Panasonic TX-P37C2B Schematic

ORDER NO.PCZ1004039CE

Plasma Television

Model No. TX-P37C2B

TX-P37C2E TX-PR37C2

GPH13DE Chassis

1 Safety Precautions

1.1. General Guidelines

1. When conducting repairs and servicing, do not attempt to modify the equipment, its parts or its materials.

2. When wiring units (with cables, flexible cables or lead wires) are supplied as repair parts and only one wire or some of the wires have been broken or disconnected, do not attempt to repair or re-wire the units. Replace the entire wiring unit instead.

3. When conducting repairs and servicing, do not twist the Faston connectors but plug them straight in or unplug them straight out.

4. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit.

5. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.

6. After servicing, make the following leakage current checks to prevent the customer from being exposed to shock hazards.

1.2. Touch-Current Check

1. Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check.

2. Connect a measuring network for touch currents between each exposed metallic part on the set and a good earth ground such as a water pipe, as shown in Figure 1.

3. Use Leakage Current Tester (Simpson 228 or equivalent) to measure the potential across the measuring network.

4. Check each exposed metallic part, and measure the voltage at each point.

5. Reserve the AC plug in the AC outlet and repeat each of the above measure.

6. The potential at any point (TOUGH CURRENT) expressed as voltage U

For a. c.: U1 = 35 V (peak) and U2 = 0.35 V (peak);

For d. c.: U

Note:

The limit value of U

mA d. c. The limit value U

7. In case a measurement is out of the limits specified, there is a possibility of a shock hazard, and the equipment should be repaired and rechecked before it is returned to the customer.

= 1.0 V,

1

= 0.35 V (peak) for a. c. and U1 = 1.0 V for d. c. correspond to the values 0.7 mA (peak) a. c. and 2.0

2

= 35 V (peak) for a. c. correspond to the value 70 mA (peak) a. c. for frequencies greater than 100 kHz.

1

and U2, does not exceed the following values:

1

Figure 1

3

2Warning

2.1. Prevention of Electrostatic Discharge (ESD) to Electrostatically Sensitive (ES) Devices

Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor [chip] components. The following techniques should be used to help reduce the incidence of component damage caused by electrostatic discharge (ESD).

1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any ESD on your body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging ESD wrist strap, which should be removed for potential shock reasons prior to applying power to the unit under test.

2. After removing an electrical assembly equipped with ES devices, place the assembly on a conductive surface such as aluminum foil, to prevent electrostatic charge buildup or exposure of the assembly.

3. Use only a grounded-tip soldering iron to solder or unsolder ES devices.

4. Use only an anti-static solder removal device. Some solder removal devices not classified as [anti-static (ESD protected)] can generate electrical charge sufficient to damage ES devices.

5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES devices.

6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or comparable conductive material).

7. Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material to the chassis or circuit assembly into which the device will be installed.

Caution

Be sure no power is applied to the chassis or circuit, and observe all other safety precautions.

8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise ham less motion such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity (ESD) sufficient to damage an ES device).

4

2.2. About lead free solder (PbF)

Note: Lead is listed as (Pb) in the periodic table of elements. In the information below, Pb will refer to Lead solder, and PbF will refer to Lead Free Solder. The Lead Free Solder used in our manufacturing process and discussed below is (Sn+Ag+Cu). That is Tin (Sn), Silver (Ag) and Copper (Cu) although other types are available.

This model uses Pb Free solder in it’s manufacture due to environmental conservation issues. For service and repair work, we’d suggest the use of Pb free solder as well, although Pb solder may be used.

PCBs manufactured using lead free solder will have the PbF within a leaf Symbol PbF stamped on the back of PCB.

Caution

• Pb free solder has a higher melting point than standard solder. Typically the melting point is 50 ~ 70 °F (30~40 °C) higher. Please use a high temperature soldering iron and set it to 700 ± 20 °F (370 ± 10 °C).

• Pb free solder will tend to splash when heated too high (about 1100 °F or 600 °C). If you must use Pb solder, please completely remove all of the Pb free solder on the pins or solder area before applying Pb solder. If this is not practical, be sure to heat the Pb free solder until it melts, before applying Pb solder.

• After applying PbF solder to double layered boards, please check the component side for excess solder which may flow onto the opposite side. (see figure below)

Suggested Pb free solder

There are several kinds of Pb free solder available for purchase. This product uses Sn+Ag+Cu (tin, silver, copper) solder. However, Sn+Cu (tin, copper), Sn+Zn+Bi (tin, zinc, bismuth) solder can also be used.

5

3 Service Navigation

3.1. PCB Layout

Board Name Function Board Name Function

P Power Supply C1 Data Driver (Lower Right) A DC-DC Converter, Tuner

Speaker out, AV Terminal, HDMI in, SD Card Digital Signal Processor, PEAKS-sLD Format Converter, Plasma AI, Sub-Field Processor

Key Switch K Remote receiver, Power LED S Power Switch

C2 Data Driver (Lower Left) SC Scan Drive SS Sustain Drive

SM Scan out

Non serviceable. SM-Board should be exchanged for service.

6

3.2. Applicable signals

COMPONENT (Y, PB, PR), HDMI

* Mark: Applicable input signal for Component (Y, PB, PR) and HDMI

Signal name COMPONENT HDMI 525 (480) / 60i * * 525 (480) / 60p * * 625 (576) / 50i * * 625 (576) / 50p * * 750 (720) / 60p * * 750 (720) / 50p * * 1,125 (1,080) / 60i * * 1,125 (1,080) / 50i * * 1,125 (1,080) / 60p * 1,125 (1,080) / 50p * 1,125 (1,080) / 24p *

PC (from HDMI terminal)

Applicable input signal for PC is basically compatible to HDMI standard timing.

Signal name Horizontal frequency (kHz) Vertical frequency (Hz) 640 × 480 @60 Hz 31.47 60.00 750 (720) / 60p 45.00 60.00 1,125 (1,080) / 60p 67.50 60.00

Note

• Signals other than above may not be displayed properly.

• The above signals are reformatted for optimal viewing on your display.

• PC signal is magnified or compressed for display, so that it may not be possible to show fine detail with sufficient clarity.

7

4 Specifications

Power Source AC 220-240 V, 50 / 60 Hz Power Consumption 190 W (B/E), 225W (R) Power Consumption in Standby mode 0.4 W (Without monitor out recording)

15 W (With monitor out recording)

Display panel

Aspect Ratio 16:9 Visible screen size 94 cm (diagonal)

819 mm (W) × 457 mm (H)

Number of pixels 737,280 (1,024 (W) × 720 (H)) [3,072 × 720 dots]

Sound

Speaker 160 mm × 40 mm × 2 pcs, 6 Ω Audio Output 20 W ( 10 W + 10 W ) Headphones M3 (3.5 mm) stereo mini Jack × 1

Receiving Systems / Band name (B)

PAL I : UHF E21-68 PAL 525/60 : Playback of NTSC tape from some PAL Video recorders (VCR)

DVB-T : Digital terrestrial services via UHF aerial input. M.NTSC : Playback from M.NTSC Video recorders (VCR). NTSC (AV input only) : Playback from NTSC Video recorders (VCR).

Receiving Systems / Band name (E)

PAL B, G, H, I, SECAM B, G, SECAM L, L’

VHF E2 - E12 VHF H1 - H2 (ITALY) VHF A - H (ITALY) UHF E21 - E69 CATV (S01 - S05) CATV S1 - S10 (M1 - M10) CATV S11 - S20 (U1 - U10) CATV S21 - S41 (Hyperband)

PAL D, K, SECAM D, K

VHF R1 - R2 VHF R3 - R5 VHF R6 - R12 UHF E21 - E69

PAL 525/60 Playback of NTSC tape from some PAL Video recorders (VCR) M.NTSC Playback from M. NTSC Video recorders (VCR) NTSC (AV input only) Playback from NTSC Video recorders (VCR) DVB-T Digital terrestrial services (MPEG2 and MPEG4-AVC(H.264)) DVB-C Digital cable services (MPEG2 and MPEG4-AVC(H.264))

• Check the latest information on the available services at the following website. (English only) http://panasonic.jp/support/global/cs/

Receiving Systems / Band name (R)

PAL D, K, SECAM D, K

VHF R1 - R2 VHF R3 - R5 VHF R6 - R12 UHF E21 - E69

PAL 525/60 Playback of NTSC tape from some PAL Video recorders (VCR) M.NTSC Playback from M. NTSC Video recorders (VCR) NTSC (AV input only) Playback from NTSC Video recorders (VCR) DVB-T Digital terrestrial services (MPEG2 and MPEG4-AVC(H.264))

• Check the latest information on the available services at the following website. (English only) http://panasonic.jp/support/global/cs/

Aerial - input UHF (B), VHF / UHF (E/R) Operating Conditions

Temperature: 0 °C - 35 °C Humidity: 20 % - 80 % RH (non-condensing)

Connection Terminals

AV1 (Scart terminal) 21 Pin terminal (Audio/Video in, Audio/Video out, RGB in, S-Video in, Q-Link) AV2

VIDEO RCA PIN Type × 1 1.0 V [p-p] (75 Ω) AUDIO L - R RCA PIN Type × 2 0.5 V [rms]

COMPONENT

VIDEO Y 1.0 V [p-p] (including synchronization)

, P

P

B

R

AUDIO L - R RCA PIN Type × 2 0.5 V [rms]

Others

HDMI1 / 2 TYPE A Connectors

HDMI1 : HDMI (Version 1.3a with x.v.Colour.)

or NTSC disc playback from DVD player and recorder.

Countries that DVB-C is available: Germany, Switzerland, Denmark, Sweden, Norway, Finland, Netherlands

± 0.35 V [p-p]

8

HDMI2 : HDMI (Version 1.4 with Audio Return Channel) and

HDMI (Version 1.3a with x.v.Colour.)

• This TV supports [ HDAVI Control 5 ] function.

Card slot SD Card slot × 1

Output

DIGITAL AUDIO OUT PCM / Dolby Digital / DTS, Fiber optic

Dimensions (W × H × D) 929 mm × 640 mm × 307 mm (With Pedestal)

Mass 21.5 kg Net (With Pedestal)

Common Interface slot × 1

929 mm × 596 mm × 94 mm (TV only)

20.0 kg Net (TV only)

Note

• Design and Specifications are subject to change without notice. Mass and Dimensions shown are approximate.

• This equipment complies with the EMC standards listed below. EN55013, EN61000-3-2, EN61000-3-3, EN55020.

9

5 Technical Descriptions

5.1. Specification of KEY for CI Plus, DTCP-IP and One-to-One

5.1.1. General information:

1. EEPROM (IC8950) for spare parts has the seed of KEY for each.

2. The final KEY data will be generated by Peaks IC (IC8001) when SELF CHECK was done and are stored in both Peaks IC (IC8001) and EEPROM (IC8950). Three KEY are not generated for all models. The necessary KEY are only generated and stored depend on the feature of models.

5.1.2. Replacement of ICs:

When Peaks IC (IC8001) is replaced, EEPROM (IC8950) should be also replaced with new one the same time. When EEPROM (IC8950) is replaced, Peaks IC (IC8001) is not necessary to be replaced the same time. After the replacement of IC, SELF CHECK should be done to generate the final KEY data. How to SELF CHECK: While pressing [VOLUME ( - )] button on the main unit, press [MENU] button on the remote control for more than 3 seconds. TV will be forced to the factory shipment setting after this SELF CHECK.

5.1.3. Model and Keys:

Model No. Keys

CI Plus DTCP-IP One-to-One

(For USB Rec.) TX-P37C2B None None None TX-P37C2E Yes None None TX-PR37C2 None None None

10

6 Service Mode

6.1. How to enter into Service Mode

While pressing [VOLUME ( - )] button of the main unit, press [0] button of the remote control three times within 2 seconds.

6.1.1. Key command

[1] button...Main items Selection in forward direction [2] button...Main items Selection in reverse direction [3] button...Sub items Selection in forward direction [4] button...Sub items Selection in reverse direction [RED] button...All Sub items Selection in forward direction [GREEN] button...All Sub items Selection in reverse direction [VOL] button...Value of sub items change in forward direction ( + ), in reverse direction ( - )

11

6.1.2. Contents of adjustment mode

• Value is shown as a hexadecimal number.

• Preset value differs depending on models.

• After entering the adjustment mode, take note of the value in each item before starting adjustment.

6.1.3. How to exit

Switch off the power with the [POWER] button on the main unit or the [POWER] button on the remote control.

12

6.2. Option - Mirror

Picture can be reversed left and right or up and down. 00 : Default (Normal picture is displayed) 01 : Picture is reversed left and right. 02 : Picture is reversed up and down.

Hint : If the defective symptom (e.g. Vertical bar or Horizontal bar) is moved by selection of this mirror, the possible cause is in A-board.

6.3. Service tool mode

6.3.1. How to access

1. Select [SRV-TOOL] in Service Mode.

2. Press [OK] button on the remote control.

6.3.2. Display of SOS History

SOS History (Number of LED blinking) indication. From left side; Last SOS, before Last, three occurrence before, 2nd occurrence after shipment, 1st occurrence after shipment. This indication will be cleared by [Self-check indication and forced to factory shipment setting].

6.3.3. POWER ON Time, On/Off

Note : To display TIME/COUNT menu, highlight position, then press MUTE for 3sec. Time : Cumulative power on time, indicated hour : minute by decimal On/Off : Number of On/Off switching by decimal Note : This indication will not be cleared by either of the self-checks or any other command.

6.3.4. Exit

1. Disconnect the AC cord from wall outlet or switch off the power with [ Power ] button on the main unit.

13

6.4. Hotel mode

1. Purpose Restrict a function for hotels.

2. Access command to the Hotel mode setup menu In order to display the Hotel mode setup menu, please enter the following command (within 2 second). [TV] : Vol. [Down] + [REMOTE] : AV (3 times)

Then, the Hotel mode setup menu is displayed.

3. To exit the Hotel mode setup menu Disconnect AC power cord from wall outlet.

4. Explain the Hotel mode setup menu

item Function Hotel Mode Select hotel mode ON/OFF Initial INPUT Select input signal modes.

Set the input, when each time power is switched on. Selection : Off/DVB-C/DVB-T/Analog/AV1/AV1S/AV2/COMPONENT/HDMI1/HDMI2

• Off: give priority to a last memory. However, Euro model is compulsorily set to TV.

• AVnS/AVnC: only Euro model selectable

• PC: selectable with VGA option

Initial POS Select programme number.

Selection : Off/0 to 99

• Off: give priority to a last memory

Initial VOL level Adjust the volume when each time power is

switched on. Selection/Range : Off/0 to 100

• Off: give priority to a last memory

Maximum VOL level

Button lock Select local key conditions.

Remote lock Select remote control key conditions.

Adjust maximum volume. Range : 0 to 100

Selection : Off/SETUP/MENU/ALL

• Off: altogether valid

• SETUP: only F-key is invalid (Tuning guide(menu) can not be selected.)

• MENU: only F-key is invalid (only Volume/Mute can be selected.)

• ALL: altogether invalid.

Selection : Off/SETUP/MENU

• Off: altogether valid

• SETUP: only Setup menu is invalid

• MENU: Picture/Sound/Setup menu are invalid

14

6.5. Data Copy by SD Card

6.5.1. Purpose

(a) Board replacement (Copy the data when exchanging A-board):

When exchanging A-board, the data in original A-board can be copied to SD card and then copy to new A-board.

(b) Hotel (Copy the data when installing a number of units in hotel or any facility):

When installing a number of units in hotel or any facility, the data in master TV can be copied to SD card and then copy to other TVs.

6.5.2. Preparation

Make pwd file as startup file for (a) or (b) in a empty SD card.

1. Insert a empty SD card to your PC.

2. Right-click a blank area in a SD card window, point to New, and then click text document. A new file is created by default (New Text Document.txt).

3. Right-click the new text document that you just created and select rename, and then change the name and extension of the file to the following file name for (a) or (b) and press ENTER.

File name:

(a) For Board replacement : boardreplace.pwd (b) For Hotel : hotel.pwd

Note:

Please make only one file to prevent the operation error.

No any other file should not be in SD card.

15

6.5.3. Data copy from TV set to SD Card

1. Turn on the TV set.

2. Insert SD card with a startup file (pwd file) to SD slot. On-screen Display will be appeared according to the startup file automatically.

3. Input a following password for (a) or (b) by using remote control.

(a) For Board replacement : 2770

(b) For Hotel : 4850 Data will be copied from TV set to SD card. It takes around 2 to 6 minutes maximum for copying.

4. After the completion of copying to SD card, remove SD card from TV set.

5. Turn off the TV set.

Note:

Following new folder will be created in SD card for data from TV set.

(a) For Board replacement : user_setup (b) For Hotel : hotel

16

6.5.4. Data copy from to SD Card to TV set

1. Turn on the TV set.

2. Insert SD card with Data to SD slot. On-screen Display will be appeared according to the Data folder automatically.

3. Input a following password for (a) or (b) by using remote control.

(a) For Board replacement : 2771 (b) For Hotel : 4851

Data will be copied from SD card to TV set.

4. After the completion of copying to SD card, remove SD card from TV set.

(a) For Board replacement : Data will be deleted after copying (Limited one copy). (b) For Hotel : Data will not be deleted and can be used for other TVs.

5. Turn off the TV set.

Note:

1. Depending on the failure of boards, function of Data copy for board replacement does not work.

2. This function can be effective among the same model numbers.

17

7 Troubleshooting Guide

Use the self-check function to test the unit.

1. Checking the IIC bus lines

2. Power LED Blinking timing

7.1. Check of the IIC bus lines

7.1.1. How to access

7.1.1.1. Self-check indication only:

Produce TV reception screen, and while pressing [VOLUME ( - )] button on the main unit, press [OK] button on the remote control

for more than 3 seconds.

7.1.1.2. Self-check indication and forced to factory shipment setting:

Produce TV reception screen, and while pressing [VOLUME ( - )] button on the main unit, press [MENU] button on the remote con-

trol for more than 3 seconds.

7.1.2. Screen display

7.1.3. Check Point

Confirm the following parts if NG was displayed.

7.1.4. Exit

Disconnect the AC cord from wall outlet or switch off the power with [ Power ] button on the main unit.

18

7.2. Power LED Blinking timing chart

1. Subject Information of LED Flashing timing chart.

2. Contents When an abnormality has occurred the unit, the protection circuit operates and reset to the stand by mode. At this time, the defective block can be identified by the number of blinks of the Power LED on the front panel of the unit.

19

7.3. No Power

First check point There are following 3 states of No Power indication by power LED.

1. No lit.

2. Green is lit then turns red blinking a few seconds later. (See 7.2.)

3. Only red is lit.

20

7.4. No Picture

21

7.5. Local screen failure

Plasma display may have local area failure on the screen. Fig-1 is the possible defect P.C.B. for each local area.

Fig-1

22

8 Service Fixture & Tools

8.1. SC jig

Purpose:

To find the failure board (SC) when the power LED is blinking 7 times.

SC jig:

Jumper connector to connect to SC50 connector on SC board

Part number:

TZSC09187

How to use: Caution: Remove SC jig from SC board after inspection.

1. Connect SC jig to connector SC50 at left bottom side of SC board

2. Turn on the TV/Display Unit and confirm the power LED blinking. LED blinking: Possible cause of failure is in SC board No LED blinking (Lighting or no lighting): Possible cause of failure is in SM board

3. After inspection, turn off the TV/Display Unit and wait a few minutes to discharge.

4. Remove SC jig from SC board.

Remark: This SC jig can be used for all 2010 Plasma TV and Plasma Display.

23

9 Disassembly and Assem-

bly Instructions

9.1. Remove the Rear cover

1. See PCB Layout (Section 3)

9.2. Remove the AC inlet

Caution:

To remove P.C.B. wait 1 minute after power was off for discharge from electrolysis capacitors.

1. Unlock the cable clampers to free the cable.

2. Disconnect the connector (P9).

3. Remove the screw (×1 ) and remove the AC inlet.

9.4. Remove the Side terminal cover and the Side shield metal

1. Remove the screws (×2 , ×1 , ×1 ).

2. Remove the Side terminal cover.

9.3. Remove the P-Board

Caution:

To remove P.C.B. wait 1 minute after power was off for discharge from electrolysis capacitors.

1. Unlock the cable clampers to free the cable

2. Disconnect the connectors (P2, P6, P7, P9, P11, P34 and P35).

3. Remove the screws (×9 ) and remove the P-Board.

3. Remove the Side shield metal.

24

9.5. Remove the Tuner unit

1. Remove the Side terminal cover and the Side shield metal. (See section 9.4.)

2. Unlock the cable clampers to free the cable.

3. Disconnect the connectors (A1, A6, A7 and A11).

4. Disconnect the flexible cables (A20, A31 and A32).

5. Remove the screws (×2 ) and remove the Tuner unit.

9.7. Remove the Speakers

1. Unlock the cable clampers to free the cable.

2. Disconnect the Speaker terminal.

3. Remove the screws (×2 each) and remove the Speakers (L, R).

9.8. Remove the SM-Board

1. Remove the flexible cables (SM1, SM2, SM3, SM4, SM5 and SM6) connected to the SM-Board.

2. Remove the bridge connectors (SC42-SM42B and SC46SM46B).

3. Remove the molding props (×4 ).

4. Remove the screws (×3 , ×4 ) and remove the SM- Board.

9.6. Remove the A-Board

1. Remove the Tuner unit. (See section 9.5.)

2. Remove the screws (×2 ) and remove the A-Board.

25

9.9. Remove the SC-Board

1. Remove the SM-Board. (See section 9.8.)

2. Disconnect the connectors (SC2 and SC3).

3. Disconnect the flexible cable (SC20).

4. Remove the screws (×6 ) and remove the SC-Board.

9.11. Remove the Hanger metals and the Stand brackets

1. Remove the Plasma panel section from the servicing stand and lay on a flat surface such as a table (covered by a soft cloth) with the Plasma panel surface facing downward.

2. Remove the Stand brackets (L, R) fastening screws (×3

each) and the Stand brackets (L, R).

9.10. Remove the SS-Board

1. Remove the Tuner unit. (See section 9.5.)

2. Unlock the cable clampers to free the cable.

3. Disconnect the connectors (SS3, SS11 and SS23).

4. Disconnect the flexible cables (SS53B and SS55B).

5. Remove the screws (×4 ) and remove the SS-Board.

3. Remove the Hanger metals (L, R) fastening screws (×2

each) and remove the Hanger metals (L, R).

26

9.12. Remove the C1-Board

1. Remove the Hanger metal R and the Stand bracket R. (See section 9.10.)

2. Remove the flexible cable holder fastening screws (×8

).

3. Disconnect the flexible cables (CB1, CB2, CB3 and CB4).

4. Disconnect the flexible cables (C10 and C11).

5. Remove the screws (×3 ) and remove the C1-Board.

9.13. Remove the C2-Board

1. Remove the Tuner unit. (See section 9.5.)

2. Remove the Hanger metal L and the Stand bracket L. (See section 9.11.)

3. Remove the flexible cable holder fastening screws (×8

).

4. Disconnect the flexible cables (CB5, CB6, CB7 and CB8).

5. Disconnect the flexible cables (C20 and C21).

6. Disconnect the connectors (C23 and C25).

7. Remove the screws (×3 ) and remove the C2-Board.

9.14. Remove the S-Board

1. Remove the screws (×2 ) and remove the S-Board unit.

2. Disconnect the connector (S1B).

3. Remove the Power Button.

4. Remove the screw (×1 ) and remove the S-Board.

27

9.15. Remove the Plasma panel section from the Cabinet assy (glass)

1. Remove the plasma panel fastening screws (×3 ) and remove the cabinet assy.

9.16. Remove the Glass holders

1. Remove the Cabinet assy. (See section 9.15.)

2. Remove the screws (×4 ).

3. Remove the Glass holder side (L, R).

4. Remove the screws (×5 ).

5. Remove the Glass holder top.

6. Remove the screws (×5 ).

7. Remove the Glass holder bottom.

2. For leaving the cabinet assy from the plasma panel, pull the bottom of the cabinet assy forward, lift, and remove.

9.17. Remove the K-Board

1. Remove the Glass holders. (See section 9.16.)

2. Remove the screws (×2 ).

3. Remove the claws (×2 ).

4. Disconnect the connector (K1) and Remove the K-Board from LED Panel.

28

9.18. Replace the plasma panel

Caution:

A new plasma panel itself without Hanger metals is fragile. To avoid the damage to new plasma panel, carry a new plasma panel taking hold of the Hanger metals after assembling the Hanger metals and the Stand brackets.

1. Place a carton box packed a new plasma panel on the flat surface of the work bench.

2. Open a box and without taking a new plasma panel; Attach the C1-Board and the C2-Board, connect the flexible cables from the plasma panel to the C1-Board and the C2-Board, and fit the flexible cable holders.

3. Attach the Hanger metals and the Stand brackets to the new plasma panel.

4. Place the plasma panel on the servicing stand taking hold of the Hanger metals.

5. Attach the cabinet assy and each P.C.Board and so on, to the new plasma panel.

*When fitting the cabinet assy, be careful not to allow any debris, dust or handling residue to remain between the front glass and plasma panel.

29

10 Measurements and Adjustments

10.1. Adjustment

10.1.1. Vsus selection

Caution:

When Plasma panel or A-board is replaced, Vsus should be set to LOW or HIGH.

Procedure

1. Go into main item [VSUS] in Service Mode. LOW or HIGH will be displayed.

2. Press [OK] button to go to TEST stage. White pattern without On-Screen Display will be displayed during TEST and CONF stage. Press [5] button to display the On-Screen Display.

3. Press [VOL (-)] button to set to LOW.

4. In LOW setting

a. If no several dead pixel is visible remarkably in white pattern, press [3] button to go to CONF stage. b. If the several dead pixels are visible remarkably in white pattern, Set to HIGH by press [VOL (+)] button. Press [3] button

to go to CONF stage if the symptom is improved.

5. Press [OK] button in CONF stage to store LOW or HIGH.

6. Exit Service Mode by pressing [Power] button.

30

10.1.2. Sub-Contrast adjustment

Name of measuring instrument Connection Remarks RF generator Base Band signal generator HD signal generator

Steps Remarks

Adjustment of TV (RF system)

Note:

In adjustment, you must setting to modulation of signal at 80%.

Ref.:

RF signal modulation spec. B models: 80% Other models: 90%

1. Receive a RF PAL 100% Full White or Split Colour bar shown as below.

2. Goes into service adjustment mode.

3. Push a [ 1 ] or [ 2 ] key, and goes into adjustment mode for [ CONTRAST ].

Adjustment

1. The colour key yellow button of remote control is pushed.

2. The OSD character of sub-contrast becomes red. (Inside under automatic adjustment)

3. The OSD character of sub-contrast returns to black.

4. End.

Note:

Sub-contrast adjustment is unadjusted for AV/ HD input. But, when needing the adjustment chosen manually, please refer to [ alternative method ].

31

Steps Remarks

Another procedure

Adjustment of AV system

1. PAL 100% Full White or Split Colour bar receive AV1(or AV2), shown as below.

2. Goes into service adjustment mode.

3. Push [ 1 ] or [ 2 ] key, and goes into adjustment mode for [ Contrast ].

Adjustment

1. The colour key yellow button of remote control is pushed.

2. The OSD character of sub-contrast becomes red. (Inside under automatic adjustment)

3. The OSD character of sub-contrast returns to black.

4. End.

Steps Remarks

Another procedure

Adjustment of HD system

1. At 1080i 100% Full White or Split colour bar receive component signal, as shown below.

2. Goes into service adjustment mode.

3. Push [ 1 ] or [ 2 ] key, and goes into adjustment mode for [ Contrast ].

Adjustment

1. The colour key yellow button of remote control is pushed.

2. The OSD character of sub-contrast becomes red. (Inside under automatic adjustment)

3. The OSD character of sub-contrast returns to black.

4. End.

32

10.1.3. White balance adjustment

Name of measuring instrument Connection Remarks W/ B pattern Color analyzer (Minolta CA-100 or equivalent)

Steps Remarks

• Make sure the front panel to be used on the final set is fitted.

• Make sure a color signal is not being shown before adjustment.

• Put the color analyzer where there is little colour variation. Adjustment Remarks

1. Enter the service mode menu. Please receive the external signal. Or, please select CVBS/YUV (no sync).

2. A number key [1] or [2] are operated and [WB-ADJ] is displayed. Check that the color balance is [ COOL ].

3. A number key [0] is operated and select [METHOD].

4. A number key [5] is operated and [INNER PATTERN] is displayed.

Panel surface

Picture menu : Dynamic ASPECT : 16:9

METHOD=01 copy adjustments

5. Select [G-CUTOFF] item, using the number-key [3] or [4], and set to [80], using the volume-key [+] or [-]. Also, [B-CUTOFF] and [R-CUTOFF] set to [80]

6. Set [G-DRIVE] at [D0].

7. Touch the signal receiver of color analyzer to the INNER PATTERN's center, and adjust B drive and R drive so x, y become the [COLOR TEMP COOL] in the below table1.

8. All RGB drive increase so that the maximum drive value of RGB may become [FF]. ([ALL-DRIVE] set to [FF].)

9. Set color balance to [NORMAL] using [7] key.

10. Fix G-CUTOFF, B-CUTOFF and R-CUTOFF at [80].

11. Set [G-DRIVE] at [D0].

12. Adjust B-DRIVE and R-DRIVE so the INNER PATTERN’s x, y become the [COLOR TEMP NORMAL] in the below table1.

13. All RGB drive increase so that the maximum drive value of RGB may become [FF]. ([ALL-DRIVE] set to [FF].)

14. Set color balance to [WARM] using [7] key.

15. Fix G-CUTOFF, B-CUTOFF and R-CUTOFF at [80].

16. Set [G-DRIVE] at [D0].

17. Adjust B-DRIVE and R-DRIVE so the INNER PATTERN’s x, y become the [COLOR TEMP WARM] in the below table1.

18. All RGB drive increase so that the maximum drive value of RGB may become [FF]. ([ALL-DRIVE] set to [FF].)

33

34

11 Block Diagram

11.1. Main Block Diagram

DIGITAL SIGNAL PROCESSOR

A

IFD_OUT

SIF_OUT

TUNER

V

AM

V/R/G/B

L/R

V OUT

AV1

L/R OUT

Y/PB/PR

L/R

COMP

V

AV2

HP L/R

HEAD_ PHONE

A11

SM42B

SM46B

OPTICAL

AUDIO

OUT

L

R

SC42

SC46

SM

SPEAKER(L)

SPEAKER(R)

SCAN OUT

SCAN DRIVER

BUFFER

OFDM

AV SW

AUDIO

AMP

OPTICAL AUDIO OUT

SCAN DRIVE

SC

SC-BOARD ENERGY RECOVERY SOS DETECT

(LED:6TIMES)

SC-BOARD FLOATING PART SOS DETECT

(LED:7TIMES)

VSCAN GEN.

VAD GEN.

Parallel_ TS(FE)

RGB_CVBS

Y/PR/PB

L/R

PWM L/R

CONTROL PULSE

Parallel_ TS(CI)

CI TS CONT.

SOUND SOS DET CIRCUIT

(LED:12TIMES)

SOS6_SC1

SOS7_SC2

P+5V

P+15V

SCAN CONTROL

CI SLOT

VSUS

CI ASIC

NAND FLASH

SC20

SC2

SC3

HDMI1-2

CPU BUS

A20

TMDS DATA

Parallel_ TS

EEPROM

DVB_RF

TV_L/R

MON_L/R

HP_L/R

STB1.2V

STB3.3V

STB5V

SUB9V

P+3.3V

SOS6_SC1

SOS7_SC2

+5V(P)

+15V(P)

SCAN CONTROL

STB5V_M

HDMI I/F RECEIVER

SIF I/F

TS I/F

AV IN I/F

CPU BUS I/F

VDAC OUT

TV_L/R

MON_L/R

HP_L/R

SOS6_SC1

SOS7_SC2

DCDC

STB_D3.3V

ANALOG AUDIO OUT I/F

ANALOG-ASIC

(LED:4TIMES)

POWER SOS

(LED:6TIMES)

(LED:7TIMES)

SOS8_SS

(LED:8TIMES)

STB_D3.3V

DATA DRIVER (RIGHT)

C1

PEAKS-sLD

PWM L/R

OPTICAL OUT

DCC SOS(LED:9TIMES)

Vda

VIDEO DATA

PANEL SOS

LVDS DATA

PLASMA AI CPG with SS H/V Sync Control Sub Filed Processor Plasma AI

VIDEO DATA

P+5V

A31

VIDEO DATA

P+3.3V

C11

P+3.3V

VIDEO DATA

(LED:12TIMES)

SOUND SOS

PD4

VIDEO DATA

MPU

PANEL MAIN ON

PANEL SOS

SUSTAIN CONTROL

P+5V

A32

(LED:3TIMES)

(LED:5TIMES)

P+3.3V DET

P+5V DET

P+5V

P+3.3V

SOS4_PS

STB5V

PANEL MAIN ON

P+15V

F15V

SOUND15V

SOS8_SS

SUSTAIN CONTROL

VIDEO DATA

P+3.3V,P+5V

C10

SUB+3.3V DET

C20

SD CARD IF

SUB+9V DET

SUB+5V DET

LED_R/G

REMOTE IN

KEYSCAN1

A7

A6

C21

P+5V

P+3.3V

F15V

P7

P6

P2

EEPROM

SUB9V

SUB5V

SUB3.3V

DCDC

SUB9V

DCDC

SUB5.6V

DCDC SUB5V

SUB3.3V

DCDC SUB1.8V SUB1.2V

POWER SUPPLY

P

STB5V

P+15V

F15V

SOUND15V

VSUS

DATA DRIVER (LEFT)

C2

F15V

STB5V

SUB9V

SUB5.6V

SUB5V

SUB3.3V

SUB1.8V

SUB1.2V

PS SOS4 (LED:4TIME)

POWER MICOM

ON/OFF CONTROL

Vda

P+15V

P+5V

COLD HOT

STANDBY VOLTAGE RECTIFIER

RECTIFIER

P+15V

P-BOARD SOS DETECT

PROCESS VOLTAGE RECTIFIER

POWER FACTOR CONTROL

RECTIFIER

RELAY

P9

SOS8_SS

SUSTAIN CONTROL

Vda

VIDEO DATA

DCDC

P+1.2V

DCDC P+5V

DCDC

P+3.3V

KEY SWITCH

VSUS

SUSTAIN VOLTAGE RECTIFIER

AC CORD

P+1.2V

P+5V

P+3.3V

VSUS

P+15V

MAIN SW2

MAIN SW1

Vda

P35

C25

Vda

SD CARD DATA

P11

P34

P+5V

SD CARD

SLOT

K

POWER LED REMOTE RECEIVER

STB3.3V

SS11

A1

SUSTAIN DRIVE

SS

VSUS

P+15V

P+5V

SS23

SOS8_SS

K1

SS-BOARD SOS DETECT

(LED:8TIME)

VSUS GEN. VE GEN. ENERGY RECOVERY

ENERGY RECOVERY COIL

SUSTAIN CONTROL

STB3.3V

SS3

LED_R/G

REMOTE RECEIVER

MID

POWER SW

MAIN SW2

MAIN SW1

S1B

POWER SWITCH

S

ON

C23

DATA DRIVER

35

DATA DRIVER

11.2. Block (1/4) Diagram

JK3302A

COMP

JK3100C

AV2

JK3107A

HEADPHONE

TV_SUB_ON

PANEL_MAIN_ON

STB5V_SW_ON

SOUND15V

AV1

YPBPR

AUDIO IN

JK8940

CI SLOT

STB5V

SOS4_PS

P+15V

P_S0

P_S1

F15V

12

L(+)

L(-)

SPEAKER

15V

D2014

CI POWER ON

P ON/OFF

L_OUT

SOS

SOUND SOS

(LED:12TIMES)

KEYSCAN1

POWER_DET

KEYSCAN1

SPEAKER_R

3

R(+)

SYS_IIC0

PWM L/R

POWER_DET

SW_OFF_DET

4

R(-)

R_OUT

SPEAKER

SUB9V DET

P+15V

SUB3.3V DET

SUB5V DET

LVDS_OUT

OSD I/F

P+5V DET

SUB3.3V

IIC0

IIC1

IIC2

GENX IIC

P+3.3V DET

(LED:3TIMES)

(LED:5TIMES)

STB3.3VSTB3.3V

STB1.2V

LVDS DATA

IIC0

IIC1

IIC2

GENX IIC

P+3.3V

P+5V

IC1000

TEMP SENSOR

P+15V

STB5V

SUB9V

SUB5V

IC1100

EEPROM

1

2

STB3.3V

3

4

IIC2

5

6

7

8

9

10

11

IC2301

SOUND15V

PWM L/R

POWER LED(R)

G LED ON

PANEL SOS

SPEAKER_L

A11

Q2301

SOUND SOS DET

PANEL SOS

PANEL MAIN ON

CI POWER ON

D3300

SUB3.3V

Q4512

STB_RST

XRST_SYS_PD4

ARC_OFF

TV SUB ON

SOS

TV SUB ON

OPTICAL

AUDIO

OUT

OPTICAL AUDIO OUT

AUDIO I/F

REMOTE IN

(LED:10TIMES)

SOS

REMOTE IN

AUDIO AMP

SPDIF

POWER LED(R)

SD DATA:4bit

SD CARD

I/F

NRST

XRST

JK8850

SD CARD

P

SUB_SD_3.3V

DTV_XRST

DTV_RST

STB_RST

IIC_TU

IIC2

JK4700

HDMI IN 1

TMDS DATA

CLOCK

Y/PR/PB

L/R

VV

LO1_L/RMON_L/R

LO2_L/R

HP_L/R

VDAC OUT

SUB3.3V

DDC IIC

SIF I/F

TS I/F

V

DIGITAL SIGNAL PROCESSOR

A

AV1_VIN

AV1_RED

AV1_GREEN

AV1_BLUE

AV1_LIN

AV1_RIN

AV1_VOUT

AV1_LOUT

AV1_ROUT

AV1_QLINK

Y

PB

PR

V

LIN

RIN

HP_L

HP_R

Parallel_TS(CI_IN)

Parallel_TS(CI_OUT)

IC8402

5V_CI

V/R/G/B

L/R

V

L/R

Y/PB/PR

AV1_VOUT

AV1_L/ROUT

IIC2

AV1

AV2

COMP

IC3000

AV SW

5V9V

3.3V

TV

MAIN

Y/PR/PB

TV_L/R

IC3001

+5V

L/R

CVBS IN1

TU2901A

ANT IN

V

L/R

SUB5.6V

TV_V

VIDEO

AM

AUDIO

TUNER

5V

IIC_TU

IF_AGC

IFD_OUT2

SIF_OUT

IFD_OUT1

1.2V

3.3V

IC2950

1.2V

SUB3.3V

IC8302

2.5V

RGB_CVBS

DVB_RF

IC8400

CI TS CONT.

