Outdoor Great Room Jag24c, Lg24i, Jag24 Owner's Manual
LEGACY CONVECTION RANGE
OWNER’S MANUAL
Assembly•
Operation•
Maintenance•
CAUTION: DO NOT DISCARD THIS MANUAL
NOTICE TO INSTALLER AND CONSUMER
• Read, understand and follow
these instructions for safe
installation and operation.
WARNING
If the information in these instructions
isnotfollowedexactly,areorexplosion may result causing property damage, personal injury or death.
WARNING
1. Do not store or use gasoline or other
ammableliquidsorvaporsinthevicinity of this or any other appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity of this or any other appliance.
DANGER
If you smell gas:
Shut off gas to the appliance. 1.
Extinguishanyopename.2.
Open lid. 3.
If odor continues keep away from the ap-4.
pliance and immediately call your gas
supplieroryourredepartment.
Models: JAG24c (shown)
JAG24
LG24c
LG24i
JAG36c
JAG36
LG36c
LG36i
• These instructions must be left with the
consumer and the consumer should
retain them for future reference.
Read the following instructions carefully and be sure your grill is properly installed, assembled and maintained.
Failure to follow these instructions may
result in serious bodily injury and/or
property damage. If you have questions
concerning assembly or operation, consult your dealer, gas appliance service
person or your LP gas company.
This outdoor cooking gas appliance is
not intended to be installed in or on recreational vehicles and/or boats.
Installation and service must be performed
bya qualiedinstaller,serviceagency,or
the gas supplier. In the Commonwealth of
Massachusetts installation must be per-
formedbyalicensedplumberorgastter.
GAS-FIRED
LISTED
DO NOT
DISCARD
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
1
760-920E 9/08
TABLE OF CONTENTS
WARRANTY .................................................................................. 3
SAFETY INSTRUCTIONS ............................................................. 4
SERVICE PARTS LIST .................................................................. 6
ASSEMBLY INSTRUCTIONS ...................................................... 10
LIGHTING INSTRUCTIONS ........................................................ 16
COOKING INSTRUCTIONS ....................................................... 18
CLEANING AND MAINTENANCE INSTRUCTIONS .................. 19
CONTACT INFORMATION .......................................................... 21
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
2
WARRANTY
Legacy - JAG24c / JAG24 / LG24c / LG24i /
JAG36c / JAG36 / LG36c / LG36i Gas Grills
Limited Lifetime Warranty
The Outdoor Greatroom Company extends the following warranty for Legacy Series Gas Grills used in the United
States of America or Canada. Dealers and employees of The Outdoor Greatroom Company have no authority to
make any warranty or authorize any remedies in addition to or inconsistent with the terms of this warranty. This
warranty gives you specic legal rights. You may also have other rights that vary from state to state.
The Outdoor Greatroom Company warrants that this Legacy Series Gas Grill (the “Product”) will be free from
defects in material and workmanship as follows:
• Stainless steel parts - for the life of the Product.
• All other parts - for a period of one year from the Product’s date of purchase.
This warranty is subject to the conditions, exclusions and limitations described below.
This warranty applies only to the original owner of the Product and is nontransferable. The Outdoor Greatroom
Company’s obligation under this warranty does not extend to damages resulting from (1) assembly, operation
or maintenance of the Product not in accordance with the Installation/Assembly Instructions, Operating Instructions and the Listing Agency Identication Label furnished with the Product; (2) installation or use which does not
comply with local building codes and ordinances; (3) shipping, improper handling, improper operation, abuse,
misuse, accident or unworkmanlike repairs; (4) use of fuels other than those specied in the Operating Instructions; (5) installation or use of components not supplied with the Product or any other components not expressly
authorized and approved in writing by The Outdoor Greatroom Company; and/or (6) modication of the Product
not expressly authorized and approved in writing by The Outdoor Greatroom Company. Any of the circumstances
described in the previous sentence voids this warranty. This warranty is void if the Product or any component has
been removed, repaired or replaced before The Outdoor Greatroom Company has been afforded a reasonable
opportunity to inspect the Product. This warranty does not cover LP tanks.
