Nex 720-0341 Owner's Manual
Cover
Assembly Instructions/Use and Care Manual
Liquid Propane Gas Grill
Model No.: 122.16119
!
WARNING:
Read this Owner’s manual carefully and be
sure your gas grill is properly assembled,
installed and maintained. Failure to follow
these instructions could result in serious injury
and/or property damage. This gas grill is
intended for outdoor use only and is not
intended to be installed in or on recreational
vehicles or boats.
Note to Installer
Leave this Owner’s Manual with the customer
after delivery and/or installation.
•Parts
•Assembly
•Safety Rules
•Use and Care
•Troubleshooting
•Español
Note to Consumer
Leave this Owner’s Manual in a convenient
place for future reference.
Customer Service Helpline:
For parts ordering, call:
1-800-4–MY-HOME
For assembly questions, call:
1-800-913-8999
Date: 2006/10/26
H16Y06P-1
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
Table of Contents
PRECAUTIONS
Warranty------------------------------------------------2
Safety Precautions--------------------------------2~4
Hardware List------------------------------------------5
Parts Diagram -----------------------------------------6
Parts List------------------------------------------------7
Assembly Instructio ns---------------------------8~13
Lighting Instructions----------------------------14~15
Cleaning and Maintenance-------------------16~17
Troubleshooting--------------------------------------18
Cooking Instru ction----------------------------------19
Cooking Chart----------------------------------------20
Kenmore Grill Warranty
One-Year Full Warranty on Kenmore Grill
If this grill fails due to a defecting material or
workmanship within one year from the date of
purchase, call 1-800-MY-HOME to arrange for
free repair (or replacement if repair proves
impossible).
Five-Year Limited Warranty on Stainless Steel
Burners
For five years from the date of purchase, any
stainless steel burner that rusts through will be
replaced free of charge. After the first year from
the date of purchase, you pay for labor if you
wish to have it install ed.
All warranty coverage excludes ignitor batteries
and grill part paint loss, discoloration or rusting,
which are either expendable parts that can wear
out from normal use within the warranty period,
or are conditions that can be the result or normal
use, accident or improper maintenance,
All warranty coverage is void if this grill is ever
used for commercial or rental purposes.
All warranty coverage applies only if this grill is
used in the United States.
This warranty gives you specific legal rights, and
you may have other right which vary from state to
state.
Sears, Roebuck and Co.,
Hoffman Estates, IL 60179
U.S.A.
WARNING
!
Combustion by products produced when using
this product contain chemicals known to the
State of California to cause cancer, birt h de f ect s,
or other reproductive harm.
WARNING
!
Failure to comply with these instructions could
result in a fire or explosion that could cau se
serious bodily injury, death, or property damage.
WARNING
!
Your grill will get very hot. Never lean over the
cooking area while using your grill. Do not touch
cooking surfaces, grill housing, lid or any other
grill parts while the grill is in operation, or until
the gas grill has cooled down after use.
Failure to comply with these instructions may
result in serious bodily injury.
WARNING
!
1. Do not store or use gasoline or other
flammable material and liquids in the
vicinity of this or any other appliance.
2. A LP cylinder not connected for use must
not be stored in the vicinity of this or any
other appliance.
DANGER
!
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open Lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department
Grill Installation Codes
The installation must conform with local codes or,
in the absence of local codes, with either the
national fuel gas code, ANSIZ 223.1/NFPA S4,
Natural gas and propane installation code, CSA
B149.1, or propane storage and handling code,
B149.2, or the standard for Recreational vehicles,
ANSI A 119.2, and CSA Z240 RV series
recreational vehicle code, as applicable.
LP gas grill models are designed for use with a
standard 20 lb. Liquid Propane Gas tank, not
included with grill. Never connect your gas grill to
an LP gas tank that exceeds this capacity.
.
2
PRECAUTIONS
A tank of approximately 12 inches in diameter by 181/2 inches high is the maximum size LP gas tank to
use. You must use an OPD gas tank which offers
an Overfill Prevention Device.
This safety feature prevents the tank from being
overfilled which can cause malfunction of the LP gas
tank, regulator and/or grill.
The LP gas tank must be constructed and marked in
accordance with specifications of the U.S. Dept. of
Transportation (DOT). In Canada, the LP gas tank
must meet the National Standard of Canada ,Can
CSA –B339 , Cylinders , spheres and Tubes for
Transportation of Dangerous Goods and Commission .
1. The LP gas tank must have a shutoff valve,
terminating in an LP gas supply tank valve outlet, that
is compatible with a Type 1 tank connection device.
The LP gas tank must also have a safety relief device
that has a direct connection with the vapor space of
the tank.
2. The tank supply system must be arranged for vapor
withdraw.
3. The LP gas tank used must have a collar to protect
the tank valve.
Proper Placement and Clearance of Grill
Never use your gas grill in a garage, porch, shed,
breezeway or any other enclosed area. Your gas grill
is to be used outdoors only, at least 24 inches from
the back and side of any combustible surface. Your
gas grill should not be used under overhead
combustible construction . Do not obstruct the flow of
ventilation air around the gas grill housing.