FE1.2V

IFD1

IFD2

IF_AGC

DIGITAL DEMODULATOR

Parallel_TS(FE)

Parallel_TS

IC8300

OFDM

IC8401

CI ASIC

P7

A7

1

3

4

5

7

8

9

A6P6

1

2

7

8

9

3

CI POWER ON

TV_SUB_ON

PANEL_MAIN_ON

STB5V_SW_ON

SOS4_PS

F15V

P_S0

P_S1

IC5401

9V

D5602

Q5603

Q5602

F15V DET ON/OFF

STB5V

SUB9V

IC5601

IC5600

SOUND15V

SUB5V SUB3.3V

+5V

+3.3V

SUB1.8V SUB1.2V

+1.8V

+1.2V

SUB5V

SUB3.3V

SUB1.8V

SUB1.2V

F15V

P+15V

IC2953

TNR3.3V

IC2952

TNR5V

IC2870

TNR3.3V

TNR5V

SUB5.6V

+5.6V

TV_SUB_ON

SUB5.6V

SUB9V

SUB5V

+5V

QLINK1

CI DATA

D5471

D5472

HDMI_CEC

ANALOG AV I/F

ANALOG AUDIO OUT I/F

IC8950

EEPROM

IC8921

NAND FLASH

JK4701

HDMI IN 2

+5V

TMDS DATA

CLOCK

DDC IIC

HDMI_CEC

RX0

RX1

HDMI I/F RECEIVER

Q5471

VOLTAGE DROP ERROR DET

SUB5.6V SUB9V SUB5V

ARC

CI I/F

DDC_IIC0

DDC_IIC1

SOS

IIC_IF

IIC1

CPU BUS

5VDET_1

5VDET_0

CPU BUS

HDMI_CEC_

I/F

IN_OUT

X8001 X8000

12MHz

OSCX0

OSCXI

VCC

AVDDH3.3V

AVDD3.3V

IC5603

AVDD

IC5604

AVDDH

IC8001

PEAKS-sLD

SUB1.8V

SUB3.3V

SUB1.2V

24.576MHz

AXO

AXI

MPU(GenX)

STB1.2V

STB3.3V

36

11.3. Block (2/4) Diagram

DIGITAL SIGNAL PROCESSOR

A

LVDS DATA

1

2

P+15V

IC9800

+1.2V

P+1.2V

IC9802

3.3V P+3.3V

P_S0

P_S1

IC9304

FLASH MEMORY

LVDS DATA

ADDR/DATA

IC9300

PLASMA AI CPG with SS H/V Sync Control Sub Filed Processor

FLASH I/F

P_S0

P_S1

1.2V

3.3V

OSD VOUT

XRST_SYS_PD4

DRVRST_PD4

PD4

DISCHARGE CONTROL

CONTROL DATA

SUSTAIN CONTROL

SCAN CONTROL

X0 X1

SOS_DCC

X9300

C11

A31

VIDEO DATA

IIC0

IC9400,01

BUFFER

UHZ

P+3.3V

11

VIDEO DATA

35

38

P+3.3V

40

P+3.3V

CONTROL DATA

A32

C21

3

VIDEO DATA

31

CONTROL DATA

52

P+3.3V

53

P+5V

55

SUSTAIN CONTROL

49

SOS8_SS

P ON/OFF

3

4

5

6

7

8

9

10

11

P+3.3V

P+5V

P+15V

STB5V

SUB9V

SUB5V SUB5V

STB3.3V

STB1.2V

STB_RST

DRVRST_ PD4

UHZ

STB3.3V

STB1.2V

STB_RST

PANEL SOS

DRVRST_PD4

SC_UHZ

D_UHZ

IC5000

ANALOG-ASIC

TV SUB ON

Q5000

SOS8_SS

SOS6_SC1

SOS7_SC2

SOS_DCC

SOS4_PS

P+3.3V

D5000

STB5V

SUB9V

SOS8_SS (LED:8TIMES)

SOS6_SC1

(LED:6TIMES)

SOS7_SC2 (LED:7TIMES)

SOS_DCC (LED:9TIMES)

SOS4_PS (LED:4TIMES)

STB+3.3V

STB+1.2V

STB5V_SW_ON

PANEL SOS

STB5V_SW_ON

STB_RST

POWER_DET

SW_OFF_DET

IC9801

+5V

D5100

Q5100

Q5101

POWER_DET

P+5V

P+15V

KEYSCAN1

KEY SWITCH

F

SW5150 SW5151 VOL.UP/CH.UP SW5152

VOL.DN/CH.UP

SW5153

TV

SW5154

AV

KEY SWITCH

DRVRST_PD4

XRST_SYS_PD4

STB3.3V

SOS_DCC

D_UHZ

SOS8_SS

SC_UHZ

SOS6_SC1

SOS7_SC2

G_LED_ON

POWER LED(R)

REMOTE IN

P+5V

P+15V

SC20A20

SCAN CONTROL

18

UHZ

15

SOS6_SC1

16

SOS7_SC2

1

P+5V

29

P+15V

30

P+15V

CN0102

IIC1 IIC2 Genx_IIC

A1

G_LED_ON

2

R_LED_ON

3

RMIN

1

STB3.3V

4

K1

POWER LED

2

3

1

4

POWER LED

K

REMOTE RECEIVER

D2520

G

R

FOR FACTORY USE

RM2510

REMOTE

37

11.4. Block (3/4) Diagram

P POWER SUPPLY

T100

IC100

PFC

D100

RECTIFIER

L100,L101

Q103 Q104

DRIVE

CONTROL

R141

PFC

NEUTRAL

LIVE

630mA 250V

F200

FILTER

D108 D109

AC DET

IC200

5A 250V

PR101

Q101

D200

RECTIFIER

IC201

STB CONTROL

HOT COLD

Q300-Q303

RESONANCE

PFC_ON

T301

T300

IC601

PHOTO COUPLER

RL100

RL101

D701

PHOTO COUPLER

D702 D703

MULTI CONTROL

IC700

Q609

IC903

Q705

4A 250V

D903 D904

Q706

Vsus REFERENCE

Q707

IC901

Vda ERROR DET

PR900

Vsus

VR251

Q714

Q709-Q712

Vsus Adj

Q602

RL102

Q600

D800

T400

Q400-Q402

DET

IC400

STB CONTROL

IC401

PHOTO COUPLER

IC800

F+15V ERROR DET

+

V_RESO_ON

PFC_ON

MAIN RELAY_ON

RUSH RELAY_ON

+5V

IC603

POWER MICOM

(LED:4TIMES)

AC FAIL

RST

MAIN SW_ON

IC600

PHOTO COUPLER

T200

D501

IC602

RESET

-

+

DRIVE

Q901

CONTROL

D600

IC902

Vda CONTROL

+

-

Q703

Q715

Vsus_IN

ALL_OFF

PANEL_MAIN_ON

POWER SOS

TV SUB ON

STB5V_IN

F_15V_ON

STB5V_

ON/OFF

Q701

DET

D708

Vda_IN

XOUT

XIN

Q801

ON/OFF

Q800

IC701

Vsus ERROR DET

X600 4MHz

T900

Vda ERROR DET

Q805 Q807

15V DET

IC904

Vsus

R923

Vda

DISCHARGE

P2

1

Vsus

P11

1

Vsus

4

P+15V

P35

1

Vda

2

Vda

P25

1

P+15V

2

P+15V

5

STB5V

7

S0

8

S1

9

PANEL_MAIN_ON

10

SOS_P4

SC2

SS11

C25

NO USE

Q505

F100 F101

10A 250V

IC202

10A 250V

LIVE

NEUTRAL

1 143

P9

PHOTO COUPLER

COLDHOT

IC500

STB ERROR DET

1

P34

931

P6

7

2

A6

P+15V

F+15V

AC CORD

MAIN_SW_2

MAIN_SW_1

1

5V

S POWER SWITCH

PUSH

SW2500

POWER SWITCH

3

S1B

STB_PS

F+15V

SOUND+15V

38

SOUND+15V

5

73 3

11

8

9

ALL_OFF

TV SUB ON

14

SOS_P4

MAIN_SW_112MAIN_SW_2

STB5V_SW_ON

P7

S0

S1

A7

STBY5V

PANEL_MAIN_ON

11.5. Block (4/4) Diagram

SCAN DRIVE

SC

SC2P2

Vsus

1

IC16771

Vad+5V

PC16461

PHOTO COUPLER

IC16501

CSH/CMH GATE DRIVE CIRCUIT

MID

3

5

IC16521

CSL/CML GATE DRIVE CIRCUIT

IC16581

ERROR DET

1

2

D16822

TPSOS6

(LED:6TIMES)

SCAN CONTROL

TPSOS7

(LED:7TIMES)

SOS6_SC1

SOS7_SC2

SCAN CONTROL

SS3

A20

P+15V

P+5V

SC3

MID

SC 20

30

13

UHZ

16

15

CMH

CSH

F16V

CSL

CML

CMH

CSH

P+5V

D16820

D16480

TPVSUS

UHZ

Q16401 Q16402

D16461

Q16441

D16583

LED(G)

D16493

PHOTO COUPLER

VRH

VRL

D16481

Q16451

Q16421

IC16561,62

BUFFER

IC16563

INVERTER

D16920

Q16876

ERROR DET

PC16480

PHOTO COUPLER

PC16603

PC16684

IC16490,91

SEPA PROTECT CIRCUIT

PC16685

PHOTO

COUPLER

Q16490

P+15V

D16821

IC16471

SHUNT REG

VOL

Q16607

CERS

CPH1

Q16621

CML CMH CSH CSL

CRC1

D16618

Q16601

CIS

CPH1 CIS CERS CEL

CRC2

SIU OC1 OC2 CLK

D16490

D16871

Q16471

TP59,TP60 TP61,TP62,TP63

VFG

IC16661

Q16661

COMPARATOR

CRC1

CRC2

Q16672

D16901

IC16692

SHUNT

REG.

IC16773

CEL

Q16885

+5V

(SC1)

INVERTER

IC16784,85

PC16896,97

IPD CIRCUIT

VAD GEN. SHUNT REG

F16V

F16V GEN.

IC16786,87

PC16722,23

IPD CIRCUIT

VSCN GEN.

Vscn

D16721

(16V_F)

D16475

D16473

SHUNT REG

IC16724

CHA

SCNR_PRO

VFG

T16471

TPVSCN

D16728

Q16818

D16859

TPVAD

TPSC1

5V_F

VSCN-F

SIU OC1 OC2 CLK

SC 50

1

SC JIG

2

P11

Vsus

P+15V

SM

SCAN OUT

IC14901-04

SCAN

DRIVER

SC3

MID

C23

SM

SC

42B

42

Vfo

1

2

5

66

8

99

SM

SC

46B

46

IC14951-54

DRIVER

SCNR_PRO

CHA

LOGIC IC

SUSTAIN CONTROL

SCAN

P+5V

SOS8_SS

SS 11

1

4

SS3

3

5

SS

23

1

5

SUSTAIN DRIVE

SS

IC16131

VSUS Gen.

DRIVER

IC16241

BUFFER

SUSTAIN CONTROL

TPVSUS

D16316

IPD CIRCUIT

UMH

Q16001 Q16002

Q16021

UML

Q16022

MID

UMH UML UEH

FPC DET

VE GEN.

PC16192

PHOTO COUPLER

PC16191

VE Gen. DRIVER

D16280

(LED:8TIMES)

IC16304

IC16312

SHUNT

REG.

L16303

Q16101 Q16102

UEH

TPSS1

Q16280

ERROR DET

TPVE

D16282

SS 53B

1

2

13

PLASMA PANEL

PANEL SUSTAIN ELECTRODE

SS 55B

1

2

13

IC14961-63

SM1-SM6

IC17101

PLASMA PANEL

PANEL SCAN ELECTRODE

VIDEO DATA

A31

C11

30

BUFFER

CONTROL DATA

6

CB2

PANEL DRIVER

3

P+3.3V

1

CB3CB1

P+3.3V

DATA DRIVER (RIGHT)

C1

CB4

C10

P+3.3V

19

P+3.3V

18

Vda

5

Vda

1

PLASMA PANEL

C20

2

3

16

20

CB5

A32

C21

IC17202

53

CB6

VIDEO DATA

CONTROL DATA

25

BUFFER

SOS8_SS

P+3.3V

SUSTAIN CONTROL

7

4

3

CB7

PANEL DRIVER

P+5V

1

DATA DRIVER (LEFT)

C2

BUFFER

IC17203

CB8

C23

SS23

1

P+5V

5

SOS8_SS

SUSTAIN CONTROL

C25

P35

1

Vda

2

Vda

39

40

12 Wiring Connection Diagram

12.1. Caution statement.

Caution:

Please confirm that all flexible cables are assembled correctly. Also make sure that they are locked in the connectors. Verify by giving the flexible cables a very slight pull.

12.2. Wiring (1)

12.3. Wiring (2)

41

12.4. Wiring (3)

42

12.5. Wiring (4)

43

44

13 Schematic Diagram

13.1. Schematic Diagram Note

45

13.2. P-Board (1/4) Schematic Diagram

!

A

P-BOARD LSEP1287LDHB (1/4)

COLD

B

COLD

HOT

TO AC CORD

C

HOT

1

2

3

D

C0DBZYY00361

PFC

E

COLD

HOT

F

AB AG

AA

AC AD AF AH AJ AKAIAE

3

4

TO P-BOARD (3/4)

582 71

96

46

13.3. P-Board (2/4) Schematic Diagram

!

P-BOARD LSEP1287LDHB (2/4)

COLD

HOT

1

2

C0DBZYY00360

Vda CONTROL

C0DBZMC00006

Vda ERROR DET

B3PBA0000459

PHOTO

COUPLER

C0DBZMC00006

Vda ERROR DET

TO C2-BOARD (C25)

3

TO SC-BOARD (SC2)

TO SS-BOARD (SS11)

LSSK0087

MULTI CONTROL

C0DBZMC00006

Vsus ERROR DET

HOT

COLD

TO

BA BB BC BE BF BG

P-BOARD (4/4)

BD BH

13 1812 1710 15 161411

47

BI BJ BL BM

BK

13.4. P-Board (3/4) Schematic Diagram

AA

AC AD AF AH AJ AKAIAE

AB AG

COLD

A

B

HOT

TO P-BOARD (1/4)

MIP2K20MSSCF

STB CONTROL

!

P-BOARD LSEP1287LDHB (3/4)

COLD

HOT

11

C

C0DBZMC00006

AC DET

B3PBA0000459

PHOTO

COUPLER

12

13

14

D

HOT

COLD

B3PBA0000459

HOT

COLD

E

PHOTO

COUPLER

*********

PHOTO

COUPLER

B3PBA0000459

PHOTO

COUPLER

C0DBZMC00006

STB ERROR DET

15

16

17

18

19

20

F

21

22

3

4

582 71

96

48

13.5. P-Board (4/4) Schematic Diagram

TO P-BOARD (2/4)

HOT

COLD

C0DBZMC00006

F+15V ERROR DET

HOT

MIP418AMDS

STB

CONTROL

B3PBA0000459

PHOTO

COUPLER

11

12

BD

BHBA BB BC BE BF BG

BI BJBLBM

BK

TO A-BOARD (A6)

13

14

15

16

17

18

19

C2ABDB000129

POWER MICOM

20

!

P-BOARD LSEP1287LDHB (4/4)

21

22

C0EBH0000447

RESET

TO S-BOARD (S1B)

NO USE

TO A-BOARD (A7)

13 1812 1710 15 161411

49

13.6. A-Board (1/19) Schematic Diagram

!

A-BOARD (1/19)

IIC

A

B

Change Reason :

For pattern module

FRONT END

SUB3.3V

R0966

R0967

4.7k

D-TNR_SCL

FE-OUT_SCL

TO 9,19/19

FE-OUT_SDA

D-TNR_SDA

TU2901A

D/A TUNER

A TUNER

P3.3V

R0948

PEAKS sLD

C

D

sLD IIC0 -> Develop IIC0

LDA2 IIC2 -> Develop IIC0

sLD IIC2 -> Develop IIC2

LDA2 IIC0 -> Develop IIC2

sLD IIC1 -> ADJ-Peaks IIC LDA2 IIC1 -> ADJ-Peaks IIC

TO 3/19

R0940

SCL0

SDA0

MSCL

SCL2

SDA2

MSDA

SCL1

SDA1

68

R0941

68

R0942

68

R0943

68

R0944

68

R0945

68

S

P3V_SCL02

P3V_SDA02

TO 13/19

PDP-PANEL_SCL

PDP-PANEL_SDA

PDP-PANEL

R0949

2.2k

S

R0951 R0978R0952 R0959

TMP-SENS_SCL

TMP-SENS_SDA

TO 17/19

TEMP SENSOR MM3285ANRE

SSS

SCL

TO 2/19

A-Chip

I2CSEL

H: Outside IIC control (Study only) L: D-chip internal control (Normal)

R0955

SDA

TO 2/19

I2CSEL

TP0940

R0957

1k

R0958R0950R0953 R0954

TO 11/19

AV-SW

AV-SW_SCL

SSS

AV-SW_SDA

TO 9,19/19

FE_SCL

DEVELOP_SCL2

TO 19/19

FE_SDA

DEVELOP_SDA2

FE-OUT_SCL

FE-OUT_SDA

SUB3.3V

R0980

4.7k

TO 5/19

PEAKS-EEP_SCL

Peaks EEP 32k

R0981

4.7k

SSS

R0979

PEAKS-EEP_SDA

STM

TO 3/19

STMSCL

STMSDA

R0982

22

R0983

22

STB3.3V

R0984

4.7k

IC1101

GenX EEP 16k

TO 6/19

DEVELOP_SCL0

DEVELOP_SDA0

DEVELOP_SCL2

DEVELOP_SDA2

ADJ-PEAKS_SCL

ADJ-PEAKS_SDA

(Peaks BE E2PROM)

ADJ-STM_SCL

ADJ-STM_SDA

(STM Loarder/E2PROM)

R0985

4.7k

R0987

R0986

STM-EEP_SCL

STM-EEP_SDA

CN0101

TO 19/19

TO 17/19

CN0100

E

TO 2,3,12/19

TO 3/19

JTAG

R0900

68

XRST

R0901

68

TRST

TMS

R0902

TDI

EXB28V680JX

TCK

R0903

68

R0910

SUB3.3V

R0905

10k

TD0900

XRST

TD0901

EVTRG

TD0902

TRST

TD0903

TMS

TD0904TDO

TDO

TD0905

TDI

TD0906

TCK

C0900

R0913

R0911

R0912

10k

16V

0.1u

F

1

2 96

3

57

84

50

13.7. A-Board (2/19) Schematic Diagram

!

A-BOARD (2/19)

Achip

RESET

NRST

CLK

IIC I/F

HDMI

DDCSDA0

DDCSCL0

RXCM0

DDCSDA2

DDCSCL2

RXCM2

IF I/F

SIF I/F

TO 18/19

RXCP0

RX0M0

RX0P0

RX0M1

RX0P1

RX0M2

RX0P2

RXCP2

RX2M0

RX2P0

RX2M1

RX2P1

RX2M2

RX2P2

TO 8/19

C8081 50V

C8079 50V

TO 12/19

IC8001 T3 NRST

10p

24.576MHz

X8000

H0J245500101

12p

I2CSEL

TO 7/19

TO 18/19

SUB1.2V

VDDAVAD

IC8001 B16 AXI

R8015

1k

IC8001 A16 AXO

TO 1/19

IC8001 AB3 SCL

SCL

IC8001 AC3 SDA

SDA

IC8001 C24 I2CSEL

IC8001 N3 DDCSDA0

IC8001 K3 DDCSCL0

IC8001 F2 RXCM0

IC8001 F1 RXCP0

IC8001 G2 RX0M0

IC8001 G1 RX0P0

IC8001 H2 RX0M1

IC8001 H1 RX0P1

IC8001 J2 RX0M2

IC8001 J1 RX0P2

IC8001 P3 DDCSDA1

IC8001 L3 DDCSCL1

IC8001 K2 RXCM1

IC8001 K1 RXCP1

IC8001 L2 RX1M0

IC8001 L1 RX1P0

IC8001 M2 RX1M1

IC8001 M1 RX1P1

IC8001 N2 RX1M2

IC8001 N1 RX1P2

IC8001 R3 DDCSDA2

IC8001 M3 DDCSCL2

IC8001 P2 RXCM2

IC8001 P1 RXCP2

IC8001 R2 RX2M0

IC8001 R1 RX2P0

IC8001 T2 RX2M1

IC8001 T1 RX2P1

IC8001 U2 RX2M2

IC8001 U1 RX2P2

IC8001 B14 FEAINN

IC8001 A14 FEAINP

D15_VREFHSIF

C15_VREFLSIF

SIFINN

SIFINP

IC8001 L11 VDDAVAD

IC8001 L12 VDDAVAD

IC8001 M11 VDDAVAD

IC8001 M12 VDDAVAD

IC8001 N11 VDDAVAD

IC8001 N12 VDDAVAD

IC8001 D15 VREFHSIF

IC8001 C15 VREFLSIF

IC8001 B13 SIFINN

IC8001 A13 SIFINP

PEAKS-sLD

VSW

C10_BIAS

D10_BIAS2

ADC

C6_VREFH0

D6_VREFL0

C7_VREFH1

D7_VREFL1

C8_VREFH2

D8_VREFL2

C9_VREFH3

D9_VREFL3

Analog Video In I/F

TO 7/19

B1

B1N

G1

G1N

R1

R1N

V1

V1N

HIN

VIN

FBL1

TO 18/19

SUB3.3V

AVDDV3.3V

TO 18/19

IC8001 C10 BIAS

IC8001 D10 BIAS2

TO 18/19

IC8001 D11 S11

IC8001 A3 B1

IC8001 B3 B1N

IC8001 A6 B2

IC8001 A9 B3

IC8001 D13 C1

IC8001 A2 G1

IC8001 B2 G1N

IC8001 A5 G2

IC8001 B5 G2N

IC8001 A8 G3

IC8001 A4 R1

IC8001 B4 R1N

IC8001 A7 R2

IC8001 A10 R3

IC8001 A11 V1

IC8001 B11 V1N

IC8001 D14 V2

IC8001 A12 V3

IC8001 D12 Y1

IC8001 D2 HIN

IC8001 D1 VIN

IC8001 C1 FBL1

IC8001 F4 AVDDV

IC8001 G4 AVDDV

IC8001 H4 AVDDV

IC8001 J4 AVDDV

IC8001 C5 AVSSV

IC8001 D4 AVSSV

IC8001 D5 AVSSV

IC8001 E5 AVSSV

IC8001 M13 AVSSV

IC8001 N13 AVSSV

IC8001 N14 AVSSV

IC8001 N15 AVSSV

IC8001 N16 AVSSV

IC8001 P15 AVSSV

IC8001 P16 AVSSV

IC8001 R15 AVSSV

IC8001 R16 AVSSV

IC8001 C6 VREFH0

IC8001 D6 VREFL0

IC8001 C7 VREFH1

IC8001 D7 VREFL1

IC8001 C8 VREFH2

IC8001 D8 VREFL2

IC8001 C9 VREFH3

IC8001 D9 VREFL3

IC8001 B1 VCMOBGR

TO 18/19

AVDD3.3V

AVDDA

TO 18/19

AVDD3.3V AVDDHP

Analog Audio In I/F

TO 8/19

LIN5_LP

TO 8/19

LIN5_RP

D21_VREF1V5

TO 18/19

Analog Audio Out I/F

HP1_L1

HP1_R1

LO1_L

LO1_R

LO2_L

LO2_R

TEST

AVDDV3.3V

IC8001 L19 AVDDA

IC8001 L20 AVDDA

IC8001 L21 AVDDA

IC8001 M19 AVSSA

IC8001 M20 AVSSA

IC8001 M21 AVSSA

IC8001 L22 AVDDHP

IC8001 L23 AVDDHP

IC8001 L24 AVDDHP

IC8001 M22 AVSSHP

IC8001 M23 AVSSHP

IC8001 M24 AVSSHP

A_MUTE

D20_VREG

IC8001 C18 HP1_L1

IC8001 D18 HP1_R1

IC8001 A18 LO1_L

IC8001 B18 LO1_R

IC8001 C17 LO2_L

IC8001 D17 LO2_R

IC8001 B15 ZEROMUTE0

IC8001 D16 ZEROMUTE1

IC8001 B17 ZEROMUTE2

IC8001 U11 TMODE0

IC8001 V11 TMODE1

IC8001 W11 TESTIOH

IC8001 K4 ADCT0

IC8001 D3 ADCT2

IC8001 C4 ADCT1

IC8001 E2 T_L0N

IC8001 E1 T_L0P

IC8001 C3 T_L1N

IC8001 C2 T_L1P

IC8001 C16 TESTIO

IC8001 D22 TEST_A1

IC8001 D23 TEST_A2

TO 18/19

AVDD3.3V L15_AVDDPLLA

TO 18/19

AVDD3.3V AVDDADA1/2/3

TO 18/19

AVDD3.3V

AVDDADA1/2/3

TO 18/19

AVDD3.3V AVDDADA1/2/3

IC8001 D19 A_MUTE

IC8001 C19 LIN1_LP

IC8001 B19 LIN_LN

IC8001 A19 LIN1_RP

IC8001 C20 LIN2_LP

IC8001 A20 LIN2_RP

IC8001 C21 LIN3_LP

IC8001 A21 LIN3_RP

IC8001 C22 LIN4_LP

IC8001 A22 LIN4_RP

IC8001 C23 LIN5_LP

IC8001 B23 LIN_RN

IC8001 A23 LIN5_RP

IC8001 D21 VREF1V5

IC8001 D20 VREG

TO 8/19

IC8001 L15 AVDDPLLA

IC8001 M15 AVSSADA

IC8001 L17 AVDDADA

IC8001 M17 AVSSADA

IC8001 L16 AVDDADA

IC8001 M16 AVSSADA

IC8001 L18 AVDDADA

IC8001 M18 AVSSADA

TO 18/19 TO 18/19

SUB1.2V

VDD12

IC8001 N17 VDD12

IC8001 N18 VDD12

IC8001 P17 VDD12

IC8001 P18 VDD12

IC8001 R17 VDD12

IC8001 R18 VDD12

IC8001 R19 VDD12

IC8001 T17 VDD12

IC8001 T18 VDD12

IC8001 T19 VDD12

IC8001 U17 VDD12

IC8001 U18 VDD12

IC8001 U19 VDD12

IC8001 U20 VDD12 IC8001 AC11 VDD3

IC8001 U21 VDD12

IC8001 U22 VDD12

IC8001 U23 VDD12

IC8001 U24 VDD12

IC8001 U31 VDD12

IC8001 U33 VDD12

IC8001 U34 VDD12

IC8001 V13 VDD12

IC8001 V14 VDD12

IC8001 V15 VDD12

IC8001 V16 VDD12

IC8001 V17 VDD12

IC8001 V18 VDD12

IC8001 V19 VDD12

IC8001 V20 VDD12

IC8001 V21 VDD12

IC8001 V22 VDD12

IC8001 V23 VDD12

IC8001 V24 VDD12

IC8001 V31 VDD12

IC8001 V32 VDD12

IC8001 V33 VDD12

IC8001 V34 VDD12

IC8001 W13 VDD12

IC8001 W14 VDD12

IC8001 W15 VDD12

IC8001 W16 VDD12IC8001 U32 VDD12

IC8001 W17 VDD12

IC8001 W18 VDD12

IC8001 W19 VDD12

IC8001 W20 VDD12

SUB3.3V

VDD3

MN2WS0125FE

IC8001 N19 VDD3

IC8001 N20 VDD3

IC8001 P19 VDD3

IC8001 P20 VDD3

IC8001 R20 VDD3

IC8001 T20 VDD3

IC8001 T21 VDD3

IC8001 T22 VDD3

IC8001 T23 VDD3

IC8001 T24 VDD3

IC8001 T31 VDD3

IC8001 T32 VDD3

IC8001 T33 VDD3

IC8001 T34 VDD3

IC8001 AC12 VDD3

IC8001 AD11 VDD3

IC8001

PEAKS-sLD

IC8001 A1 VSS

IC8001 A15 VSS

IC8001 A17 VSS

IC8001 A24 VSS

IC8001 AA12 VSS

IC8001 AA13 VSS

IC8001 AA14 VSS

IC8001 AA15 VSS

IC8001 AA16 VSS

IC8001 AA17 VSS

IC8001 AA18 VSS

IC8001 AA19 VSS

IC8001 AA21 VSS

IC8001 AA22 VSS

IC8001 AB12 VSS

IC8001 AB13 VSS

IC8001 AB15 VSS

IC8001 AB16 VSS

IC8001 AB17 VSS

IC8001 AB18 VSS

IC8001 AB21 VSS

IC8001 AB22 VSS

IC8001 AC17 VSS

IC8001 AC18 VSS

IC8001 AC21 VSS

IC8001 AC22 VSS

IC8001 AC31 VSS

IC8001 AC32 VSS

IC8001 AD21 VSS

IC8001 AD22 VSS

IC8001 AD31 VSS

IC8001 AD32 VSS

IC8001 AE31 VSS

IC8001 AE32 VSS

IC8001 AF31 VSS

IC8001 AF32 VSS

IC8001 AJ3 VSS

IC8001 AK3 VSS

IC8001 AL3 VSS

IC8001 AL4 VSS

IC8001 AL5 VSS

IC8001 AL6 VSS

IC8001 AL20 VSS

IC8001 AM3 VSS

IC8001 AM19 VSS

IC8001 AM20 VSS

IC8001 AM21 VSS

IC8001 AM22 VSS

IC8001 AM23 VSS

IC8001 AM24 VSS

IC8001 AM30 VSS

IC8001 AN2 VSS

IC8001 AN31 VSS

IC8001 AP1 VSS

IC8001 B24 VSS

IC8001 C25 VSS

IC8001 E3 VSS

IC8001 F3 VSS

IC8001 G3 VSS

IC8001 H3 VSS

IC8001 J3 VSS

IC8001 N21 VSS

IC8001 N22 VSS

IC8001 P21 VSS

IC8001 P22 VSS

IC8001 R21 VSS

IC8001 R22 VSS

IC8001 R23 VSS

IC8001 R24 VSS

IC8001 T11 VSS

IC8001 T12 VSS

IC8001 T13 VSS

IC8001 T14 VSS

IC8001 T15 VSS

IC8001 T16 VSS

IC8001 U12 VSS

IC8001 U13 VSS

IC8001 U14 VSS

IC8001 U15 VSS

IC8001 U16 VSS

IC8001 V12 VSS

IC8001 W12 VSS

IC8001 W21 VSS

IC8001 W22 VSS

IC8001 W23 VSS

IC8001 Y12 VSS

IC8001 Y13 VSS

IC8001 Y14 VSS

IC8001 Y18 VSS

IC8001 Y19 VSS

IC8001 Y21 VSS

IC8001 Y22 VSS

IC8001 AM7 NC

IC8001 AM8 NC

IC8001 AM9 NC

IC8001 AM10 NC

IC8001 B6 NC

IC8001 B7 NC

IC8001 B8 NC

IC8001 B9 NC

IC8001 B10 NC

IC8001 B12 NC

IC8001 B20 NC

IC8001 B21 NC

IC8001 B22 NC

IC8001 C11 NC

IC8001 C12 NC

IC8001 C13 NC

IC8001 C14 NC

TO 18/19

AVDDH3.3V

AVDDH

IC8001 P11 AVDDH

IC8001 P12 AVDDH

IC8001 P13 AVDDH

IC8001 P14 AVDDH

IC8001 R11 AVDDH

IC8001 R12 AVDDH

IC8001 R13 AVDDH

IC8001 R14 AVDDH

TO 18/19

AVDDPLLV/75D

TO 18/19

SUB3.3V

L14_AVDDSIF

G_SIF S_GND

IC8001 L13 AVDDPLLV

IC8001 E4 AVDD75D

IC8001 L14 AVDDSIF

IC8001 M14 AVSSSIF

10 15 1613 1811 171412

51

13.8. A-Board (3/19) Schematic Diagram

!

A-BOARD (3/19)

IC8001

MN2WS0125FE

PEAKS-sLD

Dchip

R8212

PEAKS-sLD

RESET

TO 1,2,12/19

IC8001 Y33 XRST

XRST

CLK

IC8001 AM12 CLK27

IC8001 AM13 CLK74

IIC I/F

SCL0

SDA0

SCL1

SDA1

MSCL

MSDA

TO 1/19

IC8001 AL17 SCL0

IC8001 AP17 SDA0

IC8001 AP16 SCL1

IC8001 AN16 SDA1

IC8001 D28 MSCL

IC8001 D27 MSDA

SCL2

SDA2

R8211

10k

SERIAL I/F

IC8001 AN10 SBI0

IC8001 AP10 SBO0

IC8001 AN11 SBI1

IC8001 AP11 SBO1

IC8001 AN8 SBT1

IC8001 AL14 TXD0

R4004

R4003

47k

IC8001 AM15 RXD0

47k

CI I/F

TO 4/19

CH0DATA

CH0PSYNC

TS I/F

Parallel

EA12

EA14

EA15

EA13

EA16

EA17

EA18

EA19

EA20

EA21

EA22

CH0CLK

CH0VAL

XRTS0

XDSR0

XDTR0

XDCD0

XCTS0

XRI0

IC8001 AL13 XRTS0

IC8001 AN12 XDSR0

IC8001 AN13 XDTR0

IC8001 AP12 XDCD0

IC8001 AP13 XCTS0

IC8001 AL12 XRI0

IC8001 AL16 CH0CLK

IC8001 AN17 CH0DATA

IC8001 AL15 CH0PSYNC

IC8001 AN14 CH0VAL

TO 4/19

IC8001 AN3 EA12

IC8001 AK4 EA14

IC8001 AM2 EA15

IC8001 AP2 EA13

IC8001 AN1 EA16

IC8001 AJ4 EA17

IC8001 AL2 EA18

IC8001 AM1 EA19

IC8001 AK2 EA20

IC8001 AL1 EA21

IC8001 AJ2 EA22

PCWAIT

PCOE

PCWE

PCIORD

PCIOWR

PCRESET

PCCD1

PCREADY

PCCE1

PCDOE

HSBCLKIN

HSSYNIN

HSVALIN

HSDIN0

HSDIN1

HSDIN2

HSDIN3

HSDIN4

HSDIN5

HSDIN6

HSDIN7

SD CARD I/F

TO 18/19

W24_LVVDD12

SUB1.2V

TO 5/19

TO 18/19

SUB1.2V

VDDR/A

TO 18/19

SUB_SD_3.3V

SDCLK

SDCMD

SDDAT0

SDDAT1

SDDAT2

SDDAT3

SDCD

SDWP

IC8001 AA20 VDDR

IC8001 AB20 VDDR

IC8001 AC20 VDDR

IC8001 AD20 VDDR

IC8001 Y20 VDDR

IC8001 AB19 VDDA

IC8001 AC19 VDDA

IC8001 AD19 VDDA

IC8001 W24 LVVDD12

IC8001 AB11 VDD33SD

IC8001 AL19 SDCLK

IC8001 AN18 SDCMD

IC8001 AP19 SDDAT0

IC8001 AN19 SDDAT1

IC8001 AP18 SDDAT2

IC8001 AL18 SDDAT3

IC8001 AM18 SDCD

IC8001 AM17 SDWP

TO 18/19 TO 18/19 TO 18/19

SUB1.8V

1.8V_DDRI/F

DDR MONITOR

IC8001 AA31 MMDQ6

IC8001 AA32 MMDQ13

IC8001 AJ32 MMDQ22

IC8001 AH32 MMDQ29

IC8001 Y31 MMDQS0

IC8001 W32 MMDQS1

IC8001 AL25 MMDQS2

IC8001 AM26 MMDQS3

IC8001 AL26 MMXDQS3

IC8001 AM25 MMXDQS2

IC8001 W31 MMXDQS1

IC8001 Y32 MMXDQS0 IC8001 H34 TF1P

DDR

TO 18/19

IC8001 AG31 MMCK

AG31_MMCK

IC8001 AG32 MMXCK

AG32_MMXCK

MMVCAL/REF

AB31_MMCKE

AB32_MMODT

IC8001 AL28 MMRODT

IC8001 AL27 MMRDRV

IC8001 AH31 MMVCAL

IC8001 AL29 MMVREF

IC8001 AB31 MMCKE

IC8001 AB32 MMODT

AL28_MMRODT

AL27_MMRDRV

NAND IF

IC8001 Y1 XNFCE

XNFCE

IC8001 W3 XNFRE

XNFRE

IC8001 Y3 XNFWE

XNFWE

TO 5/19

TO 4/19

TO 4,5/19

USB I/F

SUB1.2V AA11_VDDUSB

SUB3.3V AD15_VDDAUSB

SUB3.3V AD14_VDDPUSB

IC8001 Y23 VDDIO IC8001 U3 STMHPD1

IC8001 Y24 VDDIO

IC8001 AA23 VDDIO

IC8001 AA24 VDDIO

IC8001 AB23 VDDIO

IC8001 AB24 VDDIO

IC8001 AC23 VDDIOCK

IC8001 AC24 VDDIO

IC8001 AD24 VDDIO

IC8001 AJ31 VDDIO

IC8001 AK31 VDDIO

IC8001 AK32 VDDIO

IC8001 AL30 VDDIO

IC8001 AL31 VDDIO

IC8001 AL32 VDDIO

IC8001 AM31 VDDIO

IC8001 AM32 VDDIO

IC8001 AM33 VDDIO

IC8001 AN32 VDDIO

IC8001 AN33 VDDIO

IC8001 AN34 VDDIO

IC8001 AP33 VDDIO

IC8001 AP34 VDDIO

SUB3.3V

LVVDD33

IC8001 Y2 NFCLE

NFCLE

IC8001 W4 XNFWP

XNFWP

IC8001 AA4 NANDRYBY

NANDRYBY

IC8001 Y4 NFALE

NFALE

TO 18/19

IC8001 AA11 VDDUSB

IC8001 AD15 VDDAUSB

IC8001 AC14 VSSAPUSB

IC8001 AD14 VDDPUSB

IC8001 AD13 VSSAPUSB

IC8001 AD12 USBRREF

IC8001 AC13 USBRREF

IC8001 AP20 USBDP

IC8001 AN20 USBDN

IC8001 AB14 USBATEST

IC8001 J31 LVVDD33

IC8001 K31 LVVDD33

IC8001 L31 LVVDD33

IC8001 M31 LVVDD33

IC8001 N31 LVVDD33

IC8001 P31 LVVDD33

IC8001 R31 LVVDD33

IC8001 A34 LVVSSIC8001 AD23 VDDIO

IC8001 B32 LVVSS

IC8001 C32 LVVSS

IC8001 D32 LVVSS

IC8001 E32 LVVSS

IC8001 F32 LVVSS

IC8001 G32 LVVSS

IC8001 H32 LVVSS

IC8001 J32 LVVSS

IC8001 K32 LVVSS

IC8001 L32 LVVSS

IC8001 M32 LVVSS

IC8001 N32 LVVSS

IC8001 P32 LVVSS

IC8001 R32 LVVSS

SUB3.3V

AD18_DPAVDD

TO 18/19

SUB3.3V

P24_M1A1AVDD

TO 18/19

SUB3.3V

N24_MVAVDD

TO 18/19

SUB3.3V

AD16_AVDDPWM

TO 18/19

SUB3.3V

AD17_A2AVDD

CPU BUS I/F

TO 4/19

TO 5/19

TO 4/19

COMMON PORT

TO 6/19

TO 4/19

TO 6/19

TO 4/19

JTAG

TMS

TCK

TRST

TDO

TDI

IC8001 AD18 DPAVDD

IC8001 P24 M1A1AVDD

IC8001 P23 M1A1AVSS

IC8001 N24 MVAVDD

IC8001 N23 MVAVSS

IC8001 AD16 AVDDPWM

IC8001 AC15 AVSSPWM

IC8001 AD17 A2AVDD

IC8001 AC16 A2AVSS

EA0

EA1

EA2

EA3

EA4

EA5

EA6

EA7

EA24

EAS

ECLK

XERE

ERXW

TO 4/19

ACTIVE_ANTENNA_ON

TO 13/19

TO 6,8/19

TO 6/19

PD4H_NCS / SD_LED_ON

TO 5/19

TO 6/19

TO 4/19

TO 6/19

FE_XRST / SDRAM_CHK

MAIN_FAN_ON / SP_LED_ON

TO 6/19

TO 4/19

TO 12/19

TO 4/19

PD4H_OSD_VIN/DTV_VOUTENB

TO 6/19

PG-ACTIVE_ANTENNA_DET

TO 1/19

IC8001 AB34 TMS

IC8001 AA34 TCK

IC8001 AC33 TRST

IC8001 AC34 TDO

IC8001 AB33 TDI

IC8001 AN7 EA0

IC8001 AL7 EA1

IC8001 AM6 EA2

IC8001 AN6 EA3

IC8001 AP6 EA4

IC8001 AN5 EA5

IC8001 AP5 EA6

IC8001 AM5 EA7

IC8001 AH2 EA24

IC8001 AD4 EAS

IC8001 AP7 ECLK

IC8001 AC4 XERE

IC8001 AB4 XEWE0

IC8001 AA3 XEWE1

IC8001 AD3 ERXW

IC8001 AC2 ESZ0

IC8001 AB1 ESZ1

IC8001 AB2 XEDK

TO 4/19

TO 6/19

SDVOLC

DISPEN

SOUND_SOS

SIF_FIL_ON

EEPROM_WP

PANEL_LED_ON

LCD_EEP_WP

FAN_MAX/

SP_LED_DIM

USB_VBUS

AVDD_ENB

REV_DAC_ENB

CI_POWER_ON

XETS_CI

CI_OSEL

XEAB

SD_PWR_ON

FILM_DET

SDBOOT

CI_OCP

POWER_DET

USB_OCP

FAN_SOS/FV_STS

TO 5/19

TO 4/19

TO 7/19

SUPPORT_CARD

FE_IRQ

SD_COIN_DET

XECS2

CH1PSYNC

CH1VAL

EA10

SDOUT0

SRCK0

SLRCK

LOSDOUT0

LOSDOUT1

ADCCK

SDOUT3

SMTD

SMTRST

SMTCMD

SMTSEL

AGCI

AGCR

PORT0

PORT1

PORT2

CH1CLK

EA23

SBT0

EA25

EA11

XECS3

IC8001 AA1 XECS2

IC8001 AP9 SMTCLK

IC8001 AP15 CH1DATA

IC8001 AN15 CH1PSYNC

IC8001 AM14 CH1VAL

IC8001 AP4 EA8

EA8

IC8001 AN4 EA9

EA9

IC8001 AM4 EA10

IC8001 C26 SDOUT0

IC8001 D29 SRCK0

IC8001 C29 SLRCK

IC8001 B30 LOSDOUT0

IC8001 C30 LOSDOUT1

IC8001 A30 ADCCK

IC8001 B31 SDOUT3

IC8001 AN9 SMTD

IC8001 AL9 SMTRST

IC8001 AL10 SMTCMD

IC8001 AP8 SMTSEL

IC8001 D24 AGCI

IC8001 D25 AGCR

IC8001 W33 PORT0

IC8001 W34 PORT1

IC8001 Y34 PORT2

IC8001 AP14 CH1CLK

IC8001 AK1 EA23

IC8001 AL11 SBT0

IC8001 AJ1 EA25

IC8001 AP3 EA11

IC8001 AA2 XECS3

TEST

ED0

ED1

ED2

ED3

ED4

ED5

ED6

ED7

ED8

ED9

ED10

ED11

ED12

ED13

ED14

ED15

XECS1

IECIN

XIRQ1

XIRQ2

XIRQ3

IC8001 Y15 TSTSEL

IC8001 Y11 FPENF

IC8001 C28 TSTAIO

IC8001 AM16 DTCPOUT

IC8001 Y17 V2TCPOUT

IC8001 AM11 A2TCPOUT

IC8001 Y16 M1A1TCPOUT

IC8001 AH3 ED0

IC8001 AH1 ED1

IC8001 AG2 ED2

IC8001 AG3 ED3

IC8001 AG1 ED4

IC8001 AG4 ED5

IC8001 AF2 ED6

IC8001 AH4 ED7

IC8001 AF1 ED8

IC8001 AF3 ED9

IC8001 AF4 ED10

IC8001 AE1 ED11

IC8001 AE4 ED12

IC8001 AE2 ED13

IC8001 AE3 ED14

IC8001 AD1 ED15

IC8001 AD2 XECS0

IC8001 AC1 XECS1

IC8001 AL8 BOOTSWAP

IC8001 A28 IECIN

VOUTENB

IC8001 C31 XNMIRQ

IC8001 A31 XIRQ1

IC8001 A32 XIRQ2

IC8001 A33 XIRQ3

PORT0[6]