This warranty is limited to the replacement of defective components and The Outdoor Greatroom Company may
fully discharge its obligations under this warranty by replacing, at its discretion, the defective components. The
Outdoor Greatroom Company will provide replacement parts at no charge and will pay reasonable and necessary
freight costs related to replacing defective components under this warranty. The maximum amount recoverable
under this warranty is limited to the purchase price of the Product and, if The Outdoor Greatroom Company is
unable to provide replacement components in an expedient and cost-effective manner, The Outdoor Greatroom
Company may discharge all obligations under this warranty by refunding the purchase price of the Product.
EXCEPT TO THE EXTENT PROVIDED BY LAW, THE OUTDOOR GREATROOM COMPANY MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY EXPRESSED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO THE DURATION OF THE WARRANTY SPECIFIED ABOVE. IN NO EVENT
SHALL THE OUTDOOR GREATROOM COMPANY BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES CAUSED BY DEFECTS IN THE PRODUCT. Some states do not allow limitations on how long an
implied warranty lasts, or do not allow exclusion or limitation of incidental or consequential damages, so these
limitations may not apply to you.
To obtain service under this warranty, you must:
1. Obtain service and/or parts at any authorized dealer, or send written notice of the claimed condition to The
Outdoor Greatroom Company, 12400 Portland Ave. So., Burnsville, MN 55337.
2. Provide documentary proof that you are the original owner of the Product.
3. Provide The Outdoor Greatroom Company reasonable opportunity to investigate the claim, including reasonable opportunity to inspect the Product prior to any repair or replacement work and before the Product or any
component of the Product has been removed.
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
3
Read These Safety Instructions
WARNING
Fire Risk
Explosion Risk
Failure to comply with these instructions could
result in a re or explosion which could cause
property damage, serious bodily injury or death.
WARNING
Combustion by-products produced when using this
product contain chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.
Grill Installation Codes
This grill has been tested in accordance with ANSI Z21.582005/CSA 1.6-2005 and ANSI Z21.58a-2006/CSA1.6a2006 . The installation of this gas grill must conform with
local codes or, in the absence of local codes with the National Fuel Gas Code, ANSI Z223.1/NFPA54 (In the USA)
or Natural Gas and Propane Installation Code, CSA B149.1
or Propane Storage and Handling Code, B149.2 (in Canada).
Never use this gas grill in a garage, porch, shed, breezeway or any other enclosed area. The gas grill is to be used
outdoors only, with at least 6 inch clearance from the back
and sides of the grill to any combustible surface. The gas
grill shall not be located under overhead combustible construction. Do not obstruct the ow of combustion or ventilation air around the gas grill housing.
This outdoor gas grill is not intended to be installed in or on
recreational vehicles and/or boats. If installed other than in
the grill cart, refer to ANSI Z223.1 for specic details relative to installation within a conned space.
Correct LPG Cylinder Use
This gas grill is designed for use with a standard 20 lb.
Liquid Propane Gas (LPG) cylinder, not included with grill
box. Never connect the gas grill to an LPG cylinder that exceeds this capacity. A cylinder of approximately 12 inches
in diameter by 18-1/2 inches high should be the maximum
size LPG cylinder used. The LPG cylinder must be an
“OPD” gas cylinder which offers an Overll Prevention Device. This safety feature prevents the cylinder from being
overlled which can cause malfunction of the LPG cylinder,
regulator and/or grill.
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
The LPG cylinder must be constructed and marked in accordance with the Specications for LP-Gas Cylinders of the
U.S. Department of Transportation (DOT) or the National
Standard of Canada, CAN/CSA-B339, Cylinders, Spheres
and Tubes for Transportation of Dangerous Goods: and
Commission, as applicable.
