

WIFI_EN

B0M B0P B1M B1P B2M B2P BCKM BCKP B3M B3P

B4M B4P A0M A0P A1M A1P A2M A2P ACKM ACKP A3M A3P A4M A4P

NAND-REZ NAND-WEZ NAND-CEZ NAND-D0 NAND-D1 NAND-D2 NAND-D3 NAND-D4 NAND-D5 NAND-D6 NAND-D7

R195

4.7K

R196 100RR196 100R

R197 100RR197 100R

AVDD15_MOD

AVDDL_MOD

AVDD_MOD

+1.2V_VDDC VDDP_3318

+1.2V_VDDC_CPU

I2C_SCL

I2C_SDA

+3.3V_Normal

I2C-SCL I2C-SDA

CON5-2.0

3

J104

1 2 3 4 5

3

2

HDMI/MHL

HDMI1-ARC HDMI1-ARC

HDMI1

HDMI1_RX2P HDMI1-RX2P

HDMI1_RX2N HDMI1-RX2N HDMI1_RX1P HDMI1-RX1P

HDMI1_RX1N HDMI1-RX1N HDMI1_RX0P HDMI1-RX0P

HDMI1_RX0N HDMI1-RX0N HDMI1_CLKP HDMI1-CLKP

HDMI1_CLKN HDMI1-CLKN

HDMI1-SCL HDMI1-SCL HDMI1-SDA HDMI1-SDA

HDMI1-HPDIN HDMI1-HPDIN

HDMI2

HDMI2_RX2P HDMI2-RX2P

HDMI2_RX2N HDMI2-RX2N HDMI2_RX1P HDMI2-RX1P

HDMI2_RX1N HDMI2-RX1N HDMI2_RX0P HDMI2-RX0P

HDMI2_RX0N HDMI2-RX0N HDMI2_CLKP HDMI2-CLKP

HDMI2_CLKN HDMI2-CLKN

HDMI2-SCL HDMI2-SCL HDMI2-SDA HDMI2-SDA

HDMI2-HPDIN HDMI2-HPDIN

HDMI3

HDMI3_RX2P HDMI3-RX2P HDMI3_RX2N HDMI3-RX2N HDMI3_RX1P HDMI3-RX1P HDMI3_RX1N HDMI3-RX1N

HDMI3_RX0P HDMI3-RX0P

HDMI3_RX0N HDMI3-RX0N

HDMI3_CLKP HDMI3-CLKP HDMI3_CLKN HDMI3-CLKN

HDMI3-SCL HDMI3-SCL HDMI3-SDA HDMI3-SDA

HDMI3-HPDIN HDMI3-HPDIN

MHL_Cable_DET MHL_Cable_DET AVDD5V_MHL AVDD5V_MHL

HDMI-CEC HDMI-CEC

HDMI Power detect

HOTPLUGA_HDMI20_5V HOTPLUGA_HDMI20_5V HOTPLUGB_HDMI20_5V HOTPLUGB_HDMI20_5V

HOTPLUGC_HDMI20_5V HOTPLUGC_HDMI20_5V

HDMI1-ARC 8

HDMI1-RX2P 8

HDMI1-RX2N 8 HDMI1-RX1P 8

HDMI1-RX1N 8 HDMI1-RX0P 8

HDMI1-RX0N 8 HDMI1-CLKP 8

HDMI1-CLKN 8

HDMI1-SCL 8 HDMI1-SDA 8

HDMI1-HPDIN 8

HDMI2-RX2P 8

HDMI2-RX2N 8 HDMI2-RX1P 8

HDMI2-RX1N 8 HDMI2-RX0P 8

HDMI2-RX0N 8 HDMI2-CLKP 8

HDMI2-CLKN 8

HDMI2-SCL 8 HDMI2-SDA 8

HDMI2-HPDIN 8

HDMI3-RX2P 8 HDMI3-RX2N 8 HDMI3-RX1P 8 HDMI3-RX1N 8

HDMI3-RX0P 8

HDMI3-RX0N 8

HDMI3-CLKP 8 HDMI3-CLKN 8

HDMI3-SCL 8 HDMI3-SDA 8

HDMI3-HPDIN 8

MHL_Cable_DET 8 AVDD5V_MHL 8

HDMI-CEC 8

HOTPLUGA_HDMI20_5V 8 HOTPLUGB_HDMI20_5V 8

HOTPLUGC_HDMI20_5V 8

Source Input

VGA

VGA_HSYNC VGA_VSYNC RIN0 BIN0 GIN0 GIN0N

Compoent

RIN1 BIN1 GIN1 GIN1N

AV IN

CVBS0 VCOM0

CVBS OUT

CVBS_OUT

Audio input

LINE_IN_0R LINE_IN_0L

C203 47nFC203 47nF C204 47nFC204 47nF C205 47nFC205 47nF C206 47nFC206 47nF

C232 47nFC232 47nF C227 47nFC227 47nF C242 47nFC242 47nF C231 47nFC231 47nF

C228 47nFC228 47nF C229 47nFC229 47nF

C220 2.2uFC220 2.2uF C223 2.2uFC223 2.2uF

R286 33RR286 33R R287 33RR287 33R R288 33RR288 33R R289 68RR289 68R

R294 33RR294 33R R295 33RR295 33R R296 33RR296 33R R297 68RR297 68R

R241 33RR241 33R R242 68RR242 68R

AV1_IN

VGA_HSYNC 7 VGA_VSYNC 7 VGA-Rin 7 VGA-Bin 7 VGA-Gin 7

YPbPr_PR 7 YPbPr_PB 7 YPbPr_Y 7

AV1_IN 7

CVBS_OUT 7

HD_RIN 7 HD_LIN 7

USB/LAN

USB0_DUSB0_D+

USB1_DUSB1_D+ USB2_DUSB2_D+

MDI_TP MDI_TN MDI_RP MDI_RN

AGC

R232 10KR232 10K

IF_AGC

R236 0RR236 0R

IF /AGC

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

C262

C262 22nF

22nF

+3.3V_TU

IF-AGC

USB0_D- 7 USB0_D+ 7

USB1_D- 7 USB1_D+ 7 USB2_D- 7 USB2_D+ 7

MDI_TP 8 MDI_TN 8 MDI_RP 8 MDI_RN 8

IF-AGC 9

USB

LAN

Close to MST IC with width trace

C192

DIFP+

0.1uF

C193

DIFM-

0.1uF

DIFP

DIFP 9

DIFM

DIFM 9

@

深圳市康冠技术有限公司

Copyright@ ShenZhen KTC Technology Co., LTD

IF

2

VB1/LVDS

Audio Out

HP out trace need to shield GND

EARPHONE-OUTR

HP and AMP OUT

