Master Forge Ggp-2601 Owner's Manual

ITEM # 296451

4-Burner LP Gas Grill

with Rotisserie Burner

MODEL #GGP-2601

version 2.0

Questions, problems, missing parts? Before returning to your retailer, call our customer service department at 1-866-869-5300, 8 a.m.-6 p.m., EST, Monday-Friday.

! DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.

! WARNING

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

3. This grill is for outside use only, and should not be used in a building, garage, under overhangs or any other enclosed area.

4. Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.

CALIFORNIA PROPOSITION 65

(1) Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. (2) This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer, birth defects or other reproductive harm.

Wash your hands after handling this product

TABLE OF CONTENTS

Safety Information .....................................................................................................................

Package Contents .....................................................................................................................

Illustrated Parts List ...................................................................................................................

Hardware Contents ....................................................................................................................

Preparation ................................................................................................................................

Assembly Instructions ................................................................................................................

Operation Instructions ...............................................................................................................

Care and Maintenance ..............................................................................................................

Troubleshooting .........................................................................................................................

Warranty ....................................................................................................................................

Replacement Parts List .............................................................................................................

2 4 5 7

7 8

19 21 24 25

SAFETY INFORMATION Please read and understand this entire manual before attempting to assemble, operate or install

the product. If you have any questions regarding the product, please call customer service at 1-866-869-5300, 8 a.m.-6 p.m., EST, Monday-Friday.

1. DO NOT store or use gasoline or any other flammable vapors and liquids within 25 feet (8 m) of this or any other appliance.

2. When cooking with oil/grease, do not allow the oil/grease to exceed 350° F (177°C). Do not store or use extra cooking oil in the vicinity of this or any other appliance.

3. An LP Cylinder not connected for use should be stored a minimum of 10 feet (3 m) away from this or any other appliance.

4. If you smell gas:

- Shut off gas to the grill.

- Extinguish any open flame.

- Open Lid.

- If odor continues, immediately call your gas supplier or fire department.

5. This grill is for use with propane gas only (propane gas cylinder not included).

6. Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor home or house.

7. Never use charcoal or lighter fluid with the grill.

8. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and marked in accordance with the specifications for propane gas cylinders of the U.S. Department of Transportation (DOT) CFR 49. This grill is not intended to be used in or installed on recreation vehicles and/or boats.

9. Do not attempt to move the grill while it is lit.

10. Do not use the grill unless it is completely assembled and all parts are securely fastened and tightened.

11. Keep all combustible items and surfaces at least 20 inches (50.8 cm) away from the grill at all times.

12. DO NOT use this gas grill or any gas product near unprotected combustible constructions.

13. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

14. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc…).

15. Do not alter this grill in any manner.

16. Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to operating the appliance. The replacement hose assembly will be that which is specified by the manufacturer.

17. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

18. Never keep a filled container in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the relief valve and allow gas to escape.

19. Keep the grill's valve compartment, burners and circulating air passages clean. Inspect the grill before each use.

20. This grill is for outside use only, and should not be used in a building, garage, under

overhangs or any other enclosed area.

21. The use of alcohol, prescription or non-prescription drugs may impair the operator's ability to properly assemble or safely operate the grill.

22. Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn you severely.

23. Always place your grill on a hard, level surface far away from combustibles. An asphalt or blacktop surface may not be acceptable for this purpose.

24. Do not leave a lit grill unattended. Keep children and pets away from the grill at all

times.

25. Do not place this grill on any type of tabletop surface.

26. Do not use the grill in high winds.

27. Minimum clearance from sides and back of unit to combustible construction, 36 inches from sides and back.

NOTE: The installation must confirm with local codes or,in the absence of local codes,with either the National Fuel Gas Code,ANSI Z 223.1/NFPA 54,Natural Gas and Propane Installation Code, CSA B149.1,or Propane Storage and Handling Code,B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/ NFPA 1192,and CSA Z240 RV Series,Recreational Vehicle Code,as applicable.

PACKAGE CONTENTS

Part

A B

C D

F G H

J K

Description

right side cabinet panel

left side cabinet panel

bottom cabinet panel back cabinet panel

front top beam

steel wire

left door

door handle

right door

grill housing assembly

left side table assembly

right side table assembly

Quantity

1 1

1 1 1 1 1

2 1 1 1

Part

M N

O P

Q R S

T U

Description

side knob

drip pan

condiment box

grease collection pan

heat shield cooking grate warming rack

tool hook

tank retainer wire

Quantity

2 1

2 1 4 3 1 1 1

ILLUSTRATED PARTS LIST

Right side cabinet panel

Back cabinet panel

Left door

Left side cabinet panel

Front top beam

Door handle

Bottom cabinet panel Assembly

Steel wire

Right door

Grill housing assembly

Side knob

Left side table assembly

Drip pan

Right side table assembly

Condiment box

ILLUSTRATED PARTS LIST

Grease collection pan

Warming rack

Heat shield

Tool hook

Cooking grate

Tank Retainer Wire

HARDWARE CONTENTS

Part

Description

M6x12 Screw

M5x8 Screw

M4x10 Screw

M4x8 Screw

Quantity

Picture

Part

Description

Flat Washer

Spring Washer

Flat Washer

Spring Axis

Quantity

Picture

PREPARATION

Before beginning assembly of product, make sure all parts are present. Compare parts with package contents list and diagram above. If any part is missing or damaged, do not attempt to assemble the product. Contact customer service for replacement parts.

Estimated Assembly Time: 35-45 minutes Tools Required for Assembly (sold separately):

+ 18 hidden pages