Nokia N90 Service Manual issue2

Nokia Customer Care

Service Manual

RM-42 (Nokia N90)

Mobile Terminal

Part No: 9241872 (Issue 2)

COMPANY CONFIDENTIAL

RM-42

Nokia Customer Care Amendment Record Sheet

Amendment Record Sheet

Amendment No Date Inserted By Comments

Issue 1 06/2005 J-PH Issue 2 02/2006 J-PH Baseband troubleshooting and

Service concepts updated

Page ii COMPANY CONFIDENTIAL Issue 2

RM-42 Copyright Nokia Customer Care

Copyright

without the prior written permission of Nokia is prohibited. Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of Nokia

Corporation. Other product and company names mentioned herein may be trademarks or tradenames of their respective owners.

Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice.

Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.

The contents of this document are provided ”as is“. Except as required by applicable law, no warranties of any kind, either express or implied, including, but not limited to, the implied warranties of merchantability and fitness for a particular purpose, are made in relation to the accuracy, reliability or contents of this document. Nokia reserves the right to revise this document or withdraw it at any time without prior notice.

The availability of particular products may vary by region.

IMPORTANT

This document is intended for use by qualified service personnel only.

Issue 2 COMPANY CONFIDENTIAL Page iii

RM-42

Nokia Customer Care Warnings and cautions

Warnings and cautions

Warnings

• IF THE DEVICE CAN BE INSTALLED IN A VEHICLE, CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/ MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.

• THE PRODUCT MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES, FOR EXAMPLE, PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.

• OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.

• BEFORE MAKING ANY TEST CONNECTIONS, MAKE SURE YOU HAVE SWITCHED OFF ALL EQUIPMENT.

Cautions

• Servicing and alignment must be undertaken by qualified personnel only.

• Ensure all work is carried out at an anti-static workstation and that an anti-static wrist strap is worn.

• Ensure solder, wire, or foreign matter does not enter the telephone as damage may result.

• Use only approved components as specified in the parts list.

• Ensure all components, modules, screws and insulators are correctly re-fitted after servicing and alignment.

• Ensure all cables and wires are repositioned correctly.

• Never test a mobile phone WCDMA transmitter with full Tx power, if there is no possibility to perform the measurements in a good performance RF-shielded room. Even low power WCDMA transmitters may disturb nearby WCDMA networks and cause problems to 3G cellular phone communication in a wide area.

• During testing never activate the GSM or WCDMA transmitter without a proper antenna load, otherwise GSM or WCDMA PA may be damaged.

Page iv COMPANY CONFIDENTIAL Issue 2

RM-42 ESD protection Nokia Customer Care

ESD protection

Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone.

Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.

To replace the covers ESD protection must be applied. All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity

discharge. All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside

any ESD Protected Area (EPA). Every repair action involving opening the product or handling the product components must be done under

ESD protection. ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area. For more information and local requirements about ESD protection and ESD Protected Area, contact your local

Nokia After Market Services representative.

Issue 2 COMPANY CONFIDENTIAL Page v

RM-42

Nokia Customer Care Care and maintenance

Care and maintenance

This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years.

• Keep the phone and all its parts and accessories out of the reach of small children.

• Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits.

• Do not use or store the phone in dusty, dirty areas. Its moving parts can be damaged.

• Do not store the phone in hot areas. High temperatures can shorten the life of electronic devices, damage batteries, and warp or melt certain plastics.

• Do not store the phone in cold areas. When it warms up (to its normal temperature), moisture can form inside, which may damage electronic circuit boards.

• Do not drop, knock or shake the phone. Rough handling can break internal circuit boards.

• Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the phone.

• Do not paint the phone. Paint can clog the moving parts and prevent proper operation.

• Use only the supplied or an approved replacement antenna. Unauthorised antennas, modifications or attachments could damage the phone and may violate regulations governing radio devices.

All of the above suggestions apply equally to the product, battery, charger or any accessory.

Page vi COMPANY CONFIDENTIAL Issue 2

RM-42 Company Policy Nokia Customer Care

Company Policy

Our policy is of continuous development; details of all technical modifications will be included with service bulletins.

While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/email.

Please state:

• Title of the Document + Issue Number/Date of publication

• Latest Amendment Number (if applicable)

• Page(s) and/or Figure(s) in error

Please send to:

NOKIA CORPORATION Nokia Mobile Phones Business Group Nokia Customer Care PO Box 86 FIN-24101 SALO Finland E-mail: Service.Manuals@nokia.com

Issue 2 COMPANY CONFIDENTIAL Page vii

RM-42

Nokia Customer Care Battery information

Battery information

Note: A new battery's full performance is achieved only after two or three complete charge and

discharge cycles!

The battery can be charged and discharged hundreds of times but it will eventually wear out. When the operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery.

Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer. Unplug the charger when not in use. Do not leave the battery connected to a charger for longer than a week, since overcharging may shorten its lifetime. If left unused a fully charged battery will discharge itself over time.

Temperature extremes can affect the ability of your battery to charge. For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by leaving the

product switched on until it turns itself off (or by using the battery discharge facility of any approved accessory available for the product). Do not attempt to discharge the battery by any other means.

Use the battery only for its intended purpose. Never use any charger or battery which is damaged. Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object (coin, clip or

pen) causes direct connection of the + and - terminals of the battery (metal strips on the battery) for example when you carry a spare battery in your pocket or purse. Short-circuiting the terminals may damage the battery or the connecting object.

Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions, will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C and 25°C (59°F and 77° F). A phone with a hot or cold battery may temporarily not work, even when the battery is fully charged. Batteries' performance is particularly limited in temperatures well below freezing.

Do not dispose of batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste.

Page viii COMPANY CONFIDENTIAL Issue 2

RM-42 Nokia N90 Service Manual Structure Nokia Customer Care

Nokia N90 Service Manual Structure

1 General Information 2 Parts Lists and Component Layouts 3 Service Software Instructions 4 Service Tools and Service Concepts 5 Disassembly / Reassembly Instructions 6 BB Troubleshooting and Manual Tuning Guide 7 RF Troubleshooting and Manual Tuning Guide 8 Camera Module Troubleshooting 9 System Module 10 Schematics

Issue 2 COMPANY CONFIDENTIAL Page ix

RM-42

Nokia Customer Care Nokia N90 Service Manual Structure

(This page left intentionally blank.)

Page x COMPANY CONFIDENTIAL Issue 2

Nokia Customer Care

1 — General Information

Issue 2 COMPANY CONFIDENTIAL Page 1 –1

RM-42

Nokia Customer Care General Information

(This page left intentionally blank.)

Page 1 –2 COMPANY CONFIDENTIAL Issue 2

RM-42 General Information Nokia Customer Care

Table of Contents

RM-42 product selection........................................................................................................................................1–5

RM-42 transceiver features....................................................................................................................................1–5

RM-42 mobile enhancements................................................................................................................................1–8

Technical specifications.......................................................................................................................................1–10

RM-42 transceiver general specifications.....................................................................................................1–10

Main RF characteristics for triple-band (EGSM900/GSM1800/GSM1900) and WCDMA phones.................1–10

Battery endurance...........................................................................................................................................1–11

Environmental conditions..............................................................................................................................1–11

List of Tables

Table 1 Batteries.....................................................................................................................................................1–8

Table 2 Chargers.....................................................................................................................................................1–8

Table 3 Car accessories..........................................................................................................................................1–8

Table 4 Pop-PortTM accessories............................................................................................................................1–9

Table 5 Imaging accessories.................................................................................................................................1–9

Table 6 Bluetooth accessories...............................................................................................................................1–9

Table 7 Other accessories....................................................................................................................................1–10

List of Figures

Figure 1 View of RM-42..........................................................................................................................................1–5

Issue 2 COMPANY CONFIDENTIAL Page 1 –3

RM-42

Nokia Customer Care General Information

(This page left intentionally blank.)

Page 1 –4 COMPANY CONFIDENTIAL Issue 2

RM-42 General Information Nokia Customer Care

RM-42 product selection

The Nokia RM-42 is a GSM/WCDMA Dual mode hand portable phone supporting EGSM 900/1800/1900 and WCDMA 2100 (UMTS).

The Nokia RM-42 is a 3GPP Release 99 terminal supporting WCDMA, EGPRS and GPRS data bearers. For WCDMA the maximum bit rate is up to 384 kbps for downlink and 128 kbps for uplink with simultaneous CS speech (12.2 kbps). For GSM networks the Nokia RM-42 is a class B terminal with EGPRS multislot class 10 (4 Rx + 1 Tx, 3+2) and GPRS multislot class 10 (4+1, 3+2)

According to GSM standard 05.05 it responds to class 4 (max. 2W) in EGSM 900, class 1 (1W) in DCS 1800 and class 1 in PCS 1900. The Nokia RM-42 supports EGPRS (EDGE) class B as well as Bluetooth 1.1 standard.

The handset has full phase 2 Type Approval and complies with GSM Type Approval. It has full CE approval and FCC approval.

Nokia RM-42 is supporting two way video calls with one integrated swing axis camera. Nokia RM-42 is an MMS (Multimedia Messaging Service) enabled phone with a large bright high-resolution color display and an integrated 2.0 Mega Pixel (effective image size 1.92 Megapixel) digital camera. The MMS implementation follows the OMA MMS standard release 1.2. The WAP 2.0 compatible Browser supports XHTML Mobile Profile (MP) and uses a TCP/IP stack to communicate with a gateway in network.

Nokia RM-42 uses Symbian 8.1a operating system and supports also MIDP Java 2.0 & CLDC1.1, providing a good platform for compelling 3rd party applications.

Figure 1 View of RM-42

RM-42 transceiver features

Displays

Main display:

• · A high resolution, full graphics, TFT (Thin Film Transistor) Active Matrix colour display (262144 colors, 18bit)

• · Display resolution is 352 x 416 pixels

• · 416 x 352 in landscape view

Issue 2 COMPANY CONFIDENTIAL Page 1 –5

RM-42

Nokia Customer Care General Information

• · Active area dimensions are 34.85 mm x 41.18 mm (Approx 2.12" Diagonal) Cover display:

• · A full graphics, TFT (Thin Film Transistor) Active Matrix colour display (65536 colors, 16-bit)

• · Display resolution is 128 x 128 pixels

• · Active area dimensions are 27.69 x 27.69 mm Both displays are of transflective active matrix type. This means display works as a reflective display (backlight

off) in bright light conditions and as a transmissive display (backlight on) in low light conditions.

Camera

Nokia RM-42 has one integrated swing axis digital camera supporting still image and video capture. Same camera is also used for video calls.

Nokia RM-42 camera characteristics are following:

Sensor type: CMOS Sensor Photo detectors: 2.0 million F number/Aperture: F2.88 Focal length: f5.5mm (35mm film format equivalent f35mm) Focus range: 10cm (macro mode) to infinity Still image resolutions: 1600x1200, 800x600, 640x480 Still image file format: EXIF (JPEG), *.jpg Still image compression: • Low: Q value 50 (typically 80-150kB image file)

• Basic: Q value 50 (typically 80-150kB image file)

• Normal: Q value 82 (default setting, 200-250kB)

• Fine: Q value 94 (approximately 300-700+ kB)

Video resolutions: 352x288 (CIF), 176x144, 128x96. All 15 frames per

second.

Video clip length: 30 seconds or free. Maximum clip length in free

mode is one hour.

Video file formats: MPEG-4, .mp4 and 3GPP, *.3gp (mp4: 768kbpss, 3gp:

64kbps in short mode and 128kbps in maximum

mode) Exposure: Automatic and manual White balance: Automatic or adjustable ISO: 250 - 2000 (Automatic) Colours: 16.7 million / 24-bit Capture modes: Night mode, sequence mode, selftimer

Hardware characteristics

• · Dual mode WCDMA/GSM and triband GSM 900/1800/1900 (WCDMA 2100)

Page 1 –6 COMPANY CONFIDENTIAL Issue 2

RM-42 General Information Nokia Customer Care

• · Codecs: Decoding: MP3, AAC, Real Audio, WAV, Nokia Ring Tones, AMR, AMR-WB, AMR-NB, AU, MIDI, H.263, JPEG, JPEG2000, EXIF 2.2, GIF 87/89, PNG, BMP (W-BMP), MBM, MPEG-4 Encoding: AMR, AMR-NB, AAC, H.263, JPEG, EXIF 2.2, MPEG-4

• · Main display: 2.1” (34x41mm) up to 262,144 colours TFT Active matrix display, 352x416 pixels

• · Cover display:27.7x27.7mm up to 65,536 colours TFT Active matrix display,128x128pixels

• · Keymat: ITU-T keymat, plastic keys and metal domes

• · Antenna: Internal

• · Ringing vol.: 105 dB from 5cm distance

• · Charging: 2mm jack, or via Pop-Port

• · Headset: Pop-Port connector/Bluetooth connectivity

• · Memory: 35MB internal memory and 64 MB Reduced Size Dual Voltage MultiMediaCard (RS-MMC) in the standard sales package

• · Camera: 2Mpixel (effective resolution 1.92 Mpixel, 1600x1200 pixels)

• · Flash: LED flash integrated to camera unit

UI features

• · High resolution display 352x416 pixels, up to 262,144 colours

• · Landscape oriented user interface for camcorder mode

• · Cover display in Nokia Series 60 phone 128x128 pixels up to 65536 colours

• · Fold and twist form factor combined with rotating camera unit (four axis concept)

• · 2Mpix (effective resolution 1.92Mpixel) autofocus camera

• · MP4 for video recording and playback (MPEG4 & AAC-LC)

• Speaker Independent Name Dialling (SIND)

Sales package

• · Customer Tranceiver

• · Wrist trap

• · Cleaning towel

• · Charger AC-4

• · Charger adapter CA-44 2.5/2mm

• · Battery BL-5B

• · 1-2 Booklets

• · Users guide(s) 1 languages per package

• · Club Nokia

• · Warranty disclaimer

• · Enhancements

• · Add-on Applications Guide(MMC and CD-ROM)

• · MMC application and warranty disclaimer

• · Quick Start Guide

• · Sample Image Print

• · MMC Carrying Case

• · 64MB RS-MMC Memory Card MU-1

Issue 2 COMPANY CONFIDENTIAL Page 1 –7

RM-42

Nokia Customer Care General Information

• · Adapter to full size MMC

• · Label

• · CD-ROM

• · PC Suite, applications, etc.

