Manitowoc Ice GS1200 User Manual
Guardian® Slime Inhibitor
Model
K-00206 (S-S eries) GS1200 (Q, IB, J or B Series)
Sachet Refill Features
• EPA registered as a slime inhibitor; FDA approved,
and NSF listed to standard 12.
• The sachet active ingredient is contained in a breathable tyvek
sachet and packaged within a foil outer-wrap.
• Ready to use formula. No mixing required. Simply remove sachet
packet from foil outer-wrap and insert into Guardian holder.
• No moving parts; no mechanical parts.
• Will not affect ice produced or alter taste of beverages served.
• Will not harm plastic or stainless steel.
• Recommended change out frequency– 30-day replacement for
maximum slime inhibitor effectiveness.
Guardian
®
Slime Inhibitor
Slime is a leading cause of ice machine breakdowns and biological
growth is a health concern.
Manitowoc's exclusive Guardian® Accessory is patented technology that releases chlorine
dioxide on a controlled basis to inhibit the growth of bacteria and fungi that form slime
and cause odors in the food zone of ice machines.
It is not uncommon to perform a monthly manual cleaning of an ice machine to remove
slime. Professional cleaning will typically cost $160 on average. Manitowoc's Guardian can
extend slime cleaning effectiveness by up to six times the normal frequency... six months
instead of one. The Guardian sachet housing is built into every S-Series ice machine.
Precautionary Statements
• Hazardous to humans and domestic animals.
Caution: Causes moderate eye irritation. Harmful
if swallowed, inhaled or absorbed through the
skin. Avoid contact with eyes or clothing. Wash
thoroughly with soap and water after handling.
• Environmental Hazards - This product is toxic to
fish and aquatic organisms.
• Storage and Disposal - Do not contaminate water,
food or feed by storage or disposal. Store in a cool,
dry, well-ventilated area.
• Physical or Chemical Hazards - Do not mix
with acids or chlorine. Do not store at elevated
temperatures. Discard used sachet in trash.
• Not for use in conjunction with rust and stain
water treatments.
I
nitial
Installation
When installing a Guardian accessory for the
first time, thoroughly clean and sanitize the
ice machine and bin/dispenser following
Manitowoc's cleaning instructions. Note: The
Guardian will not control mineral or other
water borne build-up. Mineral build-up must be
removed as often as necessary to ensure
trouble-free operation of the ice machine.
Use Instructions - Replacing Sachet
1. Swing open front door panel of ice machine.
2. Remove and discard spent sachet packets.
3. Remove sachet from foil package and install into
holder. Removing the foil packet allows the
moisture in the air to activate the packet contents.
4. Close front door panel of ice machine.
5. Discard used sachet in trash.
Ice Machine Model
(S-Series)
300, 322, 422, 450, 500 Use 1
600, 850, 1000, 1200,
1400, 1600, 1800
*Although one sachet is recommended, extreme
conditions may necessitate using two sachet packets.
Guardian Ice Sentry Sachet Refill - K-00206
Sachet refill size 200 gram. Sachet packet(s)
requires replacement every 30 days.
200 Gram
Ice Sentry Sachet
Use 1 or 2*
2380E ©2010 Ma nitowoc 1 /10 Con tinuing product i mprovement may ne cessitate change of speci fications without notice.
2110 South 26th Street
PO Box 1720
Manitowoc, WI 54221-1720 USA
Tel: 1.920.682.0161
Fax: 1.920.683.7589
www.manitowocice.com
Loading...