PORT1[0]

PORT1[3]

PORT1[4]

PORT1[5]

PORT3[0]

PORT3[1]

PORT3[2]

PORT6[2]

PORT7[1]

PORT7[2]

PORT7[4]

PORT7[5]

PORT7[6]

PORT7[7]

PORT9[0]

PORT9[1]

PORT9[2]

PORT9[3]

PORT10[0]

PORT10[1]

PORT14[0]

PORT14[1]

PORT14[2]

PORT15[4]

PORT15[5]

PORT15[6]

PORT16[1]

PORT16[2]

PORT16[4]

VC27

STM

Analog Video Out I/F

SUB3.3V

L8007 J0JHC0000045

AUDIO I/F

TO 8/19

TO 7,10/19

TO 6/19

RESET

XRSTSTM

CLK

C8082

8p

50V

C8080

X8001

50V

H0J120500062

8p

IIC I/F

STMSCL

STMSDA

REMOTE

STMRMIN

HDMI I/F

TO 6,7/19

TO 6/19

TO 6,10/19

TO 6,7/19

TO 4/19

TO 8/19

IC8001 AH34 XRSTSTM

R8016

S

470

R8017

12.0MHz

TO 1/19

IC8001 AE33 STMSCL

IC8001 AD33 STMSDA

TO 6,17/19

IC8001 AG34 STMRMIN

TO 18/19

AP32_VDD12STM

STB1.2V

R8002

24k

R8003

10k

C8016

6.3V 1u

VDACO_PEAKS

PWM0LP

PWM0LN

PWM1RP

PWM1RN

IECOUT

NSHUTDOWN

IC8001 AN30 OSCXI

IC8001 AP30 OSCXO

STMCECO

STMCECPUL

STMCECAVL1A

STMCECAVL1B

STMHPD0

STMHPD1

STMHPD2

STMDDCSCL0

STMDDCSDA0

STMDDCSCL1

STMDDCSDA1

STMDDCSCL2

STMDDCSDA2

C8127

C8045

1u

0.1u

6.3V

16V

C8015

6.3V R8004

1u

24k

IC8001 AP23 PWM0LP

IC8001 AN23 PWM0LN

IC8001 AP22 PWM1RP

IC8001 AN22 PWM1RN

IC8001 B28 IECOUT

IC8001 AP21 NSHUTDOWN

IC8001 AN21 MUTEB

MUTEB

IC8001 W1 STMCECO

IC8001 W2 STMCECPUL

IC8001 AD34 STMCECAVL1A

IC8001 AE34 STMCECAVL1B

IC8001 V4 STMHPD0

IC8001 U4 STMHPD2

IC8001 L4 STMDDCSCL0

IC8001 P4 STMDDCSDA0

IC8001 M4 STMDDCSCL1

IC8001 R4 STMDDCSDA1

IC8001 N4 STMDDCSCL2

IC8001 T4 STMDDCSDA2

IC8001 AP32 VDD12STM

IC8001 A27 DAAVDD

IC8001 B27 DAAVSS

IC8001 B26 VVREF

IC8001 B25 VIREF

IC8001 A26 VCOMP

IC8001 A25 VDACO

TO 18/19

VDD33STM/ADAVDD

COMMON PORT

TO 6/19

TO 6,12/19

TO 6/19

TO 6,7/19

TO 6/19 TO 6,12/19 TO 6/19

TO 6,17/19

TO 6,9,11,12,17/19

TO 6,12/19

DEBUG

TEST

IC8001 AP31 VDD33STM

10k

R8032

LVDS I/F

TA1N

TA1P

TB1N

TB1P

TC1N

TC1P

TCLK1N

TCLK1P

TD1N

TD1P

TE1N

TE1P

PANEL PWM

TCON

R4005

47k

PANEL_VCC_ON

P5V_DET/BL_ON

PD4H_DRVRST/PWM_POW_ON

TO 6,17/19

PD4H_XRST_SYS/PANEL_TEST_ON

PD4H_PANEL_MAIN_ON/SBI

SUB3.3V_SENSE

SUB5V/SUB12V_SENSE

TO 6/19

TO 6,12/19

TO 6/19

PANEL_SOS/BL_SOS

TO 6,16/19

TO 6/19

SCLOCK

SDATA

STMEXTRG

TO 1,3,12/19

XRST

TO 13/19

TP4023

TP4022

TP4020

TP4021

IC8001 C27 SDOUT1

IC8001 D26 SDOUT2

IC8001 A29 LOSDOUT2

IC8001 B29 LOSDOUT3

IC8001 D30 LOSDOUT4

IC8001 D31 LOSDOUT5

IC8001 E31 LOSDOUT6

R4006

47k

IC8001 F31 LOSDOUT7

IC8001 G31 LOSDOUT8

IC8001 H31 LOSDOUT9

G_LED_ON

STMTIME0

STMTIME1

STMTIME2

STMTIME3

STMTIME4

R_LED_ON

SP_HP_MUTE

STMSBO0

MON_MUTE

STMSBI0

STMSBT0

P3.3V_DET/SBO

STMSBO1

STMSBI1

HDMI_5V_DET1

STMGPIO7

HDMI_5V_DET2

STMGPIO8

HDMI_5V_DET0

STMGPIO9

STMGPIO0

STMGPIO1

SW_OFF_DET

STMGPIO2

SRQ_GenX

STMGPIO3

GenX-EEP_WP

STMGPIO4

TV_SUB_ON

STMGPIO5

DTV_XRST

STMGPIO6

AI_SENSOR

STMADIN0

RF_AFT1 TRCST

STMADIN1

FACT

STMADIN2

KEY1

STMADIN3

STMADIN4

SOS

STMADIN5

IC8001 AK34 SCLOCK

IC8001 AM34 SDATA

IC8001 AL34 STMEXTRG

IC8001 AM29 STMTEST0

IC8001 AM28 STMTEST1

IC8001 AM27 STMTEST2

IC8001 AP29 ADAVDD

IC8001 AN29 ADAVSS

TP4014

TP4019

TP4016

TP4018

TP4015

TP4017

PWM1

PWM2

IC8001 AP26 STMTIME0

IC8001 AN26 STMTIME1

IC8001 AP27 STMTIME2

IC8001 AN27 STMTIME3

IC8001 AN25 STMTIME4

IC8001 AK33 STMSBO0

IC8001 AL33 STMSBI0

IC8001 AP28 STMSBT0

IC8001 AL24 STMSBO1

IC8001 AN28 STMSBI1

IC8001 V1 STMGPIO7

IC8001 V2 STMGPIO8

IC8001 V3 STMGPIO9

IC8001 AF34 STMGPIO0

IC8001 AJ34 STMGPIO1

IC8001 AG33 STMGPIO2

IC8001 AF33 STMGPIO3

IC8001 AJ33 STMGPIO4

IC8001 AH33 STMGPIO5

IC8001 AA33 STMGPIO6

IC8001 AN24 STMADIN0

IC8001 AP25 STMADIN1

IC8001 AL21 STMADIN2

IC8001 AL22 STMADIN3

IC8001 AL23 STMADIN4

IC8001 AP24 STMADIN5

TP4013

TP4012

LPL

LPR

POLL

POLR

CPV

GDATA1

GDATA2

LD

IC8001 B33 TA1N

IC8001 B34 TA1P

IC8001 C33 TB1N

IC8001 C34 TB1P

IC8001 D33 TC1N

IC8001 D34 TC1P

IC8001 E33 TCLK1N

IC8001 E34 TCLK1P

IC8001 F33 TD1N

IC8001 F34 TD1P

IC8001 G33 TE1N

IC8001 G34 TE1P

IC8001 H33 TF1N

IC8001 J33 TA2N

IC8001 J34 TA2P

IC8001 K33 TB2N

IC8001 K34 TB2P

IC8001 L33 TC2N

IC8001 L34 TC2P

IC8001 M33 TCLK2N

IC8001 M34 TCLK2P

IC8001 N33 TD2N

IC8001 N34 TD2P

IC8001 P33 TE2N

IC8001 P34 TE2P

IC8001 R33 TF2N

IC8001 R34 TF2P

P01

TRCD0

P02

TRCD1

P03

TRCD2

P04

TRCD3

P05

P10

P11

P12

P13

P14

P43

P44

P45

P70

P71

P72

P73

P74

P75

BEPOWER

BENST

P76

P80

TRCCLK

P81

P82

P83

P84

P85

19 2720 23 2524 2621 22

52

13.9. A-Board (4/19) Schematic Diagram

CI_DA6

CI_DA5

CI_DA4

CI_DA3

CI_DA2

CI_DA1

CI_DA0

CI_EAA1

CI_EAA2

CI_EAA3

CI_EAA4

CI_EAA5

CI_EAA6

CI_EAA7

CI_OCP

CI_POWER_ON

FE0_CLK

FE0_VAL

FE0_PSYNC

FE0_MDO7

FE0_MDO6

FE0_MDO5

FE0_MDO4

FE0_MDO3

FE0_MDO2

FE0_MDO1

FE0_MDO0

FE0_TS_Parallel

FE_MDO0

FE_MDO1

FE_MDO4

FE_MDO5

FE_CH0CLK

FE_CH0VAL

R8393

10k

R8394

10k

R8395

10k

EXB2HV101JV

EXB2HV680JV

C1AB00002913

JS8360

JS8361

JS8364

JS8365

JS8368

JS8369

R8397

EXB2HV103JV

R8420

R8422

IC8401

CI ASIC

TP8403

FE0_CLK

FE0_VAL

FE0_PSYNC

FE0_MDO7

FE0_MDO6

FE0_MDO5

FE0_MDO4

FE0_MDO3

FE0_MDO2

FE0_MDO1

FE0_MDO0

S

FE0_PSYNC

C8408

FE0_MDO0

FE0_MDO1

FE0_MDO4

FE0_MDO5

FE0_CLK

FE0_VAL

FE0_CLK

FE0_VAL

FE0_MDO7

FE0_MDO6

FE0_MDO5

FE0_MDO4

FE0_MDO3

FE0_MDO2

FE0_MDO1

FE0_MDO0

16V

0.1u

VJ8515

S

1

VIN

2

GND

3

EN

IC8402

C0ZBZ0001584

5V_CI

TO 19/19

FE0_MDO3

FE0_MDO2

FE0_MDO7

FE0_MDO6

FE1_XIRQ

FE0_PSYNC

FE0_TS_PD

FE_MDO7

FE_MDO6

FE_MDO5

FE_MDO4

FE_MDO3

FE_MDO2

FE_MDO1

FE_MDO0

FE_CH0CLK

FE_CH0VAL

FE_CH0PSYNC

C8400

16V

0.1u

SUB5V

P

L8400

J0JHC0000045

SUB5V_CI

AC_XETS_CI

AC_CI_OSEL

R8400

R8485

C8409

16V

0.1u

R8436

VJ8516

R8465

EXB28V680JX

22k

68

R8462

R8467

10k

R8437

22k

68

22k

C8414

25V

R8466

0.01u

10k

S

CI_DATAOUTA3

CI_DATAOUTA4

CI_DATAOUTA5

CI_DATAOUTA6

CI_DATAOUTA7

68

10k

CI_PKTSTINA

CI_DATAINA0

CI_DATAINA1

CI_DATAINA2

CI_DATAINA3

CI_DATAINA4

CI_DATAINA5

CI_DATAINA6

CI_DATAINA7

68

TP8401

CI_CLKOUTA

CI_ENOUTA

CI_PKTSTOUTA

CI_DATAOUTA0

CI_DATAOUTA1

CI_DATAOUTA2

C8413

0.01u

AS_CD1-

CI_IORD-CI_DA7

CI_IOWR-

R8450

47k

CI_RESET-

CI_WAIT-

CI_REG-

AS_CD2-

25V

AC_XPDWT

AC_XPDOE

AC_IORD

AC_XPDWE

AC_IOWR

AC_CI_RESET

CH0CLK

CH0DATA

AC_XPDCE1

AC_XEDB

CI_POWER_ON

AC_XETS_CI

AC_CI_OSEL

AC_XEAB

CI_OCP

AC_REG

AC_CHVAL

AC_CHSYNC

AC_CHCLK

AC_CHDI0

AC_CHDI1

AC_CHDI2

AC_CHDI3

AC_CHDI4

AC_CHDI5

AC_CHDI6

AC_CHDI7

R8501

VJ8517

S

EXB28V680JX

XRTS0

PCWAIT

XDSR0

PCOE

XDCD0

PCWE

PCIORD

XDTR0

XCTS0

PCIOWR

XRI0

R8508

68

R8505

68

R8510

R8509

68

R8506

68

R8507

68

R8480

68

R8498

68

S

VJ8520

R8488

68

R8489

68

R8490

68

R8491

68

R8492

68

R8493

68

R8494

68

R8495

68

R8496

68

R8497

68

R8499

68

PCRESET

CH0CLK

PCCD1

CH0DATA

PCREADY

CH0PSYNC

PCCE1

PCDOE

CH0VAL

CI_POWER_ON

SMTD

SMTRST

XETS_CI

CI_OSEL

SMTCMD

XEAB

SMTSEL

CH1CLK

CI_OCP

REG

HSVALIN

EA15

HSSYNIN

EA14

HSBCLKIN

EA12

HSDIN0

EA13

HSDIN1

EA16

EA17

HSDIN2

TO 3/19

HSDIN3

EA18

EA19

HSDIN4

HSDIN5

EA20

HSDIN6

EA21

EA22

HSDIN7

TO 3/19

+

C8411

C8412

10V

16V

100u

CI_DATAINA3

CI_DATAINA2

CI_DATAINA1

CI_DATAINA0

CI_PKTSTINA

CI_DATAOUTA7

CI_DATAOUTA6

CI_DATAOUTA5

CI_DATAOUTA4

CI_DATAOUTA3

CI_IREQ-

AS_CD2-

AS_CD1-

R8417

EXB28V104JX

R8456

100k

C8401

16V

0.1u

AC_CHCLK

AC_CHVAL

AC_CHSYNC

AC_CHDI0

AC_CHDI1

AC_CHDI2

AC_CHDI3

AC_CHDI4

AC_CHDI5

AC_CHDI6

AC_CHDI7

R8511

EXB28V103JX

R8500

EXB2HV103JV

TO CI SLOT

TO 5/19

CI_DA3

CI_DA4

CI_DA5

CI_DA6

R8457

10k

CI_CE1-

CI_OE-

CI_WE-

CI_IREQ-

CI_ENINA

CI_CLKINA

EXB28V104JX

C8402

16V

0.1u

R8468

EXB2HV680JV

R8469

R8483

R8484

10k

R8404

EXB2HV680JV

CI_DA7

CI_EAA11

CI_EAA12

CI_EAA10

CI_EAA9

CI_EAA14

CI_EAA15

CI_EAA13

CI_EAA8

R8516

CI_EAA7

10k

CI_EAA6

CI_EAA5

CI_EAA4

CI_EAA3

CI_EAA2

CI_EAA1

CI_DA0

CI_DA1

CI_DA2

R8415

CI_DATAOUTA0

CI_DATAOUTA2

CI_DATAOUTA1

62

63

64

1

4

TS3VI4

5

TS3VI3

6

TS3VI2

7

TS3VI1

8

TS3VI0

9

GND

68

10

TS3VICLK

68

11

TS3VIVAL

OSEL15VDD3V16TS3VO0

68

12

TS3VISYNC

13

OE

14

17

18

19

AC_CHDI0

AC_CHDI1

AC_CHDI4

AC_CHDI2

AC_CHDI3

CI_DA3

CI_DA4

CI_DA5

CI_DA6

CI_DA7

CI_CE1-

CE1#

CI_EAA11

A10

CI_OE-

OE#

CI_EAA12

A11

CI_EAA10

A9

CI_EAA9

A8

CI_EAA14

A13

CI_EAA15

A14

CI_WE-

WE#

CI_IREQ-

IREQ#

VCC

VPP1

CI_ENINA

MIVAL

CI_CLKINA

MCLKI

CI_EAA13

A12

CI_EAA8

A7

CI_EAA7

A6

CI_EAA6

A5

CI_EAA5

A4

CI_EAA4

A3

CI_EAA3

A2

CI_EAA2

A1

CI_EAA1

A0

CI_DA0

CI_DA1

CI_DA2

100k

R8455

R8454

CI_WAIT-

CI_ENOUTA

CI_ENINA

CI_CLKOUTA

CI_CLKINA

CI_PKTSTOUTA

61

TS5VO0

TS3VO421TS3VO522TS3VO623TS3VO724VDD3V25TS3VOSYNC26TS3VOVAL27TS3VOCLK28GND29IREQ3VO

20

AC_CHDI5

60

TS5VO1

TS5VOVAL

TS5VOSYNC

TS5VO2

VDD3V

TS3VI72TS3VI63TS3VI5

TS3VO1

TS3VO2

TS3VO3

AC_CHDI6

C8415

16V

0.1u

R8411

59

WAIT5VO

AC_CHDI7

68

58

TS5VOCLK

CD12OR3VO

150

R8447

56

57

GND

TS5VI5

TS5VI4

VDD5V

CD23VO

WAIT3VO

AC_CHSYNC

AC_CHVAL

R8406

EXB28V680JX

55

TS5VICLK

R8449

54

TS5VIVAL

AC_CHCLK

CI_DATAINA7

CI_DATAINA6

150

TS5VI653TS5VI7

TS5VISYNC

CD13VO34CD15VO35CD25VO

CH0DATA

CI_DATAINA5

CI_DATAINA4

51

52

TS5VI0

GND

TS5VO7

TS5VI147TS5VI248TS5VI3

TS5VO6

TS5VO5

TS5VO4

TS5VO3

VDD3V

IREQ5VO

30

CH0CLK

AC_XPDWT

R8409

EXB28V680JX

CD1#

CI_CD1-

CI_MDO3

CI_MDO4

CI_MDO5

CI_MDO6

CI_MDO7 CE2#

CI_CE2VS1#

CI_IORD-

CI_IOWR-

CI_PKTSTINA

CI_DATAINA0

CI_DATAINA1

CI_DATAINA2

CI_DATAINA3 VCC

VPP2

MDI4

CI_DATAINA4 MDI5

CI_DATAINA5 MDI6

CI_DATAINA6 MDI7

CI_DATAINA7 MCLKO

CI_MCLKO RESET

CI_RESETWAIT#

CI_WAITINPACK#

CI_INPACKREG#

CI_REG-

CI_MOVAL

CI_MOSTRT

CI_MDO0

CI_MDO1

CI_MDO2 CD2#

CI_CD2-

J0JHC0000045

C8407

EXB28V151JX

50

31

L8401

16V

0.1u

49

46

45

44

43

42

41

40

39

38

37

36

33

32

VJ8519

R8414

R8416

EXB28V151JX

R8448

S

IC8400

C1AB00003193

CI TS CONT.

S

150

R8413

VJ8000

VJ8001

R8445

R8451

R8464

R8481

R8463

EXB28V680JX

TO 3/19

!

TO 3/19

NANDRYBY

SUPPORT_CARD

USB_OCP

TO 3/19

AA_ERXW

AA_EA1

AA_EA2

AA_EA3

AA_EA4

AA_EA5

AA_EA6

AA_EA7

A-BOARD (4/19)

VDACO_PEAKS

ECLK

XECS1

XECS2

XECS3

XERE

PORT2

R8669

NANDRYBY

XIRQ1

FE_IRQ

XIRQ2

SBT0

XECS3

AGCR

SUB3.3V

R8639

R8646

10k

CI SLOT

TP8730

R8733

160

R8664

10k

S

R8619

S

R8621

S

R8655

S

R8656

SUB3.3V

R8618

10k

S

R8607

TP8600

VJ8601

S

10k

R8638

R8661

10k

2.2k

R8645

68

S

R8635

R8636

68

VJ8600

S

VJ8602

S

VJ8603

R8628

10k

R8631

R8632

R8627

10k

R8660

EXB2HV680JV

R8617

R8633

R8671

R8616

2.2k

VDACO

TO 11/19

SUB3.3V

R8652

10k

AA_XECS2

TO 5/19

C8600

50V

1000p

SUB3.3V

R8606

2.2k

AB_NANDRYBY

TO 5/19

TP8601

TO 9,19/19

AA_FE_RST

R8610

68

ERXW

EA0

EA1

EA2

EA3

TO 3/19

EA4

EA5

EA6

EA7

NFALE

TO 3,5/19

SUB3.3V

P

VJ8514 VJ8513

CI_EAA9

CI_EAA12

CI_EAA11

CI_EAA10

CI_EAA14

CI_EAA15

CI_OE-

CI_WE-

CI_CE1-

CI_REG-

CI_RESET-

R8426

R8425

68

C8404

16V

0.1u

C8405

16V

0.1u

VOUT

/OC

R8423

EXB2HV680JV

13

14

15

16

17

18

NCE5VOUT

CI_RESET_5VOUT

20

NREG5VOUT

21

ED5VIO2

22

ED5VIO1

23

ED5VIO0

ED5VIO419ED5VIO3

24

EA5VOUT1

25

EA5VOUT2

26

EA5VOUT3

EA5VOUT631EA5VOUT732GND

27

EA5VOUT4

28

EA5VOUT5

29

30

EA3VIN137EA3VIN238EA3VIN339EA3VIN440EA3VIN541EA3VIN642EA3VIN743ED3VIO044ED3VIO145ED3VIO2

33

34

35

36

68

R8453

R8452

CI_EAA13

CI_EAA8

AA_EA1

SUB3.3V

R8470

10k

R8433

0.1

5

C8410

16V

0.1u

4

R8431

10k

R8432

10k

TO 3/19

S

JS8362

JS8363

JS8366

JS8367

FE_MDO3

S

FE_MDO2

S

FE_MDO7

S

FE_MDO6

SUB3.3V

R8396

10k

VJ8360

S

FE_CH0PSYNC

JS8370

VDD5V1

AA_EA2

ED5VIO7

ED5VIO6

ED5VIO5

VDD5V2

EA5VOUT8

EA5VOUT13

AA_EA3

AA_EA4

AA_ED0

AA_ED1

AA_ED2

AA_ED3

AA_ED4

AA_ED5

AA_ED6

AA_ED7

Q8400

DSC200100L

10

GND

NOE5V/EA10

EA5VOUT1011EA5VOUT1212EA5VOUT11

NWE5V/EA11

AA_EA5

EAS

9

ED3VIO4

ED3VIO3

AA_EA6

EA5VOUT9

VDDADR

8

AA_EA7

AA_ED0

AA_ED1

AA_ED2

AA_ED3

AA_ED4

AA_ED5

AA_ED6

AA_ED7

GND

AA_ED0

R8434

47k

CI_IOWR-

6

EA5VOUT157EA5VOUT14

NIORD3V/EA13

CI_RESET_3VIN

AA_ED1

CI_IORD-

4

5

NIORD5V/EA9

NIOWR5V/EA8

NOE3V/EA14

NWE3V/EA15

NCE3VIN

NOE_DAT

NOE_ADR

NREG3VIN

NIOWR3V/EA12

VDD3V50MODE51ED3VIO5

ED3VIO7

ED3VIO6

AA_ED2

AA_ED3

TO 5/19

R8439

22k

R8440

100k

R8622

3

RNW

46

AA_ED4

EXB28V680JX

2

LE

47

AA_ED5

68

R8429

EXB28V473JX

R8424

R8471

10k

R8438

AA_XEAS

EXB28V103JX

AC_XEAB

AC_REG

AC_IOWR

AC_IORD

AC_XPDOE

AC_XPDWE

AC_XPDCE1

AC_XEDB

AC_CI_RESET

10k

2.2k R8515

R8428

C8406

16V

0.1u

1

64

63

62

61

60

58

57

56

55

54

53

52

49

48

AA_ED6

C8403

16V

0.1u

VJ8518

S

VJ8512

S

R8419

EXB2HV101JV

AA_ED7

SUB_CI_5V

TP8400TP8402

R8441

680

Q8401

DSC200100L

AA_XEAS

VJ8511

AA_ERXW

R8649

10k

28

31 33

53

343029 3632 35

13.10. A-Board (5/19) Schematic Diagram

A-BOARD (5/19)

!

CI SLOT,SD CARD,FLASH MEMORY

USE Adress Data Multi PleX

TO 3/19

SDCLK

SDCD

SDCMD

SDDAT0

TO 3/19

SDDAT1

SDDAT2

SDDAT3

SDWP

FLASH NOR & NAND USE

R8918

EXB2HV680JV

ED0

ED1

ED2

ED3

ED4

ED5

ED6

ED7

ED8

ED9

ED10

ED11

ED12

ED13

ED14

ED15

R8919

EXB2HV680JV

R8900

68

EA24

R8857

68

S

R8858

R8859

68

R8860

68

R8861

68

R8862

68

R8863

68

S

R8864

DeMPX ED[15-0] --> EA[23-8]

AA_ED0

AA_ED1

AA_ED2

AA_ED3

AA_ED4

AA_ED5

AA_ED6 AA_ED6

AA_ED7

AA_ED8

AA_ED9

AA_ED10

AA_ED11

AA_ED12

AA_ED13

AA_ED14

AA_ED15

SUB3.3V

SD_POWER

R8856

47k

H:3.3V L:1.8V

TO 4/19

AA_XECS2

SD/IC_CARD

AD_SDCLK

AD_SDCD

AD_SDCMD

AD_SDDAT0

AD_SDDAT1

AD_SDDAT2

AD_SDDAT3

AD_SDWP

AD_SDDAT2

AD_SDDAT3

AD_SDCMD

C8862

16V

0.01u

AD_SDCLK

AD_SDDAT0

AD_SDDAT1

C8863

TP8862

4V 22u

AA_ED0

AA_ED1

AA_ED2

AA_ED3

AA_ED4

AA_ED5

AA_ED7

AD_SDCD

AA_ED0

AA_ED1

AA_ED2

AA_ED3

TO 4/19

AA_ED4

AA_ED5

AA_ED6

AA_ED7

NC

SUB3.3V

L8920

R8920

2.2k

SUB_SD_3.3V

AD_SDWP

R8867

10k

R8878

10k

R8879

EXB28V103JX

R8869

R8870

10k

R8893

SUB3.3V

P

L8850

J0JHC0000045

J0JHC0000075

1NC2NC3NC4NC5NC6NC7

AB_XNFCE

AB_XNFWE

AB_XNFRE

AB_NFALE

AB_NFCLE

AB_XNFWP

AB_NANDRYBY

AA_ED7

45NC46NC47NC48

I/O442I/O543I/O644I/O7

IC8921

TVRR431

R/B#8RE#9CE#10NC11NC12VCC13VSS14NC15NC16CLE17ALE18WE#19WP#20NC21NC22NC23NC24NC

AB_NANDRYBY

AB_XNFRE

AB_XNFCE

R8923

R8924

R8925

R8926

R8927

R8928

AA_ED6

AA_ED5

38NC39NC40NC41

68

AA_ED4

37

AA_ED3

C8922

16V

0.1u

VSS

VCC

C8923

16V

0.1u

AA_ED0

AA_ED1

AA_ED2

R8922

EXB2HVR000V

33NC34NC35NC36

NAND FLASH

AB_NFCLE

AB_NFALE

XNFCE

XNFWE

XNFRE

TO 3/19

NFCLE

XNFWP

AB_NANDRYBY

NFALE

TO 3,4/19

AB_XNFWE

AB_XNFWP

TO 4/19

25NC26NC27NC28NC29

I/O030I/O131I/O232I/O3

CI CONNECTOR

USE LO HEIGHT

TO 4/19

JK8940

K1NA68B00054

CI SLOT

PC-CARD

GND

1

GND

CI_DA3

CI_DA4

CI_DA5

CI_DA6

CI_DA7

CI_CE1-

CE1#

CI_EAA11

A10

CI_OE-

OE#

CI_EAA12

A11

CI_EAA10

A9

CI_EAA9

A8

CI_EAA14

A13

CI_EAA15

A14

CI_WE-

WE#

CI_IREQ-

IREQ#

SUB_CI_5V

VCC

VPP1

CI_ENINA

MIVAL

CI_CLKINA

MCLKI

CI_EAA13

A12

CI_EAA8

A7

CI_EAA7

A6

CI_EAA6

A5

CI_EAA5

A4

CI_EAA4

A3

CI_EAA3

A2

CI_EAA2

A1

CI_EAA1

A0

CI_DA0

CI_DA1

CI_DA2

35

2

36

3

37

4

38

5

39

6

40

7

41

8

42

9

43

10

44

11

45

12

46

13

47

14

48

15

49

16

50

17

51

18

52

19

53

20

54

21

55

22

56

23

57

24

58

25

59

26

60

27

61

28

62

29

63

30

64

31

65

32

66

33

67

IOIS16#

34

68

CI_CD1-

CI_MDO3

CI_MDO4

CI_MDO5

CI_MDO6

CI_MDO7

CI_CE2-

CI_IORD-

CI_IOWR-

CI_PKTSTINA

VCC

CI_DATAINA0

CI_DATAINA1

CI_DATAINA2

CI_DATAINA3

CI_DATAINA4

CI_DATAINA5

CI_DATAINA6

CI_DATAINA7

CI_MCLKO

CI_RESET-

CI_WAIT-

CI_INPACK-

CI_REG-

CI_MOVAL

CI_MOSTRT

CI_MDO0

CI_MDO1

CI_MDO2

CI_CD2-

SUB_CI_5V

MCLKO

RESET

WAIT#

INPACK#

REG#

CD2#

MDI0

MDI1

MDI2

TO 4/19

MDI3

MDI4

MDI5

MDI6

MDI7

C8854

16V

0.1u

C8853

16V

TP8855

TP8854

101112

D.SW

0.1u

33

R8868

TP8853

TP8863

W.P.

S

R8866

*IC8950

TVRR502

EEPROM

1

E0

2

E1

3

E2

4

Vss

32K BIT (4K BYTE)

8

Vcc

TP8952

7

WC

TP8950

6

SCL

TP8951

5

SDA

JK8850

K1NA09E00080

SD CARD SLOT

33

R887233R8874

R8875

TP8860

TP8858

TP8859

1234567

9

GND

SDCMD

SDDAT3

SDDAT2

C8861

16V

0.1u

C8860

33

R8871

R887633R887733R8873

S

TP8856

TP8857

8

GND

3.3V SDCLK

SDDAT0

SDDAT1

+

16V 47u

38 444039 4237 4541 43

54

SUB3.3V

C8950

16V

0.01u

R8952

S

EEPROM_WP SDOUT0

R8950

4.7k PEAKS-EEP_SCL

PEAKS-EEP_SDA

TO 3/19

TO 1/19

13.11. A-Board (6/19) Schematic Diagram

!

A-BOARD (6/19)

STB_MPU

PANEL-D

Peaks-COMMON

R1562

47k

R1563

47k

Analog-ASIC

Peaks-COMMON

R1505

S

TO 3,7/19

STMCECO

SG-HDMI_CEC

SG-HDMI_5V_DET0

STMGPIO9

SG-HDMI_5V_DET1

STMGPIO7

SG-HDMI_5V_DET2

STMGPIO8

SG-HPD0

STMHPD0

SG-HPD1

STMHPD1

SG-HPD2

STMHPD2

STMDDCSDA0

SG-DDCSDA0

STMDDCSCL0

SG-DDCSCL0

STMDDCSDA1

SG-DDCSDA1

SG-DDCSCL1

STMDDCSCL1

SG-DDCSDA2

STMDDCSDA2

SG-DDCSCL2

STMDDCSCL2

PG-SOUND_SOS

EA8

PG-SIF_FIL_ON

EA9

PG-PD4H_NCS / SD_LED_ON

EA10

PG-MAIN_FAN_ON/SP_LED_ON

PORT0

PG-FAN_MAX/SP_LED_DIM

LOSDOUT0

USB_VBUS

LOSDOUT1

PG-AVDD_ENB

SD_PWR_ON

AGCI

PG-FAN_SOS

EA11

SG-PD4H_PANEL_MAIN_ON/PANEL_VCC_ON

P_ON/OFF

P5V_DET

TO 14/19

SG-PD4H_DRVRST/PWM_POW_ON

SG-P15V_DET

STMSBI1

SG-P3.3V_DET

P3.3V_DET

SG-SUB3.3V_SENSE

STMGPIO0

SG-SW_OFF_DET

STMGPIO1

SG-SUB5V/SUB12V_SENSE

STMGPIO2

PG-FILM_DET

TO 14/19

SG-TV_SUB_ON

STMGPIO5

TO 3,12/19

SG-PANEL_SOS/BL_SOS

STMADIN4

TO 3/19

PG-ACTIVE_ANTENNA_ON

CH1PSYNC

PG-ACTIVE_ANTENNA_DET

XIRQ3

SG-RF_AFT1

TO 9/19

STMSBT0

SG-PD4H_XRST_SYS/PANEL_TEST_ON

EA10

PG-PD4H_NCS / SD_LED_ON

EA25

PD4H_OSD_VIN

SG-PD4H_DRVRST/PWM_POW_ON

STMSBI1

TO 3,8/19

TO 3/19

TO 14/19

TO 3,12/19

D1101

B0JCCE000008

S

R1559

R1564

S

R1552

4.7k

R1503 47k

A-Chip_V

TO Standby-MPU

POWER/PANEL CTRL

TO 3,9,11,12,17/19

TO TUNER

TO 13/19

Reset Release

EA10

TO 3,16/19

TO 3/19

PORT1

STMADIN5

S

R1160

PG-FILM_DET

STMCECO

STMCECPUL

STMCECAVL1A

SG-HDMI_CEC

SG-HDMI_CEC_PU_ON

SG-QLINK1

STMCECO

STMCECPUL

TO 3/19

TO 3,7/19

TO 3,17/19

STMRMIN

SG-RMIN

PD4H_XRST/PANEL_AGW

LOSDOUT1

STMRMIN

XIRQ3

STMCECAVL1B

SG-QLINK2

PG-ACTIVE_ANTENNA_DET

PG-PD4H_NCS / SD_LED_ON

EA10

XIRQ3

STMCECAVL1B

STMCECAVL1A

TO 3/19

TO 3,10/19

TO 3/19

TO 3,12/19

STMADIN4

STMGPIO0

LOSDOUT1

SG-PANEL_SOS/BL_SOS

SG-SUB3.3V_SENSE

STMADIN4

STMGPIO0

STMADIN2

SG-FACT

STMADIN2

TO 3/19

TO 3,12/19

STMGPIO2

STMGPIO1

SG-SW_OFF_DET

SG-SUB5V/SUB12V_SENSE

STMGPIO1

STMGPIO2

STMTIME3

STMTIME2

STMTIME1

STMADIN3

(SG-PD4H_DRVRST/PWM_POW_ON)

(SG-P5V_DET/BL_ON)

(SG-PANEL_VCC_ON)

SG-GENX-KEY1

SG-TRCD3

SG-TRCD2

SG-TRCD1

STMTIME2

STMTIME1

STMTIME3

STMADIN3

TO 3/19

TO 3,9,11,12,17/19

TO 3/19

STMSBO1

EA9

STMSBI1

S

R1176

SG-PD4H_PANEL_MAIN_ON/SBI

SG-P3.3V_DET/SBO

PG-SIF_FIL_ON

EA9

P3.3V_DET

STMSBI1

STMTIME0

STMADIN1

(SG-RF_AFT1)

(SG-G_LED_ON)

SG-TRCD0

SG-TRCST

STMTIME0

STMADIN1

TO 3/19

TO 3,12/19

TO 3/19

TO 3,8/19

ADCCK

EA8

PG-SOUND_SOS

PG-AVDD_ENB

EA8

ADCCK

STMADIN0

STMEXTRG

(SG-AI_SENSOR)

SG-TRCCLK

SG-EXTRG0

STMEXTRG

STMADIN0

TO 3/19

SCLOCK

CH1PSYNC

XRSTSTM

LOSDOUT0

STMGPIO6

STMSBI0

STMSBO0

STMGPIO5

STMGPIO4

TO 13/19

OSD_VIN

TO 13,17/19

PANEL_MAIN_ON

R1187

STMCECPUL

SG-HDMI_CEC_PU_ON

STMCECO

SG-HDMI_CEC

STMGPIO9

AGCI

EA11

STMGPIO7

STMGPIO8

STMHPD0

STMHPD1

STMHPD2

STMDDCSDA0

STMDDCSCL0

STMDDCSDA1

STMDDCSCL1

STMDDCSDA2

STMDDCSCL2

EA8

EA9

EA10

PORT0

LOSDOUT0

LOSDOUT1

ADCCK

AGCI

EA11

P_ON/OFF

P5V_DET

SG-PD4H_DRVRST/PWM_POW_ON

STMSBI1

P3.3V_DET

STMGPIO0

STMGPIO1

STMGPIO2

PG-FILM_DET

STMGPIO5

STMADIN4

CH1PSYNC

XIRQ3

SG-RF_AFT1

SDATA

PORT0

AGCI

EA11

SG-SDATA

SG-SCLOCK

PG-ACTIVE_ANTENNA_ON

SG-NRST

PG-MAIN_FAN_ON/SP_LED_ON

PG-FAN_SOS

PG-FAN_MAX/SP_LED_DIM

SG-DTV_XRST

SG-MON_MUTE

SG-SP_HP_MUTE

SG-TV_SUB_ON

SG-GENX-EEP_WP

C1101

0.01u

SDATA

SCLOCK

CH1PSYNC

XRSTSTM

25V

PORT0

LOSDOUT0

STMGPIO6

STMSBI0

STMSBO0

STMGPIO5

STMGPIO4

27k

SG-HDMI_5V_DET0

SG-HDMI_5V_DET1

SG-HDMI_5V_DET2

SG-HPD0

SG-HPD1

SG-HPD2

SG-DDCSDA0

SG-DDCSCL0

SG-DDCSDA1

SG-DDCSCL1

SG-DDCSDA2

SG-DDCSCL2

PG-SOUND_SOS

PG-SIF_FIL_ON

PG-PD4H_NCS / SD_LED_ON

PG-MAIN_FAN_ON/SP_LED_ON

PG-FAN_MAX/SP_LED_DIM

PG-AVDD_ENB

PG-ACTIVE_STBY_LED_ON

PG-FAN_SOS

SG-PD4H_PANEL_MAIN_ON/SBI

SG-P3.3V_DET/SBO

SG-SUB3.3V_SENSE

SG-SW_OFF_DET

SG-SUB5V/SUB12V_SENSE

SG-TV_SUB_ON

SG-PANEL_SOS/BL_SOS

PG-ACTIVE_ANTENNA_ON

SD_COIN_DET

SDOUT3

STB3.3V

R1104

R1101

47k

S

R1103

S

R1201

S

R1202

R1105

S

R1203

R1106

S

R1204

R1107

S

R1205

R1108

S

R1206

R1109

S

STB3.3V

R1186

47k

R1185

100

GenX

STB3.3V

C1102

TP1101

1

NC

2

NC

3

NC

4

VSS

*IC1100

0.1u

TVRR538

EEPROM

16V

R1183

8

4.7k

VCC

TP1100

IIC

R1207

STM-EEP_SCL

STM-EEP_SDA

S

TO 1/19

7

WC

6

SCL

5

SDA

SG-AI_SENSOR

SG-G_LED_ON

SG-PD4H_DRVRST/PWM_POW_ON

SG-RF_AFT1

SG-FACT

FACT_SDBOOT

TO 17/19

SG-GENX-EEP_WP

STMEXTRG

STMADIN0

STMTIME0

STMTIME1

P_ON/OFF

STMTIME2

STMTIME3

STMADIN1

STMADIN2

STMGPIO4

SG-EXTRG0

SG-TRCCLK

SG-TRCD0

SG-TRCD1

PANEL_VCC_ON

SG-TRCD2

SG-TRCD3

SG-TRCST

STMHPD0

STMHPD1

STMHPD2

STMTIME4

STMGPIO9

SRCK0

SLRCK

STMDDCSDA0

STMDDCSCL0

STMDDCSDA1

STMDDCSCL1

STMGPIO7

STMDDCSDA2

STMDDCSCL2

STMGPIO8

SG-HPD0

SG-HPD1

SG-HPD2

SG-R_LED_ON

SG-HDMI_5V_DET0

PG-PANEL_LED_ON

PG-LCD_EEP_WP

SG-DDCSDA0

SG-DDCSCL0

SG-DDCSDA1

SG-DDCSCL1

SG-HDMI_5V_DET1

SG-DDCSDA2

SG-DDCSCL2

STMHPD0

STMHPD1

STMHPD2

STMTIME4

STMGPIO9

SRCK0

SLRCK

STMDDCSDA0

STMDDCSCL0

STMDDCSDA1

STMDDCSCL1

STMGPIO7

STMDDCSDA2

STMDDCSCL2

TO 3,7/19

STMGPIO8

TO 3,7/19

TO 3,17/19

TO 3,7/19 TO 3/19 TO 3/19

TO 3,7/19

TO 3,17/19

STMGPIO3

SG-SRQ_GENX

STMGPIO3

PG-REV_DAC_ENB

SDOUT3

TO 3/19

STMSBT0

SG-SOS

SG-PD4H_XRST_SYS/PANEL_TEST_ON

STMSBT0

STMADIN5

TO 3/19

TO 12/19

ReleaseReset

TO 3/19

SG-PD4H_PANEL_MAIN_ON/SBI

TO 3/19

TO 13/19

TO 12/19

TO 3/19

STMCECAVL1A

STMCECAVL1B

SDOUT3

PG-REV_DAC_ENB

STMSBT0

SG-PD4H_XRST_SYS/PANEL_TEST_ON

STMADIN3

STMRMIN

STMTIME4

SG-G_LED_ON

SLRCK

PG-LCD_EEP_WP

SRCK0

PG-PANEL_LED_ON

SG-AI_SENSOR

XRSTSTM

STMADIN5

STMGPIO6

STMSBO0

STMSBI0

STMGPIO3

SOS

SG-SUB5V/ SUB12V_SENSE

STMGPIO2XRST_SYS

TO 3/19

SG-SUB3.3V_SENSE

STMGPIO0

TO 3/19

SG-QLINK1

SG-QLINK2

SG-GENX-KEY1

SG-RMIN

SG-R_LED_ON

SG-NRST

SG-SOS

SG-DTV_XRST

SG-SP_HP_MUTE

SG-MON_MUTE

SG-SRQ_GENX

STB3.3V

C1100

0.01u 25V

STB3.3V

SUB5V

R1519

47k

R1518

68k

SUB3.3V

R1520

10k

R1521

100k

AVSW

TO 3,10/19

STMCECAVL1A

SG-QLINK1

STMCECAVL1B

SG-QLINK2

ADV_A

TO 3/19

PG-REV_DAC_ENB

SDOUT3

ACHIP_A

TO 3/19

STMSBT0

SG-PD4H_XRST_SYS/PANEL_TEST_ON

R1179

TO Sheet Set

7.15k

1%

R1180

1k

TO STB-RESET

R1177

S

STB-RESET

R1181

Set

47k

TO 3,17/19

KEY_SCAN

STMRMIN

STMTIME4

SG-G_LED_ONADCCK

SLRCK

SRCK0

SG-AI_SENSOR

STB_RST

STMADIN5 SG-SOS

STMGPIO6

STMSBO0

STMSBI0

STMGPIO3

SG-KEY1

SG-RMIN

SG-R_LED_ON

TO 17/19

PG-LCD_EEP_WP

PG-SD_LED_ON

TO 12/19

TO 3,16/19

TO 3,12/19

SG-SP_HP_MUTE

SG-MON_MUTE

SG-SRQ_GENX

TO 3,17/19

TO 17/19

SG-DTV_XRST

TO 17/19

TO 3,17/19

TO 3/19 TO 3/19

55

534846 5447 49 525150

13.12. A-Board (7/19) Schematic Diagram

JK4700

K1FY119D0011

HDMI1

19

HPDT

+5V

17

DDCG

SDA

15

SCL

N.C.

