Panasonic S-71PE1R5B, S-60PE1R5B, S-125PE1R5B, S-100PE1R5B, U-60PE1R5A Operating Instructions Manual

Operating Instructions
Air Conditioner

Ducted (E1 type)

Model No:

INDOOR UNIT

Ducted Type
S-60PE1R5B

S-71PE1R5B
S-100PE1R5B
S-125PE1R5B
S-140PE1R5B

OUTDOOR UNIT

Single Split (Single-phase)
PE1 Type
U-60PE1R5A U-100PE1R5A

U-71PE1R5A U-125PE1R5A
U-140PE1R5A

PZ2 Type
U-60PZ2R5 U-100PZ2R5

U-71PZ2R5 U-125PZ2R5
U-140PZ2R5

Single Split (3-phase)
PE1 Type

— U-100PE1R8A
— U-125PE1R8A
U-140PE1R8A

PZ2 Type

— U-100PZ2R8
— U-125PZ2R8
U-140PZ2R8

Before operating the unit, read these
operating instructions thoroughly and
keep them for future reference.

Panasonic Corporation
1006 Kadoma, Kadoma City, Osaka, Japan

C8041-2910

PTW17_P07-T11600B (OI).indd 1PTW17_P07-T11600B (OI).indd 1 12/28/2017 2:09:10 PM12/28/2017 2:09:10 PM

2

Thank you for purchasing this Panasonic product.
This product is a commercial air conditioner indoor unit.
Installation instructions attached.

Contents

●

Safety Precautions .......................................................... 2

●

Precautions for Use ......................................................... 5

●

Names of Parts ................................................................. 6

●

Maintenance ..................................................................... 7

• Operation Mechanism ................................................... 7

●

Troubleshooting............................................................... 8

• Before Requesting Services ......................................... 9

WARNING

This symbol shows that this equipment
uses a fl ammable refrigerant. If the
refrigerant is leaked, together with
an external ignition source, there is a
possibility of ignition.

CAUTION

This symbol shows type of fl ammable
refrigerant contained in the system.

CAUTION

This symbol shows that a service
personnel should be handling this
equipment with reference to the
Technical Manual.

CAUTION

This symbol shows that there is
information included in the Operating
Instructions and/or Installation
Instructions.

Product Information

If you have problems or questions concerning your Air
Conditioner, you will need the following information. Model
and serial numbers are on the nameplate on the bottom of the
cabinet.

Model No.

Serial No.

Date of purchase

Dealer’s address

Phone number

Important Information Regarding The Refrigerant
Used

NOTE

Refer to the Installation Instructions attached to the outdoor
unit.

Safety Precautions

The following symbols used in this manual, alert you to
potentially dangerous conditions to users, service personnel or
the appliance:

WARNING

This symbol refers to a hazard or
unsafe practice which can result in
severe personal injury or death.

CAUTION

This symbol refers to a hazard or
unsafe practice which can result
in personal injury or product or
property damage.

Prohibited matters

Matters to be
observed

• Read these Operating Instructions carefully before using this
air conditioner. If you still have any diffi culties or problems,
consult your dealer for help.

• This air conditioner is designed to give you comfortable
room conditions. Use this only for its intended purpose as
described in these Operating Instructions.

WARNING

Confi rm to authorized dealer or
specialist on usage of specifi ed
refrigerant type. Using of
refrigerant other than the
specifi ed type may cause product
damage, burst and injury etc.

This air conditioner has no
ventilator for intaking fresh air
from outdoors. You must open
doors or windows frequently
when you use gas or oil heating
appliances in the same room,
which consume a lot of oxygen
from the air.
Otherwise there is a risk of
suffocation in an extreme case.

Never use or store gasoline or
other fl ammable vapor or liquid
near the air conditioner — it is
very dangerous.

Do not use this appliance in a
potentially explosive atmosphere.

Never touch the unit with wet hands.
Do not insert your fi ngers or

other objects into the air
conditioner indoor or
outdoor unit, rotating parts may
cause injury.

PTW17_P07-T11600B (OI).indd 2PTW17_P07-T11600B (OI).indd 2 12/28/2017 2:09:10 PM12/28/2017 2:09:10 PM

3

If the refrigerant comes in contact
with a fl ame, it produces a toxic
gas.

For safety, be sure to turn the
air conditioner off and also to
disconnect the power before
cleaning or servicing.

