Nex 720-0309 Owner's Manual

ASSEMBLY & OPERATING INSTRUCTIONS

MODEL# 720-0309

PLEASE CONTACT 1-866-984-7455 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE

FOR OUTDOOR USE ONLY

MESSAGE TO OUR CONSUMERS

Thank you for selecting our stainless steel gas grill.

Because this appliance contains features which may not found on other grill, we recommend that you read this entire booklet before your first use. Keep it in handy place as it has answers to questions that may occur during future use.

Read this booklet carefully and be sure your gas grill is properly assembled, installed and maintained. Failure to follow these instructions could result in serious bodily injury and/or property damage. This gas grill in intended for outdoor use only and is not intended to be installed in or on recreational vehicles or boats.

NOTE TO INSTALLER: Leave these instructions with the consumer after installation. NOTE TO CONSUMER: Retain for future reference.

TABLE of CONTENTS

SECTION ONE

Precaution ……………………………...1 Placement of the grill ………………… 3

SECTION TWO

Assembly instructions ………………...4

SECTION THREE

Gas hook-up …………………………. 13

Leak testing ……….………………..... 14

Operation Instructions...………………15

Grill lighting instruction …………….. ..16

SECTION FIVE

Care and maintenance ………………….17 To match light the grill……………………18 Troubleshooting ………………………… 19 SECTION SIX Exploded view…………………………….20 Parts list ………………………………… .21 Ordering parts ……………………………22 Grill hints ………………………………….22

SECTION SEVEN

Grill Cooking Chart ………………………23

SECTION EIGHT

Grill recipe suggestions …………………25

SECTION NINE

Warranty ………………………………….28

PRECAUTIONS

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. If odor continues, immediately call

your gas supplier or your fire department, keep away from the appliance and immediately call your gas supplier or your fire department.

1. Do not store or use gasoline or other

2. An LP cylinder not connected for use

FOR YOUR SAFETY

flammable vapors and liquids in the vicinity of this or any other appliance.

shall not be stored in the vicinity of this or any other appliance..

CALIFORNIA PROPOSITION 65-WARNING

The burning of gas fuel generates some byproducts, which are on the list of substances that are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to these substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with gas.

WARNING

Combustion by products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

WARNING

TESTED IN ACCORDANCE WITH ANSI Z21.58b-2005 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONLY.

Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223.1-1988 and the National Electrical Code ANSI/NFPA No. 70-1990.

Grill Installation Codes

A statement that the installation must conform with local codes or,in the absence of local codes ,with either the national fuel gas code ,ANSIZ 223.1/NFPA S4,Natural gas and propane installation code,CSA B149.1,or propane storage and handling code,B149.2, or the standard for Recreational vehicles,ANSI A

119.2,and CSA Z240 RV series Recreational vehicle code,as applicable. Correct LP Gas Tank Use

Do not try to light this appliance without first reading the “LIGHTING INSTRUCTIONS”

SAFETY PRACTICES TO AVOID PERSONAL INJURY

When properly cared for, your stainless steel grill will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat and that can increase accident potential. When using this appliance basic safety practices must be followed, including the following: Read this Care and Use Manual carefully and completely before using your grill to reduce the risk of fire, burn hazard or other injury. Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician.

CHILDREN SHOULD NOT BE LEFT ALONE OR UNATTENDED IN AN AREA WHERE THE GRILL IS BEING USED. NEVER ALLOW THEM TO SIT, STAND OR PLA Y ON OR AROUND THE GRILL AT ANY TIME.

PRECAUTIONS

DO NOT STORE ITEMS OF INTEREST TO

CHILDREN AROUND OR BELOW THE GRILL OR IN THE CART. NEVER ALLOW CHILDREN TO CRAWL INSIDE OF THE CART.

Never let clothing, pot holders or other flammable materials come in contact with or too close to any grate, burner or hot surface until it has cooled. Fabric may ignite and result in personal injury. For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.

Only certain types of glass, heat-proof glass ceramic, earthenware, or other glazed utensils are suitable for grill use. Theses types of materials may break with sudden temperature changes. Use only on low or medium heat settings according to the manufacturer’s directions.

Do not heat unopened food containers as a build-up of pressure may cause the container to burst.

Use a covered hand when opening the grill lid. Never lean over an open grill.

WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE ATTENTION TO WHAT YOU ARE DOING. BE CERTAIN YOU ARE TURNING THE IGNITER LABELED FOR THE BURNER YOU INTEND ON USING.