13

CEC

CLK-

CLKG

11

CLK+

9

D0-

D0G

7

D0+

D1-

5

D1G

D1+

3

D2-

D2G

1

D2+

JK4701

K1FY119D0011

HDMI2

HPDT

19

+5V

DDCG

17

SDA

SCL

15

N.C.

CEC

13

CLK-

CLKG

11

CLK+

D0-

9

D0G

D0+

7

D1-

D1G

5

D1+

D2-

3

D2G

D2+

1

SUB3.3V

S

HDMI

SG-HPD2 STMHPD2

SG-HDMI_5V_DET2

STMGPIO8

R4752

68

R4753

68

R4754

68

R4755

68

C4546

6.3V 1u

TO 3,10/19

R4548

22

IECIN

TO 3/19

IECOUT

HDMI_DDCSDA2

HDMI_DDCSCL2

RXCM2

RXCP2

RX2M0

RX2P0

RX2M1

RX2P1

RX2M2

RX2P2

HDMI_DDCSDA0

HDMI_DDCSCL0

RXCM0

RXCP0

RX0M0

RX0P0

RX0M1

RX0P1

RX0M2

RX0P2

SG-HDMI_5V_DET0

HDMI_CEC

SG-HPD0 STMHPD0

STMGPIO9

HDMI_CEC

STB5V

*R4766

*R4767

47k

HDMI_DDCSDA1

HDMI_DDCSCL1

HDMI_CEC

STMGPIO8

STMHPD2

STMGPIO9

STMHPD0

STMGPIO7

STMHPD1

R4739

22

RXCM2

RXCP2

RX2M0

RX2P0

RX2M1

RX2P1

RX2M2

RX2P2

HDMI_DDCSDA2

HDMI_DDCSCL2

SG-HDMI_5V_DET2

SG-HPD2

HDMI_DDCSDA2

HDMI_DDCSCL2

RXCM0

RXCP0

RX0M0

RX0P0

RX0M1

RX0P1

RX0M2

RX0P2

HDMI_DDCSDA0

HDMI_DDCSCL0

SG-HDMI_5V_DET0

SG-HPD0

HDMI_DDCSDA0

HDMI_DDCSCL0

SG-HDMI_5V_DET1

SG-HPD1

Standby-MPU

Peaks-COMMON!TO 2/19

R4746

S

R4747

R4740

S

R4741

Peaks-COMMON

R4748

S

R4749

Standby-MPU

S

R4742

S

R4743

S

R4744

S

R4745

STMCECO

HDMI1

RXCM2

RXCP2

RX2M0

RX2P0

RX2M1

RX2P1

RX2M2

RX2P2

DDCSDA2

DDCSCL2

Standby-MPU

STMGPIO8

STMHPD2

STMDDCSDA2

STMDDCSCL2

HDMI2

RXCM0

RXCP0

RX0M0

RX0P0

RX0M1

RX0P1

RX0M2

RX0P2

DDCSDA0

DDCSCL0

STMGPIO9

STMHPD0

STMDDCSDA0

STMDDCSCL0

Standby-MPU

STMGPIO7

STMHPD1

STMDDCSDA1

STMDDCSCL1

SG-HDMI_CEC

SG-HDMI_5V_DET2

SG-HPD2

SG-DDCSDA2

SG-DDCSCL2

SG-HDMI_5V_DET0

SG-HPD0

SG-DDCSDA0

SG-DDCSCL0

SG-HDMI_5V_DET1

SG-HPD1

SG-DDCSDA1

SG-DDCSCL1

TO 3,6/19

TO 2/19

TO 3,6/19

sLD-STMCECO

TO 3,6/19

sLD-STMDDCSDA2

sLD-STMDDCSCL2

TO 3,6/19

sLD-STMGPI09

sLD-STMHPD0

sLD-STMDDCSDA0

sLD-STMDDCSCL0

HDMI3: HPD1/DDC1/DET1

sLD-STMGPI08

sLD-STMHPD2

HDMI1: HPD2/DDC2/DET2

HDMI2: HPD0/DDC0/DET0

AVSW

TO 11/19

AVSW_R027PIN_FBOUT/TDET10

PC_HIN

PC_VIN

RGB_CVBS

MAIN_Y/CVBS

MAIN_PB/C

MAIN_PR

RGB_FB

AVSW_R027PIN_FBOUT/TDET10

PC_VS

R4651

22

R4655

YIN

22

R4659

PB/C

22

R4663

22

HIN

VIN

AVSW_R027PIN_FBOUT/TDET10

R4676

1k

C4660

6.3V 1u

RGB_CVBS

R4666

C4661

33

6.3V 1u

C4662

6.3V 1u

R4668

C4663

33

6.3V 1u

C4664

6.3V 1u

R4670

C4665

33

6.3V 1u

C4666

6.3V

PR

1u

R4672

C4667

33

6.3V 1u

Peaks-Common

PC_HS

PC_VSPC_HS

R4677

1.2k

V1

V1N

G1

G1N

TO 2/19

B1

B1N

R1

R1N

TO 2/19

HIN

VIN

FBL1

A-BOARD (7/19)

R4706

S

47k

R4704

Q4700

DSC200100L

R4702

R4703

33

10k

C4701

16V

0.1u

R4711

18

16

J0JYC0000068

14

12

10

8

6

4

2

R4715

10k

C4704

16V

0.1u

R4724

18

16

14

12

10

8

6

4

2

C4702

R4708

16V

0.1u

D4702

B0ACCJ000048

1k

L4700

J0JYC0000068

L4701

L4702

J0JYC0000068

Q4702

DSC200100L

R4716

33

R4721

C4705

16V

0.1u

D4719

B0ACCJ000048

1k

C4547

6.3V 1u

R4553

10k

FOR HDMI1.4 ARC (only HDMI2)

R4705

S

10k

47k

R4717

R4718

S

10k

L4703

J0JYC0000068

L4705

J0JYC0000068

R4552

56

R4551

150

R4709

10k

STB5V

D4704 B0JCCE000008

R4763

R4712

100k

47k

R4719

S

R4722

10k

STB5V

D4721 B0JCCE000008

R4725

R4764

47k

100k

L4704

J0JYC0000068

Q4512

B1HFCFA00026

R4560

47k

R4549

150

R4550

150

Q4513

DSA200100L

R4554

1k

SUB3.3V

R4556

10k

R4555

56

6057 6356 6259 615855

13.13. A-Board (8/19) Schematic Diagram

!

A-BOARD (8/19)

TUNER

AVSW

TO 11/19

TO 9/19

SIF

LO1_L_AVSW

LO1_R_AVSW

LO2_L_AVSW

LO2_R_AVSW

AUDIO AMP

SUB5V

R2101

3.3k

R2102

4.7k

AV_L

AV_R

R2121

R2103

22

C2110

16V

0.1u R2104

1.2k

R2135

680

Q2109

DSA200100L

R2110

22

<< Monitor L

<< Monitor R

<< TV L

<< TV R

1k

R2139

220

Q2101

DSA200100L

C2055

10V

10u

C2057

10V

10u

C2107

10V

1u

R2107

S

C2104

50V

C2108

10p

10V

1u

R2053 140k

R2055 140k

Peaks-COMMON

SIFINP

TO 2/19

SIFINN

LIN5_LP

TO 2/19

LIN5_RP

MON_L-OUT

LO1_L

MON_R-OUT

LO1_R

TV_L-OUT

LO2_L

TV_R-OUT

LO2_R

TO 3/19

TO 2/19

TO 3/19

TO 3,6/19

OPERATE

MUTEB

NSHUTDOWN

PWM0LN

PWM0LP

PWM1RN

PWM1RP

TP2008

R2308

220

R2301

10k

R2302

EXB28V220JX

To SOS

C2301

R2307

16V

4.7k

0.1u

SUB3.3V

EA8

SOS

RESET

MUTE

Q2301

DSA200100L

R2309

2.2k

C2302

16V

0.1u

OPERATE

PWM_READY

SUB3.3V

R2310

2.2k

D2014

B0ACCJ000048

C2357

C2312

25V

IC2301

C1AB00003230

R2330

0

R2331

R2304

0

47k

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

AUDIO AMP

STBY

MUTE

SOS

NC1

NC2

NC3

NC4

PWM_A1

PWM_B1

NC5

NC6

NC7

GND

PWM_B2

PWM_A2

NC8

NC9

NC10

NC11

NC12

NC13

NC14

PVD1

OUT_CH1_P

BOOT_CH1_P

VDDA1

BOOT_CH1_N

OUT_CH1_N

Thermal Pad

OUT_CH1_N

PGND1

PGND2

OUT_CH2_N

BOOT_CH2_N

VDDA2

BOOT_CH2_P

OUT_CH2_P

PVD2

10u

C2356

25V 10u

C2313

C2314

50V

25V

1000p

44

43

42

41

40

39

38

37

36

35

34

33

32

31

30

29

28

27

26

25

24

23

1u

C2316

50V

0.1u

C2317

C2318

25V

50V

1u

0.1u

C2321

50V

0.1u

C2320

C2323

25V

50V

1u

0.1u

C2324

C2325

25V

50V

1u

1000p

G1C3R0ZA0156

C2309

25V 10u

L2301

10u

J0JHC0000042

L2303

G1C220MA0416

L2304

G1C220MA0416

L2305

G1C220MA0416

L2306

G1C220MA0416

S_15V

L2302

C2304

25V

1u

R2318

3.3

C2340

C2335

50V

25V

0.022u

0.1u

C2334

0.47u

C2337

0.47u

C2341

50V

0.022u

C2342

C2349

50V

1000p

0.022u

C2343

C2336

50V

25V

0.022u

0.1u R2319

3.3

C2353

R2320

50V

3.3 1000p

C2344

C2338

0.022u

25V

0.1u C2345

0.022u

C2339

25V

0.1u

C2351

50V

1000p

C2355

50V

1000p

C2346

50V

0.022u

C2347

50V

0.022u

R2321

3.3

TP2301

TP2302

TP2303

TP2304

A11

1

2

3

4

TO SPEAKER

L+

L-

R+

R-

TO 10/19

HP_LOUT

HP_ROUT

Q2253

B1AAFB000002

Q2254

B1AAFB000002

C2071

6.3V +

100u

<< MainHP L

<< MainHP R

C2074

R2069

R2070

10k

R2258

R2259

C2073

25V

0.033u

100

Q2252

DSA200100L

100

R2256

R2257

1M

R2255

10k

R2065

S

+

R2066

S

C2072

6.3V

100u

AVDD3.3V

R2260

R2254

47k

10k

R2263

100

10k

Q2255

DSC2001S0L

HP1_L1

TO 2/19

HP1_R1

NORMAL

MUTE

NORMAL

TO 2/19

MUTE

A_MUTE

R2264

100

Analog-ASIC

OPERATE

MUTE

AMP_MUTE

TO 12/19

HP_MUTE_CTL

TO 12/19

6965 71 7266 6864 7067

57

13.14. A-Board (9/19) Schematic Diagram

!

A-BOARD (9/19)

IIC_From_Demod

TO 1,19/19

D-TNR_SCL FE-OUT_SCL

FE-OUT_SDA D-TNR_SDA

TNR5V

+

L2901

J0JCC0000278

L2900

J0JCC0000278

TUNER,TERMINAL

!

TU2901A

ENG37F03KF

TUNER

+B_active_antenna

C2907

C2905

16V

10V

0.1u

100u

C2910

16V

0.1u

C2908

16V

0.1u

Demod

RF-AGC_Monitor

BT_Monitor

IF_Monitor

TO 19/19

IFAGC

IFD1

IFD2

Audio-out

Video-out

IFD-out1

IFD-out2

1

BB

2

3

NC

5

6

8

SIF-out

9

VB1

10

11

SCL

13

SDA

14

VB2

15

IF_AGC

16

RESET

17

19

20

21

L2906

J0JCC0000278

R2907

R2926

68

C2911

16V

0.1u

L2903

J0JCC0000278

L2904

J0JCC0000278

L2905

J0JHC0000046

R2918

S

ACT5V

C2917

50V

2200p

ADV

AM

TO 11/19

SIF

AVSW

TO 11/19

MAIN_RF_CVBS

TO 4,19/19

AA_FE_RST FE_XRST / SDRAM_CHK

TO 8/19

S

R2915

FE1.2V

0

TNR3.3V

IFAGC

IFD1

IFD2

GENX

TO 6/19

SG-RF_AFT1

R2914

10k

IFAGC

IFD1

IFD2

*JK3302A

K1FY121A0010

AV1

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

GND(PLUG)

VIDEO IN

VIDEO OUT

GND(VIDEO IN)

GND(VIDEO)

FB IN

Chroma/RED in

GND(FB)

GND(RED/C)

GREEN IN

Q-LINK

GND(GREEN)

AV2 SLOW

BLUE IN

L IN

GND(BLUE)

GND(AUDIO)

TV L OUT

R IN

TV R OUT

E_AV2_VIN(20P)/A_AV3_V__TERMINAL

E_AV2_VOUT(19P)_TERMINAL

E_AV2_FB(16P)_TERMINAL

E_AV2_RED/C(15PIN)_TERMINAL

E_AV2_GREEN(11P)/A_AV2C_Y__TERMINAL

E_AV2_Q-LINK(10P)_TERMINAL SIDE_HP_L_TERMINAL

E_AV2_SLOW(_8P)_TERMINAL

E_AV2_BLUE(_7PIN)_TERMINAL SIDE_HP_GND

E_AV2_LIN(_6PIN)/A_AV3_L__TERMINAL

E_AV2_GND(AUDIO)(_4P)_TERMINAL

E_AV2_LOUT(_3PIN)_TERMINAL

E_AV2_RIN(_2PIN)/A_AV3_R__TERMINAL

E_AV2_ROUT(_1PIN)_TERMINAL

TO 10/19

D3300

K7AAAY000006

OPTICAL

AUDIO

OUT

HEADPHONE

VCC

Vin

DRIVE IC

GND

*JK3107A

K4AK04B00002

SUB3.3V

SPDIF

TO 10/19

OPT_SPDIF_TERMINAL

SIDE_HP_R_TERMINAL

TO 10/19

TUNER1.2V

FE1.2V

TUNER3.3V

TO 3,6,11,12,17/19

SG-TV_SUB_ON STMGPIO5

C0DBFYY00049

1

C2951

6.3V

4.7u 2

3

IC2950

C0CBCAG00031

TUNER1.2V

IC2953

TUNER3.3V

VOUT

VSS

ON/OFF

TNR3.3V

TUNER5V

Y

IC2952

C2959

16V

0.1u

SG-TV_SUB_ON

C2961

10V

1u

C0DBGYY00281

TUNER5V

4

VIN

CE

3

SUB5.6V

AV3.3V

P

R2966

TNR5V

P

5

R2959

VOUT

VSS

1NC2

Y

PB

PR

V

L

R

*JK3100C

K2HA608A0008

PB

PR

G

V

L

R

G

E_YPBPR_Y/A_AV1C_Y__TERMINAL

E_YPBPR_PB/A_AV1C_PB__TERMINAL

E_YPBPR_PR/A_AV1C_PR__TERMINAL

A_AV1_V__TERMINAL

E_PC_LIN/A_AV1_LIN__TERMINAL

E_PC_RIN/A_AV1_RIN__TERMINAL

TO 10/19

YPBPR

V IN

AUDIO IN

SUB3.3V

L2950

J0JHC0000045

6

VIN

C2950

6.3V

4.7u

5

VSS

4

NC

SUB5.6V

C2965

10V

1u

1

2

3

VIN

CE

VSS

VOUT

NC

TP2952

5

4

C2966

10V

2.2u

75 78 8074 77 7973 76 81

58

13.15. A-Board (10/19) Schematic Diagram

!

A-BOARD (10/19)

VIDEO IN

E_AV1_Vi/Yi

E_AV2_VIN(20P)/A_AV3_V__TERMINAL

E_AV1 RGB/C

E_AV2_RED/C(15PIN)_TERMINAL

E_AV2_GREEN(11P)/A_AV2C_Y__TERMINAL

TO 9/19 TO 9/19TO 11/19 TO 11/19

E_AV2_BLUE(_7PIN)_TERMINAL

E_YPbPr

E_YPBPR_Y/A_AV1C_Y__TERMINAL

E_YPBPR_PB/A_AV1C_PB__TERMINAL

E_YPBPR_PR/A_AV1C_PR__TERMINAL

E_AV2(RCA)

A_AV1_V__TERMINAL

R3134

R3135

R3136

*R3222

150

L3108

J0JCC0000287

R3146

150

R3147

150

JS3114

R3141

150

R3181

R3182

R3183

*L3121

J0JCC0000287

*R3221

150

JS3113

R3142

150

JS3108

R3143

150

JS3103

75

JS3101

75

JS3112

75

VIDEO AUDIO I/O

S

EXB28V221JX

R3150 220

R3151

220

R3153

220

R3157

R3192

EXB28V820JX

R3173

R3120

EXB28V221JX

*R3148

0

AUDIO OUT

C3145

10u

10V

C3146

10u

10V

C3147

10V 10u

C3148

10V 10u

C3151

10V

1u

C3152 1u

10V

C3157

10V

1u

C3158

10V

1u

AVSW_R044PIN_CVBS/Y+COUT3

AVSW_R043PIN_SAGCVBSOUT3

R3177

EXB28V331JX

AVSW_R064PIN_L4IN

AVSW_R065PIN_R4IN

AVSW_R070PIN_L7IN

AVSW_R071PIN_R7IN

AVSW_R054PIN_L2OUT

AVSW_R053PIN_R2OUT

MONITOROUT_MUTE

TO 12/19

AUDIO IN

E_AV1

C3124

10V

10u

AVSW_R023PIN_CVBSIN2

C3125

10V 10u

AVSW_R019PIN_G1/YIN1

C3130

16V

0.1u AVSW_R021PIN_B1/CIN1

C3129

10V 10u

AVSW_R011PIN_R2/CIN3

C3131

10V 10u

AVSW_R013PIN_G2/YIN2

C3132

10V 10u

AVSW_R015PIN_B2/CIN2

C3163

10V

10u

AVSW_R095PIN_CYIN1

C3164

10V 10u

AVSW_R093PIN_PBIN1

C3165

10V 10u

AVSW_R097PIN_PRIN1

*R3014

220

AVSW_R007PIN_CVBS3

*C3026

10u 10V

E_AV2_LIN(_6PIN)/A_AV3_L__TERMINAL

E_AV2_GND(AUDIO)(_4P)_TERMINAL

E_AV2_RIN(_2PIN)/A_AV3_R__TERMINAL

PC/Audio IN(RCA AV2in)

E_PC_LIN/A_AV1_LIN__TERMINAL

E_PC_RIN/A_AV1_RIN__TERMINAL

E_AV1

E_AV2_LOUT(_3PIN)_TERMINAL

E_AV2_ROUT(_1PIN)_TERMINAL

E_AV2_GND(AUDIO)(_4P)_TERMINAL

L3113 J0JYC0000331

L3125

J0JYC0000331

L IN

L3117

J0JYC0000331

R IN

L3118

J0JYC0000331

L3111

J0JYC0000331

L3112

J0JYC0000331

R3167

C3139

50V

33k

560p

R3168

C3140

50V

33k

560p

L3116

R3186

C3155

560p

33k

50V

R3187

C3156

33k

560p 50V

Q3102

DSC200100L

R3163

100k

C3135

50V 560p

C3136

50V

560p

R3171

2.2k

R3172

2.2k

R3164

100k

Q3103

DSC200100L

E_AUDIO OUT

STB5V

E_AV1

E_AV2_Q-LINK(10P)_TERMINAL STMCECAVL1B

TO 9/19

E_AV1 FB/SLOW-SW

E_AV2_FB(16P)_TERMINAL

E_AV2_SLOW(_8P)_TERMINAL

OPT

OPT_SPDIF_TERMINAL

Q-LINK

TP3103

R3198

68

D3124

DZ2J140M0L

TP3100

*R3205

0

R3200

150

S

R3202

JS3100

150

TP3101

R3204

21.5k

R3206

13k

B0ACCJ000048

R3212

68

R3208

D3130

STMCECAVL1A

QLINK_AV2

AVSW_R014PIN_S2DET2

AVSW_R078PIN_FBIN2/O2

TO 3,6/19

SG-QLINK2

*R3213

27k

47k

R3211

22

Standby-MPU

TO 11/19

AVSW_R020PIN_S2DET1

R3108

100

Peaks-COMMON

IECOUT

TO 3,7/19

E_AV1_Vo

E_AV2_VOUT(19P)_TERMINAL

JS3105

S

R3137

75

R3129

100k

+

C3120

10V 100u

C3121

10V

+

100u

E_AV2_VOUT

AVSW_R038PIN_Y/Y+C/CVBSOUT4

AVSW_R037PIN_SAGCVBSOUT4

HP

SIDE_HP_L_TERMINAL

SIDE_HP_R_TERMINAL

SIDE_HP_GND

L3102

J0JYC0000331

C3108

0.033u

L3103

J0JYC0000331

C3109

0.033u

R3126

S

R3302

25V

S

HP_LOUT

TO 8/19

S

R3300

25V

HP_ROUT

83 908584 86 888782 89

59

13.16. A-Board (11/19) Schematic Diagram

!

A-BOARD (11/19)

R3019

SUB9V

PPP

R3001

R3002

C0DBGYY00281

C3031

10V

1u

C3003

16V

0.1u

IC3001

+5V

5

VOUT4VIN

1NC2

TO 10/19

AV SW

R3004

220

SUB5.6V

C3032

10V

CE

3

1u

SG-TV_SUB_ON STMGPIO5

TO 3,6,9,12,17/19

AV1_FB

AVSW_R078PIN_FBIN2/O2

YPbPr-IN

AVSW_R093PIN_PBIN1

AVSW_R095PIN_CYIN1

AVSW_R097PIN_PRIN1

SUB3.3V

R3000

S

VSS

C3004

TO 10/19

AVSW_R070PIN_L7IN

AVSW_R071PIN_R7IN

PC/A-IN

0.1u

16V

100

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95

96

97

98

C3013

10V

1u

66

67

68

69

70

71

72

73

74

75

CVBSin6

VCC9V

CVBSin5

T_DET9

Yin4

T_DET8

Cin4

VCC5V

PBin2/B3

L3_DET2

CYin2/G3

T_DET7

PRin2/R3

T_DET6

PBin1

L3_DET1

CYin1

HD_VD/FBKMUTE

PRin1

1

2

3

L5in

L6in

L7in

L8in

R5in

R6in

R7in

R8in

L9in

R9in

CVBSin7

FBin1/O1

FBin2/O2

IC3000

C1AB00003218

GND99Bin

VDin

Gin

HDin

Rin

T_DET55CVBSin46T_DET47CVBSin38BG9Yin310S2_DET311R2/Cin312GND13G2/Yin214S2_DET215B2/Cin216T_DET317CVBSin118T_DET219G1/Yin120S2_DET121B1/Cin122T_DET1

4

C3011

10V

10u

C3014

10V

1u

65

AVSW

R3005

220

10u

C3015

10V

52

53

54

55

56

57

58

59

60

61

62

63

64

L2in

L3in

L4in

R1in

R2in

R3in

R4in

R2out

L3out

R3out

VCC5V

CVBSin2

L1in

AU1/2Vcc

R1

L2out

L10in/L1out

R10in/R1out

G/CY/Y/CVBSout7

CVBS/Y+Cout3

SAG_CVBSout3

R4out50L4out

AU_GND

C/Y+C/CVBSout5

SAG_CVBSout5

Y/Y+C/CVBSout4

SAG_CVBSout4

B/PB/Cout1

Rtate_out27T_DET10/Fbout28SDA

G/CY/CVBSout1

R/Prout1

VD_out1

HD_out1

23

51

49

48

47

O3

46

45

VCC9V

44

43

42

GND

41

40

39

S2out

38

37

36

VCC5V

35

34

33

32

31

30

GND

29

SCL

26

24

25

C3016

16V

0.1u

AV-SW_SCL

AV-SW_SDA

C3018

0.1u

16V

C3019

0.1u

16V

S

R3006

S

R3007

AV2 A-IN

AVSW_R065PIN_R4IN

AVSW_R064PIN_L4IN

AV1 A-IN

AV2 A-OUT

AVSW_R054PIN_L2OUT

AVSW_R053PIN_R2OUT

AUDIO OUT

AVSW_R044PIN_CVBS/Y+COUT3

AVSW_R043PIN_SAGCVBSOUT3

AV1 V-OUT

AVSW_R038PIN_Y/Y+C/CVBSOUT4

AVSW_R037PIN_SAGCVBSOUT4

PC_HS

PC_VS

TO 10/19

C3020

1u

10V

C3021

1u

10V

C3022

1u

10V

C3023

1u

10V

TO 10/19

RGB_CVBS

MAIN_PR

MAIN_PB/C

MAIN_Y/CVBS

R3008

R3009

R3010

R3011

AV_L

AV_R

VIN

HIN

SECAM-AM

AM

TO 9/19

S

TV OUT

LO2_R_AVSW

LO2_L_AVSW

AUDIO OUT

LO1_R_AVSW

LO1_L_AVSW

SP OUT

IIC

AV-SW_SCL

AV-SW_SDA

TO 8/19

AV_L

AV_R

TP3000

AVSW_R027PIN_FBOUT/TDET10

TP3001

TP3002

TP3003

TP3004

TP3005

TP3006

PC_HIN

PC_VIN

MAIN_Y/CVBS

MAIN_PB/C

MAIN_PR

RGB_CVBS

PC_HS

PC_VS

TO 7/19

TO 1/19

AVSW_R027PIN_FBOUT/TDET10

PC_HS

HIN

PC_VS

VIN

MAIN_Y/CVBS

MAIN_PB/C

MAIN_PR

RGB_CVBS

TO 10/19

E_AV2 V

AVSW_R007PIN_CVBS3

E_AV1 RGB/YC

AVSW_R011PIN_R2/CIN3

AVSW_R013PIN_G2/YIN2

AVSW_R015PIN_B2/CIN2

AVSW_R021PIN_B1/CIN1

AV1 V-IN

AVSW_R019PIN_G1/YIN1

AVSW_R023PIN_CVBSIN2

AVSW_R014PIN_S2DET2

E_AV1_SLOW

AVSW_R020PIN_S2DET1

R3003

100k

C3024

10V 10u

C3025

10V 10u

AVSW_R027PIN_FBOUT/TDET10

R3012

220

R3013

220

Peaks-COMMON

VDACO

TO 4/19

TUNER

TO 9/19

MAIN_RF_CVBS

9592 999896949391 97

60

13.17. A-Board (12/19) Schematic Diagram

A-BOARD (12/19)

!

ANALOG ASIC

Peaks-COMMON

GENX-DEST

POWER_DET

TO 3,6/19

SG-SW_OFF_DET

TO 17/19

STB_5V_SWON

SW_OFF_DET

TO 3/19

EA23

STMGPIO1

SUB3.3V

R5104

47k

R5110

100

R5105

S

SUB5V

R5100

27k

D5100 B0ADEJ000035

R5101

100k

R5106

68k

R5102

100k

R5103

68k

Q5101

DSC200100L

C5100

16V

0.1u

Q5100

DSC2001S0L

C5101

10V

0.47u

GENX-DEST

SG-DTV_XRST

Peaks-COMMON

TO 1,2,3/19

TO 2/19

TO 3,6/19

STMGPIO6

R5151

Peaks-RESET

100

R5154

47

R5153

100

XRST

NRST

R5155

100

TP5150

SUB3.3V

R5152

2.2k

AVSW-MODEL

MONITOROUT_MUTE

TO 10/19

Q5051

DSA200100L

1M

R5052

MUTE

C5050

10V

47k

4.7u

R5051

R5050

A-Chip_A

TO 8/19

HP_MUTE_CTL

Peaks-COMMON/GENX-DEST

SG-MON_MUTE

GENX-DEST

SG-PD4H_DRVRST/PWM_POW_ON

PANEL-D

TO 13,17/19

TO 3,6,9,11,17/19

TO 13/19

TO 6/19

STB_RST

SOS6_SC1

SOS7_SC2

SOS_DCC

SG-TV_SUB_ON STMGPIO5

SOS4_PS

SOS8_SS

SC_UHZ

STMSBI0

FC

17

PGND

18

DRV

19

DTV5VOUT

20

R5001

DTV5VIN

S

21

EN_DCDC

22

C5055 16V

0.1u

C5000

16V 0.1u

C5001

16V 0.1u

C5002

16V 0.1u

C5003

16V 0.1u

C5004

50V1000p

23

24

25

26

27

28

29

30

31

32

CD

STB_RST

DRVRST

STB5V_SW_ON

P_SOS4

SC_SOS6

SC_SOS7

SS_SOS8

D_SOS_RSV

SC_OHZ

TP5001

D_UHZ

PD4H_SOS

STB3.3V

R5005

47k

R5006

10k

R5007

47k

R5008

8.2k

Q5000

DSC200100L

D5000

B0ADCJ000100

MONITOR_MUTE

AUDIO_MUTE_IN

DRVRST_PD4

IC5000

C1ZBZ0004161

ANALOG ASIC

MUTE_VCC

SP_MUTE

STB3.3V

STB1.2V

PANEL_SOS

GND

16

FB

15

SUB9V

14

DTB9V

13

12

+

C5052

10V

11

220u

10

AMUTE

9

8

STB5V

7

6

5

4

P3.3V

TEST

3

P3.3V

2

R5000

S

UHZ

1

SUB3.3V

R5065

10k

L5000

J0JYC0000068

C5155

C5156

6.3V

10u

TP5000

C5159

C5158

C5157

6.3V

6.3V 10u

10u

STB3.3V

B0JCME000076

C5160

6.3V 10u

STB1.2V

SUB5V

STB5V

R5061

15

D5051

D5052 B0ACCJ000048

C5058

6.3V 1u

STMSBO0

A-Chip_A

Panel-D

GENX-DEST

STMADIN4

SG-PANEL_SOS/BL_SOS

AMP_MUTE

PDP_DRVRST

SG-SP_HP_MUTE

TO 8/19

TO 13/19

TO 3,6/19

103101 106105 107102100 104 108

61

13.18. A-Board (13/19) Schematic Diagram

A-BOARD (13/19)

!

DC-DC CONVERTER

SCNRST

SOS6_SC1

SOS7_SC2

P5V

SIU

SCCLK

GND

CERS

CRC2

GND

OC2

CRC1

OC1

GND

CPH1

CIS

GND

UHZ

GND

CEL

GND

CSH

GND

CSL

GND

CMH

CML

NC

+15V

TO SC-BOARD (SC20)

A20

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

P15V

C9812

25V 10u

R9920

39

C9816

C9815

22u

G1C100MA0416

22u

C9814

6.3V

G1C6R8Z00010

22u

6.3V

L9800

25V

0.01u

L9801

22u

D9804

C9066

6.3V

CTL2Vcc4OUT5ADJ

1

C9800

25V

0.1u

C9803

25V

4700p

P5V

P

R9899

S

R9111

P5V

C9101

C9100

25V

10V

SIDE

TERM

0.01u

10u

TP9081

TP9082

TP9083

TP9084

TP9085

TP9086

TP9087

TP9088

TP9089

TP9090

TP9091

TP9092

TP9093

TP9094

TP9095

R9208

EXB2HV470JV

R9198

EXB28V101JX

R9209

EXB2HV470JV

C9103

25V

0.01u

P_ON/OFF

SC_SIU

SC_SCCLK

SC_CERS

SC_CRC2

SC_OC2

SC_CRC1

SCNRST

SC_OC1

SOS6_SC1

SOS7_SC2

SC_UHZ

SC_CPH1

SC_CIS

SC_CEL

SC_CSH

SC_CSL

SC_CMH

SC_CML

P15V

C9102

25V 10u

SC_SIU

SC_SCCLK

SC_CERS

SC_CRC2

SC_OC2

SC_CRC1

SCNRST

SC_OC1

SC_CPH1

SC_CIS

SC_CEL

SC_CSH

SC_CSL

SC_CMH

SC_CML

P5V

C9400

16V

0.1u

P5V

C9401

16V

0.1u

Y8

11

Y7

12

Y6

13

Y5

14

Y4

15

Y3

16

Y2

17

IC9400

Y1

18

G2

19

Vcc

20

Y8

11

Y7

12

Y6

13

Y5

14

Y4

15

Y3

16

Y2

IC9401

17

Y1

18

0V

G2

19

Vcc

20

GND

10

A8

9

A7

8

A6

7

A5

6

A4

5

BUFFERBUFFER

A3

4

C0JBAZ002692

A2

3

A1

2

G1

1

GND

10

A8

9

A7

8

A6

7

A5

6

A4

5

A3

4

C0JBAZ002692

A2

3

A1

2

G1

1

0V

R9400

EXB2HV103JV

0V

R9401

PD_SIU

PD_SCCLK

PD_CERS

PD_CRC2

PD_OC2

PD_CRC1

PD_SCNRST

PD_OC1

PD_CPH1

PD_CIS

PD_CEL

PD_CSH

PD_CSL

PD_CMH

PD_CML

EXB2HV103JV

P1.2V

C9825

6.3V

C9813

25V 10u

DC-DC CONVERTER

1

2

3

4

C9067

50V

560p

R9016

B0JCPG000030

2.2

3

(FIN)

GND(FIN)

C9817

10V

10u

IC9800

C0DBAYY00605

DC-DC CONVERTER

15V->1.2V

1

PGND

2

PGND

3

PGND

4

SW

5

SW

6

SW

7

BOOT

8

NC

9

SS/DELAY

10

GND

IC9801

C0DBAYY00462

15V->5V

BOOT

VIN

SW

GND

IC9802

C0DBEHG00006

P3.3V

110k

R9890

32.4k

R9891

VIN

NC

EN

PSET

RT

FC

FB

20

19

18

17

16

15

14

13

12

11

COMP

P+3.3V

C9819

10V 10u

C9806

50V

R9873

10k

TO 6,17/19

TO 6/19

C9811

16V

0.1u

8

SS

7

EN

R9879

15k

6

C9809

50V

1000p

5

FB

R9878

R9014

R9877

10k

5.6k

47k

P15V

C9804

C9805

25V

10u

C9116

16V

C9807

50V

200p

R9874

27k

R9872

C9801

3.3k 25V

6800p

100p

R9875

20k

0.1u

P_ON/OFF

PANEL_MAIN_ON

P3V_SDA02

TO 1/19

P3V_SCL02

100

R9103

TO 17/19

AR_STB_SCL02

AR_STB_SDA02

TP9201

TO 6/19

TO 3/19

XRST_SYS

CH1VAL

S

TP9202

100

R9104

R4010

R4011

DRVMUTE

R9105

47k

TO 12/19

TO 6/19

OSD_VIN

PDP_DRVRST

TO 3/19

47k

OSD_VIN

R9110

S

3.3k

R9107

DRVRST

D_XRST_SYS

TE1P

TCLK1P

TD1N

TD1P

TE1N

TD1N

TD1P

TE1N

TCLK1P

TCLK1N

TC1N

TC1P

TC1N

TC1P

TA1N

TA1P

TB1P

TB1N

TA1N

TA1P

TB1N

TB1P

R9040

D9807 B0ADCJ000100

4.7k

OHZ1

TO 6,17/19

TO 12,17/19

TO 17/19

PANEL_MAIN_ON

SOS4_PS

TP9104

TP9102

TP9101

TP9103

P_S0

P_S1

PANEL_MAIN_ON

SOS4_PS

Analog ASIC

SOS6_SC1

SOS4_PS

SOS_DCC

SOS7_SC2

SOS8_SS

SC_UHZ

SOS_DCC

TO 12/19

SOS4_PS

TO 12,17/19

SOS6_SC1

SOS7_SC2

TO 12/19

SOS8_SS

SC_UHZ

TO 12/19

D_UHZ

TO 12/19

D_UHZ

R9039

47k

109 114 115113112 116111110 117

62

1

2

13.19. A-Board (14/19) Schematic Diagram

A-BOARD (14/19)

!