Pull off the power plug from
a receptacle, or switch off
the breaker, or switch off
the power disconnecting mean to
isolate the air conditioner from the
main power supply in case of
emergency.
Dispose of according to national
and/or local legislation.

This product must not be modifi ed
or disassembled under any
circumstances.
Modifi ed or disassembled unit may
cause fi re, electric shock or injury.

Do not clean inside the indoor and
outdoor units by users. Engage
authorized dealer or specialist for
cleaning.

In case of malfunction of this
appliance, do not repair by
yourself. Contact to the sales
dealer or service dealer for a
repair and disposal.

Provide a power outlet to be
used exclusively for each unit,
and a power supply disconnect,
circuit breaker and earth leakage
breaker for overcurrent protection
should be provided in the
exclusive line.

Provide a power outlet exclusively
for each unit, and full disconnection
means having a contact separation
in all poles must be incorporated in
the fi xed wiring in accordance with
the wiring rules.

To prevent possible hazards
from insulation failure, the
unit must be grounded.

Do not use modifi ed
cord, joint cord,
extension cord or
unspecifi ed cord to prevent
overheating and fi re.

WARNING

The appliance shall be stored
in a room without continuously
operating ignition sources (for
example: open fl ames, an
operating gas appliance or an
operating electric heater).

Be aware that refrigerants may not
contain an odour.

An unventilated area where
the appliance using fl ammable
refrigerants is installed shall be
so constructed that should any
refrigerant leak, it will not stagnate
so as to create a fi re or explosion
hazard.

The appliance shall be stored
in a well-ventilated area where
the room size corresponds to
the room area as specifi ed for
operation.

Do not use means to accelerate
the defrosting process or to clean,
other than those recommended by
the manufacturer.

Do not pierce or burn.
In cases that require mechanical

ventilation, ventilation openings
shall be kept clear of obstruction.

The appliance shall be stored
in a room without continuously
operating open fl ames (for
example: an operating gas
appliance) and ignition sources
(for example: an operating electric
heater).

PTW17_P07-T11600B (OI).indd 3PTW17_P07-T11600B (OI).indd 3 12/28/2017 2:09:10 PM12/28/2017 2:09:10 PM

4

WARNING

Stop using the product when any
abnormality/failure occurs and
disconnect the power plug or turn
off the power switch and breaker.
(Risk of smoke/fi re/electric shock)

Examples of abnormality/failure:

• The ELCB trips frequently.

• The product sometimes does not
start when turn on.

• The power is sometimes
disconnected when the cord is
moved.

• Burnt odor or abnormal noise is
detected during operation.

• The body is deformed or
abnormally hot.

• Water leaks from the indoor unit.

• Power cord or plug becomes
abnormally hot.

• Fan speed cannot be controlled.

• The unit stops running
immediately even if it is switched
on for operation.

• The fan does not stop even if
the operation is stopped.

Contact immediately your local
dealer for maintenance/repair.

Do not sit or step on the unit.
You may fall down accidentally.

CAUTION

This appliance is intended to be used
by expert or trained users in shops, in
light industry and on farms, or for
commercial use by lay persons.

This appliance is not intended for use
by persons (including children) with
reduced physical, sensory or mental
capabilities, or lack of experience
and knowledge, unless they have
been given supervision or instruction
concerning use of the appliance by
a person responsible for their safety.
Children should be supervised to
ensure that do not play with the
appliance.

Keep the fi re alarm and the air outlet
at least 1.5m away from the unit.

Do not cool or heat the room too
much if babies or invalids are
present.

Do not turn the air conditioner on and
off from the power mains switch.
Use the ON/OFF operation button.

Do not stick anything into the air
outlet of the outdoor unit. This
is dangerous because the fan
is rotating at high speed.

Do not touch the air inlet or the
sharp aluminum fi ns of the
outdoor unit. You may get
injured.

Do not stick any object
into the FAN CASE. You
may be injured and the
unit may be damaged.

NOTICE

• The appliance shall be stored so as to prevent mechanical
damage from occuring.

• The compressor may occasionally stop during thunderstorms.
This is not a mechanical failure. The unit automatically
recovers after a few minutes.

PTW17_P07-T11600B (OI).indd 4PTW17_P07-T11600B (OI).indd 4 12/28/2017 2:09:11 PM12/28/2017 2:09:11 PM