• · Stereo headset HDS-3

• · Data cable CA-53 (or DKU-2)

• · Sales box + 3 inner parts

RM-42 mobile enhancements

Table 1 Batteries

Battery Type Product code

Battery BL-5B

Table 2 Chargers

Chargers Type Product code

Fast travel charger (multi-

ACP-12A

voltage), Australia Fast travel charger (multi-

ACP-12AR

voltage), Argentina Fast travel charger (multi-

ACP-12C

voltage), China Fast travel charger (Euro plug),

ACP-12E

100- 240 Vac Fast travel charger (US plug), 100-

ACP-12US

240 Vac Travel charger (multi-voltage),

ACP-12UB

Brazil/Portugal Fast travel charger, Japan ACP-12J Fast travel charger (gradiente

ACP-12G

CR1000), Brazil Fast travel charger (UK plug),

ACP-12X

multi-voltage Retractable travel charger

AC-1E

(Europe) Retractable travel charger (UK) AC-1X Charging adapter CA-44

Table 3 Car accessories

Car accessories Type Product code

Headres handsfree BHF-3

Page 1 –8 COMPANY CONFIDENTIAL Issue 2

RM-42 General Information Nokia Customer Care

Car accessories Type Product code

Plug-in car handsfree HF-3 Wireless plug-in car handsfree HF-6W Wireless car kit CK-1W Advanced car kit CK-7W Mobile charger (LCH-12 update) DC-4

Table 4 Pop-PortTM accessories

Pop Port ™ accessories Type Product code

Boom mono headset HDB-4 Fashion stereo headset HDS-3 Mono headset HS-5 Stereo headset HS-3 Retractable headset HS-10 USB data cable DKU-2 Loopset LPS-4 FM radio headset HS-2R

Table 5 Imaging accessories

Imaging accessories Type Product code

Nokia remote camera PT-6 Image album PD-1

Table 6 Bluetooth accessories

Bluetooth accessories Type Product code

Wireless headset HDW-3 Wireless clip-on headset HS-21W Wireless boom headset HS-4W Wireless headset HS-11W Wireless image headset HS-13W Wireless plug-in car handsfree HF-6W Wireless car kit CK-1W Advanced car kit CK-7W Wireless GPS module LD-1W Wireless keyboard SU-8W

Issue 2 COMPANY CONFIDENTIAL Page 1 –9

RM-42

Nokia Customer Care General Information

Table 7 Other accessories

Other accessories Type Product code

64MB MultiMediaCard MU-1 128MB MultiMediaCard MU-2 256MB MultiMediaCard MU-9 512MB MultiMediaCard MU-12 Connectivity cable DKU-2 Connectivity cable CA-53

Technical specifications

RM-42 transceiver general specifications

Unit Dimensions (L x W x T) Weight (g) Volume (cm3)

Transceiver without BL-5B 760mAh Li-ion battery back

112 x 51 x 24 173 126cc

Main RF characteristics for triple-band (EGSM900/GSM1800/GSM1900) and WCDMA phones

Parameter Unit

Cellular system EGSM900, GSM1800/1900 and WCDMA Rx frequency band EGSM900: 925 - 960 MHz

GSM1800: 1805 - 1880 MHz GSM1900: 1930 - 1990 MHz WCDMA: 2110 - 2170 MHz

Tx frequency band EGSM900: 880 - 915 MHz

GSM1800: 1710 - 1785 MHz GSM1900: 1850 - 1910 MHz WCDMA: 1920 - 1980 MHz

Output power GSM900: +5 … +33dBm/3.2mW … 2W

GSM1800: +0 … +30dBm/1.0mW … 1W GSM1900: +0 … +30dBm/1.0mW … 1W WCDMA -50 … 21 dBm

Number of RF channels GSM900: 125

GSM1800: 375 GSM1900: 300

Channel spacing 200 kHz

Page 1 –10 COMPANY CONFIDENTIAL Issue 2

RM-42 General Information Nokia Customer Care

Parameter Unit

Number of Tx power levels GSM900: 15

GSM1800: 16 GSM1900: 16

Battery endurance

Battery Capacity (mAh) Talk time Stand-by

BL-5B 760 up to 3 hrs up to 12 days

Charging times

ACP-12 LCH-12

1 h 1 h

Environmental conditions

Environmental condition Ambient temperature Notes

Normal operation No operation or storage

Charging allowed Long term storage conditions

-10oC...+55oC <-40oC...>+85oC

-25oC...+50oC 0oC...+85oC

Specifications fulfilled No storage or operation: an

attempt may damage the phone.

Issue 2 COMPANY CONFIDENTIAL Page 1 –11

RM-42

Nokia Customer Care General Information

(This page left intentionally blank.)

Page 1 –12 COMPANY CONFIDENTIAL Issue 2

Nokia Customer Care

2 — Parts Lists and Component

Layouts

Issue 2 COMPANY CONFIDENTIAL Page 2 –1

RM-42

Nokia Customer Care Parts Lists and Component Layouts

(This page left intentionally blank.)

Page 2 –2 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Table of Contents

Exploded view.........................................................................................................................................................2–5

RM-42 exploded view........................................................................................................................................2–5

Parts lists.................................................................................................................................................................2–6

Mechanical spare parts overview....................................................................................................................2–6

Mechanical spare parts list...............................................................................................................................2–7

Component parts lists.......................................................................................................................................2–9

Component layouts..............................................................................................................................................2–71

RM-42 component layout - top......................................................................................................................2–71

RM-42 component layout - bottom...............................................................................................................2–72

List of Tables

Table 8 Component parts list................................................................................................................................2–9

List of Figures

Figure 2 RM-42 exploded view..............................................................................................................................2–5

Issue 2 COMPANY CONFIDENTIAL Page 2 –3

RM-42

Nokia Customer Care Parts Lists and Component Layouts

(This page left intentionally blank.)

Page 2 –4 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Exploded view

RM-42 exploded view

Issue 2 COMPANY CONFIDENTIAL Page 2 –5

Figure 2 RM-42 exploded view

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Parts lists

Mechanical spare parts overview

Page 2 –6 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Mechanical spare parts list

Bold=ASSY "XXXXXXX" = VARIANTS "-" = NOT AVAILABLE "???????" = AVAILABLE AS SPARE PART I0xx = ITEM codes for upper or mono block I1xx = ITEM codes for hinge block I2xx = ITEM codes for lower block I3xx = ITEM codes for soldered spare parts on the upper, hinge or lower block and not exchangable

ITEM QTY PART NO PART NAME

I001 2 ???????? SCREW T6+ 1.8X6

XXXXXXX B-COVER ASSY

I002 1 XXXXXXX B-COVER I003 1 ??????? MAGNET

B-COVER TRIM (INCL.

I004 1 ??????? I005 2 ??????? SCREW T6+ 1.8X6 I006 1 ??????? INNER K2 LCD (352X416)

I007 1 XXXXXXX I008 2 ??????? SCREW T6+ 1.8X6 i009 1 ??????? D-COVER

??????? DISPLAY FRAME ASSY

I010 1 - EARPIECE I011 2 - SWITCH I012 1 - DISPLAY FLEX ASSY

I013 1 -

I014 1 ??????? OUTER LCD (130X130)

ADHESIVE

D-COVER TRIM (INCL. ADHESIVE)

DISPLAY FRAME MOULDING

I015 1 ??????? DISPLAY SHIELD I016 1 XXXXXXX A-COVER ASSY

XXXXXXX C-COVER ASSY

I017 1 ??????? C-COVER

C-COVER TRIM (INCL.

I018 1 XXXXXXX

Issue 2 COMPANY CONFIDENTIAL Page 2 –7

ADHESIVE)

RM-42

Nokia Customer Care Parts Lists and Component Layouts

ITEM QTY PART NO PART NAME

I101 2 ??????? COSMETIC LAYER I102 1 XXXXXXX E-COVER I103 4 ??????? SCREW T5+ 1.6X5

??????? HINGE ASSY

I104 1 - HINGE I105 1 - CONNECTION CABLES

I106 1 ??????? CAMERA I107 1 ??????? CAMERA SOCKET

CAMERA BEZEL INCL.

I108 1 ???????

??????? AUDIO MODULE

I109 1 - LED WINDOW

WINDOW

I110 1 - FLASH LIGHT LED I111 1 - AUDIO CAVITY I112 1 - POWER BUTTON

I113 1 ??????? IHF SPEAKER I114 1 XXXXXXX G-COVER ASSY

I201 1 ??????? I-COVER TRIM I202 2 ??????? SCREW T6+ 1.8X8.5 I203 1 XXXXXXX I-COVER I204 1 XXXXXXX KEYMAT I205 4 ??????? SCREW T6+ 1.8X7

??????? ENGINE UI ASSY

I206 1 ??????? SIDE KEY BEZEL ASSY I207 1 ??????? JOYSTICK HAT I208 1 ??????? RETAINER PLATE I209 1 - DOMESHEET I210 1 - JOYSTICK I211 1 - CAPTURE KEY I212 1 - FLEX FOIL I213 4 - LEDS I214 1 - BB SHIELD ASSY I215 1 ??????? MICROPHONE CASE

Page 2 –8 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

ITEM QTY PART NO PART NAME

I216 1 ??????? MICROPHONE

I217 1 ??????? PA LID I218 1 ??????? ENGINE MODULE I219 1 ??????? RF-ENGINE LID

XXXXXXX H-COVER ASSY

I220 1 ??????? DC JACK I221 1 ??????? ANTENNA WCDMA I222 1 ??????? MMC COVER ASSY I223 1 - GSM ANTENNA I224 1 - H-COVER I225 1 - H-COVER TRIM

BATTERY COVER RELEASE

I226 1 ???????

BUTTON BATTERY COVER RELEASE

I227 1 ???????

