Nex 820-0012 Owner's Manual
Use and Care Guide
Outdoor Table Top Grill
Model No. 122.16124900
!
WARNING:
Read this Owner’s manual carefully and be
sure your gas grill is properly assembled,
installed and maintained. Failure to follow
these instructions could result in serious injury
and/or property damage. This gas grill is
intended for outdoor use only and is not
intended to be installed in or on recreational
vehicles or boats.
Note to Installer
Leave this Owner’s Manual with the customer
after delivery and/or installation.
•Parts
•Assembly
•Safety Rules
•Use and Care
•Troubleshooting
•Español (Pg. 15)
Note to Consumer
Leave this Owner’s Manual in a convenient
place for future reference.
Customer Service Helpline:
For parts ordering, call:
1-800-4–MY-HOME
For assembly questions, call:
1-800-913-8999
Date: 09/04/2008
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
Table of Contents
Warranty------------------------------------------------2
Safety Precautions--------------------------------2~5
Package Contents List-------------------------------5
Parts Diagram -----------------------------------------6
Parts List------------------------------------------------6
Assembly Instructio ns--------------------------------7
Operation Instructions----------------------------8~9
Care and Maintenance------------------------10~11
Troubleshooting--------------------------------------11
Cooking Instru ction----------------------------------12
Cooking Chart----------------------------------------13
Kenmore Grill Warranty
One-Year Full Warranty on Kenmore Grill
If this grill fails due to a defecting material or
workmanship within one year from the date of
purchase, call 1-800-4-MY-HOME to arrange for
free repair (or replacement if repair proves
impossible).
One Year Limited Warranty on Stainless Steel
Burner
For one year from the date of purchase, if the
stainless steel burner rusts through it will be
replaced free of charge. Labor not included.
All warranty coverage excludes grill part paint
loss, discoloration or rusting, which are either
expendable parts that can wear out from normal
use within the warranty period, or are conditions
that can be the result or normal use, accident or
improper maintenance,
All warranty coverage is void if this grill is ever
used for commercial or rental purposes.
PRECAUTIONS
!
WARNING
Combustion by products produced when using
this product contain chemicals known to the
State of California to cause cancer, birt h de f ect s,
or other reproductive harm.
!
WARNING
Failure to comply with these instructions could
result in a fire or explosion that could cau se
serious bodily injury, death, or property damage.
WARNING
!
Your grill will get very hot. Never lean over the
cooking area while using your grill. Do not touch
cooking surfaces, grill housing, lid or any other
grill parts while the grill is in operation, or until
the gas grill has cooled down after use.
Failure to comply with these instructions may
result in serious bodily injury.
!
WARNING
1. Do not store or use gasoline or
other flammable liquids or
vapors in the vicinity of this or
any other appliance.
2. An LP cylinder not connected for
use shall not be stored in the
vicinity of this or any other
appliance.
DANGER
!
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If the odor continues, keep away
from the appliance and
immediately call your gas
supplier or your fire department.
All warranty coverage applies only if this grill is
used in the United States.
This warranty gives you specific legal rights, and
you may have other right which vary from state to
state.
Sears, Roebuck and Co.,
Hoffman Estates, IL 60179
U.S.A.
Grill Installation Codes
The installation must conform with local codes or,
in the absence of local codes, with either the
national fuel gas code, ANSI Z 223.1/NFPA S4,
Natural gas and propane installation code, CSA
B149.1, or propane storage and handling code,
B149.2, or the standard for Recreational vehicles,
ANSI A 119.2, and CSA Z240 RV series
recreational vehicle code, as applicable.
LP gas grill models are designed for use with a
standard 20 lb. Liquid Propane Gas tank, not
included with grill. Never connect your gas grill to
an LP gas tank that exceeds this capacity.
2
SAFETY INFORMATION
Please read the following instructions carefully before attempting to assemble, operate or install the product.
Failure to follow these instructions may result in serious bodily injury and/or property damage. If you have
questions regarding the product please call customer service at 1-800-913-8999.
LP- gas supply cylinder to be used must be constructed and marked in accordance with the specifications for
LP-gas cylinders of the U.S Department of Transportation (DOT) or the National Standard of Canada, CANB339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods.