EARPHONE-OUTL

SPDIF_OUT

Close to MSTAR IC

EMMC/NAND/SD

NAND-REZ NAND-CEZ NAND-WEZ

NAND-D0 NAND-D1 NAND-D2 NAND-D3

NAND-D4 NAND-D5 NAND-D6 NAND-D7

NAND-D[7:0]9

GPIO

控制

PWR-ON/OFF

AMP-MUTE

PANEL_ON/OFF

BRI_ADJ

VBL_CTRL

WIFI_EN

R2 100RR2 100R

T_RESET

VID0

1

TP47TP47

TP47 请靠近U15 附近放

VID0 预留VDDC 控制电压使用

B0M

B0P

B1M B1P

B2M B2P BCKM

BCKP

B3M B3P B4M B4P

A0M A0P

A1M A1P

A2M A2P

ACKM ACKP

A3M A3P

A4M A4P

I2C-SCL I2C-SDA

LR_SYNC 3D_EN

共用

C235

NC/33pF

卡

NAND-REZ 9 NAND-CEZ 9 NAND-WEZ 9

NAND-D0 9 NAND-D1 9 NAND-D2 9 NAND-D3 9

NAND-D4 9 NAND-D5 9 NAND-D6 9 NAND-D7 9

B0M 6 B0P 6

B1M 6 B1P 6

B2M 6 B2P 6 BCKM 6

BCKP 6

B3M 6 B3P 6 B4M 6 B4P 6

A0M 6 A0P 6

A1M 6 A1P 6

A2M 6 A2P 6

ACKM 6

ACKP 6

A3M 6 A3P 6

A4M 6 A4P 6

I2C-SCL 3,6,9

I2C-SDA 3,6,9

LR_SYNC 6 3D_EN 6

LED2 4

EARPHONE-OUTR 7

EARPHONE-OUTL 7

SPDIF_OUT 7

NAND-D7 NAND-D6 NAND-D5 NAND-D4 NAND-D3 NAND-D2 NAND-D1 NAND-D0

PWR-ON/OFF 3

AMP-MUTE 7

PANEL_ON/OFF 3

BRI_ADJ 3

VBL_CTRL 3

WIFI_EN 7

TUNER_RESET 7

文件名称：

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

文件编号：

文件编号：设计:

设计:

设计: 发行部门：生效日期：

发行部门：生效日期：

T4298

张志清

研发处

1

KTC ISO9001.ISO14001体系文件

版本：3.0

版本：3.0 审核:

审核:

Thursday, April 21, 2016

1

页数:

页数: 批准:

批准:

of

611

5

4

3

2

1

Core power (

D D

C C

B B

元件需要尽量靠近

Star connection from VDDC DC-DC

L211 near DC-DC,C296 near IC

25mil

L211 120R/500mAL211 120R/500mA

C295

10uF/6.3V

near L211

25mil

30mil

C190

25mil

C187

0.1uF

C94

0.1uF

25mil

Close to MTS IC

C188

0.1uF

如果做

40mil

+3.3V_Normal

10uF/6.3V

+1.8V_Normal VDDP_3318

AVDDL_DVI

R234 0RR234 0R

C189

0.1uF

TTL

C186

0.1uF

C404

0.1uF

输出，需要将

AVDDL_MOD+1.2V_VDDC

C296

1uF

DVDD_DDR

C224

0.1uF

AVDD_MOD

+3.3V_PLL+3.3V_MHL3_C+3.3V_MHL3+3.3V_Normal

C405

C405 1uF

1uF

AVDD_MOD电用0R

C185

0.1uF

IC;由于IC

FOR VB1

C294

0.1uF

C298

C297

0.1uF

2.2uF

C230

C225

0.1uF

隔开

AVDD_PLL_B

C191

0.1uF

贴散热片限高原因，所以IC的滤波电容请选择

Close to MTS IC

+1.2V_VDDC

120mil

C499

C501

10uF/6.3V

0.1uF

Close to MTS IC

C213/C211/C212/C214 close to the IC ball ;C243/C237 加112 pin

+1.2V_VDDC_CPU

30mil

C239

10uF/6.3V

80mil

C236

2.2uF

2.2uF 10uF/6.3V

10uF/6.3V

Close to CHIP MIU_A side

AVDD_DDR_A+1.5V_DDR

Close to MTS IC

C173

C173 1uF

1uF

AVDD3.3V_ST+3.3V_Standby

C181

C210

2.2uF

15mil

L30 120R/500mA

L0402

10mA,15mil 40mA,15mil

To reduce ripple,please mount cap on the Board bottom and near IC ball

C504

C502

0.1uF

C234

10uF/6.3V

C500

0.1uF

C237

10uF/6.3V/bot

DRAM_Power_A

C174

C503

0.1uF

C175

0.1uF

C103

0.1uF

C504

2.2uF

C176

0.1uF

C506

10uF/6.3V

C154

C142

0.1uF

Close to CHIP MIU_B side

AVDD_DDR_B

C172

10uF/6.3V

C505

0.1uF

C155

0.1uF

DRAM_Power_B

C167

2.2uF

C498

0.1uF

C171

0.1uF

C209

0.1uF

30mil

Close to MTS IC

C183

C182

C180

0.1uF

AVDD_AU33AVDD3.3V_ST

0.1uF

15mil

AVDD3.3V_ST AVDD3P3_DMPLL AVDD3.3V_ST AVDD3P3_MPLL

L32 1000R/500mA

L0402

C179

0.1uF

L0402

C198

0.1uF

0603或0402

C507

0.1uF

底部

Close to MTS IC

C226

C240

0.1uF

0.1uF 10uF/6.3V

10uF/6.3V

AVDD15_MOD

FOR VB1

L212 120R/500mAL212 120R/500mA

C170

0.1uF

15mil

L42 1000R/500mA

L0402

C233

2.2uF

C168

0.1uF

40mA,15mil

AVDD_DADCAVDD_NODIE AVDD_ETH

封装，勿选用

C243

0.1uF/bot

C241

0.1uF

0805封装)

