Omega Products OM-PLPT User Manual

Portable Low-Cost Data Loggers Part of the NOMAD®Family
OM-PL Series
Starts at
$
113
Measure and Record
Selectable Sample Rate:
1 Second to 18 Hours (1-Second Increments)
Real-Time Data MonitoringHigh/Low Alarm
Threshold Settings
Visual Alarm IndicationUser-Selectable Recording
Start (Specified Date and Time, Immediately After Setup, or on Door Close)
20-Month Battery Life
(at 1-Minute Sample Rate)
The OM-PL Series data loggers are versatile devices that can be used for a wide range of logging applications. Each data logger is capable of sampling data as fast as once per second or as slow as once every 18 hours. The data logger can stop recording when memory becomes full or rollover for continuous recording. The start of recording is software selectable to be immediate, delayed, or initiated when the data logger door is closed.
The data logger can also be used to monitor high and low alarm events, which indicate if the recorded data passed above and/or below the user-selected threshold. The alarm events are stored separately from the data samples and are not affected by data rollover. When the recorded data passes the high or the low alarm threshold, the data logger records the time of the alarm.
When the recorded data returns to within the acceptable range, the data logger records the duration of the alarm. Up to 50 such alarm events can be recorded. The data logger has a visual indication of an alarm condition without the need to connect to the computer.
All OM-PL Series data loggers have an internal real-time clock/calendar. This real-time clock is used to record the time stamps for data samples and alarm events. It is independent of the computer clock and can be set separately, or set to match the computer clock.
These data loggers provide a high level of data security. They have physical security, when the data access door is locked, as well as software security. It is virtually impossible to falsify sample data or alarm information of OM-PL Series data loggers. Their power requirement is very low: under normal operating conditions, a 9-volt alkaline battery will last 18 months to 2 years.
OM-PLT2, $113, shown smaller than actual size.
OM-PL Series data loggers have the capacity to store over 10,000 readings. Simply connect the data logger to your PC’s serial port and use the available Windows software to set up parameters for your recording session. Once the data logger is set up, you can disconnect it and put it in the field to record data. The data logger door can be locked on to prevent accidental or intentional disruptions of the recording session. When recording is completed, reconnect the data logger to your PC and download the recorded data using the Windows software. The Windows software allows you to view recorded data in text or graphical format. OM-PL models are available to record internal temperature and an external temperature channel (OM-PLT2); two external temperature channels (OM-PLTT); temperature, humidity and dew point (OM-PLTH); temperature and pressure (OM-PLPT); AC current and voltage (OM-PLCV); 4 to 20 mA (OM-PL420); and internal temperature and an external thermocouple input (OM-PLTC).
To Order, Call or Shop Online at omega.com
SM
1
Specifications
GENERAL Operating Temperature Range (Data Logger): 0 to 60°C (32 to 140°F)
using alkaline battery; -40 to 65°C (-40 to 150°F) using lithium battery
Humidity:
0 to 95% RH, non-condensing
Storage Temperature:
-40 to 77°C (-40 to 170°F)
Time Accuracy: ±100 ppm @ 75°F Power: 9 V alkaline or lithium battery Battery Life (Average Use):
20 months using alkaline battery, 40 months using lithium battery Dimensions: 7.6 W x 6.4 H x 2.8 cm D
(3 x 2.5 x 1.1")
Weight: 71 g (2.5 oz) Software: WIN/XP/VISTA 32-bit
(VISTA 32-bit version only; VISTA 64-bit is not supported) Measurement Interval: 1 sec to 18 hr (selectable in 1-second increments) Computer Interface: RS-232
standard; for computers with only a USB port, use model no. OM-PL-USBS (RS-232/USB adaptor)
OM-PLTT, $165,
shown smaller
than actual size.