SPRING

I228 1 ??????? POP-PORT COVER I229 1 ??????? TYPE LABEL I230 1 XXXXXXX BATTERY COVER

Component parts lists

Table 8 Component parts list

Item Side Grid ref. Description and Value

RF-ENGINE SHIELD

A7400 Bottom M 7

A7401 Top N 5

I216 Top P 9

SHIELD_04 0_003698

SHIELD_04 0_003699

MIC_OBE_4 15S42_RC3 310CL

ASSY R1107

PA-SHIELD ASSY R1107

CLAPTON EMC MICROPHO NE MOD

-42DB CRYSTAL

32.768KHZ

B2200 Top K 5

CRYSTAL_3 .3X1.6NR

+-20PPM

12.5PF 32.768kHz

Issue 2 COMPANY CONFIDENTIAL Page 2 –9

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N

C1470 Top I 1 0402C

C1471 Top I 2 0805C

C1472 Top I 1 0805C

C1473 Top D 6 0603C

C1474 Bottom C 1 0402C

C1475 Top D 4 0402C

K 10V 0402 100n 10V CHIPCAP

X5R 22U M 6V3 0805 22u 6V3

CHIPCAP X5R 10U M 6V3 0805 10U 6V3

CHIPCAP X5R 2U2 K 6V3 0603 2u2 6V3

CHIPCAP X5R 100N K 10V 0402 100n 10V

Chipcap 5% X7R 3n3 50V

C1476 Top D 4 0603C

C1477 Top C 5 0402C

C1478 Top C 6 0402C

C1479 Top J 1 0402C

C1480 Top K 1 0402C

C1481 Top K 1 0402C

C1482 Top D 4 0402C

CHIPCAP X5R 2U2 K 6V3 0603 2u2 6V3

Chipcap X5R 10%

6.3V 0402 220n 6.3V CERCAP

X7R 22N K 16V 0402 22n 16V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap X7R 10% 16V 0402 10n 16V

Chipcap X7R 10%

C1483 Top D 6 0402C

C1484 Top B 3 0402C

Page 2 –10 COMPANY CONFIDENTIAL Issue 2

16V 0402 10n 16V Chipcap

X7R 10% 16V 0402 10n 16V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C1485 Top B 2 0402C

C1486 Top C 4 0402C

C1487 Bottom C 2 0402C

C1488 Bottom C 1 0402C

C1489 Top G 2 0402C

C1490 Top G 2 0402C

16V 0402 10n 16V Chipcap

X7R 10% 16V 0402 10n 16V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP NP0 270P J 25V 0402 270p 25V

C2000 Bottom D 1 0402C

C2001 Bottom D 1 0402C

C2002 Top K 2 0805C

C2003 Top K 2 0402C

C2004 Top K 2 0402C

C2005 Top J 2 0402C

C2006 Top J 2 0402C

Chipcap 5% NP0 27p 50V

Chipcap X7R 10% 50V 0402 1n0 50V

CHIPCAP X5R 22U M 6V3 0805 22u 6V3

CERCAP X7R 22N K 16V 0402 22n 16V

Chipcap X7R 10% 16V 0402 10n 16V

Chipcap X7R 10%

C2007 Bottom L 2 0402C

C2008 Bottom L 2 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –11

16V 0402 10n 16V Chipcap

X7R 10% 16V 0402 10n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C2009 Bottom K 2 0402C

C2010 Bottom K 2 0402C

C2011 Top H 2 0402C

C2070 Bottom L 3 0402C

C2100 Top L 5 0402C

C2101 Top L 5 0402C

16V 0402 10n 16V Chipcap

X7R 10% 16V 0402 10n 16V

CHIPCAP NP0 270P J 25V 0402 270p 25V

Chipcap 5% NP0 15p 50V

CERCAP X7R 22N K 16V 0402 22n 16V

C2102 Top L 6 0603C

C2200 Top L 4 0603C

C2201 Top J 5 0603C

C2202 Top L 5 0402C

C2203 Top K 5 0402C

C2204 Top L 4 0402C

C2205 Top L 5 0402C

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap X7R 10%

C2206 Top L 5 0402C

C2207 Top J 4 0402C

Page 2 –12 COMPANY CONFIDENTIAL Issue 2

50V 0402 1n0 50V Chipcap

X7R 10% 50V 0402 1n0 50V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap

C2208 Top K 5 0402C

C2209 Top K 5 0402C

C2210 Top J 3 0603C

C2211 Top J 3 0805C

C2212 Top K 3 0603C

C2213 Top I 3 0603C

5% NP0 27p 50V Chipcap

5% NP0 22p 50V CHIPCAP

X5R 1U K 16V 0603 1u0 16V

CHIPCAP X5R 4U7 K 10V 0805 4u7 10V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C2214 Top L 5 0603C

C2215 Top I 3 0603C

C2216 Top J 3 0603C

C2217 Top I 3 0603C

C2219 Top J 4 0603C

C2220 Top K 3 0603C

C2221 Top K 3 0603C

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K

C2222 Top K 3 0603C

C2223 Top L 4 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –13

6V3 0603 1u0 6.3V Chipcap

X7R 10% 16V 0402 10n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C2224 Top L 5 0402C

C2225 Top K 3 0603C

C2226 Top J 2 0603C

C2227 Top J 4 0603C

C2228 Top J 3 0603C

C2230 Top J 4 0603C

16V 0402 10n 16V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C2231 Top L 3 0805C

C2232 Top J 3 0603C

C2233 Bottom M 2 0402C

C2234 Top J 5 0402C

C2235 Top L 4 0402C

C2300 Top J 6 0402C

C2301 Top J 6 0805C

C2302 Top L 6 0805C

CHIPCAP X5R 10U M 6V3 0805 10U 6V3

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% NP0 27p 50V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 22U M 6V3 0805 22u 6V3

CHIPCAP X5R 1U K

C2303 Top I 6 0603C

Page 2 –14 COMPANY CONFIDENTIAL Issue 2

6V3 0603 1u0 6.3V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C2304 Top J 5 0402C

C2306 Top I 4 0603C

C2307 Top I 4 0603C

C2309 Top I 6 0805C

C2312 Top I 3 0603C

C2313 Top I 3 0603C

16V 0402 10n 16V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 22U M 6V3 0805 22u 6V3

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C2314 Top L 6 0805C

C2315 Top M 5 0805C

C2700 Bottom M 4 0402C

C2800 Top I 3 0402C

C2801 Top H 6 0402C

C2802 Top H 6 0402C

CHIPCAP X5R 4U7 K 25V 0805 4u7 25V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V

C2803 Top I 3 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –15

0402 100n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C2804 Top I 3 0402C

C2805 Top I 3 0402C

C2806 Top G 6 0402C

C2807 Top H 6 0603C

C2808 Top H 6 0402C

0402 100n 16V CHIPCAP

X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 100N M 16V 0402 100n 16V

C2809 Top H 6 0402C

C2810 Top I 3 0402C

C2811 Top G 3 0402C

C2812 Top I 3 0402C

C2813 Top I 2 0402C

C2814 Top I 4 0402C

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap X7R 10%

C2815 Top I 6 0402C

Page 2 –16 COMPANY CONFIDENTIAL Issue 2

50V 0402 1n0 50V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap

C2816 Top H 6 0402C

C3000 Top F 5 0402C

C3001 Top F 5 0402C

C3002 Top F 5 0402C

C3003 Top F 5 0402C

5% NP0 47p 50V CHIPCAP

X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap X7R 10% 16V 0402 10n 16V

C3004 Top G 2 0402C

C3005 Top H 2 0402C

C3006 Top H 2 0402C

C3007 Top I 2 0402C

C3008 Top I 2 0402C

C4200 Top E 9 0805C

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 22U M 6V3 0805 22u 6V3

CHIPCAP X5R 22U M

C4201 Top F 9 0805C

C4202 Top F 9 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –17

6V3 0805 22u 6V3 Chipcap

X7R 10% 16V 0402 10n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 1U K

C4203 Top D 6 0603C

C4400 Bottom D 1 0603C

C4401 Bottom C 1 0603C

C4402 Top L 2 0402C

C4403 Top L 3 0402C

C4800 Top D 9 0402C

6V3 0603 1u0 6.3V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% X7R 1n0 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

C4801 Top G 6 0603C

C4802 Top G 7 0402C

C4803 Top D 9 0402C

C4804 Top G 6 0402C

C4805 Top D 6 0402C

C4806 Top E 9 0402C

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V

C4807 Top F 9 0402C

Page 2 –18 COMPANY CONFIDENTIAL Issue 2

0402 100n 16V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C4808 Top F 5 0402C

C4809 Top G 6 0402C

C4810 Top G 6 0402C

C4811 Top F 9 0402C

0402 100n 16V CHIPCAP

X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

C4812 Top G 6 0402C

C4813 Top G 6 0402C

C5000 Top D 7 0402C

C5001 Top D 7 0402C

C5002 Top D 8 0402C

C5003 Top D 7 0402C

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap X7R 10% 50V 0402 1n0 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V

C5004 Top D 8 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –19

0402 100n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C5005 Top D 8 0402C

C5200 Top H 7 0603C

C6031 Top H 9 0402C

C6032 Top H 8 0402L

C6033 Top G 9 0603C

0402 100n 16V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% NP0 15p 50V

CHIP COIL 2N2+-0N3 Q30/800M 0402 2n2H ~

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

C6036 Top G 8 0402C

C6037 Top G 9 0402C

C6038 Top H 7 0402C

C6039 Top H 8 0402C

C6040 Top G 9 0402C

C6041 Top H 8 0402C

C6042 Top H 8 0402C

CHIPCAP X5R 1U5 K 4V 0402 1u5 4V

CHIPCAP X5R 100N K 10V 0402 100n 10V

CHIPCAP X5R 0U47 K 6.3V 0402 0u47 6V3

CHIPCAP X5R 1U K 6V3 0402 1u0 6.3V

CHIPCAP X5R 0U47 K 6.3V

C6043 Top G 8 0402C

C7501 Bottom M 7 0402C

Page 2 –20 COMPANY CONFIDENTIAL Issue 2

0402 0u47 6V3 Chipcap

5% NP0 18p 50V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 1U K

C7503 Bottom M 7 0603C

C7504 Bottom M 7 0603C

C7505 Bottom L 6 0402C

C7507 Bottom M 5 0402C

C7508 Bottom L 5 0402C

C7509 Bottom M 5 0402C

6V3 0603 1u0 6.3V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap 5% NP0 18p 50V

Chipcap +-0.25pF NP0 2p7 50V

C7512 Top P 3 0402C

C7513 Bottom L 6 0402C

C7514 Top P 3 0402C

C7515 Bottom K 6 0402C

C7516 Bottom K 6 0402C

C7518 Bottom N 7 0402C

C7520 Bottom N 7 0402C

C7522 Bottom K 5 0402C

Chipcap +-0.25pF NP0 2p7 50V

Chipcap X7R 10% 25V 0402 4n7 25V

Chipcap +-0.25pF NP0 2p7 50V

Chipcap 5% NP0 10p 50V

Chipcap 5% NP0 150p 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap 5% NP0 18p 50V

Chipcap 5% NP0 150p 50V

Chipcap +-0.25pF

C7523 Top O 3 0402C

C7524 Bottom L 5 0603C

Issue 2 COMPANY CONFIDENTIAL Page 2 –21

NP0 5p6 50V CHIPCAP

NP0 2N2 G 16V 0603 2n2 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap +-0.25pF

C7525 Top O 3 0402C

C7526 Bottom K 7 0402C

C7527 Bottom M 5 0402C

C7528 Bottom M 5 0402C

C7529 Bottom L 6 0402C

C7530 Bottom L 7 0402C

NP0 5p6 50V Chipcap

X7R 5% 16V 0402 10n 16V

Chipcap 5% NP0 100p 50V

Chipcap 5% NP0 22p 50V

Chipcap 5% NP0 100p 50V

Chipcap X7R 10% 16V 0402 8n2 16V

C7531 Bottom M 5 0402C

C7532 Bottom L 6 0402C

C7533 Bottom K 7 0402C

C7534 Bottom L 7 0402C

C7535 Bottom L 6 0402C

C7536 Bottom M 7 0402C

C7537 Top P 4 0402C

C7538 Top O 4 0402C

Chipcap 5% NP0 22p 50V

Chipcap X7R 10% 16V 0402 8n2 16V

Chipcap X7R 10% 16V 0402 10n 16V

Chipcap X7R 10% 16V 0402 8n2 16V

Chipcap 5% NP0 100p 50V

Chipcap X7R 10% 16V 0402 8n2 16V

Chipcap 5% NP0 100p 50V

Chipcap

C7539 Top P 4 0402C

C7540 Bottom N 9 0402C

C7541 Bottom N 9 0603C

Page 2 –22 COMPANY CONFIDENTIAL Issue 2

5% NP0 100p 50V Chipcap

5% NP0 18p 50V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap

C7542 Bottom N 9 0402C

C7543 Bottom N 8 0603C

C7544 Top M 5 0402C

C7545 Top N 5 0402C

C7547 Bottom N 9 0402C

C7548 Bottom N 9 0603C

5% NP0 18p 50V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

Chipcap +-0.25pF NP0 4p7 50V

Chipcap +-0.25pF NP0 1p8 50V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C7549 Bottom N 8 0402C

C7550 Bottom L 9 0402C

C7552 Bottom L 9 0402C

C7553 Bottom L 9 0402C

C7554 Bottom K 8 0402C

C7555 Bottom K 8 0402C

C7556 Top N 3 0402C

C7558 Bottom N 8 0402C

Chipcap 5% NP0 100p 50V

Chipcap +-0.25pF NP0 2p7 50V

Chipcap X7R 10% 16V 0402 8n2 16V

Chipcap +-0.25pF NP0 4p7 50V

CHIPCAP NP0 0P5 C 50V 0402 0p5 50V

Chipcap 5% NP0 10p 50V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap +-0.25pF

C7559 Top O 4 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –23

NP0 1p0 50V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C7560 Bottom L 8 0402C

C7561 Top N 3 0402C

C7562 Bottom N 9 0402C

C7563 Top N 3 0402C

C7564 Top O 4 0402C

C7567 Bottom M 7 0402C

25V 0402 4n7 25V Chipcap

+-0.25pF NP0 4p7 50V

CHIPCAP NP0 0P5 C 50V 0402 0p5 50V

Chipcap +-0.25pF NP0 4p7 50V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap 5% NP0 15p 50V