• Do not install this outdoor gas grill in or on
recreational vehicles or boats
• Keep outdoor gas grill area clear and free from
combustible materials, gasoline and other flammable
vapors and liquids
•Do not obstruct the flow of combustion and ventilation
air. Check for this each time prior to using grill.
• Never connect an unregulated LP gas tank to your
gas grill. The gas regulator assembly supplied with
your gas grill is adjusted to have an outlet pressure of
11” water column (W.C.) for connection to an LP gas
tank.
• Only use the regulator and the hose assembly
supplied with your gas grill. Replacement regulators
and hose assemblies must be those specified in this
manual.
• Have your LP gas tank filled by a reputable propane
gas dealer and visually inspected and re-qualified at
each filling.
• Do not store a spare LP gas tank under or
• near this appliance.
• Never fill the tank beyond 80 percent full . If this
information is not followed exactly a fire causing
death or serious injury may occur.
• Always keep LP gas tanks in an upright position.
• Do not store (or) or use gasoline or other flammable
vapors and liquids in the vicinity of this gas grill.
• Do not subject the LP gas tank to excessive heat.
• Never store an LP gas tank indoors. If you store your
gas grill in the garage or other indoor location,
always disconnect the LP gas tank first and store it
safely outside.
• Place dust cap on tank valve outlet whenever the
tank is not in use. Only install the type of dust cap on
the tank valve outlet that is provided with the tank
valve. Other types of caps or plugs may result in
leakage of propane.
• LP gas tanks must be stored outdoors in a wellventilated area and out of reach of children.
Disconnected LP gas tanks must not be stored in a
building, garage or any other enclosed area.
• When your gas grill is not in use the gas must be
turned off at the LP gas tank.
• The regulator and hose assembly must be inspected
before each use of the grill. If there is excessive
abrasion or wear or if the hose is cut, it must be
replaced prior to the grill being used again.
• Keep the gas regulator hose away from hot grill
surfaces and dripping grease. Avoid unnecessary
twisting of hose. Visually inspect the hose prior to
each use for cuts, cracks, excessive wear or other
damage. If the hose appears damaged do not use
the gas grill. Call 1-800-4-MY-HOME for assistance.
• Never light your gas grill with the lid closed or before
checking to ensure the burner tubes are fully seated
over the gas valve orifices.
• Never allow children to operate your grill.
3
WARNING
!
A strong gas smell, or the hissing sound of gas
indicates a serious problem with your gas grill or
the LP gas tank. Failure to immediately follow the
steps listed below could result in a fire or
explosion that could cause serious bodily injury,
death, or property damage.
• Shut off gas supply to the gas grill.
• Turn the control knobs to OFF position.
• Put out any flame with a proper fire extinguisher.
• Open Grill Lid.
• Get away from the LP gas tank.
• Do not try to fix the problem yourself.
• If odor continues or you have a fire you can not
extinguish, call your fire department. Do not call
near the LP gas tank because your telephone is
a form of electrical device and could create a
spark resulting in fire and/or explosion.
NOTE: The normal flow of gas through the regulator
and hose assembly can create a humming noise. A
low volume of noise is perfectly normal and will not
interfere with operation of the grill. If humming noise
is loud and excessive you may need to purge air from
the gas line or reset the regulator excess gas flow
device. This purging procedure should be done every
time a new LP gas tank is connected to your grill. For
help with this procedure refer to page 15, step 4, or
call the Customer Service Helpline 8 AM to 5 PM
EST at: 1-800-4-MY-HOME
CAUTION: Beware of Flash-back
CAUTION: Spiders and small insects occasionally
spin webs or make nests in the grill burner tubes
during transit and warehousing. These webs can lead
to gas flow obstruction which could result in a fire in
and around burner tubes. This type of fire is known as
“FLASH-BACK” and can cause serious damage to
your grill and create an unsafe operating condition for
the user.
Although an obstructed burner tube is not the only
cause of “FLASH-BACK”, it is the most common
cause.
To reduce the chance of “FLASH-BACK”, you must
clean the burner tubes before assembling your grill,
and at least once a month in late summer or early fall
when spiders are most active. Also perform this
burner tube cleaning procedure if your grill has not
been used for an extended period of time.
Burner Flame Check
Visually check the burner flames prior to each use. The
flames should look like picture, if they do not, refer to the
cleaning burner tubes and ports, see page 17 of this
manual.
Repair Protection Agreements
Congratulations on making a smart purchase. Your
new Kenmore product is designed and manufactured
for years of dependable operation. But like all products,
it may require repair from time to time. That's when
having a Repair Protection Agreement can save you
money and aggravation.
Purchase a Repair Protection Agreement now and
protect yourself from unexpected hassle and expense.
