Mountain Off Road LUBEABLE SHACKLES User Manual

MOUNTAIN OFF ROAD ENTERPRISES, LLC. P.O. BOX 690 DELTA COLORADO 81416

970-625-0500

970-625-3747 FAX

E-mail: info@mountainoffroad.com

www.mountainoffroad.com

INSTALLATIONS INSTRUCTIONS for M.O.R.E.™ LUBEABLE SHACKLES

4-side plates 4-drilled shackle bolts 6-crimp-loc nuts ,4-w/o center brace 4-drilled sleeves, not available on CJ shackles w/ 1” bushings 2-center braces, Not available on LS9039 2-center brace bolts, Not available on LS9039 8-polyurethane bushing halves

Contents of SHACKLES :

This is the proper configuration for the shackles. On some applications the bolt in center brace may need to be left out. This picture shows the shackle in a S.R.S. set up.

The LUBEABLE shackles fit the front & rear of your leaf sprung Jeep®. The above pictures show the proper way to install them. After removing the stock shackles, install the shackles as shown in the picture(s) above. Torque the bolt-in center brace bolt/nut to 55 Lb. Ft. torque. Tighten the greaseable shackle bolts to 30 Lb. Ft. torque. Lube with your favorite chassis grease.

TERMS-POLICIES:

DAMAGE CLAIMS: All orders are carefully packed, however, mishandling by the carrier can result in damage. The carrier has the responsibility for the shipment from the time it leaves our warehouse until it is delivered to you. All claims for lost or damaged goods should be reported to the carrier, not to M.O.R.E.™ LLC.

RETURNS: No returns will be accepted without prior permission from M.O.R.E.™ LLC. After you receive a Return Goods Authorization (RGA) number, merchan- dise must be returned prepaid and insured. A claim must be made with in 30 days from receipt of merchandise. The original invoice or a copy with the RGA number written on must accompany all returns. A 20% restocking fee will be charged on all parts returned for credit or refund un less merchandise is proven to be defective or was shipped wrong by M.O.R.E.™ LLC. No merchandise will be issued credit or refund if it has been installed, modified, used in any way or is in unsalable condition.

WARRANTY: All merchandise is warranted to be free from defects in materials and workmanship prior to installation. Any alteration or improper use will void this warranty. Because all parts we sell are intended for use in heavy-duty applications it is not possible to warrantee or guarantee the performance of any items. M.O.R.E.™ LLC. products and the products manufactured by others, which we sell may be subject to an infinite variety of conditions due to the manner in which they are used, serviced and/or installed. Purchasers and users of such products rely upon their own judgment as to the suitable use selection, service and installation of such products.

PRODUCT DISCLAIMER: Modification of your vehicle to enhance performance with parts sold by M.O.R.E.™ LLC. may create a dangerous condition which could cause serious bodily injury, and the buyer hereby expressly assumes all risks associated with any such modifications. All parts sold by M.O.R.E.™ LLC. are for racing or off road use only. Mountain Off Road Enterprises LLC. will not accept responsibility for personal injury or property damage arising from the failure of any parts manufactured or sold by M.O.R.E.™ LLC.

Specifications are subject to change without notice.

Jeep®, AMC®, CJ®, YJ®, Wrangler®, are registered trademarks of DaimlerChrysler. M.O.R.E.™ is not affiliated with DaimlerChrysler.