C7568 Bottom M 9 0402C

C7569 Top N 3 0603C

C7570 Bottom L 8 0402C

C7571 Bottom L 8 0402C

C7573 Bottom M 9 0603C

C7575 Bottom M 8 0402C

C7576 Top P 4 0402C

C7577 Bottom M 8 0402C

Chipcap 5% NP0 150p 50V

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap 5% NP0 18p 50V

CHIPCAP NP0 330P J 50V 0402 330p 50V

CHIPCAP NP0 2N2 G 16V 0603 2n2 16V

Chipcap 5% NP0 15p 50V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap 5% NP0 15p 50V

Chipcap

C7578 Top O 5 0402C

C7579 Top P 6 0402C

Page 2 –24 COMPANY CONFIDENTIAL Issue 2

5% NP0 10p 50V Chipcap

5% NP0 10p 50V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 1U K

C7580 Top P 6 0603C

C7581 Top P 3 0402C

C7582 Bottom L 9 0402C

C7583 Top N 5 0603C

C7584 Top O 3 0402C

C7585 Top O 6 0402C

6V3 0603 1u0 6.3V Chipcap

+-0.25pF NP0 5p6 50V

Chipcap X7R 10% 50V 0402 1n0 50V

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap +-0.25pF NP0 5p6 50V

CHIPCAP NP0 1P0 B 50V 0402 1p0 50V

C7586 Top O 6 0402C

C7587 Top O 6 0402C

C7588 Top N 5 0603C

C7589 Top N 5 0603C

C7590 Top O 5 0402C

C7591 Top O 5 0402C

C7592 Top O 5 0402C

C7593 Top M 3 0603C

Chipcap 5% NP0 10p 50V

CHIPCAP X5R 2U2 K 6V3 0603 2u2 6V3

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap 5% NP0 10p 50V

CHIPCAP NP0 470P J 6V3 0402 470p 6V3

Chipcap 5% X7R 3n3 50V

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap +-0.25pF

C7595 Top M 4 0402C

C7596 Bottom N 6 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –25

NP0 1p2 50V Chipcap

+-0.25pF NP0 2p7 50V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPTCAP 100U M

TANT_6.3X

C7597 Bottom M 2

C7598 Bottom K 6 0402C

D1470 Bottom B 1 PDSO_G5

D1471 Top B 5

3.5_H2.0

P_TFBGA1 21

14V 6X3.2X2 100u_14V 14V

CHIPCAP NP0 0P5 C 50V 0402 0p5 50V

OR-GATE 2INPUT 74LVC1G3 2 SC70-5 ~ ~

DSP TC39C01X BG

8.0X8.0X1. 2 TFBGA121 ~ ~

PBFREEBG A40_64MB _54MHZ_M

D3000 Top E 5

D3001 Top H 2

D4400 Top G 3 DSBGA_5

D5000 Top C 7 FBGA133

F2000 Bottom F 1

AX SDRAM_11

0MHZ_64M BIT_BGA60 _PBFREE_M AX

0603_FUSE _AVX2MATSSM FUSE F

FLASH 4MX16

1.8/1.8V FBGA44 4Mx16 ~

SDRAM 4MX16

1.8V/1.8V WBGA60 PBFREE 4Mx16 ~

NOR 2INPUT 74LVC1G0 2 6.5V DSBGA ~ ~

COMBO 512M DDR +512MNA ND FBGA133 PBFREE

2.0A 32V 2A ~

32Mx16/6 4Mx8 ~

VCO 3610-434

VCO_FDK_

G7500 Bottom L 6

Page 2 –26 COMPANY CONFIDENTIAL Issue 2

WB002

0MHZ 2.7V 15MA

3610-434 0MHz ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

VCTCXO

VCTCXO_KT

G7501 Bottom L 7

L1470 Top I 1

L1471 Top K 1 0603_BLM

L1472 Top K 1 0603_BLM

L2000 Bottom E 1 0603_BLM

21P2

COIL_LQH3 2CN

38.4MHZ

2.5V 38.4MHz ~ CHOKE 10U

K 0R39

0.45A 1210 10uH ~

FERR.BEAD 220R/ 100M 2A 0R05 0603

220R/ 100MHz ~

0405_2_M

L2001 Bottom K 2

L2002 Bottom K 2

L2003 Bottom L 2

L2202 Top L 3 0603_BLM

L2203 Top J 4

ATSU

0405_2_M ATSU

FERRITE_0 402

CHIP BEAD ARRAY 2X1000R 0405

FERR.BEAD 220R/ 100M 2A 0R05 0603

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

2x1000R/ 100MHz ~

220R/ 100MHz ~

600R/ 100MHz ~

FERRITE BEAD 0.6R 600R/

FERRITE_0

L2204 Top J 4

Issue 2 COMPANY CONFIDENTIAL Page 2 –27

402

100MHZ 0402

600R/ 100MHz ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

FERR.BEAD 220R/

L2205 Top J 3 0603_BLM

FERRITE_0

L2206 Top J 3

L2301 Top J 6 0603_BLM

L2302 Top K 6

402

CHOKE_ELL 4LM100M N

100M 2A 0R05 0603

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

FERR.BEAD 220R/ 100M 2A 0R05 0603

CHOKE 10U M 0.69A 0R18 4X4X1.8 10uH ~

220R/ 100MHz ~

600R/ 100MHz ~

220R/ 100MHz ~

CHOKE_98

L2304 Top M 5

L2305 Top M 6

L4200 Top D 9

L4201 Top F 9 0603_BLM

L4400 Bottom D 1

4FB

FERRITE_B K1608

CHOKE_SER 400

FERRITE_0 402

CHOKE 22U M 1R4

0.33A

3.3X3.3X1. 5 22uH ~

FERRITE BEAD 0R35 68R/ 100MHZ 0603

CHOKE 10U

0.8A 0R24 4X4X1.8 10uH ~

FERR.BEAD 220R/ 100M 2A 0R05 0603

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

68R/ 100MHz ~

220R/ 100MHz ~

600R/ 100MHz ~

FERRITE BEAD 0.6R 600R/

FERRITE_0

L4401 Bottom C 1

Page 2 –28 COMPANY CONFIDENTIAL Issue 2

402

100MHZ 0402

600R/ 100MHz ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

FERRITE BEAD 0.6R 600R/

FERRITE_0

L5200 Top G 6

L6030 Top G 9 0402L

L7400 Top P 2 0402L

L7502 Bottom L 9 0402L_POL

402

100MHZ 0402

CHIP COIL 22N J Q28/800M 0402 22nH ~

CHIP COIL 5N6 +-0N3 Q28/800M 0402 5n6H ~

CHIP COIL 82N J Q17/300M 0402 82nH ~

600R/ 100MHz ~

FERRITE_0

L7503 Bottom N 9

L7504 Top P 3 0402L

L7505 Top P 3 0402L

L7506 Top O 3 0402L

L7510 Bottom M 8 0402L

402

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

CHIP COIL 27N J Q27/800M 0402 27nH ~

CHIP COIL 12N J Q31/800M 0402 12nH ~

CHIP COIL 4N7 +-0N3 Q28/800M 0402 4n7H ~

600R/ 100MHz ~

CHIP COIL 10N J Q30/800M

L7511 Bottom M 7 0402L

L7512 Bottom M 8 0402L

Issue 2 COMPANY CONFIDENTIAL Page 2 –29

0402 10nH ~ CHIP COIL

4N7 +-0N3 Q28/800M 0402 4n7H ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIP COIL 1N8+-0N3 Q31/800M

L7513 Bottom N 7 0402L

L7514 Top P 6 0402L

CHOKE_SER

L7515 Top N 6

L7516 Top M 3

400

FERRITE_0 402

0402 1n8H ~ CHIP COIL

8N2 J Q28/800M HZ 0402 8n2H ~

CHOKE 10U

0.8A 0R24 4X4X1.8 10uH ~

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

600R/ 100MHz ~

L7517 Bottom M 9 0402L

USMD_10_

2.458X1.8

N1470 Top I 2

N1471 Top D 5 LLP_6

N2200 Top K 4

N2300 Top J 5

99

TFBGA_10 8

TFBGA_84_

6.15X6.15

CHIP COIL 1N5 +-0N3 Q33/800M 0402 1n5H ~

DC-DC CONV LM2708HT LX-1.57V/

1.35V USMD10 ~ ~

REG LP3981YD X 2.8/ NOPB 0.3A LLP-6 ~ 2.8V

RETU 3.02 TSA1GJWE TFBGA108 ~ ~

TAHVO V4.1 LEADFREE TFBGA84 6X6 ~ ~

WHITE LED DRIVER 4LEDS 500MW

USMD8_1.

N2301 Top M 6

Page 2 –30 COMPANY CONFIDENTIAL Issue 2

69X1.69

8BUMP USMD8 ~ ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

DC_DC CONV

N4200 Top E 9

N4201 Top D 6

N6030 Top G 8

N7500 Bottom M 6

N7501 Bottom M 8

USMD_10_

2.458X1.8 99

USMD4_1. 313X1.033

uBGA63_4. 6X4.6 BRF6150 ~ ~

TFBGA_84_

6.15X6.15

TFBGA64_ H1.2

LM2708H-

1.40V/

1.09V ~ ~ REG 1.8V

4BUMPS 150MA LQ 40UA USMD4 ~ 1.8V

RF ASIC HINKU310 A TFBGA84 ~ ~

RF ASIC VINKU314 A TFBGA64 ~ ~

RITSA_PA_

N7502 Top N 4

N7503 Top P 5

N7504 Top N 5

R1470 Top G 7 0402R

R1471 Top F 7 0402R

R1472 Top G 6 0402R

REL3

PW_AMP_P F57603B

USMD10_2 . 534X2.026

PW AMP PF09014B _CUT5.3 QUADBAN D ~ ~

PW AMP PF57603B CUT8.1 1920-198 0MHZ ~ ~

DC CONV SUPA LM2706 PBFREE ~ ~

Resistor 5% 63mW 100R ~

Resistor 5% 63mW 3k3 ~

Resistor

R1473 Top G 6 0402R

R1474 Top G 2 0402R

R1475 Top C 6 0402R

Issue 2 COMPANY CONFIDENTIAL Page 2 –31

5% 63mW 3k3 ~ Resistor

5% 63mW 150R ~ Resistor

5% 63mW 1k0 ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Resistor

R1476 Top C 5 0402R

R1477 Top C 5 0402R

R1478 Bottom C 1 0402R

R1479 Bottom C 1 0402R

R1480 Top G 2 0402R

R1483 Top D 6 0402R

R1484 Top I 2 0402R

5% 63mW 100R ~ Resistor

5% 63mW 2k2 ~ Resistor

5% 63mW 2k2 ~ Chipres

0W06 jumper 0402 0R ~

Resistor 5% 63mW 100k ~

Resistor 5% 63mW 1k0 ~

R2000 Top K 2 0402R

uBGA11_2.

R2001 Top J 2

R2002 Bottom K 2 0402R

R2003 Bottom K 2 0402R

R2004 Bottom L 2 0402R

R2005 Bottom L 2 0402R

R2006 Bottom K 2 uBGA5

R2007 Top H 1

15X1.65

uBGA11_1. 6X2.15

Resistor 5% 63mW 220R ~

ASIP MIC W/ESD RES +CAP+ZDI BGA11 ~ ~

Resistor 5% 63mW 10R ~

ASIP 4XESD **PBFREE** BGA5 ~ ~

ASIP SILIC USB OTG / ESD BGA11 ~ ~

RES NETWORK 0W06 220K/ 120K J

R2008 Top H 1 0404_RP

Page 2 –32 COMPANY CONFIDENTIAL Issue 2

0404

220k/ 120k ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Resistor

R2009 Top H 1 0402R

R2070 Bottom K 2 0402_VAR

0402_NTH

R2071 Bottom K 5

R2100 Top O 9

5

FLIP_CHIP_ 8_1.7X1.7

5% 63mW 100R ~ CHIP

VARISTOR VWM14V VC50V 0402 14V/50V ~

NTC RES 47K J B=4050 +-3% 0402 47k ~

ASIP SINGLE ENDED MICROPHO NE INTERF BGA8 ~ ~

R2101 Top L 5 0402R

R211 Top J 5 0402R

R2200 Top L 5 0402R

R2201 Top I 4 0402R

R2203 Top K 5 0402R

R2301 Top J 6 0402R

R2302 Top M 6 0402R

R2303 Top L 1 0402R

R2304 Top L 1 0402R

Resistor 5% 63mW 220R ~

Resistor 5% 63mW 47R ~

Resistor 5% 63mW 100k ~

Resistor 5% 63mW 120k ~

Chipres 0W06 5% 0402 3M3 ~

Resistor 5% 63mW 4k7 ~

Resistor 5% 63mW 10k ~

Resistor 5% 63mW 1k0 ~

Resistor 5% 63mW 39R ~

Resistor

R2305 Top L 2 0402R

R2307 Top K 2 0402R

R2308 Top K 3 0402R

Issue 2 COMPANY CONFIDENTIAL Page 2 –33

5% 63mW 33R ~ Resistor

5% 63mW 39k ~ Resistor

5% 63mW 1k0 ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

ASIP EMIF03SIM01F2 **PB-

R2700 Bottom M 4 uBGA8

R3000 Top F 4 0402R

R4400 Top L 2 0402R

R4401 Top L 3 0402R

R4402 Top G 3 0402R

FREE** ~ ~ Resistor

5% 63mW 4k7 ~ Chipres

0W06 jumper 0402 0R ~

Chipres 0W06 jumper 0402 0R ~

Resistor 5% 63mW 47R ~

R4800 Top D 9 0402R

R4801 Top F 9 0402R

R4809 Top F 6 0402R

R5100 Top F 9 0402R

uBGA11_1.