PD4

D-PCD1

1M

R9321

D-PCD2

IC9300 V30 XI

C9301

C9302

X9300

H0J200500076

1.5k

R9320

IC9300 W30 XO

IC9300 B21 RXEAP

IC9300 A21 RXEAN

IC9300 B20 RXEBP

IC9300 A20 RXEBN

IC9300 B19 RXECP

IC9300 A19 RXECN

IC9300 B18 RXECKP

IC9300 A18 RXECKN

IC9300 B17 RXEDP

IC9300 A17 RXEDN

IC9300 B16 RXEEP

IC9300 A16 RXEEN

D-CLRD1

50V 15p

50V 18p

PD_SIU

PD_SCCLK

PD_CERS

PD_OC2

PD_CRC1

PD_SCNRST

PD_OC1

PD_CIS

PD_CEL

PD_CSH

PD_CSL

PD_CPH1

PD_CMH

PD_CML

PD_CRC2

D_UHZ

IC9300 L3 DCCOP27

IC9300 M3 DCCOP35

IC9300 N3 DCCOP39

TP9383

IC9300 R3 DCCIFBK1

IC9300 V3 DCCOP11

IC9300 T3 DCCIFBK2

IC9300 K2 DCCOP30

IC9300 K1 DCCOP34

IC9300 L2 DCCOP6

IC9300 L1 DCCOP38

IC9300 M2 DCCOP33

IC9300 M1 DCCOP7

IC9300 N2 DCCOSCRST

IC9300 N1 DCCOP32

IC9300 P2 DCCOP10

IC9300 R2 DCCOP5

IC9300 R1 DCCOP9

IC9300 T2 DCCOP2

IC9300 T1 DCCOP3

IC9300 U2 DCCOP4

IC9300 U1 DCCOP0

IC9300 V2 DCCOP1

IC9300 V1 DCCOP8

IC9300 W2 DCCOP31

IC9300 P1 DCCIFBK0

DD5_2P

DD5_2N

DD5_1P

DD5_1N

DRVCLK3P

DRVCLK3N

DD6_2P

DD6_2N

DD6_1P

DD6_1N

IC9300

C1AB00003259

IC9300 AC2 LVDOD0P

IC9300 AC1 LVDOD0N

IC9300 AD2 LVDOD1P

IC9300 AD1 LVDOD1N

IC9300 AC4 LVDRCK0P

IC9300 AC3 LVDRCK0N

IC9300 AE2 LVDOD2P

IC9300 AE1 LVDOD2N

IC9300 AF2 LVDOD3P

IC9300 AF1 LVDOD3N

IC9300 AG2 LVDOD4P

IC9300 AG1 LVDOD4N

IC9300 AH2 LVDOD5P

IC9300 AG3 LVDRCK2P

IC9300 AF3 LVDRCK2N

IC9300 AJ4 LVDOD6P

IC9300 AK4 LVDOD6N

IC9300 AJ5 LVDOD7P

IC9300 AK5 LVDOD7N

IC9300 AJ6 LVDOD8P

IC9300 AK6 LVDOD8N

IC9300 AJ7 LVDOD9P

IC9300 AK7 LVDOD9N

IC9300 AH7 LVDRCK4P

IC9300 AH6 LVDRCK4N

IC9300 AJ8 LVDOD10P

IC9300 AK8 LVDOD10N

IC9300 AJ9 LVDOD11P

IC9300 AK9 LVDOD11N

PD4

DD7_2P

DD7_2N

DD7_1P

DD7_1N

DRVCLK4P

DRVCLK4N

DD8_2P

DD8_2N

DD8_1P

DD8_1N

DD9_2P

DD9_2N

DD9_1P

DD9_1N

DRVCLK6P

DRVCLK6N

DD10_2P

DD10_2N

DD10_1P

DD10_1N

DD11_2P

DD11_2N

DD11_1P

DD11_1N

DRVCLK7P

DRVCLK7N

DD12_2P

DD12_2N

DD12_1P

DD12_1N

IC9300 AJ12 LVDOD12P

IC9300 AK12 LVDOD12N

IC9300 AJ13 LVDOD13P

IC9300 AK13 LVDOD13N

IC9300 AH13 LVDRCK6P

IC9300 AH12 LVDRCK6N

IC9300 AJ14 LVDOD14P

IC9300 AK14 LVDOD14N

IC9300 AJ15 LVDOD15P

IC9300 AK15 LVDOD15N

IC9300 AH15 LVDRCK7P

IC9300 AH14 LVDRCK7N

IC9300 AK16 LVDOD16N

IC9300 AJ17 LVDOD17P

IC9300 AK17 LVDOD17N

IC9300 AH17 LVDRCK8P

IC9300 AH16 LVDRCK8N

IC9300 AJ18 LVDOD18P

IC9300 AK18 LVDOD18N

IC9300 AJ19 LVDOD19P

IC9300 AK19 LVDOD19N

IC9300 AJ22 LVDOD20P

IC9300 AK22 LVDOD20N

IC9300 AJ23 LVDOD21P

IC9300 AK23 LVDOD21N

IC9300 AH23 LVDRCK10P

IC9300 AH22 LVDRCK10N

IC9300 AJ24 LVDOD22P

IC9300 AK24 LVDOD22N

IC9300 AJ25 LVDOD23P

IC9300 AK25 LVDOD23N

IC9300 AJ26 LVDOD24P

IC9300 AK26 LVDOD24N

IC9300 AJ27 LVDOD25P

IC9300 AK27 LVDOD25N

IC9300 AH27 LVDRCK12P

IC9300 AH26 LVDRCK12N

IC9300 AH29 LVDOD26P

IC9300 AH30 LVDOD26N

IC9300 AG29 LVDOD27P

IC9300 AG30 LVDOD27N

IC9300 AF29 LVDOD28P

IC9300 AF30 LVDOD28N

IC9300 AE29 LVDOD29P

IC9300 AE30 LVDOD29NIC9300 AH1 LVDOD5N

IC9300 AD28 LVDRCK14P

IC9300 AE28 LVDRCK14N

IC9300 AD29 LVDOD30P

IC9300 AD30 LVDOD30N

IC9300 AC29 LVDOD31P

IC9300 AC30 LVDOD31N

IC9300 AE3 LVDRCK1P

IC9300 AD3 LVDRCK1N

IC9300 AH5 LVDRCK3P

IC9300 AH4 LVDRCK3N

IC9300 AH9 LVDRCK5P

IC9300 AH8 LVDRCK5N

IC9300 AH19 LVDRCK9P

IC9300 AH18 LVDRCK9N

IC9300 AH25 LVDRCK11P

IC9300 AH24 LVDRCK11N

IC9300 AF28 LVDRCK13P

IC9300 AG28 LVDRCK13N

IC9300 AB28 LVDRCK15P

IC9300 AC28 LVDRCK15N

11

12

P3.3V

1k

TP9300

R9323

IC9300 B30 DCCIPORT0

NC/SIO3

P3.3V

C9300

16V

0.1u

8

VCC

R9306

S S

7

6

SCLK

R9307

S

5

SI/SIO0

PD_UEH

PD_USL/UML2

PD_USH

PD_UML

PD_UMH

R9609

EXB2HV470JV

R9610

EXB2HV470JV

PD_LED2

PD_ODED2

PD_PCD3

PD_PCD4

PD_CLRD2

USL/UML2_C

D-ODED2

D-CLRD2

D-LED2

D-PCD3

D-PCD4

TP9105

TP9106

TP9107

TP9108

TP9109

TP9110

UEH_C

USH_C

UML_C

UMH_C

R9334

R9335

PDP_SCLK

PDP_SOUT

NCS

PD_UEH

PD_USL/UML2

PD_USH

PD_UML

PD_UMH

PD_LED2

PD_PCD3

PD_PCD4

PD_ODED2

PD_CLRD2

PD_LED1

PD_PCD1

PD_PCD2

PD_ODED1

PD_CLRD1

S

P3.3V

R9030

R9203

4.7k

2.7k

R9205

R9031

33k

330

R9206

56k

P3.3V_DET

TO 6/19

R9054

0

C9052

0.1u

16V

S

R9042

P5V

P5V_DET

TO 6/19

R9058

0

C9040

16V

0.1u

R9308

R9309

S

1

CS#

2

SO/SIO1

3

WP#/SIO2

4

GND

*IC9304

TVRR576

FLASH MEMORY

IC9300 B6 SPIHZ

IC9300 A4 FLSCK

IC9300 B5 FLNCS

IC9300 B4 FLSIO0

IC9300 C5 FLSIO1

IC9300 A6 FLSIO2

IC9300 A5 FLSIO3

IC9300 B3 EXTFLSO

IC9300 A3 EXTFLSCK

IC9300 C4 EXTFLSI

IC9300 A2 EXTFLNCS

IC9300 N28 DCCOP26

IC9300 P28 DCCOP25

IC9300 Y3 DCCOP22

IC9300 R28 DCCOP23

IC9300 K30 DCCOP24

IC9300 L29 DCCOP15

IC9300 L30 DCCOP14

IC9300 M29 DCCOP13

IC9300 M30 DCCOP12

IC9300 R29 DCCOP37

IC9300 P29 DCCOP18

IC9300 N30 DCCOP19

IC9300 P30 DCCOP21

IC9300 N29 DCCOP29

IC9300 W1 DCCOP36

IC9300 Y1 DCCOP16

IC9300 AA2 DCCOP17

IC9300 Y2 DCCOP20

IC9300 AA1 DCCOP28

R9341

S

P_S0

P_S1

OSD_VIN

D9806

B0ADCJ000100

D_XRST_SYS

DRVRST

DRVMUTE

SOS_DCC

OHZ1

LVDS_INPUT

R9318

1k

TO 6/19

PG-FILM_DET

TO 15/19

OSDCLK

R9122

S

R9123

S

R9035

3.3k

R9342

S

R9125

S

R9099

S

IC9300 B15 RXOAP

IC9300 A15 RXOAN

IC9300 B14 RXOBP

IC9300 A14 RXOBN

IC9300 B13 RXOCP

IC9300 A13 RXOCN

IC9300 B12 RXOCKP

IC9300 A12 RXOCKN

IC9300 B11 RXODP

IC9300 A11 RXODN

IC9300 B10 RXOEP

IC9300 A10 RXOEN

IC9300 U3 DCCOP40

IC9300 P3 DCCOP41

IC9300 T30 CKMO

IC9300 C29 SFLATCHI

TP9111

IC9300 A27 SFRST

TP9112

IC9300 B26 SFVRST

IC9300 D30 FPCLK

IC9300 E29 FPDAT1

IC9300 E28 FPDAT0

TP9076

IC9300 C2 OSDHO

TP9100

IC9300 K29 SFVO

TP9113

IC9300 D1 OSDVO

IC9300 C1 OSDCKO

IC9300 E2 OSDYSI

IC9300 D2 OSDRI

IC9300 E1 OSDBI

IC9300 D3 OSDGI

IC9300 F1 OSDCKI

IC9300 E3 OSDHI

IC9300 A29 XRST

C9393

16V

0.1u

IC9300 B28 XRSTSYS

C9394

16V

0.1u IC9300 A28 DCCIDRVRST

C9303

0.1u

16V

IC9300 C30 DCCIDISPEN

IC9300 B27 SOS

TA1P

TA1N

TB1P

TB1N

TC1P

TC1N

TCLK1P

TCLK1N

TD1P

TD1N

TE1P

TE1N

IIC

R9339

P3V_SDA02

P3V_SCL02

S

R9340

S

IC9300 B7 SDA

IC9300 A7 SCL

D-LED1

D-ODED1

13

DD8_2N

TP9151

DD8_2P

TP9152

DD8_1N

TP9153

DD8_1P

TP9154

P3.3V

3.30V

VJ9902

P

PD_LED1

PD_ODED1

PD_PCD1

PD_PCD2

PD_CLRD1

R9608

EXB2HV470JV

D-ODED1

D-CLRD1

D-LED1

D-PCD1

D-PCD2

DATA_DRIVER

SS_PULSE

DD5_1P

DD5_1N

DD5_2P

DD5_2N

TP9136

TP9901

TP9900

TP9902

TP9135

TP9904

TP9903

DRVCLK3P

DRVCLK3N

TP9138

TP9137

TP9139

TP9140

DD6_2N

TP9141

DD6_2P

TP9142

DD6_1N

TP9143

DD6_1P

TP9144

DD7_2N

TP9145

DD7_2P

TP9146

DD7_1N

TP9147

DD7_1P

TP9148

DRVCLK4N

TP9149

DRVCLK4P

TP9150

1

SIDE

123456789

2

KEY_SCAN

LE1

GND

ODE1

1011121314151617181920212223242526272829303132

PC2

PC1

GND

CLR1

GND

DD5_2-

DD5_1-

DD5_1+

DD5_2+

DRVCLK3-

DRVCLK3+

DD6_1-

DD6_2-

DD6_2+

DD6_1+

33343536373839

GND

DD7_1+

DRVCLK4-

DRVCLK4+

GND

DD7_2-

DD7_1-

DD7_2+

GND

DD8_1-

DD8_2-

DD8_1+

DD8_2+

TERM

TP9195

TP9197

TP9193

TP9194

40

NC

P3.3V

TO

P3.3V

A31

C1-BOARD (C11)

118 122 124120 121 123 125119 126

63

13.20. A-Board (15/19) Schematic Diagram

A-BOARD (15/19)

!

C9307 0.1u

16V

C9308 0.1u

16V

C9311

16V

C9312

10V

C9313 0.1u

16V

C9314

10V

C9315 0.1u

16V

C9316

10V

IC9300 D18 LRX_V12C_2

IC9300 D19 LRX_V12C_3

IC9300 D20 LRX_V12C_0

IC9300 D21 LRX_V12C_1

J0JHC0000117

IC9300 E11 LRX_V12

IC9300 E12 LRX_V12

IC9300 E19 LRX_V12

IC9300 E20 LRX_V12

0.1u IC9300 W27 PLLICK_AVD

10u

IC9300 Y27 PLLICK_AVS

IC9300 AB27 PLLSSDCCCK_AVD

10u

IC9300 AA27 PLLSSDCCCK_AVS

P P P

VJ9302 VJ9301 VJ9300

IC9300 AG19 PLLSSMLCK_AVD

10u

IC9300 AG18 PLLSSMLCK_AVS

P1.2V

IC9300 AA4 VDDC

IC9300 AA5 VDDC

C9319 0.1u

IC9300 AB1 VDDC

16V

IC9300 AB2 VDDC

IC9300 AB3 VDDC

IC9300 AB4 VDDC

C9322 0.1u

IC9300 AB5 VDDC

16V

C9323 0.1u

IC9300 AB26 VDDC

16V

IC9300 AC26 VDDC

C9325 0.1u

IC9300 AD26 VDDC

16V

IC9300 AE26 VDDC

IC9300 AF8 VDDC

C9327 0.1u

IC9300 AF9 VDDC

16V

L9300

IC9300 AF10 VDDC

IC9300 AF21 VDDC

IC9300 AF22 VDDC

IC9300 AF23 VDDC

IC9300 AF24 VDDC

IC9300 E7 VDDC

IC9300 E8 VDDC

IC9300 E9 VDDC

IC9300 E10 VDDC

IC9300 E21 VDDC

IC9300 E22 VDDC

IC9300 E23 VDDC

IC9300 E24 VDDC

C9335

10u

IC9300 G5 VDDC

10V

C9336

10u

IC9300 G26 VDDC

10V

C9337

10u

IC9300 H5 VDDC

10V

IC9300 H26 VDDC

IC9300 J5 VDDC

IC9300 J26 VDDC

IC9300 K5 VDDC

IC9300 U26 VDDC

IC9300 V26 VDDC

PD4

C9339 0.1u

16V

C9340 0.1u

16V

C9347 1u

6.3V

C9342 0.1u

16V

C9344 0.1u

16V

C9349 10u

10V

C9350 0.1u

16V

C9352

6.3V

C9351 0.1u

16V

IC9300 AF13 SCS_VDD18

IC9300 AF14 SCS_VDD18

IC9300 AF16 SCS_VDD18

IC9300 AF17 SCS_VDD18

IC9300 N26 SCS_VDD18

IC9300 P26 SCS_VDD18

IC9300 R26 SCS_VDD18

IC9300 T26 SCS_VDD18

IC9300 E13 SCS_VDD18

IC9300 E14 SCS_VDD18

IC9300 E16 SCS_VDD18

IC9300 E17 SCS_VDD18

IC9300 R5 SCS_VDD18

IC9300 T5 SCS_VDD18

IC9300 U5 SCS_VDD18

IC9300 V5 SCS_VDD18

IC9300 N5 SCS_VDD15

1u

IC9300 P5 SCS_VDD15

IC9300 L26 SCS_VDD15

IC9300 M26 SCS_VDD15

C9356

16V

C9361

16V

C9363

16V

C9371

10V

C9372

10V

C9373

10V

C9374 0.1u

16V

C9375 0.1u

16V

0.1u

10u

IC9300

A1 VDD33

IC9300 B2 VDD33

IC9300 C3 VDD33

IC9300 D4 VDD33

IC9300 D8 VDD33

IC9300 D9 VDD33

IC9300 D10 VDD33

IC9300 D16 VDD33

IC9300 D17 VDD33

IC9300 D23 VDD33

IC9300 D24 VDD33

IC9300 D25 VDD33

IC9300 E5 VDD33

IC9300 H3 VDD33

IC9300 H27 VDD33

IC9300 H28 VDD33

IC9300 J3 VDD33

IC9300 J4 VDD33

IC9300 J27 VDD33

IC9300 N27 VDD33

IC9300 P4 VDD33

IC9300 P27 VDD33

IC9300 R4 VDD33

IC9300 U28 VDD33

IC9300 V4 VDD33

IC9300 V28 VDD33

IC9300 W3 VDD33

IC9300 W4 VDD33

IC9300 W28 VDD33

L9301

J0JHC0000117

IC9300 A9 LRX_VDDH

IC9300 A22 LRX_VDDH

IC9300 B9 LRX_VDDH

IC9300 B22 LRX_VDDH

C1AB00003259

C9380 0.1u

16V

C9383 0.1u

16V

C9391

10V

C9392

10V

J0JHC0000117

IC9300 AA28 MLVDS_VDD

IC9300 AA29 MLVDS_VDD

IC9300 AA30 MLVDS_VDD

IC9300 AB29 MLVDS_VDD

IC9300 AB30 MLVDS_VDD

IC9300 AC5 MLVDS_VDD

IC9300 AC27 MLVDS_VDD

IC9300 AD4 MLVDS_VDD

IC9300 AD5 MLVDS_VDD

IC9300 AD27 MLVDS_VDD

IC9300 AF6 MLVDS_VDD

IC9300 AF7 MLVDS_VDD

IC9300 AG6 MLVDS_VDD

IC9300 AG7 MLVDS_VDD

IC9300 AG8 MLVDS_VDD

IC9300 AG9 MLVDS_VDD

IC9300 AG13 MLVDS_VDD

IC9300 AG14 MLVDS_VDD

IC9300 AG16 MLVDS_VDD

IC9300 AG17 MLVDS_VDD

10u

IC9300 AG24 MLVDS_VDD

10u

IC9300 AG25 MLVDS_VDD

IC9300 AG26 MLVDS_VDD

IC9300 Y28 MLVDS_VDD

IC9300

C1AB00003259

P3.3V

L9302

IC9300 A8 GND

IC9300 A23 GND

IC9300 A30 GND

IC9300 AA3 GND

IC9300 AF4 GND

IC9300 AF5 GND

IC9300 AF11 GND

IC9300 AF12 GND

IC9300 AF15 GND

IC9300 AF20 GND

IC9300 AF26 GND

IC9300 AG20 GND

IC9300 AG27 GND

IC9300 AG4 GND

IC9300 AH3 GND

IC9300 AH11 GND

IC9300 AH20 GND

IC9300 AH28 GND

IC9300 AJ1 GND

IC9300 AJ2 GND

IC9300 AJ11 GND

IC9300 AJ20 GND

IC9300 AJ29 GND

IC9300 AJ30 GND

IC9300 AK1 GND

IC9300 AK2 GND

IC9300 AK3 GND

IC9300 AK11 GND

IC9300 AK20 GND

IC9300 AK28 GND

IC9300 AK29 GND

IC9300 AK30 GND

IC9300 B1 GND

IC9300 B8 GND

IC9300 B23 GND

IC9300 B29 GND

IC9300 C9 GND

IC9300 C10 GND

IC9300 C11 GND

IC9300 C12 GND

IC9300 C13 GND

IC9300 C14 GND

IC9300 C15 GND

IC9300 C16 GND

IC9300 C17 GND

IC9300 C20 GND

IC9300 C21 GND

IC9300 C22 GND

IC9300 C23 GND

IC9300 C27 GND

IC9300 C28 GND

IC9300 D5 GND

IC9300 D22 GND

IC9300 D26 GND

IC9300 D27 GND

IC9300 E4 GND

IC9300 E6 GND

IC9300 E15 GND

IC9300 E25 GND

IC9300 E26 GND

IC9300 F4 GND

IC9300 F5 GND

IC9300 F26 GND

IC9300 G1 GND

IC9300 G4 GND

IC9300 H1 GND

IC9300 H4 GND

IC9300 J1 GND

IC9300 J2 GND

IC9300 K4 GND

IC9300 K26 GND

IC9300 K27 GND

IC9300 L4 GND

IC9300 L5 GND

IC9300 L27 GND

IC9300 M5 GND

IC9300 R30 GND

IC9300 T4 GND

IC9300 T27 GND

IC9300 T28 GND

IC9300 T29 GND

IC9300 U30 GND

IC9300 V27 GND

IC9300 V29 GND

IC9300 W5 GNDIC9300 E18 GND

IC9300 W26 GNDIC9300 H2 GND

IC9300 W29 GND

IC9300 Y4 GND

IC9300 Y5 GND

IC9300 Y30 GND

IC9300 AA26 SCS_ANA_40

IC9300 AF18 SCS_ANA_0

IC9300 AF19 SCS_ANA_2

IC9300 AF25 SCS_ANA_18

IC9300 AG5 SCS_ANA_39

IC9300 AG10 SCS_ANA_24

IC9300 AG21 SCS_ANA_20

IC9300 AH10 SCS_ANA_19

IC9300 AH21 SCS_ANA_22

IC9300 AJ3 SCS_ANA_37

IC9300 AJ10 SCS_ANA_17

IC9300 AJ21 SCS_ANA_1

IC9300 AJ28 SCS_ANA_16

IC9300 AK10 SCS_ANA_21

IC9300 AK21 SCS_ANA_3

IC9300 C7 SCS_ANA_23

IC9300 C8 SCS_ANA_8

IC9300 C18 SCS_ANA_13

IC9300 C19 SCS_ANA_15

IC9300 C24 SCS_ANA_14

IC9300 C25 SCS_ANA_12

IC9300 C26 SCS_ANA_10

IC9300 D11 SCS_ANA_6

IC9300 D12 SCS_ANA_11

IC9300 E27 SCS_ANA_7

IC9300 F2 SCS_ANA_25

IC9300 F3 SCS_ANA_4

IC9300 F27 SCS_ANA_9

IC9300 G2 SCS_ANA_29

IC9300 G3 SCS_ANA_27

IC9300 G27 SCS_ANA_5

IC9300 J28 SCS_ANA_26

IC9300 M4 SCS_ANA_31

IC9300 M27 SCS_ANA_28

IC9300 N4 SCS_ANA_33

IC9300 R27 SCS_ANA_30

IC9300 U4 SCS_ANA_35

IC9300 U27 SCS_ANA_34

IC9300 U29 SCS_ANA_32

IC9300 Y26 SCS_ANA_38

IC9300 Y29 SCS_ANA_36

PD4

IC9300 AE5 miniLVDS_MON0

IC9300 AG11 miniLVDS_MON1

IC9300 AG22 miniLVDS_MON2

IC9300 D29 SBI0

IC9300 D28 SBI1

IC9300 E30 SBO0

IC9300 F28 SBO1

IC9300 F30 SBT0

IC9300 F29 SBT1

TP9114

IC9300 D6 LRX_TXN_1

IC9300 D7 LRX_TXP_1IC9300 AE27 miniLVDS_MON3

IC9300 D13 LRX_TXN_0

IC9300 D14 LRX_TXP_0

IC9300 A26 SFLATCHO

R9324

IC9300 AE4 miniLVDS_RI0

1.6k

R9325

IC9300 AF27 miniLVDS_RI3

1.6k

R9326

IC9300 AG12 miniLVDS_RI1

1.6k

R9327

IC9300 AG23 miniLVDS_RI2

1.6k

IC9300 B25 TEST

IC9300 K28 TMODE0

IC9300 L28 TMODE1

IC9300 M28 DCCIPORT1

IC9300 D15 VTEST0

IC9300 AG15 VTEST1

IC9300 A24 ID0

IC9300 B24 ID1

IC9300 A25 ID2

IC9300 C6 IICSYNC

TO 14/19

OSDCLK

IC9300 K3 OCKOUT

IC9300 G30 SRLF0

IC9300 G29 SRLF1

IC9300 G28 SRLF2

IC9300 H29 MVIO

IC9300 H30 MHIO

IC9300 J29 SVIO

IC9300 J30 SHIO

11

12

DRVRST

13

Q9900

DSC200100L

R9903

4.7k

R9904

100k

P3.3V

TP9010

10k

R9905

Q9901

DSC200100L

100k

R9906

C9900

25V

0.01u

SIDE

3.3V_DET

DD9_1N

DD9_2N

DD9_2P

DD9_1P

TP9158

TP9159

TP9160

TP9157

123456789

GND

DD9_1-

DD9_2-

DD9_1+

DD9_2+

DD10_1N

DD10_2P

DD10_2N

DRVCLK6P

DRVCLK6N

TP9164

TP9162

TP9161

TP9163

1011121314151617181920212223242526272829303132

GND

DD10_2-

DD10_2+

DRVCLK6-

DRVCLK6+

DD11_2N

DD11_1P

DD11_2P

DD10_1P

TP9166

TP9165

GND

DD10_1-

DD10_1+

DD11_1N

TP9168

TP9170

TP9169

TP9167

GND

DD11_1-

DD11_2-

DD11_2+

DD11_1+

DRVCLK7N

TP9171

DRVCLK7-

DRVCLK7P

TP9172

DRVCLK7+

DD12_2P

DD12_2N

TP9173

TP9174

GND

DD12_2-

DD12_2+

DD12_1P

DD12_1N

TP9175

TP9176

GND

DD12_1-

DD12_1+

D-LED2

D-PCD3

D-ODED2

TP9907

TP9906

TP9905

3334353637383940414243444546474849505152535455

LE2

GND

PC3

GND

ODE2

D-PCD4

TP9908

UMH_C

D-CLRD2

TP9909

TP9910

PC4

GND

UMH

CLR2

SOS8_SS

UML_C

USH_C

UEH_C

USL/UML2_C

TP9913

TP9911

TP9914

TP9912

100

R9907

NC

USL

USH

UEH

UML

DRVSOS8

GND

P5V

P3.3V

VJ9901

P

P5V

VJ9900

P

TERM

A32

TP9198

TO C2-BOARD (C21)

TP9205

TP9199

TP9206

135129 134127 130 133128 132131

64

13.21. A-Board (16/19) Schematic Diagram

A-BOARD (16/19)

!

IC5603

C0DBFYY00049

AVDD3.3V

F15V

SUB9V

SOS-SENSE

STB3.3V

Q5471

DSA200100L

R5471

2.2k

R5472

3.3k

C5471

16V

0.1u

B0ACCJ000048

B0ADEJ000035

PEAKS-AVC POWER

SUB3.3V

C5649

10V

10k

R5640

1u

10k

D5471

D5472

R5641

POWER-MODEL

TP5409

R5473

1k

1

2

3

VIN

CE

VSS

VOUT

NC

5

4

C5650 10V

2.2u

C5472

R5474

16V

10k

0.1u

SUB5.6V

R5475

220

SUB9V

R5479

470

SUB5V

R5481

220

L5608

J0JHC0000045

TP5471

SUB5V

AVDD3.3V

R5500

P

TO 3,6/19

SG-SOS STMADIN5

C5722

25V 1u

SUB5V

D5605

B0HCMM000014

100k

R5642

C5651

IC5401

C0DBGYY00884

SUB9V

VOUT 3

1

VIN

VSS

2

IC5604

C0DBGYY00578

AVDDH3.3V

4

VIN

4.7u10V

VSS

NC

2

3

C5723

16V 1u

Q5472

DSC2001S0L

R5486

B0ADCJ000100

ON/OFF

F15V

CTL

D5602

R5609

DZ2J056M0L

AVDDH3.3V

5

VOUT

C5652

10V

SUB3.3V

4.7u

1

10k

R5643

7.5k

R5644

P3.3V

P5V

D5476

DZ2J068M0L

1k

R5485

D5475

100k

B0ADCJ000100

D5481

DZ2J120M0L

D5478

B0ADCJ000100

D5483

DZ2J068M0L

D5479

D5485

DZ2J068M0L

D5480

SUB1.2V

SUB3.3V

SUB5.6V

D5477

DZ2J068M0L

R5488

R5487

4.7k

SUB9V

D5482

DZ2J120M0L

R5490

R5489

4.7k

SUB1.8V

D5484

DZ2J068M0L

R5492

R5491

4.7k

SUB5V

D5486

DZ2J068M0L

R5493

R5494

4.7k

C5615

10V

2.2u

10k

R5611

2.2k

R5610

47k

Q5603

DSC2001S0L

Q5602

DSC2001S0L

R5612

10k

R5613

R5607

R5600

22k

68k

R5608

C5616

25V

0.01u

47k

TO 17/19

68

DCDC_CTL1

PEAKS-AVC POWER

IC5601

C0DBAYY00715

SUB5V

SUB3.3V

1

DRVH1

2

VBST1

EN1

VO1

VFB1

GND

SS1

VFB2

VO2

EN2

VBST2

DRVH2

1

DRVH1

2

VBST1

3

EN1

4

VO1

5

VFB1

6

GND

7

SS1

8

VFB2

9

VO2

10

EN2

11

VBST2

12

DRVH2

IC5600

C0DBAYY00715

SUB1.8V SUB1.2V

DRVL1

PGND1

VREG5

V5FILT

PGND2

DRVL2

3

3.3k

R5618

R5638

S

R5620

1k

R5634

S

R5621

1k

5.6k

R5619

R5602

2.7k

R5636

S

R5604

2k

R5603

R5637

1.24k

S

R5601

820

4

R5647

5

S

6

C5627

10V

0.039u

7

R5648

8

S

9

10

11

12

R5645

S

C5606

10V

0.15u

R5646

S

C5634

R5627

0.1u16V

10

S

R5635

24

SW1

23

22

R5622

24k

21

TRIP1

20

VIN

C5632

4.7u

10V

19

C5635

1u16V

18

C5631

16V

0.1u

17

SS2

R5623

22k

16

TRIP2

15

14

13

SW2

R5639

S

C5633

R5626

0.1u16V

10

R5616

C5608

10

0.1u16V

S

R5628

24

SW1

23

DRVL1

22

R5606

PGND1

24k

21

TRIP1

20

VIN

C5607

19

VREG5

V5FILT

TRIP2

PGND2

DRVL2

4.7u

10V

C5612

18

1u16V

C5602

17

SS2

25V

6800p

16

R5605

20k

15

14

13

SW2

R5631

S

C5609

0.1u16V

R5617

10

S1G1S2G2

Q5605

B1MBEDA00015

Q5604

B1MBDDA00003

S1G1S2G2

Q5600

B1MBDDA00003

Q5601

B1MBEDA00015

S1G1S2G2

10u

10u25V

C5626

25V

C5628

D2 D2 D1 D1

10u25V

10u

D2 D2 D1 D1

C5629

C5625

25V

C5604

C5600

25V

10u

D2 D2 D1 D1

C5603

C5601

25V

D2 D2 D1 D1

10u

25V 10u

G1C100MA0077

G1C3R3Z00005

L5605

G1C4R7Z00014

L5602

G1C100MA0077

L5601

G1C3R3Z00004

L5600

G1C2R2Z00006

DCDC15V

L5606

SUB3.3V

L5604

TP5602

22u

C5643

C5641

C5642

6.3V

22u

SUB5V

TP5603

C5658

C5659

C5660

6.3V

DCDC15V

L5603

J0JHC0000075

C5611

25V

1u

SUB1.8V

TP5601

22u

C5618

C5619

C5617

6.3V

22u

SUB1.2V

TP5600

C5620

C5621

C5622

6.3V

PA5610

K5H4022A0031

F15V

65

142141136 144137 138 140139 143

13.22. A-Board (17/19), K-Board and S-Board Schematic Diagram

!

Standby-MPU

TO 3,6,9,11,12/19

sLD-STMGPIO5 SG-TV_SUB_ON

Analog-ASIC

A-BOARD (17/19)

Panel-D

P15V

TP9196

C9106

25V 10u

STB5V

TPST5

STMGPIO5

TO 12/19

STB_5V_SWON

TPS0N

TP2805

CONNECTOR

CN0102

STB5V

IC2870

R2875

39

C2872

25V

0.01u

C2873

10V 10u

D2870

C0DBAYY00462

SUB5.6V(TUNER-AVSW)

1

BOOT

2

VIN

3

SW

4

COMP

GND

C2877

50V

0.022u

8

SS

7

EN

R2870

2.2k

6

5

FB

TP2871

R2873

R2872

10k

1.5k

"H": ON

R2871

"L": OFF

10k

DCDC_CTL1

C2878

50V

TO 16/19

4700p

R2874

P

TO P-BOARD (P6)

A6

1

2

C9108

25V

0.01u

5V_STB

C2824

10V 10u

R2820

100

3

4

5

6

7

8

9

10

TP2810

11

TO P-BOARD (P7)

A7

1

2

3

4

5

6

7

8

9

10

11

R2823

12

47k

13

14

+15V_S

+15V_C

S_GND

GND

F+15V

GND

STBY5V

GND

S0

S1

TUNER_SUB_ON (F_STBY_ON)

PANEL_MAIN_ON

STBY5V_SW

SOS4_PS

S_15V

TPS15V

F15V

Spec 3000mA

L2871

J0JHC0000075

C2884 25V

1u

Panel-D

TP2820

TP2821

R9191 100

R9190 100

TP2822

R9145 100

TP2823

R9120 100

R2884

P

C2886

C2885

25V 10u

SUB5.6V

TPF15V

+

C2883

25V

47u

P_S0

TO 13/19

TO 6,13/19

PANEL_MAIN_ON

TO 12,13/19

SOS4_PS

C2871

25V

25V 10u

10u

TP2870

L2870

G1C101MA0416

C2874

10V 10u

B0JCME000092

GenX-DEST

TO 3,6/19

IIC/Panel-D-PDP

TO 1/19

LVDS-MODEL

TO 13/19

IIC

TMP-SENS_SDA

TMP-SENS_SCLP_S1

IIC

TO 1/19

SG-SRQ_GENX STMGPIO3

ADJ-STM_SCL

ADJ-STM_SDA

ADJ-PEAKS_SCL

ADJ-PEAKS_SDA

AR_STB_SCL02

PANEL_SCL2

AR_STB_SDA02

PANEL_SDA2

R2750

100

R2753

10k

1

SDA

2

SCL

3

ALERT

4

GND

IC1000

C1ZBZ0003775

TEMP SENSOR

TP2751

SUB3.3V

TP2750

TP2752

TP2753

TP2754

TP2755

8

V+

7

A0

6

A1

5

A2

1

STB5V

2

SRQ

3

GND

4

GenX8_SCL

5

GenX8_SDA

6

PEAKS_SCL3

7

PEAKS_SDA3

8

Panel_SCL (Panel Dpr.E2PROM)

9

Panel_SDA

10

IIC_CONT

11

SUB3.3V

FOR FACTORY USE

C2751 25V 1u

(GenX8 Loarder/E2PROM)

(PEAKS E2PROM)

(Panel Dpr.E2PROM)

(Genx7_SRQ)

FACT_SDBOOT

TO 6/19

R2882

7.15k

1%

SW5152

K0H1BA000445

SW2500

K0F162B00002

POWER SWITCH

1%

SW5153

K0H1BA000445

KEY_SCAN

R2883

1.74k

1%

SW5154

K0H1BA000445

TO 6/19

R2880

14.3k

1%

R2881

6.65k

SW5150

RM2510

B3RAD0000168

C2510

0.01u

50V

Q2510

DSC200100L

REMOTE RECEIVER

VCC

GND

R2511

100k

R2512

220k

OUT

123

REMOCON

K-BOARD TXN/K1LGUE

!

R2510

R2513

22k

47

C2511

10V 10u

STB3.3V

R2514

10k

G_LED_ON

Q2512

DSC200100L

D2520

B3AGB0000060

G

R

POWER LED

R2519

R2516

1.82k

680

Q2511

DSC200100L

R2515

47k

C2515

50V

0.01u

R2517

R2518

22k

47k

R_LED_ON

K1

TP2501

1

TP2502

2

TP2503

3

TP2504

4

5

TP2505

RMIN

G_LED_ON

R_LED_ON

STB3.3V

TP2874

A1

1

2

3

4

5

GND

6

7

8

TP2875

TP2878

TP2879

TP2877

STB3.3V

TP2876

R2878

S

Standby-MPU

STMRMIN SG-RMIN

SG-G_LED_ON SG-R_LED_ON

STMTIME4

TO 6/19

SG-AI_SENSOR

TO 3,6/19

TO 6/19

TO 3,6/19

sLD-STMADIN0

!

SW5151

K0H1BA000445

UP DOWNFAVTV

S-BOARD TNPA4858AB

123

S1B

TO P-BOARD (P34)

STB_PS

5V

PUSH

149145 148 150 152 153146 147 151

66

13.23. A-Board (18/19) Schematic Diagram

A-BOARD (18/19)

!

