Oceanic OCS30, OCS40, OCS45, OCS60, OCS80 Assembly Manual

PRODUCT IMAGE

Oceanic Ltd, Pountney Street, Wolverhampton, WV2 4HX

Phone: [phone] [e-mail] www.oceanic-saunas.co.uk

Sauna & Steam

SAUNA HEATER

with OCSB/LB CONTROLLER

Assembly and operating manual

31.06.16

Sauna & Steam

Oceanic Saunas 01902 450 550 [e-mail] www.oceanic-saunas.co.uk

2

Sauna Heater Manual

Table of contents

1. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

2. Important Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

3. Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

4. Electrical connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

4.1. Installation overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

4.2. Circuit Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5. Sauna Heater Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

5.1. Sauna Heater Parts Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

5.2. Controller parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

5.3. Control Box Circuit Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

5.4. Single Phase connection upto 9kw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

5.5. Controller Parts Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

5.6. Control Box Frame and Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

6. Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

6.1. Parts Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

6.2. Temperature Sensor Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

7. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

7.1. Minimum Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

7.2. Installation for sauna heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

7.3. Installation for controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

7.4. Installing the temperature sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

8. Sauna heater, controller and temperature sensor connection drawing . . . . . . . 14

9. Testing and Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

9.1. Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

9.2. Setting time and temperature: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

9.3. Door Interlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

10. Trouble shooting Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

11. Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

11.1. Sauna Heaters & Sauna Cabins Maintenance . . . . . . . . . . . . . . . . . . . . . . 18

11.2. Sauna Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

11.3. Maintenance Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

11.4. Sauna Heater: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

11.5. Sauna Cabin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

12. Warranty & After Sales . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Sauna & Steam

Oceanic Saunas 01902 450 550 [e-mail] www.oceanic-saunas.co.uk

3

Sauna Heater Manual

1. Introduction

Thank you for choosing to buy our Oceanic sauna heater, please take the time to read these
instructions before you begin as they contain important information about the installation and
maintenance requirements.

Depending upon the size of cabin heaters from 3kW to 9kW can be used in single or three phase.

2. Important Notes

• Read the manual before installation and operation.

• This equipment is intended for indoor use only

• This equipment is not intended for marine use

• This Equipment must be installed by competent person.

• This equipment must be connected to an RCD protected all pole isolator.

• Disconnect the power supply before exposing electrical connections.

• The sauna heater should not be used for any other purpose

• Do not cover the sauna heater or allow contact with ammable materials such as toweling –
Risk of re.

• Do not operate sauna heater without sauna stone

• Do not touch the heater when operational as it is very hot

3. Safety Precautions

• Elderly persons, pregnant women, or these suering heart disease, high blood pressure,
diabetes or not in good health are advised to seek medical opinion before using a sauna room;

• Do not smoke in the sauna room;

• Avoid using the sauna room immediately after strenuous exercise;

• Do not use the sauna room when under the inuence of alcohol;

• Leave the sauna room at once if you feel sleepy, sick or uncomfortable;

• Ensure there is good ventilation for the sauna room

• We do not recommend this product is used by children under 16 years old unless they are
supervised by an adult

• This appliance is not intended for use by persons including children with reduced physical,
sensory or mental capabilities or lack of experience unless they have been given supervision
or instruction concerning the use by a person responsible for their safety

• Commercial operators should post a notice of these precautions in a prominent position

4. Electrical connection

A qualied electrician will have no problem installing this system with the provided wiring
schematic and with the help of the circuit diagram mounted inside the respective control unit.
According to the valid regulations, the electrical connection of the sauna and the control box has
to be carried out by an authorised electrician. In case of a warranty claim, you are kindly requested
to present a copy of the invoice from the electrician.

Sauna & Steam

Oceanic Saunas 01902 450 550 [e-mail] www.oceanic-saunas.co.uk

4

OCSB Keypad

5V DC

OCSB Keypad

5V DC

Temperature

Sensor

Temperature

Sensor

OC Wall Hung

Heater 3 - 4kW

OC Wall Hung

Heater 6 - 9kW

Mains Power

240 1N~

Mains Power

240 1N~ / 400V 3N~

OCSB/LB Contol Box

OCSB/LB Contol Box

4 core heat proof silicon cable

5 core heat proof silicon cable

Sauna Heater Manual



OCS60B~OCS90B Circuit diagram

4.1. Installation overview

4.2. Circuit Diagram

OC30~OC40 Circuit diagram

Use 4 core cable Use 5 core cable

1 2 3 4 5 6

Sauna & Steam

Oceanic Saunas 01902 450 550 [e-mail] www.oceanic-saunas.co.uk

5

Sauna Heater Manual

5. Sauna Heater Parameters

OSC Series Sauna Heater Parameter

Model Power

(KW)

Voltage

(V)

Phase

(N~)

Current

(A)

Heater
Elements

Sauna

Stone (kg)

Dimensinos

LxWxH (mm)

OCS30 3 230 1 13 2 12-14

410 x 280 x 570

OCS40 4 230/400 1/3 17 2 13-15

OCS45 4.5 230/400 1/3 19/6.5 3 14-16

OCS60 6 230/400 1/3 26.4/8.7 3 16-18

OCS80 8 230/400 1/3 34.8/13 3 18-20

OCS90 9 230/400 1/3 39/14 3 18-20

5.1. Sauna Heater Parts Description



No. Parts

1 Inner shell
2 Stone bracket
3 Shell
4 Heat element
5 Fix bracket
6 Cover Panel
7 Terminal

5.2. Controller parameters

Model Input Output Load

power

Size (mm)

1N~ 3N~ 1N~ 3N~ (Kw) L W H
OCSB Control box 230V 400v 230V 400v 2.5~8kw 310 260 70
OCSB Control box 400v 400v 9kw 310 260 70
OCSB Keypad Voltage:DC5V 2.5~20kw 150 92 22

Sauna & Steam

Oceanic Saunas 01902 450 550 [e-mail] www.oceanic-saunas.co.uk

6

Sauna Heater Manual

5.3. Control Box Circuit Diagram using three phase connection