R5200 Top G 7

R5204 Bottom E 10 0402_VAR

R7501 Bottom K 5 0402R

62X2.12

Resistor 5% 63mW 10R ~

Resistor 5% 63mW 100k ~

Resistor 5% 63mW 1k0 ~

Resistor 5% 63mW 10k ~

ASIP EMIF04MMC02F2* *PBFREE** ~ ~

CHIP VARISTOR VWM14V VC50V 0402 14V/50V ~

Resistor 5% 63mW 1k0 ~

Resistor

R7503 Bottom L 8 0402R

R7504 Bottom M 7 0402R

Page 2 –34 COMPANY CONFIDENTIAL Issue 2

5% 63mW 4k7 ~ CHIPRES

0W06 10K F 0402 10k ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPRES 0W06 8K2

R7505 Bottom K 5 0402R

R7506 Top N 3 0402R

R7509 Bottom K 7 0402R

0404_RAC

R7512 Top M 3

R7514 Bottom N 8 0402R

R7516 Top O 4 0402R

10

F 0402 8k2 ~ Resistor

5% 63mW 33R ~ Resistor

5% 63mW 22k ~ RES

NETWORK 0W04 2DB ATT 0404

Resistor 5% 63mW 12k ~

Resistor 5% 63mW 1k0 ~

436R/ 11R6/436 R ~

R7517 Top O 4 0402R

R7518 Top N 5 0402R

R7519 Bottom M 9 0402R

R7520 Bottom M 8 0402R

R7521 Bottom N 8 0402R

R7522 Top O 5 0402R

R7523 Bottom M 9 0402R

R7525 Top O 5 0402R

Resistor 5% 63mW 3k3 ~

Resistor 5% 63mW 470k ~

Resistor 5% 63mW 1k0 ~

Resistor 5% 63mW 270R ~

CHIPRES 0W06 10K F 0402 10k ~

Resistor 5% 63mW 220k ~

CHIPRES 0W06 9K1 F 100PPM 0402 9k1 ~

Resistor 5% 63mW 10R ~

Resistor

R7526 Top O 6 0402R

R7527 Top O 6 0402R

R7528 Bottom M 9 0402R

R7529 Top O 5 0402R

Issue 2 COMPANY CONFIDENTIAL Page 2 –35

5% 63mW 5k6 ~ Resistor

5% 63mW 220R ~ Resistor

5% 63mW 470k ~ Resistor

5% 63mW 2k2 ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Resistor

R7530 Top O 5 0402R

R7531 Top O 5 0402R

R7534 Top N 5 0402R

5% 63mW 8k2 ~ Resistor

5% 63mW 470k ~

S5200 Bottom H 9

T7500 Bottom N 6

T7501 Bottom L 5

T7502 Top M 3

T7503 Bottom K 9

SWITCH_JP S1110_52 01F

TRANS_LD B15

SWITCH SPST 5V

0.01A ~ ~ TRANSF

BALUN 2134 +-90MHZ 0805 ~ ~

TRANSF BALUN 3800 +-550MHZ 0805 ~ ~

TRANSF BALUN 1800 +-100mhz 2x1.25 ~ ~

TRANSF BALUN 3800 +-550MHZ 0805 ~ ~

TVS DI 1PMT16AT 3 16V 175W

V2000 Bottom E 1 CASE_457

V2300 Top L 6 VMT3_R

V2301 Top K 2 VMT3

Page 2 –36 COMPANY CONFIDENTIAL Issue 2

PWRMITE ~ ~ TR

DTC143ZM N RB=4K7 RBE=47K VMT3 ~ ~

TR 2SC5658Q RS N 50V 0A1 0W15 VMT3 ~ ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

TR 2SC5658Q RS N 50V 0A1 0W15

V2303 Top K 2 VMT3

V7500 Top O 6 SOT_563

ANTENNA_

W1 Bottom J 9

I220 Bottom H 1

G1_BT

CON_JACK_ HR33NK_2 DJA_2S

VMT3 ~ ~ SCHDIX2

RF DETECTOR CT 1PF 0V39 SOT666 ~ ~

MURATA CERAMIC BT ANTENNA G1 SERIES ~ ~

CONN DCJACK

2.0MM 3POL SPR 90DEG ~ ~

X2001 Bottom K 1

X2061 Bottom O 3

X2070 Bottom K 3

X2700 Bottom M 4

X4400 Top E 3

X4401 Top M 1

SYSCON_M Q202_NK_ 14R3

TRACEABIL ITY_PAD

CONN_CY_5 225_1817 H

SIM_CONN_ C707_10M 006_139_2

MOLEX_50 0024_500 8

MOLEX_51 338_0304

SM SYSTEM CONNECTO R 14POL ~ ~

MODULE ID COMPONE NT

2.8X1.8X0. 3 ~ ~

SM BATTERY CONN 3POLE SPR ~ ~

CONN SIM 2X3POL P2.54 ~ ~

SM CONN 2X25F P0.4 PWB/ PWB ~ ~

SM CONN BTB 2X15F P0.4 ~ ~

Issue 2 COMPANY CONFIDENTIAL Page 2 –37

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CONN MMC

X5200 Top K 8

X7400 Bottom O 2

Z1470 Top J 2

Z2000 Bottom I 2

CONN_CT7 _00220_20 0

RF_SWITCH _MS_156

FC6_1.65X

1.15

FERRITE_0 402

6P RS PUSHPUSH ~ ~

SM RF SWITCH MS156 DNS05952 HDC13 ~ ~

ASIP 2-CH MIC EMI/ ESD **PBFREE** ~ ~

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

600R/ 100MHz ~

Z2001 Bottom I 2

Z2003 Bottom I 2

Z4400 Top K 1

Z4405 Top J 1

Z6030 Top H 9

FERRITE_0 402

uBGA25_2. 69X2.69

EZFVQ42N M77S_V2

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

ASIP 10-CH ESD EMI FILTER BGA25 ~ ~

LTCC FILT

2441.75 +-41.75M HZ 2.0X1.5

600R/ 100MHz ~

2441.75M Hz ~

FERRITE BEAD 0R01 28R/

FERRITE_F

Z7500 Top M 3

Page 2 –38 COMPANY CONFIDENTIAL Issue 2

BMJ1608

100MHZ 0603

28R/ 100MHz ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

SAW FILTER

Z7501 Bottom N 5

Z7502 Top O 8

Z7503 Top O 3

Z7504 Top M 4

FILTER_SA W_2.1X1.7 _H0.8

DFYK61G9 5LBJCB

ANT_SW_L MSP_0094

FILTER_SA W_2.0X1.6 _H0.68

2140 +-30MHZ/ 4DB 2X1.6 2140MHz ~

DUPL 1920-198 0/2110-21 70MHZ 9X4.3

ANT.SW +3SAW 880-960/1 710-1990 MHZ ~ ~

SAW FILTER

897.5 +-17.5MHZ 2X1.6MM 897.5MHz ~

1920-198 0/2110-21 70MHz ~

Z7505 Top P 6

Z7506 Bottom N 7

A3000 BTM D 3

A6000 BTM G 3

A7000 BTM L 6

A7001 BTM O 9

ISOLATOR_ CEZ0047

FILTER_SA W_2.1X1.7 _H0.9

SHIELD_DM C07004

SHIELD_DM C07003

SHIELD_DM C07006

SHIELD_DM C07007

ISOLATOR 1950 +-30MHZ 13DB

3.35X3.35 ~ ~ SAW

FILTER 1950 +-30MHZ

2.0X1.6 1950MHz ~ FLASH CAN

DMC07004 RM-1 ~ ~

BT CAN DMC07003 RM-1 ~ ~

RF ENGINE CAN DMC07006 RM-1 ~ ~

WDCMA PA CAN DMC07007 RM-1 ~ ~

Issue 2 COMPANY CONFIDENTIAL Page 2 –39

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

GSM PA CAN

SHIELD_DM

A7002 BTM R 3

A7003 BTM M 9

B2200 Top C 4

C1470 BTM R 6 0603C

C1471 BTM O 6 0603C

C07005

SHIELD_DM D11427

CRYSTAL_3 .3X1.6

DMC07005 RM-1 ~ ~

VCO CAN DMD11427 RM-1 ~ ~

CRYSTAL

32.768KHZ +-20PPM

12.5PF 32.768kHz ~ CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C1472 BTM D 6 0603C

C1473 BTM D 5 0603C

C2000 BTM B 9 0402C

C2002 BTM D 5 0603C

C2003 Top B 5 0402C

C2004 Top B 5 0402C

C2005 Top B 5 0402C

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% NP0 27p 50V

CHIPCAP X5R 2U2 K 6V3 0603 2u2 6V3

CERCAP X7R 22N K 16V 0402 22n 16V

Chipcap X7R 10% 16V 0402 10n 16V

Chipcap X7R 10%

C2006 Top B 5 0402C

C2007 BTM B 4 0402C

Page 2 –40 COMPANY CONFIDENTIAL Issue 2

16V 0402 10n 16V Chipcap

X7R 10% 16V 0402 10n 16V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C2008 BTM A 4 0402C

C2009 BTM C 4 0402C

C2010 BTM B 3 0402C

C2011 BTM D 6 0402C

C2012 BTM B 9 0603C

TANT_6.3X

C2070 BTM H 3

3.5_H2.0

16V 0402 10n 16V Chipcap

X7R 10% 16V 0402 10n 16V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP NP0 270P J 25V 0402 270p 25V

CHIPCAP X5R 1U K 25V 0603 1u0 25V

CHIPTCAP 100U M 14V 6X3.2X2 100u_14V 14V

C2100 Top B 5 0402C

C2101 Top B 5 0402C

C2102 Top B 5 0603C

C2105 Top B 6 0402C

C2106 Top B 6 0402C

C2107 Top B 6 0402C

C2108 Top B 8 0402C

CHIPCAP X7R 15N K 16V 0402 15n 16V

CHIPCAP X5R 2U2 K 6V3 0603 2u2 6V3

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap X7R 10%

C2109 Top B 8 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –41

50V 0402 1n0 50V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C2110 Top B 8 0402C

C2200 Top B 5 0603C

C2201 Top D 4 0603C

C2202 Top C 4 0402C

C2203 Top C 4 0402C

C2204 Top B 4 0402C

50V 0402 1n0 50V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap X7R 10% 50V 0402 1n0 50V

C2205 Top B 4 0402C

C2206 Top B 4 0402C

C2207 Top D 4 0402C

C2208 Top C 4 0402C

C2209 Top C 4 0402C

C2210 Top D 6 0603C

C2211 Top C 7 0805C

C2212 Top C 6 0603C

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap 5% NP0 27p 50V

Chipcap 5% NP0 22p 50V

CHIPCAP X5R 1U K 16V 0603 1u0 16V

CHIPCAP X5R 4U7 K 10V 0805 4u7 10V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K

C2213 Top E 4 0603C

Page 2 –42 COMPANY CONFIDENTIAL Issue 2

6V3 0603 1u0 6.3V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 1U K

C2214 Top D 5 0603C

C2215 Top D 5 0603C

C2216 Top D 5 0603C

C2217 Top E 4 0603C

C2219 Top D 4 0603C

C2220 Top D 6 0603C

6V3 0603 1u0 6.3V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C2221 Top D 6 0603C

C2222 Top D 6 0603C

C2223 Top C 4 0402C

C2224 Top D 5 0402C

C2225 Top D 4 0603C

C2226 Top C 6 0603C

C2227 Top D 6 0603C

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K

C2228 Top E 5 0603C

Issue 2 COMPANY CONFIDENTIAL Page 2 –43

6V3 0603 1u0 6.3V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 1U K

C2230 Top E 5 0603C

C2231 Top B 6 0805C

C2232 Top D 6 0603C

C2233 BTM D 11 0603C

C2234 Top C 4 0402C

C2235 Top C 3 0402C

6V3 0603 1u0 6.3V CHIPCAP

X5R 10U M 6V3 0805 10U 6V3

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% NP0 27p 50V

Chipcap X7R 10% 50V 0402 1n0 50V

C2237 Top E 5 0603C

C2240 Top E 9 0402C

C2241 Top D 4 0402C

C2242 Top E 8 0402C

C2243 Top F 6 0402C

C2244 Top F 11 0402C

C2300 Top C 9 0402C

C2301 Top C 8 0805C

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% NP0 12p 50V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 22U M 6V3 0805 22u 6V3