Heat Sink

R8 0R/NCR8 0R/NC

S1

1

2

Heat-sink58X58mm

R4 0R/NCR4 0R/NC

A A

KTC ISO9001.ISO14001体系文件

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

5

4

3

Copyright@ ShenZhen KTC Technology Co., LTD

2

文件名称：

文件编号：

设计:

发行部门：生效日期：

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Thursday, April 21, 2016

1

of

711

5

VB1 For CMI LG Sansung &LVDS

Bom

D D

B0M B0P B1M B1P

B2M B2P BCKM BCKP

B3M B3P B4M B4P

A0M A0P A1M A1P A2M A2P ACKM ACKP

C C

A3M A3P

A4M

Net

B B

A A

可以用0R电阻，方便调试

互相更改

(VB1使用0.1uf

,lvds使用0R，lvds时RP452

+3.3V_Normal

R472 0RR472 0R R473 0RR473 0R

B0M B0P

B1M B1P

B2M B2P BCKM

BCKP

B3M B3P B4M B4P

A0M A0P

A1M A1P

A2M A2P

ACKM ACKP

A3M A3P

A4M A4P

I2C-SCL I2C-SDA

LR_SYNC 3D_EN

RP452

7531

NC/0RX4

0.1uF

0.1uF C464

C464

0.1uF

0.1uF C465

C465

0.1uF

0.1uF C466

C466

0.1uF

0.1uF C467

C467

0.1uF

0.1uF C468

C468

0.1uF

0.1uF C469

C469

0.1uF

0.1uF C470

C470

0.1uF

0.1uF C471

C471

0.1uF

0.1uF C472

C472

0.1uF

0.1uF C473

C473

0.1uF

0.1uF C474

C474

0.1uF

0.1uF C475

C475

0.1uF

0.1uF C476

C476

0.1uF

0.1uF C477

C477

0.1uF

0.1uF C478

C478

0.1uF

0.1uF C479

C479

R474 10KR474 10K R475 10KR475 10K

LVDS和VBY

要上件）

8642

I2C-SCL 3,4,9

I2C-SDA 3,4,9

LR_SYNC 4 3D_EN 4

VBY0N VBY0P VBY1N VBY1P

VBY2N VBY2P VBY3N VBY3P

VBY4N VBY4P VBY5N VBY5P VBY6N VBY6P VBY7N

B0M 4 B0P 4

B1M 4 B1P 4

B2M 4 B2P 4 BCKM 4

BCKP 4

B3M 4 B3P 4 B4M 4 B4P 4

A0M 4 A0P 4

A1M 4 A1P 4

A2M 4 A2P 4

ACKM 4

ACKP 4

A3M 4 A3P 4

A4M 4 A4P 4

VBYLOCKn VBYHTPDn

VBY0N_C VBY0P_C VBY1N_C VBY1P_C

VBY2N_C VBY2P_C VBY3N_C VBY3P_C

VBY4N_C VBY4P_C VBY5N_C VBY5P_C VBY6N_C VBY6P_C VBY7N_C VBY7P_C

需要

LVDS/TCON

VBY1

时需要NC，否则影响

靠近

VBY

座子放置

RP453

7531

NC/0RX4

RP454

7531

NC/0RX4

RP455 NC/0RX4

7531

RP456

7531

NC/0RX4

R493 NC/0RR493 NC/0R R494 NC/0RR494 NC/0R

R496 NC/0RR496 NC/0R R497 NC/0RR497 NC/0R

该部分需要上件，

VBY

RXO0-P32 RXO0+3D_EN_C RXO1-AGP RXO1+P28

RXO2RXO2+ RXOCRXOC+

8642

RXO3RXO3+ RXO4RXO4+

8642

RXE0RXE0+ RXE1RXE1+

8642

RXE2RXE2+ RXECRXEC+VBY7P

8642

RXE3RXE3+

RXE4RXE4+A4P

4

CMI/LG/BOE 4K2K@60HZ

Panel_VCC Panel_VCC_VB1

10uF/16V

C128

PWM IN#

BL-ADJUST

PWM OUT

信号

配奇美42寸屏时，

配

LG 4K

屏时，

LD_EN

配奇美屏时，需下拉，上

3D_LR_in LR_SYNC

+3.3V_Normal

Note1: Pin44（Panel端为Pin8)华星Panel Note2：Pin38（Panel端为Pin14) LG panel 需要NC,CMI，Susuang

：

Pin43（Panel端为Pin9)，PIN32（Panel端为Pin20)

Note3 Note4：Pin37（Panel端为Pin15)，Pin36（Panel端为Pin16) LG panel为Data Format CMI

为眼睛同步的输入输出，目前设置为

：

Pin30（Panel端为Pin22)，Pin29（Panel端为Pin23)Samsung

Note5 Pin30（Panel端为Pin22) 为CMI Local dimming Note6：Pin31（Panel端为Pin21) 为sansung pane 3D enable