Here’s what’s included in the Agreement:
Expert service by our 12,000 professional repair
specialists
Unlimited service and no charge for parts and labor
on all covered repairs
Product replacement if your covered product can not
be fixed
Discount of 10% from regular price of service and
service-related parts not covered by the agreement,
also, 10% off regular price of preventive maintenance
check
Fast help by phone-phone support from a Sears
technician on products requiring in-home repair, plus
convenient repair scheduling
Once you purchase the Agreement, a simple phone
call is all that it takes for you to schedule service. You
can call anytime day or night, or schedule a service
appointment online.
Some limitations and exclusions apply.
For prices and additional information call 1 -800-827-
6655.
See Cleaning Burner Tubes and Ports on page # 17
4
Contents for Hardware Pack
The following table illustrates a breakdown of the hardware pack. It highlights what components are used in
the various stages of assembly.
Item Description Specification Quantity
Phillips Head Screw
1/4 x 1.38"18 pcs
Phillips Head Screw
2 1/4 x 3/5" 19 pcs
Phillips Head Screw
3 5/32 x 2/5" 19 pcs
Phillips Head Screw
4 5/32 x 1.38" 1 pcs
Hex Nut
5 1/4" 2 pcs
Hex Nut
63 pcs
5/32"
Flat Washer
7 1/4" 6 pcs
Lock Wa sher
8 1/4" 23 pcs
Lock Wa sher
9 20 pcs5/32"
5
Model 122.16119 Parts Diagram
01
02
03
04
28
24
25
26
27
31
09
08
11
18
19
12
20
21
22
23
54
44
46
41
42
49
39
40
32
33
34
35
36
37
38
55
47
48
50
51
52
53
6
Model 122.16119 Parts List
KEY# PART S # DESCRI PTIO N Q’T Y KEY# PART S # DESCRI PT ION Q’TY
1 341-001 Main Lid 1 30 341-030 Tank Heat Shi el d 1
2 341-002 Temperature Gauge 1 31 341-031 Side Burner Lid 1
3 341-003 Logo 1 32 341-032 Side Burner Lid Hinge Rod 1
4 341-004 Main B urner bowl as sembl y 1 33 341-033 Side Burner Bowl A ss em bl y
Frame
5 341-005 Front B affle 1 34 341-034 Side Burner Cooking Grat e 1
6 341-006 Main Gas Val ve( Cast brass) 4 35 341-035 Side Burner Igniter W i re 1
7 341-007 Main Mani fold 1 36 341-036 Side Burner Bowl A ss em bl y
Firebox
8 341-008 Main Control P anel A ss em bl y 1 37 341-037 Side Burner Head 1
9 341-009 Pulse Igniter M odule 1 38 341-038 Side Burner, P i pe 1
10 341-010 Control K nob 5 39 341-039 Grease Slide Panel, Top 1
11 341-011 Bez el 5 40 341-040 Grease Slide Panel, B ottom 1
12 341-012 Timer 1 41 341-041 Grease Cup Holder 1
13 341-013 Side S hel f, Left 1 42 341-042 Grease Cup 1
14 341-014 Side S hel f Front P anel , Left 1 43 341-043 Cart Frame, Rear 1
15 341-015 Side P anel , Left 1 44 341-044 Side Gas V al ve 1
16 341-016 Cart Frame, F ront 1 45 341-045 Regulator, LP 1
17 341-017 Cart Front S upport 1 46 341-046 Bac k P anel 1
18 341-018 Front Door, Left 1 47 341-047 Side Shelf ,Right 1
19 341-019 Wheel 2 48 341-048 Side Shelf Front Panel, Right 1
20 341-020 Door Magnet 4 49 341-049 Side P anel , Ri ght 1
21 341-021 Cart Clapboard 1 50 341-050 Tank Bolt 1
22 341-022 Bottom P anel 1 51 341-051 Cart Caster Insert 2
23 341-023 Front Door, Ri ght 1 52 341-052 Swivel Caster W i t h Brake 2
24 341-024 Warm i ng Rac k 1 53 341-053 Lighting Rod 1
25 341-025 Cooking Grids wit h Hole (Cas t
iron)
26 341-026 Flame Tamer 4 55 341-055 Side B urner B rac ket 1
27 341-027 Main B urner 4 56 341-056 M anual
28 341-028 Main B urner Igniter Wire 4 57 341-057 Hardware Pac k 1
29 341-029 Tank Heat Shi el d, P i ece 1
2 54 341-054 Regulator Hos e Ret ention Clam p 1
1
1
1
For assembly questions, call:
1-800-913-899
For parts ordering, please call:
1-800-4-MY-HOME
To make sure you obtain the correct replacement
parts for your Kenmore gas grill, pl ease refer to
the part numbers on this page.
Important: Use only parts listed above. When ordering
parts, providing the following information:
1. Model #
2. Part Number (see PART# in chart)
3. Part Description
4. Quantity of parts needed
Important: Keep this Owner’s Manual for convenient
reference and for part replacement.
7
Loading...