CHIPCAP X5R 22U M

C2302 Top B 7 0805C

C2303 Top E 8 0603C

Page 2 –44 COMPANY CONFIDENTIAL Issue 2

6V3 0805 22u 6V3 CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C2304 Top C 8 0402C

C2306 Top D 9 0603C

C2307 Top C 9 0603C

C2309 Top B 8 0805C

C2312 Top D 9 0603C

C2313 Top D 9 0603C

16V 0402 10n 16V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 22U M 6V3 0805 22u 6V3

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C2314 Top D 10 0805C

C2315 Top C 10 0805C

C2316 Top C 8 0402C

C2700 BTM G 11 0402C

C2800 BTM F 4 0402C

C2801 Top H 4 0402C

CHIPCAP X5R 4U7 K 25V 0805 4u7 25V

Chipcap X7R 10% 50V 0402 1n0 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V

C2802 Top F 3 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –45

0402 100n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C2803 Top E 5 0402C

C2804 Top E 3 0402C

C2805 Top G 6 0402C

C2806 Top H 4 0402C

0402 100n 16V CHIPCAP

X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

C2807 Top H 3 0603C

C2808 Top H 4 0402C

C2809 BTM G 4 0402C

C2810 Top G 6 0402C

C2811 Top H 5 0402C

C2812 Top E 5 0402C

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V

C2813 Top E 4 0402C

Page 2 –46 COMPANY CONFIDENTIAL Issue 2

0402 100n 16V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C2814 Top F 3 0402C

C3000 Top C 3 0402C

C3001 Top D 4 0402C

C3002 Top C 3 0402C

0402 100n 16V CHIPCAP

X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

C3003 Top D 4 0402C

C3004 Top E 1 0402C

C3005 Top E 3 0402C

C3006 Top E 4 0402C

C3007 Top C 3 0402C

C3008 Top D 4 0402C

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 22U M

C4200 Top C 7 0805C

C4201 Top C 7 0805C

Issue 2 COMPANY CONFIDENTIAL Page 2 –47

6V3 0805 22u 6V3 CHIPCAP

X5R 22U M 6V3 0805 22u 6V3

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap X7R 10%

C4202 Top D 8 0402C

C4400 BTM O 7 0603C

C4401 BTM R 5 0603C

C4402 BTM Q 10 0402C

C4800 Top F 9 0402C

C4801 Top E 7 0603C

16V 0402 10n 16V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap 5% NP0 27p 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C4802 Top E 8 0402C

C4803 Top E 6 0402C

C4804 Top G 9 0402C

C4805 Top H 7 0402C

C4806 Top H 6 0402C

C4807 Top E 8 0402C

CHIPCAP X5R 100N M 16V 0402 100n 16V

Page 2 –48 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C4808 Top E 8 0402C

C4809 Top H 7 0402C

C4810 Top G 9 0402C

C4811 Top F 6 0402C

0402 100n 16V CHIPCAP

X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V 0402 100n 16V

C4812 Top E 7 0402C

C4813 Top E 6 0402C

C5000 Top F 11 0402C

C5001 Top E 9 0402C

C5002 Top G 11 0402C

C5003 Top F 9 0402C

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap X7R 10% 50V 0402 1n0 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

CHIPCAP X5R 100N M 16V

C5004 Top E 11 0402C

Issue 2 COMPANY CONFIDENTIAL Page 2 –49

0402 100n 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIPCAP X5R 100N M 16V

C5005 Top E 9 0402C

C5006 Top F 11 0603C

C5200 BTM H 2 0603C

C6031 BTM F 3 0402C

C6033 BTM F 3 0402C

0402 100n 16V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap X7R 10% 16V 0402 10n 16V

C6035 BTM G 2 0402C

C6036 BTM G 4 0603C

C6042 BTM G 3 0603C

C6043 BTM F 3 0402C

C6044 BTM F 2 0402C

C6045 BTM G 2 0402C

C6046 BTM G 1 0402C

C6047 BTM G 2 0603C

Chipcap X7R 10% 16V 0402 10n 16V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap X7R 10% 16V 0402 10n 16V

Chipcap 5% NP0 15p 50V

Chipcap +-0.25pF NP0 1p0 50V

CHIPCAP X5R 2U2 K 6V3 0603 2u2 6V3

Chipcap +-0.25pF

C6048 BTM F 2 0402C

C7501 BTM N 7 0402C

Page 2 –50 COMPANY CONFIDENTIAL Issue 2

NP0 5p6 50V Chipcap

5% NP0 18p 50V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIPCAP X5R 1U K

C7503 BTM M 7 0603C

C7504 BTM M 7 0603C

C7505 BTM L 7 0402C

C7507 BTM M 6 0402C

C7508 BTM M 6 0402C

C7509 BTM M 6 0402C

6V3 0603 1u0 6.3V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap 5% NP0 18p 50V

Chipcap +-0.25pF NP0 2p7 50V

C7512 BTM S 4 0402C

C7513 BTM L 6 0402C

C7514 BTM S 4 0402C

C7515 BTM K 7 0402C

C7516 BTM K 6 0402C

C7518 BTM N 7 0402C

C7520 BTM N 7 0402C

C7522 BTM L 6 0402C

Chipcap +-0.25pF NP0 2p7 50V

Chipcap X7R 10% 25V 0402 4n7 25V

Chipcap +-0.25pF NP0 2p7 50V

Chipcap 5% NP0 10p 50V

Chipcap 5% NP0 150p 50V

CHIPCAP X5R 100N M 16V 0402 100n 16V

Chipcap 5% NP0 18p 50V

Chipcap 5% NP0 150p 50V

Chipcap +-0.25pF

C7523 BTM R 4 0402C

C7524 BTM K 5 0603C

Issue 2 COMPANY CONFIDENTIAL Page 2 –51

NP0 5p6 50V CHIPCAP

NP0 2N2 G 16V 0603 2n2 16V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap +-0.25pF

C7525 BTM R 4 0402C

C7527 BTM M 6 0402C

C7528 BTM M 6 0402C

C7529 BTM L 7 0402C

C7530 BTM L 7 0402C

C7531 BTM M 6 0402C

C7532 BTM L 7 0402C

NP0 5p6 50V Chipcap

5% NP0 100p 50V Chipcap

5% NP0 22p 50V Chipcap

5% NP0 100p 50V Chipcap

X7R 10% 16V 0402 8n2 16V

Chipcap 5% NP0 22p 50V

Chipcap X7R 10% 16V 0402 8n2 16V

C7533 BTM K 7 0402C

C7534 BTM M 7 0402C

C7535 BTM L 6 0402C

C7536 BTM M 7 0402C

C7541 BTM K 7 0603C

C7543 BTM K 7 0603C

C7545 BTM Q 2 0402C

Chipcap X7R 10% 16V 0402 10n 16V

Chipcap X7R 10% 16V 0402 8n2 16V

Chipcap 5% NP0 100p 50V

Chipcap X7R 10% 16V 0402 8n2 16V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

Chipcap +-0.25pF NP0 4p7 50V

Chipcap +-0.25pF

C7547 BTM J 7 0402C

C7548 BTM J 7 0603C

Page 2 –52 COMPANY CONFIDENTIAL Issue 2

NP0 1p8 50V CHIPCAP

X5R 1U K 6V3 0603 1u0 6.3V

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap

C7549 BTM K 6 0402C

C7550 BTM I 7 0402C

C7552 BTM I 7 0402C

C7553 BTM I 7 0402C

C7554 BTM M 10 0402C

C7555 BTM M 10 0402C

5% NP0 100p 50V Chipcap

+-0.25pF NP0 2p7 50V

Chipcap +-0.25pF NP0 2p7 50V

Chipcap X7R 10% 16V 0402 8n2 16V

Chipcap +-0.25pF NP0 4p7 50V

CHIPCAP NP0 0P5 C 50V 0402 0p5 50V

C7556 BTM Q 4 0402C

C7558 BTM J 6 0402C

C7559 BTM R 2 0402C

C7560 BTM I 7 0402C

C7561 BTM Q 4 0402C

C7563 BTM Q 4 0402C

C7564 BTM R 3 0402C

Chipcap 5% NP0 10p 50V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap +-0.25pF NP0 1p0 50V

