Nex 720-0686 Owner's Manual

ITEM #0297983

STAINLESS STEEL CHARCOAL GRILL

WARNING WARNING

READ ALL INSTRUCTIONS AND WARNINGS CAREFULLY. FAILURE TO FOLLOW PROPER PROCEDURES AND WARNINGS MAY RESULT IN SERIOUS INJURY AND PROPERTY DAMAGE

Example only: SERIAL # ________ MFG. DATE ________ PURCHASE DATE: _________

Questions, problems, missing parts? Before returning to your retailer, call our customer service department at 1-877-323-5263, 8 a.m. - 6 p.m., PST, Monday - Friday, 8 a.m. – 12 p.m. Saturday.

FOR OUTDOOR USE ONLY

WARNING

This grill is not intended to be installed in or on recreational vehicles and/or boats.

MODEL #720-0686

TABLE OF CONTENTS

Safety Information……………………………………………………..........................................3

Package Contents List……….……………………………………………………………………….5

Hardware Contents…….…………………. ……………………….…………….……………….....6

Preparation...............................................................................................................................6

Assembly Instructions…………………………………………………………………….…..……6

Operating Tips ……………………………………………………………….....…….……...........12

Charcoal Grill Information ………………………………………………………………….………14 Warranty……………………….………….…………………………………………..…………..….16

Replacement Parts List………………….…....……………………………………..…….….…….17

SAFETY INFORMATION

WARNING – Hazards or unsafe

practices which COULD result in severe personal injury or death.

CAUTION – Hazards or unsafe practices which COULD result in minor personal injury.

CAUTION

This unit is heavy. Two people required for safe assembly.

Some parts may contain sharp edges. Wear protective gloves if necessary.

Read and follow all safety statements, warning, assembly instructions and use and care instructions before attempting to assemble and use.

WARNING Carbon monoxide hazard. Burning charcoal inside can kill you. It gives off carbon monoxide, which has no odor. NEVER burn charcoal

inside homes, vehicles or tents.

WARNING

If for any reason you do not understand any of these instructions, contact customer service at 1-877-323-5263.

WARNING Keep a fire extinguisher near this unit at all times.

WARNING This grill is for outdoor use only, in well-ventilated areas..

WARNING

The use of alcohol, prescription or non-prescription drugs may impair the user’s ability to properly assemble and safely operate this unit

WARNING Use caution when lifting and moving the unit to avoid back strain or back injury. Use two people to lift or move the unit. Do not move the unit while it is in use.

WARNING

DO NOT Operate the unit near or under flammable

or combustible materials such as decks, porches or carports. A minimum clearance of 36 in. (92 cm) is recommended. DO NOT operate the unit under overhead construction.

WARNING

Use caution when assembling and operating this unit to avoid cuts and scrapes from edges.

WARNING This product is not to be used as a heater.

WARNING Operate the unit on a stable, level, non-

flammable surface such as asphalt, concrete or solid ground. DO NOT operate the unit on flammable material such as carpet or wood deck.

WARNING

DO NOT use this product in a manner other than

its intended a purpose. It is NOT intended for commercial use. It is not intended to be installed or used in or on a recreational vehicle and/or boats.

WARNING DO NOT Store this unit near gasoline or other

combustible liquids or where other combustible vapors may be present.

WARNING WARNING

DO NOT store or operate this product in an area

accessible to children or pets. Store this unit in a dry, protected location.

The grill head is heavy and will require two or more people to lift and position onto grill cart.

WARNING

DO NOT leave the unit unattended while in use..

WARNING

DO NOT move the unit while in use or while ashes

are still hot. Allow the unit to cool completely before moving or storing.

WARNING DO NOT leave hot ashes unattended until the

rill cools completely.

WARNING NEVER use gasoline or other highly volatile fluids as a starter.

WARNING WARNING Always cook your food on the grade after the flame is burned out.

WARNING If you must dispose of ashes in less time than it takes for the ashes to completely cool down, then remove the ashes from the unit, keeping them in the heavy-duty foil, and soak them completely with water before disposing of them in a

Dispose of cold ashes by wrapping them in a heavy-duty aluminum foil and placing in a noncombustible container. Make sure that there are no other combustible materials in or near the container.

WARNING Allow the unit to cool completely before conducting any routine cleaning or maintenance.

SAFETY PRACTICES TO AVOID INJURY

When properly cared for, your grill will provide safe, reliable service for many years. However, use extreme care as the grill produces intense heat that can increase accident potential.

When operating this appliance, practice these basic safety precautions: Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service

should be referred to a qualified technician. Do not install the grill in or on recreational vehicles and/or boats. Do not leave children alone or unattended in an area where the grill is being used. Do not allow children to sit,

stand or play on or around the grill at any time. Do not store items of interest to children around or below the grill or cart. Do not allow children to crawl insi de the cart.

Do not use aluminum foil to line the grill racks or grill bottom. This can severely upset combustion air flow or trap excessive heat in the control area.

Do not use the grill to cook excessively fatty meats or other products, which promote flare-ups.

This unit is intended for outdoor use only. Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront,

mountaintop, etc.), a windbreak will be required. Always adhere to the clearance specifications

PACKAGE CONTENTS LIST

A. Bottom Panel -----------1pc

B. Caster ------------------2pcs

C.Swivel Caster with brake--1pc

D. Swivel Caster ----------1pc .

G. Back Panel ----------1pc

J. Crank Handle ----------1pc

E. Left Side Panel --------1pc

H. Charcoal grill firebox ---1pc

K. Charcoal Tray ----------1pc

F. Right Side Panel---------1pc

I. Main Lid -----------------1pc

L. Drawer A ----------1pc .

M. Drawer B ----------1pc

P. Side Shelf,right--------1pc

N. Push Bar ----------------1pc

Q. Grate Lifter--------------1pc

O. Side shelf,left------------1pc

HARDWARE CONTENTS

Pack Description Quantity

AA 1/4-in. x 23-mm Main Lid Screw 2 pcs. BB 1/4-in. x 15-mm Truss Head Screw 8 pcs. CC 1/4-in. x 12-mm Truss Head Screw 36 pcs. DD 5/32-in. x 10-mm Truss Head Screw 10pcs. EE 1/4-in. Nut 4 pcs.

FF 1/4-in. Flat Washer 10 pc. GG 1/4-in. Locking Washer 36 pc. HH 5/32-in. Locking Washer 10 pc.

II 1 pc.

AA BB CC DD EE

PREPARATION

Before beginning assembly, installation or operation of product, make sure all parts are present. Compare parts with package contents list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the product. Contact customer service for replacement parts.

y Estimated Assembly Time: 50 minutes

FF GG HH

y Tools Required for Assembly:

Phillips Screwdriver (not included) and Wrench (not included)

y Note: The right and left sides of the grill are designated as if you are standing and facing the grill.

ASSEMBLY INSTRUCTIONS

1. Swivel Caster Assembly Mount the caster onto the bottom panel (A) using sixteen 1/4-in. x15-mm truss head screws (BB), sixteen 1/4-in. locking washers (GG) and sixteen 1/4-in. flat washers (FF).

Position The swivel caster with brake (C) under the left rear of the cart bottom (A), and position the swivel

caster (D) under left front as shown in Fig. 1.

Position the two stationary casters (B) should be positioned under the right side.

NOTE: Turn over the bottom panel to mount the caster.

A C

Hardware Used Quantity 1/4-in. x 15-mm truss head screws (BB) 1/4 in. locking washers 16 x 1/4-in. flat washers (FF) 16 x

Fig. 1

16 x

+ 11 hidden pages