OM-PLTT DUAL TEMPERATURE DATA LOGGER Channels: Two external
temperature channels Sample Point Capacity: 21,500 temperature points for single channel (1 probe); 10,750 temperature points per channel for dual channel (2 probes) Alarms: High and low alarms for each probe
External Probe Temperature Range: -46 to 150°C (-50 to 300°F) Accuracy: ±1°C (±2°F) Resolution: 0.05 °C (0.1°F) Probe: 76 mm (3") stainless steel
tip, 1.8 m (6') cable Calibration: Single point offset calibration available through software
Relative Humidity Range:
0 to 99.9% RH, non-condensing
Relative Humidity Accuracy:
±2% full scale, from 0 to 95% RH for temperatures between 0 and 60°C (32 to 140°F)
Relative Humidity Resolution:
0.1% RH Calibration: Single point offset calibration available through software;
humidity is factory calibrated
OM-PLPT, $205, shown smaller than actual size.
OM-PLT2, $113, shown smaller than actual size.
OM-PLT2 TEMPERATURE DATA LOGGER Channels: One internal
temperature channel and one external temperature channel Sample Point Capacity: 21,500 points for single channel; 10,750 points per channel for dual channel Alarms: High and low alarms for internal and external channel Temperature Range: Internal sensor: 0 to 60°C (32 to 140°F) with alkaline battery, -40 to 65°C (-40 to 150°F) with lithium battery; external sensor: -40 to 65°C (-40 to 150°F)
Accuracy: ±0.5°C (±1.0°F) Resolution: 0.05°C (0.1°F) External Probe Temperature Range: -40 to 65°C (-40 to 150°F) Calibration: Single point offset
calibration available through software
OM-PLTH, $130,
shown smaller than actual size.
OM-PLTH TEMPERATURE/ HUMIDITY DATA LOGGER Channels: Two internal channels
(temperature and humidity); two calculated channels (dew point and wet bulb) Sample Point Capacity: 21,500 for temperature only; 10,750 points for temperature, humidity and dew point Alarms: High and low alarms for temperature and humidity Temperature Range: 0 to 60°C (32 to 140°F) with alkaline battery,
-40 to 65°C (-40 to 150°F) with lithium battery
Temperature Accuracy: ±1°C (±2°F) Resolution: 0.05°C (0.1°F)
OM-PLPT PRESSURE AND TEMPERATURE DATA LOGGER Channels: Two external channels
(temperature and pressure) Sample Point Capacity: 21,500 points for temperature or pressure; 10,750 points for both pressure and temperature Alarms: High and low alarms for temperature and pressure Temperature Range: -40 to 65°C (-40 to 150°F)
Temperature Accuracy:
±0.5°C (±1°F)
Resolution: 0.05°C (0.1°F) Temperature Probe: -40 to 65°C
(-40 to 150°F)
Pressure Range: 0 to 500 psi Pressure Accuracy: ±3 psi
Pressure Resolution: 0.15 psi Pressure Sensor: Stainless steel
sensor, 1.8 m (6') cable,
1
4 NPT
male pressure port
Operating Temperature Range (Pressure Sensor): 0 to 54°C
(32 to 130°F) Calibration: Single point offset calibration available through software; pressure is factory calibrated
2
To Order, Call or Shop Online at omega.com
SM
OM-PLTC, $145,
shown smaller than actual size.
OM-PLTC THERMOCOUPLE DATA LOGGER Channels: Two channels, one for
internal ambient temperature and one for external thermocouple input
Measurement Capacity:
10,750 points for both internal temperature and external thermocouple input
Thermocouple Types (External Channel):
J, K, T, E, R, S (software selectable)
Thermocouple Temperature Ranges:
Type J: -79 to 732°C
(-110 to -1350ºF) Type K: -140 to 1038°C (-220 to 1900°F) Type T: -148 to 349°C (-235 to 660°F) Type E: -59 to 560°C (-75 to 1040°F) Type R: 0 to 1449°C (32 to 2640°F) Type S: 0 to 1449°C (32 to 2640°F)
Thermocouple Connection:
Subminiature female thermocouple jack
Accuracy (Thermocouple Channel):
Type J, K, T: ±0.8°C (±1.5°F) Type E: ±0.6°C (±1.0°F)
Type R, S: ±2.8°C (±5°F) Resolution (Thermocouple Channel): 0.05°C (0.1°F) Accuracy (Internal Channel):
±1°C (± 2°F)
Resolution (Internal Channel):
0.05°C (0.1°F) Alarms: High and low alarms for thermocouple and ambient temperature Calibration: Single point offset calibration available through software for both internal ambient channel and external thermocouple channel
OM-PLCV, $165,
shown smaller
than actual size
OM-PL420, $105,
shown smaller than actual size.