：

Pin35（Panel端为Pin17) 为CMI pane 3D enable

Note7

以上接法主要考虑开发过程，如果客户做MP，请按

R452 0RR452 0R

PWM OUT BL-ADJUST

R450 0R/NCR450 0R/NC

R442 0R/NCR442 0R/NC

R444 0R/NCR444 0R/NC

PIN12

需接地，

Note4

R436

。

R436 10K/CMIR436 10K/CMI R421 0R/NCR421 0R/NC R422 NCR422 NC

R437 10K/LGR437 10K/LG

R416

R441 10K/LG（G+）/CMIR441 10K/LG（G+）/CMI

R440 10K/LG（RGB

R439 10KR439 10K R417 0R/NCR417 0R/NC R418 NCR418 NC

I2C-SDA

R437

。

I2C-SCL

配

LCxxxEGY 4K屏(G+屏)时，R441 LCxxxEQJ 4K屏(RGB屏)时，R440

配

+3.3V_Normal

3D_LR_in

需上拉，上

Note5

RXE4RXE3RXECRXE2RXE1RXE0RXO4RXO3RXOCRXO2RXO1RXO0-

PWM OUT#

上件。

为地，

NC

CN401

CN401 40PIN/2.0mm/nc

40PIN/2.0mm/nc

GND1VCC GND3VCC

5

NC

7

GND

9

GND

11

GND

13

GND

15

E4-

17

E3-

19

EC-

21

E2-

23

E1-

25

E0-

27

O4-

29

O3-

31

OC-

33

O2-

35

O1-

37

O0-

39

GND

上件。

3D_EN

VBYHTPDn VBYLOCKn

R1 0RR1 0R

）

3D_EN

Note7

Note3

R476 NCR476 NC

LD_EN AGP

R423 0R/BOER423 0R/BOE

BOE

屏时，

当配

VBY0N_C VBY0P_C

VBY1N_C VBY1P_C

VBY2N_C VBY2P_C

VBY3N_C VBY3P_C

VBY4N_C VBY4P_C

VBY5N_C VBY5P_C

VBY6N_C VBY6P_C

VBY7N_C VBY7P_C

CMI,LG,Susung

，需要NC，不支持

设置，设置为

，目前

panel

实际使用处理

2 4 6

VCC

8

VCC

10

VCC

12

P_PWM

14

GND

16

E4+

18

E3+

20

EC+

22

E2+

24

E1+

26

E0+

28

O4+

30

O3+

32

OC+

34

O2+

36

O1+

38

O0+

40

GND

3

1 2 3 4 5 6 7 8

Note1 Note3

9 10

Note2

R416 0R/CMI&BOER416 0R/CMI&BOE

Data_fromat_0

Data_fromat_1LR_SYNC

R480 NCR480 NC

R423

为电源，为了防止实验烧坏单板，

disable

，目前

NC.

Panel_VCC

11 12 13 14 15 16 17 18 19 20

P32

21

3D_EN_C

22

Note6

23 24

P28

25 26 27

需贴。

28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44

46 47 48 49 50 51

需要接地，为兼容

NC

4V4O

模式

为眼睛同步的输入输出，目前设置为

NC.

R448 0R/NCR448 0R/NC

RXE4+ RXE3+ RXEC+ RXE2+ RXE1+ RXE0+ RXO4+ RXO3+ RXOC+ RXO2+ RXO1+ RXO0+

55

51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10

54

，设置为

52

G1

51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10

9

8

7

6

5

4

3

2

1

G2

53

“01”，2divison

2

CSOT(

J455

G3

FI-RE51S-HF

56

G6

57

G7

58

G8

G9

G10

G11

G4

NC.

NC,

VBY0N VBY0P

VBY1N

VBY1P

R424 0RR424 0R

VBY2N VBY2P

59

VBY3N

VBY3P

R425 0RR425 0R

VBY4N

60

VBY4P

VBY5N

VBY5P

VBY6N VBY6P

VBY7N

VBY7P

R426 0RR426 0R

R427 0RR427 0R

61

，

RP458

7531

0RX4

RP459

7531

0RX4

RP460

7531

0RX4

RP461

7531

0RX4

8642

VBY0N_C VBY0P_C

VBY1N_C

VBY1P_C

VBY2N_C VBY2P_C

VBY3N_C

VBY3P_C

VBY4N_C VBY4P_C

VBY5N_C

VBY5P_C

VBY6N_C VBY6P_C

VBY7N_C

VBY7P_C

+3.3V_Normal

LR_SYNC 3D_LR_in 3D_EN

华星

Panel_VCC

VBY0N VBY0P

VBY1N VBY1P

VBY2N VBY2P

VBY3N VBY3P

HTPDN VBYHTPDn LOCKN VBYLOCKn

VBY4N VBY4P

VBY5N VBY5P

VBY6N VBY6P

VBY7N VBY7P

R455 0RR455 0R R454 0RR454 0R R477 0R/ncR477 0R/nc

R478 10K/ncR478 10K/nc

高电平为3D。低或空为

2D

R482 10KR482 10K

低电平为

) 4K2K@60HZ

55

1

51

2

50

3

49

4

48

5

47

6

46

7

45

8

44

9

43

10

42

11

41

12

40

13

39

14

38

15

37

16

36

17

35

18

34

19

33

20

32

21

31

22

30

23

29

24

28

25

27

26

27

25

28

24

29

23

30

22

31

21

32

20

33

19

34

18

35

17

36

16

37

15

38

L/R L/R_O 2D/3D_Enable

。

Disable

Local-Dim

14

39

13

40

12

41

11

42

10

43

9

44

8

45

7

46

6

47

5

48

4

。

49

3

50

2

51

1

54

1

52

J454

G3

G1

51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

G2

NC/FI-RE51S-HF

56

G6

57

G7

58

G8

59

G9

60

G10

61

G11

G4

53

LVDS

KTC ISO9001.ISO14001体系文件

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

5

4

3

Copyright@ ShenZhen KTC Technology Co., LTD

2

文件名称：

文件编号：

设计:

发行部门：生效日期：

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Thursday, April 21, 2016

1

of

811

5

CN311

12

D816NCD816

D815NCD815

D814NCD814

NC

YPBPR_IN

D D

HD-AuLin

R406 10KR406 10K

HD-AuRin

AV1_IN

CN307

D825NCD825

1 2

NC

R407 10KR407 10K

D824NCD824

1 2

NC

YPBPR & AV IN

Coaxial

CN314

SPDIF_O

D826NCD826

1 2

NC

HP_MUTE

R280 10kR280 10k

+3.3V_Standby

EARPHONE-OUTL4

R556 100RR556 100R

R557

R557 100R

100R

R292

4.7k

R283 33KR283 33K

EARPHONE-OUTR4

1 2

C C

AMP-MUTE

L:ON H:MUTE

B B

NC

Close to Mstar IC

R408

R408 12K

12K

Keep A_GND trace with Signal. Keep Spacing for L/R cahnnel. Keep trace width(12mil+).