In addition:
1. The LPG cylinder must also be provided with a listed
overlling prevention device, and a cylinder connection device compatible with the connection for outdoor
cooking appliances.
2. The LPG cylinder used must have a collar to protect the
cylinder valve.
3. The cylinder supply system must be arranged for vapor
withdrawal. See Figure 11 on page 13. Keep the ventilation openings of the cylinder enclosure free and clear
from debris.
4. Never connect an unregulated LPG cylinder to the gas
grill. The gas regulator assembly supplied with this gas
grill is adjusted to have an outlet pressure of 11” water
column (W.C.) for connection to an LPG cylinder.
5. Only use the regulator and hose assembly supplied with
the gas grill. The regulator and hose assembly must be
inspected before each use of the grill. If there is excessive abrasion or wear or if the hose is cut, it must be
replaced prior to the grill being used again. Open the
lower grill cart cabinet doors to access and inspect the
regulator and hose assembly. Replacement pressure
regulators and hose assemblies must be those specied by The Outdoor Greatroom Company.
6. Have the LPG cylinder lled by a reputable propane
gas dealer and visually inspected and re-qualied at
each lling.
Never ll the gas cylinder beyond 80% full. Have the
propane gas dealer check the release valve after every
lling to ensure that it remains free of defects.
Do not store a spare LP-gas cylinder under or near this
appliance or any other ignition source.
If this information is not followed exactly, a re
causing death or serious injury may occur.
7. Always keep LPG cylinders in an upright position.
8. Do not store (or use) combustible materials, gasoline or
other ammable vapors and liquids in the vicinity of this
gas grill.
9. Do not subject the LPG cylinder to excessive heat.
10. When the gas grill is not in use the gas must be turned
off at the LPG cylinder.
11. Never store an LPG cylinder indoors. If storing the gas
grill in the garage or other indoor location, always disconnect and remove the LPG cylinder. Cylinders must
be stored outdoors out of the reach of children and
must not be stored in a building, garage or any other
enclosed area.
4
• If the hose appears damaged do not use gas grill. Call
your dealer for a factory authorized replacement hose.
WARNING
• Keep the gas regulator hose away from hot grill surfaces and dripping grease. Avoid unnecessary twisting of
hose. Visually inspect hose prior to each use for cuts,
cracks, excessive wear or other damage.
• Never light the gas grill with the lid closed or before
checking to insure the burner tubes are fully seated over
the gas valve orices.
• Never allow children to operate the grill. Do not allow
children to play near the grill.
• Never obstruct the ow of combustion and ventilation
air to the grill.
Beware of Spiders
CAUTION: Spiders and small insects occasionally spin
webs or make nests in the grill burner tubes during transit and warehousing. These webs can lead to a gas
ow obstruction which could result in a re in and
around the burner tubes. This type of re is known as
a “FLASH-BACK” and can cause serious damage to
the grill and create an unsafe operating condition for the
user.
Fire Risk
Explosion Risk
A strong gas smell, or the hissing sound of gas indicates a serious problem with the gas grill or the LPG
cylinder.
• Get away from the LPG cylinder.
• Do not try to x the problem yourself.
• Call the re department. (Do not call near the LPG cylinder because the telephone is an electrical device.)
Failure to immediately follow the steps listed above
could result in a re or explosion which could cause
property damage, serious bodily injury or death.
Although an obstructed burner tube is not the only cause of
“FLASH-BACK”, it is the most common cause.
To reduce the chance of “FLASH-BACK”, clean the
burner tubes before assembling the grill, and at least
once a month in late summer or early fall when spi-
ders are most active. Also perform this burner tube
cleaning procedure if the grill has not been used for an
extended period of time.
Safety Instructions
Natural Gas Safety
(Conversion Kit available through The Outdoor Greatroom Company)
This converted natural gas grill is designed to operate on
natural gas ONLY, at a pressure of 7” water column (W.C.)