Chipcap X7R 10% 25V 0402 4n7 25V

Chipcap +-0.25pF NP0 4p7 50V

Chipcap X7R 10% 50V 0402 1n0 50V

Chipcap

C7567 BTM J 6 0402C

C7568 BTM I 7 0402C

C7569 BTM R 4 0603C

Issue 2 COMPANY CONFIDENTIAL Page 2 –53

5% NP0 15p 50V Chipcap

5% NP0 150p 50V CHIPCAP

X5R 4U7 K 6V3 0603 4u7 6.3V

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Chipcap

C7570 BTM I 6 0402C

C7571 BTM L 10 0402C

C7573 BTM I 7 0603C

C7575 BTM I 6 0402C

C7577 BTM I 6 0402C

C7579 BTM N 11 0402C

C7580 BTM O 10 0603C

5% NP0 18p 50V CHIPCAP

NP0 330P J 50V 0402 330p 50V

CHIPCAP NP0 2N2 G 16V 0603 2n2 16V

Chipcap 5% NP0 15p 50V

Chipcap 5% NP0 10p 50V

CHIPCAP X5R 1U K 6V3 0603 1u0 6.3V

C7581 BTM S 4 0402C

C7582 BTM I 7 0402C

C7583 BTM N 8 0603C

C7584 BTM S 4 0402C

C7585 BTM O 10 0402C

C7586 BTM P 9 0402C

C7587 BTM P 9 0402C

C7589 BTM O 8 0603C

Chipcap +-0.25pF NP0 5p6 50V

Chipcap 5% NP0 100p 50V

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap +-0.25pF NP0 5p6 50V

CHIPCAP NP0 1P0 B 50V 0402 1p0 50V

Chipcap 5% NP0 10p 50V

CHIPCAP X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap

C7590 BTM O 9 0402C

C7591 BTM N 9 0402C

Page 2 –54 COMPANY CONFIDENTIAL Issue 2

5% NP0 10p 50V CHIPCAP

NP0 470P J 6V3 0402 470p 6V3

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Chipcap

C7592 BTM N 9 0402C

C7593 BTM Q 4 0603C

C7596 BTM N 6 0402C

TANT_6.3X

C7597 BTM O 4

C7598 BTM K 7 0402C

D2800 Top G 4 uBGA_289

3.5_H2.0

5% X7R 3n3 50V CHIPCAP

X5R 4U7 K 6V3 0603 4u7 6.3V

Chipcap +-0.25pF NP0 2p7 50V

CHIPTCAP 100U M 14V 6X3.2X2 100u_14V 14V

CHIPCAP NP0 0P5 C 50V 0402 0p5 50V

RAP3G V2.1E-PA UMC8D F761800B 027 U*BGA ~ ~

PBFREEBG A40_64MB _54MHZ_M

D3000 BTM D 3

D3001 Top D 2

D4800 Top F 7 uBGA_289

D5000 Top F 10

F2000 BTM A 9

AX SDRAM_11

0MHZ_64M BIT_BGA60 _PBFREE_M AX

FBGA121_ H1.1

0603_FUSE _AVX2MATSSM FUSE F

FLASH 4MX16

1.8/1.8V FBGA44 4Mx16 ~

SDRAM 4MX16

1.8V/1.8V WBGA60 PBFREE 4Mx16 ~

HELEN3 PS1.1E F761991A C027 UBGA289 ~ ~

COMBO 256M DDR + 256M NAND FBGA121 PBFREE

2.0A 32V 2A ~

256M_DDR / 256M_NAN D ~

Issue 2 COMPANY CONFIDENTIAL Page 2 –55

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CELL CAPACITOR

G2200 BTM F 11

G7500 BTM K 6

G7501 BTM L 7

G7502 BTM M 9

BATTER_R B414H

VCO_FDK_I T_H1.7

NKG3176B _H1.0

VCO_FDK_I T_H1.7

0.01MAH 3V3 3V3 ~

VCO 3610-434 0MHZ 2.7V 13MA WCDMA FDD

VCTCXO

38.4MHZ

2.5V 38.4MHz ~ VCO

3420-396 0MHZ 2.7V 14MA WCDMA FDD

3610-434 0MHz ~

3420-396 0MHz ~

L2000 BTM B 8 0603_BLM

0405_2_M

L2001 Top B 6

L2002 BTM B 4

L2003 BTM B 4

L2100 Top U 3

L2101 Top B 6 0603_BLM

ATSU

0405_2_M ATSU

FERR.BEAD 220R/ 100M 2A 0R05 0603

CHIP BEAD ARRAY 2X1000R 0405

FERR.BEAD 220R/ 100M 2A 0R05 0603

220R/ 100MHz ~

2x1000R/ 100MHz ~

220R/ 100MHz ~

Page 2 –56 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIP COIL 56N J

COIL_0603

L2102 BTM S 5

L2103 BTM S 6

L2104 Top B 6 0603_BLM

L2105 Top B 8 0402L_XL

CS

COIL_0603 CS

Q38/250M HZ 0603 56nH ~

CHIP COIL 56N J Q38/250M HZ 0603 56nH ~

FERR.BEAD 220R/ 100M 2A 0R05 0603

FERRITE BEAD 220R 0R45 0.3A 0402

220R/ 100MHz ~

L2106 Top B 8 0402L_XL

L2202 Top E 4 0603_BLM

FERRITE_0

L2203 Top E 5

L2204 Top D 5

L2205 Top C 6 0603_BLM

402

FERRITE_0 402

FERRITE BEAD 220R 0R45 0.3A 0402

FERR.BEAD 220R/ 100M 2A 0R05 0603

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

FERR.BEAD 220R/ 100M 2A 0R05 0603

220R/ 100MHz ~

600R/ 100MHz ~

220R/ 100MHz ~

FERRITE BEAD 0.6R 600R/

FERRITE_0

L2206 Top E 5

Issue 2 COMPANY CONFIDENTIAL Page 2 –57

402

100MHZ 0402

600R/ 100MHz ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

FERRITE BEAD 0.6R 600R/

FERRITE_0

L2207 BTM E 11

L2301 Top B 8 0603_BLM

L2302 Top B 7

L2304 Top D 10

402

CHOKE_SER 400

CHOKE_98 4FB

100MHZ 0402

FERR.BEAD 220R/ 100M 2A 0R05 0603

CHOKE 10U

0.8A 0R24 4X4X1.8 10uH ~

CHOKE 22U M 1R4

0.33A

3.3X3.3X1. 5 22uH ~

600R/ 100MHz ~

220R/ 100MHz ~

CHOKE_SER

L4200 Top D 7

L4201 Top E 7 0603_BLM

L4400 BTM O 7

L4401 BTM R 5

L5200 BTM I 2

400

FERRITE_0 402

CHOKE 10U

0.8A 0R24 4X4X1.8 10uH ~

FERR.BEAD 220R/ 100M 2A 0R05 0603

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

220R/ 100MHz ~

600R/ 100MHz ~

CHIP COIL 2N7+-0N3 Q29/800M

L6031 BTM G 2 0402L

Page 2 –58 COMPANY CONFIDENTIAL Issue 2

0402 2n7H ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIP COIL 2N7+-0N3 Q29/800M

L6032 BTM G 2 0402L

L6033 BTM F 2 0402L

L6034 BTM F 2 0402L

L7502 BTM I 7 0402L

0402 2n7H ~ CHIP COIL

22N J Q28/800M 0402 22nH ~

CHIP COIL 22N J Q28/800M 0402 22nH ~

CHIP COIL 100N J Q16/300M 0402 100nH ~

FERRITE_0

L7503 BTM K 7

L7504 BTM S 4 0402L

L7505 BTM S 4 0402L

L7506 BTM R 4 0402L

L7510 BTM J 6 0402L

402

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

CHIP COIL 27N J Q27/800M 0402 27nH ~

CHIP COIL 12N J Q31/800M 0402 12nH ~

CHIP COIL 4N7 +-0N3 Q28/800M 0402 4n7H ~

600R/ 100MHz ~

CHIP COIL 10N J Q30/800M

L7511 BTM J 6 0402L

L7512 BTM J 6 0402L

Issue 2 COMPANY CONFIDENTIAL Page 2 –59

0402 10nH ~ CHIP COIL

4N7 +-0N3 Q28/800M 0402 4n7H ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CHIP COIL 8N2 J Q28/800M

L7514 BTM O 10 0402L

CHOKE_SER

L7515 BTM P 9

L7516 BTM P 4

L7517 BTM J 7 0402L

400

FERRITE_0 402

HZ 0402 8n2H ~ CHOKE 10U

0.8A 0R24 4X4X1.8 10uH ~

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

CHIP COIL 1N5 +-0N3 Q33/800M 0402 1n5H ~

600R/ 100MHz ~

N1470 BTM D 5 LLP6

TFBGA_10

N2200 Top C 5

N2300 Top D 8

N2301 Top D 10

N4200 Top C 7

8

TFBGA_84_

6.15X6.15

USMD8_1. 69X1.69

USMD_10_

2.458X1.8 99

REG LP3990YD X-1.5V LLP-6 ~ 1.5V

RETU 3.02 L TSA1GJWE TFBGA108 ~ ~

TAHVO V4.1 TFBGA84 6X6 ~ ~

WHITE LED DRIVER 4LEDS 500MW 8BUMP USMD8 ~ ~

DC_DC CONV LM2708H-

1.40V/

1.09V ~ ~ BC3-ROM

WITH BC2

TFBGA84_

N6030 BTM G 3

Page 2 –60 COMPANY CONFIDENTIAL Issue 2

H1.0

MOULD MATERIAL ~ ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

VREG

2.85/150M A

N6031 BTM G 3

N7500 BTM M 6

N7501 BTM J 7

N7502 BTM Q 3

USMD5_1. 468X1.036

TFBGA_84_

6.15X6.15

TFBGA64_ H1.2

RITSA_PA_ REL3

LP3987-2. 85 USMD5 ~ 2.85V

RF ASIC HINKU310 A TFBGA84 ~ ~

RF ASIC VINKU314 A TFBGA64 ~ ~

PW AMP RF9292E9. 2 QUADBAN D ~ ~

RF9252E2.

N7503 BTM O 10

N7504 BTM O 9

R1470 Top H 6 0402R

R1471 Top H 6 0402R

R1472 Top H 8 0402R

R1473 Top H 8 0402R

R1474 Top G 6 0402R

R2000 BTM D 5 0402R

1

USMD10_2 . 534X2.026

PW AMP RF9252E8. 2 1920-198 0MHZ ~ ~

DC CONV SUPA LM2706 PBFREE ~ ~

Resistor 5% 63mW 100R ~

Resistor 5% 63mW 3k3 ~

Resistor 5% 63mW 33R ~

Resistor 5% 63mW 220R ~

ASIP MIC W/ESD RES

uBGA11_2.

R2001 Top B 5

R2002 BTM B 4 0402R

Issue 2 COMPANY CONFIDENTIAL Page 2 –61

15X1.65

+CAP+ZDI BGA11 ~ ~

Resistor 5% 63mW 10R ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Resistor

R2003 BTM C 4 0402R

R2004 BTM C 4 0402R

R2005 BTM C 4 0402R

R2006 BTM B 4 uBGA5

uBGA11_1.

R2007 BTM B 6

R2009 BTM C 6 0402R

6X2.1

5% 63mW 10R ~ Resistor

5% 63mW 10R ~ ASIP

4XESD **PBFREE** BGA5 ~ ~

ASIP SILIC USB OTG / ESD BGA11 ~ ~

Resistor 5% 63mW 100R ~

R2010 BTM C 6 0402R

R2011 BTM D 5 0402R

R2012 BTM D 5 0402R

R2013 BTM D 4 0402R

R2014 BTM D 4 0402R

R2070 BTM B 8 0402_VAR

0402_NTH

R2071 Top C 2

R2100 Top B 5

5

FLIP_CHIP_ 8_1.7X1.7

Resistor 5% 63mW 220k ~

Resistor 5% 63mW 120k ~

Resistor 5% 63mW 100k ~

Resistor 5% 63mW 330R ~

Resistor 5% 63mW 1M0 ~

CHIP VARISTOR VWM14V VC50V 0402 14V/50V ~

NTC RES 47K J B=4050 +-3% 0402 47k ~

ASIP SINGLE ENDED MICROPHO NE INTERF BGA8 ~ ~

Resistor

R2101 Top B 5 0402R

Page 2 –62 COMPANY CONFIDENTIAL Issue 2

5% 63mW 220R ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

CHIP VARISTOR VWM14V VC50V

R2104 Top U 4 0402_VAR

R2105 Top U 4 0402_VAR

R2106 BTM S 5 0402_VAR

R2107 BTM S 5 0402_VAR

0402 14V/50V ~ CHIP

VARISTOR VWM14V VC50V 0402 14V/50V ~

CHIP VARISTOR VWM14V VC50V 0402 14V/50V ~

R2200 Top C 4 0402R

R2201 Top D 4 0402R

R2202 BTM E 11 0402_VAR

R2205 Top C 4 0402R

R2301 Top C 10 0402R

R2302 Top D 11 0402R

R2303 Top C 10 0402R

R2304 Top C 10 0402R

Resistor 5% 63mW 100k ~

Resistor 5% 63mW 120k ~

CHIP VARISTOR VWM14V VC50V 0402 14V/50V ~

CHIPRES 0W06 2M2 J 0402 2M2 ~

Resistor 5% 63mW 4k7 ~

Resistor 5% 63mW 10k ~

Resistor 5% 63mW 1k0 ~

Resistor 5% 63mW 39R ~

Resistor

R2305 Top E 8 0402R

Issue 2 COMPANY CONFIDENTIAL Page 2 –63

5% 63mW 33R ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

ASIP EMIF03SIM01F2 **PB-

R2700 BTM E 11 uBGA8

R3000 Top H 3 0402R

R4400 Top B 4 0402R

R4401 Top C 4 0402R

R4402 Top B 4 0402R

0402_NTH

R4403 Top U 4

5

FREE** ~ ~ Resistor

5% 63mW 4k7 ~ Resistor

5% 63mW 470k ~ Resistor

5% 63mW 100k ~ Resistor

5% 63mW 470k ~ NTC RES

47K J B=4050 +-3% 0402 47k ~

R4404 BTM Q 10 0402_VAR

R4405 BTM Q 10 0402_VAR

R4406 BTM Q 2 0402_VAR

R4408 Top E 1 0603_VAR

R4409 Top F 1 0603_VAR

CHIP VARISTOR VWM14V VC50V 0402 14V/50V ~

CHIP VARISTOR VWM19V VC27V 0603 19V/27V ~

Resistor

R4800 Top F 9 0402R

Page 2 –64 COMPANY CONFIDENTIAL Issue 2

5% 63mW 10R ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

Resistor

R4809 Top E 6 0402R

R5100 Top H 6 0402R

uBGA11_1.