PEAKS-COMMON

Achip

TO 2/19 TO 2/19 TO 2/19

SIF I/F

C8004

16V

0.1u D15_VREFHSIF

C8005

16V

0.1u

C8010 16V

C8076

16V

0.1u

C8019

16V

0.1u

C8125

10V 10u

C8067

16V

0.1u

C8069

16V

0.1u

C8070

16V

0.1u

C15_VREFLSIF

0.1u

SUB1.2V

L8004

J0JHC0000045

TO 2/19

VDDAVAD

CN

TERM

FUNC

VDDAVAD

IC8001

1

L12

VDDAVAD

2

IC8001

VDDAVAD

IC8001

M11

3

VDDAVAD

4

M12

IC8001

5

N11

VDDAVAD

IC8001

VDDAVAD

6

N12

AVDDH3.3V

L8009 J0JHC0000045

TO 2/19

AVDDH

TERM

FUNC

CN

1

IC8001

P11

IC8001

P12

2

3

IC8001

P13

4

P14

IC8001

5

R11

IC8001

6

R12

IC8001

7

R13

IC8001

R14

8

SUB3.3V

L8008

J0JHC0000045

C8062

C8126

16V

10V

0.1u

10u

1

AVDDH

TO 2/19

L14_AVDDSIF

IC8001

TERM FUNC

AVDDSIFCNL14

VSW

ADC

C8073

1u

6.3V

C8074

1u

6.3V

TO 2/19

C8114

C8006

16V

0.1u

16V

0.1u

C8011

0.1u

16V

C8115

C8007

16V

0.1u

16V

0.1u

C8012

0.1u

16V

C8116

C8008

16V

0.1u

16V

0.1u

C8013

0.1u

16V

C8117

C8009

16V

0.1u

16V

0.1u

C8014

0.1u

16V

SUB3.3V

L8010

J0JHC0000045

C8124

10V

10u

C8017

16V

0.1u

C8123

16V

0.1u

SUB3.3V

L8022

J0JHC0000045

C8022

10V

10u

C8068

16V

0.1u

C8113

16V

0.1u

1

2

IC8001

C10_BIAS

D10_BIAS2

C6_VREFH0

D6_VREFL0

C7_VREFH1

D7_VREFL1

C8_VREFH2

D8_VREFL2

C9_VREFH3

D9_VREFL3

CN

Dchip

Analog Audio In I/F

C8075

1u

6.3V

C8077

25V

0.01u

D21_VREF1V5

D20_VREG

SUB1.2V

L8002

J0JKC0000021

TO 2/19

TERM

FUNC

1

2

3

4

5

6

7

8

9 IC8001

10

11

12

13

14

15

16

17

19

20

21

22

CN

IC8001

N17

IC8001

N18

P17

IC8001

P18

IC8001

R17

IC8001

R18

IC8001

R19

IC8001

T17

T18

T19

IC8001

U17

IC8001

U18

IC8001

U19

IC8001

U20

U21

IC8001

U22

IC8001

U23

U24

IC8001

U31

U32

IC8001

U33

IC8001

U34

C8036

10V 10u

C8120

16V

0.1u

C8035

10V

VDD12

10u

VDD12

C8093

VDD12

6.3V

VDD12

1u

VDD12

C8097

VDD12

16V

VDD12

0.1u

VDD12

CN

TERM

FUNC

IC8001

V13

VDD12

1

IC8001

V14

VDD12

2

V15

3

IC8001

VDD12

IC8001

4

V16

VDD12

5

IC8001

V17

VDD12

6

V18

IC8001

VDD12

7

V19

IC8001

VDD12

8

IC8001

V20

VDD12

9

V21

IC8001

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

VDD12

IC8001

V22

VDD12

V23

IC8001

VDD12

IC8001

V24

VDD12

IC8001

V31

VDD12

IC8001

V32

VDD12

V33

IC8001

VDD12

V34

IC8001

VDD12

W13

IC8001

VDD12

W1418

IC8001

VDD12

W15

IC8001

VDD12

IC8001

W16

VDD12

IC8001

W17

VDD12

IC8001

W18

VDD12

IC8001

VDD12

W19

W20

IC8001

VDD12

SUB3.3V

L8001

J0JHC0000116

TO 2/19

C8044

10V 10u

C8042

6.3V 1u

C8048

6.3V 1u

C8037

16V

0.1u

R8031

2.2k

VDD3

TERM

CN

FUNC

N19

IC8001

VDD3

1

VDD3

N20

IC8001

2

3

P19

IC8001

VDD3

IC8001

4

P20

VDD3

5

IC8001

R20

VDD3

T20

6

IC8001

VDD3

7

T21

IC8001

VDD3

8

IC8001

T22

VDD3

9

T23

IC8001 FUNC

VDD3

IC8001

T24

10

VDD3

IC8001

T31

VDD3

11

IC8001

12

T32

VDD3

IC8001

T33

13

VDD3

IC8001

T34

VDD3

14

AC11

IC8001

VDD3

15

16

AC12

IC8001

VDD3

IC8001

17

AD11

VDD3

DDR

1.8V_DDRI/F

R8005

R8006

TO 3/19

R8007

110

R8010

300

R8009

56

1k

R8008

10k

R8014

10k

1

AB31_MMCKE

AB32_MMODT

AG31_MMCK

AG32_MMXCK

AL28_MMRODT

AL27_MMRDRV

MMVCAL/REF

CN

IC8001

C8047

16V

0.1u

CN

IC8001

C8046

16V

0.1u

TERM

AH31

MMVCAL

TERM

FUNC

AL29

MMVREF

USB I/F

SD CARD I/F

SUB1.2V

SUB3.3V

C8091

0.1u

J0JHC0000045

16V

1

L8017

J0JHC0000045

L8018

J0JHC0000045

L8019

SUB_SD_3.3V

CN

IC8001

TO 3/19

C8058

16V

0.1u

C8050

16V

0.1u

C8057

16V

0.1u

TERM

AD11

TO 3/19

SUB_SD_3.3V

FUNC

VDD33SD

AA11_VDDUSB

AD15_VDDAUSB

AD14_VDDPUSB

STM

AVDD3.3V

L8023

J0JHC0000045

L8011

AVDDV3.3V

TO 2/19

AVDDV3.3V

TERM

CN

FUNC

IC8001

1

AVDDV

F4

G4

IC8001

AVDDV

2

IC8001

3

H4

AVDDV

4

J4

IC8001

AVDDV

TO 2/19

AVDDPLLV/75D

TERM

FUNC

L13

AVDDPLLV

AVDD75D

E4

J0JHC0000045

C8023

10V 10u

AVDDA

TO 2/19

CN

TERM

FUNC

L19

IC8001

AVDDAL11

1

L20

IC8001

AVDDA

2

L21

3

IC8001

AVDDA

R8011

330

C8064

4V

22u

SUB3.3V

L8012

J0JHC0000045

C8024

10u

TO 2/19

10V

AVDDHP

CN

TERM

FUNC

L22

IC8001

AVDDHP

1

L23

IC8001

AVDDHP

2

IC8001

L24

3

AVDDHP

TO 2/19

L15_AVDDPLLA

C8063

16V

TERM

CN

1

CN

IC8001

TO 2/19

AVDDADA1/2/3

TERM

L17

TO 2/19

AVDDADA1/2/3

TERM

L16

TO 2/19

AVDDADA1/2/3

FUNC

L15

AVDDPLLA

FUNC

AVDDADA1

FUNC

AVDDADA2

TERM

FUNC

L18

AVDDADA3

C8099

6.3V 1u

C8020

16V

0.1u

C8021

16V

0.1u

1

IC8001

1

STB1.2V

L8016

J0JHC0000045

C8056

16V

TO 3/19

0.1u AP32_VDD12STM

SUB1.2V

L8005

J0JKC0000021

TO 3/19

VDDR/A

TERM

CN

FUNC

IC8001

AA20

VDDR

1

IC8001

VDDR

AB20

2

3

IC8001

VDDR

AC20

4

IC8001

VDDR

AD20

5

IC8001

VDDR

Y20

VDDA

AB19

IC8001

6

IC8001

VDDA

AC19

7

8

IC8001

VDDA

AD19

SUB1.2V

L8015

J0JHC0000045

C8055

16V

TO 3/19

0.1u

W24_LVVDD12

STB3.3V

L8000

J0JHC0000045

C8002

16V

0.1u

FUNC

TERM

CN

1

AP31

IC8001

VDD33STM

SUB1.8V

L8003 J0JKC0000021

C8100

10V 10u

C8101

10V 10u

C8104

6.3V

C8105

16V

0.1u

C8108

16V

0.1u

C8110

16V

0.1u

C8111

16V

0.1u

C8112

16V

0.1u

1.8V_DDRI/F

TO 3/19 TO 3/19

1.8V_DDRI/F

TERM

CN

FUNC

IC8001

Y23

1

Y24

IC8001

2

AA23

3

IC8001

4

AA24

IC8001

1u

5

IC8001

AB23

IC8001

6

AB24

IC8001

AC23

7

IC8001

8

AC24

IC8001

9

AD23

AD24

IC8001

10

AJ31

IC8001

11

12

AK31

IC8001

VDDIO

IC8001

13

AK32

AL30

IC8001

14

AL31

IC8001

15

AL32

IC8001

16

AM31

IC8001

17

18

IC8001

AM32

19

AM33

IC8001

AN32

20

21

IC8001

AN33

AN34

22

IC8001

23

IC8001

AP33

AP34

IC8001

24

VDDIO

VDDIOCK

VDDIO

TO 3/19

VDD33STM/ADAVDD

C8003

16V

0.1u

FUNC

TERM

CN

1

IC8001

ADAVDD

AP29

SUB3.3V

L8013 J0JHC0000045

C8085

10V 10u

C8051

16V

0.1u

SUB3.3V

L8014

J0JHC0000045

L8020

J0JHC0000045

L8021

J0JHC0000045

L8024

J0JHC0000045

L8025

J0JHC0000045

LVVDD33

TERM

CN

FUNC

J31

IC8001

LVVDD33

1

K31

IC8001

LVVDD33

2

L31

IC8001

3

LVVDD33

4

IC8001

M31

LVVDD33

5

N31

IC8001

LVVDD33

IC8001

P31

6

LVVDD33

R31

7

IC8001

LVVDD33

TO 3/19

AD18_DPAVDD

C8052

16V

0.1u

TO 3/19

P24_M1A1AVDD

C8053

16V

0.1u

TO 3/19

N24_MVAVDD

C8054

16V

0.1u

TO 3/19

AD16_AVDDPWM

C8000

16V

0.1u

TO 3/19

AD17_A2AVDD

C8001

16V

0.1u

67

161158154 162155 160157 159156

13.24. A-Board (19/19) Schematic Diagram

A-BOARD (19/19)

!

DVB-T/C DEMODULATOR

TUNER

TO 1,9/19

TO 9/19

FE-OUT_SDA

FE-OUT_SCL

C8320

10V

FE_XRST / SDRAM_CHK

AA_FE_RST

TO 4,9/19

IC8302

C0DBFYY00041

PVDD33XVDD

DVB-T/C

FE0_CLK

31

SONY

TSDATA3

TSDATA2

68

R8303

DVB 2.5V

R8310

68

C8319

16V

0.1u

VJ8300

S

25A026

27

28

29

30

24

VSS

PVSS

CVDD

23

VSS

RESETN

22

OSCENBN

CVDD

OSCMODE

21

SDA

20

SCL

19

DVDD

18

VSS

TESTMODE

17

TSDATA7

16

TSDATA6

15

TSDATA5

14

TSDATA4

13

12

C8314

16V

0.1u

C8306

16V

0.1u

C8305

C8304

50V

10p

41.0MHz

C8308

16V

0.1u

34

35

36

37

XTALI

38

XTALO

AINP

39

AVSS

40

AVDD

41

RFAIN

42

RVDD

43

VSS

44

CVDD

45

IFAGC

TUNERDAT

46

TUNERCLK

47

RFAGC_GPIO1

48

TSERR3TSSYNC4TSVALID5TSCLK6VSS7DVDD8TSDATA09TSDATA110CVDD11VSS

1

2

FE0_PSYNC

10p

R8302

470

C8317

16V

0.1u

32

XVSS

AINM

GPIO0

68

R8306

R8305

FE0_VAL

X8300

H0J410500001

L8302

J0JHC0000045

C8322

16V

0.1u

L8303

J0JHC0000045

C8318

C8303

16V

IFD1

IFD2

IFAGC

0.1u

C8301

16V

0.1u

C8324

50V

R8316

56p

0

R8315

0

C8325

50V 56p

SUB3.3V

R8327

R8326

4.7k

R8301

C8300

10k

16V

0.1u

16V 0.1u

C8315

16V

0.1u R8324

560

R8325

560

C8316

16V0.1u

1u

1

2

3

VIN

CE

VSS

VOUT

NC

5

4

TP8301

C8321

10V

2.2u

J0JHC0000045

C8309

16V

0.1u

C8310

16V

0.1u

R8300

EXB2HV680JV

IC8300

C1AB00003188

OFDM

SUB3.3V

L8300

J0JHC0000045

C8311

10V

10u

FE1.2V

L8304

R8322

22

FE_SDA DEVELOP_SDA2

TO 1/19

DEVELOP_SCL2

R8323

FE_SCL

22

FE0_MDO7

FE0_MDO6

FE0_MDO5

FE0_MDO4

TO 4/19

FE0_MDO3

FE0_MDO2

FE0_MDO1

FE0_MDO0

TO 4/19

165 169168164 170 171163 166 167

68

13.25. C1-Board Schematic Diagram

DD6_2-

DD5_2-

GND

!

C1-BOARD TXNC111EFK

A

AB_LED1

AB_PCD1

AB_CLRD1

AB_ODED1

C1_P3.3V

C17104

10V

AB_PCD1

AB_PCD2

1u

CLR

AB_CLRD1

CLR

AB_CLRD1

C1_P3.3V

VDD1 VDD1

C1_P3.3V

NC

OHZ

GND

VDD1

C17105

10V

1u

NC

OHZ

VDD1

C17107

10V

1u

GND

BLK

B

150

R17101

SIDE

1345789

NC

DM

VDD2

CB1

TO PANEL DATA DRIVER

1112131415161718192021222324252627282930313233343536373839404142434445474849515253

NC

GND

VDD2

LEN

GND

AB_LED1

AB_ODED1

C

SIDE

1345789

NC

DM

CB2

TO PANEL DATA DRIVER

NC

VDD2 VDD2

VDD2

D

111213141516171819202122232425262728293031

NC

GND

VDD2

C17103

100V

0.33u

LEN

GND

ODE

GND

AB_LED1

AB_ODED1

DD5_1-

DD5_2-

DD5_1+

DD5_2+

A2P

A2N

GND

DD6_2-

DD6_2+

32

A2P

A2N

GND

DD7_2+

DD7_2-

DRVCLK3-

DRVCLK3+

100

R17102

A1N

GND

DD6_1-

100

R17104

33

34

A1N

GND

DD7_1-

100

R17107

200

R17103

R17105

A1P

FXP

FXN

GND

DD6_1+

DRVCLK3-

100

R17106

3536373839404142434445474849515253

A1P

FXN

GND

DD7_1+

DRVCLK4-

100

R17109

DRVCLK3+

FXP

DRVCLK4+

GND

TEST

200

R17108

GND

TEST

200

R17110

VDA

C17109

100V

0.33u

NC

GND

C17110

100V

0.33u

NC

GND

1

R17112

TERM

55

CB1

NC

DM

VDD2

Y8

11

Y7

12

R17124

VDA

1

R17116

TERM

55

CB2

NC

DM

VDD2

VDD2 VDD2

VDD2

VDA

1

R17118

AB_LED1

AB_ODED1

AB_PCD1

AB_PCD2

AB_CLRD1

47

R17125

EXB38V470JV

C17113

16V

0.1u

C1_P3.3V

Y6

13

Y5

14

Y4

15

Y3

16

Y2

17

Y1

18

G2

19

Vcc

20

GND

BUFFER

IC17101

C0JBAU000043

10

A8

9

A7

8

A6

7

A5

6

A4

5

A3

4

A2

3

A1

2

G1

1

LE1

TERM

AA_LED1

R17126

680

ODE1

AA_ODED1

R17127

EXB38V681JV

R17131

R17132

AA_PCD1

GND

PC2

PC1

AA_PCD2

0

AA_ODED1

AA_CLRD1

0

CLR1

AA_CLRD1

AA_LED1

AA_PCD1

AA_PCD2

DD5_1-

DRVCLK3-

DD5_2+

GND

DD5_1+

GND

DRVCLK3-

DD5_1+

DD5_1-

DD5_2+

DD5_2-

DRVCLK3+

DD6_1-

GND

DD6_2+

DD6_1-

DD6_2+

DD6_2-

DD6_1+

DD7_1-

DD7_2-

GND

DD7_2+

DD7_1+

DD7_1-

DD7_2+

DD7_2-

C1_P3.3V

VDA

R17129

220k

DD8_2-

DRVCLK4+

DD8_1-

DD8_2+

NC

P3.3V

GND

DD8_1+

GND

10111213141516171819202122232425262728293031323334353637383940

DD8_2-

DD8_2+

DD8_1-

DD8_1+

TO C2-BOARD (C20)

GND

DRVCLK4-

C10

3.3V_DET

TERM

20

3.3V_DET

19

P3.3V

18

P3.3V

17

NC

16

GND

15

GND

14

GND

13

GND

12

GND

11

GND

10

GND

9

GND

8

NC

7

NC

6

NC

5

VDA

4

VDA

3

VDA

2

VDA

1

VDA

SIDE

R17128

1k

TO

P3.3V

A-BOARD (A31)

123456789

SIDE

C11

C1_P3.3V

R17130

0

SIDE

1345789

NC

DM

E

F

CB3

TO PANEL DATA DRIVER

SIDE

1345789

DM

CB4

TO PANEL DATA DRIVER

NC

VDD2

NC

VDD2

111213141516171819202122232425262728293031

NC

GND

VDD2

GND

VDD2

111213141516171819202122232425262728293031

NC

GND

GND GND

VDD2

GND

BLK

LEN

CLR

ODE ODE

GND

VDD1

AB_LED1

AB_PCD2

AB_CLRD1

AB_ODED1

C1_P3.3V

BLK

LEN

CLR

ODE

GND

VDD1

32

33343536373839404142434445474849515253

NC

OHZ

GND

C17108

10V

1u

NC

OHZ

GND

A2P

A1P

FXP

A1N

A2N

GND

DD8_2-

DD8_2+

R17111

32

33343536373839404142434445474849515253

A2P

A2N

GND

FXN

GND

DD8_1+

GND

TEST

DRVCLK4-

DRVCLK4+

100

200

R17113

R17115

A1P

FXP

FXN

GND

TEST

GND

DD8_1-

100

A1N

GND

NC

GND

VDD2

C17112

100V

0.33u

NC

GND

R17120

NC

VDD2

TERM

55

CB3

NC

DM

VDD2

ZA17103

K4CD01000013

ZA17104

K4CD01000013

20

C10

1

551551551551

140

VDA

1

TERM

55

CB4

NC

DM

VDD2

ZA17102

K4CD01000013

C11

87321 54 96

69

13.26. C2-Board Schematic Diagram

!

C2-BOARD TXNC211EFK

A

B

SIDE

3.3V_DET 1

P3.3V

2

P3.3V

3

NC

4

GND

5

GND

6

GND

7

GND

8

GND

9

GND

10

GND

11

GND

12

NC

C

13

NC

14

NC

15

VDA

16

VDA

17

VDA

18

VDA

19

VDA

20

C20

TO C1-BOARD (C10)

D

C2_P3.3V

VDA

TERM

AB_LED2

AB_PCD3

AB_CLRD2

AB_ODED2

C2_P3.3V VDA

C17208

ZA17202

C20

1

20

19

18

17

16

15

14

13

12

11

AB_PCD4

20

SS_5V

C17214

16V

0.1u

EXB38V470JV

C2_P3.3V

C17216

10V

1u

GND

DRVCLK7-

DD11_1+

DD10_1+

Vcc

G2

Y1

Y2

Y3

Y4

Y5

Y6

Y7

Y8

DD10_1+

GND

DD11_2-

DD11_1-

GND

DD11_2+

GND

DD11_2-

DD11_2+

DD11_1-

DD11_1+

DRVCLK7-

C2_P3.3V

C17210

16V

20

0.1u

19

18

17

16

15

14

13

12

11

C17211

100V

0.33u

R17209

EXB38V470JV

R17210

47

1

R17213

GND

DD9_1+

DD9_2+

DD9_2-

GND

3.3V_DET

55

TERM

DD9_2-

DD9_2+

R17232

0

AA_CLRD2

AA_PCD4

AA_PCD3

AA_ODED2

AA_LED2

R17233

0

R17203

EXB38V681JV

DD9_2-

DD9_2+

10V 1u

DRVCLK6-

DD9_1-

GND

DD9_1-

DD9_1+

DRVCLK6-

R17204

680

DD9_1-

DD9_1+

DRVCLK6-

100

R17206

R17205

DRVCLK6+

1

2

3

4

5

6

7

8

9

10

DRVCLK6+

GND

G1

A1

A2

A3

A4

A5

A6

A7

A8

GND

R17207

DD10_2-

200

DD10_2+

DD10_2-

DD10_2+

IC17202

C0JBAU000043

GND

DD10_1-

BUFFER

DRVCLK7+

DD12_2-

AB_CLRD2

AB_PCD4

AB_PCD3

AB_ODED2

AB_LED2

DD12_2+

GND

DD12_1-

DD12_1+

GND

AA_LED2

GND

PC4

PC3

ODE2

LE2

AA_ODED2

AA_PCD3

AA_PCD4

GND

AA_UEH

AA_UML

AA_UMH

CLR2

AA_CLRD2

UML

UMH

NC(USH)

NC(USL)

GND

101112131415161718192021222324252627282930313233343536373839404142434445464748495051525354

AA_UMH

AA_UML

AA_UEH

P3.3V

NC

GND

UEH

DRVSOS8

NC

R17217

EXB38V681JV

1

2

3

4

5

6

7

8

9

10

G1

A1

A2

A3

A4

A5

A6

A7

A8

GND

P3.3V

R17219

P5V_SS

TO A-BOARD (A31)

123456789

C21

SIDE

0

BUFFER

IC17203

C0JBAZ002692

AB_LED2

Vcc

G2

Y1

Y2

Y3

Y4

Y5

Y6

Y7

Y8

SS_5V

C2_P3.3V

K4CD01000013

ZA17201

K4CD01000013

R17218

AB_UEH

AB_UML

AB_UMH

DD11_2-

DD11_2+

DD11_1-

DD11_1+

100

R17221

R17220

155

C21

551551 155 55

AB_UEH

AB_UML

AB_UMH

SS_5V

SOS8_SS

TO SS-BOARD

SOS8_SS

12345

C23

(SS23)

5V

UML

UEH

UMH

VDA

C17218

100V

0.33u

1

R17227

6

GND

DRVCLK7-

DRVCLK7+

200

100

R17222

1

6

ZA17203

K4CD01000013

1

GND

VDA

NC

123

4

C25

R17226

220k

TO P-BOARD (P35)

VDA

1

4

SIDE

1345789

NC

DM

VDD2

CB5

TO PANEL DATA

E

F

DRIVER

SIDE

1345789

NC

DM

CB6

TO PANEL DATA DRIVER

NC

VDD2

111213141516171819202122232425262728293031

NC

GND

VDD2

111213141516171819202122232425262728293031

NC

GND

VDD2

GND

BLK

LEN

CLR

ODE

GND

AB_LED2

LEN

GND

AB_ODED2

ODE

AB_PCD3

BLK

AB_CLRD2

CLR

VDD1

C2_P3.3V

VDD1

2 94

32

33343536373839404142434445474849515253

NC

OHZ

GND

C17209

10V 1u

NC

OHZ

GND

A2P

A1P

DD10_1-

FXP

A1N

FXN

GND

TEST

DD10_1+

DRVCLK6+

DRVCLK6-

200

100

R17212

R17211

A1P

FXP

A1N

FXN

GND

TEST

A2N

GND

DD10_2+

DD10_2-

100

R17208

32

33343536373839404142434445474849515253

A2P

A2N

GND

NC

GND

VDD2

C17212

100V

0.33u

NC

GND

R17215

NC

VDD2

3 71 5

TERM

55

NC

DM

VDD2

VDA

1

TERM

55

NC

DM

VDD2

SIDE

1345789

NC

DM

CB7

TO PANEL DATA DRIVER

SIDE

1345789

NC

DM

CB8

TO PANEL DATA DRIVER

111213141516171819202122232425262728293031

NC

VDD2

C17215

100V

0.33u

111213141516171819202122232425262728293031

NC

VDD2

GND

VDD2

GND

NC

GND

VDD2

BLK

LEN

ODE

GND

AB_LED2

AB_PCD4

AB_ODED2 AB_ODED2

BLK

LEN

ODE

GND

CLR

AB_CLRD2 AB_CLRD2

CLR

VDD1

C2_P3.3V

VDD1

NC

OHZ

GND

VDD1

C17217

10V

1u

NC

OHZ

GND

VDD1

6

32

333435363738394041424344454748

A1P

A2P

A2N

GND

DD12_2+

DD12_2-

100

R17223

32

33343536373839404142434445474849515253

A2P

A2N

GND

DD12_1-

FXP

A1N

FXN

GND

DD12_1+

DRVCLK7-

DRVCLK7+

100

R17224

A1P

FXP

A1N

FXN

GND

TEST

200

R17225

GND

GND GND

GND

TEST

GND

NC

VDD2

NC

VDD2

4951525355

NC

VDD2

R17229

NC

VDD2

8

TERM

NC

DM

VDD2

VDA

1

150

R17231

TERM

55

NC

DM

VDD2

70

13.27. SC-Board (1/4) Schematic Diagram

!

SC-BOARD TXNSC11EFK (1/4)

A

D16871

DZ2J330M0L

C16565

0.01u

C16566

0.01u

TP117

50V

B0ADCJ000100

TP118TP116

TPSOS7

R16751

150k

R16783

150k

D16875

B0ACCJ000048

5V

R16752

4.7k

Q16876

B1ABCF000231

1

A_OUTPUT

2

A_-INPUT

3

A_+INPUT

4

GND

IC16581

C0BBBA000024

ERROR DET

D16820

B0ACCJ000048

B_OUTPUT

B_-INPUT

B_+INPUT

SOS7_SC2

MID

1

D16583

R16581

B3ABB0000210

22k

15V

8

VCC

7

R16585

1k

6

5

R16586

1.69k

R16593

1.33k

(GREEN LED)

C16581

R16582

25V

39k

1u

R16583

39k

C16582

R16584

25V

6.81k

4.7u

VOLTAGE ERROR DET(C16582) OPERATES AT 11.8V OR MORE AND 5.2V OR LESS

15V

R16774

27k

*

D16821

TP125

DZ2J330M0L

R16755

27k

R16750

27k

R16753

47k

D16480

B0ACCJ000048

TPSOS6

R16587

SOS7_SC2

TP72

TP74

2.2k

5V

R16588

10k

R16476

4.7k

TP71TP73

D16822

TP112

TP110

TP115

TP114

TP113

VSCN

Vsus

GND

TO P-BOARD (P2)

SC2

1

3

TP107

TP105

TPVSUS

TP1

TP2

TP5

TP4

C16412

VSUS

250V

1.5u

TP108

TP106

TP109 TP111

B

VAD VOLTAGE ERROR DET OPERATES AT -169V OR MORE AND -210V OR LESS

VSCAN VOLTAGE ERROR DET OPERATES AT 166V OR MORE AND 125V OR LESS

TP82

TP7

TP6

TP8

TO A-BOARD (A20)

SC20

TERM

30

P5V

29

SIU

28

CLK

27

SC_FPGANRST

GND

26

CERS

25

CRC2

24

GND

23

OC2

22

CRC1

21

20

OC1

19

GND

18

CPH1

17

CIS

16

SOS6

15

SOS7

14

GND

13

UHZ

12

GND

11

CEL

10

GND

9

CSH

8

GND

7

CSL

6

GND

5

CMH

4

CML

3

NC

2

P15V

1

P15V

TP28

+

SIDE

C16791

TP29

TP30

TP31

C

D

E

TP9

15V

TP17

TP16

P5V

TP38

SIU

TP19

CLK

TP24

TP70

CERS

TP40

CRC2

TP52

OC2

TP21

CRC1

TP39

SC_FPGANRST

TP18

OC1

TP22

CPH1

TP23

CIS

TP36

TP20

TP37

UHZ

TP14

CEL

TP25

TP11

CSH

TP10

CSL

TP26

CMH

TP27

CML

D16790

25V

B0JCME000093

220u

TP34

TP32

TP35

TP33

R16561

EXB38V470JV

R16562

EXB38V470JV

R16563

EXB38V470JV

R16564

EXB38V470JV

EXB38V472JV

C16561

R16580

10V

5.6k 10u

R16565

R16566

R16568

R16567

IC16561

C0JBAU000043

BUFFER

1

G1

2

A1

3

A2

4

A3

5

A4

6

A5

7

A6

8

A7

9

A8

10

GND

1

G1

2

A1

3

A2

4

A3

5

A4

6

A5

7

A6

8

A7

9

A8

10

GND

TP12

TP13

IC16562

C0JBAU000043

BUFFER

14

VCC

13

6A

12

6Y

11

5A

10

5Y

9

4A

8

4Y

IC16563

C0JBAB000916

INVERTER

5V

20

Vcc

19

G2

18

Y1

17

Y2

16

Y3

15

Y4

14

Y5

13

Y6

12

Y7

11

Y8

20

Vcc

19

G2

18

Y1

17

Y2

16

Y3

15

Y4

14

Y5

13

Y6

12

Y7

11

Y8

1

1A

2

1Y

3

2A

4

2Y

5

3A

6

3Y

7

GND

R16591

EXB38V472JV

AA_CERS

AA_SC_FPGANRST

MAIN_STOP0

AA_CPH1

AA_CML2

AA_CLK

AA_OC2

AA_OC1

AA_CEL

AA_CSH

AA_CSL

AA_CMH

AA_CML

AA_CRC2

AA_UHZ

AA_SIU

AA_CIS

D16874

DZ2J051M0L

C16562

16V

1u

R16590

220

C16593

50V

1000p

C16564

16V

1u

AA_CRC1

F

2

12

3

5

96847

71

13.28. SC-Board (2/4) Schematic Diagram

!

SC-BOARD TXNSC11EFK (2/4)

TO SS-BOARD (SS3)

1

3

SC3

5

AA_CMH

AA_CML2

AA_CSH

D16441

B0ECHR000001

D16411

B0ACCJ000048

D16461

B0FACQ000001

R16416

10k

Q16441

DG3D5010CSLW

VRH

IC16771

C0CBADC00072

C16771

16V 1u

Vad+5V

1

VOUT

NC

9

NC

10

VCC

11

HIN

12

NC

13

LIN

14

GND

15

NC

16

IC16501

C0ZBZ0001708

FET DRIVER

CSH/CMH GATE DRIVE CIRCUIT

VIN 3

COM

2

Vad+5V

PC16461

B3PBE0000054

1

R16411

2

270

3

R16410

390

45

R16441

5.6

MIDF

VSUS

C16471

630V

1000p

TP91

TP90

C16533

25V 1u

8

7

6

R16533

47k

Q16531

B1HFPFA00001

*L16401

G0C2R0K00001

R16417

100

R16418

100

C16524

25V

4.7u

C16501

25V 1u

VAD

R16531

10

16V_F

D16401

+

C16796

25V

470u

HO

8

VB

7

VS

6

NC

5

NC

4

VCC2

VCOM

LO

R16523

3

C16522

25V

4.7u

2

D16522

1

B0ECHR000001

R16534

5.6

D16534

D1FK60-5073

R16504

C16502

25V

4.7u

75

+

D16503

B0ECHR000001

R16510

C16523

25V 470u

D16536

B0ECHR000001

R16503

75

1

10

+

C16504

C16503

25V

4.7u

470u

Vad+5V

VFG

Q16501

B1HFPFA00001

R16512

47k

DA3DF50ACSLW

R16401

7.5

R16402

7.5

Q16401

B1JAEQ000010

Q16402

B1JAEQ000010

VSUS

C16401

630V

5600p

11

VFG

12

VOL

13

TP100

TP99

VSUS

C16727

630V

1500p

1

D16724

DA3DF30ACSLW

D16481

B0FACQ000002

D16451

B0ECHR000001

TP93

VRL

MIDC

Q16451

DG3D5010CSRP

TP92

C16491

630V

1000p

R16451

5.6

R16553

47k

Q16551

B1HFPFA00001

*L16411

G0C2R0K00001

R16521

100

AA_CSL

AA_CML

R16522

100

R16551

10

IC16521

C0ZBZ0001708

FET DRIVER

CSL/CML GATE DRIVE CIRCUIT

NC

9

NC

10

15V

VCC

11

HIN

12

C16521

25V

1u

NC

13

LIN

14

GND

15

NC

16

HO

8

VB

VS

NC

VCC2

VCOM

LO

R16524

7

C16527

25V

4.7u

6

5

4

3

2

1

R16619

1

D16620

B0ECKP000055

75

C16525

25V

4.7u

D16722

DA3DF30ACSRP

15V

Vad+5V

R16506

10

C16505

25V 1u

Q16521

B1HFPFA00001

Q16421

R16421

7.5

R16517

47k

B1JAEP000014

D16421

B0FACP000006

C16421

630V

5600p

14

152

72

171614 181211 151310

13.29. SC-Board (3/4) Schematic Diagram

!

SC-BOARD TXNSC11EFK (3/4)

21

R16604

AA_CERS

AA_CPH1

SEPA PROTECT CIRCUIT

3

ANODE

CATHODE

IC16490

C0DBZMC00006

SHUNT REG

4

1NC2

REFERENCE

R16494

IC16491

C0BBAA000008

SEPA PROTECT

DZ2J047M0L

5V

C16490

2k

R16495

390

3

+INPUT

OUTPUT

GND

2

VCC

1

-INPUT

D16492

R16493

6.98k

TP68TP67

R16496

47

Q16490

B1CBGD000001

R16498

10k

R16492

120k

16V 1u

4

5

330

PC16603

B3PBA0000223

PC16684

B3PBA0000496

1

2

34

R16684

220

R16491

R16490

110k

100k

D16490

B0ECKP000055

4

12

C16602

50V 22p

3

R16631

10k

6

C16684

50V

0.1u

5

11

AA_CIS

VFG

12

VOL

13

D16678

DZ2J15000L

D16702

1

2

3

IC16773

C0JBAB000715

INVERTER

Vad+5V

5

NC

VCC

C16708

50V

0.1u

IN_A

4

GND

OUT_Y

Vad+5V

14

C16707

50V

AA_CEL

22p

R16717

1k

Q16701

R16707

B1ADCN000007

3.9k

B0ACCJ000048

Q16702

B1ABCF000231

R16711

R16712

4.7k

1k

R16685

220

R16891

69.8k

R16892

82.5k

R16893

82.5k

Q16818

B1CBGD000001

R16776

47

1

2

34

PC16685

B3PBA0000496

IC16661

C0BBBA000024

COMPARATOR

1

A_OUTPUT

2

A_-INPUT

3

A_+INPUT

4

GND

C16773

25V 1u

6

C16685

5

8

VCC

7

B_OUTPUT

6

B_-INPUT

5

B_+INPUT

16V_F

50V

0.1u

C16753

R16921

1.54k

R16922

4.02k

Q16670

B1ADCN000007

15V

R16633

R16765

10

22k

D16497

RF071L4STE25

D16765

RF071L4STE25

C16756

C16755

25V

4.7u

R16769

75

R16761

10

25V

4.7u

C16641

630V

3300p

16V_F

R16686

10k

R16897

2.61k

R16899

3.01k

R16801

22k

Q16801

DSA2001S0L

R16802

33.2k

R16690

4.7k

R16691

56k

R16692

1.5k

Q16671

B1ABCF000231

Q16607

B1CBGD000001

R16615

D16604

1.13k

D16605

DZ2J051L0L

B0ADCJ000100

R16607

6.49k D16610

B0ACCJ000048

C16608

50V 220p

Q16603

DSA2001S0L

R16621

220

R16681

10

Q16621

B1JADN000009

R16920

10k

R16926

2.2k

D16901

B0ADCJ000100

R16904

Q16921

B1ABCN000007

R16928

4.7k

Q16602

DSC2001Q0L

R16634

470

R16605

1.8k

D16602

DZ2J150M0L

Q16762

B1HFPFA00001

D16407

B0JCME000093

R16763

47k

C16642

630V

3300p

C16891

25V

1u

D16478

R16746

47k

R16745

470k

R16675

4.7k

R16694

56k

R16695

1.5k

R16742

47k

Q16675

B1ADCN000007

Q16676

B1ABCF000231

D16477

DZ2J047L0L

B1ABCF000231

16V_F

Q16810

16V_F

VOL

R16804

1.1k

R16747

2.2k

R16699

10k

Q16920

B1ABCN000007

22k

C16603

C16604

630V

1000p

1.2k

B0ADCJ000100

Q16662

DSC2001Q0L

R16609

2k

D

G

5V

R16923

10k

4

NC

REFERENCE

3

ANODE

CATHODE

IC16692

C0DBZYY00352

SHUNT REG

R16601

Q16601

B1CERR000025

S

R16680

10k

1

2

Q16606

DSC2001Q0L

R16612

47

R16617

2.2k

D16920

R16679

10k

C16675

50V

390p

1000p

D16607

R16610

B0ACCJ000048

100k

D16641

B0FBCN000007

R16927

22k

R16661

16V_F

1

D16618

B0ECKP000055

D16493

B0ADCJ000100

D16494

B0ADCJ000100

R16658

9.76k

R16663

6.98k

B0ACCJ000048

VSUS

D16671

Q16663

DSA2001S0L

VSUS

+

C16414

220V 250u

VFG

R16497

47k

Q16672

B1CBGD000001

C16661

630V 1000p

R16666

22k

C16664

50V 68p

C16662

630V

1000p

D16662

DZ2J330M0L

R16665

B1JAER000010

33

C16665

50V 68p

D16663

Q16661

C16666

D16664

DZ2J330M0L

50V 68p

R16674

R16664

1k

D16672

B0ECHR000001

D16670

B0ECHR000001

VAD

22

VAD

23

24

VFG

25

15

AA_CRC1

AA_CRC2

26

2622 2721 25242319 20

73

13.30. SC-Board (4/4) Schematic Diagram

!

SC-BOARD TXNSC11EFK (4/4)

21

Q16931

R16936

C16721

50V

100u

2.2k

D16721

B0ECHR000001

12

B1ABCN000007

R16930

2.7

Q16930

DSC2001Q0L

D16893

DZ2J056H0L

34

R16826

10k

16V_F

Q16817

DSC2001Q0L

R16929

T16471

G4DYA0000201

1

10

NC

P1

8

PT

VSUS

22

IC16784

MIP3910MSSCF

VAD GEN.

LS

R16938

180k

AA_UHZ

R16789

10k

34

Q16816

DSC2001Q0L

AA_SC_FPGANRST

MAIN_STOP0

12

C16856

C16843

50V

0.1u

PC16896

B3PBA0000223

VAD

23

24

VFG

25

4

FB

3

NC

2

VDD

1

C16857

R16475

4.7k

D16474

B0ACCJ000048

PC16480

B3PBA0000223

R16837

1k

16V

0.1u

B0ECHR000001

R16473

12

34

10V 1u

C16858

10V

1u

VAD

5V

DRAIN

SOURCE

D16711

560

D16719

B0ECKP000055

5

7

8

PC16897

B3PBA0000223

R16474

1k

3

ANODE

CATHODE

IC16471

C0DBEYY00114

SHUNT REG

4

1NC2

REFERENCE

34

TP94

R16471

3.9k

R16472

2.2k

R16841

4.7k

12

R16843

1k

R16852

470k

3

ANODE

CATHODE

IC16785

C0DBZYY00352

SHUNT REG

SCNR_PRO

4

1NC2

REFERENCE

B0ACCJ000048

C16859

50V

0.1u

C16854

50V

0.1u

D16473

Q16471

B1ABCF000231

+

C16413

220V 250u

*

R16838

DZ2J15000L

C16472

25V 1u

82k

D16710

TPVAD

R16479

R16845

60.4k

+

C16813

R16846

220V

60.4k

220u

R16849

60.4k

R16844

2.4k

L16472

G0ZZ00002183

CHA15V_F

R16478

5.6k

D16475

DZ2J051M0L

10k

S3

S1

NC6P2

R16825

150k

5V_F

2

4

5

R16785

100k

R16786

100k

DZ2J330M0L

R16787

33k

IC16724

C0CBADE00049

C16724

25V

4.7u

D16728

B0ECKP000055

C16793

D16824

OUT3

5V_F

COMMON

25V 220u

2

Q16885

B1CFNG000001

R16827

2.2k

+

R16822

R16937

82k

180k

PC16722

B3PBA0000223

R16823

82k

Q16815

B1ABCN000007

D16825

DZ2J330M0L

R16824

33k

15V_F

1

IN

+

C16723

25V

1u

C16794

10V 10u

R16932

22k

R16931

2.7

Q16932

DSC2001Q0L

C16844

50V

0.1u

VSCN

R16933

R16934

R16935

5.1k

4

3

2

1

C16860

C16862

10V

1u

10k

6.8k

IC16786

MIP3910MSSCF

VSCN GEN.

LS

FB

NC

VDD

C16861

16V

0.1u

TP57

+

C16795

25V

470u

DRAIN

SOURCE

R16829

1k

TPVSCN

R16860

8.2

D16859

B0ECHR000001

1

+

C16691

160V 100u

VSCN_F

C16462

C16461

C16463

630V

630V 220p

630V

220p

4700p

TP58

5

7

8

L16851

G0ZZ00002183

D16720

B0ECKP000055

PC16723

B3PBA0000223

D16713

B0ECHR000001

16V_F

TPSC1

TP96

L16698

G0C681MA0065

R16772

4.7k

12

34

IC16787

C0DBZYY00352

SHUNT REG

R16773

CATHODE

SCNR_PRO

SC46

TO SM-BOARD (SM46B)

SC42

TO SM-BOARD (SM42B)

VAD

TP95

VSCN

R16870

68k

C16864

50V

0.1u

R16851

1k

470k

C16863

50V

0.1u

4

3

ANODE

1NC2

REFERENCE

R16696

2.2

D16712

DZ2J15000L

R16831

68.1k

+

C16842

R16832

160V

71.5k

100u

R16873

2.4k

TP59

TP60

TP61

VFO

TP62

TP63

TP41

9

8

TP42

7

6

5

4

3

2

1

9

8

5V_F

7

6

5

5V_F

4

VSCN_F

3

2

1

R16721

EXB38V220JV

TP43

TP44

ZA16411 TUXJ490

ZA16412 TUXJ490

SC46SC42

ZA16421 TUXJ490

ZA16422

TUXJ490

TP51

TP80

TP81

TP78

TP79

ZA16401

K4CD01000011

ZA16403

K4CD01000011

CHA

AA_SIU

AA_OC2

AA_CLK

AA_OC1

SC3

ZA16402

K4CD01000011

ZA16404

K4CD01000011

SC2

SC20

SC50

FOR

1

2

FACTORY USE

26

28

3630 35343231 3329

74

13.31. SS-Board (1/2) Schematic Diagram

SS-BOARD TXNSS11EFK (1/2)

!

A

TO P-BOARD (P11)

SS11

1

VSUS

3

GND

4

15V

B

C

D

TP7

TP1

TPVSUS

TP8

TP2

C16103

C16104

25V

47p

*C16011

1

TO SC-BOARD (SC3)

+

C16018

220V 250u

+

250V

1.5u

C16272

25V 470u

R16131

AA_UMH

AA_UML

100

R16132

100

1

3

*C16101

630V

1000p

5

*L16011

G0ZZ00002183

*L16012

G0ZZ00002183

*L16013

G0ZZ00002183

*L16014

G0ZZ00002183

*C16004

TP61

Q16001

B1JBEN000002

R16001

630V

1000p

R16141

10

TP68 TP70

Q16141

B1HFPFA00001

7.5

TP71TP69

Q16002

B1JBEN000002

R16002

7.5

TP60

C16001

*C16003

630V

1000p

470p

TP63

TP62

TP65

TP64

C16002

630V

4700p

TP66

TP67

SS3

C16105

C16106

630V

220p

2

R16143

47k

D16131

R16137

NC

9

NC

10

NC

11

HIN

12

NC

13

LIN

14

GND

15

NC

16

IC16131

C0ZBZ0001707

FET DRIVER

VSUS Gen.

DRIVER

B0ECKP000055

HO

8

VB

7

C16131

R16134

25V

75

4.7u

VS

6

NC

5

NC

4

VCC

3

C16135

25V 1u

GND

2

LO

1

D16001

C16133

25V

4.7u

Q16161

B1HFPFA00001

R16161

10

B0FCCN000003

Q16021

B1JBEN000002

R16021

7.5

Q16022

R16163

B1JBEN000002

R16022

47k

7.5

*C16023

C16022

630V

470p

1000p

TO C2-BOARD (C23)

SS23

TP13

AAA_UEH

SOS8_SS

1

P5V

2

3

UML

4

UMH

5

6

GND

TP16

TP17

TP18

R16241

EXB38V470JV

EXB38V472JV

TP14

R16242

E

C16243

50V

0.01u

TP22

TPSOS8

R16280

2.2k

D16281

DZ2J051M0L

5V

C16242

1

G1

2

A1

3

A2

4

A3

5

A4

6

A5

7

A6

8

A7

9

A8

10

GND

IC16241

C0JBAU000043

BUFFER

20

Vcc

19

G2

18

Y1

17

Y2

16

Y3

15

Y4

14

Y5

13

Y6

12

Y7

11

Y8

C16244

10V

16V

1u

10u

AAA_UEH

AA_UML

AA_UMH

AA_SOS8

D16021

B0FCCN000003

3

4

F

5

6

74132

89

75

13.32. SS-Board (2/2) Schematic Diagram

SS-BOARD TXNSS11EFK (2/2)

!