SPDIF OUT

R293 0RR293 0R

Q27

1

3904

2 3

R285

R285 10K

10K

D206 1N4148D206 1N4148

R281 68KR281 68K

R298 68KR298 68K

R402

R401

75R

R405

R409

75R

12K

SPDIF_OUT 4

R273

10K

1

Q209

3906

YPbPr_Y 4

YPbPr_PB 4

YPbPr_PR 4

R404

R404 75R

75R

AV1_IN 4

HD_LIN 4

HD_RIN 4

D819NCD819

1 2

NC

VIDEO-OUT/YELLOW

CN315

VIDEO-OUT

MUTE

AMP_12V

C304

100uF/16V

23

R266 33KR266 33K

C158

1uF

C250 0.47uFC250 0.47uF

C249 0.47uFC249 0.47uF

Close to Mstar IC

AVOUT-V

RIN_N

RIN_P

C247

R415 0RR415 0R

D817NCD817

1 2

NC

R2821kR282 1k

R291 100KR291 100K

L:SHUTDOWN

SD

1

2

LIN_P

3

LIN_N

4

5

6

7

8

9

10

11

12

13

14

1uF/16V

1 2

D207

1N4148

R270

100k

C330 0.47uFC330 0.47uF

C325 0.47uFC325 0.47uF R290

AUDIO AMP

D811NCD811

1 2

NC

R410

R410 75R

75R

U203

SD

FAULT

LINP

LINN

LIMRATE

GAIN

SSCTRL

LIMTHRES

GVDD

AGND

RINN

RINP

1SPW

AVCC

TPA3140D2

4

CON501

1617

11

12

13

14

15

VGA

D810NCD810

1 2

NC

C401

C401 100pF

100pF

R268 10RR268 10R

1 6 2 7 3 8 4 9 5 10

D809NCD809

D808NCD808

1 2

NC

CVBS_OUT 4

GND

29

DDC_SCL_D DDC_SDA_D

R507

R507 10K

10K

28

PVCC

PVCC16PVCC

15

27

PVCC

OUTPL

OUTNL

OUTNR

OUTPR

BSPL

PGND

BSNL

BSNR

PGND

BSPR

D804NCD804

1 2

NC

C208

1nF

C211

1nF

R508

R508 10K

10K

VGA-Rin

VGA-Gin

VGA-Bin

D803NCD803

1 2

NC

C331

100nF

26

25

24

23

22

21

20

19

18

17

C248

100nF

12

AMP_12V

OUTPL

OUTNL

OUTNR

OUTPR

AMP_12V

D801NCD801 NC

R504100R R504100R R505100R R505100R

C324

10uF/16V

C306 0.22uFC306 0.22uF

VGA-Bin VGA-Gin VGA-Rin

UART_RX 4 UART_TX 4

VGA_VSYNC 4 VGA_HSYNC 4

+12V_NORMAL

0.22uF

C332

C305 0.22uFC305 0.22uF

C307

0.22uF

R502

R501

75R

L207

0805_BEAD

L213

0805_BEAD

L16 600R@100MHzL16 600R@100MHz

C212 330pFC212 330pF

C213 330pFC213 330pF

L11

L17

C195 330pFC195 330pF

C196 330pFC196 330pF

L26

3

VGA-Bin 4

VGA-Gin 4

VGA-Rin 4

R503

R503 75R

75R

Close to Mstar IC

AMP_12V

C251

470uF/16V

R263

1nF

C201

47R

R284

10R

R290

R254

10R

C197 1nFC197 1nF

47R

600R@100MHz

R264

R260

C202 1nFC202 1nF 47R

47R

10R

R262

R265

10R

C207

1nF

47R

600R@100MHz

Video

ROUT+

LOUT+

LOUT-

ROUT-

1

2

3

3Pin/2.0mm

-

GND

+

CN210CN210

2

1

CN202

CN318 USB_4PCN318 USB_4P

1

VCC

2

D-

3

D+

4

GND

5

SHIELD

6

SHIELD

1

VCC

2

D-

3

D+

4

GND

5

SHIELD

6

SHIELD

CN319

USB_4P

1 2 3 4 5

CN207

CON5-2.0mm

+5V_Standby

+5V_Normal

+5V_IN

IR_IN

GND

LED

KEY0

KEY1

PWR

GND

LED-2

9pin/2.0MM

CN103

所用IO口

按键功能

电阻值

电压值

5V_USB_WIFI

R169 10RR169 10R

USB ESD

D603NCD603

D605NCD605

1 2

NC

R157

10K

IR_5V

1

IR-in

2

3

LED+

4

KEY0-in

5

KEY1-in

6

KEY_POWER

7

C184

8

0.1uF

9

LED_LOGO

把按键板上的

欧

0.985V0V 1.951V 0.323V

分布电容要求

5V_USB1

5V_USB2

R17 100R/NCR17 100R/NC

D607NCD607

D606NCD606

1 2

NC

L4030R/0805 L4030R/0805

L4046V/1.1A L4046V/1.1A

L4056V/1.1A L4056V/1.1A

IR-in

0.1uF

C194

C150

0.1uF

R11 470RR11 470R

MENU

SOURCECH-CH+

D608NCD608

D609NCD609

1 2

NC

C619

0.1uF

C618

0.1uF

C617

0.1uF

R204 0RR204 0R

R205 1.2KR205 1.2K

R201 510RR201 510R

C177

0.1uF

Q4 3906Q43906

上的电阻R4由

SAR0

POWER

510欧6.8K2K0

2

<2pF

Note:0R

电阻靠近端子,减小

R601 0RR601 0R R602 0RR602 0R

Note:0R

电阻靠近端子,减小

R603 0RR603 0R R604 0RR604 0R

R605 0RR605 0R

R606 0RR606 0R

USB INTERFACE

5V_USB_WIFI

C603

10uF

5V_USB1

C604

10uF

5V_USB2

C605

10uF

R167 100RR167 100R

+5V_Standby

R1822KR182

2K

1

Q112

Q112 3904

3904

2 3

+5V_Standby

R14 4.7KR14 4.7K

1

3 2

6.8K改为10K

。

MENUV0L+V0L-

11.2K3.2K1.2K

2.325V1.337V0.671V

EOS.

USB0_DUSB0_D+

EOS.