OM-PL420 4 to 20 MA DATA LOGGER Channels: One 4 to 20 mA input Measurement Capacity:
21,500 points
Alarms: High and low alarms Input Current Range: 0 to 40 mA Current Accuracy: ±0.05 mA Current Resolution: 0.01 mA Calibration: Single point offset
calibration available through software
OM-PLCV CURRENT AND VOLTAGE LOGGER Channels: Two channels,
one for AC current (measured using supplied current probe) and one for AC voltage Sample Point Capacity: 21,500 points for current or voltage; 10,750 points for both current and voltage Alarms: High and low alarms for current and voltage
Current Range: 0 to 300 Aac Current Accuracy: ±5% Current Resolution: 0.1 Aac Voltage Range: 0 to 500 Vac Voltage Accuracy: ±1 Vac Voltage Resolution: 0.1 Vac Calibration: Single point offset
calibration available through software; current and voltage are factory calibrated
Windows software displays data in graphical or tabular format.
To Order, Call or Shop Online at omega.com
SM
3
OM-PL SERIES LOGGER
Extended Warranty
Program
SM
INTERFACE SOFTWARE SPECIFICATIONS Sampling Interval:
User-selectable from 1 second to 18 hours, in 1-second increments Interface: COM (RS232) serial port. Software supports COM1 through COM8. Optional USB interface (model no. OM-PL-USBS). Alarms: Visual alarms with user­selectable low and high thresholds for every channel Alarm Memory: Up to 50 alarm events. Alarm start time and alarm duration are stored Data Security: Locking sliding door prevents physical access to the logger data. Unique factory set logger ID. Data collection session counter. Compatibility: WIN XP/VISTA 32­bit (VISTA 32-bit version only; VISTA 64-bit is not supported)
Minimum System Requirements:
8MB of RAM, 2 MB of disk space, 800 x 600 resolution, 1 free COM port or a free USB port (optional USB interface is required: Model OM-PL-USBS) Recording Start: On door close, immediately after setup, or at a user­specified date and time Recording Mode: Stop on memory full or continuous recording with memory rollover Real-Time Status: Visual indication through the status LED. User­selectable status display frequency and LED brightness, software real­time status User Calibration: Password­protected calibration for each channel
User Message: Up to 30 characters Logger Channels: User selectable.
Disabling channels increases the storage capacity of the other Units: US and Metric (user-selectable units) Data Format: Custom format exportable to text or Excel spreadsheet Real-Time Monitoring: Logger can be permanently connected to the computer and used as a real-time, multichannel sensor with logging capability. Battery does not drain when logger is connected to the computer
OMEGACARE available for models shown on this page. Ask your sales representative for full details when placing an order. OMEGACARE labor and equivalent loaners.
4
Windows software displays data in graphical or tabular format.
Windows software displays graphs, tables, and alarm summary (start and end times).
MOST POPULAR MODELS HIGHLIGHTED!
To Order (Specify Model Number)
channels.
