Nokia NBB5005000 - IP VPN 5i, 5i, 10i Installation Manual

Nokia 5i and 10i

Installation Guide

Part No. N451658002 Rev A

Published July 2005

COPYRIGHT

©2005 Nokia. All rights reserved.
Rights reserved under the copyright laws of the United States.

RESTRICTED RIGHTS LEGEND

Use, duplication, or disclosure by the United States Government is subject to restrictions as set
forth in subparagraph (c)(1)(ii) of the Rights in Technical Data and Computer Software clause at
DFARS 252.227-7013.

Notwithstanding any other license agreement that may pertain to, or accompany the delivery of,
this computer software, the rights of the United States Government regarding its use,
reproduction, and disclosure are as set forth in the Commercial Computer Software-Restricted
Rights clause at FAR52.227-19.

IMPORTANT NOTE TO USERS

This software and hardware is provided by Nokia Inc. as is and any express or implied
warranties, including, but not limited to, implied warranties of merchantability and fitness for a
particular purpose are disclaimed. In no event shall Nokia, or its affiliates, subsidiaries or
suppliers be liable for any direct, indirect, incidental, special, exemplary, or consequential
damages (including, but not limited to, procurement of substitute goods or services; loss of use,
data, or profits; or business interruption) however caused and on any theory of liability, whether in
contract, strict liability, or tort (including negligence or otherwise) arising in any way out of the use
of this software, even if advised of the possibility of such damage.

Nokia reserves the right to make changes without further notice to any products herein.

TRADEMARKS

Nokia is a registered trademark of Nokia Corporation. Other products mentioned in this
document are trademarks or registered trademarks of their respective holders.

050110

2 Nokia 5i and 10i Installation Guide

Nokia Contact Information
Corporate Headquarters

Web Site http://www.nokia.com
Telephone [phone] or

1-650-625-2000

Fax [phone]
Mail

Address

Regional Contact Information

Americas Nokia Inc.

Europe,
Middle East,
and Africa

Asia-Pacific 438B Alexandra Road

Nokia Customer Support

Web Site: https://support.nokia.com/
Email: [e-mail]

Nokia Inc.
313 Fairchild Drive
Mountain View, California
94043-2215 USA

313 Fairchild Drive
Mountain View, CA 94043-2215
USA

Nokia House, Summit Avenue
Southwood, Farnborough
Hampshire GU14 ONG UK

#07-00 Alexandra Technopark
Singapore 119968

Tel: [phone]
Outside USA and Canada: [phone]
email: [e-mail]

Tel: UK: [phone]
Tel: France: [phone]
email: [e-mail]

Tel: [phone]
email: [e-mail]

Americas Europe
Voice: 1-888-361-5030 or

Fax: [phone] Fax: [phone]
Asia-Pacific
Voice: [phone]
Fax: [phone]

Nokia 5i and 10i Installation Guide 3

Voice: [phone]

1-613-271-6721

050602

4 Nokia 5i and 10i Installation Guide

Contents

About This Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

In This Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Conventions This Guide Uses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Notices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Command-Line Conventions. . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Text Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Related Documentation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

1 Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

About the Nokia 5i and 10i Gateways . . . . . . . . . . . . . . . . . . . . . . 17

Preparing the Installation Environment . . . . . . . . . . . . . . . . . . . . . 17

Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Humidity and Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Product Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Site Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

2 Installing a Nokia 5i and 10i Gateway . . . . . . . . . . . . . . . . . . . . 23

Resetting the Gateway to Factory Default. . . . . . . . . . . . . . . . . . 24

Performing the Initial Hardware Configuration. . . . . . . . . . . . . . . . 25

Connecting the Console Port . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

Connecting Power and Turning the Power On . . . . . . . . . . . . . . 29

Connecting Network Interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Connecting to Ethernet Ports . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Nokia 5i and 10i Installation Guide 5

3 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

A Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Physical Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Space Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Random Access Memory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Data Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

B Compliance Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Declaration of Conformity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

Compliance Statements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

FCC Notice (US) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

6 Nokia 5i and 10i Installation Guide

Figures

Figure 1 Rear View of the Nokia 5i and Nokia 10i Gateways . . . 23
Figure 2 Pin Assignments for Console and AUX Connections . . 28
Figure 3 Power Cord Receptacle on the Nokia 5i and Nokia 10i 30
Figure 4 System Status LEDs for the Nokia 5i and Nokia 10i . . . 31