USB1_DUSB1_D+

USB2_DUSB2_D+

USB POWER

R126 10KR126 10K

ED1

0.1pF

R16

4.7K

R18 1KR18 1K

USB0_D- 4 USB0_D+ 4

USB1_D- 4

USB1_D+ 4

WIFI_EN 4

USB2_D- 4 USB2_D+ 4

IRIN

R155 4.7KR155 4.7K

R171 1KR171 1K

C151

33pF

IRIN 4

LED

+3.3V_Standby

IR&KEY Connector

LED2 4

1

LED-R 4

KEY_SAR0 4

功放放大倍数调节

EARPHONE OUT

HP/BLUE

CN22

678

5 4 2 1 3

A A

HP_MUTE

E_AMP-L

E_AMP-R

5

R2711kR271

1k

R2761kR276

1k

C327

1nF

C328

1nF

C326 10ufC326 10uf

R278 68RR278 68R

R279 68RR279 68R C329 10ufC329 10uf

EARPHONE-OUTL 4

EARPHONE-OUTR 4

GAIN1(PIN6) GAIN0(PIN5)

0

01

1

4

0

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

AMP GAIN(db)

20

26

32

361

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

文件名称：

文件编号：

设计:

3

Copyright@ ShenZhen KTC Technology Co., LTD

2

设计:

发行部门：生效日期：

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Thursday, April 21, 2016

1

of

911

5

4

3

2

1

HDMI1(ARC)

CON801

DATA2+

DATA2 SHIELD

DATA2-

DATA1+

DATA1 SHIELD

DAT1A-

DATA0+

DATA0 SHIELD

DATA0-

CLK+

CLK SHIELD

D D

20

GND1

21

GND2

22

GND3

23

GND3

DDC/CEC GND

+5V POWER

HOT PLUG

HDMI/90D

HDMI1_RX2P

1 2

HDMI1_RX2N

3

HDMI1_RX1P

4 5

HDMI1_RX1N

6

HDMI1_RX0P

7 8

HDMI1_RX0N

9

HDMI1_CLKP

10 11

HDMI1_CLKN

12

CLK-

CEC

13

CEC

HDMI1_ARC

14

NC

HDMI1-DDC-SCL

15

SCL

HDMI1-DDC-SDA

16

SDA

17 18

HDMI1-HPD

19

HDMI1/5V

D813

ESD

1 2

HDMI1_RX2P HDMI1-RX2P

HDMI1_RX2N HDMI1-RX2N HDMI1_RX1P HDMI1-RX1P

HDMI1_RX1N HDMI1-RX1N HDMI1_RX0P HDMI1-RX0P

HDMI1_RX0N HDMI1-RX0N HDMI1_CLKP HDMI1-CLKP

HDMI1_CLKN HDMI1-CLKN

HDMI1-RX2P 4

HDMI1-RX2N 4 HDMI1-RX1P 4

HDMI1-RX1N 4 HDMI1-RX0P 4

HDMI1-RX0N 4 HDMI1-CLKP 4

HDMI1-CLKN 4

HDMI1-RX2P HDMI1-RX2N HDMI1-RX1P HDMI1-RX1N

HDMI1-RX0P HDMI1-RX0N HDMI1-CLKP HDMI1-CLKN

ED4 ESD/NCED4 ESD/NC

1

2

4

5

5 GND3GND

ED5 ESD/NCED5 ESD/NC

1

2

4

5

5 GND3GND

HDMI1-RX2P

10

HDMI1-RX2N

9

HDMI1-RX1P

7

HDMI1-RX1N

6

8

HDMI1-RX0P

10

HDMI1-RX0N

9

HDMI1-CLKP

7

HDMI1-CLKN

6

8

HDMI1-HPD

HDMI1/5V

R8021KR802

1K

3904

2 3

Q801

R807 10KR807 10K

1

R805

10K

HDMI1-HPDIN

HDMI1-HPDIN 4

HDMI1-DDC-SCL HDMI1-DDC-SDA

HDMI1/5V

R803

10K

HDMI1-DDC-SCL HDMI1-DDC-SDA

D800

D802

ESD

1 2

R804

10K

R801 22RR801 22R R806 22RR806 22R

Note:ESD

器件靠近端子放

HDMI1-SCL 4 HDMI1-SDA 4

HDMI2

HDMI2-HPD

HDMI2/5V

R8081KR808

1K

3904

2 3

Q802

R814 10KR814 10K

1

R809

10K

HDMI2-HPDIN

HDMI2-HPDIN 4

HDMI2-DDC-SCL HDMI2-DDC-SDA

CON802

DATA2+

DATA2 SHIELD

DATA2-

DATA1+

DATA1 SHIELD

DAT1A-

DATA0+

DATA0 SHIELD

DATA0-

CLK+

CLK SHIELD

20

GND1

21

GND2

22

GND3

23

GND3

DDC/CEC GND

+5V POWER

C C

HOT PLUG

HDMI/90D

HDMI2_RX2P

1 2

HDMI2_RX2N

3

HDMI2_RX1P

4 5

HDMI2_RX1N

6

HDMI2_RX0P

7 8

HDMI2_RX0N

9

HDMI2_CLKP

10 11

HDMI2_CLKN

12

CLKCEC

NC SCL SDA

13 14 15 16 17 18 19

CEC

HDMI2-DDC-SCL HDMI2-DDC-SDA

HDMI2-HPD

HDMI2/5V

HDMI2_RX2P HDMI2-RX2P

HDMI2_RX2N HDMI2-RX2N HDMI2_RX1P HDMI2-RX1P

HDMI2_RX1N HDMI2-RX1N HDMI2_RX0P HDMI2-RX0P

HDMI2_RX0N HDMI2-RX0N HDMI2_CLKP HDMI2-CLKP

HDMI2_CLKN HDMI2-CLKN

HDMI2-RX2P 4

HDMI2-RX2N 4 HDMI2-RX1P 4

HDMI2-RX1N 4 HDMI2-RX0P 4

HDMI2-RX0N 4 HDMI2-CLKP 4

HDMI2-CLKN 4

HDMI2-RX2P HDMI2-RX2N HDMI2-RX1P HDMI2-RX1N

HDMI2-RX0P HDMI2-RX0N HDMI2-CLKP HDMI2-CLKN

ED6 ESD/NCED6 ESD/NC

1

2

4

5

5 GND3GND

ED7 ESD/NCED7 ESD/NC

1

2

4

5

5 GND3GND

10

9 7 6

HDMI2-RX2P

10

HDMI2-RX2N

9

HDMI2-RX1P

7

HDMI2-RX1N

6 8

HDMI2-RX0P

10

HDMI2-RX0N

9

HDMI2-CLKP

7

HDMI2-CLKN

6 8

HDMI2/5V

R810

10K

HDMI2-DDC-SCL HDMI2-DDC-SDA

D821

D820

ESD

1 2

R811

10K

Note:ESD

R812 22RR812 22R R813 22RR813 22R

器件靠近端子放

HDMI2-SCL 4 HDMI2-SDA 4

HDMI3(MHL)