When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders.

Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or potholders. Do not let potholders touch hot portions of the grill rack.

Grease is flammable. Let hot grease cool before attempting to handle it. Avoid letting excess grease deposits collect in the grease tray at the bottom of the grill’s firebox. Clean often.

DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can

severely upset combustion air flow or trap excessive heat in the control area.

For proper lighting and performance of the burners keep the burner ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation.

Clean the grill with caution. Avoid steam burns; do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface.

Keep the cover of the grill closed during preheat period

INSECT WARNING!!! Spiders and insects can nest in the burners of this and any other grill, and cause the gas to flow improperly. This is a very dangerous condition which can cause a fire to occur behind the value panel, thereby damaging the grill and making it unsafe to operate. Inspect the grill twice a year.

Be sure all grill controls are turned off and the grill is cool before using any type of aerosol cleaner on or around the grill. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode.

PRECAUTIONS

Do not use the grill for cooking excessively fatty meats or products which promote flare-ups. Do not operate the grill under unprotected combustible construction. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas. THIS UNIT IS FOR OUTDOOR

USE ONLY.

Keep the area surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. A minimum of 24” clearance away from combustible material. Do not obstruct the flow of combustion and ventilation air. If the unit is stored indoors ensure that it is cool. If propane is used, the cylinder must be unhooked and the propane cylinder stored outside in a well ventilated area, out of the reach of children.

DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL.

This stainless steel grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent. Adding briquettes can damage ignition components and knobs, and void the warranty.

Keep the back of the cart free and clear from debris. Keep any electrical supply cord, or the rotisserie motor cord away from the heated areas of the grill. Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.) a windbreak will be required (see below). Always adhere to the specified clearance.

NEVER USE A DENTED OR RUSTY PROPANE TANK.

PLACEMENT OF THE GRILL

CLEARANCE

To Non-Combustible Construction

A minimum of 3” clearance from the back of the grill to non-combustible construction is required for the lid to open fully.

DO NOT INSTALL THIS UNIT INTO COMBUSTIBLE ENCLOSURES!

LOCATION

When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths and keeping any gas supply lines as short as possible.

Locate the grill only in a well-ventilated area. Never locate the grill in a building, garage, breezeway, shed or other such enclosed areas without an approved ventilation system. During heavy use, the grill will produce a lot of smoke. Lock the wheels after the grill is placed in a suitable position according to the sticker located beneath the right door. Keep any electrical supply cord and the fuel supply hose away from any heated surfaces. Storage of an outdoor gas cooking appliance indoor is permissible only if the cylinder is disconnected and removed from the appliance. This outdoor cooking gas appliance shall be used only outdoor and shall not be used in a building, garage or any other enclosed area. This appliance is not intended to be installed on or on recreational vehicles and/or boats

ASSEMBLE INSTRUCTIONS

PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP

¾ Propane Tank is not included ¾ Philips head Screwdriver (not provided) ¾ The following hardware is provided

Item

Descr i pt i on( SCALE 1: 1)

cr ossed r ound head scr ew

was her

f l at washer

Quant i t ySpecification

1/ 4¡ Á40mm

1/ 4¡ Á15mm

5/ 32¡ Á10mm

1/ 4

8pcs

22pcs

14pcs

30pcs

PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP.

Caution: Please lock casters during installation process

STEP 1: Remove side panel (L+R) and caster from the carton, secure two caster to side panel marked “R” and two caster with brake to side panel marked “L” as shown in

figure below.

STEP 2: Attach bottom panel to side panel legs use 8 pieces truss head screws (1/4” x 40 mm) with 8 pieces 1/4” lock washers and flat washers to

secure bottom panel and side panel legs.

STEP 3: Assemble back panel to side panel legs with 6 (5/32” x 8mm) truss head screws as shown fi

ure below.

STEP 4: Fix cart frame cross bar to both side panel-legs with 4 (1/4” x 15mm) truss head screws with lock washers and flat washers.

STEP 5: Attach door with door shaft in the bottom panel, at the same time assembly the front flame with the door shaft, second assembly the front flame to side panel legs with 4 pieces (1/4” x 15mm) truss head screws with lock washers and flat washers.

Caution : There is many parts need to connect, we recommend two persons at least for this step.

STEP 6: Atta ch center door flame with bottom panel and front flame use 4 pieces (5/32”x10) screws.

+ 21 hidden pages