SM
extended warranty program is
SM
covers parts,
To Order, Call or Shop Online at omega.com
Model No. Price Description
OM-PLT2 $113 Temperature data logger OM-PLTT 165 Dual-temperature data logger OM-PLTH 130 Temperature and humidity data logger OM-PLPT 205 Pressure and temperature data logger OM-PLCV 165 AC current and voltage data logger OM-PL420 105 4 to mA data logger OM-PLTC 145 Thermocouple data logger OM-PLLS 59 Windows software, 1.8 m (6') RS232 cable and adaptor OM-PL-USBS 49 USB to RS232 converter
All data loggers are supplied with complete operator’s manual. OM-PLT2 includes one external temperature sensor (4.6 m [15'] cable, epoxy-coated tip). OM-PLTT includes two external temperature probes (1.8 m [6'] cable, 76 mm [3"] long stainless steel probe with penetration tip). OM-PLPT includes one external temperature sensor (4.6 m [15'] cable, epoxy coated tip) and one pressure transducer (1.8 m [6'] cable, stainless steel pressure transducer with 1⁄2 NPT male pressure port). OM-PLCV includes AC current clamp and set of voltage test leads. OM-PLTC includes 1 m (3') long beaded wire Type K thermocouple with subminiature male connector. Ordering Example: OM-PLTT, dual-temperature data logger, OMEGACARESM, 1-year extended warranty for OM-PLTT (adds 1 year to standard 1-year warranty), and OM-PLLS Windows software with RS232 cable, $165 + 25 + 52 = $242.
SM
One Omega Drive | Stamford, CT 06907 | 1-888-TC-OMEGA (1-888-826-6342) | info@omega.com
EPG05
www.omega.com
UNITED KINGDOM
www. omega.co.uk
Manchester, England
0800-488-488
UNITED STATES
www.omega.com
1-800-TC-OMEGA
Stamford, CT.
CANADA
www.omega.ca
Laval(Quebec)
1-800-TC-OMEGA
GERMANY
www.omega.de
Deckenpfronn, Germany
0800-8266342
Karviná, Czech Republic
FRANCE
www.omega.fr
Guyancourt, France
088-466-342
CZECH REPUBLIC
www.omegaeng.cz
596-311-899
BENELUX
www.omega.nl
Amstelveen, NL 0800-099-33-44
More than 100,000 Products Available!
Temperature
Calibrators, Connectors, General Test and Measurement Instruments, Glass Bulb Thermometers, Handheld Instruments for Temperature Measurement, Ice Point References, Indicating Labels, Crayons, Cements and Lacquers, Infrared Temperature Measurement Instruments, Recorders Relative Humidity Measurement Instruments, RTD Probes, Elements and Assemblies, Temperature & Process Meters, Timers and Counters, Temperature and Process Controllers and Power Switching Devices, Thermistor Elements, Probes and Assemblies,Thermocouples Thermowells and Head and Well Assemblies, Transmitters, Wire
Flow and Level
Air Velocity Indicators, Doppler Flowmeters, Level Measurement, Magnetic Flowmeters, Mass Flowmeters, Pitot Tubes, Pumps, Rotameters, Turbine and Paddle Wheel Flowmeters, Ultrasonic Flowmeters, Valves, Variable Area Flowmeters, Vortex Shedding Flowmeters
pH and Conductivity
Conductivity Instrumentation, Dissolved Oxygen Instrumentation, Environmental Instrumentation, pH Electrodes and Instruments, Water and Soil Analysis Instrumentation
Data Acquisition
Auto-Dialers and Alarm Monitoring Systems, Communication Products and Converters, Data Acquisition and Analysis Software, Data Loggers Plug-in Cards, Signal Conditioners, USB, RS232, RS485 and Parallel Port Data Acquisition Systems, Wireless Transmitters and Receivers
Pressure, Strain and Force
Displacement Transducers, Dynamic Measurement Force Sensors, Instrumentation for Pressure and Strain Measurements, Load Cells, Pressure Gauges, Pressure Reference Section, Pressure Switches, Pressure Transducers, Proximity Transducers, Regulators, Strain Gages, Torque Transducers, Valves
Heaters
Band Heaters, Cartridge Heaters, Circulation Heaters, Comfort Heaters, Controllers, Meters and Switching Devices, Flexible Heaters, General Test and Measurement Instruments, Heater Hook-up Wire, Heating Cable Systems, Immersion Heaters, Process Air and Duct, Heaters, Radiant Heaters, Strip Heaters, Tubular Heaters
click here to go to the omega.com home page
Loading...