R5200 BTM H 2

R5204 BTM O 3 0402_VAR

R6030 BTM G 3 0402R

62X2.12

5% 63mW 1k0 ~ Resistor

5% 63mW 10k ~ ASIP

EMIF04MMC02F2* *PBFREE** ~ ~

CHIP VARISTOR VWM14V VC50V 0402 14V/50V ~

Resistor 5% 63mW 10k ~

R6034 BTM F 2 0402R

R7501 BTM K 6 0402R

R7503 BTM I 6 0402R

R7504 BTM M 7 0402R

R7505 BTM L 6 0402R

R7506 BTM Q 4 0402R

R7509 BTM K 7 0402R

0404_RAC

R7512 BTM P 4

10

CHIPRES 0W06 2R2 J 0402 2R2 ~

Resistor 5% 63mW 1k0 ~

Resistor 5% 63mW 4k7 ~

CHIPRES 0W06 10K F 0402 10k ~

CHIPRES 0W06 8K2 F 0402 8k2 ~

Resistor 5% 63mW 270R ~

Resistor 5% 63mW 22k ~

RES NETWORK 0W04 2DB ATT 0404

436R/ 11R6/436 R ~

Resistor

R7514 BTM K 6 0402R

R7516 BTM R 3 0402R

R7518 BTM Q 2 0402R

Issue 2 COMPANY CONFIDENTIAL Page 2 –65

5% 63mW 12k ~ Resistor

5% 63mW 1k0 ~ Resistor

5% 63mW 470k ~

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

Resistor

R7519 BTM J 7 0402R

R7520 BTM J 6 0402R

R7521 BTM J 6 0402R

R7522 BTM N 8 0402R

R7523 BTM I 7 0402R

R7525 BTM N 9 0402R

5% 63mW 1k0 ~ Resistor

5% 63mW 270R ~ CHIPRES

0W06 10K F 0402 10k ~

Resistor 5% 63mW 220k ~

CHIPRES 0W06 9K1 F 100PPM 0402 9k1 ~

Resistor 5% 63mW 10R ~

R7526 BTM O 9 0402R

R7527 BTM O 9 0402R

R7528 BTM J 7 0402R

R7529 BTM O 9 0402R

R7530 BTM N 9 0402R

R7531 BTM N 9 0402R

R7534 BTM R 2 0402R

SWITCH_SK

S4400 BTM R 11

RE_II

Resistor 5% 63mW 5k6 ~

Resistor 5% 63mW 220R ~

Resistor 5% 63mW 470k ~

Resistor 5% 63mW 2k2 ~

Resistor 5% 63mW 8k2 ~

Resistor 5% 63mW 470k ~

SM TACT SW TRAV

0.2

4.1X3.55X

1.75 ~ ~ SM TACT

SW TRAV

0.2

SWITCH_SK

S4401 BTM R 2

S5200 BTM O 2

Page 2 –66 COMPANY CONFIDENTIAL Issue 2

RE_II

SWITCH_SP VN220100

4.1X3.55X

1.75 ~ ~ SM SW

DETECTOR SPST-NO 5V 1MA ~ ~

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

TRANSF BALUN 2134

T7500 BTM N 6

T7501 BTM L 6

T7502 BTM P 3

T7503 BTM M 9

TRANS_LD B15

+-90MHZ 0805 ~ ~

TRANSF BALUN 3800 +-550MHZ 0805 ~ ~

TRANSF BALUN 1800 +-100mhz 2x1.25 ~ ~

TRANSF BALUN 3800 +-550MHZ 0805 ~ ~

V2000 BTM B 8 CASE_457

V2001 BTM D 4 SC_75A

V2300 Top D 8 EM3

PT202MR0

V4400 Top U 4

V7500 BTM O 9 SOT_563

MP

TVS DI 1PMT16AT 3 16V 175W PWRMITE ~ ~

MFET 2SK3019 N 30V 0.1A 7R SC-75A ~ ~

TR DTC143ZE N RBE4K7/4 7K 0A1 SC75 ~ ~

DI PHOTO PT202MR0 MP 620NM

1.25X2 ~ ~ SCHDIX2

RF DETECTOR CT 1PF 0V39 SOT666 ~ ~

Issue 2 COMPANY CONFIDENTIAL Page 2 –67

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

CAMERA MOD.SOCK

X1470 BTM P 6

SOCKET_D MD10413

ET 2X7POL SPR P1.4 ~ ~

X2001 BTM A 6

X2060 Top N 11

X2070 BTM C 8

X2700 BTM F 8

X4400 Top F 2

SYSCON_M Q202_NK_ 14R3

TRACEABIL ITY_PAD

LYNX_BAT T_CONN

SIM_READE R_M_C707_ 10M006_5 32_2

SMK_4309 _B_B_16P_ V8

SM SYSTEM CONNECTO R 14POL ~ ~

MODULE ID COMPONE NT

2.8X1.8X0. 3 ~ ~

SM LYNX BATT.CON N 3POL 12V 2A H7 ~ ~

SM SIM CONN 2X3POL P2.54 15V

0.5A ~ ~ SM CONN

16P SPR P1.3 50V PWB/PWB ~ ~

X4401 Top T 3

X4402 Top R 9

X4403 Top J 9

X4404 Top R 4

X4405 Top J 4

JST_R_JAVK _G_1_R3

FORK_SPRI NG_040_0 00443_RM _1

SM CONN 2X12F P0.4 30V

0.3A PCB/ PCB ~ ~

FORK SPRING 040-0004 43 RM-1 ~ ~

Page 2 –68 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Item Side Grid ref. Description and Value

X5200 BTM L 3

Z2000 BTM B 7

Z2001 BTM B 7

Z2003 BTM B 7

Z4400 Top H 3

MOLEX_MM C_P03_3D0 545_001

FERRITE_0 402

uBGA25_2. 69X2.69

CONN SMC RS-MMC 6POL P2.5 ~ ~

FERRITE BEAD 0.6R 600R/ 100MHZ 0402

ASIP 10-CH ESD EMI FILTER BGA25 ~ ~

600R/ 100MHz ~

Z4401 Top G 1

Z4402 Top H 9

Z4403 Top H 10

Z6030 BTM F 1

Z7500 BTM P 4

FC6_1.65X

1.15

uBGA25_2. 69X2.69

EZFVQ42N M61S

FERRITE_F BMJ1608

ASIP 2-CH MIC EMI/ ESD **PBFREE** ~ ~

ASIP 10-CH ESD EMI FILTER BGA25 ~ ~

LTCC FILT

2441.75 +-41.75M HZ 2.5X2

FERRITE BEAD 0R01 28R/ 100MHZ 0603

2441.75M Hz ~

28R/ 100MHz ~

Issue 2 COMPANY CONFIDENTIAL Page 2 –69

RM-42

Nokia Customer Care Parts Lists and Component Layouts

Item Side Grid ref. Description and Value

SAW FILTER 2140

Z7501 BTM N 6

FILTER_SA W_2.1X1.7 _H0.8

+-30MHZ

2.0X1.6X1. 0 2140MHz ~

DUPL 1920-198

Z7502 BTM Q 9

DFYK61G9 5LBJCB

0/2110-21 70MHZ 9X4.3

1920-198 0/2110-21 70MHz ~

ANT.SW +3SAW 880-960/1

Z7503 BTM S 3

ANT_SW_M 043B

710-1990 MHZ ~ ~

SAW FILTER

Z7504 BTM P 3

FILTER_SA W_2.1X1.7 _H0.8

897.5 +-17.5MHZ

2.0X1.6 897.5MHz ~ ISOLATOR

1950 +-30MHZ 13DB

Z7505 BTM P 10

ISOLATOR_ CEZ0047

3.3X3.4X1. 6 ~ ~

SAW FILTER

1950 FILTER_SA W_2.1X1.7

Z7506 BTM J 6

Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS).

To ensure you are always using the latest codes, please check the PWS on a daily basis.

_H0.8

+-30MHZ

2.0X1.6X1.

0 1950MHz ~

Page 2 –70 COMPANY CONFIDENTIAL Issue 2

RM-42 Parts Lists and Component Layouts Nokia Customer Care

Component layouts

RM-42 component layout - top

Issue 2 COMPANY CONFIDENTIAL Page 2 –71

RM-42

Nokia Customer Care Parts Lists and Component Layouts

RM-42 component layout - bottom

Page 2 –72 COMPANY CONFIDENTIAL Issue 2

Nokia Customer Care

3 — Service Software

Instructions

Issue 2 COMPANY CONFIDENTIAL Page 3 –1

RM-42

Nokia Customer Care Service Software Instructions

(This page left intentionally blank.)

Page 3 –2 COMPANY CONFIDENTIAL Issue 2

RM-42 Service Software Instructions Nokia Customer Care

Table of Contents

Phoenix installation steps in brief........................................................................................................................3–5

Installing Phoenix...................................................................................................................................................3–6

Updating Phoenix installation..............................................................................................................................3–8

Uninstalling Phoenix..............................................................................................................................................3–9

Repairing Phoenix installation...........................................................................................................................3–11

Phone data package overview............................................................................................................................3–11

Installing phone data package...........................................................................................................................3–12

Uninstalling phone data package.......................................................................................................................3–15

Configuring users in Phoenix..............................................................................................................................3–17

Managing connections in Phoenix......................................................................................................................3–17

Installing flash support files for FPS-8 and FPS-10...........................................................................................3–19

Updating FPS-8 and FPS-10 flash prommer software.......................................................................................3–22

Activating FPS-8....................................................................................................................................................3–23

Deactivating FPS-8................................................................................................................................................3–24

List of Figures

Figure 3 Dongle not found.....................................................................................................................................3–6

Figure 4 Disclaimer text.........................................................................................................................................3–7

Figure 5 InstallShield Wizard Complete...............................................................................................................3–8

Figure 6 Installation interrupted..........................................................................................................................3–9

Figure 7 Remove program...................................................................................................................................3–10

Figure 8 Finish uninstallation.............................................................................................................................3–10

Figure 9 Repair program.....................................................................................................................................3–11

Figure 10 Data package setup information.......................................................................................................3–13

Figure 11 Data package destination folder.......................................................................................................3–14

Figure 12 InstallShield Wizard Complete...........................................................................................................3–15

Figure 13 Uninstalling phone data package......................................................................................................3–16

Figure 14 Finishing data package uninstallation..............................................................................................3–16

Figure 15 Phoenix login.......................................................................................................................................3–17

Figure 16 New user configured..........................................................................................................................3–17

Figure 17 Select mode: Manual...........................................................................................................................3–18

Figure 18 Connections list...................................................................................................................................3–19

Figure 19 Connection information.....................................................................................................................3–19

Figure 20 Product support module information (example from RM-1)..........................................................3–19

Figure 21 Flash update welcome dialog............................................................................................................3–20

Figure 22 Flash installation interrupted............................................................................................................3–20

Figure 23 Flash destination folder......................................................................................................................3–21

Figure 24 Finish flash update..............................................................................................................................3–22

Figure 25 Flash directory window......................................................................................................................3–22

Figure 26 Prommer software update finished..................................................................................................3–23

Figure 27 Prommer Maintenance window........................................................................................................3–23

Figure 28 Box activation......................................................................................................................................3–24

Figure 29 Deactivation warning.........................................................................................................................3–24

Issue 2 COMPANY CONFIDENTIAL Page 3 –3

RM-42

Nokia Customer Care Service Software Instructions

(This page left intentionally blank.)

Page 3 –4 COMPANY CONFIDENTIAL Issue 2

RM-42 Service Software Instructions Nokia Customer Care

Phoenix

installation steps in brief

Before you begin

Recommended hardware requirements:

• Computer processor: Pentium 700 MHz or higher

• RAM 256 MB

• Disk space 100-300 MB Supported operating systems:

•

Windows 2000

•

Windows XP

Service Pack 3 or higher

Service Pack 1 or higher

Context

Phoenix

is a service software for reprogramming, testing and tuning phones.

Phoenix

• Service software support for all phone models included in the package

• Flash update package files for programming devices

• All needed drivers for:

The phone model specific data package includes all changing product specific data:

• Product software binary files

• Files for type label printing

• Validation file for the faultlog repair data reporting system

• All product specific configuration files for

To use

installation contains:

• PKD-1 (DK2) dongle

• DKU-2 USB cable

Note: Separate installation packages for flash update files and drivers are also available, but it is

not necessary to use them unless there are updates between separate update packages are used, they should be used after installed.

Note:

Uninstallation should be made from the

Phoenix

, you need to:

and phone data packages should only be used as complete installation packages.

Phoenix

software components

Windows

Control Panel.

Phoenix

service software releases. If

and data packages have been

Steps

1. Connect a PKD-1 (DK2) dongle to the computer parallel port.

2. Install

3. Install the phone-specific data package.

4. Configure users.

5. Manage connection settings (depends on the tools you are using).

Issue 2 COMPANY CONFIDENTIAL Page 3 –5

Phoenix

If you use FPS-8: • Update FPS-8 software

.

• Activate FPS-8

RM-42

Nokia Customer Care Service Software Instructions

If you use FPS-10: • Update FPS-10 software

Note: There is no need to activate FPS-10.

• Activate SX-4 smart card, if you need tuning and testing functions.

Note: When FPS-10 is used only for

product software updates, SX-4 smart card is not needed.

Results

Phoenix

is ready to be used with FPS-8 or FPS-10 flash prommers and other service tools.

Installing

Phoenix

Before you begin

• Check that a dongle is attached to the parallel port of your computer.

• Download the computer (in

• Close all other programs.

• Depending on your operating system, administrator rights may be required to install

• If uninstalling or rebooting is needed at any point, you will be prompted by the InstallShield program.

Phoenix

C:\TEMP

installation package (for example,

, for instance).

phoenix_service_sw_2004_39_x_xx.exe

Phoenix

) to your

.

Context

At some point during the installation procedure, you may get the following message:

Figure 3 Dongle not found

This may be a result of a defective or too old PKD-1 dongle. Check the COM/parallel ports used. After correcting the problem, you can restart the installation. For more detailed information, please refer to

Tip: Each feature in

program. Press the F1 key or the feature’s Help button to activate a Help file.

Phoenix

has its own Help function, which can be activated while running the

Phoenix

Help files.

Steps

1. To start the installation, run the application file (for example,

2. In the

Page 3 –6 COMPANY CONFIDENTIAL Issue 2

Welcome

dialogue, click Next.

phoenix_service_sw_2004_39_x_xx.exe

).

Nokia N90 Service Manual issue2

Specifications and Main Features

Frequently Asked Questions

User Manual

Amendment Record Sheet

Copyright

Warnings and cautions

ESD protection

Care and maintenance

Company Policy

Battery information

Nokia N90 Service Manual Structure

RM-42 product selection

RM-42 transceiver features

RM-42 mobile enhancements

Technical specifications

RM-42 transceiver general specifications

Main RF characteristics for triple-band (EGSM900/GSM1800/GSM1900) and WCDMA phones

Battery endurance

Environmental conditions

Exploded view

RM-42 exploded view

Parts lists

Mechanical spare parts overview

Mechanical spare parts list

Component parts lists

Component layouts

RM-42 component layout - top

RM-42 component layout - bottom