(1/4 psig or 1.75 kPa), regulated at the residential meter.
Check with the gas utility for local gas pressure and with
the local municipality for building code requirements. If the
residential gas utility line pressure has not been regulated
to 7” W.C., contact the local gas utility or gas grill dealer for
professional assistance.
Check with the gas utility or with local building codes for
instructions to install gas supply line, or call a licensed and
knowledgeable installer. The grill must be chained to stay
in one location so that it cannot roll.
It is recommended that an “ON-OFF” shut-off valve be installed at the gas supply source:
• outdoors after gas line piping exits outside wall and before
quick-disconnect, or before gas line piping enters ground.
• indoors in the branch fuel line in an accessible location
near the supply line.
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
Converting to Natural Gas
WARNING
Fire Risk
Explosion Risk
Only factory authorized dealers may convert the grill
from LP to NG.
• Any attempt to do otherwise voids the product warranty and releases The Outdoor Greatroom Company from all liabilities due to unauthorized conversion.
• Failure to comply with these instructions could result in re or explosion which could cause property
damage, serious bodily injury, or death.
Pipe sealing compound or pipe thread tape of the type resistant to the action of natural gas must be used on all male
pipe threads when making the connection.
Disconnect the gas grill from fuel source when the gas supply is being tested at high pressures. This appliance and its
individual shut-off valve must be disconnected from the gas
supply piping system during any pressure testing of that
system at test pressures in excess of 1/2 psi (3.5kPa).
Turn off the gas grill when the gas supply is being tested
at low pressures. This appliance must be isolated from the
gas supply piping system by closing its individual manual
shut-off valve during any pressure testing of the gas supply
piping system at test pressures equal to or less than 1/2 psi
(3.5kPa).
5
Service Parts
LG24i
(NG, LP) Exploded Parts Diagram
Beginning Manufacturing Date: ____
Ending Manufacturing Date: ______
Remove all components from the packing carton and place within easy reach. Do not throw the shipping carton away; instead use it as an elevated assembly surface.
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
6
How to Order Replacement Parts
LG24i Service Parts List
IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on your dealers VIP site. When
ordering, supply serial and model numbers to ensure correct service parts.
ITEM DESCRIPTION PART NUMBER
1 24 in. Control Panel Assembly JL24-761-107A-L
2 24 in. Control Panel JL24-761-111
3 Logic Box Assembly JL-760-189A
4 Battery Pack Mount JL-760-209
5 Bezel JL-760-145
6 Control Knob - “D” Shaft JL-760-188A
7 Snap Bushing 760-207
8 Snap Bushing JL-760-208
9 Rocker Switch On/Off 230-0730
10 Control Knob - Spline Shaft JL-760-195A
11 Temp Gauge Cover JL-760-187
12 Temp Gauge JL-760-183A
13 24 in. Front Hood Assembly JL24-761-116A
14 Handle JL-761-126A
15 24 in. Vaporizer Plate JL24-761-200A
Items not shown
Battery Pack 593-594A
24 in. Valve 760-191
24 in. Wire Harness JL-24-760-193
Probe 760-144
Searing Plate 760-108
SS Grill 760-109
Hose and Regulator 760-182
Ignitor JL-761-303
Ignition Wire JL-761-304
To order replacement parts, contact the dealer where the product was purchased.
To obtain the correct replacement part(s) for
this Patio Gourmet Series III gas grill, please
refer to the service parts list. The following
information is required to assure receipt of
correct parts:
• Gas Grill Model Number (see data sticker
on grill)
• Part Number AND Part Description
• Quantity of parts needed
Important: Keep this assembly and operating instruction manual for convenient referral
and for part replacement.
Important: Use only factory authorized parts.
The use of any unauthorized factory part can
be dangerous and will also void the product
warranty.
The Outdoor Greatroom Company • Legacy Gas Grill • Rev. E
7
Loading...