1

ZA001

K4CD01000011

FPC protector

R16281

AA_SOS8

D16280

B0ACCJ000048

TP36

2

C16195

AAA_UEH

AA_UML

D16192

B0ACCJ000048

R16192

10k

1

2

34

R16191

150

3

C16317

10V

C16316

1u

4

10k

Q16280

B1ABCF000231

R16282

220

D16195

B0ECKP000055

R16195

1

25V

1u

PC16191

B3PBA0000496

R16330

1k

16V

0.1u

C16315

10V

1u

6

5

IC16304

MIP3900MSSCF

VE GEN.

LS

4

FB

3

CL

2

VDD

1

+

C16193

C16192

C16191

25V

0.1u

4.7u

B0ECKP000055

DRAIN

SOURCE

R16284

220k

D16282

DZ2J068M0L

R16283

47k

R16193

75

25V 47u

R16109

10

D16196

DZ2J200M0L

TP73TP72

D16316

5

PC16192

B3PBA0000223

7

8

B0ADEJ000035

Q16191

B1HFPFA00001

B0ECKP000055

34

D16285

C16286

50V

0.1u

C16287

50V

0.1u

D16317

+

*C16310

220V 250u

R16334

4.7k

12

CATHODE

IC16312

C0DBZMC00006

SHUNT REG.

G0C471MA0049

R16335

1k

3

ANODE

R16116

47k

L16303

4

1NC2

REFERENCE

R16289

330k

R16290

330k

R16285

EXB38V623JV

TP43

C16102

630V

G0ZZ00002183

D

S

D

4700p

L16103

R16105

470k

TPSS1

Q16101

B1CFRM000008

R16101

220

R16102

220

D16101

B0JCME000093

TP42

+

C16328

200V 200u

TPVe

R16320

68k

C16318

D16315

50V

DZ2J150M0L

0.1u

R16332

470k

C16319

50V

0.1u

G

R16103

10

Q16102

B1CFRM000008

G

R16104

10

R16309

33k

*

R16307

62k

R16318

56k

R16319

2.4k

TP54

TP56

ZA002

K4CD01000011

*SS53B

SIDE

1

2

3

4

5

6

PANEL

7

SUSTAIN ELECTRODE

8

9

10

11

12

13

TERM

*SS55B

SIDE

1

2

3

4

5

6

PANEL SUSTAIN

7

ELECTRODE

8

9

10

11

12

13

TERM

76

1510 1811 12 1413 16 17

14 Printed Circuit Board

14.1. P-Board

P-BOARD (FOIL SIDE) LSEP1287LDHB

6

5

4

3

2

1

ABCDEFGH I

77

P

Parts Location

IC

IC100 F-3 IC200 G-2 IC201 E-2 IC202 F-2 IC400 E-3 IC401 D-2 IC500 E-1 IC600 E-1 IC601 E-2 IC602 D-2 IC603 D-1 IC604 G-1 IC700 C-6 IC701 D-5 IC800 D-2 IC901 C-3 IC902 C-3 IC903 C-3 IC904 C-3

P-BOARD (FOIL SIDE)

TRANSISTOR

Q100 E-2 Q101 F-3 Q103 G-3 Q104 G-3 Q200 F-1 Q300 E-4 Q301 E-4 Q302 E-5 Q303 E-4 Q400 E-3 Q401 E-3 Q402 E-3 Q505 C-1 Q600 H-5 Q601 C-2 Q602 H-5 Q609 H-5 Q701 D-5 Q703 D-5 Q705 D-6 Q706 D-6 Q707 D-6 Q708 C-6 Q709 D-5 Q710 D-5 Q711 D-5 Q712 C-5 Q713 C-5 Q714 D-6 Q715 C-6 Q800 B-2 Q801 C-2 Q804 B-2 Q805 B-2 Q806 B-2 Q807 B-2 Q900 B-3 Q901 C-4 Q902 C-3

VOLUME

R141 F-3 R923 B-3 VR251 D-5

TEST POINT

TP700 F-5 TP900 B-4

Parts Location

IC

IC201 D-2 IC400 E-3

P-BOARD (COMPONENT SIDE)

TRANSISTOR

Q103 C-3 Q104 C-3 Q302 E-5 Q303 E-4 Q901 G-4

VOLUME

R141 D-2 R923 H-3 VR251 F-5

TEST POINT

TP700 D-5 TP900 H-4

78

P-BOARD (COMPONENT SIDE) LSEP1287LDHB

6

5

4

3

2

1

ABCDEFGH I

79

14.2. K and S-Board

6

5

K S

4

S-BOARD (FOIL SIDE)

K-BOARD (FOIL SIDE) TXN/K1LGUE

TP02

TP03

TP04TP05

3

TP01

TNPA5158

PbF

SEE REVERSE FOR ORDER NO.

CR25

RM10

K1

TNPA4858AB

TNPA4858

SEE REVERSE

FOR ORDER NO.

SW2500

PbF

S

1

S1

1331

S-BOARD (COMPONENT SIDE)

K-BOARD (COMPONENT SIDE)

2

TXN/K1LGUE

RM10

PbF

R25

D01

C11

C10 R12

R11

R10

CR25

R13

D11

TNPA5158

Q10

R19

C15

D20

R16

1K

ORDER NO.

D12

Q11

Q12

C12

K1

R14

C14

1

R15

5

C13

R18

R17

TNPA4858AB

TNPA4858

ORDER NO.

S

131

1

PbF

3

SW2500

S1

1

ABCDEFGH I

80

14.3. A-Board

6

A-BOARD (FOIL SIDE) A-P37C2B A-P37C2E A-PR37C2

TP9104

TP9102

TP9101

TP9103

TP9082

TP9092

TP9087

TP9094

TP9084

TP9086

TP9089

TP9088

TP9081

TP9083

TP9085

TP9091

TP9093

TP9090

TP9095

C9103

TD9102

TD9103

TD9104

TD9105

TP9203

R9888

R9198

C9102

TD9130

C9100

R9876

TD9099

Q9802

R5475

Q5603

TP8402

1

R8468

R8469 R8483 R8484

JS8365

Q9802

R9899

C9116

C5004

C9807

R9884

Q9803

R9881

Q9800

C9824

R9920

R9117

Q9002

R9116

R9885

R9111

D9808

R9040

D9807

C9818

D5482

D5478

D5481

D5471

R5476

Q5602

TD8701

Q5602

TD8700

Q5603

VJ8520

R8515

R8428

64

VJ8000

TD8423

TD8424

C8363

JS8367

SW5151

R9874

R9108

R9896

R9880

Q9803

C9802

R9106

C5001

C9801

R9883

Q9801

Q9800

Q9801

R9882

C5002

32

C9816

R9113

Q9003

Q9002

Q9003

R9114

R9112

1

R5000

C5157

IC9802

R9891

C5158

C5051

C5159

1

5

C5160

C9819

R9890

C9817

C9821

C9820

C9822

R2752

TP2751

TP2756

TP2757

TP2760

TP5150

TP1100

TP2758TP2759

JK8940

TP8401

R8425

R8426

R8464

49

R8462

R8463

R8411

L8401

R8447

R8449

C8407

R8414

TD8512

JK8940

IC8400

TD8403

33

TD8402

TD8426

TD8427

17

R8404

R8406

R8409

R8511

R8394

R8393

JS8368

JS8360

JS8361

R8368

R8369

R8361

R8360

R8362

R8363

VJ8397

JS8362

JS8363

SW5152

C9803

C9806

R9872

R9873

R9875

TP5001

R5001

C5055

17

C9401

R5488

IC5000

D5475

D5477

R5065

IC5000

C5057

C5155

C5058

C5156

R5067

D5051

D5052

TP2750

TP5000

R9104

R9103

TP9202

TP9201

R0980

Q9013

R0982

R0983

R0984

R0985

R1207

TP1101

R8413

R8416

R8448 R8445

R8465

IC8400

VJ8001

JS8369

R2882

D5476

C9400

IC8950

D5100

Q5472

C8950

R8950

R5105

Q5101

IC8921

IC9304

R5487

R5486

C9300

1

Q5472

R9309

R9308

TD9334

R5485

IC9304

R5474

TP5471

C5472

TP9105

C5611

L5603

PA5610

1

R8952

IC8950

8

R5493

D5485

D5480

R5494

D5486

Q5100

C5101

R5103

R5102

R5101

R5108

Q5101

R5110

C5100

R5106

R5104

R4009

R4002

R4007

R4000

1

2

35

36

C8922

48

IC8921 IC8921-A

1

C8923

R8927

R8930

R8925

R8923

SW5154

R2883

16

R5479

R5480

R5066

L5000

R5481

R5482

D5472

C5059

R5472

C5471

R5061

Q5471

R5471

Q5471

TD9132 TD9133

4

TP2752

TP8950

TP2753

R0978

R0979

TP2754

TP2755

TP8951

5

R0981

TP8952

R9055

R9057 R9056

Q9012

Q9013

Q9012

R5100

R8436

VJ8516

C8414

R8466

SW5153

5

TD9056

IC9802

R9039

C9106

4

TPS15V

3

2

TP8346

TP8354

TP8352

TP8350

A88

A88A

TP8348

TP8343

TP8341

ZA1000

1

TP5409

TPF15V

TP9196

C5723

D5620

C5722

IC5401

TP2810

TP2824

TP2820

TP2821

TP8344

TP8345

TP8353

TP8351

TP8349

TP8347

TP8342

TP8406

TP8404

R5490

R5489

C2872

R2875

TP2871

TP2870

C5616

R5608

R5600

R5613

R5607

R5612

R5609

C5615

R5610 R5611

D5602

TP8400

TP2825

TP2822

TPS0N

R9145

TD9052

TPEC0

TP2805

TP2823

R9120

TP8403

R9191

R9190

TPST5

33

34

67

68

VJ8519

R8437

R8457

R8467

C8404

C8413

C8409

C8403

VJ8513

R8429

TD8400

R8487

R8471

R8418

R8341

R8349

R8350

R8342

R8343

R8351

R8340

R8476

R8346

R8344

C8343

TP8405

TP8340

JS8364

R8364

R8365

R8367

R8366

JS8366

F+/ -/ TV AV

R2880 R2881

SW5150

SW5150 SW5151 SW5152 SW5153 SW5154

TP9138

TP9136

TP9135

TP9904

TP9903

TP9902

TP9901

TP9900

58

4

R9306

R9307

TP9107

TP9108

TP9106

TP9110

TP9109

TD9024

TD9310

C5609

R5631

R5605

C5602

13

C5612

IC5600

C5607

24

R5606

R5628

C5608

R1179

R1186 R1185

R1188

TP1501

25

C8807

C8821

L8800

R8814 R8812

R8808

C8815

C8814

C8816

C8822

C8813

R8929

R8924

R8926

24

R8928

TP9152

TP9142

TP9144

TP9146

TP9148

TP9154

TP9153

TP9141

TP9143

TP9145

TP9147

TP9137

TP9151

TP9194

TP9197

TP9193

TP9195

TP9149

TP9140

TP9150

TP9139

R9326

C9379

C9380

C9387

C9386

C9378

R9324

C9391

C9327

C9338

C9331

L9300

C9319

C9320

C9337

C9332

L9302

TD9328

C9358

C9345

TD9330

R9341

C9349

TD9331

C9372

TD9332

C9344

TP9383

C9350

TD9382 TD9381

C9357

C9352

TD9380

C9367

TD9379

C9321

C9309

C9356

C9335

C9330

C9343

C9307

C9322

TP9113

C9397

C9355

TD9138

C9368

C9364

TP9076

C9354

TD9324

TD9323

12

C5606

IC5600

L9301

C9374

C9376

C9366

C9371

TP9301

TD9022

R5601

C5639

R5603

R5646

R5645

1

R5604

R5602

C5638

D5483

R5637

R5491

TP5600

D5601

R5492

D5484

R5636

TP5601

D5600

R9042

Q9010

Q9011

R9051

R9052

R9053

R9203

R9054

TD9002

TD9023

R9322

R5617

R5616

JK8800

1

7

8

2

7

12

R8832 R8833

T8302

R8835

R8834

1

C8827

C8826

R8205

R8201

R8203

R8200

R8202

C8201

C8208 C8200

L8200

6

A 2

C8808

C8809

C8819

C8810

L8802

C8818

L8801

C8817

R8809

R8816

C8811

R8822

TD8802

TNPH0829

SEE REVERSE FOR ORDER NO.

PbF

R8880

JK8801

4

JK8801

TP8854

TP8862

C8854

R8869

R8879

1

TP8853

TP9162

TP9161

C9381 C9382

C9388

C9315

C9316

C9339

C9346

VJ9302

C9310

C9348

C9342

C9308

C9363

C9395

Q9005

D5479

TP8600

R8669 C8600

VJ8601

Q9011

R9030

R0901

TD0901

R0909 R0914

C8202

C8205

C8206

R8204

R8206

C8207

CN8700

R5154

TP8850

TP8855

C8856

R8876

R8877

TP9157

TP9010

TP9158

TP9172

TP9171

R9327

C9389

C9329

C9323

C9328

C9334

VJ9301

C9314

C9313

C9311

C9312

VJ9300

C9317 C9340

C9347

C9341

C9353

C9351

C9336

C9333

C9325

C9318

C9362

C9396

C9370

C9377

C9375

TP9114

R9034

R9101

D9806

R9110

TD9027

R9105 R9036

Q9005

Q9001

R9037

R0940

R0948

R0949

R0952

R0953

R8617

R8210 R8209

R8648

R8670

R8650

R8618

R8661

R8630

R8640

L8850

R8893

TP8856

TP8857

C8857

R8878

R8871

R8873

TP9173

TP9159

TP9160

TP9206

R9325

C9324

C9384

C9326

C9359

TD9329 TD9327

C9360

C9361

C9365

R9123

TP9112

Q9001

R9115

R9102

R0941

VJ8600

R8658

R8647 R8659 R8615 R8608 R8616

R8890

C8860

C8859

R8867

JK8850

TP9176

TP9163

TP9165

TP9167

TP9169

TP9170

TP9168

TP9175

TP9164

TP9166

TP9174

TP9198

TP9199

TP9205

R9610

C9383

C9385

C9390

C9392

C9369

C9373

TD9347

TD9350

TD9348

TD9349

TD9384

TD9351

TD9346

TD9345

TD9344

TD9343

TD9342

TP9100

R9323

TP9300

C9303

R9035

R9342

C9393

C9394

TD9376

R9099

TD9378

R9122

R9109

TP9111

Q9000

R9100

R1519

R0911

R0906

D1501

R1520

R0912

R0905

TD0905

R0913

R1518

R0907

TD0904

C0900

C1500

TD0902 TD0903

R3210

R3213

L8003

L8016

FL2301

R1180

R8857

R8863

R4003

C8871

TP8858

R8872

C8858

R3214

C8109

R8006

C8100

C8107

R8005

R8007

C8056

C8105

C8106

C8047

R8032

C8002

C8108

C8102

C8046

C8103

L8000

C8003

R8010

R8018

R8009 R8019

R1176

C9052

C8101

C8110

C1100

L8005

L8014

R8858

C8052

L8025

R8864

C8001

L8024

C8000 C8050

L8018

R4004

C8057

R8505

L8019

VJ8517

R8824

R8508 R8507

C8038

C8042

R8506 R8626

R1562

R1501

TD9326

TD8514

R8489

R8493

R8633

R8649

R8609

JK4700 JK4701

R8889

TP8861

1

C8873

C8874

C8872

L8870

R8892

C8875

R8891

4

IC8852

TP8859

TP8860

TP8863

C8855

R8874

R8875

R9907

TP9912

TP9914

TP9910

TP9909

TP9908

TP9905

TP9906

TP9907

TP9911

R9609

C5632

R5622

24

C5634

IC5601

R5635

IC5601

R5627

1

C5653

C5627

R5647

R5620

R5618

R5638

D5604

TP5602

TP3102

TP3103

R3211 R0910 R0904

TD0906

L8002

L8001

C8044

C8036

C8034

R8031

C8026

R8020

R8021

C8087

C8051

C8084

C8083

C8027

C8049

R8008

R8014

C8119

C8118

L8015

C8043

L8020

C8055

L8021

C8053

C8039

C8094

C8040

C8054

C8029

C8041

C8111

C8112

C8024

C8071

C8030

C8104

C8099

C8078

C8031

C8072

C8048

C8032

C8020

C8120

C8021

C8033

C8028

C8095

C8063

C8093

C8096

C8121

C8126

C8097

C8098

C8122

C8062

C8070

C8068

C8092

C8069

C8058

C8076

C8037

C8035

C8067

C8025

L8004

C8091

L8017

L8009

C8125

R5155

VJ8602

TP8601

R8610

R4740

R4744

R4746

R4750

R8622

R8645

R8644

R8607

R8643

R8671

C4700 R4707

R4706

R4712

R4763

Q4701

R4701

Q4701

D4702

D4704

D4705

D4706

R4711

L4702

D4707

R4709

D4708

R4710

D8802

7

C8877

C8876

IC8852

5

D4737

R4726

R4735

D4738

R4736

D4741

L4708

JK4702

TP2878

TD9900

TP9913

C5635

C5631

R5623

13

C5633

R5639

R5626

12

C5654

R5648

R5621

R5619

R5634

D5603

TP5603

R3207

D3129

D3123

R3208

D3130

D3124

TP4012

TP4018

TP4013

TP4019

TP4014

TP4015

TP4016

R4006

C8088

C8089

C8090

R4005

C8086

C8085

L8013

L8012

C8075

L8011

C8077

R8011

C8065

C8023

C8066

C2070

C8064

L8023

C8005

L8008

C8073

C8004

C8010

L8022

C8074

C8019

C8117

C8014

C8009

C8007

C8115

C8116

C8012

C8008

C8013

C8124

L8010

C8114

C8006

C8011

C8123

C8017

Q2101

C8113

C8022

C4671

R4677

R4679

R4743

R4745

R4747

R4748

R4749

R4741

R4742

R4751

R4705

R4704

R4765

R4738

D4739

D4740

TP2873 TP2874

TP2876

TP2879

TP2875

C2888

TP2302

C2350

R2319

TP2301

TP2877

C2354

TP2304

C2322

C2311

R2322

L2301

Q2301

C3168

R3197

C3169

R3198

TP4020

TP4022

TP4021

TP4023

R0943

L8007

TP4017

R0942

R8002

C8016

C8127

C8045

R8600

R0956

VJ8603

TP0940

R0957

C2068

C2067

TP2251

C2069

L2103

C2108

C2107

R2107

C2103

R2106

C2102

R2139

L2101

R2105

R2104

Q2101

R2102

R2110

R2135

R2140

C2110

R4676 TD3001

C4679

Q4512

C4546

R4550

R4560

R4549

C4550

R4551

R4725

R4552

D4723

D4722

C4547

R4553

D4724

D4725

L4705

R4723

IC2951

C2953

1

C2954

3

TP2950

L2952

C2955

TP2952

C2348

C2343

C2334

R2318

C2342

C2335

C2336

C2340

D3300

C2341

L2303

L2304

C2352

R2315

R2314

C2326

C2327

TP2303

C2328

C2329

C2310

R2323

D2014

C2309

R2309

C2302

Q2301

R2308 R2307 C2301

TP2008

C8015

R8003

IC3001

R2310

R3020

L3001

1

3

IC3001

4

R3018

C3032

R3017

5

R3149

C3121

D3110

C3120

D3111

R3137

JS3105

R3129

TP8730

AUDIOOUT

TP3000

26

C3003

R0959

TP3003

R0958

R3002

TP3001

TP3004

R3007

R3019

TP3002

R3006

TP3005

C3031

C3019

TP3006

R3148

C3018

C3119

51

R3130

C3160

R3128

JS3106

AUDIOIN

C3122

C3161

R3195

R3201

R3199

JS3107

D3126

C3159

R3194

C3162

Q3105

15

10

5

C3011

R3157

R3013

R3014

C3129

C3026

C3132

C3131

1

IC3000

JK3100

JK3100BJK3100C

IC3000

R3177

C3015

C3111

C3152

C3112

C3149

C3150

C3151

R3120

R3173

C3143

C3144

C3141

C3142

R3162

Q3101

Q3104

Q3105

C3134

R3170

R3191

R3190

TP3100

Q3101

11

6

JK3304

1

JK3304

C3025

R3123

R3127

100

C3165

C3163

R3192

C3164

C3126

C3127

R3154

C3128

C3004

C3123

76

C3001

R3152

C3010

D3112

C3009 C3008

L3107

C3007

R3144

C3157

C3158

R3145

Q3100

L3109

R3169

R3161

C3133

L3110

JK3100

Q3100

Q3104

A21A20

A2 A1

R2260

Q2102

R2263

R2264

C2106

R2261 R2109

Q2255

C2105

Q2102

R2108

C2104

L2102

TD2026

JK3302

Q2255

C2952

4

C2959

C2961

IC2952

C2904

C2907

5

R2959

C2906

1

TP2951

TU2901

+BACTIVEANTENNA

B21B20

3

R2956

BB

IC2950

C2950

6

IC2950

1

C2963

C2956

R2957

L2905

C2951

BTMONITOR

RFAGCMONITOR

C2910

R2902

R2101

R4555

R4556

R4548

R4554

Q4513

Q4703

R4713

R4764

D4721

Q4703

R4718

R4719 C4703

R4717

D4719

R4721

R4720

Q4702

R4724

C4705

R4722

Q4702

C2958

R2910

C2905

IC2951

45

D2950

V

JK3107A

JK3107

C8311

L8300

L2950

R0973

4

R2923

TU2901 TU2901ATU2901BTU2901CTU2901D TU2901E

R0966

R0972

3

Q2903

R2922

R2908 L2909 C2913 C2914

AUDIOOUT

L

Q2904

IC8301

3

1

3

L8304

R0967

SIFOUT

1

C8313

C8320

Q2904

Q2903

R2921 L2910

TP8301

IC8302

VJ8300

L8302

C8304

VB1

+B

VB

IC8301

IC8302

R8310 C8327

L2906 C2921

JK3302

JK3302A

5

C8312

4 5

C8321

4

TD8312

C8319

C8308

C8317

C8322

R8302

X8300

R8320

C8305

R2926 R2905

C2908

C2909

VIDEOOUT

TP8300

L8301

C8309

37

C8324

C2915

SCL

C8328

R8322

C8323

C8310

25

L8305

C8302

C8325

R8315

R8316

C8301

C8303

R2906 C2912

SDA

R

R8300

R8323

13

IC8300

TD8313

48

C8315

C8318

C8316

L8303

D8300

C2901

R2900

IFAGC

VB2

SW1VBSW2

AFTOUT

TP3101

C8300 R8301

R8325 R8324

RESET

+B

B1

B2

C8314

TD8300

C8306

C8307

R8303

IC8300

R8306

TD8311

R8305 R8304

R8321

R8309

1

R8326 R8327

R8311

R8313

C8326

IFDOUT2

IFDOUT1

IFDOUT2

IFDOUT1

IFDOUT2

IFDOUT1

IFMONITOR

SW001

ZA1001

A

ABCDEFGH I

81

6

A-BOARD (COMPONENT SIDE) A-P37C2B A-P37C2E A-PR37C2

C2880

C2355

C2339

C2320

C2321 C2323

R5500

C5650

IC5603

R5641

C5649

C4704

19

IC2953

JK3107

JK3107A

R2878

C2346 C2347

R5501

R4716

R2879 C2879

L2306

C2055

Q2109

R2103

4

3

R5640

R4754

L4703

R4715

D4718

C2964

34

A1

R2317

C2324

22

R8667

R8638

X8000

R2138

C2119 R2121

R4667

R4673

C4667

R4671

R4669

L4704

C2965

IC2953

C2966

R2966

A1

L2302

C2333

C2332

C2325

23

THERMAL PAD

IC2301

C2356

C2357

C2312

VJ8360

R8636

R8396

R8635

R8634

R1504

R8004

C2057

R2053

C8079

R8015

C8081

R8000

Q2109

C4661

C4660

R4666

R4672

C4666

R4670

C4665

C4664

R4668

C4662

C4663

R4755

D4726

D4728

D4727

1

5

R2055

R2312

R2313

R1502

D4729

Q4704

18

A32

TD9901

TD9902

55

FL9901

VJ9900

C2303

C2304

C2305

C2306

C2307

C2308

L5606

C5636

C5625

C5629

Q5604

D5609

C5658

L5605

C5659

C5660

TD9118

TD9119

TD9120

TD9121

TD9122

TD9123

TD9124

TD9125

TD9126

TD9127

TD9128

TD9129

1

A

IC8001

D4730

D4732

D4731

Q4700

D4733

1

19

Q4705

R4733 C4706

Q4705

R4732

R4767

R4766

R4730

R4731

R4756

R4757

Q4704

R4734

D4742

L4706

L4707

D4743

C4708

R4729

D4735

R4737

R4728

D4734

C4707

JK4702

19

JK4702

A32

VJ9901

FL9902

C5637

C5626

C5628

Q5605

D5608

C5643

L5604

C5642

C5641

R0900

R5153

R0903

TD0900

R1160

IC8001

R8625

R8656

R8624

R1187

R8655

D1101

R4753

R4752

C4702

L4700

L4701

Q4700

D4709

R4708

D4701

R4702

R4703 C4701

C9302

R9320

Q5605

TD9321

X9300

R9321

TD9322

C9301

TD9396

TD9397

TD9398

TD9389

TD9390

TD9395

TD9385

TD9386

TD9016

R4010

TD9377

R9125

R4011

C9304

R0902

R1181

C1101

C1501

R1521

R8492

R8494

R8497

R8499

R8496

R8495

R8620

R8623

R8621

R8919

R8918

D4711

D4713

D4715

D4712

D4714

D4716

D4710

1

JK4700

JK4700JK4701

D4750

R4739

R5643

IC8850

5

1

C5651

C5652

R5644

IC5604

R5642

4

3

IC5604

9

JK8850

D4744

D4746

D4748

D4745

D4747

D4749

1

C3117

C3118

C3116

D3105R3101

C3104

FL3101

FL3102

FL3100

R3104

R3225 R3226

R3103

R3105

D3109

R3224

D3107

D3108

11

6

JK3304

1

5

R3185

C3154

L3120

R3184

C3153

L3119

R3186

C3155

R3131

D3114

JS3110

L3117

C3156

R3187

D3115

JK3100

Q5051

C5050

R5050

R5051

Q5051

R3171

R3172

R5052

Q3102

Q3103

C3136

L3111

L3112

C3135

R3163

4

R3164

Q3103

R3138

L3118

R3222

JS3109

D3116

R3221

L3121

D3131

JS3102

R3139

D3121 D3122

R3182

JS3101

R3132

R3183

JS3112

R3140

R3133

R3181

JS3103

D3120

A1

R2255 R8016

R2254

R2256

Q2252

R2257

Q2254

R2258

R2259

Q2254

Q2253

C2073

C2074

R2069

R2070

Q2253

R2067R2068

R2066

3

R2065

C2072

C2071

L3127

R3126

L3226

R3302

A2

D3119

JS3108

R3143

R3136

B1

B2

R3300

R3204

L3113

C3139

R3168

D3128

R3206

R3167

L3116

C3140

L3125

2

R3114

R3111 C3109

C3108 L3102

L3103

C3101

C3102

4

1

R0951

R0950

IC1000

R2753

5

8

C2750

C2751

ZA1001

SW001

C2918

R2901

1

D3106

R3102

C3103 R3301

15

5

R3117

C3113

JK3100BJK3100C

JK3100

R3212

R3004

R3005

C3013

C3014

R3166

L3115

C3138 L3124

JK3304

FL3105

FL3106

R3303

R3227

R3228

D3300

D3103

TD3100

10

R3108

R3217

C3100

C3130

R3153

AUDIOOUT

R3151

C3024

C3125

R3012

R3150

R8733

C3124

C3016

R3000

R3003

AUDIOIN

C3146

C3145

C3148

C3147

R3209

R3205

D3125

R3165

R3203

C3137 L3114

C3167

A11

1

4

A11

C2351

C2349

D3300

C2345

C2353

C2337

C2344

C2338

R2320 R2321

C2331

L2305

C2315

C2330

C3002

C2313

C2314

C2317

R2316

44

C2316

C2318

IC2301

R4663

R2330

R4659

R2332

R4651

1

R4655

R3001

R2304 R2331

L3000

C3020

C3021

C3022

C3023

R3008

R3009

R3011

R3010

A21

JK3302

A20

D3117

JK3302

JK3302A

R3135

R3142

D3118

C3166

JS3113

R2918

R2917

L2900

L2901

R2903

R2907

R2911

R2904

R2914

C2919

C2903

Q2902

R2919

L2908

C2920

Q2902

R3107 C3106 L3101

R

JS3114

R3141

R3134

B21

IC5603

5

B20

L3108

R3147

R3200

R3202

R3146

D3127

D3113

JS3100

TU2901TU2901ATU2901B TU2901CTU2901DTU2901E

R2909

R2913

R2915

C2967

R2954

R2960

L2904

R2955

R2958

L2903

C2911

R2920

Q2901

Q2950

Q2901

C2922

R3106 C3105

L

L3100

JK3107

1

L5608

JK4701

TU2901

D2951

C2916

R2953

C2917

C2960

L3104

R3109

R3125

R3110

D3102

V

Q9900

TD9905

C9900

R9903

R9904

Q9900

TD9904

R9906

Q9901

VJ9902

TD9903

R9905

Q9901

1

R8017

R8001

X8001

C8082

R1559

R1505

R2302

R2301

R8862

R8859

R8498

R8501

R8642

R8509

R8619

R8660

R2816

R8490

TD8513 TD8516

R8491

TD8515

R8488

R8900

R1563

R8917

R1564

R8665

R8666 R8652 R8653

R8856

R8888

C8851

3

4

D5605

C8863

C8862 C8861

JK8850

FL9900

IC9300

R9339

R9340

TD9112

TD9101

TD9108

TD9110

TD9114

TD9116

TD9111

TD9113

TD9115

TD9117

TD9109

TD9107

C5622

C5621

C5618

C5619

R5151

C8080

R1503

R8860

R8861

R0944

R0945

R8510

R8641

R8614

R8631

R8632

R8627

R8628

R8646

R8629

R1550

R8639

R8212

R8211

R8606

IC8200

R8207

R8208

TD8202TD8203

9

TD8201 TD8200

IC8200

16

C8204

X8200

R8920

1

31

CN8700

TD8702

TD8705

R8664

TD8707

R8700

60

Q8850

R8855

R8850

Q8850

C8850

1

R8851

R8852 R8853

IC8850

5

C8852

R8854

81

10

R8836

TNPH0829

8

1

ORDER

C8203

NO.

CN8700

R8883

R8884

30

2

A

R8866

R8870 C8853 R8868

JK8800

7

8

12

X8800

PbF

C8866

C8868

C8869

C8870

R8894

FL8800

D8801

D8800

1

40

A

1

L5600

C5620

C5617

L5601

JK8800

L8804

1

C8803 C8804

15

R8811 C8802 R8819 R8801 R8806 C8801

29

THERMAL PAD

5

R8881

8

JK8801

TD9372

TD9369

TD9366

TD9364

TD9361

TD9358

R9038

C8825

R8804R8805

R8885 R8886

R8820

IC8851

4

TD9354

TD9371

TD9368

TD9375

TD9363

TD9360

TD9357

TD9026 TD9134

TD9137

R9318

Q9006

D5607

D5606

2

T8800

TD8800 TD8801

R8821

IC8800

IC8851

C8867

L8851

IC9300

TD9355

TD9370

TD9367

TD9365

TD9362

TD9359

TD9136

Q9006

Q5600

C8824

C8805

R8803

R8815

TD9356

TD9352

TD9353

TD9135

L8803

C8823

R8810

IC8800

C8812

A31

R9608

1

R9401

TD9374

TD9373

10

1

R9400

10

10 1

CN7

TD9340

TD9309

TD9311

TD9313

R9334

R9336

TD9314

TD9312

R9335

Q5601

C5601

C5603

Q5601

C5614

Q5600

C5613

C5600

C5604

Q4022

R8837

R4027

Q4022

R4026

R4025

R4028

Q4023

R4020

Q4023

1

7

R8831

R8830

C8828

6

C8806

R8800

1

56

43

C8820

R8813

4

C8865

C8864

1

JK8801

A31

1

IC9401

IC9400

TD9341

TD9337

TD9339

TD9336

TD9335

TD9338

C5610

L5602

30

1

D9800

L9800

C9800

10

C9825

C9826

R9107

R9166

C9117

1120

IC9400IC9401

20

11

C5052

CN7

R5473

R5008

R5006

TD9025

Q5000

R5007

Q5000

D1012

R2750

D1013

D1014

D1015

D1016

D1008

D1009

D1010

C9805

C9804

IC9800

TD9098

TD9131

TD9055

C5000

C5003

D5000

111

CN0102

A20

R9209

20

IC9800

11

TD9057

C9814

R5005

C9815

C9066

R9014

D1011

1

CN0102

19

CN8702

R9031

R9205

R9206

R9058

C9040

R1552

R1178

D1100

R1554

R1177

R1200

Q4020

R1100

12

TD9325

R4029

R4001

1

R4008

Q4020

35

R4023

Q4021

R4024

R4021

R4022

L8920

20

TD9097

CN1102

R1201

R1202

R1203

R1204

R1205

R1206

CN1102

19

R1105

R1108

R1101

R1106

R1109

R1103

R1104

R1102

R1107

IC1100

Q4021

2

36

JK8940

R8451

R8421

R8922

R8397

IC5150

R1183

R0986

R0987

R1182

C1102

5

8

R0954

R0955

IC1100

R0968

R0969

4

1

R0970

R0971

C8412

IC8401

R8452 R8453

R8419

R8417

JK8940

C8401

R8456

R8512

R8513

R8514

JS8375

JS8377

R8375

R8384

R8385

R8387

1

R8395

8

IC8362

JS8370

R8370

9

R8392

R8386

C8362

JS8392

C9101

TD9100

R9208

L9801

D9804

1

4

R9016

C9067

IC9801

R9878

C9808

R9877

C9810

C9811

R9879

5

C9809

CN0101

2

CN0101

20

41

CN8702

R5158

C5150

R5159 C5153

R5152

34

1

IC5150

5

C5151

C5152

C8411

R8450

R8481

R8422

33

TD8408

C8405

TD8409

TD8410

49

R8427

C8406

VJ8511 VJ8512

L8400

R8454

R8455

C8402

R8415

R8401

R8400

C8400

R8485

C8415

R8500

JS8371

JS8372 JS8373

R8371

R8372

R8376

R8377

8

IC8362

IC8360

16

9

R8379

R8389

R8378

R8388

C8360

JS8389

JS8388

8

R2751

TD8406

IC8401

1

IC8360

C9813

IC9801

TD8405

TD8411

R8479 R8482 R8477

8

16

9

1

C9812

Q8401

R8420

A20

A

11 1

C2884

L2871

C2883

L2870

C2873

D2870

4

C2874

C2875

C2876

D2871

5

R2873

C2882

R2872

R8433

TD8401

5

C8410

R8441

IC8402

Q8401

C8408

1

R8440

R8434

R8439

R8435

Q8400

33

34

67

68

TD8407

17

TD8412

R8423

TD8413

TD8414

TD8415

TD8416

1

VJ8518

VJ8514

R8480

64

R8438

JS8374

R8373

R8374

R8381

R8380

1

IC8361

16

R8390

R8391

R8382

R8383

C8361

JS8391

JS8390

A6 A7

C9114

C9108

A6

R2884

L2872

C2885

C2886

1

C2870

C2871

IC2870

R2874

8

R2870

R2871

C2881

C2877

C2878

IC8402

R8470

4

3

VJ8515

R8431

R8432

Q8400

R8424

14

R2823 R2824

R1556

R2822

R2820

C2824

1

A7

A88

30

R8347

R8348

A88A

A88

R0977 R0976

L8340

C8341

C8342

1

L8341

L8343

L8342

C8340

ZA1000

ABCDEFGH I

82

14.4. C1-Board

6

5

C1

C1-BOARD (FOIL SIDE)

4

3

TXNC111EFK

TNPA5073

1C1

SEE REVERSE FOR ORDER NO.

CMM11

PbF

2 3

1

C1-BOARD (COMPONENT SIDE) TXNC111EFK

IC101

R124

R125

R107

C107

C118

CB1

CMM11

R101

1

C104

C116

C101

R102

C109 C110

R103

R112

55

R114

CB2

1

C105

R106

R104R105

C102

C117

R108

R116

55

R117

ZA102

C103

CB3

R119

1

R118

2

R131

C115

10

11

20

C113

R109

R110

C120 R126 C121

1

C122

R127

C114

R132

C111

55

40

C11

1

R130

ZA103

FL102

TNPA5073

ORDER

NO.

CB4

1

C108

C106

C119

1

CR NO.17

C1

ZA104

20

R128

R111

R113

R115

PbF

C112

R120

R129

55

1

R121

C10

1

ABCDEFGH I

83

14.5. C2-Board

6

5

C2-BOARD (FOIL SIDE)

4

TXNC211EFK

C2

CMM21

PbF

TNPA5074

SEE REVERSE FOR ORDER NO.

1C2

2

3

1

3

C2-BOARD (COMPONENT SIDE) TXNC211EFK

IC202

C207

1011

R204

1

ZA201

R233

C227

C226

C225

R203

R232

C206

55

2

1

C20

1 1

1

20

ZA202

C204 C205

R206

C208

R205

C221

R207

R210

R209

20

C211

C210

R213

55

R214

CB5

CB6

FL201

R219

C21

1

C229

R211

C209

R208

C222

C214

20

1

R217

C228

C230

R212

R218

IC203

11

10

C212

55

R215

R216

TNPA5074

ORDER

NO.

1

PbF

C2

CB7

C216

C213

1

R220

C223

C218

R221

R222

55

R227

R228

ZA203

C23

CR NO.17

CB8

16

CMM21

4

C215

C25

C217

R224

R225

R223

C224

1

R230

1

C219

R226

R231

C220

55

1

ABCDEFGH I

84

14.6. SC-Board

6

SC

5

SC-BOARD (FOIL SIDE) TXNSC11EFK

TP62

TP63

2

S3

IC784

TP59

TP60

TP51

TP61

2

1

C462

1

ZA422

C461

SC50

C793

P2

C795

TP94

C842

L698

TP116

TP115

R860

TP95

TP117

TP118

R774

TP125

C791

5

TP58

5

4

PT

IC786

S1

8

1

8

1

ZA411

C460

4

C463

TNPA5062

TP112

TP111

TP114

TP113

3

TP108

TP107

SC3

1

2

5

TP106

TP105

1

SEE REVERSE FOR ORDER NO.

CRNo.16

S

D

Q601

L411

TP93

TP92

Q451

E

C

D481

G

A

K

Q422

SC

1

G

A

2

3

1

C641

PbF

Q421

C

E

G

TP109

TP100

C642

C

K

G

A

TP99

D722

A

E

TP110

A

K

A

D421

ZA412

TP44

TP42

TP43

TP41

9

8

SC46

D641

A

Q621

A

K

C

E

G

C

Q441

Q401

A

G

A

L401

TP91

TP90

K

A

D724

E

1

2

C

E

Q661

E

G

E

Q402

C

D461

K

C

C411

C503

D401

A

K

C412

C413

TP12

C796

C523

A

ZA421

TP79

TP78

SC42

9

8

TP81

TP80

C813

T471

R696

TP96

C691

L851

G

C721

P1

TP13

TP67

C414

TP19

TP70

TP40

TP34

TP52

TP21

TP35

TP39

TP18

TP31

TP7

L400

TP6

TP14

TP10

TP22

TP27

TP20

TP26

TP9

TP33

TP32

SC2

L472

TP30

TP37

TP23

TP74

TP11

TP8

TP24

TP29

TP25

TP2

TP1

1

TP4

3

TP5

TP36

TP16

C563

R838

TP38

TP73

TP28

TP17

ABCDEFGH I

85

SC

6

5

SC-BOARD (COMPONENT SIDE) TXNSC11EFK

G

R441

Q621

Q401

C464

E

C481

E

C441

H.V. DANGER

TNPA5062

ORDER

NO.