1. The installation must conform with local codes or, in the
absence of local codes, with the National Fuel Gas
Codes, with the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, Storage and Handling of Liquefied
Petroleum Gases, ANSI/NFPA 58, or the Standard for
Recreational Vehicles, ANSI A119.2/NFPA 1192, and the
Recreational Vehicle Code, CSA Z240 RV, as applicable.
2. Table top grill is for outdoor use only. Grill should be
operated in a well-ventilated space. Never operate in an
enclosed space, garage or building. Your grill is not
intended to be installed in or on recreational vehicles and
/ or boats .
3. Heated liquids remain at scalding temperatures long after
the cooking process. Do not touch the cooking appliance
until liquids have cooled to 115˚F (45˚C) or less.
4. Do not install or use grill within 24” (10ft recommended)
of combustiblematerials from back and si des of grill. Grill
shall not be located under overhead surfaces (closed
carport, garage, porch, patio) that can catch fire.
5. Never attempt to attach this grill to the self-contained LP
gas system of a camper trailer or motor home.
6. It is the responsibility of the assembler/owner to
assemble, install and maintain gas grill. Do not let
children and pets operate or play near your table top grill.
Failure to follow these instructions could result in serious
personal injury and/ or property damage.
7. Remove lid before lighting grill. When grill is not in use,
turn off control knob on regulator.
8. Carefully follow instructions in this manual for proper
assembly and leak testing of your grill. Do not use grill
until leak checked. If leak is detected at any time, it must
be stopped and corrected before using grill further.
9. Appliance area should be kept clear and free from
combustible materials, gasoline, bottled gas in any from
and other flammable vapors and liquids. Do not obstruct
flow of combustion and ventilation air.
10.Ensure proper bottle position prior to lighting your grill.
Bottle should be vertical.
11.Never try to light grill with lid closed! Buildup of gases is
very dangerous and could cause an explosion.
12.Keep any electrical cord of fuel supply hose away from
any heated surfaces.
13.Propane is a flammable gas and improper handling may
result in explosion and/or fire and serious accident or
injury.
14.Do not allow oil or grease to get hotter than 400˚F (200˚C)
or if oil begins to smoke, immediately turn the burner or
gas supply “OFF” and wait for the temperature to
decrease to less than 350˚F (175˚C).
15.This appliance will be during and after use. Use
insulated oven mitts or gloves for protection from hot
surfaces or splatter from cooking liquids.
16.Do not leave your grill unattended while in operation.
17.Do not use while under the influence of drugs or alcohol.
18.Do not store any spare LP (propane) cylinder, full or
empty, under or near your grill.
19.Appliance is not intended for commercial use or rental.
20.The cylinder must be disconnected when the appliance
is not in use.
21.This instructions manual contains important information
necessary for the proper assembly and safe use of the
appliance.
22.Read and follow all warnings and instructions before
assembling and using the appliance.
23.Follow all warnings and instructions when using the
appliance.
24.Keep this manual for future reference.
CAUTION: Beware of Flash-back
CAUTION: Spiders and small insects occasionally spin
webs or make nests in the grill burner tubes during transit
and warehousing. These webs can lead to gas flow
obstruction which could result in a fire in and around burner
tubes. This type of fire is known as “FLASH-BACK” and
can cause serious damage to your grill and create an
unsafe operating condition for the user.
Although an obstructed burner tube is not the only cause of
“FLASH-BACK”, it is the most common cause.
To reduce the chance of “FLASH-BACK”, you must clean
the burner tubes before assembling your grill, and at least
once a month in late summer or early fall when spiders are
most active. Also perform this burner tube cleaning
procedure if your grill has not been used for an extended
period of time.
See instructions on cleaning burner tube on page 10.
3
SAFETY INFORMATION
The Fuel System
Gas grills are used safely by millions of people when
following simple safety precautions.
The items in the fuel system are designed for
operation with this Kenmore grill. They must not be
replaced with any other brand. (See parts list for
replacement items.)
GAS BURNER: The gas burner is constructed of
tubular stainless steel and should not require
maintenance other than inspection for insects/nests
inside the air intake slots.