HDMI3-HPD

+5V_Standby

R816

10K

D805

ESD

1 2

R817

10K

R819 22RR819 22R R820 22RR820 22R

R855 22RR855 22R

HDMI3-SCL 4 HDMI3-SDA 4

HDMI3-HPDIN 4

HDMI3_RX0P#

HDMI3_RX0N#

D807

ESD

1 2

D806

ESD

1 2

DATA2 SHIELD

DATA1 SHIELD

DATA0 SHIELD

20

GND1

21

GND2

22

GND3

23

GND3

DDC/CEC GND

CON803

DATA2+

DATA2-

DATA1+

DAT1A-

DATA0+

DATA0-

CLK SHIELD

+5V POWER

HOT PLUG

HDMI/90D

CLK+

HDMI3_RX2P

1

MHL_CD_SENSE

2

HDMI3_RX2N

3

HDMI3_RX1P

4 5

HDMI3_RX1N

6

HDMI3_RX0P#

7 8

HDMI3_RX0N#

9

HDMI3_CLKP

10 11

HDMI3_CLKN

12

CLK-

CEC

13

CEC

14

NC

HDMI3-DDC-SCL

15

SCL

HDMI3-DDC-SDA

16

SDA

17 18

HDMI3-HPD

19

R5 5R1R5 5R1

R7 5R1R7 5R1

HDMI3/5V

HDMI3_RX2P HDMI3-RX2P HDMI3_RX2N HDMI3-RX2N HDMI3_RX1P HDMI3-RX1P HDMI3_RX1N HDMI3-RX1N

HDMI3_RX0P HDMI3-RX0P

HDMI3_RX0N HDMI3-RX0N

HDMI3_CLKP HDMI3-CLKP HDMI3_CLKN HDMI3-CLKN

HDMI3-RX2P 4 HDMI3-RX2N 4 HDMI3-RX1P 4 HDMI3-RX1N 4

HDMI3-RX0P 4

HDMI3-RX0N 4

HDMI3-CLKP 4 HDMI3-CLKN 4

HDMI3-DDC-SCL

HDMI3-DDC-SDA

HDMI3-RX2P HDMI3-RX2N HDMI3-RX1P HDMI3-RX1N

HDMI3-CLKP HDMI3-CLKN

ED2 ESD/NCED2 ESD/NC

1

2

4

5

5 GND3GND

ED3 ESD/NCED3 ESD/NC

1

2

4

5

5 GND3GND

10

9 7 6

10

9 7 6

HDMI3-RX2P

10

HDMI3-RX2N

9

HDMI3-RX1P

7

HDMI3-RX1N

6 8

HDMI3-CLKP

10

HDMI3-CLKN

9

HDMI3-DDC-SCL

7

HDMI3-DDC-SDA

6 8

HDMI3-DDC-SCL HDMI3-DDC-SDA

Note:ESD diode(D805) to GND(VBD <=10V, Cap loading <=0.5pF)

HDMI1_ARC HDMI1-ARC

C801

C801 1uF

B B

1uF

NC/2N7002

R822 100RR822 100R

12

NC/2N7002

CEC

D822

ESD

Q580

3 2

R840 0RR840 0R

+5V_Standby

1

HDMI1-ARC 4

HDMI-CEC 4

CEC & ARC

MHL_CD_SENSE

C802

C802 47nF

47nF

R848

300K

R849 100RR849 100R

+5V_Standby

MHL_Cable_DET 4

C508

HDMI3/5V

AVDD5V_MHL4

R851 10RR851 10R

MHL_Cable_DET4

C508

10uF/6.3V

U702 SGM2588EU702 SGM2588E

IN5VOUT

GND

EN4/OC

HDMI3/5V

1

C509

2

3

10uF/6.3V

R763

R763 NC/10K

NC/10K

+5V_Normal

MHL

4

R657 75R/1%R657 75R/1%

R662 75R/1%R662 75R/1%

CB652

1nF/2KV

CN309

1

TD+

2

TD-

4

TDCT

5

RDCT

3

RD+

6

RD-

GND112GND2

10

GND3

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

RJ45-W

CH_GND

GND4

7

NC

8

13

NC1

14

NC2

11

9

Copyright@ ShenZhen KTC Technology Co., LTD

3

HST-0041

U651

C654

0.1uF

1

TD+

2

TCT

3

TD-

4

NC1

5

NC2

6

RD+

7

RCT

8

RD-

SMDTR16P

U651

TCM-

16

TX+

14

TX-

R660 75R/1%R660 75R/1%

15

TCM

13

NC4

12

NC3

11

RX+

9

RX-

R664 75R/1%R664 75R/1%

10

MDI_TP

MDI_TP4

MDI_TN

MDI_TN4

MDI_RP

MDI_RP4

MDI_RN

A A

MDI_RN4

C653

0.1uF

LAN

5

HDMI1/5V

R443

100R

R445NCR445

NC

HDMI2/5V

R451

100R

HOTPLUGB_HDMI20_5V 4HOTPLUGA_HDMI20_5V 4 HOTPLUGC_HDMI20_5V 4

R446NCR446

NC

HDMI3/5V

R449

100R

R447NCR447

NC

HDMI DETECT

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

文件名称：

文件编号：

设计:

发行部门：生效日期：

2

发行部门：生效日期：

T4298

张志清

研发处

版本：3.0

审核:

页数:

页数: 批准:

批准:

Thursday, April 21, 2016

1

of

10 11

5

选用

Part Num BALUN NO BALUN

L908

R909

3

1

后面要求

RF

D01

D01 BAV99

BAV99

R908

L907

L903

NC.