A

D641

K

Q441

D441

C727

H.V. DANGER

R633

R615

R634

R605

D602

IC521

R581

R582

D583

C892

Q521

1

D620

R583

R631

C755

8

C684

C602

R584

4

1

C505

C463

C581

R886

R887

R888

PC684

3

R585

5

D765

8

PC603

2

16

C527

ZA411

C756

9

SC3

R619

ZA403

R765

R604

4

D497

1

R684

C521

C583

R522

R521

C582

R588

1

ZA412

R601

S

R617 C608

R609

PbF

R612

D607

D618

C421

R610

C604

D610

1

SC

CRNo.16

Q422

Q601

G

D

R422

C

G

A

D421

K

A

C641

A

C642

R421

Q421

C

E

G

E

L401

ZA402

Q603

D605

R607

Q607

IC581

R586

L411

Q606

C603

R593

R516

R552

R506

R524

C460

D604

Q602

R517

R551

C525

Q551

R553

C492

R451

C491

C451

G

D481

A

K

E

C

Q451

A

K

A

D451

D724

C471

A

K

A

D722

H.V. DANGER

R721

9

1

2

8

D407

Q762

R402

C

G

R681

R621

C754

R401

G

E

C

C411

R512

Q501

C

A

D461

C707

C536

DIP

SC46

E

C522

C503

C685

C524

R761

Q402

R533

C753

R503

R763

R762

G

R511

C504

K

C

D672

D670

E

R666

IC692

R680

C773

A

K

Q663

R685

D401

PC685

A

R769

C401

A

R712 D701

Q701

R717

C413

D503

C501

D534

4

3

IC465

R420

C502

D536

R504

R534

8

1

D522

C523

IC501

R510

R523

R531

R532

Q531

9

16

R417 R502 R418

H.V. DANGER

2 1

R473

8

SC2

D474

D671 C675 R679 R661

R479

1

Q662

D480

C472

Q702

R686

Q815

R822

14

R471

IC490

A

R591

8

R897

C827

R893

D721

D824 D825 R823

R892

1

3

IC563

C721

R899

C564

C691

TP68

7

1

IC724

5

4

R824

ZA404

D411

C724

C666

R891

C490

Q490

C565

TPSOS6

L851

C723

Q810

R664

R416

R411

TPSC1

D664

C664

D662

Q920

D493

R410

D663

R674

R699

Q921

D920

Q671

D494

R497

R694

C665

C662

C796

IC771

R419

R414

PC461

ZA421

Q661

R690

Q670

C414

C771

C535

C661

IC464

Q672

5

G

R665

D667

1

3

4

5

R707

R675

Q675

C412

C772

R501

4

3

1

5

1

R415

C533

ZA422

C462

R930

R774

R932

ZA401

Q930

R860

C842

L698

R870

D712

R751

D790

R931

R938

Q885

TP82

D711 PC896

1

2

C791

R933

R827

Q932

C461

R825

R832

R935

P2

Q816

C864

R783

R750

1

4

TP57

C794

Q931

R937

3

TPVSCN

2

R831 D871

D821

R755

1

R936

R772

R934

R773

R873

2

C857

3

2

D713

8

1

8

1

PC723

D822

C858

C862 R829

4

SC50

C795

C793

S1

3

1

IC786

C861

C863

D874

C566

PT

PC897

2

IC785

C860

1

D728

5

C856

R837

R843

C844

R826

R851

TPSOS7

R753

30

2

IC784

4

5

4

D719

R838

R561

SC42

S3

Q817

1

IC787

R564

R562

R580

C813

P1

R841

D710

R852

D720

3

4

PC722

2

R752

Q876

R563

C563

1

D859

D893

4

3

C843

R789

4

1

D875 R754

SC20

R845

R846

D820

9

8

T471

R746

R747

R742

R928

R920 R921

R493

C859

C854

TPVAD

L472

R787

R587

R568

1

10

IC561

1

C561

10

R844

D492

R566

C891

R804

R849

R692

R691

R695

R565

D473

R474

R495

Q676

D477

IC491

IC471 R472

3

4

R786

D475

R492

D478

C593

20

R696

PC480

R490

R922

R802 R801

L400

11

R927

Q801

R592

IC562

11

IC661

R496

20

R745

R658 D901 R777

R776

C708

R476

R478

R491

R494 R923 R498

R567

C562

4

5

R926

D921

IC773

R785

R590

Q471

D678

R904

D702 R711

1

3

R475

D490

R929

R663

Q818

ABCDEFGH I

86

14.7. SS-Board

6

5

SS

4

SS-BOARD (FOIL SIDE) TXNSS11EFK

113 113113 113 113 113113 113

TP13

TP36

C241

TP27

TP14

TP17

113 113 113 113113 113 113 113

TPSOS8

113

TP16

TP18

TP56

3

TP29

TP26

C105

C106

TP32

TP33

5

SS3

TP72

L014

1

L013

L012

L011

R309

TP73

C193

2

SS52 SS55

TP54

113

TP31

C328

TPVe

L303

PbF

C272

TP7

TP8

TP28

1

4

5

IC304

8

CR No.16

SEE REVERSE FOR ORDER NO.

SS53A SS53B

TP25

C310

C003

1TNPA5072 SS

TP30

4

SS11

1

TP60

TP62

C011

TP61

TP63

TP71

TP2

L103

C018

TP65

TP66

TP70

TPVSUS

TP64

C012

TP67

TP24

TP69

TPSS1

TP68

C023

SS55ASS55B

12 3

1

ABCDEFGH I

87

6

SS

5

4

SS-BOARD (COMPONENT SIDE) TXNSS11EFK

C241

SS23

3

16

C243

R241

D280

R281

R280

TPSOS8

D281

TD37

C280

R284

C286

R285

R289

C244

11

C242

20

IC241

10

1

R242

C281

R283

Q280

R282

D282

D285

C287

R290

C022

C023

EG

R163

Q161

2

1

R132

5

4

R131

R161

R135

R136

16

1

R162

EG

C135

R021R022

Q021Q022

98

IC131

R134

C131

C133

R141

C021

D131

R137

4

5

2

R142

R143

2

C

13113

SS55

SS55A SS55B

SS55A

11 31311 31131

C

1

SSMM1

C104

DIP

Q141

1

ZA002

CR No.16

C102

D021

C002

C012

Q002

R002

G

PbF

C018

C

TPSS1

E

L103

C103

C011

4

SS11

D001

Discharge

TPVSUS

R001

D315

C318

1

C

Q001

C310

C003

C001

E

G

SS53B

1

SS53A

C319

1131

1

R319

R332

IC312

2

3

2

3

D316

C316

C317

ZA001

C272

C328

R334

1

R320

R318

4

R335

R307

1

PC192

4

R330

C315

1

4

IC304

D317

R105

TPVe

L303

8

5

131311 31

13

R116

D192

C195

R309

R110

S

D

11 3131

R102

G

SS52

R195

D195

C193

R191

R104

Q102

R193

Q101

R192

3

PC191

52

D101

S

4

R101

D

1

C105C106

6

D196

C192

C191

5

C198

R109

4

Q191

1

R103

L014

L013

G

L012

L011

D022

C004

C101

SS3

1

13111 313113

1TNPA5072 SS

ORDER

NO.

1

ABCDEFGH I

88

15 Exploded View and Replacement Parts List

15.1. Exploded View and Mechanical Replacement Parts List

15.1.1. Exploded View 1

89

15.1.2. Exploded View 2

90

15.1.3. Packing 1

91

15.1.4. Packing 2

92

15.1.5. Mechanical Replacement Parts List

93

Safety

Ref.

No.

1 K2AHYH000033 AC INLET WITH CABLE 1 PAVCCZ

2 K2CN3YY00006 AC CORD 1 PAVCCZ E/R

2 K2CT3YY00021 AC CORD 1 PAVCCZ B

3 MD37H13C2Z PLASMA DISPLAY PANEL 1 PAVCCZ

4 N2QAYB000487 REMOTE CONTROL 1 PAVCCZ

5 TBLA3689 STAND POLE R 1

6 TBLA3690 STAND POLE L 1

7 TBLX0136 PEDESTAL STAND (SQUARE GB) 1 PAVCCZ

8 TBMA339 PANASONIC SHEET BADGE 1

9 TBX3EA00201 POWER BUTTON 1 PAVCCZ

10 TKGA5608 FRONT GLASS 1 PAVCCZ

11 TKK3EC5002 LED PANEL 1 PAVCCZ

12 TKKL5493 M8 CAP 4

13 TMK0EG012 SPONGE(TKG/UPPER/BOTTOM) 2 PAVCCZ

14 TMK0EG013 SPONGE(TKG/LEFT/RIGHT) 2 PAVCCZ

15 TMW0E910 SP BRACKET L 2 PAVCCZ

16 TMW0E911 SP BRACKET R 2 PAVCCZ

17 TMW3EC002 POWER BUTTON BRACKET 1 PAVCCZ

18 TMXX064 AC CORD CLAMPER A 1

19 TMXX065 AC CORD CLAMPER B 1

20 TMZX5160-1 STAND BRACKET(L) 1

21 TMZX5161-1 STAND BRACKET(R) 1

31 TPC0E69601 CARTON BOX 1 PAVCCZ B/E

31 TPC0EA01401 CARTON BOX 1 PAVCCZ R

32 TPD0E1130 TOP CUSHION 1 PAVCCZ

33 TPD0E2134 BOTTOM CUSHION 1 PAVCCZ

34 TPD0E2135 PEDESTAL CUSHION 1 PAVCCZ

Part No. Part Name & Description Q'ty Remarks

THEJ0339 SCREW (BC-TUNER:1 SIDE_COVER:2) 3

THEL0429 SCREW 2

THEL052Z SCREW (BC TOP:4) 2

THEL079N PF SCREW(5x30) 4

THTD020J SCREW(A-PRINT:4) 4

THTF011N SCREW 9

THTF016J SCREW(SC:6 SS:4 SM:3 K-P:2 K-D:2) 17

THTF016J SCREW(DD:16 C:6) 22

TMM23417 CLAMPER 2

TMME224 CLAMPER 3

TMME292 CLAMPER 1

TMME331 CLAMPER(P:2) 2

TMME332 CLAMPER(SS:1 HANGER:3 AC-INLET METAL:1) 5

TMME332 CLAMPER 2

TMME341 CLAMPER 2

TMME379 CLAMPER 3

94

Safety

Ref.

No.

35 TPDX0016-1 JOINT FOR PEDESTAL 1

36 TPE0E4047 SET BAG 1 PAVCCZ

37 TPE0E9002 ACCESSORIES BAG 1 PAVCCZ

38 TPE0E9003 BAG FOR AC CORD 1 PAVCCZ

39 TPEB341 STAND ACCESSORY BAG 1

40 TPEB423 BAG (PEDESTAL STAND) 1

41 TQB0E0908 INSTRUCTION BOOK(ENGLISH) 1 PAVCCZ B

41 TQB0E0909A INSTRUCTION BOOK(GERMAN) 1 PAVCCZ E

41 TQB0E0909B INSTRUCTION BOOK(DUTCH) 1 PAVCCZ E

41 TQB0E0909C INSTRUCTION BOOK(ITALIAN) 1 PAVCCZ E

41 TQB0E0909D INSTRUCTION BOOK(FRENCH) 1 PAVCCZ E

41 TQB0E0909E INSTRUCTION BOOK(SPANISH) 1 PAVCCZ E

41 TQB0E0909F INSTRUCTION BOOK(SWEDISH) 1 PAVCCZ E

41 TQB0E0909G INSTRUCTION BOOK(NORWEGIAN) 1 PAVCCZ E

41 TQB0E0909H INSTRUCTION BOOK(FINNISH) 1 PAVCCZ E

41 TQB0E0909I INSTRUCTION BOOK(LITHUANIAN) 1 PAVCCZ E

41 TQB0E0909J INSTRUCTION BOOK(PORTUGUESE) 1 PAVCCZ E

41 TQB0E0909K INSTRUCTION BOOK(DANISH) 1 PAVCCZ E

41 TQB0E0909M INSTRUCTION BOOK(BULGARIAN) 1 PAVCCZ E

41 TQB0E0909N INSTRUCTION BOOK(ROMANIAN) 1 PAVCCZ E

41 TQB0E0909O INSTRUCTION BOOK(LATVIAN) 1 PAVCCZ E

41 TQB0E0909P INSTRUCTION BOOK(POLISH) 1 PAVCCZ E

41 TQB0E0909Q INSTRUCTION BOOK(HUNGARIAN) 1 PAVCCZ E

41 TQB0E0909R INSTRUCTION BOOK(CZECH) 1 PAVCCZ E

41 TQB0E0909S INSTRUCTION BOOK(GREEK) 1 PAVCCZ E

41 TQB0E0909T INSTRUCTION BOOK(TURKISH) 1 PAVCCZ E

41 TQB0E0909U INSTRUCTION BOOK(ENGLISH) 1 PAVCCZ E

41 TQB0E0909W INSTRUCTION BOOK(SLOVAKIAN) 1 PAVCCZ E

41 TQB0E0909X INSTRUCTION BOOK(CD-ROM) 1 PAVCCZ E

41 TQB0E0909Z INSTRUCTION BOOK(ESTONIAN) 1 PAVCCZ E

41 TQB0E09119 INSTRUCTION BOOK(KAZAKHATAN) 1 PAVCCZ R

41 TQB0E0911L INSTRUCTION BOOK(RUSSIAN) 1 PAVCCZ R

41 TQB0E0911Y INSTRUCTION BOOK(UKRAINAN) 1 PAVCCZ R

51 TSXL519 CABLE (C10-C20) 1

52 TSXL964 CABLE (A20-SC20) 1 PAVCCZ

53 TSXL965 CABLE (A31-C11) 1 PAVCCZ

54 TSXL966 CABLE (A32-C21) 1 PAVCCZ

61 TTU0E0715 REAR COVER 1 PAVCCZ E

61 TTU0E0719 REAR COVER 1 PAVCCZ R

61 TTU0E0724 REAR COVER 1 PAVCCZ B

62 TUX0E151 37HANGER METAL 2 PAVCCZ

Part No. Part Name & Description Q'ty Remarks

TPG0E9331 PAPER CAP 0.25 PAVCCZ

TQZJ202 SCREW USE HANDBILL 1

95

Safety

Ref.

No.

63 TXFEA01LWUE SPEAKER ASSY 2 PAVCCZ

64 TXFKP01LDUE SIDE TERMINAL COVER ASSY 1 PAVCCZ

65 TXFKY01LDUE CABINET ASSY 1 PAVCCZ

Part No. Part Name & Description Q'ty Remarks

TXJA11LFUE SPEAKER LEAD (A11-SPL/SPR) 1 PAVCCZ

XSB3+6FJ SCREW(HDMI:3) 2

XTB4+12GFJ SCREW(GH:20 PW:2 LED:1) 17

XTB4+12GFJK SCREW(BC:11) 11

XTV3+10JFJK SCREW(REAR AV:2) 2

XTW3+10TFJ SCREW 1

XYN3+F10FJK SCREW(BC-AC_INLET:2) 2

XYN3+F8FJ SCREW(TU:2 AC-INLET METAL:2) 4

XYN3+J10FJ SCREW 15

XYN4+E6FJ SCREW(INLET:1) 1

XYN4+F10FJ SCREW(AL-GHT:4) 18

XYN4+F10FJ SCREW(SM:4) 4

XYN4+F10FJ SCREW(KARI-HANGER METAL:8) 8

XYN5+F18FN SCREW (STAND POLE) 4

XZB17X19C03 POLY BAG (STAND POLE) 1

XZBT6506 POLY BAG (INSTRUCTION BOOK) 1

96

15.2. Electrical Replacement Parts List

15.2.1. Replacement Parts List Notes

97

15.2.2. Electrical Replacement Parts List

Safety Ref. No. Part No. Part Name &

PCB LSEP1287LDHB CIRCUIT BOARD P 1 (RTL)PA

PCB A-P37C2B CIRCUIT BOARD A 1 (RTL)PA

PCB A-P37C2E CIRCUIT BOARD A 1 (RTL)PA

PCB A-PR37C2 CIRCUIT BOARD A 1 (RTL)PA

PCB TNPA4858AB CIRCUIT BOARD S 1 (RTL)

PCB TXN/K1LGUE CIRCUIT BOARD K 1 (RTL)PA

PCB TXNC111EFK CIRCUIT BOARD C1 1 (RTL)PA

PCB TXNC211EFK CIRCUIT BOARD C2 1 (RTL)PA

PCB TXNSC11EFK CIRCUIT BOARD SC 1 (RTL)PA

PCB TXNSM11EFK CIRCUIT BOARD SM 1 PAVCCZ

PCB TXNSS11EFK CIRCUIT BOARD SS 1 (RTL)PA

A1 K1KY08AA0719 8P CONNECTOR 1

A6 K1KY11AA0719 11P CONNECTOR 1 A7 K1KY14AA0719 14P CONNECTOR 1 PAVCCZ A11 K1KA04AA0728 4P CONNECTOR 1

A20 K1MY30BA0345 30P CONNECTOR 1 PAVCCZ A31 K1MY40BA0345 40P CONNECTOR 1 PAVCCZ A32 K1MY55BA0345 55P CONNECTOR 1

C0900 F1G1C104A116 C 0.10UF, K, 16V 1 C1100 F1G1E103A123 C 0.010UF, K,

C1101 F1G1E103A123 C 0.010UF, K,

C1102 F1G1C104A116 C 0.10UF, K, 16V 1 C2055 F1J1A106A087 C 0.010UF, K,

C2057 F1J1A106A087 C 0.010UF, K,

C2071 EEEHB0J101UR C 100PF, J, 6.3V 1

C2072 EEEHB0J101UR C 100PF, J, 6.3V 1 C2073 F1G1E333A091 C 0.033UF, K,

C2074 F1G1E333A091 C 0.033UF, K,

C2104 F1G1H100A731 C 10PF, K, 50V 1 C2107 F1G1A105A047 C 1UF, K, 10V 1 C2108 F1G1A105A047 C 1UF, K, 10V 1

C2110 F1G1C104A116 C 0.10UF, K, 16V 1 C2301 F1G1C104A116 C 0.10UF, K, 16V 1 C2302 F1G1C104A116 C 0.10UF, K, 16V 1

C2304 F1J1E105A231 C 1 UF 25V 1 C2309 F1K1E106A136 C 10UF, Z, 25V 1 C2312 F1K1E106A136 C 10UF, Z, 25V 1

C2313 F1G1H102A730 C 1000UF, 50V 1 C2314 F1J1E105A231 C 1 UF 25V 1 C2316 F1H1H104A970 C 0.1UF, K, 50V 1

C2317 F1J1E105A231 C 1 UF 25V 1 C2318 F1H1H104A970 C 0.1UF, K, 50V 1 C2320 F1J1E105A231 C 1 UF 25V 1

C2321 F1H1H104A970 C 0.1UF, K, 50V 1 C2323 F1H1H104A970 C 0.1UF, K, 50V 1

Description

25V

10V

25V

Pcs Remarks

VCCZ

VCCZ P37C2B

VCCZ P37C2E

VCCZ PR37C2

VCCZ

1

Safety Ref. No. Part No. Part Name &

C2324 F1J1E105A231 C 1 UF 25V 1

C2325 F1G1H102A730 C 1000UF, 50V 1 C2334 F1J1H474A757 C 0.47UF, 50V 1 C2335 F1H1E104A129 C 0.1UF, 25V 1

C2336 F1H1E104A129 C 0.1UF, 25V 1 C2337 F1J1H474A757 C 0.47UF, 50V 1

C2338 F1H1E104A129 C 0.1UF, 25V 1 C2339 F1H1E104A129 C 0.1UF, 25V 1 C2340 F1H1H223A970 C 0.22UF, K, 50V 1

C2341 F1H1H223A970 C 0.22UF, K, 50V 1 C2342 F1H1H223A970 C 0.22UF, K, 50V 1 C2343 F1H1H223A970 C 0.22UF, K, 50V 1

C2344 F1H1H223A970 C 0.22UF, K, 50V 1 C2345 F1H1H223A970 C 0.22UF, K, 50V 1 C2346 F1H1H223A970 C 0.22UF, K, 50V 1

C2347 F1H1H223A970 C 0.22UF, K, 50V 1 C2349 F1G1H102A730 C 1000UF, 50V 1 C2351 F1G1H102A730 C 1000UF, 50V 1

C2353 F1G1H102A730 C 1000UF, 50V 1 C2355 F1G1H102A730 C 1000UF, 50V 1 C2356 F1K1E106A136 C 10UF, Z, 25V 1

C2357 F1K1E106A136 C 10UF, Z, 25V 1 C2510 F1H1H103A970 C 0.001UF, K,

C2511 F1J1A106A087 C 0.010UF, K,

C2515 F1H1H103A970 C 0.001UF, K,

C2751 F1J1E105A231 C 1 UF 25V 1 C2824 F1J1A106A087 C 0.010UF, K,

C2871 F1K1E106A136 C 10UF, Z, 25V 1 C2872 F1G1E103A123 C 0.010UF, K,

C2873 F1J1A106A087 C 0.010UF, K,

C2874 F1J1A106A087 C 0.010UF, K,

C2877 F1H1H223A970 C 0.22UF, K, 50V 1

C2878 F1H1H472A970 C 4700PF, K, 50V 1 C2883 F2H1E470A007 E 47UF, 25V 1 C2884 F1J1E105A231 C 1 UF 25V 1

C2885 F1K1E106A136 C 10UF, Z, 25V 1 C2886 F1K1E106A136 C 10UF, Z, 25V 1 C2905 EEEHB1C101P C 100PF, J, 16V 1

C2907 F1G1C104A116 C 0.10UF, K, 16V 1 C2908 F1G1C104A116 C 0.10UF, K, 16V 1 C2910 F1G1C104A116 C 0.10UF, K, 16V 1

C2911 F1G1C104A116 C 0.10UF, K, 16V 1 C2917 F1G1H222A730 C 2200UF, 50V 1 C2950 ECJ2YB0J475K C 3.3UF, Z, 4.7V 1

C2951 ECJ2YB0J475K C 3.3UF, Z, 4.7V 1 C2959 F1G1C104A116 C 0.10UF, K, 16V 1 C2961 ECJ1VB1A105K C 0.01UF, Z, 10V 1

C2965 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C2966 F1H1A225A051 C 22UF, 50V 1 C3003 F1G1C104A116 C 0.10UF, K, 16V 1

C3004 F1G1C104A116 C 0.10UF, K, 16V 1 C3011 F1J1A106A087 C 0.010UF, K,

C3015 F1J1A106A087 C 0.010UF, K,

C3016 F1G1C104A116 C 0.10UF, K, 16V 1 C3018 F1G1C104A116 C 0.10UF, K, 16V 1 C3019 F1G1C104A116 C 0.10UF, K, 16V 1

C3020 ECJ1VB1A105K C 0.01UF, Z, 10V 1

Description

50V

10V

50V

10V

25V

10V

Pcs Remarks

1

98

Safety Ref. No. Part No. Part Name &

C3021 ECJ1VB1A105K C 0.01UF, Z, 10V 1

C3022 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C3023 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C3024 F1J1A106A087 C 0.010UF, K,

C3025 F1J1A106A087 C 0.010UF, K,

C3026 F1J1A106A087 C 0.010UF, K,

C3031 ECJ1VB1A105K C 0.01UF, Z, 10V 1

C3032 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C3108 F1G1E333A091 C 0.033UF, K,

C3109 F1G1E333A091 C 0.033UF, K,

C3120 EEEHB1C101P C 100PF, J, 16V 1 C3121 EEEHB1C101P C 100PF, J, 16V 1 C3124 F1J1A106A087 C 0.010UF, K,

C3125 F1J1A106A087 C 0.010UF, K,

C3129 F1J1A106A087 C 0.010UF, K,

C3130 F1G1C104A116 C 0.10UF, K, 16V 1

C3131 F1J1A106A087 C 0.010UF, K,

C3132 F1J1A106A087 C 0.010UF, K,

C3135 F1G1H561A730 C 56UF, 50V 1 C3136 F1G1H561A730 C 56UF, 50V 1

C3139 F1G1H561A730 C 56UF, 50V 1 C3140 F1G1H561A730 C 56UF, 50V 1 C3145 F1J1A106A087 C 0.010UF, K,

C3146 F1J1A106A087 C 0.010UF, K,

C3147 F1J1A106A087 C 0.010UF, K,

C3148 F1J1A106A087 C 0.010UF, K,

C3151 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C3152 ECJ1VB1A105K C 0.01UF, Z, 10V 1

C3155 F1G1H561A730 C 56UF, 50V 1 C3156 F1G1H561A730 C 56UF, 50V 1 C3157 ECJ1VB1A105K C 0.01UF, Z, 10V 1

C3158 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C3163 F1J1A106A087 C 0.010UF, K,

C3164 F1J1A106A087 C 0.010UF, K,

C3165 F1J1A106A087 C 0.010UF, K,

C4546 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4547 ECJ1VB0J105K C 1UF, K, 6.3V 1

C4660 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4661 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4662 ECJ1VB0J105K C 1UF, K, 6.3V 1

C4663 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4664 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4665 ECJ1VB0J105K C 1UF, K, 6.3V 1

C4666 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4667 ECJ1VB0J105K C 1UF, K, 6.3V 1 C4701 F1G1C104A116 C 0.10UF, K, 16V 1

C4702 F1G1C104A116 C 0.10UF, K, 16V 1 C4704 F1G1C104A116 C 0.10UF, K, 16V 1 C4705 F1G1C104A116 C 0.10UF, K, 16V 1

C5000 F1G1C104A116 C 0.10UF, K, 16V 1 C5001 F1G1C104A116 C 0.10UF, K, 16V 1

C5002 F1G1C104A116 C 0.10UF, K, 16V 1 C5003 F1G1C104A116 C 0.10UF, K, 16V 1 C5004 F1G1H102A730 C 1000UF, 50V 1

C5050 F1J1A475A087 C 4.7UF, K, 10V 1 C5052 F2G1A221A149 E 220UF, 10V 1 C5055 F1G1C104A116 C 0.10UF, K, 16V 1

C5058 ECJ1VB0J105K C 1UF, K, 6.3V 1 C5100 F1G1C104A116 C 0.10UF, K, 16V 1

Description

10V

25V

10V

Pcs Remarks

1

Safety Ref. No. Part No. Part Name &

C5101 F1H1A474A084 C 0.47UF, 50V 1

C5155 F1J0J106A004 C 0.010UF, K,

C5156 F1J0J106A004 C 0.010UF, K,

C5157 F1J0J106A004 C 0.010UF, K,

C5158 F1J0J106A004 C 0.010UF, K,

C5159 F1J0J106A004 C 0.010UF, K,

C5160 F1J0J106A004 C 0.010UF, K,

C5471 F1G1C104A116 C 0.10UF, K, 16V 1 C5472 F1G1C104A116 C 0.10UF, K, 16V 1

C5600 F1K1E106A136 C 10UF, Z, 25V 1 C5601 F1K1E106A136 C 10UF, Z, 25V 1 C5602 F1G1E682A123 C 6800UF, Z, 25V 1

C5603 F1K1E106A136 C 10UF, Z, 25V 1 C5604 F1K1E106A136 C 10UF, Z, 25V 1 C5606 F1G1A154A053 C0.015UF, K, 10V 1

C5607 F1J1A475A087 C 4.7UF, K, 10V 1 C5608 F1H1C104A143 C 0.1UF, K, 16V 1 C5609 F1H1C104A143 C 0.1UF, K, 16V 1

C5611 F1J1E105A231 C 1 UF 25V 1 C5612 F1H1C105A145 C 0.01UF, K, 16V 1 C5615 F1H1A225A051 C 22UF, 50V 1

C5616 F1G1E103A123 C 0.010UF, K,

C5617 F1K0J226A008 C 22UF, K,6.3V 1

C5618 F1K0J226A008 C 22UF, K,6.3V 1 C5619 F1K0J226A008 C 22UF, K,6.3V 1 C5620 F1K0J226A008 C 22UF, K,6.3V 1

C5621 F1K0J226A008 C 22UF, K,6.3V 1 C5622 F1K0J226A008 C 22UF, K,6.3V 1 C5625 F1K1E106A136 C 10UF, Z, 25V 1

C5626 F1K1E106A136 C 10UF, Z, 25V 1 C5627 F1G1A393A053 C0.015UF, K, 10V 1 C5628 F1K1E106A136 C 10UF, Z, 25V 1

C5629 F1K1E106A136 C 10UF, Z, 25V 1 C5631 F1G1C104A116 C 0.10UF, K, 16V 1 C5632 F1J1A475A087 C 4.7UF, K, 10V 1

C5633 F1H1C104A143 C 0.1UF, K, 16V 1 C5634 F1H1C104A143 C 0.1UF, K, 16V 1 C5635 F1H1C105A145 C 0.01UF, K, 16V 1

C5641 F1K0J226A008 C 22UF, K,6.3V 1 C5642 F1K0J226A008 C 22UF, K,6.3V 1 C5643 F1K0J226A008 C 22UF, K,6.3V 1

C5649 ECJ1VB1A105K C 0.01UF, Z, 10V 1 C5650 F1H1A225A051 C 22UF, 50V 1 C5651 F1J1A475A087 C 4.7UF, K, 10V 1

C5652 F1J1A475A087 C 4.7UF, K, 10V 1 C5658 F1K0J226A008 C 22UF, K,6.3V 1 C5659 F1K0J226A008 C 22UF, K,6.3V 1

C5660 F1K0J226A008 C 22UF, K,6.3V 1 C5722 F1J1E105A231 C 1 UF 25V 1 C5723 F1H1C105A145 C 0.01UF, K, 16V 1

C8000 F1G1C104A116 C 0.10UF, K, 16V 1 C8001 F1G1C104A116 C 0.10UF, K, 16V 1 C8002 F1G1C104A116 C 0.10UF, K, 16V 1

C8003 F1G1C104A116 C 0.10UF, K, 16V 1 C8004 F1G1C104A116 C 0.10UF, K, 16V 1 C8005 F1G1C104A116 C 0.10UF, K, 16V 1

C8006 F1G1C104A116 C 0.10UF, K, 16V 1 C8007 F1G1C104A116 C 0.10UF, K, 16V 1

C8008 F1G1C104A116 C 0.10UF, K, 16V 1 C8009 F1G1C104A116 C 0.10UF, K, 16V 1 C8010 F1G1C104A116 C 0.10UF, K, 16V 1

C8011 F1G1C104A116 C 0.10UF, K, 16V 1 C8012 F1G1C104A116 C 0.10UF, K, 16V 1 C8013 F1G1C104A116 C 0.10UF, K, 16V 1

C8014 F1G1C104A116 C 0.10UF, K, 16V 1 C8015 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8016 ECJ1VB0J105K C 1UF, K, 6.3V 1

Description

16V

25V

Pcs Remarks

1

99

Safety Ref. No. Part No. Part Name &

C8017 F1G1C104A116 C 0.10UF, K, 16V 1

C8019 F1G1C104A116 C 0.10UF, K, 16V 1 C8020 F1G1C104A116 C 0.10UF, K, 16V 1 C8021 F1G1C104A116 C 0.10UF, K, 16V 1

C8022 F1J1A106A087 C 0.010UF, K,

C8023 F1J1A106A087 C 0.010UF, K,

C8024 F1J1A106A087 C 0.010UF, K,

C8035 F1J1A106A087 C 0.010UF, K,

C8036 F1J1A106A087 C 0.010UF, K,

C8037 F1G1C104A116 C 0.10UF, K, 16V 1

C8042 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8044 F1J1A106A087 C 0.010UF, K,

C8045 F1G1C104A116 C 0.10UF, K, 16V 1 C8046 F1G1C104A116 C 0.10UF, K, 16V 1 C8047 F1G1C104A116 C 0.10UF, K, 16V 1

C8048 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8050 F1G1C104A116 C 0.10UF, K, 16V 1 C8051 F1G1C104A116 C 0.10UF, K, 16V 1

C8052 F1G1C104A116 C 0.10UF, K, 16V 1 C8053 F1G1C104A116 C 0.10UF, K, 16V 1 C8054 F1G1C104A116 C 0.10UF, K, 16V 1

C8055 F1G1C104A116 C 0.10UF, K, 16V 1 C8056 F1G1C104A116 C 0.10UF, K, 16V 1 C8057 F1G1C104A116 C 0.10UF, K, 16V 1

C8058 F1G1C104A116 C 0.10UF, K, 16V 1 C8062 F1G1C104A116 C 0.10UF, K, 16V 1 C8063 F1G1C104A116 C 0.10UF, K, 16V 1

C8064 F1J0G2260001 C 0.001UF, 6.3V 1 C8067 F1G1C104A116 C 0.10UF, K, 16V 1 C8068 F1G1C104A116 C 0.10UF, K, 16V 1

C8069 F1G1C104A116 C 0.10UF, K, 16V 1 C8070 F1G1C104A116 C 0.10UF, K, 16V 1 C8073 ECJ1VB0J105K C 1UF, K, 6.3V 1

C8074 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8075 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8076 F1G1C104A116 C 0.10UF, K, 16V 1

C8077 F1G1E103A123 C 0.010UF, K,

C8079 F1G1H120A731 C 12UF, 50V 1

C8080 F1G1H8R0A732 C 8.0UF, 50V 1 C8081 F1G1H100A731 C 10PF, K, 50V 1 C8082 F1G1H8R0A732 C 8.0UF, 50V 1

C8085 F1J1A106A087 C 0.010UF, K,

C8091 F1G1C104A116 C 0.10UF, K, 16V 1

C8093 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8097 F1G1C104A116 C 0.10UF, K, 16V 1 C8099 ECJ1VB0J105K C 1UF, K, 6.3V 1

C8100 F1J1A106A087 C 0.010UF, K,

C8101 F1J1A106A087 C 0.010UF, K,

C8104 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8105 F1G1C104A116 C 0.10UF, K, 16V 1

C8108 F1G1C104A116 C 0.10UF, K, 16V 1 C8110 F1G1C104A116 C 0.10UF, K, 16V 1 C8111 F1G1C104A116 C 0.10UF, K, 16V 1

C8112 F1G1C104A116 C 0.10UF, K, 16V 1 C8113 F1G1C104A116 C 0.10UF, K, 16V 1 C8114 F1G1C104A116 C 0.10UF, K, 16V 1

C8115 F1G1C104A116 C 0.10UF, K, 16V 1 C8116 F1G1C104A116 C 0.10UF, K, 16V 1

C8117 F1G1C104A116 C 0.10UF, K, 16V 1 C8120 F1G1C104A116 C 0.10UF, K, 16V 1 C8123 F1G1C104A116 C 0.10UF, K, 16V 1

C8124 F1J1A106A087 C 0.010UF, K,

C8125 F1J1A106A087 C 0.010UF, K,

Description

10V

25V

10V

Pcs Remarks

1

Safety Ref. No. Part No. Part Name &

C8126 F1J1A106A087 C 0.010UF, K,

C8127 ECJ1VB0J105K C 1UF, K, 6.3V 1 C8300 F1G1C104A116 C 0.10UF, K, 16V 1

C8301 F1G1C104A116 C 0.10UF, K, 16V 1 C8303 F1G1C104A116 C 0.10UF, K, 16V 1 C8304 F1G1H100A731 C 10PF, K, 50V 1

C8305 F1G1H100A731 C 10PF, K, 50V 1 C8306 F1G1C104A116 C 0.10UF, K, 16V 1 C8308 F1G1C104A116 C 0.10UF, K, 16V 1

C8309 F1G1C104A116 C 0.10UF, K, 16V 1 C8310 F1G1C104A116 C 0.10UF, K, 16V 1

C8311 F1J1A106A087 C 0.010UF, K,

C8314 F1G1C104A116 C 0.10UF, K, 16V 1

C8315 F1G1C104A116 C 0.10UF, K, 16V 1 C8316 F1G1C104A116 C 0.10UF, K, 16V 1 C8317 F1G1C104A116 C 0.10UF, K, 16V 1

C8318 F1G1C104A116 C 0.10UF, K, 16V 1 C8319 F1G1C104A116 C 0.10UF, K, 16V 1 C8320 ECJ1VB1A105K C 0.01UF, Z, 10V 1

C8321 F1H1A225A051 C 22UF, 50V 1 C8322 F1G1C104A116 C 0.10UF, K, 16V 1 C8324 F1G1H560A731 C 56UF, 50V 1

C8325 F1G1H560A731 C 56UF, 50V 1 C8400 F1G1C104A116 C 0.10UF, K, 16V 1 C8401 F1G1C104A116 C 0.10UF, K, 16V 1

C8402 F1G1C104A116 C 0.10UF, K, 16V 1 C8403 F1G1C104A116 C 0.10UF, K, 16V 1 C8404 F1G1C104A116 C 0.10UF, K, 16V 1

C8405 F1G1C104A116 C 0.10UF, K, 16V 1 C8406 F1G1C104A116 C 0.10UF, K, 16V 1 C8407 F1G1C104A116 C 0.10UF, K, 16V 1

C8408 F1G1C104A116 C 0.10UF, K, 16V 1 C8409 F1G1C104A116 C 0.10UF, K, 16V 1 C8410 F1G1C104A116 C 0.10UF, K, 16V 1

C8411 EEEHB1C101P C 100PF, J, 16V 1 C8412 F1G1C104A116 C 0.10UF, K, 16V 1 C8413 F1G1E103A123 C 0.010UF, K,

C8414 F1G1E103A123 C 0.010UF, K,

C8415 F1G1C104A116 C 0.10UF, K, 16V 1 C8600 F1G1H102A730 C 1000UF, 50V 1 C8853 F1G1C104A116 C 0.10UF, K, 16V 1

C8854 F1G1C104A116 C 0.10UF, K, 16V 1 C8860 F2G1C470A022 E 47UF, 16V 1 C8861 F1G1C104A116 C 0.10UF, K, 16V 1

C8862 F1G1C103A116 C 0.010UF, K,

C8863 F1J0G226A001 C 0.001UF, 6.3V 1

C8922 F1G1C104A116 C 0.10UF, K, 16V 1 C8923 F1G1C104A116 C 0.10UF, K, 16V 1 C8950 F1G1C103A116 C 0.010UF, K,

C9040 F1G1C104A116 C 0.10UF, K, 16V 1 C9052 F1G1C104A116 C 0.10UF, K, 16V 1

C9066 F1K0J226A008 C 22UF, K,6.3V 1 C9067 F1G1H561A730 C 56UF, 50V 1 C9100 F1J1A106A087 C 0.010UF, K,

C9101 F1G1E103A123 C 0.010UF, K,

C9102 F1K1E106A136 C 10UF, Z, 25V 1 C9103 F1G1E103A123 C 0.010UF, K,

C9106 F1K1E106A136 C 10UF, Z, 25V 1 C9108 F1G1E103A123 C 0.010UF, K,

C9116 F1G1C104A116 C 0.10UF, K, 16V 1 C9300 F1G1C104A116 C 0.10UF, K, 16V 1

C9301 F1G1H150A731 C 15UF, 50V 1 C9302 F1G1H180A731 C 18UF, 50V 1 C9303 F1G1C104A116 C 0.10UF, K, 16V 1

C9307 F1G1C104A116 C 0.10UF, K, 16V 1

Description

10V

25V

16V

10V

25V

Pcs Remarks

1

100

Panasonic TX-P37C2B Schematic

TABLE OF CONTENTS

1 Safety Precautions

1.1. General Guidelines

1.2. Touch-Current Check

2Warning

2.1. Prevention of Electrostatic Discharge (ESD) to Electrostatically Sensitive (ES) Devices

2.2. About lead free solder (PbF)

3 Service Navigation

3.1. PCB Layout

3.2. Applicable signals

4 Specifications

5 Technical Descriptions

5.1. Specification of KEY for CI Plus, DTCP-IP and One-to-One

5.1.1. General information:

5.1.2. Replacement of ICs:

5.1.3. Model and Keys:

6 Service Mode

6.1. How to enter into Service Mode

6.1.1. Key command

6.1.2. Contents of adjustment mode

6.1.3. How to exit

6.2. Option - Mirror

6.3. Service tool mode

6.3.1. How to access

6.3.2. Display of SOS History

6.3.3. POWER ON Time, On/Off

6.3.4. Exit

6.4. Hotel mode

6.5. Data Copy by SD Card

6.5.1. Purpose

6.5.2. Preparation

6.5.3. Data copy from TV set to SD Card

6.5.4. Data copy from to SD Card to TV set

7 Troubleshooting Guide

7.1. Check of the IIC bus lines

7.1.1. How to access

7.1.1.1. Self-check indication only:

7.1.1.2. Self-check indication and forced to factory shipment setting:

7.1.2. Screen display

7.1.3. Check Point

7.1.4. Exit

7.2. Power LED Blinking timing chart

7.3. No Power

7.4. No Picture

7.5. Local screen failure

8 Service Fixture & Tools

8.1. SC jig

9.1. Remove the Rear cover

9.2. Remove the AC inlet

9.4. Remove the Side terminal cover and the Side shield metal

9.3. Remove the P-Board

9.5. Remove the Tuner unit

9.7. Remove the Speakers

9.8. Remove the SM-Board

9.6. Remove the A-Board

9.9. Remove the SC-Board

9.11. Remove the Hanger metals and the Stand brackets

9.10. Remove the SS-Board

9.12. Remove the C1-Board

9.13. Remove the C2-Board

9.14. Remove the S-Board

9.16. Remove the Glass holders

9.17. Remove the K-Board

9.18. Replace the plasma panel

10 Measurements and Adjustments

10.1. Adjustment

10.1.1. Vsus selection

10.1.2. Sub-Contrast adjustment

10.1.3. White balance adjustment

11 Block Diagram

11.1. Main Block Diagram

11.2. Block (1/4) Diagram

11.3. Block (2/4) Diagram

11.4. Block (3/4) Diagram

11.5. Block (4/4) Diagram

12 Wiring Connection Diagram

12.1. Caution statement.

12.2. Wiring (1)

12.3. Wiring (2)