BURNER VALVE/REGULATOR: The burner
control is actually a regulator/valve assembly. On
the right side of the grill, the regulator attaches
directly to the end of the burner and also to a 1pound propane cylinder. Only an identical part
gas/valve regulator must be used. (See parts list for
replacement items.)
LP GAS REGULATOR CAUTION
The gas pressure regulator provided with this
appliance must be used. This regulator is equipped
with the required orifice and is set for the required
outlet pressure for this appliance. This combination
of orifice size and pressure regulation specifications
provides the cooking performance intended by
Kenmore Table Top Grill. Substitution of regulator
by any other device or any other manufacturer is
dangerous and could result in serious injury.
LP GAS REGULATOR
The gas pressure regulator is shipped loose and
must be installed prior to operating y our grill. This is
a “slip-fit”~ requiring no tools. See assembly
instructions on page 7 for proper installation. The
regulator may be removed from the grill after use.
Turn the regulator control knob to the “OFF” position;
disconnect the LP cylinder and allow the grill to cool
for at least 30 minutes prior to removing regulator.
Care should be taken to store the regulator in a
clean, secure location when the grill is not in use.
The threaded cylinder connection area should be
kept clean and free of dust, dirt, sand or any
foreign materials. Clean both the regulator and
LP cylinder threaded areas prior to connecting
cylinder to regulator.
PROPANE FUEL: WARNING - propane is a
flammable gas. Improper handling may result in
an explosion and/or fire and serious accident or
injury. Your grill is designed to operate with
propane (LP) gas only and is equipped with the
proper orifice for propane gas.
WARNING: Do not connect this grill with any
gas supply other than propane. Propane gas is
heavier than air and settles in lower areas. Make
certain adequate ventilation is available when
using your grill. The gas cylinder may be stored
outside in a well-ventilated area out of the reach
of children when the grill is not in use.
LP GAS CYLINDER: This grill is designed and
intended to be used with a disposable propane
cylinder with a nominal fuel weight of 1 lb. Such
a cylinder is approximately 4” in diameter and 7”
long. The Kenmore Table Top Grill does not
include an LP gas cylinder. This must be
purchased separately and be found at most
hardware stores. The cylinder used must be
constructed in accordance with the specifications
for LP cylinders of the U.S. Department of
Transportation (DOT) DOT-39 NRC232/290 MllIO.
4
SAFETY INFORMATION
The LP gas cylinder shall be used only outdoors in a well-ventilated space and not in a building, garage, or
any other enclosed area. The Kenmore Table Top Grill may be stored indoors if the LP gas cylinder is
removed and stored outdoors. The LP gas cylinder (not included) is threaded for connection directly to the
gas regulator supplied with this appliance. Care should be taken when threading the cylinder to the regulator
to engage threads correctly to achieve the proper and intended connection. When disconnecting or
connecting the gas cylinder, be careful that the regulator does not strike the grill, the ground, or any other
surfaces. Replace the protective cap over the threaded cylinder connection when removed from grill. If any
difficulty occurs when connecting or disconnecting the cylinder to the regulator assembly, contact your local
gas supplier for assistance.
When re-connecting the LP gas cylinder to the regulator, be sure to hand-tighten until snug. This connection
should be inspected for damage and leak tested after each re-connection.
To leak test, make a soap solution of one part liquid detergent and one part water. You will need a spray
bottle, brush, or rag to apply the solution to the cylinder-regulator connection. Bubbles indicate leaks.
PACKAGE CONTENTS LIST
Part Description Quantity
1 Grill 1 set
2 Regulator 1 set
1
2
PREPARATION
Before beginning assembly, installation or operation of product, make sure all parts are present.
Compare parts with package contents list and diagram above. If any part is missing or damaged,
do not attempt to assemble, install or operate the product. Contact customer service for
replacement parts at 1-800-4-MY-HOME.
• Your Kenmore Table Top Grill is pre-assembled. The only assembly required is
to connect the gas regulator into the grill.
• Estimated Assembly Time: 5-8 minutes.
• Tools Required for Assembly: Wrench (supplied).
5
Loading...