C936

For S11 test

L901 0RL901 0R

2

22*16MM

1 2 3 4

D D

RF SIGNAL INPUT

TUNER_CONNECTOR

CON1

C C

RF-IN

1 2 3 4

TC23 10NF/1KVTC23 10NF/1KV

TC24 10NF/1KVTC24 10NF/1KV

TC25 4.7NF/1KVTC25 4.7NF/1KV

TC26 4.7NF/1KVTC26 4.7NF/1KV

TC27 470PF/1KVTC27 470PF/1KV

TC29 1NF/2KVTC29 1NF/2KV

J3

NC

0R

NC

2.2nH

nc

NC

C913 1nFC913 1nF

L904

560nH

屏蔽罩

18nH

NC

0R

8.2nH

18nH

5.6pF

L907

2.2nH

4 3

L903

L903 18nH/nc

18nH/nc

C929

replace for Balun

T901

T901 BW21S7511A01TF

BW21S7511A01TF

75 ohm Line

1 2

C934 1nFC934 1nF

VDD_1.8V_OUTPUT

IFAGC

4

Addr 0xC0

+3.3V_TU

C918

0.1uF

1nF

FB(1000ohm,200mA)

L906

C912

C933

0.1uF

NC/0.1uF

TUNER_RESET

7

U905

1

VDD_3p3_1

2

LNA_INP

3

LNA_INN

4

VDD_1p8_1

5

AGC_2/GPO3

6

AGC_1

29

GND25GND26GND27GND28GND

+3.3V_TU

C932

0.47uF

24

AS

IF_OUTN_2/GPO_17IF_OUTP_2/GPO_2

R9071MR907 1M

23

8

RESET_N

C910

VDD_1.8V_OUTPUT

10nF

22

VDD_1p8_3

MxL661

IF_OUTN_19IF_OUTP_1

C917

0.1uF

IF-IN-

21

10

IF-IN+

GND_XTAL

C914

0.1uF

3

Y001

16.000MHz

19

20

XTAL_P

VDD_3p3_211VDD_1p8_2

12

C930

C931

0.1uF

1uF

+3.3V_TU

GND30GND31GND32GND

XTAL_N

CLK_OUT

GND_DIG

VDD_1.8V_OUTPUT

33

VDD_IO

VDD_1p2

2

1

DIF IN&OUT

kick back filter:220nH/47pF 改善ATV

IF-IN-

18

SDA-T

17

SDA

SCL-T

16

SCL

15

14

13

C909

2.2nF

C907

0.1uF

+3.3V_TU

IF-IN+

AGC RC Filter &I2C(IIC串的电阻在IC端已经有）

I2C-SDA3,4,6

I2C-SCL3,4,6

IF-AGC4

R905 0RR905 0R

C915

C915 NC/47pF

NC/47pF

C919

C919 NC/10pF

NC/10pF

R904 0RR904 0R

C916

C916 NC/47pF

NC/47pF

R912 33RR912 33R

R913 33RR913 33R

IF-AGC IFAGC

C905

C905 33pF

33pF

R911 100RR911 100R

Close Tuner

水波纹！

C921

0.1uF

DIFM

DIFM 4

DIFP

DIFP 4

SDA-T

SCL-T

C906

33pF

iNAND FLASH(EMMC)

U42

EMMC-CLK EMMC-CMD

C1109

EMMC_D0

NC/33pF

EMMC_D1 EMMC_D2 EMMC_D3

B B

A A

W6 W5

H3 H4 H5

J2

K6

W4

Y4 AA3 AA5

K4

Y2

Y5 AA4 AA6

公板

5

U42

CLK CMD D0 D1 D2 D3

RESET

VDD_IF VDD_IF VDD_IF VDD_IF VDD_IF

VSS VSS VSS VSS

CREG/VDDi

VSS

eMMC

4G/8G EMMC 5.0

Note:DS PIN(R5 pin) Need to NC

EMMC_D4

J3

D4

EMMC_D5

J4

D5

EMMC_D6

J5

D6

EMMC_D7

J6

D7

DQS

R5

DS

EMMC-RESET

U5

EMMC_NAND_POWEREMMC_IO_POWER

M6

VDD

N5

VDD

T10

VDD

U9

VDD

H6

VSS

M7

VSS

P5

VSS

R10

VSS

U8

VSS

T5

VSS

K2

EMMC_REG

R1042 NC/10KR1042 NC/10K

C333

2.2uF

EMMC-CMD

R1039 NC/10KR1039 NC/10K

EMMC-RESET

R1040 NC/10KR1040 NC/10K

NAND-REZEMMC-CLK

R1101 33RR1101 33R

EMMC-CMD NAND-CEZ

EMMC_D6 EMMC_D7 EMMC_D2 EMMC_D1

EMMC_D0 EMMC_D3 EMMC_D4 EMMC_D5

RP1101 22RX4

7531

RP1102 22RX4

NAND-D[7:0]

4

8642

NAND-WEZEMMC-RESET

NAND-D0 NAND-D1 NAND-D2 NAND-D3

NAND-D4 NAND-D5 NAND-D6 NAND-D7

EMMC_IO_POWER

NAND-REZ 4 NAND-CEZ 4 NAND-WEZ 4

NAND-D0 4 NAND-D1 4 NAND-D2 4 NAND-D3 4

NAND-D4 4 NAND-D5 4 NAND-D6 4 NAND-D7 4

NAND-D[7:0] 4

EMMC_NAND_POWEREMMC_IO_POWER +3.3V_Normal+1.8V_Normal

C402

C403

2.2uF

C399

0.1uF

C398

0.1uF

C397

0.1uF

C290

0.1uF

C402

2.2uF

NAND and EMMC power

本文档仅限中国深圳市康冠技术有限公司和被呈送方内部使用，未经书面许可请勿扩散到第三方。

This document for ShenZhen KTC Technology CO., Ltd and presented party internal use only, Do not spread to third party without the written permission.

3

@

深圳市康冠技术有限公司

Copyright@ ShenZhen KTC Technology Co., LTD

2

KTC ISO9001.ISO14001体系文件

MSD6A638-T8F1三合一板DTMB数模一体智能(4K)电视原理图

文件名称：

文件编号：

设计:

发行部门：生效日期：

T4298

张志清

研发处

版本：3.0

审核:

Thursday, April 21, 2016

1

页数:

页数: 批准:

批准:

of

11 11

Philips 65HUF6923/T3 Schematic

Specifications and Main Features

Frequently Asked Questions

User Manual