Figure 5 Output Connector for the Ethernet Cable . . . . . . . . . . . 34

Figure 6 Ethernet Crossover-Cable Pin Connections . . . . . . . . . 35

Nokia 5i and 10i Installation Guide 7

8 Nokia 5i and 10i Installation Guide

Tables

Table 1 Command-Line Conventions . . . . . . . . . . . . . . . . . . . . . 13

Table 2 Text Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Table 3 Rear Panel connection descriptions of the Nokia 5i and

Nokia 10i . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Table 4 Pin Assignments for DB9 and DB25 Interface Cables . . 29
Table 5 System Status LEDs for the Nokia 5i and Nokia 10i . . . 31

Nokia 5i and 10i Installation Guide 9

10 Nokia 5i and 10i Installation Guide

About This Guide

This guide describes the installation and use of the Nokia 5i and 10i gateways.
Installation and maintenance should be performed only by experienced
technicians or Nokia-approved service providers.

This preface provides the following information:

 In This Guide
 Conventions This Guide Uses
 Related Documentation

In This Guide

This guide is organized into the following chapters and appendixes:

 Chapter 1, “Overview,” presents a general overview of the Nokia 5i and

10i gateways.

 Chapter 2, “Installing a Nokia 5i and 10i Gateway,” explains how to

install and how to physically connect the 5i and 10i to a network and
power.

 Chapter 3, “Troubleshooting,” discusses problems you might encounter

and proposes solutions to these problems.

Nokia 5i and 10i Installation Guide 11

 Appendix A, “Technical Specifications,” provides technical

specifications.

 Appendix B, “Compliance Information,” includes compliance and

regulatory information.

Conventions This Guide Uses

The following sections describe the conventions this guide uses, including
notices, text conventions, and command-line conventions.

Notices

Warning

Warnings advise the user that bodily injury might occur because of a
physical hazard.

Caution

Cautions indicate potential equipment damage, equipment
malfunction, loss of performance, loss of data, or interruption of
service.

Note

Notes provide information of special interest or recommendations.

12 Nokia 5i and 10i Installation Guide

Command-Line Conventions

This section defines the elements of commands that are available in Nokia
Internet Communications products. You might encounter one or more of the
following elements in a command-line path.

Table 1 Command-Line Conventions

Convention Description

command A user-generated instruction typically sent using a console

or terminal. The command statement and its associated
syntax must be entered exactly as shown in lowercase
letters.

italics Indicates a variable in a command that you must supply. For

example:

delete interface if_name

Conventions This Guide Uses

Supply an interface name in place of the variable. For
example:

delete interface nic1

angle brackets < > Indicates arguments for which you must supply a value:

retry-limit <1–100>

Supply a value. For example:

retry-limit 60

-flag A flag is usually an abbreviation for a function, menu, or
option name, or for a compiler or preprocessor argument.
You must enter a flag exactly as shown, including the
preceding hyphen.

Nokia 5i and 10i Installation Guide 13

Table 1 Command-Line Conventions (continued)

Convention Description

.ext A filename extension, such as .ext, might follow a variable

( . , ; + * - / ) Punctuation and mathematical notations are literal symbols

Text Conventions

Table 2 describes the text conventions this guide uses.

Table 2 Text Conventions

Convention Description

that represents a filename. Type this extension exactly as
shown, immediately after the name of the file. The extension
might be optional in certain products.

that you must enter exactly as shown.

monospace font

Indicates command syntax, or represents computer or
screen output, for example:

Log error 12453

bold monospace font Indicates text you enter or type, for example:

# configure nat

Key names Keys that you press simultaneously are linked by a

plus sign (+):
Press Ctrl + Alt + Del.

Menu commands Menu commands are separated by a greater than

sign (>):
Choose File > Open.

14 Nokia 5i and 10i Installation Guide

Related Documentation

Table 2 Text Conventions (continued)

Convention Description

The words enter and type Enter indicates you type something and then press

the Return or Enter key.
Do not press the Return or Enter key when an

instruction says type.

Italics

Related Documentation

In addition to this guide, documentation for this product includes the
following:

 Nokia IP VPN Gateway Configuration Guide v6.3 describes how to

configure and manage Nokia IP VPN Gateways by using the Nokia VPN
Manager software.

 Nokia IP VPN Gateway Command-Line Summary v6.3 is a reference for

the command-line interface (CLI) for Nokia IP VPN gateways.

 Release Notes in an ASCII-text file on the installation CD.

• Emphasizes a point or denotes new terms at the
place where they are defined in the text.

• Indicates an external book title reference.

• Indicates a variable in a command:

delete interface

if_name

Nokia 5i and 10i Installation Guide 15